Page 3 of 3 FirstFirst 123
Results 21 to 28 of 28

Thread: Long Coding for CAN gateway

  1. #21
    Verified VCDS User golfi_vend's Avatar
    Join Date
    Apr 2014
    Location
    Tartu, Estonia
    Posts
    1,988
    Post Thanks / Like
    The battery managemnt code will also flag up when very new can is installed in old car and can gw superseeding isn't followed.
    Reason is that older wirings have GND in place where newer cans have battery management LIN wire. It is needed to remove GND from there and you're fault free.

    Also, although the 61 is in Installation List, it is not in autoscan. - Please go to 61 directly and see fault and clear them.
    I am a VW Freak - Le WV Freaks OR Come visit me at my work with ODIS concerns - FORSS ODIS GeKo/FaZit access for VW/AUDI/Škoda
    The world is my oyster...

  2. Likes Uwe liked this post
  3. #22
    Verified VCDS User
    Join Date
    Aug 2015
    Location
    Italy
    Posts
    22
    Post Thanks / Like
    Well... I put 359002 as long code, cleared the faukts did the scan.

    Code:
    VCDS Version: Release 15.7.2 Running on Windows Vista x86
    Data version: 20151124
    www.Ross-Tech.com
    
    Saturday,12,December,2015,10:47:46:41339
    
    Chassis Type: 1K (7N0)
    Scan: 01 03 08 09 15 16 17 19 25 42 44 46 52 56 62 72 7D
    
    VIN: WV...............   Mileage: 60070km-37325miles
    
    01-Engine -- Status: OK 0000
    03-ABS Brakes -- Status: OK 0000
    04-Steering Angle -- Status: OK 0000
    08-Auto HVAC -- Status: OK 0000
    09-Cent. Elect. -- Status: Malfunction 0010
    15-Airbags -- Status: Malfunction 0010
    16-Steering wheel -- Status: OK 0000
    17-Instruments -- Status: OK 0000
    19-CAN Gateway -- Status: Malfunction 0010
    25-Immobilizer -- Status: OK 0000
    42-Door Elect, Driver -- Status: OK 0000
    44-Steering Assist -- Status: OK 0000
    46-Central Conv. -- Status: OK 0000
    52-Door Elect, Pass. -- Status: OK 0000
    56-Radio -- Status: Malfunction 0010
    61-Battery Regul. -- Status: Malfunction 0010
    62-Door, Rear Left -- Status: OK 0000
    72-Door, Rear Right -- Status: OK 0000
    7D-Aux. Heat -- Status: OK 0000
     
    -------------------------------------------------------------------------------
    Address 01: Engine        Labels: 03G-906-016-BKD.lbl
       Part No SW: 03G 906 016 T    HW: 028 101 195 6
       Component: R4 2,0L EDC 0000SG  7001  
       Revision: 12345678    Serial number: VW.......
       Coding: 0000072
       Shop #: WSC 01392 785 00200
       VCID: 34484E90579A149EBF-8060
    
    No fault code found.
    Readiness: 0 0 0 0 0 
    
    -------------------------------------------------------------------------------
    Address 03: ABS Brakes        Labels: 1K0-907-379-MK60-F.lbl
       Part No: 1K0 907 379 K
       Component: ESP FRONT MK60      0104  
       Coding: 0023282
       Shop #: WSC 01392 785 00200
       VCID: 3A5460A875FEE2EE65-806E
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 08: Auto HVAC        Labels: 1K0-907-044.lbl
       Part No: 1K0 907 044 AF
       Component: ClimatronicPQ35 066 0505  
       Shop #: WSC 00000 000 00000
       VCID: 6BFA95EC4A248B66AE-803E
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 09: Cent. Elect.        Labels: 3C0-937-049-23-H.lbl
       Part No SW: 1K0 937 049 N    HW: 1K0 937 049 N*
       Component: Bordnetz-SG     H34 0803  
       Revision: 00H34000    Serial number: 0000000.........
       Coding: 01890F2600041800000A00000F00000000085D035C
       Shop #: WSC 00000 000 00000
       VCID: 3A5460A875FEE2EE65-806E
    
       Subsystem 1 - Part No: 5M0 955 119 
       Component: Wischer VW359  012  0402  
       Coding: 00065493
       Shop #: WSC 00000  
    
    2 Faults Found:
    01299 - Diagnostic Interface for Data Bus (J533) 
                004 - No Signal/Communication - Intermittent
    01299 - Diagnostic Interface for Data Bus (J533) 
                005 - No or Incorrect Basic Setting / Adaptation - Intermittent
    
    -------------------------------------------------------------------------------
    Address 15: Airbags        Labels: 1K0-909-605.lbl
       Part No SW: 1K0 909 605 C    HW: 1K0 909 605 C
       Component: 1M AIRBAG VW8   013 2100  
       Revision: 02013000    Serial number: 0033.......  
       Coding: 0012621
       Shop #: WSC 01372 785 00200
       VCID: 2C7856F08FAA4C5EE7-8078
    
       Subsystem 1 - Serial number: 6332MSME085610281
    
       Subsystem 2 - Serial number: 6342MSME08394B6CP
    
       Subsystem 3 - Serial number: 6351HSME06401118V
    
       Subsystem 4 - Serial number: 6361HSME062E5A75H
    
    1 Fault Found:
    01578 - Airbag Deactivation Warning Lamp; Passenger Side (K145) 
                009 - Open or Short to Ground - Intermittent - MIL ON
    
    -------------------------------------------------------------------------------
    Address 16: Steering wheel        Labels: 1K0-953-549-MY8.lbl
       Part No SW: 1K0 953 549 G    HW: 1K0 953 549 G
       Component: Lenksäulenmodul 521 0050  
       Coding: 0002012
       Shop #: WSC 01392 785 00200
       VCID: 364C749841E6068E81-8062
    
       Subsystem 1 - Part No: XXXXXXXXXXX 
       Component: Lenkradmodul    007 0050
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 17: Instruments        Labels: 1K0-920-xxx-17.lbl
       Part No: 1K0 920 861 B
       Component: KOMBIINSTRUMENT VDD 0814  
       Coding: 0003103
       Shop #: WSC 30562 264 68225
       VCID: 2870AAE09B52607E03-807C
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 19: CAN Gateway (J533)       Labels: 7N0-907-530-V2.clb
       Part No SW: 7N0 907 530 AM    HW: 7N0 907 530 AM
       Component: J533  Gateway H55 1642  
       Revision:   H55       Serial number: 111213F1002338
       Coding: 359002
       Shop #: WSC 12345 123 12345
       VCID: 7BDAA5ACFA441BE63E-802E
    
    1 Fault Found:
    01305 - Databus for Infotainment 
                004 - No Signal/Communication - Intermittent
                 Freeze Frame:
                        Fault Status: 00100100
                        Fault Priority: 1
                        Fault Frequency: 1
                        Reset counter: 46
                        Mileage: 60078 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 10:33:48
    
    
    -------------------------------------------------------------------------------
    Address 25: Immobilizer        Labels: 1K0-920-xxx-25.clb
       Part No: 1K0 920 861 B
       Component: IMMO            VDD 0814  
       Shop #: WSC 00000 000 00000
       VCID: 2870AAE09B52607E03-807C
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 42: Door Elect, Driver        Labels: 1K0-959-701-MIN1.lbl
       Part No: 1K0 959 701 E
       Component: Tuersteuergeraet 09 0167  
       Coding: 0000052
       Shop #: WSC 01287 785 00200
       VCID: 30404280A38228BEDB-8064
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 44: Steering Assist        Labels: 1Kx-909-14x-44.clb
       Part No: 1K1 909 144 H
       Component: EPS_ZFLS Kl.3       1502  
       Shop #: WSC 00000 000 00000
       VCID: 30404280A38228BEDB-8064
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 46: Central Conv.        Labels: 1K0-959-433-MIN.clb
       Part No: 1K0 959 433 AK
       Component:    KSG              0401  
       Coding: 00C802087F2D8404084F01E010CC
       Shop #: WSC 01392 785 00200
       VCID: 79D6BFA4307829F62C-802C
    
       Subsystem 1 - Component:   Sounder n.mounted     
    
       Subsystem 2 - Component:       NGS n.mounted     
    
       Subsystem 3 - Component:      IRUE n.mounted     
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 52: Door Elect, Pass.        Labels: 1K0-959-702-MIN1.lbl
       Part No: 1K0 959 702 E
       Component: Tuersteuergeraet 09 0167  
       Coding: 0000052
       Shop #: WSC 01287 785 00200
       VCID: 31464784A88821B6D4-8064
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 56: Radio (J503)       Labels: 5M0-035-1xx-56.clb
       Part No SW: 5J0 035 161 G    HW: 5J0 035 161 G
       Component: Radio-SWING   006 0005  
       Revision: -----09S    Serial number: SKZ4Z2R1132598
       Coding: 0D0004000006
       Shop #: WSC 33361 790 00099
       VCID: 266CA4D85146760E31-8072
    
    4 Faults Found:
    00856 - Radio Antenna 
                011 - Open Circuit
                 Freeze Frame:
                        Fault Status: 01101011
                        Fault Priority: 5
                        Fault Frequency: 1
                        Reset counter: 32
                        Mileage: 59040 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 19:13:38
    
    01336 - Company Data Bus for Comfort System 
                004 - No Signal/Communication - Intermittent
                 Freeze Frame:
                        Fault Status: 00100100
                        Fault Priority: 6
                        Fault Frequency: 6
                        Reset counter: 46
                        Time Indication: 0
    
    01327 - Control Module for Parking Aid (J446) 
                004 - No Signal/Communication
                 Freeze Frame:
                        Fault Status: 01100100
                        Fault Priority: 6
                        Fault Frequency: 3
                        Reset counter: 6
                        Mileage: 59949 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 14:18:58
    
    00873 - Bass Speaker Rear Right (R17) 
                011 - Open Circuit
                 Freeze Frame:
                        Fault Status: 01101011
                        Fault Priority: 5
                        Fault Frequency: 1
                        Reset counter: 2
                        Time Indication: 0
    
    
    -------------------------------------------------------------------------------
    Address 62: Door, Rear Left        Labels: 1K0-959-703-GEN1.lbl
       Part No: 1K0 959 703 C
       Component: Tuersteuergeraet 06 0220  
       Coding: 0000016
       Shop #: WSC 01287 785 00200
       VCID: 30404280A38228BEDB-8064
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 72: Door, Rear Right        Labels: 1K0-959-704-GEN1.lbl
       Part No: 1K0 959 704 C
       Component: Tuersteuergeraet 06 0220  
       Coding: 0000016
       Shop #: WSC 01287 785 00200
       VCID: 31464784A88821B6D4-8064
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 7D: Aux. Heat        Labels: 1K0-963-235.lbl
       Part No SW: 1K0 963 235 E    HW: 1K0 963 235 E
       Component: PTC-Element         0404  
       Revision: 00800000    Serial number:               
       Shop #: WSC 00000 000 00000
       VCID: 2D7E5BF4B4B04556F0-8078
    
    No fault code found.
    
    End-------------------------(Elapsed Time: 01:14)--------------------------
    Last edited by Uwe; 12-12-2015 at 08:58 AM. Reason: CODE tags

  4. #23
    Verified VCDS User
    Join Date
    Aug 2015
    Location
    Italy
    Posts
    22
    Post Thanks / Like
    I omitted the serial numbers only for a matter of privacy.

    I am worried of the remaining faults... Except for the radio because I need a radio antenna cable adapter.

    What about the battery regulator? Do I have really to weld the groud in a different way?

    09-Cent. Elect. -- Status: Malfunction 0010

    19-CAN Gateway -- Status: Malfunction 0010

    56-Radio -- Status: Malfunction 0010

    61-Battery Regul. -- Status: Malfunction 0010



    VCDS Version: Release 15.7.2 Running on Windows Vista x86
    www.Ross-Tech.com

    Address 61: Battery Regul. Labels: 1K0-907-534.clb
    Control Module Part Number: 7N0 907 534 HW: 7N0 907 530 AM
    Component and/or Version: Batt.regelung H55 1642
    Software Coding: F000185A
    Work Shop Code: WSC 12345 123 12345
    VCID: 71C68784A80861B694-8024
    1 Fault Found:

    02071 - Local Databus
    012 - Electrical Fault in Circuit
    Freeze Frame:
    Fault Status: 01101100
    Fault Priority: 2
    Fault Frequency: 1
    Reset counter: 6
    Mileage: 60078 km
    Time Indication: 0
    Date: 2000.00.00
    Time: 10:52:58

    Thanks again for your tips.

  5. #24
    Ross-Tech Employee Sebastian's Avatar
    Join Date
    Feb 2014
    Location
    Magdeburg, Germany
    Posts
    1,944
    Post Thanks / Like
    #09 The gateaway you installed isn't exactly compatible to the central electronics, it will likely keep flagging those codes. Install a proper gateway to fix this.

    #19 See comments on #56.

    #56 A Skoda Fabia/Roomster Radio in a Golf will never run free of faults, you may be able to reduce them but that's about it. Install a proper radio to fix this.

    #61 Since your car doesn't have battery management (and the relating sensors), but the Gateway (that isn't meant for your car) looks for them - there is nothing you can do, other than installing a proper gateway. If if you retrofitted the sensor etc., the remaining vehicle systems would have no idea what to do with the information. IMO not worth it...
    Sebastian @ Ross-Tech.com // VCDS Rookie since 2003

    »Nichts erweitert das eigene Wissen mehr,
    als die Meinung eines Andersdenkenden.«

  6. Likes Uwe liked this post
  7. #25
    Verified VCDS User golfi_vend's Avatar
    Join Date
    Apr 2014
    Location
    Tartu, Estonia
    Posts
    1,988
    Post Thanks / Like
    61 fault will flag up because LIN wire is short to ground, not because the can has it listed.

  8. #26
    Verified VCDS User
    Join Date
    Aug 2015
    Location
    Italy
    Posts
    22
    Post Thanks / Like
    But then... Can I solve the problem opening the CAN gateway and unwelding the LIN... or it is better to give up??

  9. #27
    Verified VCDS User golfi_vend's Avatar
    Join Date
    Apr 2014
    Location
    Tartu, Estonia
    Posts
    1,988
    Post Thanks / Like
    Quote Originally Posted by enrico View Post
    But then... Can I solve the problem opening the CAN gateway and unwelding the LIN... or it is better to give up??
    Yes cut pin or remove wire. But you have others faults to address.
    I am a VW Freak - Le WV Freaks OR Come visit me at my work with ODIS concerns - FORSS ODIS GeKo/FaZit access for VW/AUDI/Škoda
    The world is my oyster...

  10. #28
    Verified VCDS User
    Join Date
    Aug 2015
    Location
    Italy
    Posts
    22
    Post Thanks / Like
    Well, no... Better to stop this kind of troubleshooting on the car I own. Today I put back the old gateway and RCD300 radio.
    I thought it was much simpler upgrading a radio, even the volume control on steer does not work.

    But thank you for your support. Now I have much clear the use of VCDS.

    Bye

Tags for this Thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •