2015 Passat with MIL on checked Group 1 Fault Codes found this:
4238 - Engine Coolant Temp Sensor on Radiator Outlet (G83)
P2185 00 [175] - Signal too High
Checked advanced measuring codes for coolant sensors found this:
Replaced coolant temp. sensor at radiator outlet and it appears that fixed the issue. So far.
I am was confused by the similar labeling of the IDE measuring codes. Is this correct?
It appears by the actual temperature/voltage readings that IDE07727 and IDE07728 are for the sensor at the radiator outlet.
Complete Autoscan:
Thank you!
4238 - Engine Coolant Temp Sensor on Radiator Outlet (G83)
P2185 00 [175] - Signal too High
Checked advanced measuring codes for coolant sensors found this:
Code:
IDE00025 Coolant temperature 59 °C
IDE00194 Coolant temperature at radiator output: specified value 90.0 °C
IDE01266-ENG57549 Coolant shut-off valve-Bits 0-7 3
IDE07724 Coolant temperature at engine outlet: calculated 59.7 °C
IDE07725 Coolant temp.sens.1 bank 1 at cylinder head: raw value 59.5 °C
IDE07726 Coolant temp.sens.1 bank 1 at cylinder head: uncnd. voltage 1906.0 mV
IDE07727 Coolant temp. sensor 1 bank 1 at cylinder head: raw value -40.0 °C
IDE07728 Coolant temp. sensor 1 bank 1 at cylinder head: uncnd. voltage 4999.8 mV
Replaced coolant temp. sensor at radiator outlet and it appears that fixed the issue. So far.
I am was confused by the similar labeling of the IDE measuring codes. Is this correct?
It appears by the actual temperature/voltage readings that IDE07727 and IDE07728 are for the sensor at the radiator outlet.
Complete Autoscan:
Code:
Chassis Type: A3-VW41 (7N0)
Scan: 01 02 03 08 09 15 16 17 19 1C 25 2E 42 44 46 4F 52 56 62 72
75 77
VIN: 1VWBV7A32FC095600 Mileage: 187170km-116302miles
01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: Malfunction 0010
03-ABS Brakes -- Status: Malfunction 0010
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
1C-Position Sensing -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
4F-Centr. Electr. II -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
56-Radio -- Status: Malfunction 0010
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
75-Telematics -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CVCA) Labels:. 04L-907-309-V1.clb
Part No SW: 04L 997 016 D HW: 04L 907 309 K
Component: R4 2.0l TDI H20 9466
Revision: 8AH20---
Coding: 011D0012032410080000
Shop #: WSC 03340 444 00000
ASAM Dataset: EV_ECM20TDI01104L997016D 004002
ROD: EV_ECM20TDI01104L997016D.rod
VCID: 346694E39F0DD1EF4D-8060
2 Faults Found:
4238 - Engine Coolant Temp Sensor on Radiator Outlet (G83)
P2185 00 [175] - Signal too High
MIL ON - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 186517 km
Date: 2019.08.29
Time: 12:03:52
Engine speed: 1006.00 /min
Normed load value: 16.1 %
Vehicle speed: 0 km/h
Coolant temperature: 51 °C
Intake air temperature: 48 °C
Ambient air pressure: 980 mbar
Voltage terminal 30: 12.280 V
Unlearning counter according OBD: 40
Accelerator pedal travel: raw value: 0.00 %
Coolant temp. sensor 1 bank 1 at cylinder head: raw value: -40.0 °C
Heat delivery temperature in cooling system: -273.1 °C
Extern.temp.sens.1 bank 1: raw value: 26.0 °C
Fuel consumption: 0.63 l/h
Fuel temp. sensor 1 bank 1: raw value: 48.0 °C
Engine oil temperature: 47.7 °C
25147 - Control Circuit for Reductant Pump 1
P208B 00 [096] - Implausible Signal
Intermittent - Not Confirmed - Tested Since Memory Clear
Readiness: 1 1 0 0 0
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 02E-927-770.clb
Part No SW: 02E 300 061 T HW: 02E 927 770 AL
Component: GSG DSG AG6 531 4518
Revision: 05653104 Serial number: 00001501250253
Coding: 0000020
Shop #: WSC 09003 957 00200
VCID: 254079A7ECD7B867CA-8070
1 Fault Found:
28907 - No Communications with Cruise Control (Front) Distance Sensor
U0235 - 000 - - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 0
Fault Frequency: 103
Reset counter: 37
Mileage: 168898 km
Time Indication: 0
Date: 2019.04.16
Time: 12:18:08
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels:. 1K0-907-379-60EC1F.clb
Part No SW: 1K0 907 379 BS HW: 1K0 907 379 BS
Component: ESP MK60EC1 H46 0166
Revision: 00H46001
Coding: C54BC0F5492B00FFA31103E492190042A1100012
Shop #: WSC 09003 957 00200
VCID: 04060423872DA16FBD-8050
1 Fault Found:
02214 - Tire Pressure Warning
002 - Lower Limit Exceeded - Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 2
Fault Frequency: 4
Reset counter: 149
Mileage: 177406 km
Time Indication: 0
Date: 2019.06.06
Time: 08:49:31
Freeze Frame:
Count: 0
Count: 32768
Count: 4608
Count: 16401
Count: 51325
Count: 0
Count: 65277
Count: 0
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301) Labels:| 3C8-907-336.clb
Part No SW: 561 907 426 J HW: 561 907 426 J
Component: AC Manuell H02 0404
Revision: 00001K01
Coding: 0010001002
Shop #: WSC 09003 957 00200
ASAM Dataset: EV_ACManuaElectGen2BHTC 001002
ROD: EV_ACManuaElectGen2BHTC_VW36.rod
VCID: 224A62BB35F94F5FAF-8076
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 1K0-937-08x-09.clb
Part No SW: 5K0 937 085 AB HW: 5K0 937 085 AB
Component: BCM PQ35 B+ 122 0174
Revision: BH122001
Coding: EF200E1B802B2AD4098800010600044800F1A08640801520648060000C70
Shop #: WSC 05512 002 1048576
VCID: 73E457FFD28396D794-8026
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:| 5K0-959-655.clb
Part No SW: 5C0 959 655 AB HW: 5C0 959 655 AB
Component: AirbagVW10 500 0975
Serial number: 003LZD06G7W4
Coding: 00004D53
Shop #: WSC 34130 003 1048576
ASAM Dataset: EV_AirbaVW10SMEVW360 001030
ROD: EV_AirbaVW10SMEVW360.rod
VCID: 72EA52FBA5999FDF9F-8026
Seat occupied recognition:
Subsystem 1 - Part No SW: 5C6 959 339 B HW: 5C6 959 339 B
Component: BF-Gewichtss. H10 0046
Serial number: 6940000Y150001BX2L0+
Coding: 303044
Crash sensor for side airbag: driver side:
Subsystem 2 - Part No SW: 5K0 959 354 HW: 5K0 959 354
Component: S.Sens.Fahr.V H02 ----
Serial number: 3572MSME68326A4EZZZ3
Crash sensor for side airbag: front passenger side:
Subsystem 3 - Part No SW: 5K0 959 354 HW: 5K0 959 354
Component: S.Sens.Beif.V H02 ----
Serial number: 3582MSME38035C4EZZZ0
Crash sensor for side airbag: rear: driver side:
Subsystem 4 - Part No SW: 5K0 959 351 A HW: 5K0 959 351 A
Component: S.Sens.Fahr.H H02 ----
Serial number: 3516KSME03506635ZZZH
Crash sensor for side airbag: rear: passenger side:
Subsystem 5 - Part No SW: 5K0 959 351 A HW: 5K0 959 351 A
Component: S.Sens.Beif.H H02 ----
Serial number: 3526KSME2D056635ZZZU
Crash sensor for front airbag: driver side:
Subsystem 6 - Part No SW: 5K0 959 659 A HW: 5K0 959 659 A
Component: F.Sens.Fahr H02 ----
Serial number: 3556LSME5F1E6634ZZZ5
Crash sensor for front airbag: front passenger side:
Subsystem 7 - Part No SW: 5K0 959 659 A HW: 5K0 959 659 A
Component: F.Sens.Beif H02 ----
Serial number: 3566LSME7D0A6634ZZZ1
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels:| 5K0-953-569.clb
Part No SW: 1K5 953 521 BM HW: 5K0 953 569 AE
Component: LENKS.MODUL 016 0162
Revision: FF010042 Serial number: 20150304101167
Coding: 088A140000
Shop #: WSC 09003 957 00200
ASAM Dataset: EV_SMLSNGVOLWSXS A01004
ROD: EV_SMLSNGVOLWS.rod
VCID: 79F865D7F8EFEC87DE-802C
Multifunction steering wheel control module:
Subsystem 1 - Part No SW: 3C8 959 537 D HW: 3C8 959 537 D Labels: 3C8-959-537.CLB
Component: E221__MFL-8LP H07 0023
Serial number: 00000000000001044861
Coding: E20000
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5K0-920-XXX-17.clb-SRI1
Part No SW: 561 920 970 G HW: 561 920 970 G
Component: KOMBI H05 0813
Serial number: 00000000000000
Coding: 231E01
Shop #: WSC 09003 957 00200
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04723
ROD: EV_Kombi_UDS_VDD_RM09_004_VW32.rod
VCID: 1E32564B01816BBF8B-804A
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 7N0-907-530-V2.clb
Part No SW: 7N0 907 530 AR HW: 7N0 907 530 AM
Component: J533 Gateway H55 1653
Revision: H55 Serial number: 30031503000942
Coding: 461000
Shop #: WSC 09003 957 00200
VCID: 000E08339335BD4F99-8054
No fault code found.
-------------------------------------------------------------------------------
Address 1C: Position Sensing
Cannot be reached
-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels:| 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H05 0813
Serial number:
Coding: 000000
Shop #: WSC 09003 957 00200
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03710
ROD: EV_Immo_UDS_VDD_RM09.rod
VCID: 6ADA4A9B8D49571F27-803E
No fault code found.
-------------------------------------------------------------------------------
Address 2E: Media Player 3
Cannot be reached
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 561 959 701 HW: 3C0 959 793 B
Component: TUER-SG FT 002 0525
Revision: 13110009 Serial number: 0009492876
Coding: 0404B5
Shop #: WSC 09003 957 00200
ASAM Dataset: EV_TSGFPQ25BRFVW46X A04001
ROD: EV_TSGFPQ25BRFVW46X.rod
VCID: 5BB41F5F52133E97AC-800E
Slave Driver:
Subsystem 1 - Part No SW: 561 959 811 B HW: 561 959 811 B Labels: 1K0-959-70X-GEN4.CLB
Component: J388__TSG_HL 006 5470
Serial number: 14202630150417191230
Coding: 800000
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1K0-909-14x-GEN3.clb
Part No: 1K0 909 144 R
Component: EPS_ZFLS Kl. 215 3501
Revision: 00H22000
Shop #: WSC 01357 011 00200
VCID: 3978A5D7706F2C879E-806C
No fault code found.
-------------------------------------------------------------------------------
Address 4F: Centr. Electr. II (J520) Labels:. 1K0-907-532.clb
Part No SW: 7N0 907 532 HW: 7N0 907 530 AM
Component: EZE_2 H55 1653
Revision: H55 Serial number: 30031503000942
Coding: 01030108
Shop #: WSC 09003 957 00200
VCID: 6FEC5B8FBEABB23770-803A
Subsystem 1 - Part No SW: 561 959 591 A HW: 561 959 591 A
Component: J245 P05 9BA3 H08 0005
Serial number: 53388786011433300690
Coding: 181100
Subsystem 2 - Part No SW: 561 919 204 B HW: 561 919 204 B
Component: Analoguhr 009 0005
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 561 959 702 HW: 3C0 959 792 B
Component: TUER-SG BT 002 0525
Revision: 15110009 Serial number: 0009434365
Coding: 0404B4
Shop #: WSC 09003 957 00200
ASAM Dataset: EV_TSGBPQ25BRFVW46X A04001
ROD: EV_TSGBPQ25BRFVW46X.rod
VCID: 5CB61C43571D39AFA5-8008
Slave Passenger:
Subsystem 1 - Part No SW: 561 959 812 B HW: 561 959 812 B Labels: 1K0-959-70X-GEN4.CLB
Component: J389__TSG_HR 006 5470
Serial number: 14102631150417110200
Coding: 800000
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (J503) Labels:. 5M0-035-1xx-56.clb
Part No SW: 1K0 035 188 F HW: 1K0 035 188 F
Component: Radio Prem-8 H08 0009
Revision: -----13S Serial number: VWZ4Z7R3697294
Coding: 0100044004000B
Shop #: WSC 09003 957 00200
VCID: 2B548F9F4A338E171C-807E
1 Fault Found:
02635 - Tuner Not Enabled/Activated
000 - -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 7
Fault Frequency: 2
Reset counter: 169
Mileage: 167927 km
Time Indication: 0
Date: 2019.04.10
Time: 16:03:45
-------------------------------------------------------------------------------
Address 75: Telematics (J949) Labels:| 12E-035-284.clb
Part No SW: 561 035 285 A HW: 561 035 285 A
Component: OCULowUSA 020 0156
Serial number: 000003554140536
Coding: 02140102C21632007F1606C00000
Shop #: WSC 09003 957 00200
ASAM Dataset: EV_OCULow 002009
ROD: EV_OCULow_002.rod
VCID: 14263463FF4D31EF2D-8040
No fault code found.
-------------------------------------------------------------------------------
Address 77: Telephone (J412) Labels:| 5N0-035-729.clb
Part No SW: 5N0 035 729 E HW: 5N0 035 729 E
Component: TELEFON H07 0593
Revision: 1B001001 Serial number: 00007670129560
Coding: 0A10030080010110
Shop #: WSC 09003 957 00200
ASAM Dataset: EV_UHVUMI 001007
ROD: EV_UHVUMI.rod
VCID: 326A92FB6519DFDF5F-8066
No fault code found.
Thank you!