- Joined
- Oct 15, 2019
- Messages
- 5
- Reaction score
- 1
- Location
- Oklahoma, USA
- VCDS Serial number
- C?ID=52136
I bought the '06 v10 Touareg about a month ago. The headlights worked when I bought it, but were very dim. It had cheap bulbs in it that probably burnt the chrome (lovely).
I replaced the hardly insulated short jumper behind trays that somehow worked, and the bulbs with Sylvania Basic D1S. Both lows worked but were still not very bright. After a week the left light fails to turn on, right at the start of a trip of course...
I then bought a new Valeo ballast and replaced the left one thinking that was the problem. Still no left light, shows the below error in VCDS:
Address 09: Cent. Elect. Labels:. 7Lx-937-049-V1.clb
Part No: 7L6 937 049 N
Component: 3002
Coding: 0111838
Shop #: WSC 22188 444 89171
VCID: 4796E2DA3580D07718-5120
00978 - Lamp for Low Beam; Left (M29)
007 - Short to Ground (BUT WHERE?)
Thinking it was the internal headlight module wiring, I bought and replaced the headlight units with new Valeo ones, swapping the low bulbs and ballasts. Still no left light! I cleared the code, turned the vehicle off. Started it up - still the same error.
I tested the short 3-wire jumper from the ballast to the bulb, and it appears to be fine as I swapped left and rights with no change. Then I poked around in VCDS some more and realized that if I select 39 - the right headlight, it connects to the controller fine. If I select 29 - the left headlight, nothing. VCDS cannot find it! The rest of the lights work fine on that side (high, turn, marker). From what I can tell these are all driven from the "Vehicle Electrical System Central Control Unit" module under that dash.
I'm still looking for a good wiring diagram for 2006 xenons so I can actually test voltages and find the short to ground (if that is still true, and not something that just needs to be re-coded or reset). Recommendations?
Thanks in advance,
Bryan
Here is a full scan I did earlier before replacing anything:
I replaced the hardly insulated short jumper behind trays that somehow worked, and the bulbs with Sylvania Basic D1S. Both lows worked but were still not very bright. After a week the left light fails to turn on, right at the start of a trip of course...
I then bought a new Valeo ballast and replaced the left one thinking that was the problem. Still no left light, shows the below error in VCDS:
Address 09: Cent. Elect. Labels:. 7Lx-937-049-V1.clb
Part No: 7L6 937 049 N
Component: 3002
Coding: 0111838
Shop #: WSC 22188 444 89171
VCID: 4796E2DA3580D07718-5120
00978 - Lamp for Low Beam; Left (M29)
007 - Short to Ground (BUT WHERE?)
Thinking it was the internal headlight module wiring, I bought and replaced the headlight units with new Valeo ones, swapping the low bulbs and ballasts. Still no left light! I cleared the code, turned the vehicle off. Started it up - still the same error.
I tested the short 3-wire jumper from the ballast to the bulb, and it appears to be fine as I swapped left and rights with no change. Then I poked around in VCDS some more and realized that if I select 39 - the right headlight, it connects to the controller fine. If I select 29 - the left headlight, nothing. VCDS cannot find it! The rest of the lights work fine on that side (high, turn, marker). From what I can tell these are all driven from the "Vehicle Electrical System Central Control Unit" module under that dash.
I'm still looking for a good wiring diagram for 2006 xenons so I can actually test voltages and find the short to ground (if that is still true, and not something that just needs to be re-coded or reset). Recommendations?
Thanks in advance,
Bryan
Here is a full scan I did earlier before replacing anything:
Code:
Monday,12,August,2019,13:43:53:11556
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 19.6.1.0 (x64)
Data version: 20190529 DS308.0
www.Ross-Tech.com
VIN: WVGPT77L46D063114 License Plate: TOURAG
Mileage: 339690km-211073mi Repair Order:
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
0111838
Chassis Type: 7L (7L - VW Touareg (2003 > 11/2006))
Scan: 01 02 03 05 06 08 09 11 13 15 16 17 18 19 1C 22 29 32 34 36
37 39 3C 46 47 55 56 57 64 65 68 69 6C 6D 6E 75 76 77
VIN: WVGPT77L46D063114 Mileage: 339690km-211073miles
-------------------------------------------------------------------------------
Address 01: Engine Labels: Redir Fail!
Part No SW: 070 906 016 CQ HW: 028 101 196 2
Component: V10 5,0L EDCG000AGMª8472
Revision: --H02--- Serial number: VWZ3Z0F6459651
Coding: 0060575
Shop #: WSC 66565 257 00032
VCID: 61C21C42BB648E47F6-5120
No fault code found.
Readiness: 0 0 0 0 1
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 09D-927-750.clb
Part No SW: 09D 927 750 DP HW: 09D 927 750 DP
Component: AL 750 6A 0856
Revision: 00H37000 Serial number:
Coding: 0004216
Shop #: WSC 31414 000 00000
VCID: 7F06BA3A2DD058B7E0-513C
No fault code found.
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 7L0-907-379-MK25.lbl
Part No: 7L0 907 379 G
Component: ESP ALLRAD MK25 0203
Coding: 0022786
Shop #: WSC 31414 000 00000
VCID: 3D7A8032675C8AA7B2-513C
No fault code found.
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. Labels: None
Part No SW: 7L0 909 137 A HW: 5WK 485 02
Component: 29 Kessy 6700
Revision: 67005915 Serial number: VWZ3Z0F6459651
Coding: 0147688
Shop #: WSC 31414 000 00000
VCID: 3162AC02AB047EC726-513C
Subsystem 1 - Part No: XXXXXXXXXXX
Component: ELV XXXX
No fault code found.
-------------------------------------------------------------------------------
Address 06: Seat Mem. Pass Labels: None
Part No: 7L0 959 760
Component: Sitzverstellung 0701
Shop #: WSC 00000 000 00000
VCID: 77F6521A05E060F7A8-513C
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: None
Part No: 7L6 907 044 T
Component: CLIMAtronic 2+2 4222
Coding: 0021030
Shop #: WSC 31414 000 00000
VCID: 458AE8D20F8CC267EA-513C
Subsystem 1 - Part No: 7L6 907 049 E
Component: CLIMAtronic FOND 0400
2 Faults Found:
00710 - Defroster Flap Positioning Motor (V107)
000 - -
02600 - Rear Right Temperature Flap Motor (V314)
000 - - - Intermittent
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels:. 7Lx-937-049-V1.clb
Part No: 7L6 937 049 N
Component: 3002
Coding: 0111839
Shop #: WSC 22188 444 89171
VCID: 4796E2DA3580D07718-513C
1 Fault Found:
00907 - Intervention load Management
000 - -
-------------------------------------------------------------------------------
Address 11: Engine II Labels: Redir Fail!
Part No SW: 070 906 016 CQ HW: 028 101 196 2
Component: V10 5,0L EDCG000AGSª8472
Revision: --H02--- Serial number: VWZ3Z0F6459651
Coding: 0060575
Shop #: WSC 66565 257 00032
VCID: 61C21C42BB648E47F6-513C
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 3D0-909-601.lbl
Part No: 3D0 909 601 H
Component: 05 Airbag 8.4E++H01 0562
Revision: BB38727 Serial number: 0007756?
Coding: 0012341
Shop #: WSC 31414 000 00000
VCID: 2854416698DE3F0FF1-5120
Subsystem 1 - Part No: 7L0 959 339 C
Component: BF-Gewichtsens. 006 0008
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 7L6-953-549.lbl
Part No: 7L6 953 549 F
Component: Lenksaeulenmodul 3501
Coding: 0010032
Shop #: WSC 31414 790 00001
VCID: 4280F3CE1EA2F55FCF-5120
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 7L6-920-xxx-7LA.lbl
Part No: 7L6 920 981 R
Component: KOMBIINSTRUMENT RB8 3211
Coding: 0005231
Shop #: WSC 31414 000 00000
VCID: 4894E1E6389EDF0F11-513C
No fault code found.
-------------------------------------------------------------------------------
Address 18: Aux. Heat Labels: 7L6-819-008.clb
Part No: 7L6 815 071 D
Component: Standheizung E1MAC
Coding: 0000100
Shop #: WSC 31414 000 00000
VCID: 336EA60A51184CD754-5120
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 6N0-909-901-19.lbl
Part No: 6N0 909 901
Component: Gateway K<>CAN 0101
Coding: 0000006
Shop #: WSC 22188 444 52556
VCID: 70E46906608E37CF69-513C
No fault code found.
-------------------------------------------------------------------------------
Address 1C: Position Sensing Labels: 7L6-919-879.lbl
Part No: 7L6 919 879 A
Component: JCI PathPoint 2200
Shop #: WSC 00000 000 00000
VCID: 458AE8D20F8CC267EA-5120
No fault code found.
-------------------------------------------------------------------------------
Address 22: AWD Labels: None
Part No: 0AD 927 755 AT
Component: TRANSFERCASE 0114
Shop #: WSC 00000 000 00000
VCID: 0D1A10F2177C7A27E2-513C
No fault code found.
-------------------------------------------------------------------------------
Address 34: Level Control Labels: 7Lx-907-553-34.clb
Part No: 7L0 907 553 F
Component: LUFTFDR.-CDC- 3C3P1 3081
Coding: 0015521
Shop #: WSC 31414 000 00000
VCID: 36689F1E426A59FF73-513C
No fault code found.
-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr Labels: None
Part No: 7L0 959 760
Component: Sitzverstellung 0703
Shop #: WSC 00000 000 00000
VCID: 77F6521A05E060F7A8-513C
No fault code found.
-------------------------------------------------------------------------------
Address 37: Navigation Labels: 7L6-919-887-DVD.lbl
Part No: 7L6 919 887 M
Component: Navigation 0047
Coding: 0000101
Shop #: WSC 31414 000 00000
VCID: 50A4C986C0CE17CF49-513C
No fault code found.
-------------------------------------------------------------------------------
Address 39: Right Light Labels: 3D0-909-158.lbl
Part No: 3D0 909 158
Component: EVG GDL+AutoLWR(r) 0001
Coding: 0000003
Shop #: WSC 31414 000 00000
VCID: 67D6025A5540F07738-5102
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv. Labels: 7L0-959-933.lbl
Part No: 7L0 959 933 J
Component: HSG 5115
Coding: 0000085
Shop #: WSC 31414 000 00000
VCID: 438EF6CA01B8FC57C4-4B00
Subsystem 1 - Part No: 7L0 959 701 H
Component: Tuersteuergeraet FS 0201
Subsystem 2 - Part No: 7L0 959 702 H
Component: Tuersteuergeraet BF 0201
Subsystem 3 - Part No: 7L0 959 703 D
Component: Tuersteuergeraet HL 0201
Subsystem 4 - Part No: 7L0 959 704 D
Component: Tuersteuergeraet HR 0201
6 Faults Found:
00927 - Terminal 30 (Right)
011 - Open Circuit - Intermittent
01516 - Terminal 30; Left
011 - Open Circuit - Intermittent
00926 - Terminal 30
011 - Open Circuit - Intermittent
00668 - Supply Voltage Terminal 30
002 - Lower Limit Exceeded - Intermittent
01134 - Alarm Horn (H12)
000 - -
00488 - Rear Right Outside Door Handle Central Locking Button (E372)
007 - Short to Ground
-------------------------------------------------------------------------------
Address 47: Sound System Labels: 7Lx-035-4xx-47.lbl
Part No: 7L6 035 456
Component: 08K Audioverst. 0105
Shop #: WSC 00000 000 00000
VCID: 70E46906608E37CF69-5120
Subsystem 1 - Part No: 7L6 035 456
Component: 08K Audioverst. 0105
No Faults Found
or DTCs not supported by controller
or a communication error occurred
-------------------------------------------------------------------------------
Address 56: Radio Labels: 7L6-035-186-DVD.lbl
Part No: 7L6 035 186 E
Component: Radio 0047
Coding: 0014062
Shop #: WSC 31414 000 00000
VCID: 356A98125F6C52E77A-5120
No fault code found.
-------------------------------------------------------------------------------
Address 68: Wiper Electr. Labels: 7L0-955-119-V2.clb
Part No: 7L0 955 119 K
Component: Front Wiper 4027
Coding: 0000341
Shop #: WSC 31414 000 376832
VCID: 3C7C8D367C4683AF85-513C
Subsystem 2 - Part No: 1K0 955 559 T Labels: 1K0-955-559-AF.CLB
Component: RegenLichtSens 011 1110
Coding: 00208933
Shop #: WSC 31414
No fault code found.
-------------------------------------------------------------------------------
Address 69: Trailer Labels: 7L0-907-383-1D2.lbl
Part No SW: 7L0 907 383 G HW: 7L0 907 383 G
Component: ANHAENGERELEKTRONIK 8854
Coding: 0000002
Shop #: WSC 31414 000 00000
VCID: 38749126487EAF8F61-5120
No fault code found.
-------------------------------------------------------------------------------
Address 6C: Back-up Cam. Labels: 5N0-907-441.clb
Part No SW: 7L6 907 441 HW: 7L6 907 441
Component: J772__Rearview 0051
Revision: 00H07000 Serial number: PA8 J620637
Coding: 0000101
Shop #: WSC 31414 000 00000
VCID: 72E0630E6E8205DF9F-513C
No fault code found.
-------------------------------------------------------------------------------
Address 6E: Ctrl Head Roof Labels: None
Part No: 7L6 919 044 T
Component: DACHDISPLAY 0539
Revision: 00900539 Serial number: 2009289.07
Shop #: WSC 31414 000 00000
VCID: 4894E1E6389EDF0F11-5120
No fault code found.
-------------------------------------------------------------------------------
Address 76: Park Assist Labels: Redir Fail!
Part No: 7L0 919 283 F
Component: 0E Einparkhilfe 1107
Shop #: WSC 00000 000 00000
VCID: 397294227374B6879E-513C
No fault code found.
End-------------------------(Elapsed Time: 09:50)--------------------------
Last edited by a moderator: