1.9tdi bls engine code.New battery, new tandem pump. new temp sensor. new fuel pipes and clamps.new fuel filter and rings. waiting for a new injector harness to arrive. but one in looks fine and ohm resistance is 0.1 with continuity on all wiring. all earths cleaned from chassis and engine. Egr valve removed and cleaned. can hear pump in the tank running for 1-2 seconds. hard starting and idle seems fine. when driving seems ok then starts to juddering in 3,4th gears. then stalls and wont start up again until it cools but again it is hard starting. starting motor shows as 295rpm. The battery replaced was 62 amp and now 72 amp.
van still struggles to start and once its started and hot, the engine wont start again.
once the faults are cleared, they stay clear. Some of these faults are from when ive had things unplugged.
apologies for wording
van still struggles to start and once its started and hot, the engine wont start again.
Code:
Monday,24,June,2019,21:18:02:18214
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 19.6.0.2 (x64) HEX-V2 CB: 0.4505.4
Data version: 20190529 DS308.0
www.Ross-Tech.com
VIN: WV1ZZZ2KZAX063763 License Plate:
Chassis Type: 2K (1K0)
Scan: 01 03 08 09 15 16 17 19 25 42 46 52 56
VIN: WV1ZZZ2KZAX063763 Mileage: 246670km-153273miles
01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
56-Radio -- Status: Malfunction 0010
-------------------------------------------------------------------------------
Address 01: Engine Labels: 03G-906-021-BLS.clb
Part No SW: 03G 906 021 PD HW: 03G 906 021 CG
Component: R4 1,9L EDC 000SG 2387
Revision: --H11--- Serial number: VWX7Z0I93NQ0KX
Coding: 0000071
Shop #: WSC 00000 256 01574
VCID: 70B9D32AE6A761E73A1-8024
5 Faults Found:
000769 - Cylinder 1
P0301 - 000 - Misfire Detected - Intermittent
Freeze Frame:
Fault Status: 00110000
Fault Priority: 3
Fault Frequency: 1
Reset counter: 255
Mileage: 246664 km
Time Indication: 0
Date: 2000.00.00
Time: 11:52:20
Freeze Frame:
RPM: 819 /min
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 14.21 V
Inj. Quantity: 2.96 mg/str
Temperature: 67.5°C
(no units): 0.0
000258 - Mass Air Flow Sensor (G70)
P0102 - 000 - Signal too Low - Intermittent
Freeze Frame:
Fault Status: 00110000
Fault Priority: 2
Fault Frequency: 6
Reset counter: 255
Mileage: 246665 km
Time Indication: 0
Date: 2000.00.00
Time: 01:49:13
Freeze Frame:
RPM: 840 /min
Speed: 0.0 km/h
Load: 0.0 %
Duty Cycle: 100.6 %
Bin. Bits: 00000000
Mass Air / Rev.: 240.0 mg/str
Mass Air / Rev.: 0.0 mg/str
000770 - Cylinder 2
P0302 - 000 - Misfire Detected
Freeze Frame:
Fault Status: 01110000
Fault Priority: 3
Fault Frequency: 5
Reset counter: 255
Mileage: 246667 km
Time Indication: 0
Date: 2000.00.00
Time: 00:15:57
Freeze Frame:
RPM: 798 /min
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 14.44 V
Inj. Quantity: 2.96 mg/str
Temperature: 46.8°C
(no units): 0.0
008581 - Engine Coolant Temp Sensor on Radiator Outlet (G83)
P2185 - 000 - Signal too High - Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 3
Fault Frequency: 1
Reset counter: 255
Mileage: 246667 km
Time Indication: 0
Date: 2000.00.00
Time: 00:16:11
Freeze Frame:
RPM: 819 /min
Speed: 0.0 km/h
Load: 0.0 %
Voltage: 14.44 V
Bin. Bits: 00000100
Temperature: 66.6°C
Temperature: 47.7°C
012295 - Camshaft Position Sensor (G40)
P3007 - 000 - No Signal - Intermittent
Freeze Frame:
Fault Status: 00110000
Fault Priority: 3
Fault Frequency: 1
Reset counter: 255
Mileage: 246677 km
Time Indication: 0
Date: 2000.00.00
Time: 06:29:59
Freeze Frame:
RPM: 294 /min
Speed: 0.0 km/h
Load: 100.0 %
Voltage: 11.17 V
Bin. Bits: 00000100
Idle Stabilization: 0.0°KW
(no units): 32.0
Readiness: 0 1 0 0 1
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels:. 1K0-907-379-MK70M.clb
Part No SW: 1K0 907 379 AF HW: 1K0 907 379 AF
Component: MABS MK70M 0104
Revision: 00H32001
Coding: 0020801
Shop #: WSC 35110 377 00157
VCID: 76B5E53284C34FD7E0D-8022
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 1K0-820-047.lbl
Part No SW: 2K0 820 047 BM HW: 2K0 820 047 BM
Component: Climatic PQ35 143 1515
Revision: 00143033 Serial number: 00000000000000
Shop #: WSC 00000 000 00000
VCID: 71BFD62EEDAD68EF35F-8024
1 Fault Found:
00229 - Refrigerant Pressure
002 - Lower Limit Exceeded
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels:. 3C0-937-049-30-M.lbl
Part No SW: 3C8 937 049 D HW: 3C8 937 049 D
Component: Bordnetz-SG H54 2602
Revision: 00H54000 Serial number: 01000003455243
Coding: 00804F030004100057000000000000000009FB075C000120000000000000
Shop #: WSC 35110 377 08192
VCID: 323D1922282B13F70C5-8066
Subsystem 1 - Part No: 1T2 955 119 Labels: 1KX-955-119.CLB
Component: Wischer 071009 021 0512
Coding: 00038805
Shop #: WSC 35110
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 6Q0-909-605-VW52.lbl
Part No SW: 6Q0 909 605 AH HW: 6Q0 909 605 AH
Component: 2Q AIRBAG VW52 025 2400
Revision: 06025000 Serial number: 0037TR05HC4I
Coding: 0012881
Shop #: WSC 35110 377 00157
VCID: 7DA7FA1EA1F51C8FA17-8028
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY9.lbl
Part No SW: 1K0 953 549 CT HW: 1K0 953 549 CT
Component: J0527 053 0111
Coding: 0000001
Shop #: WSC 35110 377 08192
VCID: 065595F2F4235F57F0D-8052
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 1K0-920-xxx-17.lbl
Part No SW: 2K0 920 944 C HW: 2K0 920 944 C
Component: KOMBIINSTRUMENT VDD 1222
Revision: V0002000 Serial number: VWX7Z0I93NQ0KX
Coding: 0016401
Shop #: WSC 00288 210 87232
VCID: 2C01075A0A0F4507469-8078
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels:. 1K0-907-530-V4.clb
Part No SW: 1K0 907 530 AD HW: 1K0 907 951
Component: J533 Gateway H07 0111
Revision: H07 01 Serial number: 221009F1000624
Coding: 89801F06000202007401
Shop #: WSC 35110 377 00157
VCID: 698FBE4EC57D902F7DF-803C
No fault code found.
-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 1K0-920-xxx-25.clb
Part No SW: 2K0 920 944 C HW: 2K0 920 944 C
Component: IMMO VDD 1222
Revision: V0002000 Serial number: VWX7Z0I93NQ0KX
Shop #: WSC 00000 000 00000
VCID: 2C01075A0A0F4507469-8078
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels: 1K0-959-793.lbl
Part No: 1K0 959 793
Component: Tuersteuergeraet 02 0160
Coding: 0000000
Shop #: WSC 35110 377 08192
VCID: 76B5E53284C34FD7E0D-8022
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv. Labels:. 1K0-959-433-MIN.clb
Part No: 1K0 959 433 CP
Component: KSG 0401
Coding: 018A0C087F2D8C0D4858061000C0
Shop #: WSC 35110 377 00157
VCID: 005983EAD6077167CA1-8054
Subsystem 1 - Part No: 1K0 951 605 C
Component: LIN BACKUP HORN H03 1301
Subsystem 2 - Component: NGS n.mounted
Subsystem 3 - Component: IRUE n.mounted
1 Fault Found:
00930 - Locking Module for Central Locking; Rear Left (F222)
012 - Electrical Fault in Circuit - Intermittent
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels: 1K0-959-792.lbl
Part No: 1K0 959 792
Component: Tuersteuergeraet 02 0160
Coding: 0000000
Shop #: WSC 35110 377 08192
VCID: 75B7E23E99C544CFE97-8020
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (J503) Labels:. 5M0-035-1xx-56.clb
Part No SW: 1K0 035 186 AA HW: 1K0 035 186 AA
Component: Radio RCD310 013 0036
Revision: 00000000 Serial number: VWZ1Z2I6759399
Coding: 0000020001
Shop #: WSC 35110 377 08192
VCID: 6597B27E2565B44F597-8030
2 Faults Found:
00870 - Bass Speaker Front Left (R21)
011 - Open Circuit - Intermittent
Freeze Frame:
Fault Status: 00101011
Fault Priority: 5
Fault Frequency: 1
Reset counter: 54
Mileage: 246617 km
Time Indication: 0
Date: 2000.00.00
Time: 20:59:35
00871 - Bass Speaker Front Right (R23)
011 - Open Circuit - Intermittent
Freeze Frame:
Fault Status: 00101011
Fault Priority: 5
Fault Frequency: 1
Reset counter: 54
Mileage: 246617 km
Time Indication: 0
Date: 2000.00.00
Time: 20:59:35
End----------(Elapsed Time: 00:52, VBatt start/end: 12.5V/12.5V)-----------once the faults are cleared, they stay clear. Some of these faults are from when ive had things unplugged.
apologies for wording
