I am hoping this forum could help me with a problem that I cannot seem to get past with an aftermarket trailer module that I installed on my 2019 VW Alltrack SE. I have tried reading through the Ross-Tech, VW Vortex, and TDI Club forums, but have not found a solution. My autoscan is below.
I bought a 7 pin towbar electrics set from PF Jones. It is labeled as PF Jones, but manufactured by ConWys. PF Jones assured me that the module could be coded for North America, but, looking back, I am starting to wish I had bought the 13 pin Westfalia module.
Physical installation seemed to go okay. Coding did as well for the most part and I do not see any problems in the autoscan.
However, I cannot get the trailer module to switch to the USA configuration (it says "USA" in the long-coding helper, not "North America"). VCDS indicates that the coding was accepted, but power keeps going to the dedicated brake pin instead of the two "turn signal" pins, so the coding must not be taking. The WSC has all zeros in the module, so I suspect that might be the problem.
I am getting the message for an uninitialized module and have entered a fake workshop code, although it does say "coding accepted" after I do that.
One approach I have read about, but not tried, is changing my WSC permanently in the "options" menu. The Ross-Tech wiki on trailer modules does not recommend it, so I have avoided it so far, but I would like to hear whether people think that is worth a try. I also have not tried using an access code yet. I have read that trailer modules typically do not require access codes, but maybe this one is different. One of these forums lists 20103 as an access code for trailer modules, so maybe that is worth a shot.
I called PF Jones earlier this week and they re-confirmed that the module should be capable of coding for North America, but they said they could not provide coding advice for North American specific issues. ConWys does not appear to have any customer support.
Does anyone have any suggestions, maybe even someone with experience with these ConWys modules?
I bought a 7 pin towbar electrics set from PF Jones. It is labeled as PF Jones, but manufactured by ConWys. PF Jones assured me that the module could be coded for North America, but, looking back, I am starting to wish I had bought the 13 pin Westfalia module.
Physical installation seemed to go okay. Coding did as well for the most part and I do not see any problems in the autoscan.
However, I cannot get the trailer module to switch to the USA configuration (it says "USA" in the long-coding helper, not "North America"). VCDS indicates that the coding was accepted, but power keeps going to the dedicated brake pin instead of the two "turn signal" pins, so the coding must not be taking. The WSC has all zeros in the module, so I suspect that might be the problem.
I am getting the message for an uninitialized module and have entered a fake workshop code, although it does say "coding accepted" after I do that.
One approach I have read about, but not tried, is changing my WSC permanently in the "options" menu. The Ross-Tech wiki on trailer modules does not recommend it, so I have avoided it so far, but I would like to hear whether people think that is worth a try. I also have not tried using an access code yet. I have read that trailer modules typically do not require access codes, but maybe this one is different. One of these forums lists 20103 as an access code for trailer modules, so maybe that is worth a shot.
I called PF Jones earlier this week and they re-confirmed that the module should be capable of coding for North America, but they said they could not provide coding advice for North American specific issues. ConWys does not appear to have any customer support.
Does anyone have any suggestions, maybe even someone with experience with these ConWys modules?
Code:
Tuesday,21,July,2020,18:15:48:60668
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 20.4.1.0 (x64) HEX-V2 CB: 0.4508.4
Data version: 20200331 DS317.0
www.Ross-Tech.com
VIN: 3VWH17AU1KM506752 License Plate:
Mileage: 7888km-4901mi Repair Order:
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: AU-VW37 (3Q0)
Scan: 01 02 03 05 08 09 10 13 15 17 19 22 29 2B 39 3C 42 44 4B 52
5F 69 75 A5 CA D6 D7
VIN: 3VWH17AU1KM506752 Mileage: 7888km-4901miles
01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
13-Auto Dist. Reg -- Status: OK 0000
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
22-AWD -- Status: OK 0000
29-Left Light -- Status: OK 0000
2B-Steer. Col. Lock -- Status: OK 0000
39-Right Light -- Status: OK 0000
3C-Lane Change -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
4B-Multifunc. Module -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
5F-Information Electr. -- Status: OK 0000
69-Trailer -- Status: OK 0000
75-Telematics -- Status: OK 0000
A5-Frt Sens. Drv. Assist -- Status: OK 0000
CA-Sunroof -- Status: OK 0000
D6-Light Ctrl Left 2 -- Status: OK 0000
D7-Light Ctrl Right 2 -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CXBB) Labels:. 06K-907-425-V1.clb
Part No SW: 8V0 906 264 M HW: 06K 907 425 B
Component: 1.8l R4 TFSI H13 0001
Revision: --H13---
Coding: 311D00322436002F1000
Shop #: WSC 00066 790 00392
ASAM Dataset: EV_ECM18TFS0208V0906264M 001003
ROD: EV_ECM18TFS020_VW37.rod
VCID: 46D55370C82922FB297-8012
No fault code found.
Readiness: 1110 1101
-------------------------------------------------------------------------------
Address 02: Auto Trans (J743) Labels: 0D9-927-770.clb
Part No SW: 0D9 300 018 HW: 02E 927 770 AS
Component: DQ250-6A MQB H54 5201
Revision: 06454104 Serial number: TFK01811160277
Coding: 0014
Shop #: WSC 00066 790 00392
ASAM Dataset: EV_TCMDQ250021 001001
ROD: EV_TCMDQ250021.rod
VCID: 59EF880C6997BD03745-800C
No fault code found.
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels: None
Part No SW: 5Q0 614 517 FC HW: 5Q0 614 517 BM
Component: ESC H45 0191
Revision: 00000000 Serial number: 53348000000328
Coding: 43FA6AA130200972807E0305A0C529C2560C9001C005943430435050F0A94B0B0040010312121212B435351919323200
Shop #: WSC 58774 003 1048576
ASAM Dataset: EV_Brake1UDSContiMK100IPB 038007
ROD: EV_Brake1UDSContiMK100IPB_038.rod
VCID: 77ABEEB4FF438B73621-8022
No fault code found.
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J518) Labels:| 5Q0-959-435.clb
Part No SW: 3Q0 959 435 L HW: 3Q0 959 435 L
Component: VWKESSYMQB 037 1204
Revision: 00037000 Serial number: 0502943760
Coding: 132C0C0723
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_KessyHellaMQBAB 004046
ROD: EV_KessyHellaMQBAB.rod
VCID: 43D34A64FB1B17D30E9-8016
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301) Labels:| 5G0-907-426.clb
Part No SW: 5GM 907 426 G HW: 5GM 907 426 G
Component: AC Manuell H03 2001
Revision: 00001K05
Coding: 02020004200110000100000000000002
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_ACManueBHBVW37X 004134
ROD: EV_ACManueBHBVW37X_004.rod
VCID: 4CC16158D645D8ABFF3-8018
Fresh Air Blower Front:
Geber für Kältemitteldruck/Kältemitteltemperatur:
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 5Q0-937-08X-V2.clb
Part No SW: 5Q0 937 087 BA HW: 5Q0 937 087 BA
Component: BCM PQ37BOSCH 036 0265
Revision: -------- Serial number: C86404011904CH
Coding: 000000000000000000000000000000000000000000000000000000000000
Shop #: WSC 00066 790 00280
ASAM Dataset: EV_BodyContrModul1UDSBosc 019001
ROD: EV_BCMBOSCH_019.rod
VCID: 7BA3F284C36BAF13069-802E
Control Unit For Wiper Motor:
Subsystem 1 - Part No SW: 5G1 955 119 A HW: 5G1 955 119 Labels: 5QX-955-119-V1.CLB
Component: WWS 181113 043 0551
Serial number: 97022066181129085345
Coding: 0E4DDD
Rain Light Recognition Sensor:
Subsystem 2 - Part No SW: 5Q0 955 559 B HW: 5Q0 955 559 B Labels: 5Q0-955-547.CLB
Component: RLS 050 0105
Serial number: S6Y18M11D30H15M17S25
Coding: 00A8DD
Steering Column Switch:
Subsystem 3 - Part No SW: 5Q1 953 521 M HW: 5Q1 953 569
Component: Lenks.Modul H03 0170
Serial number: 0300150120190C202076
No fault code found.
-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J791) Labels:| 5Q0-919-298.clb
Part No SW: 5QA 919 298 D HW: 5QA 919 298 A
Component: PLA 3.0 12KH07 0050
Serial number: 000137089R19004
Coding: 0271167111
Shop #: WSC 00066 790 00267
ASAM Dataset: EV_EPHVA2CAU3700000 009041
ROD: EV_EPHVA2CAU3700000_009_VW37.rod
VCID: 51FF702C3167F5438C5-8004
No fault code found.
-------------------------------------------------------------------------------
Address 13: Auto Dist. Reg (J428) Labels:| 3Q0-907-572.clb
Part No SW: 5Q0 907 572 P HW: 3QF 907 572 A
Component: ACC BOSCH MQB H11 0682
Coding: 350000C901FFC728949C810500401600000000000000000004
Shop #: WSC 00066 790 00392
ASAM Dataset: EV_ACCBOSCHVW416 002008
ROD: EV_ACCBOSCHVW416_002_VW37.rod
VCID: 44D14978FE1510EB373-8010
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:| 5Q0-959-655.clb
Part No SW: 5Q0 959 655 J HW: 5Q0 959 655 J
Component: AirbagVW20 010 0830
Serial number: 003GCR0ASUUR
Coding: 8CCCFC00000000005000001AC24800000065
Shop #: WSC 00066 790 00267
ASAM Dataset: EV_AirbaVW20SMEVW37X 002144
ROD: EV_AirbaVW20SMEVW37X_VW37.rod
VCID: 47CB5E74CF233BF3D21-8012
Occupant Detection:
Subsystem 1 - Part No SW: 4M0 959 339 B HW: 4M0 959 339 B
Component: BF-Gewichtss. H13 0022
Serial number: IBH00000000000AU5PTG
Coding: 303135
Side Sensor Driver Front:
Subsystem 2 - Part No SW: ----------- HW: 480 001 611 18
Component: SideSensor_Df 001 0887
Serial number: 35700000000485344639
Coding: 2D2D2D
Side Sensor Passenger Front:
Subsystem 3 - Part No SW: ----------- HW: 480 001 611 18
Component: SideSensor_Pf 001 0887
Serial number: 35800000000940FC163N
Coding: 2D2D2D
Side Sensor Driver Rear:
Subsystem 4 - Part No SW: ----------- HW: 480 400 609 18
Component: SideSensor_Dr 004 6149
Serial number: 3510001142B70FA3411Q
Coding: 2D2D2D
Side Sensor Passenger Rear:
Subsystem 5 - Part No SW: ----------- HW: 480 400 609 18
Component: SideSensor_Pr 004 6149
Serial number: 3520001142B70FA3432U
Coding: 2D2D2D
Front Sensor Driver:
Subsystem 6 - Part No SW: ----------- HW: 480 402 611 18
Component: FrontSensor_D 003 6149
Serial number: 3550001A52E1DC424421
Coding: 2D2D2D
Front Sensor Passenger:
Subsystem 7 - Part No SW: ----------- HW: 480 402 611 18
Component: FrontSensor_P 003 6149
Serial number: 3560001A52E1DC41D4AI
Coding: 2D2D2D
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5G0-920-XXX-17.clb-SRI3
Part No SW: 5G1 920 840 D HW: 5G1 920 840 D
Component: KOMBI 252 2500
Coding: 0BA4101DE988CF0502886A0B5001000080000000
Shop #: WSC 00066 790 00267
ASAM Dataset: EV_DashBoardVDDMQBAB 009065
ROD: EV_DashBoardVDDMQBAB_009_VW37.rod
VCID: 2809FDC8627DD48B3BB-807C
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:| 3Q0-907-530-V1.clb
Part No SW: 3Q0 907 530 AA HW: 3Q0 907 530 C
Component: GW MQB High 521 5366
Serial number: 06011900840060
Coding: 0901000830085900FB00200A1E0F00000001070000000000000000000000
Shop #: WSC 00066 790 00267
ASAM Dataset: EV_GatewNF 013025
ROD: EV_GatewNF_VW37.rod
VCID: 6E85CBD08019CABBB17-803A
Alternator:
Component: 0-00-0d-00-04
Multi Function Steering Wheel Control Module:
Subsystem 2 - Part No SW: 5G0 959 442 AA HW: 5G0 959 442 AA Labels: 3C8-959-537.CLB
Component: E221__MFL-DC1 H17 0052
Serial number: 33180001840030071439
Coding: 28FFFF
Power Converter DC AC:
Subsystem 3 - Part No SW: 5Q0 907 155 A HW: 5Q0 907 155 A
Component: U13DCAC H25 0780
Serial number: 0014029
No fault code found.
-------------------------------------------------------------------------------
Address 22: AWD (J492) Labels:* 0CQ-907-554.clb
Part No SW: 0CQ 907 554 J HW: 0CQ 525 130
Component: Haldex4Motion H55 7084
Serial number: HA1-00029.10.18
Coding: 0001
Shop #: WSC 00066 790 00392
ASAM Dataset: EV_AllWheelContrHA1VW37X 004013
ROD: EV_AllWheelContrHA1VW37X.rod
VCID: 4CC16158D645D8ABFF3-8018
No fault code found.
-------------------------------------------------------------------------------
Address 29: Left Light (J1018) Labels: 8V0-907-399.clb
Part No SW: 8V0 907 399 D HW: 8V0 907 399 D
Component: LCM_MLBevoH08 0014
ASAM Dataset: EV_LCMLeftHELLAAU736 001012
ROD: EV_LCMLeftHELLAAU736_VW37.rod
VCID: 47CB5E74CF233BF3D21-8012
No fault code found.
-------------------------------------------------------------------------------
Address 2B: Steer. Col. Lock (J764) Labels:* 5Q0-905-861.clb
Part No SW: 2Q0 905 861 A HW: 2Q0 905 861 A
Component: ELV-MQBB H07 0021
Serial number: 18000353376013
Coding: 0800000000000000
Shop #: WSC 00066 790 00267
ASAM Dataset: EV_ELVMarqMQBA0 002002
ROD: EV_ELVMarqMQBA0_VW37.rod
VCID: 313F10AC51A79543EC5-8064
No fault code found.
-------------------------------------------------------------------------------
Address 39: Right Light (J1023) Labels: 8V0-907-399.clb
Part No SW: 8V0 907 399 D HW: 8V0 907 399 D
Component: LCM_MLBevoH08 0014
ASAM Dataset: EV_LCMRightHELLAAU736 001012
ROD: EV_LCMLeftHELLAAU736_VW37.rod
VCID: 47CB5E74CF233BF3D21-8012
No fault code found.
-------------------------------------------------------------------------------
Address 3C: Lane Change (J1086) Labels:| 5Q0-907-686.clb
Part No SW: 5Q0 907 686 C HW: 5Q0 907 686 C
Component: HRE_Master H12 0081
Serial number: 0501039365
Coding: 02011103
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_HREntryHella 001028
ROD: EV_HREntryHella_VW37.rod
VCID: 3D273C9C9DFF612378D-8068
Lane Change Assistant 2:
Subsystem 1 - Part No SW: 5Q0 907 685 C HW: 5Q0 907 685 C
Component: HRE_Slave H12 0081
Serial number: 0502086146
Coding: 020111
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:| 5QX-959-X93-42.clb
Part No SW: 5Q4 959 593 M HW: 5Q4 959 593 F
Component: TSG FS 006 0247
Serial number: 42035900200414
Coding: 003A13200000040000000000
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_DCU2DriveSideMAXHCONT 001005
ROD: EV_DCU2DriveSideMAXHKLO.rod
VCID: 4FFB76542753E3B39A1-801A
Drivers Door Rear Control Module:
Subsystem 1 - Part No SW: 5Q4 959 811 F HW: 5Q4 959 811 F Labels: 5QX-959-81X-V1.CLB
Component: Fond FHSG DRV 010 0004
Serial number: 00000000000001519385
Coding: 011000
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist (J500) Labels:| 5Q0-909-144.clb
Part No SW: 5QM 909 144 B HW: 5QM 909 144 B
Component: EPS_MQB_ZFLS 172 1081
Coding: 930A0000
Shop #: WSC 00066 790 00392
ASAM Dataset: EV_SteerAssisMQB 015157
ROD: EV_SteerAssisMQB_015.rod
VCID: 50F975283A6DFC4B83B-8004
No fault code found.
-------------------------------------------------------------------------------
Address 4B: Multifunc. Module (J745) Labels:| 3Q0-907-338-V2.clb
Part No SW: 3Q0 907 338 C HW: 3Q0 907 338 C
Component: FCM MQB Low 002 0345
Serial number: 06121800841484
Coding: 000000050900211200110F00030000000000000000000000000000000000
Shop #: WSC 00066 790 00267
ASAM Dataset: EV_MultiModulContiVW48X 002006
ROD: EV_MultiModulContiVW48X_002_VW37.rod
VCID: 353724BCA5CFB963B0D-8060
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:| 5QX-959-X92-52.clb
Part No SW: 5Q4 959 592 M HW: 5Q4 959 592 F
Component: TSG BFS 006 0247
Serial number: 46035900301114
Coding: 003A13200000040000000000
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_DCU2PasseSideMAXHCONT 001005
ROD: EV_DCU2PasseSideMAXHKLO.rod
VCID: 4EC56B502059EABB917-801A
Passengers Rear Door Control Module:
Subsystem 1 - Part No SW: 5Q4 959 812 F HW: 5Q4 959 812 F Labels: 5QX-959-81X-V1.CLB
Component: Fond FHSG PSG 010 0004
Serial number: 00000000000001502172
Coding: 091000
No fault code found.
-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794) Labels:| 5G0-035-MIB-STD2.clb
Part No SW: 3Q0 035 844 B HW: 3Q0 035 844 B
Component: MU-S-S-US 724 0890
Serial number:
Coding: 02731200BE00000041220001001808009F0508D40120050002
Shop #: WSC 00066 790 00267
ASAM Dataset: EV_MUStd4CDELP 001001
ROD: EV_MUStd4CDELP_VW37.rod
VCID: 2E050BD040998ABBF17-807A
Operating And Display Unit 1:
Subsystem 1 - Part No SW: 5G6 919 605 C HW: 5G6 919 605 C
Component: ABT_Std-2 252 8130
Serial number: VWZ6ZMW0155275
No fault code found.
-------------------------------------------------------------------------------
Address 69: Trailer (J345) Labels:| 5Q0-907-383.clb
Part No SW: 5Q0 907 383 E HW: 5Q0 907 383 B
Component: ConWysTrailer H14 0137
Serial number: 00000181563668
Coding: 020D000000000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_TrailFunctGener2Hella 001005
ROD: EV_TrailFunctGener2Hella_VW37.rod
VCID: 392F288C89D75D03545-806C
No fault code found.
-------------------------------------------------------------------------------
Address 75: Telematics (J949) Labels:| 5QE-035-285.clb
Part No SW: 5QE 035 285 A HW: 5QE 035 285 A
Component: OCULowMQBUS 009 0570
Coding: 02730202C2823A017F1E06020000
Shop #: WSC 00066 790 00267
ASAM Dataset: EV_OCULowMQB 001006
ROD: EV_OCULowMQB.rod
VCID: 43D34A64FB1B17D30E9-8016
No fault code found.
-------------------------------------------------------------------------------
Address A5: Frt Sens. Drv. Assist (R242) Labels:| 3Q0-980-65X-A5.clb
Part No SW: 3Q0 980 654 L HW: 3Q0 980 654 A
Component: MQB_B_MFK H09 0610
Serial number: 30101815P21152
Coding: 000307020002020100220054C150890084000E20012000
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_MFKBoschMQBB 002041
ROD: EV_MFKBoschMQBB_002.rod
VCID: 40D94568EA0D0CCB13B-8014
No fault code found.
-------------------------------------------------------------------------------
Address CA: Sunroof (J245) Labels:| 4M0-907-594.clb
Part No SW: 4M0 907 594 J HW: 4M0 907 594
Component: SAD_STG_1 014 0005
Coding: 00804073720C
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_SunRoofCONTIAU736 006008
ROD: EV_SunRoofCONTIAU736_006.rod
VCID: 3D273C9C9DFF612378D-8068
No fault code found.
-------------------------------------------------------------------------------
Address D6: Light Ctrl Left 2 (A31) Labels: 7PP-941-572.clb
Part No SW: 7P5 941 572 A HW: 7P5 941 572 A
Component: LED1L H06 0002
ASAM Dataset: EV_LEDMinMaxL_KEBODAVW481 001003
ROD: EV_LEDMinMaxL_KEBODAVW481.rod
VCID: 392F288C89D75D03545-806C
No fault code found.
-------------------------------------------------------------------------------
Address D7: Light Ctrl Right 2 (A27) Labels: 7PP-941-572.clb
Part No SW: 7P5 941 572 A HW: 7P5 941 572 A
Component: LED1R H06 0002
ASAM Dataset: EV_LEDMinMaxR_KEBODAVW481 001003
ROD: EV_LEDMinMaxRKEBODVW481.rod
VCID: 392F288C89D75D03545-806C
No fault code found.
End----------(Elapsed Time: 01:50, VBatt start/end: 12.2V/12.2V)-----------