Good morning ladies and gentlemen,
I have a stock 2010 Golf TDI DSG. It does have a Polar FIS installed, a panzer plate and a dieselgeek P2015 intake flap repiar bracket.
Auto scan:
No recent repairs other than the VW emissions modification that was performed some time last year. Probably over a year ago at least. The OEM VW battery is from 8/15 but it my little Midtronics PBT-300 tester shows 800CA. The engine starts great.
We also have a Nissan leaf for around town and usually only use the TDI car for distant trips from Chapel Hill, NC to out of state (usually VA).
The problem at hand began about 3 weeks ago. It was raining here almost every day so I was driving this car to work instead of riding my ebike like I normally do. I got in the car on that Monday and was greeted with chimes and warnings for ABS/ESP and airbag. I thought no big deal I'll scan it later and see what's going on. Probably just low battery voltage since this car sits a lot. Car ran fine. No problems.
I drove it all week and never got around to scanning it. No problems.
The next weekend my wife takes the car to VA to visit her folks. I tell her about the lights and say it's no problem.
She calls me when she's 4 hrs into her 5 hour drive to tell me that while on a 50MPH road, the BRAKE light came on and began flashing and beeping. At the same time, the speed dropped to 20mph and engine rpm was 4000. She pulled over and shut the car off. After a while she got back in and it ran fine the rest of the way to her parents' place.
The car did basically this same thing 2 more times while she was up there (3 times total). She ended up drivng her dad's car back here to NC because she was afraid the TDI would either not make it home or endager her on I-95.
A few days later, her dad hauls the TDI down here with his suburban and hauls his car back.
I have driven it a number of times since with no issues though I did note that none of the wheels are able to report speed.
I will admit that this would be the first time I ever tried to observe wheel speed in the ABS controller so I don't know what (if anything) I am supposed to see in those MB's. Sometimes it would show me zeros and sometimes 65535.
Another thing that I will note is that while sitting in the drivers seat with the engine running, I notice that the transmission seems to want to lurch against the parking brake similar to what it does when you're performing the DSG basic settings adaptation AND that the little green light with the foot-on-brake icon is sort of flickering from time to time. When I observe the brake switch status in VCDS it does not show the same flicker so I don't think it is actually the switch's signal causing the flicker.
I have checked all fuses in the B panel, I have inspected wiring in the rain tray and as much of what I can see near the ABS module and each wheel. I see nary a sign of rodents living anywhere on the car.
Here is a small album of photos and videos I put together on google photos. I will add to it as I investigate further.
Thanks for your help!
-Robby
I have a stock 2010 Golf TDI DSG. It does have a Polar FIS installed, a panzer plate and a dieselgeek P2015 intake flap repiar bracket.
Auto scan:
Code:
Wednesday,01,July,2020,17:14:22:32736
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 18.9.1.0 (x64)
Data version: 20190114 DS296.0
www.Ross-Tech.com
VIN: WVWDM7AJ4AW375250 License Plate:
Mileage: 172300km-107062mi Repair Order:
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: AJ-VW36 (1K0)
Scan: 01 02 03 08 09 15 16 17 19 1C 25 2E 42 44 46 52 55 56 62 65
72 77
VIN: WVWDM7AJ4AW375250 Mileage: 172300km-107062miles
01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: Malfunction 0010
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
1C-Position Sensing -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: Malfunction 0010
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: Malfunction 0010
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: Malfunction 0010
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (CJA) Labels: 03L-906-022-CBE.clb
Part No SW: 03L 997 030 K HW: 03L 906 022 TS
Component: R4 2.0l TDI G001AG 9983
Revision: 12H03--- Serial number:
Coding: 0050078
Shop #: WSC 49955 002 1048576
VCID: 3669D2C941389DFA37-8062
1 Fault Found:
006480 - Radiator Fan (V7)
P1950 - 000 - Movement Restricted / Jammed - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 2
Fault Frequency: 31
Reset counter: 255
Mileage: 169820 km
Time Indication: 0
Date: 2014.07.20
Time: 18:26:56
Freeze Frame:
RPM: 1978 /min
Speed: 101.0 km/h
Temperature: 3.6°C
Temperature: 86.4°C
Temperature: 2.7°C
Lambda: 86.8 %
Lambda: 0.0 %
Readiness: 0 0 0 0 0
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 02E-927-770.clb
Part No SW: 02E 300 052 T HW: 02E 927 770 AL
Component: GSG DSG AG6 511 9037
Revision: 51112 Serial number: 00001003170199
Coding: 0000024
Shop #: WSC 01357 011 00200
VCID: 254B0585EC9EE6628E-8070
No fault code found.
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels:. 1K0-907-379-60EC1F.clb
Part No SW: 1K0 907 379 AJ HW: 1K0 907 379 AJ
Component: ESP MK60EC1 H30 0107
Revision: 00H30001
Coding: 114B400C492900FF880D02E992190042310000
Shop #: WSC 01357 011 00200
VCID: 7AF106F9F5A0B99A93-802E
7 Faults Found:
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 1
Fault Frequency: 7
Reset counter: 138
Mileage: 171521 km
Time Indication: 0
Date: 2014.11.03
Time: 07:37:04
Freeze Frame:
Count: 16391
Count: 15
Count: 4096
Count: 128
Count: 35584
Count: 1280
Count: 255
Count: 6400
00290 - ABS Wheel Speed Sensor; Rear Left (G46)
003 - Mechanical Failure - Intermittent
Freeze Frame:
Fault Status: 00100011
Fault Priority: 1
Fault Frequency: 1
Reset counter: 138
Mileage: 172286 km
Time Indication: 0
Date: 2014.11.18
Time: 22:00:10
Freeze Frame:
Count: 3
Count: 0
Count: 4608
Count: 67
Count: 51213
Count: 1289
Count: 516
Count: 0
00287 - ABS Wheel Speed Sensor; Rear Right (G44)
003 - Mechanical Failure - Intermittent
Freeze Frame:
Fault Status: 00100011
Fault Priority: 1
Fault Frequency: 5
Reset counter: 98
Mileage: 171522 km
Time Indication: 0
Date: 2014.11.03
Time: 07:38:38
Freeze Frame:
Count: 1088
Count: 0
Count: 4608
Count: 83
Count: 51253
Count: 65534
Count: 65030
Count: 0
00290 - ABS Wheel Speed Sensor; Rear Left (G46)
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 1
Fault Frequency: 5
Reset counter: 98
Mileage: 172206 km
Time Indication: 0
Date: 2014.11.18
Time: 08:57:33
Freeze Frame:
Count: 3
Count: 0
Count: 4608
Count: 71
Count: 49768
Count: 1
Count: 2
Count: 0
00287 - ABS Wheel Speed Sensor; Rear Right (G44)
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 1
Fault Frequency: 7
Reset counter: 98
Mileage: 171607 km
Time Indication: 0
Freeze Frame:
Count: 16387
Count: 14
Count: 4096
Count: 87
Count: 38912
Count: 1001
Count: 254
Count: 1280
00290 - ABS Wheel Speed Sensor; Rear Left (G46)
012 - Electrical Fault in Circuit - Intermittent
Freeze Frame:
Fault Status: 00101100
Fault Priority: 1
Fault Frequency: 3
Reset counter: 98
Mileage: 172254 km
Time Indication: 0
Date: 2014.11.18
Time: 09:26:47
Freeze Frame:
Count: 7
Count: 0
Count: 4608
Count: 64
Count: 48896
Count: 0
Count: 65283
Count: 0
00287 - ABS Wheel Speed Sensor; Rear Right (G44)
012 - Electrical Fault in Circuit
Freeze Frame:
Fault Status: 01101100
Fault Priority: 1
Fault Frequency: 7
Reset counter: 98
Mileage: 171521 km
Time Indication: 0
Freeze Frame:
Count: 16386
Count: 14
Count: 4096
Count: 80
Count: 43008
Count: 1474
Count: 0
Count: 6912
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301) Labels:| 3C8-907-336.clb
Part No SW: 3C8 907 336 AJ HW: 3C8 907 336 AJ
Component: Climatic H14 0305
Revision: 00009001
Coding: 0000001002
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_Climatic A01005
ROD: EV_ClimaBasis_VW36.rod
VCID: 75EB15C5D4BED6E2FE-8020
1 Fault Found:
13701888 - Function Restriction due to Faults in Other Modules
U1113 00 [008] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 30
Reset counter: 137
Mileage: 158078 km
Date: 2019.02.01
Time: 09:13:19
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 1K0-937-08x-09.clb
Part No SW: 1K0 937 087 G HW: 1K0 937 087 G
Component: BCM PQ35 H+ 103 0578
Revision: 00103 AF
Coding: 67180A1A90272AC48088008160008D0441050086534D8560648020200000
Shop #: WSC 49955 002 1048576
VCID: 356BD5C59C3E96E23E-8060
Subsystem 1 - Part No: 1K1 955 119 F Labels: 1KX-955-119.CLB
Component: Wischer 24031 21 0512
Coding: 009795
2 Faults Found:
01038 - Central Locking Thermal Protection
000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 6
Fault Frequency: 1
Reset counter: 100
Mileage: 171014 km
Time Indication: 0
Date: 2014.09.30
Time: 18:51:29
Freeze Frame:
Term 15 Off
Voltage: 12.00 V
OFF
ON
Term 50 Off
OFF
OFF
01516 - Terminal 30; Left
011 - Open Circuit - Intermittent
Freeze Frame:
Fault Status: 00101011
Fault Priority: 1
Fault Frequency: 1
Reset counter: 137
Mileage: 172280 km
Time Indication: 0
Freeze Frame:
Term 15 Off
Voltage: 12.45 V
OFF
ON
Term 50 Off
OFF
OFF
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:| 5K0-959-655.clb
Part No SW: 5K0 959 655 B HW: 5K0 959 655 B
Component: AirbagVW10G 021 0706
Serial number: 003C4D0AUE22
Coding: 00003031
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_AirbaVW10SMEVW360 A01012
ROD: EV_AirbaVW10SMEVW360.rod
VCID: 3973D9F5B8267282DA-806C
Seat occupied recognition:
Subsystem 1 - Part No SW: 5K0 959 339 HW: 5K0 959 339
Component: BF-Gewichtss. 007 0002
Serial number: ---0000R--0005446Q00
Crash sensor for side airbag: driver side:
Subsystem 2 - Part No SW: 5K0 959 354 HW: 5K0 959 354
Component: S.Sens.Fahr.V H01 ----
Serial number: 3572MSME0D032251ZZZJ
Crash sensor for side airbag: front passenger side:
Subsystem 3 - Part No SW: 5K0 959 354 HW: 5K0 959 354
Component: S.Sens.Beif.V H01 ----
Serial number: 3582MSME5A673350ZZZX
Crash sensor for side airbag: rear: driver side:
Component: S.Sens.Fahr.H --- ----
Serial number: 3512QSME3A0A523BZZZZ
Crash sensor for side airbag: rear: passenger side:
Component: S.Sens.Beif.H --- ----
Serial number: 3522QSME260A5318ZZZR
Crash sensor for front airbag: driver side:
Component: F.Sens.Fahr --- ----
Serial number: 35527SME39153321ZZZ3
Crash sensor for front airbag: front passenger side:
Component: F.Sens.Beif --- ----
Serial number: 35627SME6C093221ZZZC
1 Fault Found:
9483008 - Seat Occupied Recognition
B10B3 00 [137] - Function Restriction due to Implausible Message(s)
MIL ON - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 12
Reset counter: 98
Mileage: 171521 km
Date: 2020.06.12
Time: 07:37:23
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY9.lbl
Part No SW: 1K0 953 549 CD HW: 1K0 953 549 CD
Component: J0527 056 0111
Coding: 0001632
Shop #: WSC 01357 011 00200
VCID: 76E912C901B8DDFAF7-8022
Subsystem 1 - Part No: 3C8 959 537 D Labels: 3C8-959-537.CLB
Component: E221__MFL-TK6 H06 0022
Coding: 00000227
Shop #: WSC 00000
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5K0-920-xxx-17.clb-SRI1
Part No SW: 5K0 920 970 Q HW: 5K0 920 970 Q
Component: KOMBI H03 0305
Serial number: 00000000000000
Coding: 270D00
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04052
ROD: EV_Kombi_UDS_VDD_RM09_004_VW32.rod
VCID: 3C7DC0E1B71447AAC1-8068
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels:. 1K0-907-530-V4.clb
Part No SW: 1K0 907 530 AD HW: 1K0 907 951
Component: J533 Gateway H07 0112
Revision: H07 01 Serial number: 260310F1000133
Coding: ED817F07001612000002
Shop #: WSC 01357 011 00200
VCID: 69D349B5400602026A-803C
No fault code found.
-------------------------------------------------------------------------------
Address 1C: Position Sensing Labels: 1Kx-919-xxx-1C.lbl
Part No SW: 5N0 919 879 HW: 5N0 919 879
Component: Kompass 001 0001
Revision: 00001000 Serial number: 1225223R8AB406
Coding: 0000002
Shop #: WSC 01357 011 00200
VCID: 7EF90AE9298895BAAF-802A
No fault code found.
-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels:| 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H03 0305
Serial number: 00000000000000
Coding: 000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03005
ROD: EV_Immo_UDS_VDD_RM09.rod
VCID: 6AD136B98D00091A63-803E
No fault code found.
-------------------------------------------------------------------------------
Address 2E: Media Player 3 (J650) Labels:. 5N0-035-342.lbl
Part No SW: 5N0 035 342 B HW: 5N0 035 342 B
Component: SG EXT.PLAYER H13 0090
Revision: A1001003 Serial number: 7667911112
Coding: 010000
Shop #: WSC 01357 011 00200
VCID: 264902895198ED7A87-8072
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels:. 1K0-959-701-MIN3.clb
Part No SW: 5K0 959 701 D HW: 5K0 959 701 D
Component: Tuer-SG 009 2139
Coding: 0001204
Shop #: WSC 01357 011 00200
VCID: 336FEBDD524A88D210-8066
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1K0-909-14x-GEN3.clb
Part No: 1K0 909 144 J
Component: EPS_ZFLS Kl. 70 3001
Revision: 00H17000
Shop #: WSC 01357 011 00200
VCID: 3163E1D5A856BAC262-8064
1 Fault Found:
01316 - ABS Control Module
013 - Check DTC Memory
Freeze Frame:
Fault Status: 01101101
Fault Priority: 3
Fault Frequency: 23
Reset counter: 98
Mileage: 172304 km
Time Indication: 0
Date: 2014.11.22
Time: 05:45:49
Freeze Frame:
Voltage: 11.75 V
DD
Temperature: 30.0°C
RPM: 0 /min
Speed: 0.0 km/h
Speed: 0.0 km/h
Count: 0
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels:. 1K0-959-702-MIN3.clb
Part No SW: 5K0 959 702 B HW: 5K0 959 702 B
Component: Tuer-SG 009 2113
Coding: 0001204
Shop #: WSC 01357 011 00200
VCID: 3261EED9AD5081DA1B-8066
2 Faults Found:
00929 - Locking Module for Central Locking; Front Passenger Side (F221)
008 - Implausible Signal - Intermittent
00106 - Signal Central Locking SAVE/LOCK Passenger Side
008 - Implausible Signal - Intermittent
-------------------------------------------------------------------------------
Address 55: Headlight Range Labels: 5M0-907-357-V2.lbl
Part No SW: 5M0 907 357 C HW: 5M0 907 357 C
Component: AFS-Steuergeraet 0142
Revision: 00H04000 Serial number:
Coding: 1446940
Shop #: WSC 01357 011 00200
VCID: 346DE8C157448FEA09-8060
Subsystem 1 - Part No: 7L6 941 329 B Labels: 3D0-941-329.CLB
Component: AFS-Lst.-Modul l 0005
Coding: 00000022
Subsystem 2 - Part No: 7L6 941 329 B Labels: 3D0-941-329.CLB
Component: AFS-Lst.-Modul r 0005
Coding: 00000022
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (J503) Labels:. 5M0-035-1xx-56.clb
Part No SW: 1K0 035 180 AC HW: 1K0 035 180 AC
Component: Radio Prem-8 H10 0035
Revision: -----20S Serial number: VWZ4Z7K1120605
Coding: 0100040004
Shop #: WSC 01357 011 00200
VCID: 61C3519578364A42B2-8034
1 Fault Found:
02635 - Tuner Not Enabled/Activated
000 - -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 3
Fault Frequency: 1
Reset counter: 31
Mileage: 158013 km
Time Indication: 0
Date: 2013.06.23
Time: 00:07:52
-------------------------------------------------------------------------------
Address 62: Door, Rear Left Labels:. 1K0-959-703-GEN3.clb
Part No SW: 5K0 959 703 C HW: 5K0 959 703 C
Component: Tuer-SG 007 2101
Coding: 0001168
Shop #: WSC 01357 011 1012552
VCID: 346DE8C157448FEA09-8060
No fault code found.
-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502) Labels:. 1K0-937-08x-65.clb
Part No SW: 1K0 937 087 G HW: 1K0 937 087 G
Component: RDK 103 0521
Coding: 018704
Shop #: WSC 25155 444 85637
VCID: 356BD5C59C3E96E23E-8060
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right Labels:. 1K0-959-704-GEN3.clb
Part No SW: 5K0 959 704 C HW: 5K0 959 704 C
Component: Tuer-SG 007 2101
Coding: 0001168
Shop #: WSC 01357 011 1012552
VCID: 356BD5C55C3E96E23E-8060
No fault code found.
-------------------------------------------------------------------------------
Address 77: Telephone (J738) Labels:. 1K8-035-730.clb
Part No SW: 1K8 035 730 D HW: 1K8 035 730 D
Component: Telefon H08 6900
Revision: 00008000 Serial number: 00000330900915
Coding: 412100
Shop #: WSC 01357 011 00200
VCID: 2A51F6B94580C91AA3-807E
No fault code found.
End-------------------------(Elapsed Time: 02:43)--------------------------
No recent repairs other than the VW emissions modification that was performed some time last year. Probably over a year ago at least. The OEM VW battery is from 8/15 but it my little Midtronics PBT-300 tester shows 800CA. The engine starts great.
We also have a Nissan leaf for around town and usually only use the TDI car for distant trips from Chapel Hill, NC to out of state (usually VA).
The problem at hand began about 3 weeks ago. It was raining here almost every day so I was driving this car to work instead of riding my ebike like I normally do. I got in the car on that Monday and was greeted with chimes and warnings for ABS/ESP and airbag. I thought no big deal I'll scan it later and see what's going on. Probably just low battery voltage since this car sits a lot. Car ran fine. No problems.
I drove it all week and never got around to scanning it. No problems.
The next weekend my wife takes the car to VA to visit her folks. I tell her about the lights and say it's no problem.
She calls me when she's 4 hrs into her 5 hour drive to tell me that while on a 50MPH road, the BRAKE light came on and began flashing and beeping. At the same time, the speed dropped to 20mph and engine rpm was 4000. She pulled over and shut the car off. After a while she got back in and it ran fine the rest of the way to her parents' place.
The car did basically this same thing 2 more times while she was up there (3 times total). She ended up drivng her dad's car back here to NC because she was afraid the TDI would either not make it home or endager her on I-95.
A few days later, her dad hauls the TDI down here with his suburban and hauls his car back.
I have driven it a number of times since with no issues though I did note that none of the wheels are able to report speed.
I will admit that this would be the first time I ever tried to observe wheel speed in the ABS controller so I don't know what (if anything) I am supposed to see in those MB's. Sometimes it would show me zeros and sometimes 65535.
Another thing that I will note is that while sitting in the drivers seat with the engine running, I notice that the transmission seems to want to lurch against the parking brake similar to what it does when you're performing the DSG basic settings adaptation AND that the little green light with the foot-on-brake icon is sort of flickering from time to time. When I observe the brake switch status in VCDS it does not show the same flicker so I don't think it is actually the switch's signal causing the flicker.
I have checked all fuses in the B panel, I have inspected wiring in the rain tray and as much of what I can see near the ABS module and each wheel. I see nary a sign of rodents living anywhere on the car.
Here is a small album of photos and videos I put together on google photos. I will add to it as I investigate further.
Thanks for your help!
-Robby