Results 1 to 6 of 6

Thread: 2006 D3 S8 V10 Lean Codes please help

  1. #1
    Verified VCDS User
    Join Date
    Jul 2017
    Location
    Scarborough, UK
    Posts
    7
    Post Thanks / Like

    2006 D3 S8 V10 Lean Codes please help

    Hello folks,

    I have been trying to resolve a rough idling and misfire issue with my S8 for AGES.

    After much figuring out the following jobs are completed and Fault codes present. any guidance would be greatly appreciated.

    Completed previously (engine related): two years ago: all filters, coil packs and platinum plugs, both MAF sensors, vacuum lines, Secondary Air valves and blower.
    Completed recently: fuel filter, carbon clean with all new gaskets, inlet manifold still ok - not touched, all fuel injectors serviced/replaced, new upstream lambda sensors Bank 2 and bank 4. Vacuum lines replaced, VCDS all green results on Readiness screen.

    Present engine fault codes:
    Bank 1; System too Lean at Idle P2187 - 004
    Bank 3; Mixture Regulation; Bank 3; Range 1 P1081 - 004 - Lean Limit Exceeded - MIL ON
    Bank 4; Mixture Regulation; Bank 4; Range 1 P1085 - 004 - Lean Limit Exceeded

    Comments: The MIL only comes ON after aggressive acceleration. long drives over a couple days has no Fault codes stored.
    The crankcase vacuum is tremendous - I cannot remove the Oil filler cap with the engine at Idle. Is this normal?
    I only apply Castrol Edge 5w 30 fully synthetic and replace this oil annually despite minimum mileage<4k / annum.
    Fuel is only 98 Octane (shell).


    Here is the recent VCDS Logfile:

    Code:
    Sunday,21,July,2019,13:16:06:60735
    VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
    VCDS Version: 19.6.0.6 (x64)  HEX-V2 CB: 0.4508.4
    Data version: 20190529 DS308.0
    www.Ross-Tech.com
    
    
    VIN: WAUZZZ4E67N003566   License Plate: AD06 YMC
    Mileage: 218050km-135489mi   Repair Order: TOO LEAN
    
    
    
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Chassis Type: 4E (4L0)
    Scan: 01 02 03 05 06 07 08 09 11 31 15 16 17 19 1D 1E 28 34 36 37
              38 42 46 47 4F 52 53 55 56 57 61 62 65 67 6C 72 76 77
    
    VIN: WAUZZZ4E67N003566   Mileage: 218050km-135489miles
    
    00-Steering Angle Sensor -- Status: OK 0000
    01-Engine -- Status: Malfunction 0010
    02-Auto Trans -- Status: OK 0000
    03-ABS Brakes -- Status: OK 0000
    05-Acc/Start Auth. -- Status: OK 0000
    06-Seat Mem. Pass -- Status: OK 0000
    07-Control Head -- Status: OK 0000
    08-Auto HVAC -- Status: Malfunction 0010
    09-Cent. Elect. -- Status: OK 0000
    11-Engine II -- Status: Malfunction 0010
    31-Engine other -- Status: Malfunction 0010
    15-Airbags -- Status: OK 0000
    16-Steering wheel -- Status: OK 0000
    17-Instruments -- Status: OK 0000
    19-CAN Gateway -- Status: Malfunction 0010
    1D-Driver Ident. -- Status: OK 0000
    1E-Media Player 2 -- Status: OK 0000
    28-HVAC, Rear -- Status: Malfunction 0010
    34-Level Control -- Status: OK 0000
    36-Seat Mem. Drvr -- Status: OK 0000
    37-Navigation -- Status: OK 0000
    38-Roof Electronics -- Status: OK 0000
    42-Door Elect, Driver -- Status: OK 0000
    46-Central Conv. -- Status: OK 0000
    47-Sound System -- Status: OK 0000
    4F-Centr. Electr. II -- Status: OK 0000
    52-Door Elect, Pass. -- Status: OK 0000
    53-Parking Brake -- Status: OK 0000
    55-Headlight Range -- Status: OK 0000
    56-Radio -- Status: OK 0000
    57-TV Tuner -- Status: Malfunction 0010
    61-Battery Regul. -- Status: OK 0000
    62-Door, Rear Left -- Status: OK 0000
    65-Tire Pressure -- Status: OK 0000
    67-Voice Control -- Status: OK 0000
    6C-Back-up Cam. -- Status: OK 0000
    72-Door, Rear Right -- Status: OK 0000
    76-Park Assist -- Status: OK 0000
    77-Telephone -- Status: Not registered 0011
    -------------------------------------------------------------------------------
    Address 01: Engine        Labels: Redir Fail!
       Part No SW: 4E0 910 552     HW: 4E0 907 552 
       Component: 5.2L V10/4V FSI    ª0060  
       Revision: 5AH11---    Serial number: AUX3Z0F5397064
       Coding: 01060003190F0160
       Shop #: WSC 54321 123 12345
       VCID: 5F98AA22BB334F0F93F-800A
    
    2 Faults Found:
    008583 - Bank 1; System too Lean at Idle 
                   P2187 - 004 - 
                 Freeze Frame:
                        Fault Status: 01100100
                        Fault Priority: 0
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 218042 km
                        Time Indication: 0
                        Date: 2019.07.21
                        Time: 11:18:04
    
                 Freeze Frame:
                        RPM: 669 /min
                        Load: 21.6 %
                        Speed: 0.0 km/h
                        Temperature: 102.0°C
                        Temperature: 33.0°C
                        Absolute Pres.: 1000.0 mbar
                        Voltage: 14.351 V
    
    006435 - Please Check DTC Memory of ECU Number 2 
                   P1923 - 008 - 
                 Freeze Frame:
                        Fault Status: 01101000
                        Fault Priority: 0
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 218059 km
                        Time Indication: 0
    
                 Freeze Frame:
                        RPM: 0 /min
                        Load: 0.0 %
                        Speed: 0.0 km/h
                        Temperature: 107.0°C
                        Temperature: 50.0°C
                        Absolute Pres.: 1010.0 mbar
                        Voltage: 12.065 V
    
    Readiness: 0000 1001
    
    -------------------------------------------------------------------------------
    Address 02: Auto Trans        Labels: 09E-927-156.lbl
       Part No SW: 4E1 910 156 K    HW: 09E 927 156 B
       Component: AG6 09E 5,2 FSI RdW 0020  
       Revision: --H01---    Serial number:        0087677
       Coding: 0000001
       Shop #: WSC 02313 785 00200
       VCID: 2B000EF2BF0BE3AF4F7-807E
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 03: ABS Brakes        Labels: 4E0-910-517.lbl
       Part No SW: 4E0 910 517 D    HW: 4E0 614 517 AB
       Component: ESP 5.7 allrad  H46 0500  
       Coding: 0001627
       Shop #: WSC 02313 000 00000
       VCID: 2412E5CED2D52CD78ED-8070
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 05: Acc/Start Auth.        Labels: 4E0-910-131.lbl
       Part No SW: 4E0 910 131     HW: 4E0 909 131 K
       Component:     FBS AUDID3  H10 0190  
       Revision: 01904910    Serial number: AUX3Z0F5397064
       Coding: 0412672
       Shop #: WSC 02311 785 00200
       VCID: 58EA813EDE1DB837D25-800C
    
       Subsystem 1 - Part No: XXXXXXXXXXX 
       Component: ELV                 XXXX
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 06: Seat Mem. Pass        Labels: None
       Part No SW: 4E0 910 760 D    HW: 4E0 959 760 B
       Component: Sitzmemory BFS H02  0010  
       Revision: 00000000    Serial number: 5DS 008 795-03
       Coding: 4063328
       Shop #: WSC 02313 785 00200
       VCID: 2412E5CED2D52CD78ED-8070
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 07: Control Head        Labels: 4E0-910-7xx-07.clb
       Part No SW: 4E0 910 731 G    HW: 4E0 035 729 A
       Component: Interfacebox    H43 2830  
       Revision: 00000000    Serial number: 300FZ067568958
       Coding: 0000002
       Shop #: WSC 00000 000 08192
       VCID: 2514F8CAD9EFD5DF993-8070
    
       Subsystem 1 - Part No: 4E0 910 611 
       Component: E0380 BedienteilH03 0040
    
       Subsystem 2 - Serial number: 00000000013248
    
       Subsystem 3 - Serial number: 0130.06.060000000100010002ÿ
    
       Subsystem 4 - Serial number: 010002ÿ
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 08: Auto HVAC        Labels: None
       Part No SW: 4E0 910 043 B    HW: 4E0 820 043 G
       Component: KLIMAAUTOMAT    017 0450  
       Revision: 00000032    Serial number: 00000000100165
       Coding: 0123001
       Shop #: WSC 02311 785 00200
       VCID: 1C62DD2EEAA5141736D-8048
    
    6 Faults Found:
    00714 - Centre Right Vent Positioning Motor (V111) 
                003 - Mechanical Failure
                 Freeze Frame:
                        Fault Status: 01100011
                        Fault Priority: 3
                        Fault Frequency: 3
                        Reset counter: 230
                        Mileage: 218016 km
                        Time Indication: 0
                        Date: 2019.07.20
                        Time: 19:22:06
    
                 Freeze Frame:
                        Voltage: 11.90 V
                        Temperature: 25.0°C
                        (no units): 196.0
                        (no units): 195.0
                        Temperature: 52.0°C
    
    01592 - Air Quality Sensor (G238) 
                010 - Open or Short to Plus
                 Freeze Frame:
                        Fault Status: 01101010
                        Fault Priority: 3
                        Fault Frequency: 1
                        Reset counter: 229
                        Mileage: 218016 km
                        Time Indication: 0
                        Date: 2019.07.20
                        Time: 19:22:08
    
                 Freeze Frame:
                        Temperature: 45.0°C
    
    01858 - Air Outlet Sensor; Right Center (G348) 
                010 - Open or Short to Plus
                 Freeze Frame:
                        Fault Status: 01101010
                        Fault Priority: 3
                        Fault Frequency: 1
                        Reset counter: 229
                        Mileage: 218016 km
                        Time Indication: 0
                        Date: 2019.07.20
                        Time: 19:22:08
    
    00065 - Rear Left Footwell Heater (Z42) 
                004 - No Signal/Communication
                 Freeze Frame:
                        Fault Status: 01100100
                        Fault Priority: 3
                        Fault Frequency: 1
                        Reset counter: 229
                        Mileage: 218016 km
                        Time Indication: 0
                        Date: 2019.07.20
                        Time: 19:22:09
    
                 Freeze Frame:
                        Voltage: 11.90 V
    
    00066 - Rear Right Footwell Heater (Z43) 
                004 - No Signal/Communication
                 Freeze Frame:
                        Fault Status: 01100100
                        Fault Priority: 3
                        Fault Frequency: 1
                        Reset counter: 229
                        Mileage: 218016 km
                        Time Indication: 0
                        Date: 2019.07.20
                        Time: 19:22:09
    
                 Freeze Frame:
                        Voltage: 11.90 V
    
    00565 - Rear A/C Control Head (Climatronic) (E265) 
                013 - Check DTC Memory
                 Freeze Frame:
                        Fault Status: 00000100
                        Fault Priority: 5
                        Fault Frequency: 1
                        Reset counter: 232
                        Mileage: 202614 km
                        Time Indication: 0
                        Date: 2017.02.07
                        Time: 00:04:19
    
                 Freeze Frame:
                            ON
    
    
    -------------------------------------------------------------------------------
    Address 09: Cent. Elect.        Labels: 4E0-910-279.clb
       Part No SW: 4E0 910 279 Q    HW: 4E0 907 279 Q
       Component: ILM Fahrer      H15 0230  
       Coding: 0133121
       Shop #: WSC 02313 785 00200
       VCID: 36362F867449AE47209-8062
    
       Subsystem 1 - Part No: 4E2 910 113 B
       Component: Wischer WWS D3  H50 0420  
       Coding: 00000035
       Shop #: WSC 02313  
    
       Subsystem 2 - Part No: 4E0 910 557 A  Labels: 8K0-955-559.CLB
       Component: REGENLICHTSENSORH13 0090  
       Coding: 04336190
       Shop #: WSC 02313  
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 11: Engine II        Labels: Redir Fail!
       Part No SW: 4E0 910 552     HW: 4E0 907 552 
       Component: 5.2L V10/4V FSI    ª0060  
       Revision: 5AH11---    Serial number: AUX3Z0F5397064
       Coding: 01060003190F0160
       Shop #: WSC 00673 210 83197
       VCID: 5F98AA22BB334F0F93F-800A
    
    2 Faults Found:
    004225 - Mixture Regulation; Bank 3; Range 1 
                   P1081 - 004 - Lean Limit Exceeded - MIL ON
                 Freeze Frame:
                        Fault Status: 11100100
                        Fault Priority: 0
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 218034 km
                        Time Indication: 0
                        Date: 2019.07.21
                        Time: 10:30:47
    
                 Freeze Frame:
                        RPM: 668 /min
                        Load: 14.1 %
                        Speed: 0.0 km/h
                        Temperature: 99.0°C
                        Temperature: 30.0°C
                        Absolute Pres.: 1010.0 mbar
                        Voltage: 14.351 V
    
    004229 - Mixture Regulation; Bank 4; Range 1 
                   P1085 - 004 - Lean Limit Exceeded
                 Freeze Frame:
                        Fault Status: 01100100
                        Fault Priority: 0
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 218046 km
                        Time Indication: 0
                        Date: 2019.07.21
                        Time: 11:37:55
    
                 Freeze Frame:
                        RPM: 642 /min
                        Load: 18.0 %
                        Speed: 0.0 km/h
                        Temperature: 93.0°C
                        Temperature: 45.0°C
                        Absolute Pres.: 1000.0 mbar
                        Voltage: 13.589 V
    
    
    -------------------------------------------------------------------------------
    Address 15: Airbags        Labels: 4E0-910-655-94.lbl
       Part No SW: 4E0 910 655 D    HW: 4E0 959 655 H
       Component:    Airbag 9.41  H13 3710  
       Revision: 91H13371    Serial number: 0037P000LLTK  
       Coding: 0431707
       Shop #: WSC 02313 785 00200
       VCID: 2708F2C2A3E3C7CFABF-8072
    
       Subsystem 1 - Serial number: 63328RB40149CA9BY
    
       Subsystem 2 - Serial number: 63428RB40149CA87U
    
       Subsystem 3 - Serial number: 63528RB40149CA45P
    
       Subsystem 4 - Serial number: 63628RB40149CB2BV
    
       Subsystem 5 - Serial number: 63729RB4015FE7D50
    
       Subsystem 6 - Serial number: 63829RB4015FE7BF9
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 16: Steering wheel        Labels: 4E0-910-549.lbl
       Part No SW: 4E0 910 549     HW: 4E0 953 549 
       Component: Lenksäulenmodul H14 0040  
       Coding: 0112141
       Shop #: WSC 02311 785 00200
       VCID: 6594B8CA996F15DF593-8030
    
       Subsystem 1 - Part No: XXXXXXXXXXX 
       Component: Lenkradmodul    H06 0030
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 17: Instruments        Labels: 4E0-910-xxx-17.lbl
       Part No SW: 4E0 910 951 E    HW: 4E0 920 951 E
       Component: KOMBIINSTR. VDO H82 0520  
       Revision: D03         Serial number: AUDID3F5000060
       Coding: 0048813
       Shop #: WSC 00586 210 91538
       VCID: 2708F2C2A3E3C7CFABF-8072
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 19: CAN Gateway        Labels:. 4L0-910-468.clb
       Part No SW: 4L0 910 468     HW: 4L0 907 468 
       Component: J533__Gateway   H06 0040  
       Revision: 00H06000    Serial number: 0900B0661581CD
       Coding: F5F5DFFF50661E
       Shop #: WSC 00751 210 93636
       VCID: 6C82CDEE7A85249706D-8038
    
    1 Fault Found:
    01044 - Control Module Incorrectly Coded 
                000 - -
                 Freeze Frame:
                        Fault Status: 01100000
                        Fault Priority: 1
                        Fault Frequency: 1
                        Reset counter: 229
                        Mileage: 218016 km
                        Time Indication: 0
                        Date: 2019.07.20
                        Time: 19:21:36
    
    
    -------------------------------------------------------------------------------
    Address 1D: Driver Ident.        Labels: 4E0-910-218.lbl
       Part No SW: 4E0 910 218 A    HW: 4E2 905 218 B
       Component: FPI_1           H01 0020  
       Revision: 01000102    Serial number: 28062006210124
       Shop #: WSC 00000 000 00000
       VCID: 1F18EA22FBB30F0FD3F-804A
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 1E: Media Player 2        Labels: 4E0-910-111.lbl
       Part No SW: 4E0 910 111 E    HW: 4E0 035 111 A
       Component: CD-Changer      H44 0430  
       Revision: 00000000    Serial number: AUZ5ZBE7207631
       Shop #: WSC 00000 000 00000
       VCID: 1B60DE32EFAB132F3F7-804E
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 28: HVAC, Rear        Labels: None
       Part No SW: 4E0 910 158     HW: 4E0 919 158 D
       Component: KLIMA-STG. FOND 017 0230  
       Revision: 00000019    Serial number: 00000000042851
       Coding: 0000000
       Shop #: WSC 00000 000 00000
       VCID: 619CACDA8D4779FFA5B-8034
    
    1 Fault Found:
    01866 - Rear Right Air Outlet Motor Position Sensor (G350) 
                007 - Short to Ground
    
    -------------------------------------------------------------------------------
    Address 34: Level Control        Labels: 4E0-910-553.clb
       Part No SW: 4E0 910 553 J    HW: 4E0 907 553 F
       Component: LUFTFDR.-CDC    H06 6310  
       Coding: 0015510
       Shop #: WSC 00409 210 01865
       VCID: 2A0E0BF6B0F1FAA7B41-807E
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 36: Seat Mem. Drvr        Labels: None
       Part No SW: 4E0 910 760 D    HW: 4E0 959 760 B
       Component: Sitzmemory FS  H02  0010  
       Revision: 00000000    Serial number: 5DS 008 795-03
       Coding: 4063342
       Shop #: WSC 02313 785 00200
       VCID: 2412E5CED2D52CD78ED-8070
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 37: Navigation        Labels: 4E0-910-88x-37.lbl
       Part No SW: 4E0 910 888 P    HW: 4E0 919 887 D
       Component: MNS ECE         H48 1060  
       Revision: 00000000    Serial number: 364F 067572668
       Shop #: WSC 02313 785 00200
       VCID: 3B203EB24F6B732FDF7-806E
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 38: Roof Electronics        Labels: 4E0-910-135.lbl
       Part No SW: 4E0 910 135 A    HW: 4E0 907 135 A
       Component: Dachknoten D3   H04 0090  
       Serial number: 00000617100155
       Coding: 0232912
       Shop #: WSC 02313 785 00200
       VCID: 1D64D02AF1BF1D1FC13-8048
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 42: Door Elect, Driver        Labels: 4E1-910-802-42.lbl
       Part No SW: 4E1 910 802 B    HW: 4E2 959 802 B
       Component: Türsteuer.FS BRM003 0100  
       Coding: 0032623
       Shop #: WSC 02313 785 00200
       VCID: 201AE9DEC6CD30F7EA5-8074
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 46: Central Conv.        Labels:. 4E0-910-289.lbl
       Part No SW: 4E0 910 289 D    HW: 4E0 907 289 D
       Component: Komfortgeraet   H07 0010  
       Revision: 00100007    Serial number:  W040606290218
       Coding: 0005885
       Shop #: WSC 02313 785 00200
       VCID: 2A0E0BF6B0F1FAA7B41-807E
    
       Subsystem 1 - Part No: 4E0 910 853 
       Component: Heckdeckel      H06 0060
    
       Subsystem 2 - Part No: 4E0 907 719 
       Component: Neigungssensor  H05 0020
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 47: Sound System        Labels: 4E0-910-223.lbl
       Part No SW: 4E0 910 223 P    HW: 4E0 035 223 F
       Component: DSP-High D3     H02 0070  
       Revision: PROD_01     Serial number: 00000000002235
       Coding: 0000027
       Shop #: WSC 02313 785 00200
       VCID: 2A0E0BF6B0F1FAA7B41-807E
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 4F: Centr. Electr. II        Labels: None
       Part No SW: 4E0 910 280 A    HW: 4E0 907 280 B
       Component: ILM Beifahrer   H11 0070  
       Revision:             Serial number: 00000000000507
       Coding: 0010111
       Shop #: WSC 02313 785 00200
       VCID: 1E66D726FCB90607D89-804A
    
       Subsystem 1 - Part No: 4E0 910 511 
       Component: UGDO HL ECE     H06 0050
    
       Subsystem 2 - Serial number: 0253439TJ8EZ06
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 52: Door Elect, Pass.        Labels: 4E1-910-802-52.lbl
       Part No SW: 4E1 910 802 B    HW: 4E2 959 801 B
       Component: Türsteuer.BF BRM003 0100  
       Coding: 0032623
       Shop #: WSC 02313 785 00200
       VCID: 201AE9DEC6CD30F7EA5-8074
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 53: Parking Brake        Labels: 4E0-910-801.clb
       Part No SW: 4E0 910 801 C    HW: 4E0 907 801 A
       Component: EPB  A32C0220   H02 0220  
       Revision: A32C0220    
       Coding: 0000731
       Shop #: WSC 31414 210 01865
       VCID: 1F18EA22FBB30F0FD3F-804A
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 55: Headlight Range        Labels: 4F0-910-357.lbl
       Part No SW: 4F0 910 357 F    HW: 4F0 907 357 F
       Component: AFS 1           H01 0020  
       Revision: 00000001    Serial number:               
       Coding: 0000018
       Shop #: WSC 02313 785 00200
       VCID: 290CF4FAB5F7F1BFBDB-807C
    
       Subsystem 1 - Part No: 4F0 941 329 B
       Component: AFS-Modul links H02 0020
    
       Subsystem 2 - Part No: 4F0 941 329 B
       Component: AFS-Modul rechtsH02 0020
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 56: Radio        Labels: 4E0-910-541.lbl
       Part No SW: 4E0 910 541 M    HW: 4E0 035 541 P
       Component: TUNER EU/US/RDW H42 0570  
       Revision: 00000000    Serial number: 396FM067541201
       Coding: 0000001
       Shop #: WSC 02313 785 00200
       VCID: 2A0E0BF6B0F1FAA7B41-807E
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 57: TV Tuner        Labels: None
       Part No SW: 4E0 910 148 A    HW: 4E0 919 148 
       Component: R0078 TVhybridTuner 0280  
       Revision: R0H05000    Serial number: 76300700388801
       Coding: 0000003
       Shop #: WSC 02313 785 00200
       VCID: 211CECDACDC739FFE5B-8074
    
    1 Fault Found:
    02283 - Video Connection to Output [End Unit] 
                010 - Open or Short to Plus - Intermittent
                 Freeze Frame:
                        Fault Status: 00101010
                        Fault Priority: 5
                        Fault Frequency: 20
                        Reset counter: 14
                        Mileage: 217812 km
                        Time Indication: 0
                        Date: 2019.07.13
                        Time: 17:04:41
    
    
    -------------------------------------------------------------------------------
    Address 61: Battery Regul.        Labels: 4E0-910-181.lbl
       Part No SW: 4E0 910 181 C    HW: 4E0 915 181 C
       Component: J0644 BEM       H12 0550  
       Revision: 00000000    Serial number: 00000000011975
       Shop #: WSC 00235 210 81345
       VCID: 201AE9DEC6CD30F7EA5-8074
    
       Subsystem 1 - Part No: 4E0 915 105 A
       Component: von VA0  31070881DK       
       Coding: 34453039313531303541205641303331303730383831444B
       Shop #: WSC 00586 210 83216
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 62: Door, Rear Left        Labels: 4E0-910-802.lbl
       Part No SW: 4E0 910 802 A    HW: 4E0 959 801 C
       Component: Türsteuer.HL BRM003 0100  
       Coding: 0032623
       Shop #: WSC 02313 785 00200
       VCID: 1E66D726FCB90607D89-804A
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 65: Tire Pressure        Labels: 4E0-910-273.lbl
       Part No SW: 4E0 910 273 A    HW: 4F0 907 273 A
       Component: Reifendruck 3   H05  
       Revision: 00050340    Serial number: 00000900046144
       Coding: 0212329
       Shop #: WSC 02313 785 00200
       VCID: 201AE9DEC6CD30F7EA5-8074
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 67: Voice Control        Labels: 4E0-910-75x-67.lbl
       Part No SW: 4E0 910 754 S    HW: 4E0 035 753 A
       Component: SDS 3502 UK     H45 0630  
       Revision: 00000000    Serial number: 00000606230355
       Shop #: WSC 12336 024 394758
       VCID: 36362F867449AE47209-8062
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 6C: Back-up Cam.        Labels: 4E0-910-441.clb
       Part No SW: 4E0 910 441     HW: 4L0 907 441 A
       Component: J772__Rearview      0050  
       Revision: --H12---    Serial number: 525PA8-J6610DB
       Coding: 1021302
       Shop #: WSC 02313 785 00200
       VCID: 5CE29D2EAA255417F6D-8008
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 72: Door, Rear Right        Labels: 4E0-910-802.lbl
       Part No SW: 4E0 910 802 A    HW: 4E0 959 802 D
       Component: Türsteuer.HR BRM005 0180  
       Coding: 0032623
       Shop #: WSC 00409 210 01865
       VCID: 1E66D726FCB90607D89-804A
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 76: Park Assist        Labels: 4E0-910-283.lbl
       Part No SW: 4E0 910 283 C    HW: 4E0 919 283 C
       Component: Parkhilfe 8-Kan H12 0040  
       Revision: 00H12000    Serial number: 08720617900335
       Coding: 0321008
       Shop #: WSC 02313 785 00200
       VCID: 2310E6D2D7DB2BEFF77-8076
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 77: Telephone        Labels: 4E0-910-336.lbl
       Part No SW: 4E0 910 336 H    HW: 4E0 862 335 
       Component: Handyvorb2      H00 0700  
       Revision: 00000000    Serial number: 00000000000000
       Coding: 0000000
       Shop #: WSC 00000 000 00000
       VCID: 2708F2C2A3E3C7CFABF-8072
    
    3 Faults Found:
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 7
                        Fault Frequency: 1
                        Reset counter: 164
                        Mileage: 126176 km
                        Time Indication: 0
                        Date: 2009.11.30
                        Time: 16:24:33
    
    00446 - Function Limitation due to Under-Voltage 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 7
                        Fault Frequency: 1
                        Reset counter: 164
                        Mileage: 126176 km
                        Time Indication: 0
                        Date: 2009.11.30
                        Time: 16:24:33
    
    01042 - Control Module; Not Coded 
                000 - -
                 Freeze Frame:
                        Fault Status: 01100000
                        Fault Priority: 5
                        Fault Frequency: 1
                        Reset counter: 11
                        Mileage: 101820 km
                        Time Indication: 0
                        Date: 2009.04.30
                        Time: 16:04:29
    
    
    End----------(Elapsed Time: 02:23, VBatt start/end: 12.3V/12.3V)-----------

    Code:
    Address 01: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
                    Address 11: Engine II       Labels: Redir Fail!
    Control Module Part Number: 4E0 910 552     HW: 4E0 907 552 
      Component and/or Version: 5.2L V10/4V FSI    ª0060
               Software Coding: 01060003190F0160
                Work Shop Code: WSC 00673 210 83197
                          VCID: 5F98AA22BB334F0F93F-800A
    2 Faults Found:
    
    004225 - Mixture Regulation; Bank 3; Range 1 
                   P1081 - 004 - Lean Limit Exceeded - MIL ON
                 Freeze Frame:
                        Fault Status: 11100100
                        Fault Priority: 0
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 218034 km
                        Time Indication: 0
                        Date: 2019.07.21
                        Time: 10:30:47
    
                 Freeze Frame:
                        RPM: 668 /min
                        Load: 14.1 %
                        Speed: 0.0 km/h
                        Temperature: 99.0°C
                        Temperature: 30.0°C
                        Absolute Pres.: 1010.0 mbar
                        Voltage: 14.351 V
    
    004229 - Mixture Regulation; Bank 4; Range 1 
                   P1085 - 004 - Lean Limit Exceeded
                 Freeze Frame:
                        Fault Status: 01100100
                        Fault Priority: 0
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 218046 km
                        Time Indication: 0
                        Date: 2019.07.21
                        Time: 11:37:55
    
                 Freeze Frame:
                        RPM: 642 /min
                        Load: 18.0 %
                        Speed: 0.0 km/h
                        Temperature: 93.0°C
                        Temperature: 45.0°C
                        Absolute Pres.: 1000.0 mbar
                        Voltage: 13.589 V
    
    
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 11: DTCs cleared
    Last edited by Uwe; 07-21-2019 at 04:07 PM. Reason: CODE tags

  2. #2
    Verified VCDS User
    Join Date
    Jul 2014
    Location
    Yorkshire
    Posts
    90
    Post Thanks / Like
    The crankcase vacuum is tremendous - I cannot remove the Oil filler cap with the engine at Idle. Is this normal?
    no.................

  3. Likes Jack@European_Parts, Uwe, PetrolDave liked this post
  4. #3
    NostraJackAss Jack@European_Parts's Avatar
    Join Date
    Jan 2014
    Location
    1001 State Route 17K Montgomery New York 12549
    Posts
    16,173
    Post Thanks / Like
    Comments: The MIL only comes ON after aggressive acceleration. long drives over a couple days has no Fault codes stored.
    The crankcase vacuum is tremendous - I cannot remove the Oil filler cap with the engine at Idle. Is this normal?
    I only apply Castrol Edge 5w 30 fully synthetic and replace this oil annually despite minimum mileage<4k / annum.
    Fuel is only 98 Octane (shell).


    Nope........... recheck your work and correct PCV!




    ALL BANKS System too Lean at Idle or Idle offset


    Possible Causes


    • Injectors leak/blocked
    • Air Intake Multiplicative leak for any possible leak after MAF or TV
    • Exhaust Leak
    • Fuel filter blocked or Lift/Transfer pump faulty to HPP
    • HPP damaged or mechanical clearance ware issue
    • Inadequately operating or blocked PCV
    • OXS sensor or circuits for ECU faulty from FOD damage

    Possible Solutions


    • Check Mass Air Flow Sensor (G70)
    • Check Injector(s)
    • Check ALL Fuel Pumps
    • Check Activated Charcoal Filter (EVAP) System Solenoid Valve 1 (N80)
    • Check for PCV function
    • Correct all FOD!
    European Parts Emporium/Performance / Immobilizer Solutions EPE
    Certified Master Trained NY/BAR/BAD 7076062/ASE/SAE/NASTF Legal Factory Authorized/Licensed GeKo/FaZit # 403738
    Specializing in Custom Services IE: "welding-fabrication" / EPA-SMOG Update or Pass-Thru-Programming / Data Transfer / Immobilizers & OEM Quality Parts
    Above Magic! No Written record, AUTO-SCAN or Appointment = NO HELP!
    www.FixMyEuro.com <<<<<CLICK HERE! or vwemporium@aol.com ( JPPSG & Unverified members need not PM me & Please don't email or call facility for free tech support...use the forum )
    Getting you CONTROL again of your property - TAKE IT! In Conjunction with.........

  5. #4
    Verified VCDS User
    Join Date
    Jul 2017
    Location
    Scarborough, UK
    Posts
    7
    Post Thanks / Like
    Thanks, so the high vacuum is not normal.

    I have also noticed the PCV is buzzing wildly at idle.

    I’ll remove and replace with a new PCV unit AGAIN...

    Thanks loads

    Ps. What is FOD?

    Thanks loads

  6. #5
    NostraJackAss Jack@European_Parts's Avatar
    Join Date
    Jan 2014
    Location
    1001 State Route 17K Montgomery New York 12549
    Posts
    16,173
    Post Thanks / Like
    European Parts Emporium/Performance / Immobilizer Solutions EPE
    Certified Master Trained NY/BAR/BAD 7076062/ASE/SAE/NASTF Legal Factory Authorized/Licensed GeKo/FaZit # 403738
    Specializing in Custom Services IE: "welding-fabrication" / EPA-SMOG Update or Pass-Thru-Programming / Data Transfer / Immobilizers & OEM Quality Parts
    Above Magic! No Written record, AUTO-SCAN or Appointment = NO HELP!
    www.FixMyEuro.com <<<<<CLICK HERE! or vwemporium@aol.com ( JPPSG & Unverified members need not PM me & Please don't email or call facility for free tech support...use the forum )
    Getting you CONTROL again of your property - TAKE IT! In Conjunction with.........

  7. #6
    Verified VCDS User
    Join Date
    Jul 2017
    Location
    Scarborough, UK
    Posts
    7
    Post Thanks / Like
    Hi, today a fitted another new PCV oil separator and also vacuum tested the fuel tank breather solenoid valve N80 (tested ok). Started the engine and I am now able to remove the oil filler cap with engine idling (well I couldn’t before). So it just goes to prove that cheaper parts on EBay £32 compared to the better £80 Bosch part makes one hell of a difference in quality and function.

    Next step - check VCDS for Lean operation after completing my recovery from retinal detachment surgery, hopefully early next week.

    Thanks again folks!

    Cheers,

  8. Likes Uwe, Jack@European_Parts, PetrolDave liked this post

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •