Hello
First of all, the intent of this thread is mainly for an informational purpose from my side.
I've recently retrofitted Bi-Xenon with LED DRL and AFS to my Golf Mk6, MY- 09. Car was originally fitted with halogen headlamps, euro headlight switch and RLS.
Wiring is done the same way as factory fitted bi-xenon headlamps. Please see attached sketch for how it's wired:
The wire colours I've written doesnt necessary fit your car just so you know...
To quickly recap what i've fitted, heres a list of parts and partnumbers.
Wiring harnesses will also have to be fitted. I bought a harness kit for xenon retrofit. This includes adapters for headlamps including some new wires. Wiring for the AFS master and the rear level sensor. After checking the harnesses I discovered some wiring errors in the 10-to-14-pin adapter and I decided to just ditch the adapter and replace the 10-pin connector originally fitted in the car with the new 14-pin connector. However my sketch illustrates how the 10-to-14 pin adapter should be wired if used.
If you decide to replace the 10 pin connector aswell you need to replace the terminal crimped on pin 4 (10-pin connector) with a smaller one (Part number: N10335807).
Coding
Attached picture shows partly how my BCM is coded:
To get the LED DRL function properly with this wiring I figured I had to change Byte 18 in my BCM aswell. For my light setup I found Byte 18 coded to 40 to work as expected. (Originally coded to 02)
I've also seen people just connect pin 10 and 12 together but I don't think LEDs will work properly (dimming) with this bodge. Please correct me on this.
Before you do anything to Byte 18 I'll advice you to read up on byte 18.
This thread may be a good starting point.
My exterior light setup:
You also have to code the AFS Master module, #55 in VCDS (Xenon Range/Headlight Range).
Module has to be enabled in the CAN-Gateway if you havent done that.
Please read the following Ross-Tech wiki: VW Golf (1K) Headlight Aim Control (Xenon with AFS)
My AFS-Master is under the group "not documented" and after an inquiry to Ross-Tech, Dana provided me with the following coding: 1475676
To quote Dana:
This is all I know about that coding. I have no clue what effect the AWD and RLS bit have on the light system. AFS Slaves are coded automaticly after you cycle your ignition.
I used 1446940 as coding previously, however Dana provided me with information saying this was for the NAR-market 2010+ GTI, and also missing a bit for RLS and AWD.
When I change to my new coding it felt like the AFS were "less aggressive" compared to the NAR coding. I'll do some testing and provide more information about this at a later point.
To finalize the AFS installation you need to complete the Basic Settings. Again, the Wiki above contains all information your need to know about this.
--
With all this done everything (should) works flawlessly. LED DRL should be lighted alone when its bright outside (not able to test this yet). However I've tested them manually. LEDs are dimming when I turn on the turn signal etc. Bi-Xenons are working aswell. No fault-codes.
This thread can also be worth reading
Feel free to correct me if I've done any misstakes.
Auto-Scan:
First of all, the intent of this thread is mainly for an informational purpose from my side.
I've recently retrofitted Bi-Xenon with LED DRL and AFS to my Golf Mk6, MY- 09. Car was originally fitted with halogen headlamps, euro headlight switch and RLS.
Wiring is done the same way as factory fitted bi-xenon headlamps. Please see attached sketch for how it's wired:
The wire colours I've written doesnt necessary fit your car just so you know...
To quickly recap what i've fitted, heres a list of parts and partnumbers.
- New BCM (1K0 937 087 AL)
- AFS master module (5M0 907 357 C)
- 2x AFS slave modules (at headlamps) (7L6 941 329 B)
- 2x Xenon Ballasts (5M0 907 391)
- Level sensor at rear axle (1K0 941 273M, part number for AWD only I believe)
Wiring harnesses will also have to be fitted. I bought a harness kit for xenon retrofit. This includes adapters for headlamps including some new wires. Wiring for the AFS master and the rear level sensor. After checking the harnesses I discovered some wiring errors in the 10-to-14-pin adapter and I decided to just ditch the adapter and replace the 10-pin connector originally fitted in the car with the new 14-pin connector. However my sketch illustrates how the 10-to-14 pin adapter should be wired if used.
If you decide to replace the 10 pin connector aswell you need to replace the terminal crimped on pin 4 (10-pin connector) with a smaller one (Part number: N10335807).
Coding
Attached picture shows partly how my BCM is coded:
To get the LED DRL function properly with this wiring I figured I had to change Byte 18 in my BCM aswell. For my light setup I found Byte 18 coded to 40 to work as expected. (Originally coded to 02)
I've also seen people just connect pin 10 and 12 together but I don't think LEDs will work properly (dimming) with this bodge. Please correct me on this.
Before you do anything to Byte 18 I'll advice you to read up on byte 18.
This thread may be a good starting point.
My exterior light setup:
- Bi-Xenon with LED
- Front fog-lights
- Halogen tail lights
- Single reverse light
- Tail fog light
- 3x Brake lights
- Turn Signals
You also have to code the AFS Master module, #55 in VCDS (Xenon Range/Headlight Range).
Module has to be enabled in the CAN-Gateway if you havent done that.
Please read the following Ross-Tech wiki: VW Golf (1K) Headlight Aim Control (Xenon with AFS)
My AFS-Master is under the group "not documented" and after an inquiry to Ross-Tech, Dana provided me with the following coding: 1475676
To quote Dana:
Dana said:That includes AWD (which I missed earlier), 1 level sensor in addition to the RLS for the RoW market.
This is all I know about that coding. I have no clue what effect the AWD and RLS bit have on the light system. AFS Slaves are coded automaticly after you cycle your ignition.
I used 1446940 as coding previously, however Dana provided me with information saying this was for the NAR-market 2010+ GTI, and also missing a bit for RLS and AWD.
When I change to my new coding it felt like the AFS were "less aggressive" compared to the NAR coding. I'll do some testing and provide more information about this at a later point.
To finalize the AFS installation you need to complete the Basic Settings. Again, the Wiki above contains all information your need to know about this.
--
With all this done everything (should) works flawlessly. LED DRL should be lighted alone when its bright outside (not able to test this yet). However I've tested them manually. LEDs are dimming when I turn on the turn signal etc. Bi-Xenons are working aswell. No fault-codes.
This thread can also be worth reading
Feel free to correct me if I've done any misstakes.
Auto-Scan:
Code:
Sunday,25,January,2015,09:35:12:59807
VCDS -- Windows Based VAG/VAS Emulator
VCDS Version: 14.10.0.0 (x64)
Data version: 20141022
VIN: License Plate:
Mileage: 114680km-71258mi Repair Order:
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: 1K (7N0)
Scan: 01 03 08 09 10 15 16 17 19 20 22 25 37 42 44 46 52 55 56 62
72 77
VIN: Mileage: 114680km-71258miles
01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
20-High Beam Assist. -- Status: OK 0000
22-AWD -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
37-Navigation -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: Malfunction 0010
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (CBA) Labels: 03L-906-022-CBA.clb
Part No SW: 03L 906 022 BJ HW: 03L 906 022 G
Component: R4 2,0L EDC G000SG 6758
Revision: 13H01--- Serial number:
Coding: 0000172
Shop #: WSC 18496 000 1048576
VCID: 6ED3C097797E9A518D7-803B
No fault code found.
Readiness: 0 0 0 0 0
-------------------------------------------------------------------------------
Address 03: ABS Brakes (-----) Labels: 1K0-907-379-60EC1F.clb
Part No SW: 1K0 907 379 AE HW: 1K0 907 379 AE
Component: ESP MK60EC1 H35 0106
Revision: 00H35001
Coding: 143B600D092700FB280F06E5901900423500
Shop #: WSC 01357 011 00200
VCID: 75E1EFFBDC28A9894CD-8020
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels: 5K0-907-044.clb
Part No SW: 5K0 907 044 AK HW: 5K0 907 044 AK
Component: Climatronic 130 0303
Revision: 00002001
Coding: 0000000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_Climatronic A01001
ROD: EV_ClimaAutoBasis_SE36.rod
VCID: 74E7D2FFDF52B0817B3-8021
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: 1K0-937-08x-09.clb
Part No SW: 1K0 937 087 AL HW: 1K0 937 087 AL
Component: BCM PQ35 H+ 112 0771
Revision: AF112771
Coding: 46180A3898251AC040080088710089EC477F4088733D8DF0E48420040000
Shop #: WSC 12345 123 12345
VCID: 7BF5F9C3FA0CFFF93A9-802E
Subsystem 1 - Part No: 1K1 955 119 E Labels: 1KX-955-119.CLB
Component: Wischer 18110 21 0501
Coding: 009795
Subsystem 2 - Part No: 1K0 955 559 AH Labels: 1K0-955-559-AG.CLB
Component: RLS 281108 05 54 0402
Coding: 0330AD
No fault code found.
-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446) Labels: 3C8-919-475.clb
Part No SW: 5K0 919 475 HW: 5K0 919 475
Component: PARKHILFE 8K H07 0002
Revision: -------- Serial number: 60630832100423
Coding: 100001
Shop #: WSC 01357 011 00200
VCID: 73E5D1E3D25CB7B9629-8026
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels: 5K0-959-655.clb
Part No SW: 5K0 959 655 HW: 5K0 959 655
Component: AirbagVW10 022 0507
Serial number: 003C2D063RL1
Coding: 00003135
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_AirbaVW10SMEVW360 A01003
ROD: EV_AirbaVW10SMEVW360_SK35.rod
VCID: 77FDE5F3CE24DB995E1-8022
Crash sensor for side airbag; driver side:
Subsystem 1 - Part No SW: 5K0 959 354 HW: 5K0 959 354
Component: S.Sens.Fahr.V U01 ----
Serial number: 4F697241ZZZZZZZZZZZZ
Crash sensor for side airbag; front passenger side:
Subsystem 2 - Part No SW: 5K0 959 354 HW: 5K0 959 354
Component: S.Sens.Beif.V U01 ----
Serial number: 40417241ZZZZZZZZZZZZ
Crash sensor for side airbag; rear; driver side:
Component: S.Sens.Fahr.H --- ----
Serial number: 201F1247ZZZZZZZZZZZZ
Crash sensor for side airbag; rear; passenger side:
Component: S.Sens.Beif.H --- ----
Serial number: 041A1315ZZZZZZZZZZZZ
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY9.lbl
Part No SW: 1K0 953 549 CF HW: 1K0 953 549 CF
Component: J0527 055 0111
Coding: 0000532
Shop #: WSC 01357 011 00200
VCID: 78FFE6CF0B3AD4E157B-802D
Subsystem 1 - Part No: 3C8 959 537 B
Component: E221__MFL-TAP H4ÿ 0021
Coding: 00000226
Shop #: WSC 00000
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels: 5K0-920-xxx-17.clb
Part No SW: 5K0 920 870 C HW: 5K0 920 870 C
Component: KOMBI H21 0029
Serial number: 00000000000000
Coding: 170F00
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04020
ROD: EV_Kombi_UDS_VDD_RM09_SE25.rod
VCID: 2D51079B7CF8A149F4D-8078
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels: 7N0-907-530-V2.clb
Part No SW: 7N0 907 530 AN HW: 7N0 907 530 AN
Component: J533 Gateway H56 1642
Revision: H56 Serial number: 24011400F14111
Coding: 350002
Shop #: WSC 12345 123 12345
VCID: 7CF7FADFFF02F8C1333-8029
No fault code found.
-------------------------------------------------------------------------------
Address 20: High Beam Assist. (J844) Labels: 8K0-857-511.clb
Part No SW: 5K0 857 511 B HW: 8P0 857 511 C
Component: FLA H04 0006
Revision: AA001002
Coding: 0101856B74745D545420363E00
Shop #: WSC 01357 011 00200
VCID: 2D51079B74F8A149F4D-8078
No fault code found.
-------------------------------------------------------------------------------
Address 22: AWD Labels: Redir Fail!
Part No SW: 0BR 907 554 A HW: 0BR 907 554 A
Component: Haldex 4Motion 3016
Coding: 0000005
Shop #: WSC 00000 000 00000
VCID: 43854123027C4739329-8016
No fault code found.
-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels: 5K0-920-xxx-25.clb
Part No SW: 5K0 920 870 C HW: 5K0 920 870 C
Component: IMMO H21 0029
Serial number:
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03002
ROD: EV_Immo_UDS_VDD_RM09_SE25.rod
VCID: 2D51079B7CF8A149F4D-8078
No fault code found.
-------------------------------------------------------------------------------
Address 37: Navigation (J0506) Labels: 1T0-035-680.clb
Part No SW: 1T0 035 686 E HW: 1T0 035 686 E
Component: RNS-MID H23 6270
Revision: AB001001 Serial number: VWZ6Z7P4569654
Coding: 04000400040000A00000
Shop #: WSC 12345 123 12345
VCID: 366328F781AEE291857-8063
Subsystem 1 - Part No: 1T0 919 859 B
Component: EU West V10 8048
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: 1K0-959-701-MAX3.lbl
Part No SW: 1K0 959 701 AN HW: 1K0 959 701 AN
Component: Tuer-SG 008 2015
Coding: 0004342
Shop #: WSC 01357 011 00200
VCID: 7AFBFCC73536C6F121F-802F
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1Kx-909-14x-44.clb
Part No: 1K0 909 144 C
Component: EPS_ZFLS Kl. 70 2301
Revision: 00H15000
Shop #: WSC 01324 785 00200
VCID: 2A5B0C878516B67111F-807F
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 1K0-959-702-MAX3.lbl
Part No SW: 1K0 959 702 AG HW: 1K0 959 702 AG
Component: Tuer-SG 008 2033
Coding: 0004598
Shop #: WSC 01357 011 00200
VCID: 74E7D2FF1752B0817B3-8021
No fault code found.
-------------------------------------------------------------------------------
Address 55: Headlight Range Labels: 5M0-907-357-V2.lbl
Part No SW: 5M0 907 357 C HW: 5M0 907 357 C
Component: AFS-Steuergeraet 0148
Revision: 00H04000 Serial number:
Coding: 1446940
Shop #: WSC 00000 000 00000
VCID: 346712FF57D2F081BB3-8061
Subsystem 1 - Part No: 7L6 941 329 B
Component: AFS-Lst.-Modul l 0004
Coding: 00000022
Subsystem 2 - Part No: 7L6 941 329 B
Component: AFS-Lst.-Modul r 0004
Coding: 00000022
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (J0506) Labels: 1T0-035-680.clb
Part No SW: 1T0 035 686 E HW: 1T0 035 686 E
Component: RNS-MID H23 6270
Revision: AB001001 Serial number: VWZ6Z7P4569654
Coding: 04000400040000A00000
Shop #: WSC 12345 123 12345
VCID: 366328F781AEE291857-8063
Subsystem 1 - Part No: 1T0 919 859 B
Component: EU West V10 8048
No fault code found.
-------------------------------------------------------------------------------
Address 62: Door, Rear Left Labels: 1K0-959-703-GEN3.lbl
Part No SW: 1K0 959 703 AL HW: 1K0 959 703 AL
Component: Tuer-SG 007 2009
Coding: 0000144
Shop #: WSC 01357 011 1012552
VCID: 7AFBFCC73536C6F121F-802F
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right Labels: 1K0-959-704-GEN3.lbl
Part No SW: 1K0 959 704 AL HW: 1K0 959 704 AL
Component: Tuer-SG 007 2009
Coding: 0000208
Shop #: WSC 01357 011 1012551
VCID: 7BF5F9C33A0CFFF93A9-802E
1 Fault Found:
00123 - Outside Warning Light/Door exit Light; Rear Right
012 - Electrical Fault in Circuit
-------------------------------------------------------------------------------
Address 77: Telephone (J412) Labels: 3C8-035-730-A.clb
Part No SW: 3C8 035 730 C HW: 3C8 035 730 C
Component: Telefon 012 0822
Revision: -------- Serial number: 35909603519167
Coding: 020000010100010000000400
Shop #: WSC 12345 123 12345
ASAM Dataset: EV_UHVPremi A02705
ROD: EV_UHVPremi_SE36.rod
VCID: 2345E1A32A3C6739529-8076
No fault code found.
End-------------------------(Elapsed Time: 02:31)--------------------------
Last edited: