I just did the 130K maintenance and noticed there were a couple engine faults. I had the 2nd exhaust fix done in 2018. Now there are faults in the DPF and EGR. Since they are shown as Intermittent, have they only occurred once? Would these be covered by the extended exhaust warranty?
Code:
Chassis Type: AU-VW37 (5Q0)
Scan: 01 03 05 08 09 15 16 17 19 2B 42 44 47 52 5F 75
VIN: 3VWFA7AU5FM505018 Mileage: 209117km-129939miles
01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: Malfunction 0010
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
2B-Steer. Col. Lock -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
47-Sound System -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
5F-Information Electr. -- Status: Malfunction 0010
75-Telematics -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CRUA) Labels:. 04L-907-309-V1.clb
Part No SW: 04L 997 022 M HW: 04L 907 309
Component: R4 2.0l TDI H23 9458
Revision: 85H23---
Coding: 01190012032410081000
Shop #: WSC 02616 444 00000
ASAM Dataset: EV_ECM20TDI01104L997022M 004002
ROD: EV_ECM20TDI01104L997022M.rod
VCID: 3A55CEE2BD706E5605-806E
5 Faults Found:
5158 - Diesel Particulate Filter; Differential Pressure Sensor
P2456 00 [096] - Intermittent
Intermittent - Not Confirmed - Tested Since Memory Clear
27014 - EGR System
P0401 00 [096] - Insufficient Flow
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 208293 km
Date: 2020.06.24
Time: 13:15:05
Engine speed: 1730.50 /min
Normed load value: 0.0 %
Vehicle speed: 46 km/h
Coolant temperature: 72 °C
Intake air temperature: 59 °C
Ambient air pressure: 980 mbar
Voltage terminal 30: 13.780 V
Unlearning counter according OBD: 10
EGR travel diagnosis: strongly increased NOx emission: -36.8 kg/h
Exhaust recirc.valve 1 bank 1: posit.feedback - Act.value: 79.63 %
EGR travel diagnosis: marginally increased NOx emission: -36.6 kg/h
Exhaust recirc.valve 2 bank 1: posit.feedback - Act.value: 0.00 %
Exh.recircul.valve 1 bank 1: pos.feedback - Act.value: 0.62 %
Pressure after throttle valve: calculated: 1082.0 hPa
O2 sens. 1 bank 1 upstrm oxi cat: raw value: 15.9998
23010 - Exhaust Gas Recirculation System
P240F 00 [096] - Response too Slow
Intermittent - Not Confirmed - Tested Since Memory Clear
9647 - Reductant Injector Valve (Bank 1)
P208E 00 [096] - Stuck Closed
Intermittent - Not Confirmed - Tested Since Memory Clear
5523 - Engine Start Blocked by Immobilizer
P1570 00 [040] - -
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 208143 km
Date: 2020.06.23
Time: 08:04:21
Engine speed: 865.00 /min
Normed load value: 0.0 %
Vehicle speed: 0 km/h
Coolant temperature: 29 °C
Intake air temperature: 30 °C
Ambient air pressure: 970 mbar
Voltage terminal 30: 11.720 V
Unlearning counter according OBD: 7
Immobilizer snapshot A-Sia Error Snap A: 1F 1F 10
Immobilizer snapshot B-Sia Error Snap B: 1A 00 00
Readiness: 0 0 0 0 0
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels: 5Q0-907-379-ESP-V1.clb
Part No SW: 3Q0 907 379 P HW: 3Q0 907 379 C
Component: ESC H32 0385
Revision: 00000000 Serial number: 50285000001030
Coding: 04FA6AA1242009710077020181CB2520562490004081A4B200630050C002
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_Brake1UDSContiMK100ESP 034033
ROD: EV_Brake1UDSContiMK100ESP_034_VW37.rod
VCID: 47B3A716FE8203BE8A-8012
1 Fault Found:
16401 - Tire Pressure Warning
C102D 00 [008] - -
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 114
Mileage: 190882 km
Date: 2019.11.08
Time: 20:15:06
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J518) Labels:| 5Q0-959-435.clb
Part No SW: 5Q0 959 435 A HW: 5Q0 959 435
Component: VWKESSYMQB 021 0604
Revision: 00021000 Serial number: 0358598584
Coding: 030C0C
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_KessyHellaMQBAB 002011
ROD: EV_KessyHellaMQBAB_002.rod
VCID: 3A55CEE2BD706E5605-806E
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301) Labels:| 5G0-907-426.clb
Part No SW: 5GM 907 426 A HW: 5GM 907 426 A
Component: AC Manuell H02 1001
Revision: 00001K01
Coding: 02020104202100000000000000000000
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_ACManueBHBVW37X 003019
ROD: EV_ACManueBHBVW37X_003.rod
VCID: 46ADAA12F9881AB671-8012
Fresh Air Blower Front:
Geber für Kältemitteldruck/Kältemitteltemperatur:
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:| 5Q0-937-08X-HV1.clb
Part No SW: 5Q0 937 087 R HW: 5Q0 937 087 R
Component: BCM PQ37BOSCH 028 0145
Revision: -------- Serial number: 86581201150987
Coding: 005108464041826969E44000001407001800000000000000000000000000
Shop #: WSC 00066 790 07031
ASAM Dataset: EV_BodyContrModul1UDSBosc 014004
ROD: EV_BCMBOSCH_014.rod
VCID: 4AB59E22ED90FED695-801E
Control Unit For Wiper Motor:
Subsystem 1 - Part No SW: 5GM 955 119 HW: 5GM 955 119 Labels: 5QX-955-119-V1.CLB
Component: WWS 140825 043 0581
Serial number: 150306075401
Coding: 0E4DDD
Rain Light Recognition Sensor:
Subsystem 2 - Part No SW: 5Q0 955 559 A HW: 5Q0 955 559 A Labels: 5Q0-955-547.CLB
Component: RLS 037 0059
Serial number: S3Y15M01D14H17M41S54
Coding: 06A8DD
Sun Roof:
Subsystem 3 - Part No SW: 5G0 959 591 A HW: 8V3 959 591 A
Component: J245 PS22.409 H02 0003
Serial number: 0000FST0000WQWI00000
Coding: 191800
Roof Blind:
Subsystem 4 - Part No SW: 5G0 959 591 A HW: 8V3 959 591 A
Component: J394 PS22.409 H02 0003
Serial number: 0000FST0000XDMW00000
Coding: 191800
4 Faults Found:
6922 - Bulb for Low Beam Headlamp Right
B1218 15 [008] - Open or Short to Plus
Intermittent - Confirmed - Tested Since Memory Clear
204290 - Remote key 1
B1479 18 [008] - Current Too Low
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 4
Fault Frequency: 1
Reset counter: 131
Mileage: 195790 km
Date: 2019.12.28
Time: 23:52:29
204546 - Remote key 2
B147A 18 [008] - Current Too Low
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 4
Fault Frequency: 1
Reset counter: 116
Mileage: 208140 km
Date: 2020.06.22
Time: 18:51:21
329480 - Heated Passenger Seat
B1806 F0 [008] - Safety Shut-Off due to Occupant Detection
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 53
Reset counter: 150
Mileage: 196538 km
Date: 2020.01.01
Time: 21:08:08
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:| 5Q0-959-655.clb
Part No SW: 5Q0 959 655 J HW: 5Q0 959 655 J
Component: AirbagVW20 009 0825
Serial number: 003GCR0152WC
Coding: 8CCCFC00000000005000001AC24800000065
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_AirbaVW20SMEVW37X 002138
ROD: EV_AirbaVW20SMEVW37X_VW37.rod
VCID: 47B3A716FE8203BE8A-8012
Occupant Detection:
Subsystem 1 - Part No SW: 4M0 959 339 B HW: 4M0 959 339 B
Component: BF-Gewichtss. H10 0021
Serial number: IBH0000J150002ETYF0-
Coding: 303135
Side Sensor Driver Front:
Subsystem 2 - Part No SW: ----------- HW: 480 002 201 15
Component: SideSensor_Df 001 0887
Serial number: 3570000000018C105313
Coding: 2D2D2D
Side Sensor Passenger Front:
Subsystem 3 - Part No SW: ----------- HW: 480 002 201 15
Component: SideSensor_Pf 001 0887
Serial number: 3580000000055769131A
Coding: 2D2D2D
Side Sensor Driver Rear:
Subsystem 4 - Part No SW: ----------- HW: 480 402 001 15
Component: SideSensor_Dr 001 6149
Serial number: 3510002AB19121A291D
Coding: 2D2D2D
Side Sensor Passenger Rear:
Subsystem 5 - Part No SW: ----------- HW: 480 402 001 15
Component: SideSensor_Pr 001 6149
Serial number: 3520002A519121A0321E
Coding: 2D2D2D
Front Sensor Driver:
Subsystem 6 - Part No SW: ----------- HW: 480 400 601 15
Component: FrontSensor_D 001 6149
Serial number: 3550002A1196FF60F0AH
Coding: 2D2D2D
Front Sensor Passenger:
Subsystem 7 - Part No SW: ----------- HW: 480 400 601 15
Component: FrontSensor_P 001 6149
Serial number: 3560002A1196FF64B08G
Coding: 2D2D2D
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel (J524) Labels:| 5Q0-953-549.clb
Part No SW: 5Q0 953 521 AT HW: 5Q0 953 569 A
Component: Lenks.Modul 075 0175
Revision: FF032032 Serial number: 20150120400279
Coding: 0400
Shop #: WSC 66564 385 16448
ASAM Dataset: EV_SMLSVALEOMQB 001015
ROD: EV_SMLSVALEOMQB.rod
VCID: 0429701A8F34E8A62F-8050
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5G0-920-XXX-17.clb-SRI3
Part No SW: 5G1 920 841 HW: 5G1 920 841
Component: KOMBI 243 4270
Coding: 03A4121221804F0502087A001000000000000000
Shop #: WSC 00066 790 00201
ASAM Dataset: EV_DashBoardVDDMQBAB 009037
ROD: EV_DashBoardVDDMQBAB_009_VW37.rod
VCID: 65EF4D9E644E31AE98-8030
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:| 5Q0-907-530-V1.clb
Part No SW: 5Q0 907 530 AB HW: 5Q0 907 530 L
Component: GW MQB Mid 211 2203
Revision: -------- Serial number: 10021510001546
Coding: 0901000800087300EF000008080F00000001050000000000000000000000
Shop #: WSC 00066 790 07026
ASAM Dataset: EV_GatewConti 011020
ROD: EV_GatewConti_011.rod
VCID: 71C729CEA086ED0EF4-8024
Alternator:
Multi Function Steering Wheel Control Module:
Subsystem 2 - Part No SW: 5G0 959 442 P HW: 5G0 959 442 P Labels: 3C8-959-537.CLB
Component: E221__MFL-DC1 H16 0101
Serial number: 29150000360880105084
Coding: 30FFFF
Power Converter DC AC:
Subsystem 3 - Part No SW: 5Q0 907 155 A HW: 5Q0 907 155 A
Component: WECHSELRICHTE H53 0041
Serial number: 0023406
No fault code found.
-------------------------------------------------------------------------------
Address 2B: Steer. Col. Lock (J764) Labels:* 5Q0-905-861.clb
Part No SW: 5Q0 905 861 A HW: 5Q0 905 861 A
Component: ELV-MQBA H01 0120
Revision: 00000000 Serial number: 15000010511001
Coding: 5500000000000000
Shop #: WSC 00066 790 07026
ASAM Dataset: EV_ELVMarquMQB 004111
ROD: EV_ELVMarquMQB.rod
VCID: 3449E0DA9F149826DF-8060
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:| 5QX-959-X93-42.clb
Part No SW: 5Q0 959 393 B HW: 5Q0 959 393 B
Component: TSG FS 020 0025
Serial number: 100215060507SK
Coding: 003013200000040000000000
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_DCUDriveSideEWMINKLO 006003
ROD: EV_DCUDriveSideEWMAXCONT.rod
VCID: 3E5DC2F2A158427639-806A
Drivers Door Rear Control Module:
Subsystem 1 - Part No SW: 5Q4 959 811 D HW: 5Q4 959 811 D Labels: 5QX-959-81X-V1.CLB
Component: Fond FHSG DRV 007 0002
Serial number: 00000000000000470975
Coding: 011000
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist (J500) Labels:| 5Q0-909-144.clb
Part No SW: 5Q0 909 144 R HW: 5Q0 909 144 R
Component: EPS_MQB_ZFLS 126 1061
Coding: 0102
Shop #: WSC 00066 790 00201
ASAM Dataset: EV_SteerAssisMQB 012140
ROD: EV_SteerAssisMQB_012_VW37.rod
VCID: 43ABB306CABA2F9E56-8016
No fault code found.
-------------------------------------------------------------------------------
Address 47: Sound System (J525) Labels:| 5G0-035-456.clb
Part No SW: 5G0 035 456 HW: 5G0 035 456
Component: MIB_lite_amp H40 0060
Serial number: VWZ8Z1EC40266Z6
Coding: 22000000AAAAAA0000
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_AMPMst12C1ALPI 001007
ROD: EV_AMPMst12C1ALPI.rod
VCID: 63EB53866A7A4F9E76-8036
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:| 5QX-959-X92-52.clb
Part No SW: 5Q0 959 392 B HW: 5Q0 959 392 B
Component: TSG BFS 020 0025
Serial number: 06021506050AH0
Coding: 003013200000040000000000
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_DCUPasseSideEWMINKLO 006003
ROD: EV_DCUPasseSideEWMAXCONT.rod
VCID: 3D5FC5FEAC5E596E20-8068
Passengers Rear Door Control Module:
Subsystem 1 - Part No SW: 5Q4 959 812 D HW: 5Q4 959 812 D Labels: 5QX-959-81X-V1.CLB
Component: Fond FHSG PSG 007 0002
Serial number: 00000000000000612906
Coding: 091000
No fault code found.
-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794) Labels:| 5G0-035-MIB-STD1.clb
Part No SW: 5G0 035 844 HW: 5G0 035 844
Component: MU-S-S-US 014 0655
Serial number: V7B02101150030
Coding: 027302000000000021220002001800001F0100340100010002
Shop #: WSC 00066 790 07026
ASAM Dataset: EV_MUStd4CPASE 002040
ROD: EV_MUStd4CPASE_VW37.rod
VCID: 64E9509A6F7448A68F-8030
Operating And Display Unit 1:
Subsystem 1 - Part No SW: 5G0 919 605 H HW: 5G0 919 605 H
Component: ABT_Std_Plus H60 0030
Serial number: VWZ8Z9PS501BNT
2 Faults Found:
1555 - Check Software Version Management
B201A 00 [009] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 1
Reset counter: 11
Mileage: 152730 km
Date: 2018.11.13
Time: 14:59:43
Voltage terminal 30: 12.4 V
0020 - Tuner for Satellite Radio
B11CF 53 [009] - Deactivated
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 4
Fault Frequency: 1
Reset counter: 11
Mileage: 152730 km
Date: 2018.11.13
Time: 14:59:44
Voltage terminal 30: 12.4 V
Satellite radio tuner status-Satellite radio antenna status: Electrical OK
Satellite radio tuner status-Channel selection for satellite radio: 0
Satellite radio tuner status-Audio Signal: Not available
Satellite radio tuner status-Antenna current: 0 mA
Satellite radio tuner status-Reception quality: Not available
Satellite radio tuner status-SDARS Flash Regional code: US_Audio_Traffic_Travellink
-------------------------------------------------------------------------------
Address 75: Telematics (J949) Labels:| 5QE-035-285.clb
Part No SW: 5QE 035 285 A HW: 5QE 035 285 A
Component: OCULowMQBUS 007 0564
Coding: 02730202C2823A017F1E06000000
Shop #: WSC 00066 790 00122
ASAM Dataset: EV_OCULowMQB 001003
ROD: EV_OCULowMQB.rod
VCID: 43ABB306CABA2F9E56-8016
No fault code found.
End-------------------------(Elapsed Time: 03:24)--------------------------