Results 1 to 6 of 6

Thread: 2014 VW Jetta S, 2.0 Manual, Code 00287 right rear speed senser

  1. #1
    Verified VCDS User
    Join Date
    Dec 2016
    Location
    USA
    Posts
    3
    Post Thanks / Like

    2014 VW Jetta S, 2.0 Manual, Code 00287 right rear speed senser

    HI,

    Im a back yard mech and apologize for lack of any terminology

    Scanned car and got a 00287 rear right speed sensor code

    Removed both rear Spees sensors ( left side just for comparison) Probed Right side has .5 Volts, Probed Left side and had 12V. Still on Left side I found the constant 12V (think it was black wire) then moved my lead to opposite wire and probed it w/1 lead on multi meter, 2nd lead to chassis ground and set to Millivolt scale and turned wheel Very slowly and can clearly see millivolt signal. to take it 1 step further I did same procedure for front left wheel and almost the same readings.

    Went back to problem wheel, right rear and had only .5 volts with no millivolt signal.

    I also cked the 2 fuses under the hood on drivers side i think they were F16 & F23 and they were both good

    Today I am going to pull back interior apart and locate Speed sesnser inside the car and probe there to see if i have 12v to rule out an broken wire leading to the sensor and do a better visual ck for any rodent damage to wires.

    Im leaning towards a bad ABS module? If module is bad can VCDS program a used junk yard ABS module or doe stealership have to program it? And if so any idea how much that should cost? I can replace the module myself just may need a Bleeding procedure

    Any thoughts or test I can I can perform would be greatly appreciated

    Thank you



    Code:
    Monday,23,March,2020,08:49:30:65532
    
    VCDS -- Windows Based VAG/VAS Emulator Running on Windows XP x86
    VCDS Version: 19.6.2.2  HEX-NET CB: 0.4508.4
    Data version: 20200210 DS308.0
    www.Ross-Tech.com
    
    
    VIN: 3VW1K7AJ5EM432129   License Plate: 
    
    
    Chassis Type: AJ-VW36 (6N0)
    Scan: 01 03 08 09 15 17 19 25 56
    
    VIN: 3VW1K7AJ5EM432129   Mileage: 128320km-79734miles
    
    01-Engine -- Status: Malfunction 0010
    03-ABS Brakes -- Status: Malfunction 0010
    04-Steering Angle -- Status: OK 0000
    08-Auto HVAC -- Status: OK 0000
    09-Cent. Elect. -- Status: OK 0000
    15-Airbags -- Status: Malfunction 0010
    17-Instruments -- Status: OK 0000
    19-CAN Gateway -- Status: OK 0000
    25-Immobilizer -- Status: OK 0000
    56-Radio -- Status: OK 0000
    -------------------------------------------------------------------------------
    Address 01: Engine (CBP)       Labels: 06G-906-055-CBP.clb
       Part No SW: 06G 906 055 AD    HW: 06G 906 055 B
       Component: 2.0l 85 KW       01 1302  
       Revision: T5H06---    Serial number:               
       Coding: 0001012
       Shop #: WSC 00066 000 00000
       VCID: 6B9615104A7A0C1760-803E
    
    1 Fault Found:
    053271 - Please Check Fault Codes in Control Module for ABS Brakes 
                   U1017 - 000 - 
                 Freeze Frame:
                        Fault Status: 01100000
                        Fault Priority: 0
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 116559 km
                        Time Indication: 0
                        Date: 2019.06.17
                        Time: 21:01:29
    
                 Freeze Frame:
                        RPM: 0 /min
                        Load: 0.0 %
                        Speed: 0.0 km/h
                        Temperature: 71.0C
                        Temperature: 31.0C
                        Absolute Pres.: 1000.0 mbar
                        Voltage: 12.446 V
    
    Readiness: 0000 0000
    
    -------------------------------------------------------------------------------
    Address 03: ABS Brakes (J104)       Labels:. 1K0-907-379-60EC1F.clb
       Part No SW: 1K0 907 379 BS    HW: 1K0 907 379 BS
       Component: ESP MK60EC1   H46 0166  
       Revision: 00H46001    
       Coding: A14B200C492508FC850C04E692221061A1100012
       Shop #: WSC 23111 002 1048576
       VCID: 04445EAC87E4E36F81-8050
    
    2 Faults Found:
    01325 - Control Module for Tire Pressure Monitoring (J502) 
                004 - No Signal/Communication
                 Freeze Frame:
                        Fault Status: 01100100
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 223
                        Mileage: 128327 km
                        Time Indication: 0
                        Date: 2014.08.12
                        Time: 18:24:16
    
                 Freeze Frame:
                        Count: 3
                        Count: 2
                        Count: 12800
                        Count: 16390
                        Count: 50688
                        Count: 1024
                        Count: 3
                        Count: 0
    
    00287 - ABS Wheel Speed Sensor; Rear Right (G44) 
                012 - Electrical Fault in Circuit
                 Freeze Frame:
                        Fault Status: 01101100
                        Fault Priority: 1
                        Fault Frequency: 1
                        Reset counter: 223
                        Mileage: 128327 km
                        Time Indication: 0
                        Date: 2014.08.12
                        Time: 18:24:07
    
                 Freeze Frame:
                        Count: 3
                        Count: 2
                        Count: 12800
                        Count: 80
                        Count: 50688
                        Count: 1024
                        Count: 3
                        Count: 0
    
    
    -------------------------------------------------------------------------------
    Address 08: Auto HVAC        Labels: 5C0-820-047.clb
       Part No SW: 5C0 820 047 BK    HW: 5C0 820 047 BK
       Component: J301  Klimaanlage   0204  
       Revision: 2001001S    Serial number: 00000002090942
       Shop #: WSC 00066 790 07030
       VCID: 6A9810144580151F1B-803E
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 09: Cent. Elect. (J519)       Labels:. 6R0-937-08x-09.clb
       Part No SW: 5C0 937 086 J    HW: 5C0 937 086 A
       Component: BCM25 JLB M3  H34 0411  
       Revision: B0034001    Serial number: 06013081140220
       Coding: 7B994B1808AB0B0000302000240884D40042502E60000000300010002000
       Shop #: WSC 00066 000 00000
       VCID: 3326CD7092CA94D768-8066
    
       Subsystem 1 - Part No SW: 6R0 959 801 AN    HW: 6R0 959 801 AN  Labels: 6R0-959-801.CLB
       Component: J386__TSG_FT  006 5461 
       Serial number: 14102585140306173954
       Coding: 820000
    
       Subsystem 2 - Part No SW: 6R0 959 802 AS    HW: 6R0 959 802 AS  Labels: 6R0-959-802.CLB
       Component: J387__TSG_BT  006 5461 
       Serial number: 14102584140306194357
       Coding: 820000
    
       Subsystem 3 - Part No SW: 6R0 959 811 M    HW: 6R0 959 811 M
       Component: J388__TSG_HL  006 5460 
       Serial number: 14102587140305175623
       Coding: 800000
    
       Subsystem 4 - Part No SW: 6R0 959 812 M    HW: 6R0 959 812 M
       Component: J389__TSG_HR  006 5460 
       Serial number: 14102586140312213121
       Coding: 800000
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 15: Airbags (J234)       Labels:| 5K0-959-655.clb
       Part No SW: 5C0 959 655 AD    HW: 5C0 959 655 AD
       Component: AirbagVW10    102 0912  
       Serial number: 003MVD03RKC2  
       Coding: 00004138
       Shop #: WSC 00066 790 07030
       ASAM Dataset: EV_AirbaVW10SMEVW360 001026
       ROD: EV_AirbaVW10SMEVW360.rod
       VCID: 74A40E6CDF44D3EFB1-8020
    
       Seat occupied recognition: 
       Subsystem 1 - Part No SW: 5C6 959 339 B    HW: 5C6 959 339 B
       Component: BF-Gewichtss.  H10 0046 
       Serial number: 6940000Y1400013PT50Z
       Coding: 303032
    
       Crash sensor for side airbag: driver side: 
       Subsystem 2 - Part No SW: 5K0 959 354     HW: 5K0 959 354 
       Component: S.Sens.Fahr.V  H02 ---- 
       Serial number: 3572MSME69137E41ZZZ 
    
       Crash sensor for side airbag: front passenger side: 
       Subsystem 3 - Part No SW: 5K0 959 354     HW: 5K0 959 354 
       Component: S.Sens.Beif.V  H02 ---- 
       Serial number: 3582MSME60227B41ZZZR
    
       Crash sensor for side airbag: rear: driver side: 
       Subsystem 4 - Part No SW: 5K0 959 351 A    HW: 5K0 959 351 A
       Component: S.Sens.Fahr.H  H02 ---- 
       Serial number: 3516KSME5941622BZZZT
    
       Crash sensor for side airbag: rear: passenger side: 
       Subsystem 5 - Part No SW: 5K0 959 351 A    HW: 5K0 959 351 A
       Component: S.Sens.Beif.H  H02 ---- 
       Serial number: 3526KSME2C30632BZZZT
    
       Crash sensor for front airbag: driver side: 
       Subsystem 6 - Part No SW: 5K0 959 659 A    HW: 5K0 959 659 A
       Component: F.Sens.Fahr  H02 ---- 
       Serial number: 3556LSME4735332BZZZW
    
       Crash sensor for front airbag: front passenger side: 
       Subsystem 7 - Part No SW: 5K0 959 659 A    HW: 5K0 959 659 A
       Component: F.Sens.Beif  H02 ---- 
       Serial number: 3566LSME351B332BZZZY
    
    1 Fault Found:
    9483008 - Seat Occupied Recognition 
              B10B3 00 [137] - Function Restriction due to Implausible Message(s)
              MIL ON - Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 2
                        Fault Frequency: 6
                        Reset counter: 224
                        Mileage: 128327 km
                        Date: 2020.03.21
                        Time: 14:30:49
    
    
    -------------------------------------------------------------------------------
    Address 17: Instruments (J285)       Labels:| 5K0-920-xxx-17.clb-SRI1
       Part No SW: 5C6 920 953     HW: 5C6 920 953 
       Component: KOMBI         H04 0809  
       Serial number: 00000000000000
       Coding: 270A01
       Shop #: WSC 00066 790 07030
       ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04723
       ROD: EV_Kombi_UDS_VDD_RM09_004_VW32.rod
       VCID: 6A9810148D80151F1B-803E
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 19: CAN Gateway (J533)       Labels:. 6N0-909-901-6R.clb
       Part No SW: 6N0 909 901     HW: 5C0 937 086 A
       Component: GW-K-CAN TP20 H34 0411  
       Revision: B0034001    
       Coding: 102200
       Shop #: WSC 00066 000 00000
       VCID: 70AC027CA35CEFCF55-8024
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 25: Immobilizer (J334)       Labels:| 5K0-920-xxx-25.clb
       Part No SW: 5K0 953 234     HW: 5K0 953 234 
       Component: IMMO          H04 0809  
       Serial number:               
       Coding: 000000
       Shop #: WSC 00000 000 00000
       ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03710
       ROD: EV_Immo_UDS_VDD_RM09.rod
       VCID: 6A9810148D80151F1B-803E
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 56: Radio (J503)       Labels:. 5M0-035-1xx-56.clb
       Part No SW: 1K0 035 164 D    HW: 1K0 035 164 D
       Component: LOW NAR       H03 0006  
       Revision: -----07S    Serial number: VWZ4Z6P3755149
       Coding: 05000400010006
       Shop #: WSC 00066 790 00123
       VCID: 23063D30222A045798-8076
    
    No fault code found.
    
    End----------(Elapsed Time: 00:59, VBatt start/end: 12.9V/12.8V)-----------
    Last edited by Uwe; 03-23-2020 at 10:54 AM. Reason: Fixed CODE tags

  2. #2
    Benevolent Dictator Uwe's Avatar
    Join Date
    Jan 2014
    Location
    Earth
    Posts
    27,845
    Post Thanks / Like
    Blog Entries
    1
    Hi and welcome.

    Quote Originally Posted by blue968 View Post
    Im leaning towards a bad ABS module? If module is bad can VCDS program a used junk yard ABS module
    Although MK60EC1 modules fail with some regularity, this doesn't fit the pattern.

    Yes, assuming a replacement module is an appropriate/correct one for the car, you can do it with VCDS.

    However I'd strongly suggest verifying all wiring (including its ability to carry current) before you conclude that it needs a module.

    Oh, and: Are the sensors on both sides the same? It's not clear to me from what you wrote whether you swapped sensors side-to-side.

    -Uwe-
    Lock-down of sick people: Quarantine
    Lock-down of healthy people: Tyranny

  3. #3
    Verified VCDS User
    Join Date
    Dec 2016
    Location
    USA
    Posts
    3
    Post Thanks / Like
    Hi,

    thank you for the reply

    To answer your question the 2 sensors are not physically the same there is a left and right sensor due to the angle of the connection, other than that they behave the same way.

    I only went to the left rear only for a properly functioning sensor for reference on how the right side should be working.

    Does anybody have a wiring diagram or a test procedure? I have not verified voltage from inside the car before it exits the wheel well to rule out any broken connections from that point.

    What would be a common symptom of a bad ABS module?

    Thank you

  4. #4
    Benevolent Dictator Uwe's Avatar
    Join Date
    Jan 2014
    Location
    Earth
    Posts
    27,845
    Post Thanks / Like
    Blog Entries
    1
    Quote Originally Posted by blue968 View Post
    Does anybody have a wiring diagram or a test procedure?
    Please see: Where do I get a Wiring Diagram?

    -Uwe-
    Lock-down of sick people: Quarantine
    Lock-down of healthy people: Tyranny

  5. Likes Jack@European_Parts, Dana liked this post
  6. #5
    Verified VCDS User
    Join Date
    Dec 2016
    Location
    USA
    Posts
    3
    Post Thanks / Like
    Update,

    wanted to thank everyone for help however in dealing with this I have spoke to many people and you get people who ask if the there is gas in the tank or if the oil has been changed??? Really!!!! Anyway I apologize for ranting

    OK to help someone, What I found under the passenger side rear door under foot sill (piece of trim molding that covers the carpet edge to the body) sorry not sure what to call that?? Anyway underneath that piece thats were all the wiring is and wiring leading out to right rear speed sensor. VW thought it would be a great idea not only to change the color of the wiring from Grey to black and blue to brown but to make a splice right there. What I ended up doing was pulling the big plug at the ABS module up at front of car (What Bitch that was) and check continuity of the wring from plug to rear speed sensor and found and open. Started pulling everything apart and VIOLA I found the broken splice in the back.

    Im not a mechanic but as I mentioned in 1st post I set my volt meter to DC Volts and measure a good reading sensor Left rear (only for a reference to see how a good speed sensor should read) and had 12V between the 2 wires in the sensor connector. Then I took 1 lead of my meter and placed it on the body (good ground) and other lead of meter to 1 of the 2 wires on the speed sensor wiring testing each wire. I found 1 wire was constant 12V and the other wire sent a Millivolt signal to ABS module. When I found the milivolt wire I turned the wheel VERY slowly and I could see the voltage change sending signal telling me the hub was good ( think its called a reluctor). Now I talked to another person and they said it was suppose to send A/C voltage but I was able to read on DC voltage so Im not sure if what I did it correct but it worked for me.

    Then I went back to right rear sensor connector which was giving me the fault, I tested between 2 wires (black & Brown) and had no voltage!!! After troubleshooting described above and repaired broken wire I then had 12V, problem solved

    Hope this helps someone else, I know If i had this info it would have saved me a LOT of time and not wasting time on checking the oil

  7. #6
    Verified VCDS User NZDubNurd's Avatar
    Join Date
    Nov 2014
    Location
    New Zealand
    Posts
    1,097
    Post Thanks / Like
    Well done on the find.

    Quote Originally Posted by blue968 View Post
    I talked to another person and they said it was suppose to send A/C voltage but I was able to read on DC voltage
    It's DC voltage, but it steps high and low, which is sort of like half-wave rectified AC voltage (Not really though )

    It funny how many people think they're car savvy... they seem to be the same ones who can feel the extra power from new oil and changing the oil and all the filters may possibly fix the conrod poking out of the block etc
    Allan
    The R32ran Thread
    How to post a full Auto-Scan
    "Duct tape can't fix stupid, but it can muffle the sound"

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •