witchcraftz
Active Member
- Joined
- Nov 20, 2016
- Messages
- 11
- Reaction score
- 1
- Location
- Canada
- VCDS Serial number
- HC437830 (2nd hand?)
I cannot for sure say what caused my DPF problem, the vehicle was purchased damaged and rebuilt.
At the time of purchase there were no CEL/errors, after rebuild was completed and the vehicle delivered it immediately started showing this error.
I haven't even insured it or driven it very far except for twice just for 15-20 min at speed (with temp insurance) to try to get the engine to perform a regen.
It seems to drive fine for now.
When the DPF light+CEL came on. I tested it in vagcom and it read:
soot measured = 0.12
soot calculated = 40
So I tried a forced regen (as pers VDS procedure) but it wouldn't go, and after I got:
soot measured = 0.12
soot calculated = 60
Considering it went from no CEL to crazy plugged in 154 km (according to the logged data) I'm not sure what to think.
Can someone please educate me on what values I should be reading and checking to see if the DPF is really plugged?
Here are some logged values
--------------------
DPF values at engine RPM 2000
--------------------
IDE00433 Particle filter: oil ash volume 0.03 l
IDE00434 Particle filter: soot mass calculated 60.00 g
IDE00435 Particle filter: soot mass measured 0.35 g
IDE04092 Diesel particle filter bank 1 3.40/---/--- kPa
IDE04652 Exhaust gas jet volume in particle filter 131.1 m³/h
IDE05357 Current temperature in NOx reducing catalytic converter 51.4 °C
IDE07744 Particle filter: air pressure sensor 1 bank 1: raw value 34 hPa
IDE07747 Particle filter: differential pressure sensor 1 bank 1: offset 2 hPa
--------------------
Engine Idle
--------------------
IDE00167 Exhaust temperature 1 bank 1 108.2 °C
IDE00169 Exhaust temperature 2 bank 1 59.8 °C
IDE00347 Air mass: actual value: 13.24 g/s
IDE00350 Air mass: specified value 250.0 mg/stroke
IDE04045 Exhaust gas pressure EP1:0.26 kPa
IDE04090 Exhaust temperature bank 1 S1/S2/S3/S4: / 134/105/79/49 °C
IDE04468 Air mass at air mass meter 1 48.5 kg/h
IDE07801 Mass airflow sensor 1 bank 1 airflow: raw value 533.1 mg/stroke
IDE04045 Exhaust gas pressure EP1:0.24 kPa
IDE04092 Diesel particle filter bank 1 1.30/---/--- kPa
IDE04652 Exhaust gas jet volume in particle filter 49.7 m³/h
IDE04653 Simulated particle filter surface temperature 21.0 °C
IDE07716 Particle filt.inlet temp.sens.1 bank 1: raw value 41.3 °C
IDE07718 Particle filter outlet temp.sens.1 bank 1: raw value 19.4 °C
IDE07744 Particle filter: air pressure sensor 1 bank 1: raw value 13 hPa
IDE07745 Particl.filt.: different.press.sensor 1 bank 1: adaptat. value 13 hPa
IDE07747 Particle filter: differential pressure sensor 1 bank 1: offset 2 hPa
IDE07748 Particl.filt.: differential pressur.sensor 1 bank 1: dyn.offset 0 hPa
--------------------
2000 RPM
--------------------
IDE00167 Exhaust temperature 1 bank 1 107.3 °C
IDE00169 Exhaust temperature 2 bank 1 62.9 °C
IDE00347 Air mass: actual value: 38.97 g/s
IDE00350 Air mass: specified value 250.0 mg/stroke
IDE04045 Exhaust gas pressure EP1:0.89 kPa
IDE04090 Exhaust temperature bank 1 S1/S2/S3/S4: / 152/115/82/50 °C
IDE04468 Air mass at air mass meter 1 135.5 kg/h
IDE07801 Mass airflow sensor 1 bank 1 airflow: raw value 588.8 mg/stroke
IDE04045 Exhaust gas pressure EP1:0.84 kPa
IDE04092 Diesel particle filter bank 1 3.40/---/--- kPa
IDE04652 Exhaust gas jet volume in particle filter 141.0 m³/h
IDE04653 Simulated particle filter surface temperature 32.1 °C
IDE07716 Particle filt.inlet temp.sens.1 bank 1: raw value 55.6 °C
IDE07718 Particle filter outlet temp.sens.1 bank 1: raw value 30.9 °C
IDE07744 Particle filter: air pressure sensor 1 bank 1: raw value 32 hPa
IDE07745 Particl.filt.: different.press.sensor 1 bank 1: adaptat. value 32 hPa
IDE07747 Particle filter: differential pressure sensor 1 bank 1: offset 2 hPa
IDE07748 Particl.filt.: differential pressur.sensor 1 bank 1: dyn.offset 0 hPa
======================
And full autoScan
======================
At the time of purchase there were no CEL/errors, after rebuild was completed and the vehicle delivered it immediately started showing this error.
I haven't even insured it or driven it very far except for twice just for 15-20 min at speed (with temp insurance) to try to get the engine to perform a regen.
It seems to drive fine for now.
When the DPF light+CEL came on. I tested it in vagcom and it read:
soot measured = 0.12
soot calculated = 40
So I tried a forced regen (as pers VDS procedure) but it wouldn't go, and after I got:
soot measured = 0.12
soot calculated = 60
Considering it went from no CEL to crazy plugged in 154 km (according to the logged data) I'm not sure what to think.
Can someone please educate me on what values I should be reading and checking to see if the DPF is really plugged?
Here are some logged values
--------------------
DPF values at engine RPM 2000
--------------------
IDE00433 Particle filter: oil ash volume 0.03 l
IDE00434 Particle filter: soot mass calculated 60.00 g
IDE00435 Particle filter: soot mass measured 0.35 g
IDE04092 Diesel particle filter bank 1 3.40/---/--- kPa
IDE04652 Exhaust gas jet volume in particle filter 131.1 m³/h
IDE05357 Current temperature in NOx reducing catalytic converter 51.4 °C
IDE07744 Particle filter: air pressure sensor 1 bank 1: raw value 34 hPa
IDE07747 Particle filter: differential pressure sensor 1 bank 1: offset 2 hPa
--------------------
Engine Idle
--------------------
IDE00167 Exhaust temperature 1 bank 1 108.2 °C
IDE00169 Exhaust temperature 2 bank 1 59.8 °C
IDE00347 Air mass: actual value: 13.24 g/s
IDE00350 Air mass: specified value 250.0 mg/stroke
IDE04045 Exhaust gas pressure EP1:0.26 kPa
IDE04090 Exhaust temperature bank 1 S1/S2/S3/S4: / 134/105/79/49 °C
IDE04468 Air mass at air mass meter 1 48.5 kg/h
IDE07801 Mass airflow sensor 1 bank 1 airflow: raw value 533.1 mg/stroke
IDE04045 Exhaust gas pressure EP1:0.24 kPa
IDE04092 Diesel particle filter bank 1 1.30/---/--- kPa
IDE04652 Exhaust gas jet volume in particle filter 49.7 m³/h
IDE04653 Simulated particle filter surface temperature 21.0 °C
IDE07716 Particle filt.inlet temp.sens.1 bank 1: raw value 41.3 °C
IDE07718 Particle filter outlet temp.sens.1 bank 1: raw value 19.4 °C
IDE07744 Particle filter: air pressure sensor 1 bank 1: raw value 13 hPa
IDE07745 Particl.filt.: different.press.sensor 1 bank 1: adaptat. value 13 hPa
IDE07747 Particle filter: differential pressure sensor 1 bank 1: offset 2 hPa
IDE07748 Particl.filt.: differential pressur.sensor 1 bank 1: dyn.offset 0 hPa
--------------------
2000 RPM
--------------------
IDE00167 Exhaust temperature 1 bank 1 107.3 °C
IDE00169 Exhaust temperature 2 bank 1 62.9 °C
IDE00347 Air mass: actual value: 38.97 g/s
IDE00350 Air mass: specified value 250.0 mg/stroke
IDE04045 Exhaust gas pressure EP1:0.89 kPa
IDE04090 Exhaust temperature bank 1 S1/S2/S3/S4: / 152/115/82/50 °C
IDE04468 Air mass at air mass meter 1 135.5 kg/h
IDE07801 Mass airflow sensor 1 bank 1 airflow: raw value 588.8 mg/stroke
IDE04045 Exhaust gas pressure EP1:0.84 kPa
IDE04092 Diesel particle filter bank 1 3.40/---/--- kPa
IDE04652 Exhaust gas jet volume in particle filter 141.0 m³/h
IDE04653 Simulated particle filter surface temperature 32.1 °C
IDE07716 Particle filt.inlet temp.sens.1 bank 1: raw value 55.6 °C
IDE07718 Particle filter outlet temp.sens.1 bank 1: raw value 30.9 °C
IDE07744 Particle filter: air pressure sensor 1 bank 1: raw value 32 hPa
IDE07745 Particl.filt.: different.press.sensor 1 bank 1: adaptat. value 32 hPa
IDE07747 Particle filter: differential pressure sensor 1 bank 1: offset 2 hPa
IDE07748 Particl.filt.: differential pressur.sensor 1 bank 1: dyn.offset 0 hPa
======================
And full autoScan
======================
Code:
Chassis Type: AU (5Q0)
Scan: 01 02 03 08 09 15 16 17 19 42 44 52 5F 75
VIN: Mileage: 57759km-35889miles
01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
5F-Information Electr. -- Status: Malfunction 0010 (I recently disconnected the battery so suspect that is what caused this error)
75-Telematics -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CRUA) Labels: 04L-907-309-V1.clb
Part No SW: 04L 906 021 D HW: 04L 907 309
Component: R4 2,0L EDC H23 8278
Revision: 85H23---
Coding: 011D0012032410080000
Shop #: WSC 48433 001 1048576
ASAM Dataset: EV_ECM20TDI01104L906021D 001013
ROD: EV_ECM20TDI01104L906021D.rod
VCID: 2649DBDD59710172E6-8072
1 Fault Found:
5188 - Diesel Particle Filter
P2463 00 [167] - Excessive Soot Accumulation
MIL ON - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 57759 km
Date: 2016.11.20
Time: 20:53:25
Engine speed: 0.00 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 26 °C
Intake air temperature: 21 °C
Ambient air pressure: 1000 mbar
Voltage terminal 30: 11.860 V
Unlearning counter according OBD: 40
Counter for regeneration time of diesel particle filter: 0.00 s
Particle filter: kilometers since last regeneration: 155077 m
Particle filter: soot mass measured: 0.62 g
Particle filter: soot mass calculated: 60.00 g
Particl.filt.: differential pressur.sensor 1 bank 1: dyn.offset: 2 hPa
Readiness: 0 0 0 1 1
-------------------------------------------------------------------------------
Address 02: Auto Trans (J743) Labels: 0D9-927-770.clb
Part No SW: 0D9 300 041 N HW: 02E 927 770 AQ
Component: DQ250-6F MQB H52 4506
Revision: 03252204 Serial number: TFK01404171357
Coding: 0014
Shop #: WSC 00066 790 00221
ASAM Dataset: EV_TCMDQ250021 001001
ROD: EV_TCMDQ250021.rod
VCID: 234FC2C92A43F45A81-8076
No fault code found.
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels: 5Q0-907-379-ESP-V1.clb
Part No SW: 5Q0 907 379 K HW: 5Q0 907 379 F
Component: ESC H31 0371
Revision: 00000000 Serial number: 51664000000032
Coding: 01FA6AA124210973007E020381C42580562490004081A4B200 630050C002
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_Brake1UDSContiMK100ESP 033001
ROD: EV_Brake1UDSContiMK100ESP_033.rod
VCID: 448D6155CF0DD362D8-8010
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301) Labels: 5G0-907-426.clb
Part No SW: 5G0 907 426 Q HW: 5G0 907 426 Q
Component: AC Manuell H02 0907
Revision: 00001K06
Coding: 00020104200100000000000000000000
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_ACManueBHBVW37X 003019
ROD: EV_ACManueBHBVW37X_SK48.rod
VCID: 397300A1B8CF9E8ABB-806C
Fresh Air Blower Front:
Refrigerant Pressure And Temperature Sender:
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: 5Q0-937-08X-BV1.clb
Part No SW: 5Q0 937 087 M HW: 5Q0 937 087 M
Component: BCM PQ37BOSCH 028 0106
Revision: -------- Serial number: 86582405140399
Coding: 000018424041804169E4400000040300100000000000000000 0000000000
Shop #: WSC 00066 790 00195
ASAM Dataset: EV_BodyContrModul1UDSBosc 013005
ROD: EV_BCMBOSCH_013.rod
VCID: 458B7C51C437EA6ACF-8010
Control Unit For Wiper Motor:
Subsystem 1 - Part No SW: 5GM 955 119 HW: 5GM 955 119 Labels: 5QX-955-119-V1.CLB
Component: WWS 140628 043 0581
Serial number: 140720182857
Coding: 0E4DDD
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels: 5Q0-959-655.clb
Part No SW: 5Q0 959 655 T HW: 5Q0 959 655 T
Component: AirbagVW20 009 0825
Serial number: 003MHM00HW3U
Coding: 8CCCFC00000000005000001AC24800000065
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_AirbaVW20SMEVW37X 002138
ROD: EV_AirbaVW20SMEVW37X_VW37.rod
VCID: 51A35801007F36CA63-8004
Occupant Detection:
Subsystem 1 - Part No SW: 4M0 959 339 A HW: 4M0 959 339 A
Component: BF-Gewichtss. H05 0016
Serial number: IBH0000J14000100PW0%
Coding: 30325A
Side Sensor Driver Front:
Subsystem 2 - Part No SW: ----------- HW: 480 002 105 14
Component: SideSensor_Df 001 0887
Serial number: 357000000009FC05CF0/
Coding: 2D2D2D
Side Sensor Passenger Front:
Subsystem 3 - Part No SW: ----------- HW: 480 002 805 14
Component: SideSensor_Pf 001 0887
Serial number: 35800000000FFCC4EF0H
Coding: 2D2D2D
Side Sensor Driver Rear:
Subsystem 4 - Part No SW: ----------- HW: 480 402 205 14
Component: SideSensor_Dr 001 6149
Serial number: 35100029B15C4213B05W
Coding: 2D2D2D
Side Sensor Passenger Rear:
Subsystem 5 - Part No SW: ----------- HW: 480 402 205 14
Component: SideSensor_Pr 001 6149
Serial number: 3520002AB15C4211410L
Coding: 2D2D2D
Front Sensor Driver:
Subsystem 6 - Part No SW: ----------- HW: 480 401 006 14
Component: FrontSensor_D 001 6149
Serial number: 3550002A51617D24C06$
Coding: 2D2D2D
Front Sensor Passenger:
Subsystem 7 - Part No SW: ----------- HW: 480 401 006 14
Component: FrontSensor_P 001 6149
Serial number: 3560002A31617D24B38%
Coding: 2D2D2D
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel (J524) Labels: 5Q0-953-549.clb
Part No SW: 5Q0 953 521 P HW: 5Q0 953 569 A
Component: Lenks.Modul 075 0155
Revision: FF028028 Serial number: 20140529400177
Coding: 0410
Shop #: WSC 66564 385 16448
ASAM Dataset: EV_SMLSVALEOMQB 001015
ROD: EV_SMLSVALEOMQB.rod
VCID: 3F876EB9A6EBB0BA85-806A
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels: 5G0-920-XXX-17.clb
Part No SW: 5G1 920 841 HW: 5G1 920 841
Component: KOMBI 243 4270
Coding: 0BB51A0A2180CF0502096A001000000000000000
Shop #: WSC 00066 790 00221
ASAM Dataset: EV_DashBoardVDDMQBAB 009037
ROD: EV_DashBoardVDDMQBAB_009_VW26.rod
VCID: 65CB9CD164F7CA6A2F-8030
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels: 5Q0-907-530-V1.clb
Part No SW: 5Q0 907 530 S HW: 5Q0 907 530 L
Component: GW MQB Mid 211 2186
Revision: -------- Serial number: 28061410000015
Coding: 0101000800087300EF0000081C0F0000000105000000000000 0000000000
Shop #: WSC 00066 790 07027
ASAM Dataset: EV_GatewConti 011017
ROD: EV_GatewConti_011.rod
VCID: 41836841D01FC64AF3-8014
Alternator:
Multi Function Steering Wheel Control Module:
Subsystem 2 - Part No SW: 5G0 959 442 P HW: 5G0 959 442 P
Component: E221__MFL-DC1 H14 0101
Serial number: 29140000966250074201
Coding: 29FFFF
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels: 5QX-959-X93-42.clb
Part No SW: 5Q0 959 393 B HW: 5Q0 959 393 B
Component: TSG FS 020 0025
Serial number: 280614060505BJ
Coding: 003003200000040000000000
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_DCUDriveSideEWMINKLO 006003
ROD: EV_DCUDriveSideEWMAXCONT.rod
VCID: 3E7913BDA1E1B9B28E-806A
Drivers Door Rear Control Module:
Subsystem 1 - Part No SW: 5Q0 959 811 A HW: 5Q0 959 811 A
Component: FOND_FHSG_DRV 005 0005
Serial number: 00000000000002898130
Coding: 011000
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist (J500) Labels: 5Q0-909-144.clb
Part No SW: 5Q0 909 144 P HW: 5Q0 909 144 P
Component: EPS_MQB_ZFLS 122 1043
Coding: 0102
Shop #: WSC 00066 790 00221
ASAM Dataset: EV_SteerAssisMQB 010031
ROD: EV_SteerAssisMQB_010.rod
VCID: 41836841D01FC64AF3-8014
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels: 5QX-959-X92-52.clb
Part No SW: 5Q0 959 392 B HW: 5Q0 959 392 B
Component: TSG BFS 020 0025
Serial number: 23061406050330
Coding: 003003200000040000000000
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_DCUPasseSideEWMINKLO 006003
ROD: EV_DCUPasseSideEWMAXCONT.rod
VCID: 3D7B14B1ACE7A2AA97-8068
Passengers Rear Door Control Module:
Subsystem 1 - Part No SW: 5Q0 959 812 A HW: 5Q0 959 812 A
Component: FOND_FHSG_PSG 005 0005
Serial number: 00000000000002868483
Coding: 191000
No fault code found.
-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794) Labels: 5G0-035-MIB-STD1.clb
Part No SW: 5G0 035 844 HW: 5G0 035 844
Component: MU-S-S-US 014 0645
Serial number: V7B00406142418
Coding: 02730000FF00000021220001001800001F0100040100010002
Shop #: WSC 00066 790 07027
ASAM Dataset: EV_MUStd4CPASE 002040
ROD: EV_MUStd4CPASE_VW37.rod
VCID: 64CD81D56FCDB36238-8030
Operating And Display Unit 1:
Subsystem 1 - Part No SW: 5G0 919 605 H HW: 5G0 919 605 H
Component: ABT_Std_Plus H60 0030
Serial number: VWZ8Z9PS500AMD
1 Fault Found:
0020 - Tuner for Satelite Radio
B11CF 53 [009] - Deactivated
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 4
Fault Frequency: 1
Reset counter: 87
Mileage: 57759 km
Date: 2016.11.20
Time: 20:53:29
Voltage terminal 30: 11.8 V
Satellite radio tuner status-Satellite radio antenna status: Electrical OK
Satellite radio tuner status-Channel selection for satellite radio: 0
Satellite radio tuner status-Audio Signal: Not available
Satellite radio tuner status-Antenna current: 0 mA
Satellite radio tuner status-Reception quality: Not available
Satellite radio tuner status-SDARS Flash Regional code: US_Audio_Traffic_Travellink
-------------------------------------------------------------------------------
Address 75: Telematics (J949) Labels: 5QE-035-285.clb
Part No SW: 5QE 035 285 HW: 5QE 035 285
Component: OCULowMQBUS 006 0528
Coding: 02730002C2821A017F1E06000000
Shop #: WSC 00066 790 00208
ASAM Dataset: EV_OCULowMQB 001003
ROD: EV_OCULowMQB.rod
VCID: 0201A74D95991D52AA-8056
No fault code found.
End-------------------------(Elapsed Time: 03:23)--------------------------
Last edited by a moderator: