Good evening,
I've been wanting to retrofit several features on my 2013 Touareg TDI Exec. A while ago, I installed the Area View camera, and that went pretty well. The big project I've been waiting on is the Lane Assist camera. A few weeks ago, I finally got the rock hit that insurance paid for the window to be replaced, as well as calibrating the lane assist system, so I got the correct windshield for the Lane Assist, and wired it up according to ELSA, or at least I thought I did...
I'm also trying to retrofit ACC, and I took this opportunity to do the wiring at the same time. That's all wired up with the factory bumper harness, and then there are 4 wires that run back...power, two Flex-ray wires, and ground, which I grounded to the wall in the engine bay.
I installed the Camera itself, 7P6 907 217 B, the Image Processor, and the Pitch sensor, all straight out of EKTA.
I though that I had gotten it right, but the coding may be wrong. I'm not sure at this point.
As a baseline, here is my original coding, at least going back to the Area View retrofit.
This is my current coding:
I'm getting some odd errors, in particular the engine malfunction code, which shouldn't have been affected by my installation. Obviously the CAN Gateway malfunction and Central Conv. malfunctions are a concern, as the coding may not be quite right with them as of yet. There are some Not Registered errors as well... the on-board cam, which I know has to be calibrated, so I'm assuming that's the issue, but I don't know.
I plan on going back this weekend and verifying the wiring from the Image Processor and the Pitch Sensor. I was pretty careful. All the wiring matched ELSA's color coding, and I checked the pinouts several times. Only thing I can think of is that a pin may have gotten pulled loose.
I know this is a lot, but I would appreciate any help. I know this is possible. There is a thread here where someone did it to a Q5, which is really just a more expensive Touareg.
I've been wanting to retrofit several features on my 2013 Touareg TDI Exec. A while ago, I installed the Area View camera, and that went pretty well. The big project I've been waiting on is the Lane Assist camera. A few weeks ago, I finally got the rock hit that insurance paid for the window to be replaced, as well as calibrating the lane assist system, so I got the correct windshield for the Lane Assist, and wired it up according to ELSA, or at least I thought I did...
I'm also trying to retrofit ACC, and I took this opportunity to do the wiring at the same time. That's all wired up with the factory bumper harness, and then there are 4 wires that run back...power, two Flex-ray wires, and ground, which I grounded to the wall in the engine bay.
I installed the Camera itself, 7P6 907 217 B, the Image Processor, and the Pitch sensor, all straight out of EKTA.
I though that I had gotten it right, but the coding may be wrong. I'm not sure at this point.
As a baseline, here is my original coding, at least going back to the Area View retrofit.
Code:
Thursday,25,May,2017,16:26:49:03710
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x86(VMWare)
VCDS Version 17.1.3.0
Data version: 20170320 DS267.7
www.Ross-Tech.com
VIN: WVGEP9BP7DD004878 License Plate: MAMATANK
Mileage: 153430km-95336mi Repair Order:
Chassis Type: BP (7P6)
Scan: 01 02 03 05 08 09 10 15 16 17 19 36 3C 42 46 47 52 53 55 56
5F 62 65 69 6C 6D 72
VIN: WVGEP9BP7DD004878 Mileage: 153430km-95336miles
01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: Malfunction 0010
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
3C-Lane Change -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
47-Sound System -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
5F-Information Electr. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
69-Trailer -- Status: OK 0000
6C-Back-up Cam. -- Status: Malfunction 0010
6D-Trunk Elect. -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CNRA) Labels: 059-907-401-V2.clb
Part No SW: 7P0 907 401 K HW: 7P0 907 401 K
Component: 3.0TDI EDC17 H19 0003
Revision: 56H19---
Coding: 292A4012233600050000
Shop #: WSC 05072 444 11327
ASAM Dataset: EV_ECM30TDI0117P0907401K 001004
ROD: EV_ECM30TDI0117P0907401K.rod
VCID: 3777DDCE8E43FAF918-8063
No fault code found.
Readiness: 0 0 0 1 1
-------------------------------------------------------------------------------
Address 02: Auto Trans (J217) Labels: 0C8-927-750.clb
Part No SW: 0C8 927 750 AK HW: 0C8 927 750 AK
Component: AL1000 AISIN 001 2269
Serial number:
Coding: 001368
Shop #: WSC 43979 001 1048576
ASAM Dataset: EV_TCMAL991031 002114
ROD: EV_TCMAL991031_002.rod
VCID: 75EB17C6D4CF48E9CA-8021
No fault code found.
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels: 7P0-907-379.clb
Part No SW: 7P0 907 379 M HW: 7P0 907 379 A
Component: MK25A H36 0436
Revision: -------- Serial number: 420720010EC815
Coding: 5B7613C349242557DAFCC89A92DAA4407700
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_MK25AXT 008001
ROD: EV_ESPMK25A00800.rod
VCID: 4797AD0EFEA38A7968-8013
No fault code found.
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393) Labels: 8K0-907-064-05.clb
Part No SW: 4H0 907 064 CK HW: 4H0 907 064 CK
Component: BCM2 2.0 H32 0421
Revision: 00002001
Coding: 0D860016000000000000
Shop #: WSC 31414 790 00001
VCID: 74ED2AC2D7B551E1FD-8021
Subsystem 1 - Part No SW: 4H0 905 852 B HW: 4H0 905 852 B
Component: J764 ELV MLB H40 0046
Serial number: 2312000154943013
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels: 7P6-907-040.clb
Part No SW: 7P6 907 040 BK HW: 7P6 907 040 BK
Component: Klima 2 Zonen H20 1305
Coding: B686200A80
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_AirCondiFront 004001
ROD: EV_AirCondiFront_VW52.rod
VCID: 7EF908EAE1F90BB19B-802B
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: 4H0-907-063-V1.clb
Part No SW: 4H0 907 063 BL HW: 4H0 907 063 D
Component: BCM1 2.0 H12 0111
Revision: 15012002 Serial number: 00000001586921
Coding: 26001012933C5D010020180300005D0C431C660882010261000000020000
Shop #: WSC 31414 790 00001
VCID: 73EF29DED2BB56D9E4-8027
Subsystem 1 - Part No SW: 7P0 955 119 HW: 7P0 955 119 Labels: 1KX-955-119.CLB
Component: WWS 120711 31 0020
Serial number: 90243400120719131750
Coding: 004DBD
Subsystem 2 - Part No SW: 7P0 955 559 D HW: 7P0 955 559 D Labels: 8K0-955-559.CLB
Component: RLFS H09 0011
Serial number: 10420600
Coding: 025223
Subsystem 3 - Part No SW: 7P6 941 431 AB HW: 7P6 941 431 AB
Component: E1 - LDS H02 0040
Serial number: 00000000002304140008
Subsystem 4 - Part No SW: 4H0 907 410 A HW: 4H0 907 410 A
Component: USHL4.2 H30 0020
Serial number: 0000001805569R16DW07
No fault code found.
-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446) Labels: 7P6-919-475.clb
Part No SW: 7P6 919 475 B HW: 7N0 919 475
Component: PARKHILFE 8K H05 0021
Revision: -------- Serial number: 28261219601184
Coding: 510501
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_VW526ParkiAssis2 001011
ROD: EV_VW526ParkiAssis2.rod
VCID: 4281BC1AD581AF51BF-8017
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels: 5K0-959-655.clb
Part No SW: 7P0 959 655 C HW: 7P0 959 655 C
Component: VW10Airbag025 H05 0025
Revision: -------- Serial number: 003L0004ACDK
Coding: 000000000000000000000000000000003235
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_AirbaVW10BPAVW526 001001
ROD: EV_AirbaVW10BPAVW526_001.rod
VCID: 4183B316D087B449A6-8015
Seat occupied recognition:
Subsystem 1 - Part No SW: 7P6 959 339 HW: 7P6 959 339
Component: BF-Gewichtss. 003 0005
Serial number: 5850000R1242708U3B
Crash sensor for side airbag: driver side:
Serial number: 3575LRB40511G1DOBH33
Crash sensor for side airbag: front passenger side:
Serial number: 3585LRB405L1G1DM9HFW
Crash sensor for side airbag: rear: driver side:
Serial number: 3515RRB405J1D2ASDHN%
Crash sensor for side airbag: rear: passenger side:
Serial number: 3525RRB405J1D2ASMGM7
Crash sensor for front airbag: driver side:
Serial number: 3555NRB405R1GCDMCOFF
Crash sensor for front airbag: front passenger side:
Serial number: 3565NRB40631GCDM3PJW
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels: 4H0-953-568.clb
Part No SW: 4H0 953 568 H HW: 4H0 953 568 H
Component: Lenks.Modul H03 0005
Revision: -------- Serial number: 90372LLB000VA
Coding: 000C15
Shop #: WSC 09145 444 103404
VCID: 3875DEF28B5DF58111-FFFF
Subsystem 1 - Part No SW: 7P6 959 542 HW: 7P6 959 542
Component: E221__MFL-TAS 0027
Serial number: H0
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels: 7P6-920-xxx-17.clb
Part No SW: 7P6 920 981 F HW: 7P6 920 981 F
Component: Kombi H13 0318
Revision: 13240077 Serial number: 658100812592019
Coding: 8B7733022B00CF05020004
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_KombiUDSRBVW526 001017
ROD: EV_KombiUDSRBVW526_VW52.rod
VCID: 4085B612DB8DBD41A9-8015
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels: None
Part No SW: 7P6 907 530 F HW: 7P6 907 530 F
Component: GW-CAN-L-MOST H11 6028
Revision: -------- Serial number: 00000000639722
Coding: 0001037500
Shop #: WSC 49771 001 1048576
ASAM Dataset: EV_GatewVW526UDS 001007
ROD: EV_GatewUDS_VW52.rod
VCID: 3B7FC1FEB26BDE99FC-806F
Battery Monitoring Control Module:
Subsystem 1 - Part No SW: 7P0 915 181 A HW: 7P0 915 181
Component: Batt_Sensor H07 0140
Serial number: 00000000005650867664
No fault code found.
-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr (J136) Labels: None
Part No SW: 4H0 959 760 D HW: 4H0 959 760 D
Component: MEM-FS H08 0153
Revision: AA000000 Serial number: 00000035065047
Coding: 00581B0000004001000001010101202020202121202020
Shop #: WSC 31414 790 00001
VCID: 346DEAC2973511E13D-8061
No fault code found.
-------------------------------------------------------------------------------
Address 3C: Lane Change Labels: Redir Fail!
Part No SW: 7P6 907 566 HW: 4H0 907 566
Component: J769 SWA MasterH02 0110
Revision: 00H02000 Serial number: 6PZ 010 316-01
Coding: 0010151
Shop #: WSC 01730 666 44235
VCID: 7EF908EA29F90BB19B-802B
Subsystem 1 - Part No: 7P6 907 568
Component: J770 SWA Slave H01 0110
Subsystem 2 - Serial number: 6PZ 010 316-21
Subsystem 3 - Serial number: 5F26.09.0900H010003C520076ÿ
Subsystem 4 - Serial number: 520076ÿ
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels: None
Part No SW: 4H0 959 793 N HW: 4H0 959 793 F
Component: TSG FA H07 0166
Revision: -------- Serial number: 0000129655805
Coding: 011D17205E00453005080000
Shop #: WSC 31414 790 00001
VCID: 448DBA02C795A1618D-8011
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv. (J393) Labels: 4H0-907-064-46.clb
Part No SW: 4H0 907 064 CK HW: 4H0 907 064 CK
Component: BCM2 2.0 H32 BCM2 2.0 H32 04210421
Revision: 00002001 Serial number: 0180526694
Coding: 0186123A28B9509580A00620210000000000000000000000000000000000
Shop #: WSC 31414 790 00001
VCID: 74ED2AC2D7B551E1FD-8021
Subsystem 1 - Part No SW: 7P6 959 719 HW: 7P6 959 719
Component: GTO BT H19 0059
Serial number: 1981215567
Subsystem 2 - Part No: 1K0 951 605 C
Component: LIN BACKUP HO H05 1501
Subsystem 3 - Part No SW: 7P0 959 591 B HW: 7P0 959 591 B
Component: J245 PS30.055 H01 0008
Serial number: WOO17640530
Coding: 191100
Subsystem 4 - Part No SW: 7P0 959 591 C HW: 7P0 959 591 C
Component: J394 PS30.055 H01 0008
Coding: 191100
No Faults Found
or DTCs not supported by controller
or a communication error occurred
-------------------------------------------------------------------------------
Address 47: Sound System (J525) Labels: 8T0-035-223-BOM.clb
Part No SW: 7P6 035 466 HW: 7P6 035 466
Component: DSP Prem H01 0090
Revision: 00001001 Serial number: 10811001712705
VCID: 75EB17C6DCCF48E9CA-8021
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels: None
Part No SW: 4H0 959 792 F HW: 4H0 959 792 F
Component: TSG BF H07 0166
Revision: -------- Serial number: 0000129629168
Coding: 011D17205E00453005080000
Shop #: WSC 31414 790 00001
VCID: 3B7FC1FEBA6BDE99FC-806F
No fault code found.
-------------------------------------------------------------------------------
Address 53: Parking Brake (J540-) Labels: 7P0-907-801.clb
Part No SW: 7P0 907 801 F HW: 7P0 907 801 F
Component: EPB H51 1201
Revision: 00000000 Serial number: C1272700340
Coding: 01040200
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_ParkbA7 000006
ROD: EV_ParkbA7.rod
VCID: 3669D0CA894903F103-8063
Slave 3:
No fault code found.
-------------------------------------------------------------------------------
Address 55: Headlight Range (J745) Labels: 7P6-907-357.clb
Part No SW: 7P6 907 357 HW: 7L6 907 357 C
Component: AFS-ECU H04 0110
Revision: -------- Serial number: --------------
Coding: 010A00010F000400
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_HeadlRegulVWAFS 005006
ROD: EV_HeadlRegulVWAFS_VW52.rod
VCID: 7CFD02E2F7E519A1B5-8029
Left Headlamp Power Output Stage:
Subsystem 1 - Part No SW: 8U0 941 329 HW: 8U0 941 329 Labels: 3D0-941-329.CLB
Component: LeiMo links H01 0002
Coding: 130000
Right Headlamp Power Output Stage:
Subsystem 2 - Part No SW: 8U0 941 329 HW: 8U0 941 329 Labels: 3D0-941-329.CLB
Component: LeiMo rechts H01 0002
Coding: 130000
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (R) Labels: Redir Fail!
Part No SW: 4G0 035 082 G HW: 4G0 035 082
Component: Radio U SIRIU H60 0133
Revision: AB001007 Serial number: 156G10C7618771
Coding: 020007010000000001
Shop #: WSC 31414 790 00001
VCID: 244D1A8227D58161AD-8071
No fault code found.
-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794) Labels: 4E0-035-6xx-5F.clb
Part No SW: 7P6 035 664 D HW: 7P6 035 664
Component: H-BN-NA H45 0706
Revision: -------- Serial number: 445HB0C7538995
Coding: 020200050040E1EF41022B0E00000003F00001030000000000
Shop #: WSC 43979 001 1048576
VCID: 3973DBF6B057EC89EE-806D
Subsystem 1 - Part No: 7P6 060 884 D
Component: NAR 2016 1302
Subsystem 2 - Part No SW: 7P6 919 603 C HW: 7P6 919 603 C
Component: DU8 SV Touch H26 0045
Serial number: VWZ8Z9M7900D6L
Subsystem 3 - Part No SW: 7P6 919 603 C HW: 7P6 919 603 C
Component: DU8 SV Touch H26 0045
Serial number: VWZ8Z9M7900D6L
Subsystem 4 - Part No: 8R0 060 961
Component: CD-Database 1886
No fault code found.
-------------------------------------------------------------------------------
Address 62: Door, Rear Left (J388) Labels: None
Part No SW: 4H0 959 795 B HW: 4H0 959 795 B
Component: TSG HL H09 0167
Revision: -------- Serial number: 0000129597274
Coding: 011C17200000253005080000
Shop #: WSC 31414 790 00001
VCID: 3A71C4FAB551E791E7-806F
No fault code found.
-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502) Labels: 3Y0-907-273.clb
Part No SW: 7P6 907 273 F HW: 7P6 907 273 F
Component: RDKBERU25 H09 0008
Serial number: 10000000088981
ASAM Dataset: EV_RDKBERU25 003006
ROD: EV_RDKBERU25_VW52.rod
VCID: 3F87B5EEA673C2B9D0-806B
No fault code found.
-------------------------------------------------------------------------------
Address 69: Trailer (J345) Labels: None
Part No SW: 7P0 907 383 F HW: 7P0 907 383 B
Component: Anhaenger H09 0110
Revision: 5A001001 Serial number: 00000179994560
Coding: 020D000000000000
Shop #: WSC 31414 790 00001
VCID: 3B7FC1FEBA6BDE99FC-806F
No fault code found.
-------------------------------------------------------------------------------
Address 6C: Back-up Cam. (J928) Labels: 7P6-907-441-V1.clb
Part No SW: 7P6 907 441 D HW: 7P6 907 441 D_
Component: TopView H05 0097
Revision: 11001001 Serial number: 82330010114027
Coding: 0100000000010002010102000000
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_CamerSysteTopViewVW 001014
ROD: EV_CamerSysteTopViewVW.rod
VCID: 3A71C4FABD51E791E7-806F
1 Fault Found:
10489856 - No Basic Setting
B2010 00 [009] - -
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 119
Mileage: 153430 km
Date: 2017.05.25
Time: 16:13:59
Voltage terminal 30: 14.2 V
Terminal 15 status: Terminal 15 on
-------------------------------------------------------------------------------
Address 6D: Trunk Elect. (----) Labels: 7N0-959-107.clb
Part No SW: 7P6 959 107 A HW: 7P6 959 107
Component: HDSG-Modul H10 0620
Revision: 22010001 Serial number: 192200284
Coding: 0533314003
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_HeckkTouar 202137
ROD: EV_HeckkTouar.rod
VCID: 3D7BCFE6AC7FD0A9C2-8069
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right (J389) Labels: None
Part No SW: 4H0 959 795 B HW: 4H0 959 795 B
Component: TSG HR H09 0167
Revision: -------- Serial number: 0000129584962
Coding: 011C17200000253005080000
Shop #: WSC 31414 790 00001
VCID: 3A71C4FAB551E791E7-806F
No fault code found.
End-------------------------(Elapsed Time: 06:47)--------------------------
This is my current coding:
Code:
Friday,21,June,2019,21:51:30:03710
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64
VCDS Version: 19.6.0.2 (x64)
Data version: 20190529 DS308.0
www.Ross-Tech.com
VIN: WVGEP9BP7DD004878 License Plate: LANE-TAKE3
Mileage: 244482km-151914mi Repair Order:
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: BP-VW52 (7P6)
Scan: 01 02 03 05 08 09 10 15 16 17 19 36 3C 42 46 47 52 53 55 56
5F 62 65 69 6C 6D 72 85 8E
VIN: WVGEP9BP7DD004878 Mileage: 244482km-151914miles
01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
10-Park/Steer Assist -- Status: Not registered 0001
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
36-Seat Mem. Drvr -- Status: OK 0000
3C-Lane Change -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: Malfunction 0010
47-Sound System -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
5F-Information Electr. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
69-Trailer -- Status: OK 0000
6C-Back-up Cam. -- Status: Malfunction 0010
6D-Trunk Elect. -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
85-On Board Cam. -- Status: Not registered 0011
8E-Image Processing -- Status: Cannot be reached 0100
-------------------------------------------------------------------------------
Address 01: Engine (J623-CNRB) Labels:. 059-907-401-V2.clb
Part No SW: 7P0 907 401 K HW: 7P0 907 401 K
Component: 3.0TDI FSA H19 0011
Revision: 56H19---
Coding: 292A4012233600050000
Shop #: WSC 09145 444 00000
ASAM Dataset: EV_ECM30TDI0117P0907401K 001012
ROD: EV_ECM30TDI0117P0907401K.rod
VCID: 3777DDCE8E43FAF760-8062
1 Fault Found:
4332 - Check Coding of ECUs on Powertrain Data Bus
P1647 00 [039] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 244482 km
Date: 2019.06.21
Time: 21:45:27
Engine speed: 759.00 /min
Normed load value: 40.8 %
Vehicle speed: 0 km/h
Coolant temperature: 89 °C
Intake air temperature: 49 °C
Ambient air pressure: 980 mbar
Voltage terminal 30: 13.640 V
Unlearning counter according OBD: 40
ACC target acceleration: 0.000 m/s²
ACC control module received status-Bits 0-7: 6
Active brake system error status-Bits 0-7: 0
Status of ACC/CCS acceleration interface-Bits 0-7: 3
Acceleration: 0.000 m/s²
Engine status: COENG_RUNNING
Engine status-Test_Program_Co Eng st COMPU VERB UBYTE: 3
Readiness: 0 0 0 1 1
-------------------------------------------------------------------------------
Address 02: Auto Trans (J217) Labels:| 0C8-927-750.clb
Part No SW: 0C8 927 750 AK HW: 0C8 927 750 AK
Component: AL1000 AISIN 001 3398
Serial number:
Coding: 001368
Shop #: WSC 26340 002 1048576
ASAM Dataset: EV_TCMAL991031 002115
ROD: EV_TCMAL991031_002.rod
VCID: 75EB17C6D4CF48E7B2-8020
No fault code found.
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels:* 7P0-907-379.clb
Part No SW: 7P0 907 379 M HW: 7P0 907 379 A
Component: MK25A H36 0436
Revision: -------- Serial number: 420720010EC815
Coding: 5B7613C349242557DAFCC89A92DAA4407700
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_MK25AXT 008001
ROD: EV_ESPMK25A00800.rod
VCID: 4797AD0EFEA38A7710-8012
No fault code found.
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393) Labels:. 8K0-907-064-05.clb
Part No SW: 4H0 907 064 CK HW: 4H0 907 064 CK
Component: BCM2 2.0 H32 0421
Revision: 00002001
Coding: 0D860016000000000000
Shop #: WSC 31414 790 00001
VCID: 74ED2AC2D7B551EF85-8020
Subsystem 1 - Part No SW: 4H0 905 852 B HW: 4H0 905 852 B
Component: J764 ELV MLB H40 0046
Serial number: 2312000154943013
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:| 7P6-907-040.clb
Part No SW: 7P6 907 040 BK HW: 7P6 907 040 BK
Component: Klima 2 Zonen H20 1305
Coding: B686200A80
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_AirCondiFront 004001
ROD: EV_AirCondiFront_VW52.rod
VCID: 7EF908EAE1F90BBFE3-802A
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 4H0-907-063-V1.clb
Part No SW: 4H0 907 063 BL HW: 4H0 907 063 D
Component: BCM1 2.0 H12 0111
Revision: 15012002 Serial number: 00000001586921
Coding: 26001012933C5D010020180300005D0C431C660882010261000000020000
Shop #: WSC 31414 790 00001
VCID: 73EF29DED2BB56D79C-8026
Subsystem 1 - Part No SW: 7P0 955 119 HW: 7P0 955 119 Labels: 1KX-955-119.CLB
Component: WWS 120711 31 0020
Serial number: 90243400120719131750
Coding: 004DBD
Subsystem 2 - Part No SW: 7P0 955 559 D HW: 7P0 955 559 D Labels: 8K0-955-559.CLB
Component: RLFS H09 0011
Serial number: 10420600
Coding: 025223
Subsystem 3 - Part No SW: 7P6 941 431 AB HW: 7P6 941 431 AB
Component: E1 - LDS H02 0040
Serial number: 00000000002304140008
Subsystem 4 - Part No SW: 4H0 907 410 A HW: 4H0 907 410 A
Component: USHL4.2 H30 0020
Serial number: 0000001805569R16DW07
1 Fault Found:
01330 - Central Control Module for Central Convenience (J393)
013 - Check DTC Memory
Freeze Frame:
Fault Status: 01101101
Fault Priority: 6
Fault Frequency: 1
Reset counter: 120
Mileage: 244482 km
Time Indication: 0
Date: 2019.06.21
Time: 21:45:00
-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446) Labels:| 7P6-919-475.clb
Part No SW: 7P6 919 475 B HW: 7N0 919 475
Component: PARKHILFE 8K H05 0021
Revision: -------- Serial number: 28261219601184
Coding: 510501
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_VW526ParkiAssis2 001011
ROD: EV_VW526ParkiAssis2.rod
VCID: 4281BC1AD581AF5FC7-8016
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:| 7P0-959-655.clb
Part No SW: 7P0 959 655 C HW: 7P0 959 655 C
Component: VW10Airbag025 H05 0025
Revision: -------- Serial number: 003L0004ACDK
Coding: 000000000000000000000000000000003235
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_AirbaVW10BPAVW526 001001
ROD: EV_AirbaVW10BPAVW526_001.rod
VCID: 4183B316D087B447DE-8014
Seat occupied recognition:
Subsystem 1 - Part No SW: 7P6 959 339 HW: 7P6 959 339
Component: BF-Gewichtss. 003 0005
Serial number: 5850000R1242708U3B
Crash sensor for side airbag: driver side:
Serial number: 3575LRB40511G1DOBH33
Crash sensor for side airbag: front passenger side:
Serial number: 3585LRB405L1G1DM9HFW
Crash sensor for side airbag: rear: driver side:
Serial number: 3515RRB405J1D2ASDHN%
Crash sensor for side airbag: rear: passenger side:
Serial number: 3525RRB405J1D2ASMGM7
Crash sensor for front airbag: driver side:
Serial number: 3555NRB405R1GCDMCOFF
Crash sensor for front airbag: front passenger side:
Serial number: 3565NRB40631GCDM3PJW
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels:. 4H0-953-568.clb
Part No SW: 4H0 953 568 H HW: 4H0 953 568 H
Component: Lenks.Modul H05 0005
Revision: -------- Serial number: 90372PL900040
Coding: 000CDD
Shop #: WSC 12345 123 12345
VCID: 3875DEF28B5DF58F69-806C
Subsystem 1 - Part No SW: 7P6 959 542 HW: 7P6 959 542
Component: E221__MFL-TAS H03 0027
Serial number: 0201679
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 7P6-920-xxx-17.clb-SRI1
Part No SW: 7P6 920 981 F HW: 7P6 920 981 F
Component: Kombi H13 0318
Revision: 13240077 Serial number: 658100812592019
Coding: 8B7733022B00CF05020004
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_KombiUDSRBVW526 001017
ROD: EV_KombiUDSRBVW526.rod
VCID: 4085B612DB8DBD4FD1-8014
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:* None
Part No SW: 7P6 907 530 F HW: 7P6 907 530 F
Component: GW-CAN-L-MOST H11 6028
Revision: -------- Serial number: 00000000639722
Coding: 0001037500
Shop #: WSC 49771 001 104857
ASAM Dataset: EV_GatewVW526UDS 001007
ROD: EV_GatewUDS_VW52.rod
VCID: 3B7FC1FEB26BDE9784-806E
Battery Monitoring Control Module:
Subsystem 1 - Part No SW: 7P0 915 181 A HW: 7P0 915 181
Component: Batt_Sensor H07 0140
Serial number: 00000000005650867664
2 Faults Found:
0276 - FlexRay Databus
U1032 00 [009] - Initialization Failed
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 120
Mileage: 244482 km
Date: 2019.06.21
Time: 21:45:28
Voltage terminal 30: 13.6 V
Voltage terminal 15: 13.7 V
Control Module temperature: 42 °C
System status: Terminal 15 on
IN ESP_standstill flag: standstill detected
Engine running: On
IN ZAS_Te_X: On
Terminal 15 status via CAN: On
Terminal 15 status: On
Datenfeld: 0
0021 - Control Module Incorrectly Coded
U1014 00 [009] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 3
Fault Frequency: 1
Reset counter: 120
Mileage: 244482 km
Date: 2019.06.21
Time: 21:45:32
Voltage terminal 30: 13.7 V
Voltage terminal 15: 13.8 V
Control Module temperature: 42 °C
System status: Terminal 15 on
IN ESP_standstill flag: standstill detected
Engine running: On
IN ZAS_Te_X: On
Terminal 15 status via CAN: On
Terminal 15 status: On
Datenfeld: 0
-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr (J136) Labels: None
Part No SW: 4H0 959 760 D HW: 4H0 959 760 D
Component: MEM-FS H08 0153
Revision: AA000000 Serial number: 00000035065047
Coding: 00581B0000004001000001010101202020202121202020
Shop #: WSC 31414 790 00001
VCID: 346DEAC2973511EF45-8060
No fault code found.
-------------------------------------------------------------------------------
Address 3C: Lane Change Labels: Redir Fail!
Part No SW: 7P6 907 566 HW: 4H0 907 566
Component: J769 SWA MasterH02 0110
Revision: 00H02000 Serial number: 6PZ 010 316-01
Coding: 0010151
Shop #: WSC 01730 666 44235
VCID: 7EF908EA29F90BBFE3-802A
Subsystem 1 - Part No: 7P6 907 568
Component: J770 SWA Slave H01 0110
Subsystem 2 - Serial number: 6PZ 010 316-21
Subsystem 3 - Serial number: 5F26.09.0900H010003C520076ÿ
Subsystem 4 - Serial number: 520076ÿ
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:. 4H0-959-793.clb
Part No SW: 4H0 959 793 N HW: 4H0 959 793 F
Component: TSG FA H07 0166
Revision: -------- Serial number: 0000129655805
Coding: 011D17205E00453005080000
Shop #: WSC 31414 790 00001
VCID: 448DBA02C795A16FF5-8010
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv. (J393) Labels:. 4H0-907-064-46.clb
Part No SW: 4H0 907 064 CK HW: 4H0 907 064 CK
Component: BCM2 2.0 H32 0421
Revision: 00002001 Serial number: 0180526694
Coding: 0186123A28B9509580A00620210000000000000000000000000000000000
Shop #: WSC 31414 790 00001
VCID: 74ED2AC2D7B551EF85-8020
Subsystem 1 - Part No: 1K0 951 605 C
Component: LIN BACKUP HO H05 1501
1 Fault Found:
03021 - Local databus 3
012 - Electrical Fault in Circuit
Freeze Frame:
Fault Status: 01101100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 120
Mileage: 244482 km
Time Indication: 0
Date: 2019.06.21
Time: 21:45:31
-------------------------------------------------------------------------------
Address 47: Sound System (J525) Labels:. 8T0-035-223-BOM.clb
Part No SW: 7P6 035 466 HW: 7P6 035 466
Component: DSP Prem H01 0090
Revision: 00001001 Serial number: 10811001712705
VCID: 75EB17C6DCCF48E7B2-8020
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:. 4H0-959-792.clb
Part No SW: 4H0 959 792 F HW: 4H0 959 792 F
Component: TSG BF H07 0166
Revision: -------- Serial number: 0000129629168
Coding: 011D17205E00453005080000
Shop #: WSC 31414 790 00001
VCID: 3B7FC1FEBA6BDE9784-806E
No fault code found.
-------------------------------------------------------------------------------
Address 53: Parking Brake (J540-) Labels:| 7P0-907-801.clb
Part No SW: 7P0 907 801 F HW: 7P0 907 801 F
Component: EPB H51 1201
Revision: 00000000 Serial number: C1272700340
Coding: 01040200
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_ParkbA7 000006
ROD: EV_ParkbA7.rod
VCID: 3669D0CA894903FF7B-8062
Slave 3:
No fault code found.
-------------------------------------------------------------------------------
Address 55: Headlight Range (J745) Labels:. 7P6-907-357.clb
Part No SW: 7P6 907 357 HW: 7L6 907 357 C
Component: AFS-ECU H04 0110
Revision: -------- Serial number: --------------
Coding: 010A00010F000400
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_HeadlRegulVWAFS 005006
ROD: EV_HeadlRegulVWAFS_VW52.rod
VCID: 7CFD02E2F7E519AFCD-8028
Left_headlamp_power_output_stage:
Subsystem 1 - Part No SW: 8U0 941 329 HW: 8U0 941 329 Labels: 3D0-941-329.CLB
Component: LeiMo links H01 0002
Coding: 130000
Right_headlamp_power_output_stage:
Subsystem 2 - Part No SW: 8U0 941 329 HW: 8U0 941 329 Labels: 3D0-941-329.CLB
Component: LeiMo rechts H01 0002
Coding: 130000
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (R) Labels: Redir Fail!
Part No SW: 4G0 035 082 G HW: 4G0 035 082
Component: Radio U SIRIU H60 0133
Revision: AB001007 Serial number: 156G10C7618771
Coding: 020007010000000001
Shop #: WSC 31414 790 00001
VCID: 244D1A8227D5816FD5-8070
No fault code found.
-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794) Labels:. 4E0-035-6xx-5F.clb
Part No SW: 7P6 035 664 D HW: 7P6 035 664
Component: H-BN-NA H45 0706
Revision: -------- Serial number: 445HB0C7538995
Coding: 020200050040E1EF41022B0E00000003F00001030000000000
Shop #: WSC 43979 001 104857
VCID: 3973DBF6B057EC8796-806C
Subsystem 1 - Part No: 7P6 060 884 D
Component: NAR 2016 1302
Subsystem 2 - Part No SW: 7P6 919 603 C HW: 7P6 919 603 C
Component: DU8 SV Touch H26 0045
Serial number: VWZ8Z9M7900D6L
Subsystem 3 - Part No SW: 7P6 919 603 C HW: 7P6 919 603 C
Component: DU8 SV Touch H26 0045
Serial number: VWZ8Z9M7900D6L
Subsystem 4 - Part No: 8R0 060 961
Component: CD-Database 1886
No fault code found.
-------------------------------------------------------------------------------
Address 62: Door, Rear Left (J388) Labels:. 4H0-959-795.clb
Part No SW: 4H0 959 795 B HW: 4H0 959 795 B
Component: TSG HL H09 0167
Revision: -------- Serial number: 0000129597274
Coding: 011C17200000253005080000
Shop #: WSC 31414 790 00001
VCID: 3A71C4FAB551E79F9F-806E
No fault code found.
-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502) Labels: 3Y0-907-273.clb
Part No SW: 7P6 907 273 F HW: 7P6 907 273 F
Component: RDKBERU25 H09 0008
Serial number: 10000000088981
ASAM Dataset: EV_RDKBERU25 003006
ROD: EV_RDKBERU25_VW52.rod
VCID: 3F87B5EEA673C2B7A8-806A
No fault code found.
-------------------------------------------------------------------------------
Address 69: Trailer (J345) Labels: Redir Fail!
Part No SW: 7P0 907 383 F HW: 7P0 907 383 B
Component: Anhaenger H09 0110
Revision: 5A001001 Serial number: 00000179994560
Coding: 020D000000000000
Shop #: WSC 31414 790 00001
VCID: 3B7FC1FEBA6BDE9784-806E
No fault code found.
-------------------------------------------------------------------------------
Address 6C: Back-up Cam. (J928) Labels:| 7P6-907-441-V1.clb
Part No SW: 7P6 907 441 D HW: 7P6 907 441 D_
Component: TopView H05 0097
Revision: 11001001 Serial number: 82330010114027
Coding: 0100000000010002010102000000
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_CamerSysteTopViewVW 001014
ROD: EV_CamerSysteTopViewVW.rod
VCID: 3A71C4FABD51E79F9F-806E
1 Fault Found:
10489856 - No Basic Setting
B2010 00 [009] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 120
Mileage: 244482 km
Date: 2019.06.21
Time: 21:45:28
Voltage terminal 30: 13.8 V
Terminal 15 status: Terminal 15 on
-------------------------------------------------------------------------------
Address 6D: Trunk Elect. (----) Labels:| 7N0-959-107.clb
Part No SW: 7P6 959 107 A HW: 7P6 959 107
Component: HDSG-Modul H10 0620
Revision: 22010001 Serial number: 192200284
Coding: 0533314003
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_HeckkTouar 202137
ROD: EV_HeckkTouar.rod
VCID: 3D7BCFE6AC7FD0A7BA-8068
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right (J389) Labels:. 4H0-959-795.clb
Part No SW: 4H0 959 795 B HW: 4H0 959 795 B
Component: TSG HR H09 0167
Revision: -------- Serial number: 0000129584962
Coding: 011C17200000253005080000
Shop #: WSC 31414 790 00001
VCID: 3A71C4FAB551E79F9F-806E
No fault code found.
-------------------------------------------------------------------------------
Address 85: On Board Cam. (J852) Labels:| 7P6-907-217.clb
Part No SW: 7P6 907 217 B HW: 7P6 907 217
Component: DPC-SG H24 0035
Revision: -------- Serial number: 262130025421000
Coding: 4D070000
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_OnBoardCamerDTR 001001
ROD: EV_OnBoardCamerDTR.rod
VCID: 3973DBF6B857EC8796-806C
Slave 1:
Subsystem 1 - Part No: 7P6 907 658
Component: NICKRATENSENS H02 0001
Serial number: 000000007056214_4330
4 Faults Found:
0719 - Function Restriction due to Faults in Other Modules
U1113 00 [009] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 1
Reset counter: 120
Mileage: 244482 km
Date: 2019.06.21
Time: 21:45:29
Outside air temperature: -36.5 °C
Voltage terminal 15: 13.7 V
Control Module temperature: 41.0 °C
0706 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 1
Reset counter: 120
Mileage: 244482 km
Date: 2019.06.21
Time: 21:45:29
Outside air temperature: -36.5 °C
Voltage terminal 15: 13.7 V
Control Module temperature: 41.0 °C
0724 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 1
Reset counter: 120
Mileage: 244482 km
Date: 2019.06.21
Time: 21:45:29
Outside air temperature: -36.5 °C
Voltage terminal 15: 13.7 V
Control Module temperature: 41.0 °C
0734 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[New feature! Extended UDS fault detail is only supported by current gen. interfaces]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 1
Reset counter: 120
Mileage: 244482 km
Date: 2019.06.21
Time: 21:45:29
Outside air temperature: -36.5 °C
Voltage terminal 15: 13.7 V
Control Module temperature: 41.0 °C
-------------------------------------------------------------------------------
Address 8E: Image Processing
Cannot be reached
End-------------------------(Elapsed Time: 05:30)--------------------------
I'm getting some odd errors, in particular the engine malfunction code, which shouldn't have been affected by my installation. Obviously the CAN Gateway malfunction and Central Conv. malfunctions are a concern, as the coding may not be quite right with them as of yet. There are some Not Registered errors as well... the on-board cam, which I know has to be calibrated, so I'm assuming that's the issue, but I don't know.
I plan on going back this weekend and verifying the wiring from the Image Processor and the Pitch Sensor. I was pretty careful. All the wiring matched ELSA's color coding, and I checked the pinouts several times. Only thing I can think of is that a pin may have gotten pulled loose.
I know this is a lot, but I would appreciate any help. I know this is possible. There is a thread here where someone did it to a Q5, which is really just a more expensive Touareg.