- Joined
- Feb 17, 2018
- Messages
- 24
- Reaction score
- 15
- Location
- Daytona area, FL, USA
- VCDS Serial number
- C?ID=406029
Can a 2007 R32 Climatronic unit be programmed for a 2007 EOS? OR is non-compatible? OR is it defective?
The original Clim unit in the EOS was dead, no communication, no A/C, no blower function. Replaced with a "test" unit out of same year EOS but the LCDs are roasted by sun/rain and not viewable nor show any numbers. But it DOES operate as normal otherwise--I just spin the knobs all the way to the left a few rotations and assume it is on "LO". This link will show you what it looks like: debay LINK
Picked up a Clim unit from a 2007 R32 that looked identical with the exception of "OFF" instead of "ON/OFF" and "AC" instead of "ECON". But externally they are identical. It did not have a part number sticker on it nor did the original. Plugged it into the EOS and it powered up and the LCDs, knobs and buttons worked but no air would come out the dash vents even though the fan was working variably as demanded with the knob. Checked module for codes shown below. The full scan following was AFTER I re-installed the "test" unit. The 01320 "no comm" codes cleared out after but were caused by the R32 unit. Noting the part #s, I see they are different...
So can the programming in the R32 Clim unit be modded? Or is it non-compatible? Or is it defective?
I took the original dead unit apart to see inside and if maybe I could swap the circuit board from the test unit into the pretty R32 housing but alas, the LCDs are part of the circuit boards. Face plates will swap not that I want or need to.
Thank you for your input!
The original Clim unit in the EOS was dead, no communication, no A/C, no blower function. Replaced with a "test" unit out of same year EOS but the LCDs are roasted by sun/rain and not viewable nor show any numbers. But it DOES operate as normal otherwise--I just spin the knobs all the way to the left a few rotations and assume it is on "LO". This link will show you what it looks like: debay LINK
Picked up a Clim unit from a 2007 R32 that looked identical with the exception of "OFF" instead of "ON/OFF" and "AC" instead of "ECON". But externally they are identical. It did not have a part number sticker on it nor did the original. Plugged it into the EOS and it powered up and the LCDs, knobs and buttons worked but no air would come out the dash vents even though the fan was working variably as demanded with the knob. Checked module for codes shown below. The full scan following was AFTER I re-installed the "test" unit. The 01320 "no comm" codes cleared out after but were caused by the R32 unit. Noting the part #s, I see they are different...
So can the programming in the R32 Clim unit be modded? Or is it non-compatible? Or is it defective?
I took the original dead unit apart to see inside and if maybe I could swap the circuit board from the test unit into the pretty R32 housing but alas, the LCDs are part of the circuit boards. Face plates will swap not that I want or need to.
Thank you for your input!
Code:
Saturday,11,July,2020,17:22:59:64029
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x86
VCDS Version: 20.4.1.0
Data version: 20200331 DS317.0
www.Ross-Tech.com
VIN: License Plate: EOSAC071120
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 1K0-907-044.lbl
Control Module Part Number: 1K0 907 044 BS HW: 1K0 907 044 BS
Component and/or Version: ClimatronicPQ35 120 1111
Software Coding:
Work Shop Code: WSC 00000 000 00000
VCID: 79F9DC1D30234F4E4C-802C
3 Faults Found:
01273 - Fresh Air Blower (V2)
010 - Open or Short to Plus - Intermittent
00819 - High Pressure Sensor (G65)
009 - Open or Short to Ground - Intermittent
01314 - Engine Control Module
004 - No Signal/Communication - Intermittent
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Code:
Sunday,12,July,2020,01:11:37:64029
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x86
VCDS Version: 20.4.1.0
Data version: 20200331 DS317.0
www.Ross-Tech.com
VIN: WVWAA71F37V045539 License Plate: EOS071220
Mileage: 197220km-122546mi Repair Order:
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: 1F (1K0)
Scan: 01 03 08 09 0F 15 16 17 19 1C 25 26 42 44 46 52 56 62 63 65
72
VIN: WVWAA71F37V045539 Mileage: 197220km-122546miles
01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: Malfunction 0010
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: Sporadic communication error 1000
09-Cent. Elect. -- Status: Malfunction 0010
0F-Digital Radio -- Status: Cannot be reached 1100
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
1C-Position Sensing -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
26-Auto Roof -- Status: OK 0000
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: Malfunction 0010
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: Malfunction 0010
56-Radio -- Status: Malfunction 0010
62-Door, Rear Left -- Status: OK 0000
63-Entry Assist,D -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
72-Door, Rear Right -- Status: Malfunction 0010
-------------------------------------------------------------------------------
Address 01: Engine Labels:. 06F-907-115-AXX.clb
Part No SW: 1Q0 907 115 E HW: 8P0 907 115 B
Component: 2.0l R4/4V TFSI 0020
Revision: 5BH16--- Serial number: VWX7Z0G23NG7QY
Coding: 041C010A18070160
Shop #: WSC 05073 444 60913
VCID: 2E533F41B9ED58F6A9-807A
1 Fault Found:
005425 - Camshaft Timing Adjustment
P1531 - 004 - Open Circuit - MIL ON
Freeze Frame:
Fault Status: 11100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 197223 km
Time Indication: 0
Date: 2000.00.00
Time: 07:58:08
Freeze Frame:
RPM: 1243 /min
Load: 25.1 %
Speed: 0.0 km/h
Temperature: 39.0°C
Temperature: 31.0°C
Absolute Pres.: 1010.0 mbar
Voltage: 11.811 V
Readiness: 0110 0101
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 1K0-907-379-MK60-F.lbl
Part No SW: 1K0 907 379 AC HW: 1K0 907 379 AC
Component: ESP FRONT MK60 0101
Revision: 00H11001
Coding: 0021218
Shop #: WSC 00020 000 00000
VCID: 73E5EE35124F351E06-8026
1 Fault Found:
00493 - ESP-Sensor Unit (G419)
014 - Defective
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 1K0-907-044.lbl
Part No SW: 1Q0 907 044 A HW: 1Q0 907 044 A
Component: ClimatronicPQ35 093 0101
Revision: 00093002 Serial number: 00000000000000
Shop #: WSC 00000 000 00000
VCID: 2B5536558AFF2DDE8E-807E
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels:. 3C0-937-049-23-H.lbl
Part No SW: 3C0 937 049 AE HW: 3C0 937 049 AE
Component: Bordnetz-SG H52 2002
Revision: 00H52000 Serial number: 00000006783821
Coding: 058C8F0340041500470000000F00000000285D035C0001
Shop #: WSC 00020 000 00000
VCID: 6CD7F5494F71EAE6C7-8038
Subsystem 1 - Part No: 1K1 955 119 E Labels: 1KX-955-119.CLB
Component: Wischer 270307 020 0501
Coding: 00038805
Shop #: WSC 00020
4 Faults Found:
00061 - Footwell Lights
012 - Electrical Fault in Circuit
Freeze Frame:
Fault Status: 01101100
Fault Priority: 5
Fault Frequency: 1
Reset counter: 82
Mileage: 197223 km
Time Indication: 0
Date: 2005.09.13
Time: 31:63:63
Freeze Frame:
ON
Voltage: 13.75 V
ON
ON
OFF
OFF
OFF
00156 - Control Circuit for Windshield Washer Pump
009 - Open or Short to Ground
Freeze Frame:
Fault Status: 01101001
Fault Priority: 3
Fault Frequency: 1
Reset counter: 82
Mileage: 197223 km
Time Indication: 0
Date: 2005.09.13
Time: 31:63:63
Freeze Frame:
ON
Voltage: 13.75 V
ON
ON
OFF
OFF
OFF
02398 - Control Circuit for Rear Windshield Washer Pump
009 - Open or Short to Ground
Freeze Frame:
Fault Status: 01101001
Fault Priority: 3
Fault Frequency: 1
Reset counter: 82
Mileage: 197223 km
Time Indication: 0
Date: 2005.09.13
Time: 31:63:63
Freeze Frame:
ON
Voltage: 13.75 V
ON
ON
OFF
OFF
OFF
01320 - Control Module for Climatronic (J255)
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 5
Reset counter: 122
Mileage: 197223 km
Time Indication: 0
Date: 2005.09.13
Time: 31:63:63
Freeze Frame:
OFF
Voltage: 12.75 V
ON
ON
OFF
OFF
OFF
-------------------------------------------------------------------------------
Address 0F: Digital Radio
Cannot be reached
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 1Q0-959-655.lbl
Part No SW: 1Q0 959 655 A HW: 1Q0 959 655 A
Component: 74 Airbag VW8C 0180
Revision: 92009018 Serial number: 003B3001R4W
Coding: 0014132
Shop #: WSC 00020 000 00000
VCID: 3A7B031175A5845605-806E
Subsystem 1 - Serial number: 6332SRB404DD4D2FJ
Subsystem 2 - Serial number: 6342SRB404DA4FADP
Subsystem 3 - Serial number: 6372URB40203B8993
Subsystem 4 - Serial number: 6382URB40203B8C53
4 Faults Found:
02511 - Control Module for Seat Occupied Recognition (J706)
004 - No Signal/Communication - MIL ON
Freeze Frame:
Fault Status: 11100100
Fault Priority: 1
Fault Frequency: 12
Reset counter: 255
Mileage: 197223 km
Time Indication: 0
Date: 2000.00.00
Time: 11:07:58
02756 - Redundant signal path of Airbag cut-off switch - front passenger side (E224)
010 - Open or Short to Plus - MIL ON
Freeze Frame:
Fault Status: 11101010
Fault Priority: 1
Fault Frequency: 1
Reset counter: 255
Mileage: 197223 km
Time Indication: 0
Date: 2000.00.00
Time: 11:08:00
00592 - Seat Belt Switch; Passenger (E25)
010 - Open or Short to Plus - MIL ON
Freeze Frame:
Fault Status: 11101010
Fault Priority: 1
Fault Frequency: 1
Reset counter: 255
Mileage: 197223 km
Time Indication: 0
Date: 2000.00.00
Time: 11:08:00
01218 - Side Airbag Igniter; Passenger Side (N200)
001 - Upper Limit Exceeded - MIL ON
Freeze Frame:
Fault Status: 11100001
Fault Priority: 1
Fault Frequency: 1
Reset counter: 255
Mileage: 197223 km
Time Indication: 0
Date: 2000.00.00
Time: 11:08:00
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY8.lbl
Part No SW: 1K0 953 549 AP HW: 1K0 953 549 AP
Component: Lenksäulenmodul 036 0070
Coding: 0000041
Shop #: WSC 00020 000 00000
VCID: 000FB1F953F91E860B-8054
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 1K0-920-xxx-17.lbl
Part No SW: 1Q0 920 973 B HW: 1Q0 920 973 B
Component: KOMBIINSTRUMENT VDD 1610
Revision: V0003000 Serial number: VWX7Z0G23NG7QY
Coding: 0023207
Shop #: WSC 00020 000 00000
VCID: 326B2B31ADD57C16CD-8066
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels:. 1K0-907-530-V2.clb
Part No SW: 1K0 907 530 K HW: 1K0 907 951
Component: J533__Gateway H12 0170
Revision: H12 Serial number: 33001073080C13
Coding: 3DBF23600F025000
Shop #: WSC 00020 999 00000
VCID: 2F6D2245BEE751FEA2-807A
2 Faults Found:
02649 - Digital Radio Tuner
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 81
Mileage: 197223 km
Time Indication: 0
Date: 2000.00.00
Time: 11:08:03
01320 - Control Module for Climatronic (J255)
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 122
Mileage: 197223 km
Time Indication: 0
Date: 2000.00.00
Time: 06:56:45
-------------------------------------------------------------------------------
Address 1C: Position Sensing Labels: 1Kx-919-xxx-1C.lbl
Part No SW: 1Q0 919 965 HW: 1Q0 919 965
Component: Kompass 002 0001
Revision: 00002000 Serial number: 1350208TK85W02
Shop #: WSC 00020 000 00000
VCID: 79F9DC1D30234F4E4C-802C
No fault code found.
-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 1K0-920-xxx-25.clb
Part No SW: 1Q0 920 973 B HW: 1Q0 920 973 B
Component: IMMO VDD 1610
Revision: V0003000 Serial number: VWX7Z0G23NG7QY
Shop #: WSC 00000 000 00000
VCID: 326B2B31ADD57C16CD-8066
No fault code found.
-------------------------------------------------------------------------------
Address 26: Auto Roof Labels: 1Q0-959-255.clb
Part No SW: 1Q0 959 255 G HW: 1Q0 959 255 G
Component: Verdecksteuergeraet 0860
Revision: 0033100R Serial number: 141210099
Coding: 0655360
Shop #: WSC 55552 001 1048576
VCID: 3C7705097F91BA6617-8068
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels:. 1K0-959-701-MIN3.clb
Part No SW: 1Q0 959 701 D HW: 1Q0 959 701 D
Component: Tuer-SG 006 1209
Coding: 0001207
Shop #: WSC 00020 000 00000
VCID: 3561102D5CBB6B2EE8-8060
2 Faults Found:
01811 - Supply Voltage for Door Controller; Drivers Side (J386)
001 - Upper Limit Exceeded - Intermittent
00131 - Outside Door Handle Illumination/mirror Light Driver Side
012 - Electrical Fault in Circuit - Intermittent
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1Kx-909-144-G2V3.clb
Part No: 1K1 909 144 L
Component: EPS_ZFLS Kl.070 H07 1806
Shop #: WSC 00020 000 00000
VCID: 34672D2957C17226DF-8060
1 Fault Found:
00778 - Steering Angle Sensor (G85)
000 - -
-------------------------------------------------------------------------------
Address 46: Central Conv. Labels:. 1K0-959-433-MAX.clb
Part No SW: 1K0 959 433 CT HW: 1K0 959 433 CT
Component: KSG PQ35 RDK 052 0221
Revision: 00052000 Serial number: 00000000000000
Coding: 13900F880186281B0904058FB0880F0488DCA0
Shop #: WSC 00066 000 00000
VCID: 0407BDE947E102A62F-8050
Subsystem 1 - Component: Sounder n.mounted
Subsystem 2 - Component: NGS n.mounted
Subsystem 3 - Component: IRUE n.mounted
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels:. 1K0-959-702-MAX3.clb
Part No SW: 1Q0 959 702 E HW: 1Q0 959 702 E
Component: Tuer-SG 006 1215
Coding: 0001206
Shop #: WSC 00020 790 00000
VCID: 377D1A2546B7993EFA-8062
1 Fault Found:
00132 - Outside Door Handle Illumination/mirror Light Passenger Side
012 - Electrical Fault in Circuit - Intermittent
-------------------------------------------------------------------------------
Address 56: Radio Labels: 1K0-035-1xx-56.lbl
Part No SW: 1K0 035 180 G HW: 1K0 035 180 G
Component: Radio PM6 017 0023
Revision: 00017000 Serial number: VWZ5Z7G2141368
Coding: 0040401
Shop #: WSC 00020 000 00000
VCID: 2447DD69E721E2A64F-8070
1 Fault Found:
02218 - Satellite Radio (R146)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01110100
Fault Priority: 3
Fault Frequency: 1
Reset counter: 81
Mileage: 197223 km
Time Indication: 0
Date: 2000.00.00
Time: 11:08:05
-------------------------------------------------------------------------------
Address 62: Door, Rear Left Labels:. 1K0-959-703-GEN3.clb
Part No SW: 1Q0 959 703 A HW: 1Q0 959 703 A
Component: Tuer-SG 006 1203
Coding: 0000128
Shop #: WSC 00020 000 1012544
VCID: 34672D2957C17226DF-8060
No fault code found.
-------------------------------------------------------------------------------
Address 63: Entry Assist,D Labels: 1Q0-959-790.lbl
Part No SW: 1Q0 959 790 A HW: 1Q0 959 790 A
Component: J572 EASYENTRY FS 0603
Revision: 00H02000 Serial number: 5DS008646-01--
Coding: 0000002
Shop #: WSC 00020 000 00000
VCID: 3A7B031175A5845605-806E
No fault code found.
-------------------------------------------------------------------------------
Address 65: Tire Pressure Labels: 3C0-959-433-65.lbl
Part No SW: 1K0 959 433 CT HW: 1K0 959 433 CT
Component: RDK 0450
Revision: 00052000 Serial number: 00000000000000
Coding: 0100101
Shop #: WSC 00066 000 00000
VCID: 0407BDE947E102A62F-8050
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right Labels:. 1K0-959-704-GEN3.clb
Part No SW: 1Q0 959 704 A HW: 1Q0 959 704 A
Component: Tuer-SG 006 1203
Coding: 0000128
Shop #: WSC 00020 790 1012544
VCID: 3561102D5CBB6B2EE8-8060
1 Fault Found:
01334 - Door Control Module; Rear Right (J389)
014 - Defective
End-------------------------(Elapsed Time: 02:06)--------------------------