Hello,
I have three questions for the community, highlighted in bold below.
First, the basics: 2016 Tiguan S with 4-motion, 2.0L 6-speed automatic transmission. I had the Stage I ECU upgrade installed from APR set at 93 Octane. Odometer is currently at 42,000 miles.
I just followed all the steps to change the ATF:
- Took out the drain plug and stand pipe and drained the old ATF
- Removed ATF pan, replaced filter and gasket, reinstalled
- Put the stand pipe back in
- Pumped in about 5-6 quarts of ATF
- Had the wife start the car and start cycling through R, D, S, and manual mode 1 and 2, and back to park
- As she cycled through I pumped in another quart
- After she cycled twice she left it in park with engine running and foot on the brake
- When VCDS displayed 40 degrees Celsius ATF temperature, I removed the pump adapter and let the ATF trickle back out
- When it stopped trickling and only lightly drizzled I replaced the drain plug with a new crush washer
- Car in park, I checked for leaks
- Drove the car around and parked it again, engine running, checked for leaks again
Question 1: Did I do that all right?
Question 2: If I screwed it up, how will I know? Will the shifting start to act funny? Will the ATF temperature exceed a certain temperature while driving? Will everything seem fine and then BAM! the tranny explodes while my wife is driving our daughter?
When I test drove it the shifting seemed totally fine. The ATF temperature never exceeded 60 degrees Celsius during my short test run.
I ran the auto scan while parked with engine running after the test run.
Question 3: Why is there a malfunction in Central Electronics (Line 9)? Could it have something to do with APR installing a custom flash for the ECU?
I would sincerely appreciate any insight into my three questions. I am but a humble DIY guy trying to save money by doing my own maintenance. I was dumbfounded when I found out the procedure for my vehicle.
Thank you,
Theo
I have three questions for the community, highlighted in bold below.
First, the basics: 2016 Tiguan S with 4-motion, 2.0L 6-speed automatic transmission. I had the Stage I ECU upgrade installed from APR set at 93 Octane. Odometer is currently at 42,000 miles.
I just followed all the steps to change the ATF:
- Took out the drain plug and stand pipe and drained the old ATF
- Removed ATF pan, replaced filter and gasket, reinstalled
- Put the stand pipe back in
- Pumped in about 5-6 quarts of ATF
- Had the wife start the car and start cycling through R, D, S, and manual mode 1 and 2, and back to park
- As she cycled through I pumped in another quart
- After she cycled twice she left it in park with engine running and foot on the brake
- When VCDS displayed 40 degrees Celsius ATF temperature, I removed the pump adapter and let the ATF trickle back out
- When it stopped trickling and only lightly drizzled I replaced the drain plug with a new crush washer
- Car in park, I checked for leaks
- Drove the car around and parked it again, engine running, checked for leaks again
Question 1: Did I do that all right?
Question 2: If I screwed it up, how will I know? Will the shifting start to act funny? Will the ATF temperature exceed a certain temperature while driving? Will everything seem fine and then BAM! the tranny explodes while my wife is driving our daughter?
When I test drove it the shifting seemed totally fine. The ATF temperature never exceeded 60 degrees Celsius during my short test run.
I ran the auto scan while parked with engine running after the test run.
Question 3: Why is there a malfunction in Central Electronics (Line 9)? Could it have something to do with APR installing a custom flash for the ECU?
I would sincerely appreciate any insight into my three questions. I am but a humble DIY guy trying to save money by doing my own maintenance. I was dumbfounded when I found out the procedure for my vehicle.
Thank you,
Theo
Code:
Wednesday,07,August,2019,17:46:38:43947
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 19.6.1.0 (x64) HEX-V2 CB: 0.4508.4
Data version: 20190529 DS308.0
www.Ross-Tech.com
VIN: WVGBV7AX3GW577137 License Plate:
Chassis Type: AX-VW36 (7N0)
Scan: 01 02 03 05 08 09 15 16 17 19 22 25 2B 42 44 46 4C 52 53 5F
62 72
VIN: WVGBV7AX3GW577137 Mileage: 68930km-42831miles
01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
22-AWD -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
2B-Steer. Col. Lock -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
4C-Tire Pressure II -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
5F-Information Electr. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (CCT) Labels:. 06J-906-026-CCT.clb
Part No SW: 06J 906 027 JP HW: 06J 907 309 A
Component: MED17.5.2 TFSI 2 06 1335
Revision: P3H08--- Serial number:
Coding: 0423010A190F0160
Shop #: WSC 01357 011 00200
VCID: 025D8A716805ABA7DCD-8056
No fault code found.
Readiness: 0000 0000
-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 09G-927-750.clb
Part No SW: 09G 927 750 NK HW: 09G 927 750 NK
Component: AQ 250 6F 2627
Revision: 00H97000 Serial number:
Coding: 0000840
Shop #: WSC 01357 011 00200
VCID: 074B9B6543278E8F8B3-8052
No fault code found.
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 5N0-614-109-C6.clb
Part No SW: 5N0 614 109 BN HW: 5N0 614 109 BN
Component: J104 C6 450M VDF7 0021
Revision: --H07--- Serial number: 00000009076993
Coding: 0005161
Shop #: WSC 01357 011 00200
VCID: 78A9E8993ED9F177F29-802C
No fault code found.
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J518) Labels:| 5K0-959-434.clb
Part No SW: 5K0 959 434 E HW: 5K0 959 434
Component: VWKESSYPQ35GP 092 1202
Revision: 00092000 Serial number: 0389948687
Coding: 030C0C
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_KESSYPQ35G A02717
ROD: EV_KESSYPQ35G_A02_VW31.rod
VCID: 372B2BA57FC73E0F3B3-8062
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301) Labels:| 3C8-907-336.clb
Part No SW: 561 907 426 G HW: 561 907 426 G
Component: AC Manuell H03 0506
Revision: 00001K02
Coding: 0010001002
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_ACManuaElectGen2BHTC 001002
ROD: EV_ACManuaElectGen2BHTC_VW36.rod
VCID: 1F1BE305F737664FD33-804A
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 1K0-937-08x-09.clb
Part No SW: 5K0 937 084 N HW: 5K0 937 084 N
Component: BCM PQ35 B 122 0183
Revision: BG122001
Coding: EF1A0A1B80232EC4008800C11400044448510086566D8DF064800000A040
Shop #: WSC 01357 011 00200
VCID: 3D27398D5D7B145FE1F-8068
Subsystem 1 - Part No SW: 5N1 955 119 B HW: 5N1 955 119 B Labels: 1KX-955-119.CLB
Component: WWS316 301115 24 0664
Coding: 009795
Subsystem 2 - Part No: 1K0 955 559 AH Labels: 1K0-955-559-AG.CLB
Component: RLS 221215 05 54 0403
Coding: 02304D
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 5N0-959-655.lbl
Part No SW: 5N0 959 655 AB HW: 5N0 959 655 AB
Component: J234__005 VW10 HI 5418
Revision: 36023000 Serial number: 003MAPRJW2R
Coding: 0012341
Shop #: WSC 01357 011 00200
VCID: 7DA7F98D11FBD45FA1F-8028
Subsystem 1 - Part No: 5N0 959 339 B
Component: BF-Gewichtsens. 003 0001
Subsystem 2 - Serial number: 0000000000RLSP
Subsystem 3 - Serial number: 0026.10.150000300000650008ÿ†63
Subsystem 4 - Serial number: 650008ÿ†6332MTS605663125+ÿ†63
Subsystem 5 - Serial number: 63125+ÿ†6342MTS6074931252ÿ†63
Subsystem 6 - Serial number: 931252ÿ†6351HTS6MPLA4EKJFÿ†63
Subsystem 7 - Serial number: A4EKJFÿ†6361HTS69R1P1EKR5ÿ†63
Subsystem 8 - Serial number: P1EKR5ÿ†63727TS6JEIPSDKJTÿ†63
Subsystem 9 - Serial number: PSDKJTÿ†63827TS6HH3C3EKJMÿ
Subsystem 10 - Serial number: C3EKJMÿ
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels:| 5K0-953-569.clb
Part No SW: 5K0 953 501 DM HW: 5K0 953 569 AP
Component: LENKS.MODUL 016 0180
Revision: FF010042 Serial number: 20151211300400
Coding: 1102140000
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_VW360SteerWheelUDS A03004
ROD: EV_VW360SteerWheelUDS.rod
VCID: 78A9E8993259F177F29-802C
Multifunction steering wheel control module:
Subsystem 1 - Part No SW: 5K0 959 542 C HW: 5K0 959 542 C Labels: 3C8-959-537.CLB
Component: E221__MFL-TAS H31 0037
Serial number: 0933302
Coding: 820000
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5K0-920-xxx-17.clb-SRI1
Part No SW: 5N0 920 973 L HW: 5N0 920 973 L
Component: KOMBI H04 1008
Serial number: 00000000000000
Coding: 211F010000
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A05730
ROD: EV_Kombi_UDS_VDD_RM09_005_VW25.rod
VCID: 3D27398D5DFB145FE1F-8068
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 7N0-907-530-V2.clb
Part No SW: 7N0 907 530 AT HW: 7N0 907 530 AK
Component: J533 Gateway H57 1663
Revision: H57 Serial number: 131215F1001318
Coding: 356022
Shop #: WSC 01357 011 00200
VCID: 025D8A716405ABA7DCD-8056
No fault code found.
-------------------------------------------------------------------------------
Address 22: AWD (J492) Labels:* 0CQ-907-554.clb
Part No SW: 0AY 907 554 J HW: 0CQ 525 130
Component: Haldex4Motion H52 7540
Serial number: HA1-00013.11.15
Coding: 0001
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_AllWheelContrHA1VW37X 002015
ROD: EV_AllWheelContrHA1VW37X.rod
VCID: 52FD7A31F465FB272CD-8006
No fault code found.
-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels:| 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5K0 953 234
Component: IMMO H04 1008
Serial number: 00000000000000
Coding: 000007
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03710
ROD: EV_Immo_UDS_VDD_RM09.rod
VCID: 6A8DC2D17CF553E774D-803E
No fault code found.
-------------------------------------------------------------------------------
Address 2B: Steer. Col. Lock (J764) Labels:* 5K0-905-861.clb
Part No SW: 5K0 905 861 C HW: 5K0 905 861 C
Component: ELV-PQ35 H21 0240
Revision: 00000000 Serial number: 15000260863003
Coding: 4900000000000000
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_ELVMarquMPVW36X A01001
ROD: EV_ELVMarquMPVW36X.rod
VCID: 303910B99AA9E9377A9-8064
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 5N0 959 701 H HW: 3C0 959 793 H
Component: TUER-SG FT 002 0601
Revision: 13100010 Serial number: 0010169822
Coding: 0004B4
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_TSGFPQ35BRFVW46X A04004
ROD: EV_TSGFPQ35BRFVW46X_VW36.rod
VCID: 3A2D32914CD52367C4D-806E
Slave Driver:
Subsystem 1 - Part No SW: 5N0 959 703 G HW: 3C0 959 794 D Labels: 1K0-959-70X-GEN4.CLB
Component: J388__TSG-HL 010 1505
Serial number: 00000009635653
Coding: 000490
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 5N1-909-144.clb
Part No SW: 5N1 909 144 R HW: 5N1 909 148 J
Component: J500__APA-BS KL.285 1401
Revision: 1BH04841 Serial number: 00153270164201
Coding: 0000258
Shop #: WSC 01357 011 00200
VCID: 41DF457D2D8370BF857-8014
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 5N0 959 702 F HW: 3C0 959 792 B
Component: TUER-SG BT 002 0503
Revision: 15110009 Serial number: 0010266599
Coding: 0004B4
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_TSGBPQ35BRFVW46X A04001
ROD: EV_TSGBPQ35BRFVW46X_VW36.rod
VCID: 392F2D9D49D3287FCD7-806C
Slave Passenger:
Subsystem 1 - Part No SW: 5N0 959 704 G HW: 3C0 959 795 D Labels: 1K0-959-70X-GEN4.CLB
Component: J389__TSG-HR 010 1505
Serial number: 00000009647861
Coding: 000490
No fault code found.
-------------------------------------------------------------------------------
Address 53: Parking Brake Labels: 3AA-907-801.clb
Part No SW: 3AA 907 801 J HW: 3AA 907 801 J
Component: J540 EPB4 VW-63206 0012
Revision: H19 Serial number: 00000000980834
Coding: 0026156
Shop #: WSC 01357 011 00200
VCID: 382928997E593177329-806C
No fault code found.
-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794) Labels:| 5G0-035-MIB-ENT2.clb
Part No SW: 561 035 150 HW: 561 035 150
Component: MU-E--US 857 6495
Serial number: 04121500011967
Coding: 02130600FF00000041220001001000001F0000D40000010000
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_MUEnt4CGen2LGE 001025
ROD: EV_MUEnt4CGen2LGE_VW12.rod
VCID: 4ACD62511C35B3E754D-801E
No fault code found.
End----------(Elapsed Time: 01:22, VBatt start/end: 13.5V/13.6V)-----------
Last edited: