Apologies for all of the text, however, I feel it is important.
2009 A4 6MT Quattro Sport Package (CAEB motor) – I am the original owner.
Nov ’19 – flashed IE Stage I – Tons of fun and no issues.
Feb ’20
---Installed cat-back exhaust
---Severe hesitation under load appeared.
-------Replaced spark plugs gapped to .028 (3.0T) and Coils (red top if that matters)
-------------Hesitation almost gone.
Called a local Audi performance shop and they walked me through some VCDS checks.
Fuel Pump was at 54.6% load at idle
Timing chain tensioner was a -3.2°
They suggested that I replace the fuel filter, maybe the pump, and that I get my timing chain service performed.
March ‘20
---Replaced my fuel pump and filter at the same time – 47% load at idle now.
---Clutch (w/30k mi) sticking under high RPMs – fast shifting.
------Bled the line, a little better but still sticking
April ‘20
-------Replaced Slave/Master/Braided Line
------------Still sticking – probably air in the line.
May ’20
---Timing chain service completed (by the previously mentioned shop)
---Shop bled the clutch also, there was air in the line.
---Car is in limp mode
---Cylinder 1 Bank A VVT solenoid intermittent issues (Connector was broken in the solenoid Been for a long time apparently)
---I melted the MAF connector on the exhaust when I unplugged it to test if it would fix the limp mode.
---Decided that it was easier to purchase the repair cables and connectors from Audi instead of hunting the web and trying to find them. On my way to get them, yes I am an idiot and I drove my car it died with the error of “Ignition Lock Defective”
I cleaned my key and even tried the wallet key. Nothing. Everything is normal with the car except it will not start.
I purchased a new lock, same issue.
Google a ton and people say it is the Master Cylinder clutch switch.
---Tried to do the Slave Ball Bearing fix, however, my slave already has one at the end of the rod and there is no place to put it without compromising the stability of the rod. Finally decide to try and short the Blue/gray tracer to ground. So…I cut the wire and grounded it.
------Ignition Lock defective error is now gone, however, the car still did not start.
---------Also, the key will no longer eject. I remove the ground and the error comes back and the key releases.
So I am here to ask for your help as I am out of ideas.
I have a bunch of scans, however, I think this one is the best one. Please ignore the Wiper errors as the motor is still out of the car as I removed everything to get to the master cylinder to reseat the connector.
Thank you all for your help.
2009 A4 6MT Quattro Sport Package (CAEB motor) – I am the original owner.
Nov ’19 – flashed IE Stage I – Tons of fun and no issues.
Feb ’20
---Installed cat-back exhaust
---Severe hesitation under load appeared.
-------Replaced spark plugs gapped to .028 (3.0T) and Coils (red top if that matters)
-------------Hesitation almost gone.
Called a local Audi performance shop and they walked me through some VCDS checks.
Fuel Pump was at 54.6% load at idle
Timing chain tensioner was a -3.2°
They suggested that I replace the fuel filter, maybe the pump, and that I get my timing chain service performed.
March ‘20
---Replaced my fuel pump and filter at the same time – 47% load at idle now.
---Clutch (w/30k mi) sticking under high RPMs – fast shifting.
------Bled the line, a little better but still sticking
April ‘20
-------Replaced Slave/Master/Braided Line
------------Still sticking – probably air in the line.
May ’20
---Timing chain service completed (by the previously mentioned shop)
---Shop bled the clutch also, there was air in the line.
---Car is in limp mode
---Cylinder 1 Bank A VVT solenoid intermittent issues (Connector was broken in the solenoid Been for a long time apparently)
---I melted the MAF connector on the exhaust when I unplugged it to test if it would fix the limp mode.
---Decided that it was easier to purchase the repair cables and connectors from Audi instead of hunting the web and trying to find them. On my way to get them, yes I am an idiot and I drove my car it died with the error of “Ignition Lock Defective”
I cleaned my key and even tried the wallet key. Nothing. Everything is normal with the car except it will not start.
I purchased a new lock, same issue.
Google a ton and people say it is the Master Cylinder clutch switch.
---Tried to do the Slave Ball Bearing fix, however, my slave already has one at the end of the rod and there is no place to put it without compromising the stability of the rod. Finally decide to try and short the Blue/gray tracer to ground. So…I cut the wire and grounded it.
------Ignition Lock defective error is now gone, however, the car still did not start.
---------Also, the key will no longer eject. I remove the ground and the error comes back and the key releases.
So I am here to ask for your help as I am out of ideas.
I have a bunch of scans, however, I think this one is the best one. Please ignore the Wiper errors as the motor is still out of the car as I removed everything to get to the master cylinder to reseat the connector.
Thank you all for your help.
Code:
Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: Release 20.4.1(x64) Data version: 20200331 DS317.0 www.Ross-Tech.com
Friday,29,May,2020,08:36:00:60290
VIN: WAUSF78KX9N067014 Mileage: 220980km-137310mi
Chassis Type: 8K-AU48 (8T0)
Scan: 01 03 05 08 09 15 16 17 19 2E 36 42 46 47 52 53 55 56 62 72
77
VIN: WAUSF78KX9N067014 Mileage: 220980km-137310miles
01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: Malfunction 0010
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
2E-Media Player 3 -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: Malfunction 0010
47-Sound System -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: Malfunction 0010
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: Malfunction 0010
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (DL0MA-CAEB) Labels:| 06H-907-115-CAB.clb
Part No SW: 8K2 907 115 AL HW: 8K2 907 115 D Component: 2.0l R4/4V TF H14 0003
Revision: E1H14---
Coding: 0104010A180F0160
Shop #: WSC 82976 802 690857
ASAM Dataset: EV_ECM20TFS0118K2907115AL 001003
ROD: EV_ECM20TFS0118K2907115AL.rod
VCID: 79F9CAB4F832D04E4C-802C
No fault code found. Readiness: 1110 0101
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels:. 8K0-907-379-V1.clb Part No SW: 8K0 907 379 AF HW: 8K0 907 379 AF Component: ESP8 quattro H04 0210
Revision: -------- Serial number: -------------- Coding: 070500
Shop #: WSC 02391 823 56573
VCID: 7DF1DEA4E41AEC6E60-8028
2 Faults Found:
01314 - Engine Control Module
013 - Check DTC Memory
Freeze Frame:
Fault Status: 01101101
Fault Priority: 6
Fault Frequency: 2
Reset counter: 131
Mileage: 220986 km
Time Indication: 0
Date: 2008.05.31
Time: 18:07:30
Freeze Frame:
Hex Value: 0x0000
Hex Value: 0x0782
Hex Value: 0x0025
Hex Value: 0x468B Hex Value: 0x00FF
00473 - Control Module for Elect. Park/Hand Brake (J540)
013 - Check DTC Memory
Freeze Frame:
Fault Status: 01101101
Fault Priority: 6
Fault Frequency: 1
Reset counter: 131
Mileage: 220986 km
Time Indication: 0
Date: 2008.05.31
Time: 18:07:30
Freeze Frame:
Hex Value: 0x0000
Hex Value: 0x0782
Hex Value: 0x002E Hex Value: 0x028B Hex Value: 0x00FF
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393) Labels:. 8K0-907-064-05.clb
Part No SW: 8K0 907 064 F HW: 8K0 907 064 F Component: BCM2 1.1 H80 0145
Revision: 00002001
Coding: 0B0100
Shop #: WSC 02399 823 56573
VCID: 3365389C92DEEA1EC6-8066
Subsystem 1 - Part No SW: 8T0 959 754 A HW: 8T0 959 754 A Component: FBSAUDIB8 IDG H37 0060
Serial number: 0509000008103019
Subsystem 2 - Part No SW: 8K0 905 852 D HW: 8K0 905 852 D Component: ELVAUDIB8 H36 0041
Serial number: 0209000011133006
No fault code found.
------------------------------------------------------------------------------- Address 08: Auto HVAC (J255) Labels:. 8Tx-820-043-3Z.clb
Part No SW: 8T1 820 043 AC HW: 8T1 820 043 AC Component: KLIMA 3 ZONEN H06 0150
Revision: C1000000 Serial number: 01060320091050
Coding: 64002000
Shop #: WSC 02391 823 56573
VCID: 72EBFD98AD44A3160D-8026
1 Fault Found:
01206 - Signal for Duration of Ignition Off Time
008 - Implausible Signal
Freeze Frame:
Fault Status: 01101000
Fault Priority: 7
Fault Frequency: 1
Reset counter: 131
Mileage: 220986 km
Time Indication: 0
Date: 2008.05.31
Time: 18:11:31
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 8K0-907-063.clb Part No SW: 8K0 907 063 D HW: 8K0 907 063 D Component: BCM1 1.0 H24 0253
Revision: 05024001 Serial number: 00000000220687
Coding: 26081811063CAF010000000300003D0D0F1C120800010161000000
Shop #: WSC 20209 444 99999
VCID: 306F379063C8D106BB-8064
Subsystem 1 - Part No SW: 8K0 955 559 HW: 8K0 955 559
Component: RLS H04 0003
Serial number: 10405840
Coding: 025028
Subsystem 2 - Part No SW: 8K0 941 531 AA HW: 8K0 941 531 AA Component: E1 - LDS H07 0090
Serial number: 00000000000703090574
Subsystem 3 - Part No SW: 8K0 907 410 B HW: 8K0 907 410 B Component: HOMELINK H01 0010
2 Faults Found:
01520 - Rain and Light Recognition Sensor (G397)
008 - Implausible Signal
Freeze Frame:
Fault Status: 01101000
Fault Priority: 3
Fault Frequency: 1
Reset counter: 131
Mileage: 220986 km
Time Indication: 0
Date: 2008.05.27
Time: 00:00:00
00908 - Control Module for Wiper Motor
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 3
Fault Frequency: 1
Reset counter: 131
Mileage: 220986 km
Time Indication: 0
Date: 2008.05.27
Time: 00:00:00
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:| 8K0-959-655.clb Part No SW: 8K0 959 655 F HW: 8K0 959 655 F Component: AirbagVW-AU10 H27 0410
Serial number: 0039KD14X513
Coding: 303836354230303030304A55304C384B3053
Shop #: WSC 02145 785 00200
ASAM Dataset: EV_AirbaECUVWAUDI010 A02007
ROD: EV_AirbaECUVWAUDI010_A02.rod
VCID: 408F6750DB6841864B-8014
Seat occupied recognition:
Subsystem 1 - Part No SW: 8K0 959 339 B HW: 8K0 959 339 B Component: BF-Gewichtss. H01 0030
Serial number: 5810000R0900002GBA
Crash sensor for side airbag: driver side: Serial number: 6334MSME41052724+
Crash sensor for side airbag: front passenger side: Serial number: 6344MSME44744E2DQ
Crash sensor for side airbag: rear: driver side: Serial number: 6352QSME731A10223
Crash sensor for side airbag: rear: passenger side: Serial number: 6362QSME2F1B5804O
Crash sensor for front airbag: driver side: Serial number: 63732SME62210720J
Crash sensor for front airbag: front passenger side: Serial number: 63832SME7B213F163
No fault code found.
------------------------------------------------------------------------------- Address 16: Steering wheel (J527) Labels:. 8K0-953-568.clb
Part No SW: 8K0 953 568 F HW: 8K0 953 568 F Component: Lenks.Modul H16 0014
Revision: -------- Serial number: 90315IC60008J Coding: 000016
Shop #: WSC 02391 823 56573
VCID: 3D711EA4A49A2C6E20-8068
Component: E221 - MFL H02 0003
Address 17: Instruments (J285) Labels:. 8T0-920-xxx-17.clb Part No SW: 8K0 920 950 A HW: 8K0 920 950 A Component: KOMBIINSTR. H18 0224
Revision: 00000000 Serial number: 9DR17LV29
Coding: 8B1D090002005705020000
Shop #: WSC 20209 444 99999
VCID: 2D512EE474FABCEE90-8078
No fault code found.
------------------------------------------------------------------------------- Address 19: CAN Gateway (J533) Labels:. 8T0-907-468.clb
Part No SW: 8T0 907 468 M HW: 8T0 907 468 H Component: GW-BEM 5CAN H06 0095
Revision: GB300043 Serial number: 4300G0921901F2
Coding: 000303
Shop #: WSC 02391 823 56573
VCID: 4B95407CEA2E92DEAE-801E
Subsystem 1 - Part No SW: 8K0 915 181 E HW: 8K0 915 181 E Component: J367-BDM H06 0160
Serial number: 19067982050209
1 Fault Found:
03041 - Energy Management Active
000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 7
Fault Frequency: 5
Reset counter: 171
Mileage: 220986 km
Time Indication: 0
Date: 2008.05.31
Time: 17:37:00
------------------------------------------------------------------------------- Address 2E: Media Player 3 (R199) Labels:. 8T0-035-785.clb
Part No SW: 8T0 035 785 HW: 8T0 035 785
Component: SG ext.Player H06 0210
Revision: 00000000
Coding: 020302
Shop #: WSC 02391 823 56573
VCID: 78FFCFB0CB38C94633-802C
Address 36: Seat Mem. Drvr (J136) Labels:. 8T0-959-760.clb
Part No SW: 8K0 959 760 HW: 8K0 959 760
Component: MEM-FS H05 0043
Revision: AA000000 Serial number: 00001001225709
Coding: 00581300000000000000
Shop #: WSC 02391 823 56573
VCID: 77FDCC8CC626C63E3A-8022
No fault code found.
------------------------------------------------------------------------------- Address 42: Door Elect, Driver (J386) Labels:. 8K0-959-793.clb
Part No SW: 8K0 959 793 D HW: 8K0 959 793 D Component: TSG FA H11 0250
Revision: Serial number: 0000008560145
Coding: 011C03204E00410001
Shop #: WSC 02391 823 56573
VCID: 41896254D862488E44-8014
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv. (J393) Labels:. 8K0-907-064-46.clb
Part No SW: 8K0 907 064 F HW: 8K0 907 064 F Component: BCM2 1.1 H80 0145
Revision: 00002001 Serial number: 0117341978
Coding: 0106063A007A444600B001
Shop #: WSC 20209 444 99999
VCID: 3365389C92DEEA1EC6-8066
Subsystem 1 - Part No SW: 8K0 959 719 HW: 8K0 959 719
Component: GTO BF H06 0040
Serial number: 00000000000000122611
Subsystem 2 - Part No: 1K0 951 605 C Component: LIN BACKUP HO H03 1301
Subsystem 3 - Part No SW: 8K0 959 591 HW: 8K0 959 591
Component: J245 PS034 H06 0037
1 Fault Found:
03279 - Clutch Pedal Switch for Engine Start (F194)
008 - Implausible Signal
Freeze Frame:
Fault Status: 01101000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 131
Mileage: 220986 km
Time Indication: 0
Date: 2008.05.31
Time: 18:13:06
-------------------------------------------------------------------------------
Address 47: Sound System (J525) Labels:. 8T0-035-223-ASC.clb
Part No SW: 8T0 035 223 AB HW: 8T0 035 223
Component: DSP STD H07 0220
Revision: S2100000
Coding: 0203010102
Shop #: WSC 02391 823 56573
VCID: 6ED3E9E8B97C87F6E9-803A No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:. 8K0-959-792.clb
Part No SW: 8K0 959 792 D HW: 8K0 959 792 D Component: TSG BF H11 0250
Revision: Serial number: 0000008563540
Coding: 011C03204E00410001
Shop #: WSC 02391 823 56573
VCID: 408F6750D36841864B-8014
No fault code found.
------------------------------------------------------------------------------- Address 53: Parking Brake (J540) Labels: 8K0-907-801-V1.clb
Part No SW: 8K0 907 801 G HW: 8K0 907 801 G Component: EPB Audi B8 H08 0080
Revision: 00000003 Serial number: 00000000320559
Shop #: WSC 00000 000 00000
VCID: 3365389C92DEEA1EC6-8066
1 Fault Found:
01314 - Engine Control Module
013 - Check DTC Memory - MIL ON Freeze Frame:
Fault Status: 11101101
Fault Priority: 4
Fault Frequency: 3
Reset counter: 131
Mileage: 220986 km
Time Indication: 0
Date: 2008.05.31
Time: 17:48:17
Freeze Frame: Voltage: 10.90 V Count: 58
Speed: 0.0 km/h
Hex Value: 0x0273
Hex Value: 0x0001
Hex Value: 0x1010
------------------------------------------------------------------------------- Address 55: Headlight Range Labels: 8K0-907-357.clb
Part No: 8K5 907 357
Component: Dynamische LWR H01 0010
Revision: 00000001 Serial number: Coding: 0000004
Shop #: WSC 02145 785 00200
VCID: 77FDCC8C0626C63E3A-8022
No fault code found.
Address 56: Radio (J503) Labels:. 8Tx-035-1xx-56.clb Part No SW: 8T1 035 195 AD HW: 8T1 035 195 AD Component: Symph3 Sirius H01 0351
Revision: 00000003 Serial number: AUZ5Z4I1086213
Coding: 040200020101850043D9070800
Shop #: WSC 20209 444 10112
VCID: 79F9CAB4F032D04E4C-802C
Subsystem 1 - Part No SW: 8T0 919 603 A HW: 8T0 919 603 A Component: Display
2 Faults Found:
03157 - Functionality limited due to Communications Disruption
000 - -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 6
Fault Frequency: 1
Reset counter: 131
Mileage: 220986 km
Time Indication: 0
Date: 2008.05.31
Time: 17:48:20
Freeze Frame:
Bin. Bits: 10000000
Bin. Bits: 00000000
Bin. Bits: 00000000
Bin. Bits: 00000000
Bin. Bits: 00000000
Bin. Bits: 00000000
Bin. Bits: 00000000
Bin. Bits: 00000000
02635 - Tuner Not Enabled/Activated
000 - -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 7
Fault Frequency: 1
Reset counter: 131
Mileage: 220986 km
Time Indication: 0
Date: 2008.05.31
Time: 18:05:38
-------------------------------------------------------------------------------
Address 62: Door, Rear Left (J388) Labels:. 4F0-959-795.clb Part No SW: 4F0 959 795 N HW: 8K0 959 795 C Component: TSG HL H10 0251
Revision: Serial number: 0000100757918
Coding: 010C03204000210001
Shop #: WSC 02391 823 56573
VCID: 44876B40C7705DA66F-8010
No fault code found.
------------------------------------------------------------------------------- Address 72: Door, Rear Right (J389) Labels:. 4F0-959-795.clb
Part No SW: 4F0 959 795 N HW: 8K0 959 795 C Component: TSG HR H10 0251
Revision: Serial number: 0000100757578
Coding: 010C03204000210001
Shop #: WSC 02391 823 56573
VCID: 44876B40C7705DA66F-8010
No fault code found.
------------------------------------------------------------------------------- Address 77: Telephone Labels: 8P0-862-335.lbl
Part No SW: 8T0 862 336 C HW: 8T0 862 336 C Component: FSE_256x BT H33 0550
Revision: 00000000 Serial number: 00000005033443
Coding: 0010370
Shop #: WSC 02256 785 00200
VCID: 3B7510BC7A8E225E1E-806E No fault code found.
End-------------------------(Elapsed Time: 03:23)--------------------------