No, it isn't. You have an explicit "No End-of-Line Programming" fault code. You also have a V3 AFS with 4H0 ballasts, while this is a V2 AFS with 7L0 ballasts.Hello Sebastian, what about my issue is it the same...
-Uwe-
mk6 xenon retrofit
- Thread starter dubTECH
- Start date
- Status
-Uwe-
Sebastian,
What is the minimum software level I should have to be compatible with the control module that I have? Btw, How were you able to tell from my scan what the software level was? Only thing I see is hardware part numbers for the output stages
Thanks!
Last edited:
- Joined
- Feb 13, 2014
- Messages
- 2,731
- Reaction score
- 3,059
- Location
- Magdeburg, Germany
- VCDS Serial number
- HN0-nnnnnn
Based on the reference scan's I have in my collection - 7L6-941-329-B @ 0004 definitely works. Haven't gone digging to check if earlier versions would as well.
This was my 2010 Gti with factory Xenons:
That was a very early build 2010, the first Mk6 Gti that arrived at my dealer actually. Her birthday was August, 2009 (2009-08-14 to be exact) and the replacement parts that woulda been available from the parts depots that day would have already been revised/newer in most cases.
I agree with Sebastian here and 7L6 941 329 B @ 0004 is the oldest known subsystem controller that would be compatible with any certainty.
Code:
VCDS Version: Release 908.0
Data version: 20090911
Wednesday,14,October,2009,15:33:57:18264
Chassis Type: 1K0
Scan: 01 02 03 08 09 15 16 17 19 1C 25 2E 42 44 46 47 52 55 56 62
65 72 77
VIN: WVWHD7AJ4AW057176
01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
1C-Position Sensing -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
47-Sound System -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
55-Xenon Range -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (CBF) Labels: None
Part No SW: 1K0 907 115 AL HW: 1K0 907 115 AK
Component: 2.0l R4/4V TFSI 0030
Revision: E3H21--- Serial number:
Coding: 040301081C070160
Shop #: WSC 01357 011 00200
No fault code found.
Readiness: 0000 0000
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 02E-300-0xx.lbl
Part No SW: 02E 300 051 R HW: 02E 927 770 AJ
Component: GSG DSG AG6 440 1930
Revision: 04844002 Serial number: 00000905290009
Coding: 0000020
Shop #: WSC 01357 011 00200
No fault code found.
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels: 1K0-907-379-60EC1F.clb
Part No SW: 1K0 907 379 AM HW: 1K0 907 379 AM
Component: ESP MK60EC1 H45 0108
Revision: 00H45001
Coding: 114B600CC9270001880C06EB931F0041B108
Shop #: WSC 01357 011 00200
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301) Labels: None
Part No SW: 3C8 907 336 N HW: 3C8 907 336 N
Component: Climatic H13 0203
Revision: 00006001
Coding: 0000000000
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_Climatic A01001
ROD: EV_Climatic_VW46.rod
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: 1K0-937-08x-09.clb
Part No SW: 1K0 937 087 G HW: 1K0 937 087 G
Component: BCM PQ35 H+ 103 0536
Revision: 00103 AC
Coding: 6D180A1E90272AC48088008550000D0441050086434D8D60648020200000
Shop #: WSC 01357 011 00200
Part No: 1K1 955 119 E
Component: Wischer 30060 21 0501
Coding: 009795
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels: 5K0-959-655.clb
Part No SW: 5K0 959 655 B HW: 5K0 959 655 B
Component: AirbagVW10G 019 0706
Serial number: 003C4D0709TY
Coding: 00003031
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_AirbaVW10SMEVW360 A01012
ROD: EV_AirbaVW10SMEVW360_VW36.rod
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY9.lbl
Part No SW: 1K0 953 549 CD HW: 1K0 953 549 CD
Component: J0527 055 0111
Coding: 0001632
Shop #: WSC 01357 011 00200
Part No: 5K0 959 542
Component: E221__MFL-TAS H05 0010
Coding: 00000131
Shop #: WSC 00000
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels: 5K0-920-xxx-17.clb
Part No SW: 5K6 920 970 G HW: 5K6 920 970 G
Component: KOMBI H05 0206
Serial number: 00000000000000
Coding: 270F00
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04040
ROD: EV_Kombi_UDS_VDD_RM09_VW36.rod
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 1K0-907-530.lbl
Part No SW: 1K0 907 530 AA HW: 1K0 907 951
Component: J533 Gateway H07 0081
Revision: H07 01 Serial number: 230609F2001083
Coding: ED817F07101612000002
Shop #: WSC 01357 011 00200
No fault code found.
-------------------------------------------------------------------------------
Address 1C: Position Sensing Labels: None
Part No SW: 5N0 919 879 HW: 5N0 919 879
Component: Kompass 001 0001
Revision: 00001000 Serial number: 1225223T5Q6C04
Coding: 0000002
Shop #: WSC 01357 011 00200
No fault code found.
-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels: 5K0-920-xxx-25.clb
Part No SW: 5K6 920 970 G HW: 5K6 920 970 G
Component: IMMO H05 0206
Serial number: 00000000000000
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03004
ROD: EV_Immo_UDS_VDD_RM09_VW36.rod
No fault code found.
-------------------------------------------------------------------------------
Address 2E: Media Player 3 (J650) Labels: None
Part No SW: 5N0 035 342 B HW: 5N0 035 342 B
Component: SG EXT.PLAYER H13 0084
Revision: A1001003 Serial number: 7667440739
Coding: 010000
Shop #: WSC 01357 011 00200
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: 1K0-959-701-MIN3.lbl
Part No SW: 5K0 959 701 B HW: 5K0 959 701 B
Component: Tuer-SG 009 2109
Coding: 0001204
Shop #: WSC 01357 011 00200
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1Kx-909-14x.lbl
Part No: 1K0 909 144 H
Component: EPS_ZFLS Kl. 74 2901
Revision: 00H15000
Shop #: WSC 01357 011 00200
No fault code found.
-------------------------------------------------------------------------------
Address 47: Sound System (R12) Labels: 5K0-035-456.clb
Part No SW: 5K0 035 456 HW: 5K0 035 456
Component: KonzernAmp 8K H06
Revision: -------- Serial number: BP218198607632
ASAM Dataset: EV_AudioVerst8KanalBNO1 A01003
ROD: EV_AudioVerst8KanalBNO1.rod
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 1K0-959-702-MIN3.lbl
Part No SW: 5K0 959 702 B HW: 5K0 959 702 B
Component: Tuer-SG 009 2109
Coding: 0001204
Shop #: WSC 01357 011 00200
No fault code found.
-------------------------------------------------------------------------------
Address 55: Xenon Range Labels: 5M0-907-357-A.lbl
Part No SW: 5M0 907 357 C HW: 5M0 907 357 C
Component: AFS-Steuergeraet 0142
Revision: 00H04000 Serial number:
Coding: 1446940
Shop #: WSC 01357 011 00200
Part No: 7L6 941 329 B
Component: AFS-Lst.-Modul l 0004
Coding: 00000022
Part No: 7L6 941 329 B
Component: AFS-Lst.-Modul r 0004
Coding: 00000022
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (J503) Labels: 5M0-035-1xx-56.clb
Part No SW: 1K0 035 180 AC HW: 1K0 035 180 AC
Component: Radio Prem-8 H10 0033
Revision: -----18S Serial number: VWZ4Z7J1105969
Coding: 0101000001
Shop #: WSC 01357 011 00200
No fault code found.
-------------------------------------------------------------------------------
Address 62: Door, Rear Left Labels: 1K0-959-703-GEN3.lbl
Part No SW: 5K0 959 703 C HW: 5K0 959 703 C
Component: Tuer-SG 007 2101
Coding: 0001168
Shop #: WSC 01357 011 1012552
No fault code found.
-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502) Labels: None
Part No SW: 1K0 937 087 G HW: 1K0 937 087 G
Component: RDK 103 0518
Coding: 018705
Shop #: WSC 01357 011 00200
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right Labels: 1K0-959-704-GEN3.lbl
Part No SW: 5K0 959 704 C HW: 5K0 959 704 C
Component: Tuer-SG 007 2101
Coding: 0001168
Shop #: WSC 01357 011 1012552
No fault code found.
-------------------------------------------------------------------------------
Address 77: Telephone (J738) Labels: None
Part No SW: 1K8 035 730 C HW: 1K8 035 730 C
Component: Telefon H08 6600
Revision: 00008000 Serial number: 20389520154649
Coding: 412100
Shop #: WSC 01357 011 00200
No fault code found.
End ---------------------------------------------------------------------That was a very early build 2010, the first Mk6 Gti that arrived at my dealer actually. Her birthday was August, 2009 (2009-08-14 to be exact) and the replacement parts that woulda been available from the parts depots that day would have already been revised/newer in most cases.
I agree with Sebastian here and 7L6 941 329 B @ 0004 is the oldest known subsystem controller that would be compatible with any certainty.
I got another set of modules installed with a more recent software level. I'm happy to say that I was finally able to get things properly coded! Thanks to you all for your help!!!
- Joined
- Mar 23, 2014
- Messages
- 25
- Reaction score
- 4
- Location
- Saudi Arabia
- VCDS Serial number
- C?ID=190218
can you post a scan so we can see what module and what coding. thx.
Code:
Wednesday,06,May,2015,21:47:47:35094
VCDS -- Windows Based VAG/VAS Emulator
VCDS Version: 14.10.2.0 (x64)
Data version: 20150311
www.Ross-Tech.com
VIN: 3VWTL7AJ6AM642593 License Plate:
Mileage: 119416 Repair Order:
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: AJ (1K0)
Scan: 01 02 03 08 09 15 16 17 19 1C 25 2E 42 44 46 4F 52 55 56 62
65 72 77
VIN: 3VWTL7AJ6AM642593 Mileage: 192180km-119415miles
01-Engine -- Status: OK 0000
02-Auto Trans -- Status: Malfunction 0010
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
1C-Position Sensing -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
4F-Centr. Electr. II -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: Malfunction 0010
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: Malfunction 0010
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (CJA) Labels: 03L-906-022-CBE.clb
Part No SW: 03L 906 019 CM HW: 03L 906 022 TS
Component: R4 2,0L EDC G000AG 7967
Revision: 12H02--- Serial number:
Coding: 0050078
Shop #: WSC 24339 444 85547
VCID: 78D100FE0B5A5DE156F-802D
No fault code found.
Readiness: 0 0 0 0 1
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 02E-927-770.lbl
Part No SW: 02E 300 052 HW: 02E 927 770 AJ
Component: L DSG AG6 440 1920
Revision: 04844002 Serial number: 00000910220154
Coding: 0000024
Shop #: WSC 02069 000 90108
VCID: 51879D5AC8602CA9B11-8004
1 Fault Found:
17252 - Transmission Fluid Pressure Adaptation at Limit
P0868 - 001 -
Freeze Frame:
Fault Status: 01100001
Fault Priority: 0
Fault Frequency: 255
Reset counter: 2
Mileage: 191837 km
Time Indication: 0
Date: 2015.05.05
Time: 15:35:34
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels: 1K0-907-379-60EC1F.clb
Part No SW: 1K0 907 379 AJ HW: 1K0 907 379 AJ
Component: ESP MK60EC1 H30 0107
Revision: 00H30001
Coding: 114B600C492600FC881006ED921C0042310000
Shop #: WSC 00066 000 00000
VCID: 7AD51AF6F5564FF120B-802F
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301) Labels: 3C8-907-336.clb
Part No SW: 3C8 907 336 AJ HW: 3C8 907 336 AJ
Component: Climatic H14 0305
Revision: 00009001
Coding: 0000001002
Shop #: WSC 00066 000 00185
ASAM Dataset: EV_Climatic A01005
ROD: EV_ClimaBasis_VW32.rod
VCID: 75CF09CAD44820894D9-8020
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: 1K0-937-08x-09.clb
Part No SW: 5K0 937 087 G HW: 5K0 937 087 G
Component: BCM PQ35 H+ 111 1129
Revision: BL111001
Coding: 69380E1F902F3EC480080081400089E401052086535D8560E48020040000
Shop #: WSC 18752 008 00032
VCID: 3957C5FAB0D084E9691-806C
Subsystem 1 - Part No: 1K1 955 119 F Labels: 1KX-955-119.CLB
Component: Wischer 02120 21 0512
Coding: 009795
1 Fault Found:
02895 - Supply Voltage for LED Module for DRL and Parking Light; Left
010 - Open or Short to Plus
Freeze Frame:
Fault Status: 01101010
Fault Priority: 2
Fault Frequency: 42
Reset counter: 39
Mileage: 191425 km
Time Indication: 0
Date: 2015.04.18
Time: 13:28:59
Freeze Frame:
Term 15 On
Voltage: 11.45 V
ON
ON
OFF
OFF
OFF
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels: 5K0-959-655.clb
Part No SW: 5K0 959 655 B HW: 5K0 959 655 B
Component: AirbagVW10G 019 0706
Serial number: 003C4D07FTNK
Coding: 00003044
Shop #: WSC 00066 000 00000
ASAM Dataset: EV_AirbaVW10SMEVW360 A01012
ROD: EV_AirbaVW10SMEVW360_SK35.rod
VCID: 3957C5FAB8D084E9691-806C
Seat occupied recognition:
Subsystem 1 - Part No SW: 1KM 959 339 HW: 1KM 959 339
Component: BF-Gewichtss. 007 0001
Serial number: ---0000R--0004X93P00
Crash sensor for side airbag; driver side:
Subsystem 2 - Part No SW: 1KM 955 557 HW: 1KM 955 557
Component: S.Sens.Fahr.V H01 ----
Serial number: 3572MSME7276234BZZZZ
Crash sensor for side airbag; front passenger side:
Subsystem 3 - Part No SW: 1KM 955 557 HW: 1KM 955 557
Component: S.Sens.Beif.V H01 ----
Serial number: 3582MSME220C024BZZZR
Crash sensor for side airbag; rear; driver side:
Component: S.Sens.Fahr.H --- ----
Serial number: 3511HSME2E2F701DZZZZ
Crash sensor for side airbag; rear; passenger side:
Component: S.Sens.Beif.H --- ----
Serial number: 3521HSME0E41701DZZZM
Crash sensor for front airbag; driver side:
Component: F.Sens.Fahr --- ----
Serial number: 35527SME1E0E581EZZZX
Crash sensor for front airbag; front passenger side:
Component: F.Sens.Beif --- ----
Serial number: 35627SME7720581EZZZL
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY9.lbl
Part No SW: 1K0 953 549 CD HW: 1K0 953 549 CD
Component: J0527 056 0111
Coding: 0001532
Shop #: WSC 00066 000 00000
VCID: 76CD0EC6014E2B91443-8023
Subsystem 1 - Part No: 5K0 959 542 Labels: 3C8-959-537.CLB
Component: E221__MFL-TAS H05 0010
Coding: 00000130
Shop #: WSC 00000
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels: 5K0-920-xxx-17.clb
Part No SW: 5K0 920 970 Q HW: 5K0 920 970 Q
Component: KOMBI H03 0305
Serial number: 00000000000000
Coding: 270F00
Shop #: WSC 00066 000 00148
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04052
ROD: EV_Kombi_UDS_VDD_RM09_SK35.rod
VCID: 3C59DCEEB7E2B1C1727-8069
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 1K0-907-530-V4.clb
Part No SW: 1K0 907 530 AE HW: 1K0 907 951
Component: J533 Gateway H06 0111
Revision: H06 01 Serial number: 191009F2003148
Coding: ED817F07001613002002
Shop #: WSC 00066 123 12345
VCID: 6AF52AB645F6FF71D0B-803F
No fault code found.
-------------------------------------------------------------------------------
Address 1C: Position Sensing Labels: 1Kx-919-xxx-1C.lbl
Part No SW: 5N0 919 879 HW: 5N0 919 879
Component: Kompass 001 0001
Revision: 00001000 Serial number: 1225223T6KJK04
Coding: 0000002
Shop #: WSC 00066 000 00000
VCID: 7EDD16E6297E63D11C3-802B
No fault code found.
-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels: 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H03 0305
Serial number:
Coding: 000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03005
ROD: EV_Immo_UDS_VDD_RM09_SE25.rod
VCID: 6AF52AB68DF6FF71D0B-803F
No fault code found.
-------------------------------------------------------------------------------
Address 2E: Media Player 3 (J650) Labels: 5N0-035-342.lbl
Part No SW: 5N0 035 342 D HW: 5N0 035 342 D
Component: SG EXT.PLAYER H13 0150
Revision: A1001003 Serial number: 7669537801
Coding: 010000
Shop #: WSC 00000 000 00000
VCID: 287110BE5B7A0D6106F-807D
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels: 3C0-959-70X-GEN4.clb
Part No SW: 3C0 959 701 B HW: 3C0 959 793
Component: TUER-SG FT 002 0307
Revision: 13101005 Serial number: 0000104150
Coding: 0004B5
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_DCU42BroseDriveSide A03004
ROD: EV_DCU42BroseDriveSide.rod
VCID: 277313825E6402190F5-8072
Slave Driver:
Subsystem 1 - Part No SW: 1K0 959 703 AH HW: 1K0 959 795 T Labels: 1K0-959-70X-GEN4.CLB
Component: J388__TSG-HL 006 1401
Serial number: 00000004473108
Coding: 000490
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1Kx-909-14x-44.clb
Part No: 1K0 909 144 H
Component: EPS_ZFLS Kl. 70 2901
Revision: 00H17000
Shop #: WSC 02069 000 90108
VCID: 2F43FBA2BE945A59C75-807A
No fault code found.
-------------------------------------------------------------------------------
Address 4F: Centr. Electr. II (J520) Labels: 1K0-907-532.clb
Part No SW: 1K0 907 532 HW: 1K0 907 951
Component: EZE_2 H06 0111
Revision: H06 01 Serial number: 191009F2003148
Coding: 050B0500
Shop #: WSC 00066 123 12345
VCID: 66ED5E8691EEDB11F43-8033
Subsystem 1 - Part No SW: 8R0 959 591 A HW: 8R0 959 591
Component: J245EE20SKB13 H01 0220
Subsystem 2 - Part No SW: 8R0 959 591 A HW: 8R0 959 591
Component: J394EE20SKB13 H01 0220
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels: 3C0-959-70X-GEN4.clb
Part No SW: 3C0 959 702 B HW: 3C0 959 792
Component: TUER-SG BT 002 0307
Revision: 15101005 Serial number: 0000088893
Coding: 0004B4
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_DCU52BrosePasseSide A03004
ROD: EV_DCU52BrosePasseSide.rod
VCID: 287110BE537A0D6106F-807D
Slave Passenger:
Subsystem 1 - Part No SW: 1K0 959 704 AH HW: 1K0 959 794 T Labels: 1K0-959-70X-GEN4.CLB
Component: J389__TSG-HR 006 1401
Serial number: 00000004413968
Coding: 000490
No fault code found.
-------------------------------------------------------------------------------
Address 55: Headlight Range Labels: 5M0-907-357-V2.lbl
Part No SW: 5M0 907 357 C HW: 5M0 907 357 C
Component: AFS-Steuergeraet 0148
Revision: 00H04000 Serial number:
Coding: 1446940
Shop #: WSC 01357 011 00200
VCID: 3449F4CE57B27981BA7-8061
Subsystem 1 - Part No: 7L6 941 329 B
Component: AFS-Lst.-Modul l 0004
Coding: 00000022
Subsystem 2 - Part No: 7L6 941 329 B
Component: AFS-Lst.-Modul r 0004
Coding: 00000022
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (J503) Labels: 5M0-035-1xx-56.clb
Part No SW: 1K0 035 180 AC HW: 1K0 035 180 AC
Component: Radio Prem-8 H10 0035
Revision: -----20S Serial number: VWZ4Z7J3045804
Coding: 0100040004
Shop #: WSC 00066 000 00000
VCID: 61E74D9A78C0BC29011-8034
1 Fault Found:
02635 - Tuner Not Enabled/Activated
000 - -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 3
Fault Frequency: 1
Reset counter: 243
Mileage: 188983 km
Time Indication: 0
Date: 2015.03.26
Time: 21:40:43
-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502) Labels: 1K0-937-08x-65.clb
Part No SW: 5K0 937 087 G HW: 5K0 937 087 G
Component: RDK 111 0821
Coding: 018705
Shop #: WSC 131071 102 209715
VCID: 3957C5FAB0D084E9691-806C
1 Fault Found:
02801 - Hard Warning
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 1
Fault Frequency: 2
Reset counter: 255
Mileage: 191507 km
Time Indication: 0
Date: 2015.05.01
Time: 23:54:30
Freeze Frame:
Text: 3447700539
Pressure: 1.60 bar
Pressure: 2.40 bar
Temperature: 19.2°C
Text: 00
Speed: 7.0 km/h
-------------------------------------------------------------------------------
Address 77: Telephone (J738) Labels: 1K8-035-730.clb
Part No SW: 1K8 035 730 C HW: 1K8 035 730 C
Component: Telefon H08 6600
Revision: 00008000 Serial number: 20389520266118
Coding: 412100
Shop #: WSC 00066 000 00000
VCID: 297715BA40703469191-807C
No fault code found.
End-------------------------(Elapsed Time: 02:16)--------------------------Hi John,
I replied to your PM (via email and PM) but haven't heard back from you. No rush or obligation - but if you're stuck with the UDS protocol 55 controller that has the no EOL DTC please let me know. I don't want to pull the glove box but.. I would like to plug it into my Tiggy to see if it can be coded and corrected without an actual flash update or SVM mothership shenanigans.
I replied to your PM (via email and PM) but haven't heard back from you. No rush or obligation - but if you're stuck with the UDS protocol 55 controller that has the no EOL DTC please let me know. I don't want to pull the glove box but.. I would like to plug it into my Tiggy to see if it can be coded and corrected without an actual flash update or SVM mothership shenanigans.
Hello all,
I am in the process of adding OEM BiXenon to my 2015 Jetta TDI SE Connectivity Pkg. I have acquired all the necessary components, and I am currently hung-up on how to wire-up the High Beam shutter (pin 11 on 14-pin headlight connector) to the CECM. According to another member, he has a Jetta TDI SEL w/ OEM BiXenon from the factory, and he has the exact CECM as I (BCM PQ25 Max3 H78 0725) per his posted Auto-Scan, so I am confident that this CECM supports the BiXenons, and CECM replacement is not necessary, however all the wiring diagrams that I was pulling from ProDemand were indicating 3x 52-pin connectors on the CECM, and my CECM has only 2x 73-pin connectors. I figured ProDemand might not be up-to-date for 2015 Jettas, so I paid for a 1-day subscription to VW erWin, and pulled 2015 Jetta TDI wiring diagrams. I am not seeing anything different. All wiring schematics are indicating 3x 52-pin connectors at the CECM.
I am at a loss here on how to appropriately wire the pin 11 from both left and right OEM bi-xenon headlight housing to the CECM that is present in my vehicle. Any help would be greatly appreciated. All suppliers of the 10-14 pin headlight harnesses provide instructions for adding these to pins 48 & 49 of the gold 52-pin connector to the CECM, which is obviously not correct for BCM PQ25 Max3 H78 0725. ECS Tuning Install instructions: http://bd8ba3c866c8cbc330ab-7b26c6f3e01bf511d4da3315c66902d6.r6.cf1.rackcdn.com/VW_MKVI_Xenon_Headlight_Conversion_Adapter_Harness.pdf
Below is the Auto-Scan from my vehicle prior to any headlight upgrading:
I am in the process of adding OEM BiXenon to my 2015 Jetta TDI SE Connectivity Pkg. I have acquired all the necessary components, and I am currently hung-up on how to wire-up the High Beam shutter (pin 11 on 14-pin headlight connector) to the CECM. According to another member, he has a Jetta TDI SEL w/ OEM BiXenon from the factory, and he has the exact CECM as I (BCM PQ25 Max3 H78 0725) per his posted Auto-Scan, so I am confident that this CECM supports the BiXenons, and CECM replacement is not necessary, however all the wiring diagrams that I was pulling from ProDemand were indicating 3x 52-pin connectors on the CECM, and my CECM has only 2x 73-pin connectors. I figured ProDemand might not be up-to-date for 2015 Jettas, so I paid for a 1-day subscription to VW erWin, and pulled 2015 Jetta TDI wiring diagrams. I am not seeing anything different. All wiring schematics are indicating 3x 52-pin connectors at the CECM.
I am at a loss here on how to appropriately wire the pin 11 from both left and right OEM bi-xenon headlight housing to the CECM that is present in my vehicle. Any help would be greatly appreciated. All suppliers of the 10-14 pin headlight harnesses provide instructions for adding these to pins 48 & 49 of the gold 52-pin connector to the CECM, which is obviously not correct for BCM PQ25 Max3 H78 0725. ECS Tuning Install instructions: http://bd8ba3c866c8cbc330ab-7b26c6f3e01bf511d4da3315c66902d6.r6.cf1.rackcdn.com/VW_MKVI_Xenon_Headlight_Conversion_Adapter_Harness.pdf
Below is the Auto-Scan from my vehicle prior to any headlight upgrading:
Code:
Monday,18,May,2015,15:56:21:17253
VCDS -- Windows Based VAG/VAS Emulator
VCDS Version: 14.10.2.0 (x64)
Data version: 20150311
www.Ross-Tech.com
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: AJ (6N0)
Scan: 01 02 03 05 08 09 15 17 19 25 2B 2E 44 56 75 77 0B
01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
2B-Steer. Col. Lock -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
56-Radio -- Status: Malfunction 0010
75-Telematics -- Status: Malfunction 0010
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CVCA) Labels: None
Part No SW: 04L 906 016 AK HW: 04L 907 309 K
Component: R4 2,0L EDC H20 8276
Revision: 8AH20---
Coding: 011D0012042410085000
Shop #: WSC 00066 790 00014
ASAM Dataset: EV_ECM20TDI01104L906016AK 001008
ROD: EV_ECM20TDI01104L906016AK.rod
VCID: 72C52DCAA5EC44B168B-8027
1 Fault Found:
4481 - Cruise Control Switch (E45)
P0568 00 [032] - Implausible Signal
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Readiness: 0 0 0 0 0
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 02E-927-770.lbl
Part No SW: 02E 300 061 T HW: 02E 927 770 AL
Component: GSG DSG AG6 531 4508
Revision: 05653104 Serial number: 00001408270082
Coding: 0000020
Shop #: WSC 02069 000 90108
VCID: 256F0696ECA263093D9-8070
No fault code found.
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels: 1K0-907-379-60EC1F.clb
Part No SW: 1K0 907 379 BS HW: 1K0 907 379 BS
Component: ESP MK60EC1 H46 0166
Revision: 00H46001
Coding: A14B400C492800FF851302ED921C0042A1100012
Shop #: WSC 00066 790 00081
VCID: 04297B1287587A014A7-8051
No fault code found.
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J518) Labels: 5K0-959-434.clb
Part No SW: 5K0 959 434 E HW: 5K0 959 434
Component: VWKESSYPQ35GP 092 1202
Revision: 00092000 Serial number: 0349126476
Coding: 000F0F
Shop #: WSC 00066 790 00081
ASAM Dataset: EV_KESSYPQ35G A02717
ROD: EV_KESSYPQ35G_AU21.rod
VCID: 3753DCDE8E0EE1999F5-8062
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 5C0-820-047.clb
Part No SW: 5C0 820 047 CA HW: 5C0 820 047 CA
Component: J301 Klimaanlage 0207
Revision: 2001001S Serial number: 00000002464433
Shop #: WSC 00066 790 00014
VCID: 61E75286B80ACF29011-8034
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: 7H0-937-08x-09.clb
Part No SW: 7H0 937 090 E HW: 7H0 937 090 A
Component: BCM PQ25 Max3 H78 0725
Revision: B8078001 Serial number: 78003321140909
Coding: 7B994BBA08AB0B0008382080340894CD0F86702E60000050B0A050022844
Shop #: WSC 00066 011 00000
VCID: 3041E7C2636036A1DEF-8065
Subsystem 1 - Part No SW: 6R0 959 801 AN HW: 6R0 959 801 AN Labels: 6R0-959-801.CLB
Component: J386__TSG_FT 006 5461
Coding: 820000
Subsystem 2 - Part No SW: 6R0 959 802 AS HW: 6R0 959 802 AS Labels: 6R0-959-802.CLB
Component: J387__TSG_BT 006 5461
Coding: 820000
Subsystem 3 - Part No SW: 5K0 959 591 HW: 5K0 959 591
Component: J245 PS41.022 H10 0007
Coding: 180000
Subsystem 4 - Part No SW: 6C0 959 442 A HW: 6C0 959 442 A
Component: E221__MFL-TAT H04 0019
Coding: 280000
Subsystem 5 - Part No SW: 6R0 959 811 M HW: 6R0 959 811 M
Component: J388__TSG_HL 006 5460
Coding: 800000
Subsystem 6 - Part No SW: 6R0 959 812 M HW: 6R0 959 812 M
Component: J389__TSG_HR 006 5460
Coding: 800000
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels: 5K0-959-655.clb
Part No SW: 5C0 959 655 AB HW: 5C0 959 655 AB
Component: AirbagVW10 500 0975
Serial number: 003LZD03HHXD
Coding: 00004B33
Shop #: WSC 00066 790 00014
ASAM Dataset: EV_AirbaVW10SMEVW360 001030
ROD: EV_AirbaVW10SMEVW360_SK35.rod
VCID: 72C52DCAA5EC44B168B-8027
Seat occupied recognition:
Subsystem 1 - Part No SW: 4M0 959 339 A HW: 4M0 959 339 A
Component: BF-Gewichtss. H05 0016
Serial number: IBH0000J140001QEAH09
Coding: 303345
Crash sensor for side airbag; driver side:
Subsystem 2 - Part No SW: 5K0 959 354 HW: 5K0 959 354
Component: S.Sens.Fahr.V H02 ----
Serial number: 3572MSME6A493D49ZZZ8
Crash sensor for side airbag; front passenger side:
Subsystem 3 - Part No SW: 5K0 959 354 HW: 5K0 959 354
Component: S.Sens.Beif.V H02 ----
Serial number: 3582MSME75493D49ZZZ5
Crash sensor for side airbag; rear; driver side:
Subsystem 4 - Part No SW: 5K0 959 351 A HW: 5K0 959 351 A
Component: S.Sens.Fahr.H H02 ----
Serial number: 3516KSME5C386E31ZZZ+
Crash sensor for side airbag; rear; passenger side:
Subsystem 5 - Part No SW: 5K0 959 351 A HW: 5K0 959 351 A
Component: S.Sens.Beif.H H02 ----
Serial number: 3526KSME77681E32ZZZ
Crash sensor for front airbag; driver side:
Subsystem 6 - Part No SW: 5K0 959 659 A HW: 5K0 959 659 A
Component: F.Sens.Fahr H02 ----
Serial number: 3556LSME7D4E4031ZZZ/
Crash sensor for front airbag; front passenger side:
Subsystem 7 - Part No SW: 5K0 959 659 A HW: 5K0 959 659 A
Component: F.Sens.Beif H02 ----
Serial number: 3566LSME7F427731ZZZ+
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels: 5K0-920-xxx-17.clb
Part No SW: 5C6 920 954 A HW: 5C6 920 954 A
Component: KOMBI H04 0807
Serial number: 00000000000000
Coding: 270801
Shop #: WSC 00066 011 00119
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04727
ROD: EV_Kombi_UDS_VDD_RM09_SK35.rod
VCID: 2C79F3B247485241E27-8079
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels: 6N0-909-901-6R.clb
Part No SW: 6N0 909 901 HW: 7H0 937 090 A
Component: GW-K-CAN TP20 H78 0725
Revision: B8078001
Coding: 102200
Shop #: WSC 00066 011 00000
VCID: 70C127C2A3E076A19EF-8025
No fault code found.
-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels: 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H04 0807
Serial number:
Coding: 000007
Shop #: WSC 00066 000 00119
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03710
ROD: EV_Immo_UDS_VDD_RM09_SE25.rod
VCID: 6AF535AA8D3C8C71D0B-803F
No fault code found.
-------------------------------------------------------------------------------
Address 2B: Steer. Col. Lock (J764) Labels: 5K0-905-861.clb
Part No SW: 5K0 905 861 C HW: 5K0 905 861 C
Component: ELV-PQ35 H21 0240
Revision: 00000000 Serial number: 14000305635003
Coding: 4900000000000000
Shop #: WSC 00066 000 00119
ASAM Dataset: EV_ELVMarquMPVW36X A01001
ROD: EV_ELVMarquMPVW36X.rod
VCID: 3041E7C26B6036A1DEF-8065
No fault code found.
-------------------------------------------------------------------------------
Address 2E: Media Player 3
Cannot be reached
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1Kx-909-14x-44.clb
Part No: 1K0 909 144 R
Component: EPS_ZFLS Kl. 306 3501
Revision: 00H22000
Shop #: WSC 02069 000 90108
VCID: 3957DAE6701AF7E9691-806C
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (J503) Labels: None
Part No SW: 1K0 035 188 H HW: 1K0 035 188 H
Component: Radio Prem-8 H07 0009
Revision: -----12S Serial number: VWZ4Z7P3637534
Coding: 01000440020006
Shop #: WSC 00066 790 00014
VCID: 2D7FFEB674525B49F59-8078
1 Fault Found:
02873 - Control Module for Back-Up Camera (J772)
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 5
Fault Frequency: 9
Reset counter: 163
Mileage: 3066 km
Time Indication: 0
Date: 2015.04.11
Time: 12:15:36
-------------------------------------------------------------------------------
Address 75: Telematics (J949) Labels: None
Part No SW: 561 035 285 HW: 561 035 285
Component: OCULowUSA 014 0102
Serial number: 000003554140529
Coding: 02630102C2163A007F1606000000
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_OCULow 001010
ROD: EV_OCULow_SE12.rod
VCID: 538B884E3AB62DB983D-8006
1 Fault Found:
2103041 - Control Module
B1788 F0 [009] - Start Prohibition Deactivated
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 8
Fault Frequency: 1
Reset counter: 126
Mileage: 7062 km
Date: 2015.05.18
Time: 15:50:41
-------------------------------------------------------------------------------
Address 77: Telephone (J412) Labels: 5N0-035-729.clb
Part No SW: 5N0 035 729 E HW: 5N0 035 729 E
Component: TELEFON H07 0593
Revision: 1B001001 Serial number: 00007666828147
Coding: 0A10030080010110
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_UHVUMI 001007
ROD: EV_UHVUMI.rod
VCID: 3245EDCA656C04B1A8B-8067
No fault code found.
End-------------------------(Elapsed Time: 02:38)--------------------------
- Joined
- Apr 9, 2014
- Messages
- 2,310
- Reaction score
- 2,259
- Location
- Tartu, Estonia
- VCDS Serial number
- C?ID=195131
All 3x connectors are for BCM PQ35, as your car has PQ25. You need to be checking for that.
I am aware that the 3x 52-pin connectors are for PQ35 ... however it is NOT necessary to have PQ35 to have the BiXenons, as previously stated 2015 Jetta TDI SEL w/ Lighting Package has PQ25 from the factory, and this is compatible with BiXenon lights .... I need the correct wiring diagrams for the 2x 73-pin connectors for the PQ25.
Does anyone have any insight where as to which pins on the PQ25 the left and right shutter trigger wires should be added?
If you post the VIN from the factory equipped vehicle in addition to yours I can dig to see if a diagram exists but erWin was the best bet. Which diagram numbers did you save/print to PDF already? (please don't post links to them here because they are copyrighted material, just the numbers so I know where you were already)
Dana,
I have contacted another forum member of TDI Club forums who posted an autoscan of his 2015 TDI SEL w/ Lighting Package to see if he would be willing to share his vin number for this purpose. If all else fails, I will head to the local VW dealership to fins an OEM equipped vehicle, check for PQ25 CECM and then grab the VIN # of that vehicle. Ref: http://forums.tdiclub.com/showpost.php?p=4774063&postcount=7
I thoroughly appreciate your assistance. I am at work and do not have the PDFs I saved from erWin last weekend, but I will look tonight and send you a PM with the details.
--Antonio
Dana,
I used the search function in erWin to locate electrical wiring diagrams for a 2015 Jetta TDI. Only 1 search result was found, and the corresponding file name was a 685 page document titled: MEX5R010621-Wiring_Diagrams_and_Component_Locations.pdf ... BiXenon wiring begins on page 359. Page 361 shows the required Left headlamp, with pin 11 at headlamp corresponding to connector "a"on the CECM (PQ35), pin # 5.
My 2015 Jetta TDI SE Connectivity Package Vin # is: 3VWLA7AJXFM265893
I am still awaiting a response from am member with a 2015 Jetta TDI SEL w/ Lighting Package. If I do not receive a response by EOB on Sunday 6-14-15 I will swing over to the dealer and get a vin from a vehicle with OEM BiXenons and PQ25 CECM.
Thanks,
Antonio
According to the wiring diagram that I have from a 2015 Jetta GLI w/ OEM bixenon headlights, pin # 11 on the headlight connector connects to T52a/5 on the CECM (J519). This is as you say above in which we both agree with.
Here is a chart of the lowline and highline cecm's:
CECM Jetta pinouts
Hopefully this will help you out some.
I myself am getting ready to do a complete OEM bi-xenon w/ AFS retrofit install on my 2014 Jetta GLI. I do however have the highline CECM in my vehicle.
Robchris,
I saw that post you reference previously , however I am not sure which pin still applies to the shutter trigger wires on the conversion harness, as other posts I read Say the dipped beam wire from 10 pin headlight harness converts to pin 4 on 14 pin to power the ballast. That chart shows no correlating Description. T52c/48,49 as many indicate are the appropriate positions for these trigger wires is marked not assigned.
I hope Dana is able to find the correct OEM diagrams ... Worst case scenario, I will bring my test probe to the dealership and test an oem TDI SEL with a PQ25 .... But I highly doubt they will be very receptive to allowing me to unplug wires from the headlight and cecm and test for connectivity between the pins
I saw that post you reference previously , however I am not sure which pin still applies to the shutter trigger wires on the conversion harness, as other posts I read Say the dipped beam wire from 10 pin headlight harness converts to pin 4 on 14 pin to power the ballast. That chart shows no correlating Description. T52c/48,49 as many indicate are the appropriate positions for these trigger wires is marked not assigned.
I hope Dana is able to find the correct OEM diagrams ... Worst case scenario, I will bring my test probe to the dealership and test an oem TDI SEL with a PQ25 .... But I highly doubt they will be very receptive to allowing me to unplug wires from the headlight and cecm and test for connectivity between the pins
This is the chart that I have in reference to the 14 pin connector:
1. Canbus high
2. Canbus low
3. N/A
4. Wire from fuse 11 (left), fuse 12 (right)
5. Ground
6. Low Beam
7. Ground
8. N/A
9. Turn Signal
10. Parking Light
11. High Beam
12. DRL
13. Blank
14. N/A
I was advised that the 48, 49 pin was for the Golf, GTI only. The Jetta does its shutter differently.
1. Canbus high
2. Canbus low
3. N/A
4. Wire from fuse 11 (left), fuse 12 (right)
5. Ground
6. Low Beam
7. Ground
8. N/A
9. Turn Signal
10. Parking Light
11. High Beam
12. DRL
13. Blank
14. N/A
I was advised that the 48, 49 pin was for the Golf, GTI only. The Jetta does its shutter differently.
Robchris,
The pin-out you list above seems to be the general consensus I am finding on the net as well.... now we just need to know where the pin 11's connect to on the CECM
--Antonio
Robchris,
The pin-out you list above seems to be the general consensus I am finding on the net as well.... now we just need to know where the pin 11's connect to on the CECM
--Antonio
I have looked for you also. I do not know either. I think your best bet, as you said above, would be to find another vehicle with the same CECM and have bi-xenon installed and get the wiring diagram for that VIN.
- Status