Hallo guys, I would like to ask if someone can help me out.
Im building 2010 Audi tts into a full race car, im keeping the original computers, I did removed a lot of th computers out( radio, navigation etc) coded is out of gateway and other computers looking for them, vehicle has no lights, no wiring in doors, roof, decklid etc
I did have to keep the airbag module in car for the traction control system to work and to be able to use launch control. module has only power, ground and can bus hooked to it.
The issue im having is regarding the paddle shifters under the steering wheel.
Steering module is seeing when im pressing it but if you go to dsg I do not see it being activated( of course it doesn't work when driving in any mode)
It was working before I started pulling wires out of the car.
I removed out of the car the connectors and wires from fuse box to it etc,
I did check continuity in comfort can bus, all is good same for powertrain can bus, information can bus is completely removed and coded out (since all the modules are removed out of car)
I keep only computers needed to run car.
to try to repair it:
I grab steering wheel from friends car (its working on his) and plug it in but same steering wheel module see it transmission module not
tried to put original coding in all computers and original software in engine and transmission and still didn't work
I replaced steering wheel control module and same result
Here is the scan
Im building 2010 Audi tts into a full race car, im keeping the original computers, I did removed a lot of th computers out( radio, navigation etc) coded is out of gateway and other computers looking for them, vehicle has no lights, no wiring in doors, roof, decklid etc
I did have to keep the airbag module in car for the traction control system to work and to be able to use launch control. module has only power, ground and can bus hooked to it.
The issue im having is regarding the paddle shifters under the steering wheel.
Steering module is seeing when im pressing it but if you go to dsg I do not see it being activated( of course it doesn't work when driving in any mode)
It was working before I started pulling wires out of the car.
I removed out of the car the connectors and wires from fuse box to it etc,
I did check continuity in comfort can bus, all is good same for powertrain can bus, information can bus is completely removed and coded out (since all the modules are removed out of car)
I keep only computers needed to run car.
to try to repair it:
I grab steering wheel from friends car (its working on his) and plug it in but same steering wheel module see it transmission module not
tried to put original coding in all computers and original software in engine and transmission and still didn't work
I replaced steering wheel control module and same result
Here is the scan
Code:
Sunday,14,June,2020,14:09:00:52297
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 20.4.1.0 (x64)
Data version: 20200331 DS317.0
www.Ross-Tech.com
Chassis Type: FK (1K0)
Scan: 01 02 03 09 15 16 17 19 22 25 44 46
VIN: TRUK1AFK8A1020521 Mileage: 75050km-46633miles
01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
22-AWD -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (CDM) Labels:. 06F-907-115-CDL.clb
Part No SW: 8J0 907 115 AF HW: 8P0 907 115 B
Component: 2.0l R4/4V TFSI 0010
Revision: 5BH19--- Serial number: AUX7Z0J2FNS030
Coding: 0113010A1C0B0160
Shop #: WSC 66565 257 00032
VCID: 70E437FE636F5A06FB-8024
No fault code found.
Readiness: 0110 0000
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 02E-927-770.clb
Part No SW: 02E 300 012 N HW: 02E 927 770 AM
Component: GSG DSG AG6 531 2117
Revision: 53104 Serial number: 00001411040135
Coding: 0001020
Shop #: WSC 01286 386 08256
VCID: 1B3E3052DA69895EFE-804E
No fault code found.
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 8J0-614-517.clb
Part No SW: 8J0 614 517 D HW: 8J0 614 517 D
Component: ESP MK60E1 0030
Revision: 00H60001
Coding: 0593718
Shop #: WSC 01236 785 00200
VCID: 2E58E986B9DB0CF6A9-807A
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 8P0-907-063.clb
Part No SW: 8P0 907 063 E HW: 8P0 907 063 E
Component: BCM PQ35 H 105 0575
Revision: 00105 AK
Coding: 00000000000002042024C0200000000D100077AA000050395C0000400000
Shop #: WSC 01236 758 00200
VCID: 3668C1E6818B3436E1-8062
Subsystem 1 - Part No SW: 8J1 955 119 A HW: 8J1 955 119 Labels: 1KX-955-119.CLB
Component: Wischer AU354 H07 0070
Coding: 00FD10
21 Faults Found:
01134 - Alarm Horn (H12)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 4
Fault Frequency: 1
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:02:28
Freeze Frame:
Term 15 On
Voltage: 11.75 V
ON
ON
Term 50 Off
OFF
OFF
01800 - Light Switch (E1)
008 - Implausible Signal
Freeze Frame:
Fault Status: 01101000
Fault Priority: 3
Fault Frequency: 1
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:02:28
Freeze Frame:
Term 15 On
Voltage: 11.75 V
ON
ON
Term 50 Off
OFF
OFF
02195 - Dimmer Switch Instrument Panel & Switch Lighting (E20)
002 - Lower Limit Exceeded
Freeze Frame:
Fault Status: 01100010
Fault Priority: 5
Fault Frequency: 1
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:02:28
Freeze Frame:
Term 15 On
Voltage: 11.75 V
ON
ON
Term 50 Off
OFF
OFF
03266 - Control Circuit for Signal Horn
009 - Open or Short to Ground
Freeze Frame:
Fault Status: 01101001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:02:28
Freeze Frame:
Term 15 On
Voltage: 11.80 V
ON
ON
Term 50 Off
OFF
OFF
00978 - Lamp for Low Beam; Left (M29)
010 - Open or Short to Plus
Freeze Frame:
Fault Status: 01101010
Fault Priority: 1
Fault Frequency: 10
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:02:29
Freeze Frame:
Term 15 On
Voltage: 11.75 V
ON
ON
Term 50 Off
OFF
OFF
00979 - Lamp for Low Beam; Right (M31)
010 - Open or Short to Plus
Freeze Frame:
Fault Status: 01101010
Fault Priority: 1
Fault Frequency: 10
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:02:29
Freeze Frame:
Term 15 On
Voltage: 11.75 V
ON
ON
Term 50 Off
OFF
OFF
01504 - Bulb for License-Plate Light (X)
010 - Open or Short to Plus
Freeze Frame:
Fault Status: 01101010
Fault Priority: 2
Fault Frequency: 12
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:02:29
Freeze Frame:
Term 15 On
Voltage: 11.75 V
ON
ON
Term 50 Off
OFF
OFF
02895 - Supply Voltage for LED Module for DRL and Parking Light; Left
010 - Open or Short to Plus
Freeze Frame:
Fault Status: 01101010
Fault Priority: 1
Fault Frequency: 12
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:02:29
Freeze Frame:
Term 15 On
Voltage: 11.75 V
ON
ON
Term 50 Off
OFF
OFF
02897 - Supply Voltage for LED Module for DRL and Parking Light; Right
010 - Open or Short to Plus
Freeze Frame:
Fault Status: 01101010
Fault Priority: 1
Fault Frequency: 12
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:02:29
Freeze Frame:
Term 15 On
Voltage: 11.75 V
ON
ON
Term 50 Off
OFF
OFF
01520 - Rain and Light Recognition Sensor (G397)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 6
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:12:32
Freeze Frame:
Term 15 On
Voltage: 11.75 V
ON
ON
Term 50 Off
OFF
OFF
00834 - Signal for Activation of Heated Rear Window
009 - Open or Short to Ground
Freeze Frame:
Fault Status: 01101001
Fault Priority: 5
Fault Frequency: 1
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:12:34
Freeze Frame:
Term 15 On
Voltage: 11.75 V
ON
ON
Term 50 Off
OFF
OFF
00924 - Relay for Headlamp Cleaning System (J39)
009 - Open or Short to Ground
Freeze Frame:
Fault Status: 01101001
Fault Priority: 4
Fault Frequency: 1
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:12:34
Freeze Frame:
Term 15 On
Voltage: 11.75 V
ON
ON
Term 50 Off
OFF
OFF
01259 - Fuel Pump Relay (J17)
009 - Open or Short to Ground
Freeze Frame:
Fault Status: 01101001
Fault Priority: 5
Fault Frequency: 1
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:12:34
Freeze Frame:
Term 15 On
Voltage: 11.75 V
ON
ON
Term 50 Off
OFF
OFF
01403 - Glass-Break Sensors; Rear
011 - Open Circuit
Freeze Frame:
Fault Status: 01101011
Fault Priority: 5
Fault Frequency: 1
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:12:52
Freeze Frame:
Term 15 On
Voltage: 11.70 V
ON
ON
Term 50 Off
OFF
OFF
01496 - Bulb for Fog-Lamps; Left (L22)
010 - Open or Short to Plus
Freeze Frame:
Fault Status: 01101010
Fault Priority: 4
Fault Frequency: 8
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:13:51
Freeze Frame:
Term 15 On
Voltage: 11.70 V
ON
ON
Term 50 Off
OFF
OFF
01500 - Bulb for Fog-Lamps; Right (L23)
010 - Open or Short to Plus
Freeze Frame:
Fault Status: 01101010
Fault Priority: 4
Fault Frequency: 8
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:13:51
Freeze Frame:
Term 15 On
Voltage: 11.70 V
ON
ON
Term 50 Off
OFF
OFF
03134 - Motor for Rear Spoiler Movememt (V54)
012 - Electrical Fault in Circuit
Freeze Frame:
Fault Status: 01101100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:14:27
Freeze Frame:
Term 15 Off
Voltage: 11.80 V
OFF
ON
Term 50 Off
OFF
OFF
03132 - Limit Switch for Rear Spoiler Movement (F135/F136)
008 - Implausible Signal
Freeze Frame:
Fault Status: 01101000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:14:28
Freeze Frame:
Term 15 Off
Voltage: 11.85 V
OFF
ON
Term 50 Off
OFF
OFF
01503 - Bulb for 3rd Brake Light (M25)
010 - Open or Short to Plus - Intermittent
Freeze Frame:
Fault Status: 00101010
Fault Priority: 1
Fault Frequency: 5
Reset counter: 240
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:41:28
Freeze Frame:
Term 15 On
Voltage: 13.75 V
ON
ON
Term 50 Off
OFF
ON
01495 - Bulb for High-Beams; Left (M30)
010 - Open or Short to Plus
Freeze Frame:
Fault Status: 01101010
Fault Priority: 3
Fault Frequency: 3
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 22:17:45
Freeze Frame:
Term 15 On
Voltage: 13.95 V
ON
ON
Term 50 Off
OFF
OFF
01499 - Bulb for High-Beams; Right (M32)
010 - Open or Short to Plus
Freeze Frame:
Fault Status: 01101010
Fault Priority: 3
Fault Frequency: 3
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 22:17:46
Freeze Frame:
Term 15 On
Voltage: 13.95 V
ON
ON
Term 50 Off
OFF
OFF
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 8J0-959-655.lbl
Part No SW: 8J0 959 655 HW: 8J0 959 655
Component: -E Airbag 9.43 H03 0020
Revision: 93H03002 Serial number: 0036K004BC5I
Coding: 0011589
Shop #: WSC 01236 785 00200
VCID: 79F20ADA30151B4E4C-802C
Subsystem 1 - Part No: 000 000 000 00
Component: BF-Gewichtsens. 000 0000
Subsystem 2 - Serial number: 04CUG
Subsystem 3 - Serial number: 0001.01.000000000000000000ÿ
Subsystem 4 - Serial number: 000000ÿ
20 Faults Found:
02756 - Redundant signal path of Airbag cut-off switch - front passenger side (E224)
010 - Open or Short to Plus - MIL ON
Freeze Frame:
Fault Status: 11101010
Fault Priority: 1
Fault Frequency: 1
Reset counter: 255
Mileage: 75017 km
Time Indication: 0
Date: 2020.01.09
Time: 21:23:58
01218 - Side Airbag Igniter; Passenger Side (N200)
001 - Upper Limit Exceeded - MIL ON
Freeze Frame:
Fault Status: 11100001
Fault Priority: 1
Fault Frequency: 1
Reset counter: 255
Mileage: 75017 km
Time Indication: 0
Date: 2020.01.09
Time: 21:24:00
00592 - Seat Belt Switch; Passenger (E25)
010 - Open or Short to Plus - MIL ON
Freeze Frame:
Fault Status: 11101010
Fault Priority: 2
Fault Frequency: 1
Reset counter: 194
Mileage: 75017 km
Time Indication: 0
Date: 2020.01.09
Time: 21:24:00
02511 - Control Module for Seat Occupied Recognition (J706)
004 - No Signal/Communication - MIL ON
Freeze Frame:
Fault Status: 11100100
Fault Priority: 1
Fault Frequency: 34
Reset counter: 255
Mileage: 75017 km
Time Indication: 0
Date: 2020.01.09
Time: 21:24:06
01217 - Side Airbag Igniter; Driver Side (N199)
001 - Upper Limit Exceeded - MIL ON
Freeze Frame:
Fault Status: 11100001
Fault Priority: 1
Fault Frequency: 1
Reset counter: 255
Mileage: 75017 km
Time Indication: 0
Date: 2020.01.13
Time: 19:49:08
00590 - Igniter 2 for Passenger Airbag (N132)
001 - Upper Limit Exceeded - MIL ON
Freeze Frame:
Fault Status: 11100001
Fault Priority: 1
Fault Frequency: 1
Reset counter: 255
Mileage: 75018 km
Time Indication: 0
Date: 2020.01.15
Time: 00:00:12
01742 - Igniter for Knee Airbag; Drivers Side (N295)
001 - Upper Limit Exceeded - MIL ON
Freeze Frame:
Fault Status: 11100001
Fault Priority: 1
Fault Frequency: 1
Reset counter: 255
Mileage: 75018 km
Time Indication: 0
Date: 2020.01.15
Time: 00:00:12
01743 - Igniter for Knee Airbag; Pass. Side (N296)
001 - Upper Limit Exceeded - MIL ON
Freeze Frame:
Fault Status: 11100001
Fault Priority: 1
Fault Frequency: 1
Reset counter: 255
Mileage: 75018 km
Time Indication: 0
Date: 2020.01.15
Time: 00:00:12
01739 - Crash Sensor for Front Airbag; Pass. Side (G284)
011 - Open Circuit - MIL ON
Freeze Frame:
Fault Status: 11101011
Fault Priority: 2
Fault Frequency: 1
Reset counter: 194
Time Indication: 0
00591 - Seat Belt Switch; Driver (E24)
010 - Open or Short to Plus - MIL ON
Freeze Frame:
Fault Status: 11101010
Fault Priority: 2
Fault Frequency: 1
Reset counter: 194
Mileage: 0 km
Time Indication: 0
00655 - Seat Belt Tensioner Igniter; Passenger Side (N154)
001 - Upper Limit Exceeded - MIL ON
Freeze Frame:
Fault Status: 11100001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 194
Mileage: 0 km
Time Indication: 0
01590 - Igniter for Battery Disconnect (N253)
001 - Upper Limit Exceeded - MIL ON
Freeze Frame:
Fault Status: 11100001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:00:33
01587 - Igniter 2 for Airbag; Drivers Side (N250)
001 - Upper Limit Exceeded - MIL ON
Freeze Frame:
Fault Status: 11100001
Fault Priority: 1
Fault Frequency: 1
Reset counter: 255
Mileage: 75018 km
Time Indication: 0
Date: 2020.01.15
Time: 00:00:12
03084 - Ignitor for Front Passenger's Belt Force Limiter (G552)
001 - Upper Limit Exceeded - MIL ON
Freeze Frame:
Fault Status: 11100001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 200
Mileage: 75056 km
Time Indication: 0
Date: 2020.05.06
Time: 00:00:29
01738 - Crash Sensor for Front Airbag; Drivers Side (G283)
011 - Open Circuit - MIL ON
Freeze Frame:
Fault Status: 11101011
Fault Priority: 2
Fault Frequency: 1
Reset counter: 194
Time Indication: 0
01221 - Crash Sensor Side Airbag; Driver Side (G179)
011 - Open Circuit - MIL ON
Freeze Frame:
Fault Status: 11101011
Fault Priority: 2
Fault Frequency: 1
Reset counter: 194
Time Indication: 0
01222 - Crash Sensor Side Airbag; Passenger Side (G180)
011 - Open Circuit - MIL ON
Freeze Frame:
Fault Status: 11101011
Fault Priority: 2
Fault Frequency: 1
Reset counter: 194
Time Indication: 0
01578 - Airbag Deactivation Warning Lamp; Passenger Side (K145)
009 - Open or Short to Ground - MIL ON
Freeze Frame:
Fault Status: 11101001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 255
Mileage: 75018 km
Time Indication: 0
Date: 2020.01.15
Time: 00:00:10
00588 - Airbag Igniter; Driver Side (N95)
001 - Upper Limit Exceeded - MIL ON
Freeze Frame:
Fault Status: 11100001
Fault Priority: 1
Fault Frequency: 1
Reset counter: 255
Mileage: 75018 km
Time Indication: 0
Date: 2020.01.15
Time: 00:00:11
00589 - Airbag Igniter 1; Passenger Side (N131)
001 - Upper Limit Exceeded - MIL ON
Freeze Frame:
Fault Status: 11100001
Fault Priority: 1
Fault Frequency: 1
Reset counter: 255
Mileage: 75018 km
Time Indication: 0
Date: 2020.01.15
Time: 00:00:12
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 8P0-953-549.lbl
Part No SW: 8P0 953 549 K HW: 8P0 953 549 K
Component: J0527 H38 0070
Coding: 0011141
Shop #: WSC 01236 785 00200
VCID: 4688B126316BA4B671-8012
Subsystem 1 - Part No: XXXXXXXXXXX
Component: E0221 H06 0030
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 8J0-920-xxx-17-MY8.clb
Part No SW: 8J0 920 990 J HW: 8J0 920 990 J
Component: KOMBIINSTR. VDO H03 0490
Revision: D0H03005 Serial number: 2242J005000348
Coding: 0003203
Shop #: WSC 32144 003 104857
VCID: 3972CADA7095DB4E0C-806C
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels:. 1K0-907-530-V4.clb
Part No SW: 1K0 907 530 AD HW: 1K0 907 951
Component: J533 Gateway H16 0233
Revision: H16 Serial number: 4540K103208117
Coding: ED820702000002004100
Shop #: WSC 01236 785 00200
VCID: 69D25A9A40B5ABCEBC-803C
No fault code found.
-------------------------------------------------------------------------------
Address 22: AWD Labels: 0AY-907-554-V1.clb
Part No SW: 0BR 907 554 C HW: 0BR 907 554 C
Component: Haldex 4Motion T303
Coding: 0000005
Shop #: WSC 00001 000 00000
VCID: 458AB62A0C6DAFAE78-8010
No fault code found.
-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 1K0-920-xxx-25.clb
Part No SW: 8J0 920 990 J HW: 8J0 920 990 J
Component: KOMBIINSTR. VDO H03 0490
Revision: D0H03005 Serial number: AUX7Z0J2FNS030
Shop #: WSC 00000 000 00000
VCID: 3972CADA7095DB4E0C-806C
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1K0-909-14x-GEN3.clb
Part No: 8J0 909 144 J
Component: EPS_ZFLS Kl. 237 3001
Revision: 00H17000
Shop #: WSC 01236 785 00200
VCID: 3776CCE24681CD3EFA-8062
No fault code found.
End-------------------------(Elapsed Time: 01:22)--------------------------