Results 1 to 10 of 114

Thread: 07 GTI Won't Start. Turns over and fires a couple times

Threaded View

Previous Post Previous Post   Next Post Next Post
  1. #1
    Verified VCDS User GTIF's Avatar
    Join Date
    Jun 2016
    Location
    San Diego USA
    Posts
    98
    Post Thanks / Like

    07 GTI Won't Start. Turns over and fires a couple times

    Hi, new to the forum and to computer controlled VWs. Background: I bought this 2007 GTI not running. PO said it just quit at a light and that was it. It sat for 9 months with no battery. I bought a battery and I started doing research and checking things. I replaced the spark plugs, crank sensor, cam sensor, and HPFP cam follower. Ran compression test, checked good. 130ish on all 4 (207K miles). Changed oil, new filter, checked for spark and fuel pressure, checked fuses, cleaned the MAF. No obvious cracks in intake tubes. Engine cranks and fires a couple times then nothing, just keeps cranking. Same results with starter fluid. OBDII codes wouldn't read so I bought a VCDS from Ross-Tech. The output tells me MAF, intake leak, or bad injectors (or all 3!). I will check the MAF with my multi meter tonight. Any thoughts?

    Code:
    Chassis Type: 1K (1K0)
    Scan: 01 02 03 08 09 0F 15 16 17 19 1C 25 42 44 46 52 55 56 65
    
    VIN: WVWFV71K37W16XXXX   Mileage: 333150km-207009miles
    
    00-Steering Angle Sensor -- Status: OK 0000
    01-Engine -- Status: Malfunction 0010
    02-Auto Trans -- Status: Malfunction 0010
    03-ABS Brakes -- Status: Malfunction 0010
    08-Auto HVAC -- Status: Malfunction 0010
    09-Cent. Elect. -- Status: Malfunction 0010
    0F-Digital Radio -- Status: Malfunction 0010
    15-Airbags -- Status: Malfunction 0010
    16-Steering wheel -- Status: OK 0000
    17-Instruments -- Status: Malfunction 0010
    19-CAN Gateway -- Status: Malfunction 0010
    1C-Position Sensing -- Status: OK 0000
    25-Immobilizer -- Status: Malfunction 0010
    42-Door Elect, Driver -- Status: Malfunction 0010
    44-Steering Assist -- Status: Malfunction 0010
    46-Central Conv. -- Status: Malfunction 0010
    52-Door Elect, Pass. -- Status: Malfunction 0010
    55-Headlight Range -- Status: OK 0000
    56-Radio -- Status: Malfunction 0010
    65-Tire Pressure -- Status: OK 0000
     
    -------------------------------------------------------------------------------
    Address 01: Engine        Labels: 06F-907-115-AXX.clb
       Part No SW: 1K0 907 115 H    HW: 8P0 907 115 B
       Component: 2.0l R4/4V TFSI     0020  
       Revision: 5BH15---    Serial number: VWZ7Z0G8013765
       Coding: 0403010A1C070160
       Shop #: WSC 01279 067 57207
       VCID: 2B7BF8198AC3C266FB-807E
    
    4 Faults Found:
    000768 - Random/Multiple Cylinder Misfire Detected 
                   P0300 - 008 -  - Intermittent
                 Freeze Frame:
                        Fault Status: 00111000
                        Fault Priority: 0
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 332939 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 19:57:33
    
                 Freeze Frame:
                        RPM: 889 /min
                        Load: 25.5 %
                        Speed: 0.0 km/h
                        Temperature: 86.0C
                        Temperature: 65.0C
                        Absolute Pres.: 990.0 mbar
                        Voltage: 13.081 V
    
    008583 - Bank 1; System too Lean at Idle 
                   P2187 - 004 -  - Intermittent
                 Freeze Frame:
                        Fault Status: 00110100
                        Fault Priority: 0
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 333058 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 05:03:23
    
                 Freeze Frame:
                        RPM: 1050 /min
                        Load: 15.3 %
                        Speed: 6.0 km/h
                        Temperature: 78.0C
                        Temperature: 57.0C
                        Absolute Pres.: 990.0 mbar
                        Voltage: 12.954 V
    
    008825 - Leak in Air Intake System 
                   P2279 - 002 -  - Intermittent
                 Freeze Frame:
                        Fault Status: 00110010
                        Fault Priority: 0
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 333058 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 05:03:36
    
                 Freeze Frame:
                        RPM: 895 /min
                        Load: 15.7 %
                        Speed: 0.0 km/h
                        Temperature: 78.0C
                        Temperature: 58.0C
                        Absolute Pres.: 990.0 mbar
                        Voltage: 12.954 V
    
    000256 - Mass Air Flow Sensor (G70) 
                   P0100 - 004 - Supply Voltage - Intermittent
                 Freeze Frame:
                        Fault Status: 00100100
                        Fault Priority: 0
                        Fault Frequency: 2
                        Reset counter: 255
                        Mileage: 333157 km
                        Time Indication: 0
    
                 Freeze Frame:
                        RPM: 0 /min
                        Load: 0.0 %
                        Speed: 0.0 km/h
                        Temperature: 27.0C
                        Temperature: 28.0C
                        Absolute Pres.: 990.0 mbar
                        Voltage: 12.192 V
    
    Readiness: 0110 0101
    
    -------------------------------------------------------------------------------
    Address 02: Auto Trans        Labels: 02E-927-770.lbl
       Part No SW: 02E 300 043 Q    HW: 02E 927 770 AE
       Component: GSG DSG         070 1306  
       Revision: 04607000    Serial number: 00000612040951
       Coding: 0000020
       Shop #: WSC 01279 785 00200
       VCID: 2265153DFD09032E48-8076
    
    2 Faults Found:
    18243 - Pressure Control Valve 5 (N233) 
                P1835 - 000 - Short to Plus - Intermittent
                 Freeze Frame:
                        Fault Status: 00100000
                        Fault Priority: 0
                        Fault Frequency: 255
                        Reset counter: 8
                        Mileage: 308178 km
                        Time Indication: 0
    
    19143 - Unexpected / Implausible Mechanical Gear Disengagement 
                P2711 - 005 -  - Intermittent
                 Freeze Frame:
                        Fault Status: 00100101
                        Fault Priority: 0
                        Fault Frequency: 255
                        Reset counter: 37
                        Mileage: 312318 km
                        Time Indication: 0
    
    
    -------------------------------------------------------------------------------
    Address 03: ABS Brakes        Labels: 1K0-907-379-MK60-F.lbl
       Part No SW: 1K0 907 379 AC    HW: 1K0 907 379 AC
       Component: ESP FRONT MK60      0101  
       Revision: 00H11001    
       Coding: 0021122
       Shop #: WSC 01279 785 00200
       VCID: 73CB20791273DAA673-8026
    
    2 Faults Found:
    00668 - Supply Voltage Terminal 30 
                002 - Lower Limit Exceeded - Intermittent
    01314 - Engine Control Module 
                013 - Check DTC Memory - Intermittent
    
    -------------------------------------------------------------------------------
    Address 08: Auto HVAC        Labels: 1K0-820-047.lbl
       Part No: 1K0 820 047 GS
       Component: Climatic PQ35   120 0606  
       Shop #: WSC 00000 000 00000
       VCID: 7BDB08593A2392E62B-802E
    
    1 Fault Found:
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent
    
    -------------------------------------------------------------------------------
    Address 09: Cent. Elect.        Labels: 3C0-937-049-23-H.lbl
       Part No SW: 3C0 937 049 AE    HW: 3C0 937 049 AE
       Component: Bordnetz-SG     H52 2002  
       Revision: 00H52000    Serial number: 00000006559540
       Coding: 178D8F214004150047140000001400000028770B5C0001
       Shop #: WSC 22580 444 57677
       VCID: 6CF93B054F4D055EB2-8038
    
       Subsystem 1 - Part No: 1K1 955 119 E  Labels: 1KX-955-119.CLB
       Component: Wischer 201206 020  0501  
       Coding: 00038805
       Shop #: WSC 22580  
    
    1 Fault Found:
    00446 - Function Limitation due to Under-Voltage 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 4
                        Fault Frequency: 6
                        Reset counter: 38
                        Mileage: 333157 km
                        Time Indication: 0
                        Date: 2005.09.13
                        Time: 31:63:63
    
                 Freeze Frame:
                            ON
                        Voltage: 8.90 V
                            ON
                            ON
                            OFF
                            OFF
                            OFF
    
    
    -------------------------------------------------------------------------------
    Address 0F: Digital Radio        Labels: 8E0-035-593-SIR.lbl
       Part No SW: 8E0 035 593 H    HW: 8E0 035 593 H
       Component: SDAR SIRIUS     H06 0080  
       Revision: 00000000    Serial number: AUZ4Z7F0024301
       Shop #: WSC 00000 000 00000
       VCID: 2E7DF10DB9D1B74EDC-807A
    
    5 Faults Found:
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 7
                        Fault Frequency: 2
                        Reset counter: 38
                        Mileage: 333157 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 06:17:28
    
                 Freeze Frame:
                        Voltage: 8.30 V
    
    00446 - Function Limitation due to Under-Voltage 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 7
                        Fault Frequency: 1
                        Reset counter: 38
                        Mileage: 333157 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 00:03:47
    
                 Freeze Frame:
                        Voltage: 8.40 V
    
    02635 - Tuner Not Enabled/Activated 
                000 -  - 
                 Freeze Frame:
                        Fault Status: 01100000
                        Fault Priority: 7
                        Fault Frequency: 1
                        Reset counter: 216
                        Mileage: 105914 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 13:42:53
    
    02788 - Internal Communications Error 
                000 -  - 
                 Freeze Frame:
                        Fault Status: 01100000
                        Fault Priority: 7
                        Fault Frequency: 254
                        Reset counter: 253
                        Mileage: 333157 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 19:11:35
    
                 Freeze Frame:
                        Bin. Bits: 00000000
                        Bin. Bits: 00000001
    
    01304 - Radio 
                008 - Implausible Signal - Intermittent
                 Freeze Frame:
                        Fault Status: 00101000
                        Fault Priority: 5
                        Fault Frequency: 1
                        Reset counter: 38
                        Mileage: 333157 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 00:01:34
    
    
    -------------------------------------------------------------------------------
    Address 15: Airbags        Labels: 1K0-909-605.lbl
       Part No SW: 1K0 909 605 AB    HW: 1K0 909 605 AB
       Component: 5L AIRBAG VW8R  034 8000  
       Revision: 05034000    Serial number: 003B6D07R6RE  
       Coding: 0013644
       Shop #: WSC 01269 785 00200
       VCID: 6CF93B054F4D055EB2-8038
    
       Subsystem 1 - Part No: 1K0 959 339 G
       Component: BF-Gewichtsens. 007 0007
    
       Subsystem 2 - Serial number: 6332MSME151A07522
    
       Subsystem 3 - Serial number: 6342MSME156A6B6EV
    
       Subsystem 4 - Serial number: 6352QSME1C76133DN
    
       Subsystem 5 - Serial number: 6362QSME1E183E4D-
    
       Subsystem 6 - Serial number: 63727SME0B640C2E9
    
       Subsystem 7 - Serial number: 63827SME0B771B200
    
    5 Faults Found:
    00591 - Seat Belt Switch; Driver (E24) 
                010 - Open or Short to Plus - Intermittent - MIL ON
    02513 - Belt Force Sensor for Seat Occupied Recognition (G453) 
                003 - Mechanical Failure - Intermittent - MIL ON
    00591 - Seat Belt Switch; Driver (E24) 
                008 - Implausible Signal - Intermittent - MIL ON
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent - MIL ON
    01587 - Igniter 2 for Airbag; Drivers Side (N250) 
                001 - Upper Limit Exceeded - Intermittent - MIL ON
    
    -------------------------------------------------------------------------------
    Address 16: Steering wheel        Labels: 1K0-953-549-MY8.lbl
       Part No SW: 1K0 953 549 AG    HW: 1K0 953 549 AG
       Component: J0527           636 0070  
       Coding: 0012122
       Shop #: WSC 01279 785 00200
       VCID: 77D31469060BB6864F-8022
    
       Subsystem 1 - Part No: XXXXXXXXXXX 
       Component: E0221           002 0010
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 17: Instruments        Labels: 1K0-920-xxx-17.lbl
       Part No SW: 1K6 920 973 A    HW: 1K6 920 973 A
       Component: KOMBIINSTRUMENT VDD 1610  
       Revision: V0003000    Serial number: VWZ7Z0G8013765
       Coding: 0007207
       Shop #: WSC 22580 444 53700
       VCID: 3147EA71A8EFA8B6C1-8064
    
    9 Faults Found:
    00446 - Function Limitation due to Under-Voltage 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 2
                        Fault Frequency: 5
                        Reset counter: 38
                        Mileage: 333157 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 00:03:21
    
    00771 - Fuel Level Sensor (G) 
                010 - Open or Short to Plus - Intermittent
                 Freeze Frame:
                        Fault Status: 00101010
                        Fault Priority: 2
                        Fault Frequency: 9
                        Reset counter: 38
                        Mileage: 332184 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 06:09:43
    
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 2
                        Fault Frequency: 2
                        Reset counter: 38
                        Mileage: 333157 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 00:04:17
    
    01314 - Engine Control Module 
                004 - No Signal/Communication - Intermittent
                 Freeze Frame:
                        Fault Status: 00100100
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 38
                        Mileage: 0 km
                        Time Indication: 0
    
    01316 - ABS Control Module 
                004 - No Signal/Communication - Intermittent
                 Freeze Frame:
                        Fault Status: 00100100
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 38
                        Mileage: 0 km
                        Time Indication: 0
    
    01315 - Transmission Control Module 
                004 - No Signal/Communication - Intermittent
                 Freeze Frame:
                        Fault Status: 00100100
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 38
                        Mileage: 0 km
                        Time Indication: 0
    
    01321 - Control Module for Airbags (J234) 
                004 - No Signal/Communication - Intermittent
                 Freeze Frame:
                        Fault Status: 00100100
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 38
                        Mileage: 0 km
                        Time Indication: 0
    
    01309 - Power Steering Control Module (J500) 
                004 - No Signal/Communication - Intermittent
                 Freeze Frame:
                        Fault Status: 00100100
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 38
                        Mileage: 0 km
                        Time Indication: 0
    
    00771 - Fuel Level Sensor (G) 
                003 - Mechanical Failure - Intermittent
                 Freeze Frame:
                        Fault Status: 00101010
                        Fault Priority: 2
                        Fault Frequency: 9
                        Reset counter: 38
                        Mileage: 332184 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 06:09:43
    
    
    -------------------------------------------------------------------------------
    Address 19: CAN Gateway        Labels: 1K0-907-530-V2.clb
       Part No SW: 1K0 907 530 K    HW: 1K0 907 951 
       Component: J533__Gateway   H04 0021  
       Revision:   H04 02    Serial number: 070107F1001226
       Coding: 7F8F03600F000000
       Shop #: WSC 01279 785 00200
       VCID: 2F43EC09BEDBBE46D7-807A
    
    1 Fault Found:
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 3
                        Fault Frequency: 1
                        Reset counter: 37
                        Mileage: 333157 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 00:04:17
    
    
    -------------------------------------------------------------------------------
    Address 1C: Position Sensing        Labels: 1Kx-919-xxx-1C.lbl
       Part No SW: 1K6 919 879     HW: 1K6 919 879 
       Component: Kompass         001 0003  
       Revision: 00001000    Serial number: 1225223T1QSF03
       Shop #: WSC 00000 000 00000
       VCID: 7DDF064124379CD615-8028
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 25: Immobilizer        Labels: 1K0-920-xxx-25.clb
       Part No SW: 1K6 920 973 A    HW: 1K6 920 973 A
       Component: IMMO            VDD 1610  
       Revision: V0003000    Serial number: VWZ7Z0G8013765
       Shop #: WSC 00000 000 00000
       VCID: 3147EA71A8EFA8B6C1-8064
    
    1 Fault Found:
    01176 - Key 
                008 - Implausible Signal - Intermittent
                 Freeze Frame:
                        Fault Status: 00101000
                        Fault Priority: 2
                        Fault Frequency: 4
                        Reset counter: 255
                        Mileage: 0 km
                        Time Indication: 0
    
    
    -------------------------------------------------------------------------------
    Address 42: Door Elect, Driver        Labels: 1K0-959-701-MIN3.lbl
       Part No SW: 1K0 959 701 M    HW: 1K0 959 701 M
       Component: Tuer-SG         005 0983  
       Coding: 0001077
       Shop #: WSC 01279 785 00200
       VCID: 3851D7554B9579FE86-806C
    
    3 Faults Found:
    01811 - Supply Voltage for Door Controller; Drivers Side (J386) 
                002 - Lower Limit Exceeded - Intermittent
    01552 - Motor for Central Locking; Drivers Door (V56); Lock 
                012 - Electrical Fault in Circuit - Intermittent
    00928 - Locking Module for Central Locking; Front Driver Side (F220) 
                008 - Implausible Signal - Intermittent
    
    -------------------------------------------------------------------------------
    Address 44: Steering Assist        Labels: 1Kx-909-14x-44.clb
       Part No: 1K1 909 144 L
       Component: EPS_ZFLS Kl.074 H07 1806  
       Shop #: WSC 00000 028 00001
       VCID: 3449E36557FD9D9EAA-8060
    
    2 Faults Found:
    00668 - Supply Voltage Terminal 30 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Mileage: 333150 km
                        Temperature: 17.0C
                        Voltage: 6.00 V
                        Voltage: 5.80 V
    
    00778 - Steering Angle Sensor (G85) 
                000 -  - 
                 Freeze Frame:
    
    
    -------------------------------------------------------------------------------
    Address 46: Central Conv.        Labels: 1K0-959-433-MAX.clb
       Part No SW: 1K0 959 433 CT    HW: 1K0 959 433 CT
       Component:    KSG PQ35 RDK 052 0218  
       Revision: 00052000    Serial number: 00000000000000
       Coding: 139006885103281B0904058FB0080A04889C00
       Shop #: WSC 22580 444 999999
       VCID: 042973A547DDED1E5A-8050
    
       Subsystem 1 - Component:   Sounder n.mounted     
    
       Subsystem 2 - Component:       NGS n.mounted     
    
       Subsystem 3 - Component:      IRUE n.mounted     
    
    2 Faults Found:
    01038 - Central Locking Thermal Protection 
                000 -  -  - Intermittent
                 Freeze Frame:
                        Fault Status: 00100000
                        Fault Priority: 4
                        Fault Frequency: 61
                        Reset counter: 38
                        Mileage: 330689 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 04:39:02
    
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 4
                        Fault Frequency: 6
                        Reset counter: 38
                        Mileage: 333157 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 00:04:16
    
    
    -------------------------------------------------------------------------------
    Address 52: Door Elect, Pass.        Labels: 1K0-959-702-MIN3.lbl
       Part No SW: 1K0 959 702 M    HW: 1K0 959 702 M
       Component: Tuer-SG         005 0983  
       Coding: 0001076
       Shop #: WSC 01279 785 00200
       VCID: 3957D251709F60F679-806C
    
    1 Fault Found:
    01812 - Supply Voltage for Door Controller; Pass. Side (J387) 
                002 - Lower Limit Exceeded - Intermittent
    
    -------------------------------------------------------------------------------
    Address 55: Headlight Range        Labels: 1T0-907-357.lbl
       Part No: 1T0 907 357 
       Component: Dynamische LWR      0003  
       Coding: 0000003
       Shop #: WSC 01279 785 00200
       VCID: 74C92365177DDD9E6A-8020
    
    1 Fault Found:
    00070 - Starting Battery Voltage 
                002 - Lower Limit Exceeded - Intermittent
    
    -------------------------------------------------------------------------------
    Address 56: Radio        Labels: 1K0-035-1xx-56.lbl
       Part No SW: 1K0 035 180 G    HW: 1K0 035 180 G
       Component: Radio PM6       017 0023  
       Revision: 00017000    Serial number: VWZ5Z7F2121101
       Coding: 0040401
       Shop #: WSC 01279 785 00200
       VCID: 24691325E71D0D1E3A-8070
    
    1 Fault Found:
    00668 - Supply Voltage Terminal 30 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 3
                        Fault Frequency: 7
                        Reset counter: 37
                        Mileage: 333157 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 09:00:23
    
    
    -------------------------------------------------------------------------------
    Address 65: Tire Pressure        Labels: 3C0-959-433-65.lbl
       Part No SW: 1K0 959 433 CT    HW: 1K0 959 433 CT
       Component:    RDK              0440  
       Revision: 00052000    Serial number: 00000000000000
       Coding: 0100101
       Shop #: WSC 01279 785 00200
       VCID: 042973A547DDED1E5A-8050
    
    No fault code found.
    
    End-------------------------(Elapsed Time: 01:16)--------------------------
    Last edited by GTIF; 06-29-2016 at 03:05 PM. Reason: still getting this code wrap thing worked out
    Good Thing It's Fast! '07 GTI Fahrenheit

  2. Likes Uwe, Jack@European_Parts liked this post

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •