Transporter 2011, 2.0 biTdi 4motion CFCA engine. 171000 miles.
Had dpf light and coil light come on whilst driving to airport (150miles). Limp mode.
Had vw roadside assistance come out, ws blocked dpf filter ( and dpf pressure differential sensor pipe), turbo pressure too low. Fault codes p02cb00 and P246300.
He cleared pipe, tested G450 sensor, manual regen of dpf. Has new MAP sensor.
It cleared the dpf fault but the low boost still returns after about 1/2 a mile.
Full auto scan
scan of fault code
Was thinking it could be clogged up wastegate with soot or issue with wastegate actuator?
Gonna try and get under van today and check both actuators move from end to end using
hand vacuum pump.
Whats your thinkings?
Had dpf light and coil light come on whilst driving to airport (150miles). Limp mode.
Had vw roadside assistance come out, ws blocked dpf filter ( and dpf pressure differential sensor pipe), turbo pressure too low. Fault codes p02cb00 and P246300.
He cleared pipe, tested G450 sensor, manual regen of dpf. Has new MAP sensor.
It cleared the dpf fault but the low boost still returns after about 1/2 a mile.
Full auto scan
Code:
Saturday,07,September,2019,07:53:24:16358
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x86
VCDS Version: 19.6.0.2
Data version: 20190529 DS308.0
www.Ross-Tech.com
VIN: WV1ZZZ7HZBH070165 License Plate: ND60RJO
Mileage: 275630km-171268mi Repair Order:
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: 7H-VN75 (6N0)
Scan: 01 02 03 04 08 09 15 17 19 22 25 56 69 0B
VIN: WV1ZZZ7HZBH070165 Mileage: 275630km-171268miles
01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
22-AWD -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
56-Radio -- Status: OK 0000
69-Trailer -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CFCA) Labels:. 03L-906-022-CFC.clb
Part No SW: 03L 906 022 JE HW: 03L 907 309 H
Component: R4 2,0L EDC H34 9970
Revision: 22H34--- Serial number: 00000000000000
Coding: 01254012231600080000
Shop #: WSC 81903 210 00000
ASAM Dataset: EV_ECM20BTD01103L906022JE 002009
ROD: EV_ECM20BTD01103L906022JD_002.rod
VCID: 71E9A2EDA096FCC76E-8024
1 Fault Found:
11895 - Turbo / Supercharger B
P02CB 00 [101] - Pressure too Low
Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 275624 km
Date: 2019.09.06
Time: 13:40:49
Engine speed: 2638.00 /min
Normed load value: 89.4 %
Vehicle speed: 74 km/h
Coolant temperature: 98 C
Intake air temperature: 35 C
Ambient air pressure: 1010 mbar
Voltage terminal 30: 13.780 V
Unlearning counter according OBD: 40
Charge air pressure specified value: 2532 hPa
Charge air pressure: actual value: 2427.6 hPa
Air mass: actual value (mg/stroke): 1033.6 mg/stroke
Air cleaner degree of soiling: 18.27 %
Throttle valve adapter: actual value: 64.50 %
Bypass valve f high press turboch turbine inlet: actual value: 98.01 %
Mean injection quantity: 52.89 mg/stroke
Readiness: 0 0 0 0 0
-------------------------------------------------------------------------------
Address 02: Auto Trans (J743) Labels:. 0BH-927-711.clb
Part No SW: 0BT 300 011 Q HW: 0BH 927 711 C
Component: DSG DQ500-7A H08 2258
Revision: 00H08V01
Coding: 0014
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_TCMDQ500021 001001
ROD: EV_TCMDQ500021_VW36.rod
VCID: 3C7743D9B75441AF8D-8068
No fault code found.
-------------------------------------------------------------------------------
Address 03: ABS Brakes (-----) Labels: 7E0-907-37x-MK25AXT.clb
Part No SW: 7E0 907 379 G HW: 7E0 907 379 E
Component: ESP MK25A XT H43 0105
Revision: 00H43001
Coding: 508764AD99AB0A9526A39977A96316
Shop #: WSC 02736 790 49152
VCID: 366351F181789BFF7B-8062
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301) Labels:| 7E5-907-047.clb
Part No SW: 7E5 907 047 AL HW: 7E5 907 047 AL
Component: Climatic-T5 H11 0203
Revision: 00005001
Coding: 0000000002
Shop #: WSC 02737 790 50316
ASAM Dataset: EV_ClimaticT5 A01003
ROD: EV_ClimaT5Basis.rod
VCID: 79F99ACDF8E6B487D6-802C
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 7H0-937-08x-09.clb
Part No SW: 7H0 937 087 F HW: 7H0 937 087
Component: BCM T5GP H+4 H47 0230
Revision: BO047001 Serial number: 0396 321100593
Coding: A0A0393A0E212013002008102C2B8C540000430F60044000300000000000
Shop #: WSC 02734 790 00000
VCID: 377D5CF5867262F760-8062
Subsystem 1 - Part No SW: 7E0 959 801 C HW: 7E0 959 801 C Labels: 7E0-959-80X-V1.CLB
Component: J386__TSG_FT 003 3311
Serial number: --------------------
Coding: 050000
Subsystem 2 - Part No SW: 7E0 959 802 C HW: 7E0 959 802 C Labels: 7E0-959-80X-V1.CLB
Component: J387__TSG_BT 003 3311
Serial number: --------------------
Coding: 040000
1 Fault Found:
03303 - Response Closing Status of Rear Left Door
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 2
Fault Frequency: 3
Reset counter: 27
Mileage: 275632 km
Time Indication: 0
Date: 2014.01.27
Time: 21:28:05
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:| 5K0-959-655.clb
Part No SW: 7E0 959 655 B HW: 7E0 959 655 B
Component: VW10Airbag009 H06 0013
Revision: -------- Serial number: 003HL002H9WF
Coding: 000000000000000000000000000000003039
Shop #: WSC 02734 790 50316
ASAM Dataset: EV_AirbaVW10BPAVN750 A01026
ROD: EV_AirbaVW10BPAVN750_VW12.rod
VCID: 356156FD947E90E772-8060
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5K0-920-xxx-17.clb-SRI1
Part No SW: 7E0 920 960 CX HW: 7E0 920 960 CX
Component: KOMBI H04 0204
Serial number: 00000000000000
Coding: 460300
Shop #: WSC 51034 001 1048576
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04086
ROD: EV_Kombi_UDS_VDD_RM09_004_VW32.rod
VCID: 0109F22D9036EC479E-8054
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 6N0-909-901-6R.clb
Part No SW: 6N0 909 901 HW: 7H0 937 087
Component: GW-K-CAN TP20 0230
Coding: 042300
Shop #: WSC 02734 790 00000
VCID: 70EFA7E9A39CF5CF61-8024
No fault code found.
-------------------------------------------------------------------------------
Address 22: AWD Labels: 0AY-907-554-V1.clb
Part No SW: 09N 907 554 B HW: 09N 907 554 B
Component: Haldex 4Motion 6008
Coding: 0000002
Shop #: WSC 02748 790 00000
VCID: 377D5CF5467262F760-8062
No fault code found.
-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels:| 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H04 0204
Serial number: 00000000000000
Coding: 000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03008
ROD: EV_Immo_UDS_VDD_RM09.rod
VCID: 6ADBB5818D400F1F2F-803E
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (J503) Labels:. 5M0-035-1xx-56.clb
Part No SW: 5M0 035 186 AA HW: 5M0 035 186 AA
Component: Radio RCD310 016 0049
Revision: 01000000 Serial number: VWZ1Z2K8556967
Coding: 0500020002
Shop #: WSC 02734 790 00000
VCID: 6BD5B0858ABA161754-803E
No fault code found.
-------------------------------------------------------------------------------
Address 69: Trailer (J345) Labels:. 1K0-907-383-V2.clb
Part No SW: 1K0 907 383 F HW: 1K0 907 383 F
Component: Anhaenger H09 0100
Revision: 3A001001 Serial number: 00000137824167
Coding: 410D000100000000
Shop #: WSC 02736 790 00000
VCID: 306F67E9631CB5CF21-8064
No fault code found.
End-------------------------(Elapsed Time: 03:05)--------------------------scan of fault code
Code:
Saturday,07,September,2019,12:45:54:16358
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x86
VCDS Version: 19.6.0.2
Data version: 20190529 DS308.0
www.Ross-Tech.com
VIN: WV1ZZZ7HZBH070165 License Plate: ND60RJO
Address 01: Engine Labels: 03L-906-022-CFC.clb
Control Module Part Number: 03L 906 022 JE HW: 03L 907 309 H
Component and/or Version: R4 2,0L EDC H34 9970
Software Coding: 01254012231600080000
Work Shop Code: WSC 81903 210 00000
ASAM Dataset: EV_ECM20BTD01103L906022JE 002009 (VN75)
ROD: EV_ECM20BTD01103L906022JD_002.rod
VCID: 71E9A2EDA096FCC76E-8024
1 Fault Found:
11895 - Turbo / Supercharger B
P02CB 00 [167] - Pressure too Low
MIL ON - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 275633 km
Date: 2019.09.07
Time: 11:11:59
Engine speed: 2601.50 /min
Normed load value: 77.6 %
Vehicle speed: 67 km/h
Coolant temperature: 51 C
Intake air temperature: 31 C
Ambient air pressure: 1010 mbar
Voltage terminal 30: 14.180 V
Unlearning counter according OBD: 40
Charge air pressure specified value: 2625 hPa
Charge air pressure: actual value: 2363.2 hPa
Air mass: actual value (mg/stroke): 1044.7 mg/stroke
Air cleaner degree of soiling: 18.08 %
Throttle valve adapter: actual value: 99.62 %
Bypass valve f high press turboch turbine inlet: actual value: 99.08 %
Mean injection quantity: 44.33 mg/stroke
Readiness: N/AWas thinking it could be clogged up wastegate with soot or issue with wastegate actuator?
Gonna try and get under van today and check both actuators move from end to end using
hand vacuum pump.
Whats your thinkings?
