Hello,
Asking for advice from experienced people.
History: because of bad fuel quality and dirt in the tank i needed to change injectors and clean all fuel system (changed all 6 injectors, fuel filter, took out fuel tank, washed it, dried it, changed low pressure pump in the tank.) Coded injectors, did DPF emergency regeneration... all was fine at that point, engine performed perfectly, drove around 500 km.
During one day trip there was a bumpy road and i hit one pit on asphalt in the highway - after around 30 seconds glow plug light started flashing and there was a huge loss in power. I stopped the car and switched off the engine, started again, it worked on idle for 5 seconds and suddenly engine has stopped.. after that it couldn't start trying multiple times, been pushing starter until battery started to die. (i had enough fuel in the tank and fuel was good quality since the repair).
Here is the complete auto-scan:
2008 Audi A6 Allroad 3.0TDI 171kW
Asking for advice from experienced people.
History: because of bad fuel quality and dirt in the tank i needed to change injectors and clean all fuel system (changed all 6 injectors, fuel filter, took out fuel tank, washed it, dried it, changed low pressure pump in the tank.) Coded injectors, did DPF emergency regeneration... all was fine at that point, engine performed perfectly, drove around 500 km.
During one day trip there was a bumpy road and i hit one pit on asphalt in the highway - after around 30 seconds glow plug light started flashing and there was a huge loss in power. I stopped the car and switched off the engine, started again, it worked on idle for 5 seconds and suddenly engine has stopped.. after that it couldn't start trying multiple times, been pushing starter until battery started to die. (i had enough fuel in the tank and fuel was good quality since the repair).
Here is the complete auto-scan:
2008 Audi A6 Allroad 3.0TDI 171kW
Code:
VIN: WAUZZZ4F78N...... Mileage: 317210km-197105miles
00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: Malfunction 0010
03-ABS Brakes -- Status: Malfunction 0010
05-Acc/Start Auth. -- Status: OK 0000
07-Control Head -- Status: Malfunction 0010
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
0E-Media Player 1 -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: Malfunction 0010
19-CAN Gateway -- Status: OK 0000
34-Level Control -- Status: Malfunction 0010
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: Malfunction 0010
47-Sound System -- Status: OK 0000
4F-Centr. Electr. II -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
61-Battery Regul. -- Status: Malfunction 0010
62-Door, Rear Left -- Status: OK 0000
69-Trailer -- Status: OK 0000
6D-Trunk Elect. -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
76-Park Assist -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine Labels: 059-907-401-ASB.clb
Part No SW: 4F9 910 401 L HW: 4F0 907 401 C
Component: 3.0L V6TDI G000AG 0010
Revision: --H04--- Serial number:
Coding: 0011372
Shop #: WSC 66565 257 00032
VCID: 2E58B939B989D63F05-807B
5 Faults Found:
005715 - Please check DTC Memory of ABS Controller
P1653 - 002 - - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 0
Fault Frequency: 1
Reset counter: 255
Mileage: 316755 km
Time Indication: 0
Date: 2019.11.01
Time: 17:03:19
Freeze Frame:
RPM: 0 /min
Speed: 0.0 km/h
Duty Cycle: 1.0 %
Voltage: 12.08 V
Bin. Bits: 00101000
Torque: 109.2 Nm
Bin. Bits: 00000100
005658 - Glowplug for Cylinder 1 (Q10)
P161A - 001 - Open Circuit
Freeze Frame:
Fault Status: 01100001
Fault Priority: 0
Fault Frequency: 1
Reset counter: 255
Mileage: 316767 km
Time Indication: 0
Date: 2019.11.02
Time: 10:52:23
Freeze Frame:
RPM: 924 /min
Torque: 136.5 Nm
Speed: 0.0 km/h
Duty Cycle: 1.0 %
Voltage: 13.83 V
Duty Cycle: 24.1 %
Temperature: 2.7∞C
005660 - Glowplug for Cylinder 3 (Q12)
P161C - 001 - Open Circuit
Freeze Frame:
Fault Status: 01100001
Fault Priority: 0
Fault Frequency: 1
Reset counter: 255
Mileage: 316767 km
Time Indication: 0
Date: 2019.11.02
Time: 10:52:23
Freeze Frame:
RPM: 924 /min
Torque: 136.5 Nm
Speed: 0.0 km/h
Duty Cycle: 1.0 %
Voltage: 13.83 V
Duty Cycle: 24.1 %
Temperature: 2.7∞C
005662 - Glowplug for Cylinder 5 (Q15)
P161E - 001 - Open Circuit
Freeze Frame:
Fault Status: 01100001
Fault Priority: 0
Fault Frequency: 1
Reset counter: 255
Mileage: 316767 km
Time Indication: 0
Date: 2019.11.02
Time: 10:52:23
Freeze Frame:
RPM: 924 /min
Torque: 136.5 Nm
Speed: 0.0 km/h
Duty Cycle: 1.0 %
Voltage: 13.83 V
Duty Cycle: 24.1 %
Temperature: 2.7∞C
004195 - Fuel Pressure Regulation
P1063 - 001 - Control Range Not Reached - MIL ON
Freeze Frame:
Fault Status: 11110001
Fault Priority: 0
Fault Frequency: 1
Reset counter: 255
Mileage: 317207 km
Time Indication: 0
Date: 2019.11.03
Time: 18:17:21
Freeze Frame:
RPM: 1848 /min
Torque: 273.0 Nm
(no units): 5.0
Voltage: 13.91 V
Pressure: 475.7 bar
Duty Cycle: 42.6 %
Readiness: 0 0 0 0 0
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 09L-927-760.lbl
Part No SW: 4F5 910 156 C HW: 09L 927 156 C
Component: AG6 09L 3,0 TDI RdW 0020
Revision: --H03--- Serial number: 4359852
Coding: 0000001
Shop #: WSC 02325 758 00200
VCID: 28544F219B6D880FCF-807D
1 Fault Found:
005913 - Functionality limited due to Engine Control Module
P1719 - 000 - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 0
Fault Frequency: 2
Reset counter: 255
Mileage: 316755 km
Time Indication: 0
Date: 2019.11.01
Time: 16:59:58
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 4F0-910-517.clb
Part No SW: 4F0 910 517 AB HW: 4F0 614 517 R
Component: ESP 8.0 quattro H05 0040
Revision: 00000000 Serial number: 00000000000000
Coding: 0000392
Shop #: WSC 02325 758 00200
VCID: 64CC1B11A7C52C6F23-8031
1 Fault Found:
01826 - Sensor for Steering Angle (G85); Supply Voltage Terminal 30
000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 3
Fault Frequency: 4
Reset counter: 81
Mileage: 316755 km
Time Indication: 0
Date: 2019.11.01
Time: 16:16:15
Freeze Frame:
Hex Value: 0x0000
Hex Value: 0x02A2
Hex Value: 0x0024
Hex Value: 0x0195
Hex Value: 0x00FF
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. Labels:. 4F0-910-852.clb
Part No SW: 4F0 910 852 HW: 4F0 905 852 B
Component: FBSAUDIC6 ELV H31 0230
Revision: 09010701 Serial number: 10601500852478
Coding: 0000131
Shop #: WSC 40567 222 87330
VCID: 63CE180DA2CB2B57DA-8037
Subsystem 1 - Part No: 4F0 910 131 E
Component: FBSAUDIC6 EZS H45 0080
Subsystem 2 - Part No: 4F0 910 220 K
Component: FBSAUDIC6 IDG H01 0053
No fault code found.
-------------------------------------------------------------------------------
Address 07: Control Head Labels: 4F0-910-7xx-07-H.clb
Part No SW: 4F0 910 732 A HW: 4E0 035 729
Component: Interfacebox H43 4220
Revision: 00000000 Serial number: 350HT077815553
Coding: 0003002
Shop #: WSC 02335 758 00200
VCID: 21425205F857794788-8075
Subsystem 1 - Part No: 4F0 910 609 E
Component: Bedienteil MMIC6H01 0060
Subsystem 2 - Serial number: 00000000840547
Subsystem 3 - Serial number: 0120.08.070000000100010773ˇ
Subsystem 4 - Serial number: 010773ˇ
1 Fault Found:
01317 - Control Module in Instrument Cluster (J285)
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 5
Fault Frequency: 1
Reset counter: 84
Mileage: 317208 km
Time Indication: 0
Date: 2019.11.03
Time: 18:45:06
Freeze Frame:
Bin. Bits: 10
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 4F0-910-043.clb
Part No SW: 4F0 910 043 A HW: 4F1 820 043 AG
Component: KLIMABETAETIGUNGH30 0020
Revision: 00000053 Serial number: 00000030276610
Coding: 0000278
Shop #: WSC 02325 758 00200
VCID: 1C3C63F1DF3554AF5B-8049
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels: 4F0-910-279.lbl
Part No SW: 4F0 910 279 K HW: 4F0 907 279
Component: ILM Fahrer H18 0250
Revision: 00000000 Serial number: 4F0907279
Coding: 0012122
Shop #: WSC 02335 758 00200
VCID: 3162A245A8B7C9C718-8065
Subsystem 1 - Part No: 4F1 910 113 C Labels: 1KX-955-119.CLB
Component: Wischer AudiC6 H05 0210
Coding: 00064784
Shop #: WSC 02335
Subsystem 2 - Part No: 4E0 910 557 B Labels: 8K0-955-559.CLB
Component: REGENLICHTSENSORH13 0100
Coding: 00146221
Shop #: WSC 02335
No fault code found.
-------------------------------------------------------------------------------
Address 0E: Media Player 1 Labels: 4E0-910-111.lbl
Part No SW: 4E0 910 110 C HW: 4E0 035 110 A
Component: MP3-Changer H46 0350
Revision: 00046006 Serial number: AUZ5ZBG3462549
Shop #: WSC 00000 000 00000
VCID: 18347FE12B0D388F7F-804D
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 4F0-910-655-8R.clb
Part No SW: 4F0 910 655 E HW: 4F0 959 655 B
Component: 42 AIRBAG AUDI8RH30 0280
Revision: 09H30000 Serial number: 0037LD0THNE+
Coding: 0013362
Shop #: WSC 02325 758 00200
VCID: 29524A258067B107D0-807D
Subsystem 1 - Serial number: 6332CSME1A6A743EG
Subsystem 2 - Serial number: 6342CSME16121571T
Subsystem 3 - Serial number: 6352QSME3B0B3847O
Subsystem 4 - Serial number: 6362QSME37784443I
Subsystem 5 - Serial number: 63734SME38501A15Y
Subsystem 6 - Serial number: 63834SME351B0C630
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 4F0-910-549.lbl
Part No SW: 4F0 910 549 A HW: 4F0 953 549 D
Component: J0527 0410
Revision: 00H02000 Serial number: 90026072060157
Coding: 0002042
Shop #: WSC 02323 758 00200
VCID: 27564C1D96738777C6-8073
Subsystem 1 - Part No: XXXXXXXXXXX
Component: E0221 H02 0030
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 4F0-910-xxx-17.lbl
Part No SW: 4F0 910 930 C HW: 4F0 920 933 J
Component: KOMBIINSTR. M73 H21 0240
Revision: 00700000 Serial number: 72U31FV87
Coding: 7209158
Shop #: WSC 28268 001 1048576
VCID: 234E580DE24B6B579A-8077
1 Fault Found:
00532 - Supply Voltage B+
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 4
Fault Frequency: 1
Reset counter: 84
Mileage: 317208 km
Time Indication: 0
Date: 2019.11.03
Time: 18:45:00
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels:. 4L0-910-468.clb
Part No SW: 4L0 910 468 A HW: 4L0 907 468 B
Component: J533__Gateway H06 0060
Revision: 00H06000 Serial number: 1100B0773180FC
Coding: F751BE7F30020600
Shop #: WSC 02334 758 00200
VCID: 2D5ABE35B48FAD273C-8079
No fault code found.
-------------------------------------------------------------------------------
Address 34: Level Control Labels: 4F0-910-553.clb
Part No SW: 4F0 910 553 A HW: 4F0 907 553 A
Component: J197 LUFTFEDER H17 0060
Serial number: 00619003690500
Coding: 0000220
Shop #: WSC 02335 758 00200
VCID: 22405D09FD51625F91-8077
1 Fault Found:
01316 - ABS Control Module
013 - Check DTC Memory - Intermittent
Freeze Frame:
Fault Status: 00101101
Fault Priority: 2
Fault Frequency: 7
Reset counter: 81
Mileage: 316755 km
Time Indication: 0
Date: 2019.11.01
Time: 16:14:57
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: 4F0-910-793-42.lbl
Part No SW: 4F0 910 793 P HW: 4F0 959 793 P
Component: TSG FA H12 0230
Revision: 00000000 Serial number: "ó
Coding: 0003626
Shop #: WSC 02327 758 00200
VCID: 37769C5D46D317F756-8063
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv. Labels:. 4F0-910-289.lbl
Part No SW: 4F0 910 289 K HW: 4F0 907 289 K
Component: Komfortgeraet H25 0200
Revision: 02000025 Serial number: 01058729180000
Coding: 3351281
Shop #: WSC 02335 758 00200
VCID: 3260AD49ADB1F2DF61-8067
Subsystem 1 - Part No: 1K0 951 605 C
Component: LIN BACKUP HORN H03 1301
Subsystem 2 - Part No: 4F0 910 177
Component: Innenraumueberw.H01 0020
1 Fault Found:
01505 - Bulb for Blinkers; Rear Right (M8)
009 - Open or Short to Ground
Freeze Frame:
Fault Status: 01101001
Fault Priority: 3
Fault Frequency: 254
Reset counter: 44
Mileage: 313510 km
Time Indication: 0
Date: 2019.07.30
Time: 16:03:31
-------------------------------------------------------------------------------
Address 47: Sound System (J525) Labels: Redir Fail!
Part No SW: 4F0 910 223 K HW: 4F0 035 223 L
Component: Amp.-ASK-RD H07 0250
Revision: S0900000
Coding: 080001
Shop #: WSC 02399 823 56573
VCID: 2648411951799E7FFD-8073
No fault code found.
-------------------------------------------------------------------------------
Address 4F: Centr. Electr. II Labels: 4F0-910-280.lbl
Part No SW: 4F0 910 280 HW: 4F0 907 280 A
Component: ILM Beifahrer H12 0100
Revision: Serial number: 00000000470735
Coding: 0001103
Shop #: WSC 02323 758 00200
VCID: 5EB829F989A906BFF5-800B
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 4F0-910-793-52.lbl
Part No SW: 4F0 910 793 P HW: 4F0 959 792 P
Component: TSG BF H12 0230
Revision: 00000000 Serial number: 6
Coding: 0003626
Shop #: WSC 02327 758 00200
VCID: 37769C5D46D317F756-8063
No fault code found.
-------------------------------------------------------------------------------
Address 53: Parking Brake Labels: 4F0-910-801.clb
Part No SW: 4F0 910 801 C HW: 4F0 907 801 A
Component: EPB CDEC0080 H04 0080
Revision: --H04---
Coding: 0000321
Shop #: WSC 02324 758 00200
VCID: 20445701F35D704F87-8075
No fault code found.
-------------------------------------------------------------------------------
Address 55: Headlight Range Labels: 8P0-907-357.lbl
Part No: 8P0 907 357 H
Component: Dynamische LWR H01 0010
Revision: 00000001 Serial number:
Coding: 0000004
Shop #: WSC 02325 758 00200
VCID: 3F86F47D6EE32FB79E-806B
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio Labels: 4E0-910-541.lbl
Part No SW: 4E0 910 541 Q HW: 4F0 035 541 L
Component: TUNER EU/US/RDW H42 0620
Revision: 00000000 Serial number: 384K/067624809
Coding: 0000001
Shop #: WSC 40995 222 98481
VCID: 2E58B939B989D63F05-807B
No fault code found.
-------------------------------------------------------------------------------
Address 61: Battery Regul. Labels: 4F0-910-181.lbl
Part No SW: 4F0 910 181 F HW: 4F0 915 181 B
Component: J0644 BEM H12 0760
Revision: 00000000 Serial number: 00000000013281
Shop #: WSC 40567 222 87330
VCID: 244C5B11E7456C6FE3-8071
Subsystem 1 - Part No: 4F0 915 105 D
Component: von VA0 2708021438
Coding: 344630393135313035442056413032373038303231343338
Shop #: WSC 00000 384 00290
2 Faults Found:
02272 - Quiescent Current Stage 1
000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 7
Fault Frequency: 2
Reset counter: 255
Mileage: 317212 km
Time Indication: 0
Date: 2019.11.03
Time: 19:11:59
02273 - Quiescent Current Stage 2
000 - - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 7
Fault Frequency: 1
Reset counter: 255
Mileage: 317212 km
Time Indication: 0
Date: 2019.11.03
Time: 20:17:10
-------------------------------------------------------------------------------
Address 62: Door, Rear Left Labels: 4F0-910-795.lbl
Part No SW: 4F0 910 795 E HW: 4F0 959 795 E
Component: TSG HL H21 0210
Coding: 0003114
Shop #: WSC 02327 758 00200
VCID: 2E58B939B989D63F05-807B
No fault code found.
-------------------------------------------------------------------------------
Address 69: Trailer (J345) Labels:. 4F0-907-383.clb
Part No SW: 4F0 907 383 C HW: 4F0 907 383 C
Component: Anhaenger H14 0080
Revision: 2B002001 Serial number: 00000106002078
Coding: 0103030000000000
Shop #: WSC 02399 823 56573
VCID: 2B5EB02D4A9BA31722-807F
No fault code found.
-------------------------------------------------------------------------------
Address 6D: Trunk Elect. Labels: Redir Fail!
Part No SW: 4F9 910 591 HW: 4F9 827 851 F
Component: ValeoHeckdeckel H24 0290
Revision: --H24001 Serial number: E5030000B
Shop #: WSC 98765 666 38354
VCID: 6CDC73314F15642F6B-8039
Subsystem 1 - Part No: 4F9 910 592
Component: ValeoHeckdeckel H24 0290
Subsystem 2 - Serial number: E5030100B
Subsystem 3 - Serial number: RD03.08.07--H24001001B0086ˇ
Subsystem 4 - Serial number: 1B0086ˇ
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right Labels: 4F0-910-795.lbl
Part No SW: 4F0 910 795 E HW: 4F0 959 794 E
Component: TSG HR H21 0210
Coding: 0003114
Shop #: WSC 02327 758 00200
VCID: 2E58B939B989D63F05-807B
No fault code found.
-------------------------------------------------------------------------------
Address 76: Park Assist Labels: 4Fx-910-283.lbl
Part No SW: 4F0 910 283 H HW: 4F0 919 283 H
Component: Parkhilfe 8-Kan H12 0080
Revision: 00H12000 Serial number: 06330722501766
Coding: 0211416
Shop #: WSC 131071 1023 2097151
VCID: 29524A258067B107D0-807D
No fault code found.
End-------------------------(Elapsed Time: 03:25)--------------------------
Last edited by a moderator: