hello,
I have a touareg here that came from another workshopi after body work and will not start.
the statement from the owner is that i had been involved in a minor accident to the front end but nothing major.
front bumper and the intercooler. the vehicle was starting properly throughout the repairs until it ran out of fuel.
at this point the owner says the other garage added diesel and managed to start the vehicle. but after switching off
it did not start again.
we managed to bleed the diesel lines and am now getting a healthy 464 bar on crank. no faults are logged except the
ones for low battery every time the battery dies. engine speed gets upto 210 rpm on crank then drops to 160rpm after a few seconds of sustained
cranking.
is there something im missing?
I have a touareg here that came from another workshopi after body work and will not start.
the statement from the owner is that i had been involved in a minor accident to the front end but nothing major.
front bumper and the intercooler. the vehicle was starting properly throughout the repairs until it ran out of fuel.
at this point the owner says the other garage added diesel and managed to start the vehicle. but after switching off
it did not start again.
we managed to bleed the diesel lines and am now getting a healthy 464 bar on crank. no faults are logged except the
ones for low battery every time the battery dies. engine speed gets upto 210 rpm on crank then drops to 160rpm after a few seconds of sustained
cranking.
is there something im missing?
Code:
Saturday,07,October,2017,13:44:34:58772
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64
VCDS Version: 17.8.0.1 (x64)
Data version: 20170721 DS276.2
www.Ross-Tech.com
Dealer/Shop Name: Euro Tecnik Ltd
VIN: WVGZZZ7LZ7D015391 License Plate: KBV 377B
Mileage: 156350km-97151mi Repair Order: Eubert Espira
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: 7L (7L - VW Touareg (2003 > 11/2006))
Scan: 01 02 03 05 06 08 09 11 13 15 16 17 18 19 1C 22 29 32 34 36
37 39 3C 46 47 55 56 57 64 65 68 69 6C 6D 6E 75 76 77
VIN: WVGZZZ7LZ7D015391 Mileage: 156350km-97151miles
-------------------------------------------------------------------------------
Address 01: Engine Labels: 059-907-401-ASB.clb
Part No SW: 7L0 907 401 C HW:
Component: 3.0L V6TDI G000AG 0030
Revision: --H03--- Serial number: VWZ3Z0F1512826
Coding: 0011779
Shop #: WSC 31414 790 00001
VCID: 2B53E54D89E0A41E0F-5164
1 Fault Found:
004499 - Fuel Pressure Sensor (G247)
P1193 - 001 - Open or Short to Plus - Intermittent
Freeze Frame:
Fault Status: 00100001
Fault Priority: 0
Fault Frequency: 2
Reset counter: 255
Mileage: 156352 km
Time Indication: 0
Freeze Frame:
RPM: 0 /min
Torque: 0.0 Nm
(no units): 0.0
Voltage: 12.69 V
Pressure: 0.0 bar
Duty Cycle: 7.1 %
Readiness: 0 0 0 0 1
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 09D-927-750.lbl
Part No: 09D 927 750 EB
Component: AL 750 6A 0772
Coding: 0004200
Shop #: WSC 31414 790 00001
VCID: 72ED38296E4AB5D68C-5164
4 Faults Found:
01312 - Powertrain Data Bus
014 - Defective - Intermittent
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
01316 - ABS Control Module
004 - No Signal/Communication - Intermittent
16997 - Transmission Control Module
P0613 - 004 - Processor Malfunction - Intermittent
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 7L0-907-379-MK25.lbl
Part No: 7L0 907 379 G
Component: ESP ALLRAD MK25 0203
Coding: 0014338
Shop #: WSC 31414 790 00001
VCID: 3D77DB1567943AAEA1-5164
4 Faults Found:
01312 - Powertrain Data Bus
014 - Defective - Intermittent
00778 - Steering Angle Sensor (G85)
004 - No Signal/Communication - Intermittent
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
00778 - Steering Angle Sensor (G85)
000 - -
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. Labels: 3D0-909-13x-05.lbl
Part No SW: 3D0 909 139 HW: 5WK 484 94
Component: Kessy 6700
Revision: 67006015 Serial number: VWZ3Z0F1512826
Coding: 0000232
Shop #: WSC 31414 790 00001
VCID: 66C554795282597610-5164
Subsystem 1 - Part No: XXXXXXXXXXX
Component: ELV XXXX
7 Faults Found:
01316 - ABS Control Module
004 - No Signal/Communication - Intermittent
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
01312 - Powertrain Data Bus
014 - Defective - Intermittent
00189 - Control Circuit 2; Relay for Supply Voltage Terminal 50
006 - Short to Plus - Intermittent
00668 - Supply Voltage Terminal 30
009 - Open or Short to Ground - Intermittent
00087 - Terminal 30 for Starting Relevant Consumers
009 - Open or Short to Ground - Intermittent
00185 - Control Circuit; Relay for Supply Voltage Terminal 15
009 - Open or Short to Ground - Intermittent
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 7L6-907-040.clb
Part No: 7L6 907 040 AL
Component: CLIMAtronic R/L 4537
Coding: 0000530
Shop #: WSC 00000 000 00000
VCID: 7AFD1009363ACD96C4-5148
2 Faults Found:
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
00819 - High Pressure Sensor (G65)
009 - Open or Short to Ground - Intermittent
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels:. 7Lx-937-049-V1.clb
Part No: 7L6 937 049 M
Component: 3003
Coding: 0098404
Shop #: WSC 31414 790 00001
VCID: 4685B4F932427976F0-5164
9 Faults Found:
00967 - Left Turn Signals
014 - Defective - Intermittent
01494 - Bulb for Parking Lamps; Left (M1)
010 - Open or Short to Plus - Intermittent
00978 - Lamp for Low Beam; Left (M29)
010 - Open or Short to Plus - Intermittent
00968 - Right Turn Signals
014 - Defective - Intermittent
01498 - Bulb for Parking Lamps; Right (M3)
010 - Open or Short to Plus - Intermittent
00979 - Lamp for Low Beam; Right (M31)
010 - Open or Short to Plus - Intermittent
00668 - Supply Voltage Terminal 30
008 - Implausible Signal - Intermittent
01117 - Generator Terminal DF Load Signal
008 - Implausible Signal
00907 - Intervention load Management
000 - -
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 3D0-909-601.lbl
Part No: 3D0 909 601 F
Component: 0C Airbag 8.4E+ H11 1151
Coding: 0012355
Shop #: WSC 31414 790 00001
VCID: 2645147992029976D0-5164
2 Faults Found:
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
01578 - Airbag Deactivation Warning Lamp; Passenger Side (K145)
009 - Open or Short to Ground - Intermittent
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 7L6-953-549.lbl
Part No: 7L6 953 549 H
Component: Lenksäulenmodul 3401
Coding: 0010031
Shop #: WSC 31414 790 00001
VCID: 4481AEF1047E4B66EE-5164
1 Fault Found:
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 7L6-920-xxx-7LA.lbl
Part No: 7L6 920 981 M
Component: KOMBIINSTRUMENT RB8 3211
Coding: 0007411
Shop #: WSC 31414 790 00001
VCID: 4383ADED01704C5ED7-5164
8 Faults Found:
00562 - Sensor for Oil Level/Temperature (G266)
010 - Open or Short to Plus - Intermittent
00779 - Outside Air Temp Sensor (G17)
010 - Open or Short to Plus - Intermittent
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
01315 - Transmission Control Module
004 - No Signal/Communication - Intermittent
01316 - ABS Control Module
004 - No Signal/Communication - Intermittent
02053 - Control Module for Transfer Case (J646)
004 - No Signal/Communication - Intermittent
01312 - Powertrain Data Bus
014 - Defective - Intermittent
00464 - Control Module with Display for Radio and Navigation (J503)
004 - No Signal/Communication - Intermittent
-------------------------------------------------------------------------------
Address 18: Aux. Heat Labels: 7L6-819-008.lbl
Part No: 7L6 815 071 D
Component: Standheizung E1MAC
Coding: 0000000
Shop #: WSC 31414 790 00001
VCID: 3363FD2D51D0FCDE47-5164
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 6N0-909-901-19.lbl
Part No: 6N0 909 901
Component: Gateway K<>CAN 0101
Coding: 0000006
Shop #: WSC 31414 790 00001
VCID: 70E93221604687C67A-5164
12 Faults Found:
00456 - Control Module for Access and Start Control (J518)
004 - No Signal/Communication - Intermittent
00778 - Steering Angle Sensor (G85)
004 - No Signal/Communication - Intermittent
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
01315 - Transmission Control Module
004 - No Signal/Communication - Intermittent
01316 - ABS Control Module
004 - No Signal/Communication - Intermittent
02053 - Control Module for Transfer Case (J646)
004 - No Signal/Communication - Intermittent
01312 - Powertrain Data Bus
014 - Defective - Intermittent
01320 - Control Module for Climatronic (J255)
004 - No Signal/Communication - Intermittent
01327 - Control Module for Parking Aid (J446)
004 - No Signal/Communication
00908 - Control Module for Wiper Motor
004 - No Signal/Communication - Intermittent
01207 - Control Module for Auxiliary Heater (J364)
004 - No Signal/Communication - Intermittent
00464 - Control Module with Display for Radio and Navigation (J503)
004 - No Signal/Communication - Intermittent
-------------------------------------------------------------------------------
Address 22: AWD Labels: None
Part No: 0AD 927 755 AT
Component: TRANSFERCASE 0114
Shop #: WSC 00000 000 00000
VCID: 0D174BD517B4CA2EF1-5164
1 Fault Found:
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
-------------------------------------------------------------------------------
Address 37: Navigation Labels: 7L6-919-887-DVD.lbl
Part No: 7L6 919 887 H
Component: Navigation 0028
Coding: 0000101
Shop #: WSC 31414 790 00001
VCID: 4B9385CD2920841E2F-5164
1 Fault Found:
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
-------------------------------------------------------------------------------
Address 46: Central Conv. Labels: 7L0-959-933.lbl
Part No: 7L0 959 933 H
Component: YP HSG 0400
Coding: 0000065
Shop #: WSC 00046 000 00000
VCID: 418FA7E51B6C5E4EC5-4B40
Subsystem 1 - Part No: 7L0 959 701 K
Component: Tuersteuergeraet FS 0201
Subsystem 2 - Part No: 7L0 959 702 K
Component: Tuersteuergeraet BF 0201
Subsystem 3 - Part No: 7L6 959 703
Component: Tuersteuergeraet HL 0202
Subsystem 4 - Part No: 7L6 959 704
Component: Tuersteuergeraet HR 0202
Subsystem 5 - Part No: 7L0 907 719 A
Component: Neigungssensor 0020
Subsystem 6 - Part No: 7L6 951 171 B
Component: Innenraumsensor 0020
14 Faults Found:
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
00576 - Terminal 15
008 - Implausible Signal - Intermittent
01135 - Interior Monitoring Sensors
004 - No Signal/Communication - Intermittent
01134 - Alarm Horn (H12)
004 - No Signal/Communication - Intermittent
00988 - Lamp for Brake Light; Right (M10)
009 - Open or Short to Ground
01503 - Bulb for 3rd Brake Light (M25)
009 - Open or Short to Ground
01331 - Door Control Module; Driver Side (J386)
002 - Lower Limit Exceeded - Intermittent
00932 - Electric Window Motor; Drivers Side (V147)
005 - No or Incorrect Basic Setting / Adaptation - Intermittent
00928 - Locking Module for Central Locking; Front Driver Side (F220)
008 - Implausible Signal - Intermittent
01332 - Door Control Module; Passenger Side (J387)
002 - Lower Limit Exceeded - Intermittent
00933 - Electric Window Motor; Passenger Side (V148)
005 - No or Incorrect Basic Setting / Adaptation
00929 - Locking Module for Central Locking; Front Passenger Side (F221)
008 - Implausible Signal - Intermittent
01333 - Door Control Module; Rear Left (J388)
002 - Lower Limit Exceeded - Intermittent
01334 - Door Control Module; Rear Right (J389)
002 - Lower Limit Exceeded - Intermittent
-------------------------------------------------------------------------------
Address 56: Radio Labels: 7L6-035-186-DVD.lbl
Part No: 7L6 035 186 D
Component: Radio 0028
Coding: 0014452
Shop #: WSC 31414 790 00001
VCID: 3461FE3154DEFBE65E-5164
1 Fault Found:
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
-------------------------------------------------------------------------------
Address 68: Wiper Electr. Labels: 7L0-955-119-V2.clb
Part No: 7L0 955 119 L
Component: Front Wiper 4027
Coding: 0000336
Shop #: WSC 31414 790 376833
VCID: 3D77DB1567943AAEA1-5164
Component: RLS nicht vorhanden
Coding: 00000000
Shop #: WSC 00000
No fault code found.
End-------------------------(Elapsed Time: 10:11)--------------------------