Hello all, this is my first post to this forum as I just received my Vag-com last night! Thank for having me!
In the last month I acquired my 2006 Jetta 1.9 tdi with 204k miles (now with 207,8xx). I bought it knowing the wipers didn't work thinking big deal, fuse right?! Well wrong. I've checked all fuses, hood switch works, washer fluid sprays work. I got a used motor/transmission assembly from local salvage yard, same status. I drove the car to a dealer 2 hours away for them to tell me they couldn't figure out the problem and I needed to schedule another appointment. They did tell me 3 modules were not communicating... no other details although they didn't charge me either so not much to complain about there.. I have also verified battery power to wiper motor plug, have continuity thorough ground wire and signal wire was showing 10.X volts. I have pulled my dash apart and checked pins and plugs at j519 module and j527 module in steering wheel and continuity to as many wires as I can trace. It was apparent some one else has been in there before as the J527 module had a sticker on the case that was peeled back. I have invested about 16 hours into figuring out this issue and has become apparent that I needed the Vag-com. I will post my auto scan below, I see there are a couple things in the scan I didn't know was an issue as well like the heater element and radio issue. I wonder if someone has changed the original radio to a lower option stock radio because XM radio sent me a 2 month trial radio offer but this one does not have satellite option. As far as I can tell the car is completely stock. I also had and airbag light come on after I had taken the dash and steering column apart (did all this with battery disconnected) which I was able to clear. Bulb out indicator was on until I discovered city light bulbs were missing, appears as someone replaced headlights and failed to install bulbs.
If I've missed any info please ask, I am trying my best for this 1st time around. Never used vag-com before and I do not have a service manual although this will be my next investment so suggestions are greatly appreciated of which one to get.
Thank you in advance for any help offered, I am very handy and competent just needing input where to go from here.
Best Regards
In the last month I acquired my 2006 Jetta 1.9 tdi with 204k miles (now with 207,8xx). I bought it knowing the wipers didn't work thinking big deal, fuse right?! Well wrong. I've checked all fuses, hood switch works, washer fluid sprays work. I got a used motor/transmission assembly from local salvage yard, same status. I drove the car to a dealer 2 hours away for them to tell me they couldn't figure out the problem and I needed to schedule another appointment. They did tell me 3 modules were not communicating... no other details although they didn't charge me either so not much to complain about there.. I have also verified battery power to wiper motor plug, have continuity thorough ground wire and signal wire was showing 10.X volts. I have pulled my dash apart and checked pins and plugs at j519 module and j527 module in steering wheel and continuity to as many wires as I can trace. It was apparent some one else has been in there before as the J527 module had a sticker on the case that was peeled back. I have invested about 16 hours into figuring out this issue and has become apparent that I needed the Vag-com. I will post my auto scan below, I see there are a couple things in the scan I didn't know was an issue as well like the heater element and radio issue. I wonder if someone has changed the original radio to a lower option stock radio because XM radio sent me a 2 month trial radio offer but this one does not have satellite option. As far as I can tell the car is completely stock. I also had and airbag light come on after I had taken the dash and steering column apart (did all this with battery disconnected) which I was able to clear. Bulb out indicator was on until I discovered city light bulbs were missing, appears as someone replaced headlights and failed to install bulbs.
If I've missed any info please ask, I am trying my best for this 1st time around. Never used vag-com before and I do not have a service manual although this will be my next investment so suggestions are greatly appreciated of which one to get.
Thank you in advance for any help offered, I am very handy and competent just needing input where to go from here.
Best Regards
Code:
Friday,01,December,2017,11:37:35:59552
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 17.8.1.0 (x64) HEX-V2 CB: 0.4407.4
Data version: 20171130 DS276.6
www.Ross-Tech.com
VIN: 3VWST71K66M773440 License Plate:
Mileage: 334470km-207830mi Repair Order: 001
Chassis Type: 1K (1K0)
Scan: 01 03 08 09 0F 15 16 17 19 25 42 44 46 52 56 62 72 7D
VIN: 3VWST71K66M773440 Mileage: 334470km-207830miles
00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
0F-Digital Radio -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
7D-Aux. Heat -- Status: Malfunction 0010
-------------------------------------------------------------------------------
Address 01: Engine Labels: 038-906-016-BEW.lbl
Part No SW: 03G 906 016 AB HW: 028 101 223 8
Component: R4 1,9L EDC G000SG 7550
Revision: --H01--- Serial number: VWZ7Z0F3301138
Coding: 0050071
Shop #: WSC 00066 000 00000
VCID: 6393528E275B321F273-8036
No fault code found.
Readiness: 0 0 0 0 1
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 1K0-907-379-MK60-F.lbl
Part No SW: 1K0 907 379 AA HW: 1K0 907 379 AA
Component: ESP FRONT MK60 0102
Revision: 00H13001
Coding: 0021122
Shop #: WSC 00066 000 00000
VCID: 71BF28C6EDA7908FA5F-8024
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 1K0-820-047.lbl
Part No: 1K0 820 047 EC
Component: Climatic PQ35 090 0505
Shop #: WSC 00000 000 00000
VCID: 698F40A6C577684FEDF-803C
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels:. 3C0-937-049-23-M.lbl
Part No SW: 3C0 937 049 D HW: 3C0 937 049 D
Component: Bordnetz-SG H37 1002
Revision: 00H37000 Serial number: 00000000253641
Coding: 14018E234004180000140000001400000008730B5C
Shop #: WSC 23301 444 00792
VCID: 2A0DFFAA00F1A357245-807E
Subsystem 1 - Component: Fehler Lin-Slave 01
2 Faults Found:
02071 - Local Databus
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 32
Mileage: 334470 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 13.00 V
ON
ON
OFF
OFF
OFF
00153 - Windshield Wiper Motor; Driver Side (V216)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 32
Mileage: 334470 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 13.00 V
ON
ON
OFF
OFF
OFF
-------------------------------------------------------------------------------
Address 0F: Digital Radio Labels: 8E0-035-593-XM.lbl
Part No SW: 8E0 035 593 E HW: 8E0 035 593 E
Component: SDAR XM H03 0080
Revision: 00000000 Serial number: AUZ4Z7F5044210
Shop #: WSC 00000 000 00000
VCID: 2B03FAAE0F0BBA5FDF3-807E
1 Fault Found:
02635 - Tuner Not Enabled/Activated
000 - -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 7
Fault Frequency: 1
Reset counter: 32
Mileage: 334470 km
Time Indication: 0
Date: 2000.00.00
Time: 22:33:01
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 1K0-909-605.lbl
Part No SW: 1K0 909 605 P HW: 1K0 909 605 P
Component: 39 AIRBAG VW8R 032 7900
Revision: 03032000 Serial number: 0038FD042AJV
Coding: 0013113
Shop #: WSC 00066 000 00000
VCID: 392FD0E6F55718CF5DF-806C
Subsystem 1 - Part No: 1K0 959 339 E
Component: BF-Gewichtsens. 006 0005
Subsystem 2 - Serial number: 6332MSME0D35450EF
Subsystem 3 - Serial number: 6342MSME0D351D60D
Subsystem 4 - Serial number: 6351HSME091C174AB
Subsystem 5 - Serial number: 6361HSME091D1C49H
Subsystem 6 - Serial number: 63727SME08254B4C6
Subsystem 7 - Serial number: 63827SME086C4B5DK
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY8.lbl
Part No SW: 1K0 953 549 AH HW: 1K0 953 549 AH
Component: J0527 034 0070
Coding: 0000021
Shop #: WSC 00066 000 00000
VCID: 78A915E28EDDC1C7621-802C
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 1K0-920-xxx-17.lbl
Part No: 1K0 920 952 L
Component: KOMBIINSTRUMENT 3HL 4312
Coding: 0023203
Shop #: WSC 23317 444 85571
VCID: 3333E2CED73BE29F973-8066
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels:. 1K0-907-530-V1.clb
Part No SW: 1K0 907 530 F HW: 1K0 907 951
Component: Gateway H10 0120
Revision: H10 Serial number: 2800105C1284CC
Coding: 3D3F0B60071002
Shop #: WSC 00066 000 00000
VCID: 2A0DFFAA00F1A357245-807E
No fault code found.
-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 1K0-920-xxx-25.clb
Part No: 1K0 920 952 L
Component: IMMO 3HL 4312
Shop #: WSC 00000 000 00000
VCID: 3333E2CED73BE29F973-8066
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: 1K0-959-701-MIN2.lbl
Part No: 1K0 959 701 K
Component: Tuer-SG 024 2377
Coding: 0001269
Shop #: WSC 00066 000 00000
VCID: 3635DBDAC449F7B7B0D-8062
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1Kx-909-144-G2V2.clb
Part No: 1K1 909 144 K
Component: EPS_ZFLS Kl.5 D06 1701
Shop #: WSC 00000 000 00000
VCID: 3333E2CED73BE29F973-8066
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv. Labels:. 1K0-959-433-MIN.clb
Part No: 1K0 959 433 AF
Component: KSG 0401
Coding: 137803281B09058F880F048051A0
Shop #: WSC 00066 000 00000
VCID: 74B121D292B5A5A74E9-8020
Subsystem 1 - Component: Sounder n.mounted
Subsystem 2 - Component: NGS n.mounted
Subsystem 3 - Component: IRUE n.mounted
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 1K0-959-702-MIN2.lbl
Part No: 1K0 959 702 K
Component: Tuer-SG 024 2377
Coding: 0001269
Shop #: WSC 00066 000 00000
VCID: 372BD6DEC3430EBFABB-8062
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio Labels: 1K0-035-1xx-56.lbl
Part No SW: 1K0 035 180 A HW: 1K0 035 180 A
Component: Radio DE2 008 0011
Revision: 00008000 Serial number: VWZ4Z7E2009284
Coding: 0040400
Shop #: WSC 00066 000 00000
VCID: 1E65237A4CB95FF748D-804A
No fault code found.
-------------------------------------------------------------------------------
Address 62: Door, Rear Left Labels: 1K0-959-703-GEN2.lbl
Part No: 1K0 959 703 D
Component: Tuer-SG 021 2434
Coding: 0000144
Shop #: WSC 00066 000 00000
VCID: 313FE8C62D27D08FE5F-8064
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right Labels: 1K0-959-704-GEN2.lbl
Part No: 1K0 959 704 D
Component: Tuer-SG 021 2434
Coding: 0000144
Shop #: WSC 00066 000 00000
VCID: 323DE7CA2821EB979C5-8066
No fault code found.
-------------------------------------------------------------------------------
Address 7D: Aux. Heat Labels: 1K0-963-235.lbl
Part No SW: 1K0 963 235 E HW: 1K0 963 235 E
Component: PTC-Element 0404
Revision: 00800000 Serial number:
Shop #: WSC 00000 000 00000
VCID: 2D07F4B6311FB46FC17-8078
1 Fault Found:
00361 - Heater Element for Auxiliary Heater (Z35)
014 - Defective
End----------(Elapsed Time: 01:08, VBatt start/end: 13.0V/13.0V)-----------
Last edited by a moderator: