HI,
Im a back yard mech and apologize for lack of any terminology
Scanned car and got a 00287 rear right speed sensor code
Removed both rear Spees sensors ( left side just for comparison) Probed Right side has .5 Volts, Probed Left side and had 12V. Still on Left side I found the constant 12V (think it was black wire) then moved my lead to opposite wire and probed it w/1 lead on multi meter, 2nd lead to chassis ground and set to Millivolt scale and turned wheel Very slowly and can clearly see millivolt signal. to take it 1 step further I did same procedure for front left wheel and almost the same readings.
Went back to problem wheel, right rear and had only .5 volts with no millivolt signal.
I also cked the 2 fuses under the hood on drivers side i think they were F16 & F23 and they were both good
Today I am going to pull back interior apart and locate Speed sesnser inside the car and probe there to see if i have 12v to rule out an broken wire leading to the sensor and do a better visual ck for any rodent damage to wires.
Im leaning towards a bad ABS module? If module is bad can VCDS program a used junk yard ABS module or doe stealership have to program it? And if so any idea how much that should cost? I can replace the module myself just may need a Bleeding procedure
Any thoughts or test I can I can perform would be greatly appreciated
Thank you
Im a back yard mech and apologize for lack of any terminology
Scanned car and got a 00287 rear right speed sensor code
Removed both rear Spees sensors ( left side just for comparison) Probed Right side has .5 Volts, Probed Left side and had 12V. Still on Left side I found the constant 12V (think it was black wire) then moved my lead to opposite wire and probed it w/1 lead on multi meter, 2nd lead to chassis ground and set to Millivolt scale and turned wheel Very slowly and can clearly see millivolt signal. to take it 1 step further I did same procedure for front left wheel and almost the same readings.
Went back to problem wheel, right rear and had only .5 volts with no millivolt signal.
I also cked the 2 fuses under the hood on drivers side i think they were F16 & F23 and they were both good
Today I am going to pull back interior apart and locate Speed sesnser inside the car and probe there to see if i have 12v to rule out an broken wire leading to the sensor and do a better visual ck for any rodent damage to wires.
Im leaning towards a bad ABS module? If module is bad can VCDS program a used junk yard ABS module or doe stealership have to program it? And if so any idea how much that should cost? I can replace the module myself just may need a Bleeding procedure
Any thoughts or test I can I can perform would be greatly appreciated
Thank you
Code:
Monday,23,March,2020,08:49:30:65532
VCDS -- Windows Based VAG/VAS Emulator Running on Windows XP x86
VCDS Version: 19.6.2.2 HEX-NET CB: 0.4508.4
Data version: 20200210 DS308.0
www.Ross-Tech.com
VIN: 3VW1K7AJ5EM432129 License Plate:
Chassis Type: AJ-VW36 (6N0)
Scan: 01 03 08 09 15 17 19 25 56
VIN: 3VW1K7AJ5EM432129 Mileage: 128320km-79734miles
01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: Malfunction 0010
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: Malfunction 0010
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
56-Radio -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (CBP) Labels: 06G-906-055-CBP.clb
Part No SW: 06G 906 055 AD HW: 06G 906 055 B
Component: 2.0l 85 KW 01 1302
Revision: T5H06--- Serial number:
Coding: 0001012
Shop #: WSC 00066 000 00000
VCID: 6B9615104A7A0C1760-803E
1 Fault Found:
053271 - Please Check Fault Codes in Control Module for ABS Brakes
U1017 - 000 -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 0
Fault Frequency: 1
Reset counter: 255
Mileage: 116559 km
Time Indication: 0
Date: 2019.06.17
Time: 21:01:29
Freeze Frame:
RPM: 0 /min
Load: 0.0 %
Speed: 0.0 km/h
Temperature: 71.0°C
Temperature: 31.0°C
Absolute Pres.: 1000.0 mbar
Voltage: 12.446 V
Readiness: 0000 0000
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels:. 1K0-907-379-60EC1F.clb
Part No SW: 1K0 907 379 BS HW: 1K0 907 379 BS
Component: ESP MK60EC1 H46 0166
Revision: 00H46001
Coding: A14B200C492508FC850C04E692221061A1100012
Shop #: WSC 23111 002 1048576
VCID: 04445EAC87E4E36F81-8050
2 Faults Found:
01325 - Control Module for Tire Pressure Monitoring (J502)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 223
Mileage: 128327 km
Time Indication: 0
Date: 2014.08.12
Time: 18:24:16
Freeze Frame:
Count: 3
Count: 2
Count: 12800
Count: 16390
Count: 50688
Count: 1024
Count: 3
Count: 0
00287 - ABS Wheel Speed Sensor; Rear Right (G44)
012 - Electrical Fault in Circuit
Freeze Frame:
Fault Status: 01101100
Fault Priority: 1
Fault Frequency: 1
Reset counter: 223
Mileage: 128327 km
Time Indication: 0
Date: 2014.08.12
Time: 18:24:07
Freeze Frame:
Count: 3
Count: 2
Count: 12800
Count: 80
Count: 50688
Count: 1024
Count: 3
Count: 0
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 5C0-820-047.clb
Part No SW: 5C0 820 047 BK HW: 5C0 820 047 BK
Component: J301 Klimaanlage 0204
Revision: 2001001S Serial number: 00000002090942
Shop #: WSC 00066 790 07030
VCID: 6A9810144580151F1B-803E
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 6R0-937-08x-09.clb
Part No SW: 5C0 937 086 J HW: 5C0 937 086 A
Component: BCM25 JLB M3 H34 0411
Revision: B0034001 Serial number: 06013081140220
Coding: 7B994B1808AB0B0000302000240884D40042502E60000000300010002000
Shop #: WSC 00066 000 00000
VCID: 3326CD7092CA94D768-8066
Subsystem 1 - Part No SW: 6R0 959 801 AN HW: 6R0 959 801 AN Labels: 6R0-959-801.CLB
Component: J386__TSG_FT 006 5461
Serial number: 14102585140306173954
Coding: 820000
Subsystem 2 - Part No SW: 6R0 959 802 AS HW: 6R0 959 802 AS Labels: 6R0-959-802.CLB
Component: J387__TSG_BT 006 5461
Serial number: 14102584140306194357
Coding: 820000
Subsystem 3 - Part No SW: 6R0 959 811 M HW: 6R0 959 811 M
Component: J388__TSG_HL 006 5460
Serial number: 14102587140305175623
Coding: 800000
Subsystem 4 - Part No SW: 6R0 959 812 M HW: 6R0 959 812 M
Component: J389__TSG_HR 006 5460
Serial number: 14102586140312213121
Coding: 800000
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:| 5K0-959-655.clb
Part No SW: 5C0 959 655 AD HW: 5C0 959 655 AD
Component: AirbagVW10 102 0912
Serial number: 003MVD03RKC2
Coding: 00004138
Shop #: WSC 00066 790 07030
ASAM Dataset: EV_AirbaVW10SMEVW360 001026
ROD: EV_AirbaVW10SMEVW360.rod
VCID: 74A40E6CDF44D3EFB1-8020
Seat occupied recognition:
Subsystem 1 - Part No SW: 5C6 959 339 B HW: 5C6 959 339 B
Component: BF-Gewichtss. H10 0046
Serial number: 6940000Y1400013PT50Z
Coding: 303032
Crash sensor for side airbag: driver side:
Subsystem 2 - Part No SW: 5K0 959 354 HW: 5K0 959 354
Component: S.Sens.Fahr.V H02 ----
Serial number: 3572MSME69137E41ZZZ
Crash sensor for side airbag: front passenger side:
Subsystem 3 - Part No SW: 5K0 959 354 HW: 5K0 959 354
Component: S.Sens.Beif.V H02 ----
Serial number: 3582MSME60227B41ZZZR
Crash sensor for side airbag: rear: driver side:
Subsystem 4 - Part No SW: 5K0 959 351 A HW: 5K0 959 351 A
Component: S.Sens.Fahr.H H02 ----
Serial number: 3516KSME5941622BZZZT
Crash sensor for side airbag: rear: passenger side:
Subsystem 5 - Part No SW: 5K0 959 351 A HW: 5K0 959 351 A
Component: S.Sens.Beif.H H02 ----
Serial number: 3526KSME2C30632BZZZT
Crash sensor for front airbag: driver side:
Subsystem 6 - Part No SW: 5K0 959 659 A HW: 5K0 959 659 A
Component: F.Sens.Fahr H02 ----
Serial number: 3556LSME4735332BZZZW
Crash sensor for front airbag: front passenger side:
Subsystem 7 - Part No SW: 5K0 959 659 A HW: 5K0 959 659 A
Component: F.Sens.Beif H02 ----
Serial number: 3566LSME351B332BZZZY
1 Fault Found:
9483008 - Seat Occupied Recognition
B10B3 00 [137] - Function Restriction due to Implausible Message(s)
MIL ON - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 6
Reset counter: 224
Mileage: 128327 km
Date: 2020.03.21
Time: 14:30:49
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5K0-920-xxx-17.clb-SRI1
Part No SW: 5C6 920 953 HW: 5C6 920 953
Component: KOMBI H04 0809
Serial number: 00000000000000
Coding: 270A01
Shop #: WSC 00066 790 07030
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04723
ROD: EV_Kombi_UDS_VDD_RM09_004_VW32.rod
VCID: 6A9810148D80151F1B-803E
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 6N0-909-901-6R.clb
Part No SW: 6N0 909 901 HW: 5C0 937 086 A
Component: GW-K-CAN TP20 H34 0411
Revision: B0034001
Coding: 102200
Shop #: WSC 00066 000 00000
VCID: 70AC027CA35CEFCF55-8024
No fault code found.
-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels:| 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H04 0809
Serial number:
Coding: 000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03710
ROD: EV_Immo_UDS_VDD_RM09.rod
VCID: 6A9810148D80151F1B-803E
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (J503) Labels:. 5M0-035-1xx-56.clb
Part No SW: 1K0 035 164 D HW: 1K0 035 164 D
Component: LOW NAR H03 0006
Revision: -----07S Serial number: VWZ4Z6P3755149
Coding: 05000400010006
Shop #: WSC 00066 790 00123
VCID: 23063D30222A045798-8076
No fault code found.
End----------(Elapsed Time: 00:59, VBatt start/end: 12.9V/12.8V)-----------
Last edited by a moderator: