Page 1 of 2 12 LastLast
Results 1 to 10 of 14

Thread: 2006 A4 Avant Quattro, APR stage 2+ 160K miles

  1. #1
    Verified VCDS User
    Join Date
    Jan 2018
    Location
    USA
    Posts
    7
    Post Thanks / Like

    2006 A4 Avant Quattro, APR stage 2+ 160K miles

    Good afternoon all, tried to follow instructions as close as possible for new posts. I'm seeking help as a means to learn the VCDS better and diagnose properly. Too busy fixing chevy trucks here in AR to work on my own stuff and learn by myself...need some training.

    Car ran fine until recently. Noticed a loss of power and CEL came on for P310B. I know its a common problem but I'm not throwing parts at this. Vehicle came with AutoZone DElphi LPFP which has worked fine for 2 yrs. After code came on, they gave me a new fuel pump. Installed it and now the car only runs for about 10 min then shuts off. Then it becomes hard to start. If it does start, it will only run for a few minutes and shut down. If it sits until cool, it will restart & the process starts all over again.

    I'm not replacing parts just bc they aren't OEM. I agreed to some degree aftermarket aren't the best, but that's not an excuse to replace parts...I want to learn this system and actually diagnose this problem. I need to prove a bad part as best as possible.

    Code:
    Tuesday,11,June,2019,13:13:43:19959
    VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
    VCDS Version: 19.6.0.5 (x64)  HEX-NET CB: 0.4505.4
    Data version: 20190529 DS308.0
    www.Ross-Tech.com
    
    
    VIN: WAUKF78E96xxxxx   License Plate: 
    
    
    Chassis Type: 8E (8E - Audi A4/S4/RS4 B6/B7 (2001 > 2008))
    Scan: 01 02 03 08 09 0F 11 15 16 17 18 25 36 37 45 46 55 56 57 65
              67 69 75 76 77
     
    VIN: WAUKF78E96A159082   Mileage: 258470km-160605miles
    -------------------------------------------------------------------------------
    Address 01: Engine        Labels:. 06F-907-115-AXX.clb
       Part No SW: 8E0 910 115 M    HW: 8E0 907 115 D
       Component: 2.0l R4/4V TFSI     0070  
       Revision: --H10---    Serial number:               
       Coding: 010C010A190F0120
       Shop #: WSC 25324 444 54344
       VCID: AB1668C70A48471793-80FE
    
    2 Faults Found:
    000256 - Mass Air Flow Sensor (G70) 
                   P0100 - 004 - Supply Voltage - Intermittent
                 Freeze Frame:
                        Fault Status: 00100100
                        Fault Priority: 0
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 258478 km
                        Time Indication: 0
    
                 Freeze Frame:
                        RPM: 0 /min
                        Load: 0.0 %
                        Speed: 0.0 km/h
                        Temperature: 24.0°C
                        Temperature: 28.0°C
                        Absolute Pres.: 1000.0 mbar
                        Voltage: 12.192 V
    
    012555 - Low Pressure Fuel regulation 
                   P310B - 008 - Fuel Pressure Outside Specification - MIL ON
                 Freeze Frame:
                        Fault Status: 11101000
                        Fault Priority: 0
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 258478 km
                        Time Indication: 0
    
                 Freeze Frame:
                        RPM: 949 /min
                        Load: 29.4 %
                        Speed: 0.0 km/h
                        Temperature: 25.0°C
                        Temperature: 27.0°C
                        Absolute Pres.: 1000.0 mbar
                        Voltage: 13.716 V
    
    Readiness: 0000 0101
    
    -------------------------------------------------------------------------------
    Address 02: Auto Trans        Labels: 09L-927-760.lbl
       Part No SW: 8E1 910 156 C    HW: 09L 927 156 B
       Component: AG6 09L 2.0TFSI USA 0030  
       Revision: --H01---    Serial number:        4115320
       Coding: 0000002
       Shop #: WSC 06325 000 00000
       VCID: A71E94F716A0637777-80F2
    
    1 Fault Found:
    009783 - Torque Management Feedback Signal A 
                   P2637 - 000 -  - Intermittent
                 Freeze Frame:
                        Fault Status: 00100000
                        Fault Priority: 0
                        Fault Frequency: 8
                        Reset counter: 39
                        Mileage: 253756 km
                        Time Indication: 0
    
                 Freeze Frame:
                        RPM: 0 /min
                        RPM: 96 /min
                        RPM: 0 /min
                        (no units): 30.0
                        (no units): 25.0
                        Temperature: 48.0°C
                        T.B. Angle: 0.0°
    
    
    -------------------------------------------------------------------------------
    Address 03: ABS Brakes        Labels: 8E0-910-517.clb
       Part No SW: 8E0 910 517 E    HW: 8E0 614 517 AL
       Component: ESP8 quattro    H05 0120  
       Revision: 00000000    Serial number: 00000000000000
       Coding: 0004528
       Shop #: WSC 06325 000 00000
       VCID: A91A92CF00B4550761-80FC
    
    1 Fault Found:
    18265 - Load Signal 
                P1857 - 000 - Error Message from ECU - Intermittent
                 Freeze Frame:
                        Fault Status: 00100000
                        Fault Priority: 2
                        Fault Frequency: 21
                        Reset counter: 40
                        Time Indication: 0
    
                 Freeze Frame:
                        Hex Value: 0x3500
                        Hex Value: 0x4006
                        Hex Value: 0x0028
                        Hex Value: 0x01A8
                        Hex Value: 0x0001
    
    
    -------------------------------------------------------------------------------
    Address 08: Auto HVAC        Labels: 8E0-820-043.lbl
       Part No: 8E0 820 043 BM
       Component:   A4 Klimaautomat   2832  
       Coding: 00000
       Shop #: WSC 00000  
       VCID: ED92A6DFA5DC8927CD-50D0
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 09: Cent. Elect.        Labels: 8E0-907-279-8EC.lbl
       Part No: 8E0 907 279 L
       Component: int. Lastmodul  USA 0504  
       Coding: 11023
       Shop #: WSC 65536  
       VCID: BB365887AB28D79703-4AA4
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 15: Airbags        Labels: 8E0-959-655-94.lbl
       Part No SW: 8E0 959 655 H    HW: 8E0 959 655 H
       Component:    Airbag 9.41  H11 3540  
       Revision: 91H1135    Serial number: 0036N0016SH+  
       Coding: 0032607
       Shop #: WSC 06325 000 00000
       VCID: BC345B9BFF26D0AF0A-80E8
    
       Subsystem 1 - Part No: 8E0 910 339 B
       Component: BF-Gewichtsens. 002 0070
    
       Subsystem 2 - Serial number: 363UT         
    
       Subsystem 3 - Serial number: 0001.01.000000200000000000˙†63
    
       Subsystem 4 - Serial number: 000000˙†6332DRB40275900FL˙†63
    
       Subsystem 5 - Serial number: 5900FL˙†6342DRB40275C98B ˙†63
    
       Subsystem 6 - Serial number: 5C98B ˙†6352ARB400B501436˙†63
    
       Subsystem 7 - Serial number: 501436˙†6362ARB400B39287N˙†63
    
       Subsystem 8 - Serial number: 39287N˙†63729RB400C57256K˙†63
    
       Subsystem 9 - Serial number: 57256K˙†63829RB400C57219K˙
    
       Subsystem 10 - Serial number: 57219K˙
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 16: Steering wheel        Labels: 8E0-953-549.lbl
       Part No: 8E0 953 549 Q
       Component: Lenksįulenmodul     0601  
       Coding: 04042
       Shop #: WSC 06325  
       VCID: C1CA2A6FC9C4BD4759-4AA4
    
    1 Fault Found:
    01304 - Radio 
                49-10 - No Communications - Intermittent
    
    -------------------------------------------------------------------------------
    Address 17: Instruments        Labels: 8E0-920-9xx-8EC.lbl
       Part No SW: 8E0 920 982 F    HW: 8E0 920 982 F
       Component: KOMBI+WFS 4     H12 0110  
       Revision: 0110        Serial number: 00000000000000
       Coding: 0023241
       Shop #: WSC 25324 444 84418
       VCID: B12A7AAF29642DC7A9-50F4
    
    1 Fault Found:
    01304 - Radio 
                004 - No Signal/Communication - Intermittent
    
    -------------------------------------------------------------------------------
    Address 25: Immobilizer        Labels: 8E0-920-9xx-8EC.lbl
       Part No SW: 8E0 920 982 F    HW: 8E0 920 982 F
       Component: KOMBI+WFS 4     H12 0110  
       Revision: 0110        Serial number: 00000000000000
       Coding: 0023241
       Shop #: WSC 25324 444 84418
       VCID: B12A7AAF29642DC7A9-5118
    
    1 Fault Found:
    01304 - Radio 
                004 - No Signal/Communication - Intermittent
    
    -------------------------------------------------------------------------------
    Address 36: Seat Mem. Drvr        Labels: 8E0-959-760.lbl
       Part No: 8E0 959 760 
       Component: Sitzmemory R2 F     0305  
       Coding: 00002
       Shop #: WSC 00000  
       VCID: F1AABAAFBAE46DC7E9-4B3C
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 46: Central Conv.        Labels:. 8E0-959-433-MAX.clb
       Part No: 8E0 959 433 BT
       Component: Komfortgerįt T7B    3332  
       Coding: 12156
       Shop #: WSC 06325  
       VCID: 8444E37B9656686F32-4AA4
    
       Subsystem 1 - Part No: 8E1959801G
       Component: Tõrsteuer.FS BRM 0506  
    
       Subsystem 2 - Part No: 8E1959802E
       Component: Tõrsteuer.BF BRM 0205  
    
       Subsystem 3 - Part No: 8E0959801E
       Component: Tõrsteuer.HL BRM 0606  
    
       Subsystem 4 - Part No: 8E0959802E
       Component: Tõrsteuer.HR BRM 0606  
    
    1 Fault Found:
    01572 - Alarm triggered by Door Contact Switch; Passenger Side 
                35-00 - -
    
    -------------------------------------------------------------------------------
    Address 55: Headlight Range        Labels: 4F0-910-357.lbl
       Part No SW: 4F0 910 357 E    HW: 4F0 907 357 E
       Component: AFS 1           H01 0010  
       Revision: 00000001    Serial number:               
       Coding: 0000019
       Shop #: WSC 06325 000 00000
       VCID: A81C97CB1BBE6C0F7E-80FC
    
       Subsystem 1 - Part No: 8E0 941 329 
       Component: AFS-Modul links H03 0020
    
       Subsystem 2 - Part No: 8E0 941 329 
       Component: AFS-Modul rechtsH03 0020
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 77: Telephone        Labels: 8P0-862-335.lbl
       Part No SW: 8P0 862 335 G    HW: 8P0 862 335 G
       Component: FSE_255x BT     H21 0190  
       Revision: 00000001    Serial number: 00000000348880
       Coding: 0001677
       Shop #: WSC 06325 000 00000
       VCID: BA385D83F412EE9F18-50D0
    
    1 Fault Found:
    01304 - Radio 
                004 - No Signal/Communication - Intermittent
                 Freeze Frame:
                        Fault Status: 00100100
                        Fault Priority: 5
                        Fault Frequency: 1
                        Reset counter: 158
                        Time Indication: 15
    
    
    End----------(Elapsed Time: 05:13, VBatt start/end: 12.8V/12.8V)-----------

  2. #2
    VCDS Distributor
    Join Date
    Sep 2014
    Location
    UK
    Posts
    340
    Post Thanks / Like
    Are you seeing sensible live values for Fuel Pressure in Measuring Blocks?
    If you click the Advanced Measuring Values button, it should show a list of live data offered and hopefully you can find fuel pressure listed.

    Your MAF fault may also be responsible for the engine cutting out.

  3. Likes Uwe, Jack@European_Parts liked this post
  4. #3
    Verified VCDS User
    Join Date
    Jan 2018
    Location
    USA
    Posts
    7
    Post Thanks / Like
    I agree with the MAF issue causing same problem. I slaved in a known good one and came up with same result.
    blk 106
    field 1 = 50 bar at idle
    field 2 = 83.1 at idle. I know that is high. thinking bc its a delphi pump.
    after shut down and a heat soak I drop to 3 bar in field 1.

    blk 140 hpfp
    field 3 = 50 bar

    blk 230 field 3 = deviation .01-1
    high side seems to be fine

    I had the VCDS hooked up when it died this last time but don't know to how retrieve that data...

    maybe I need to look at the MAF after it cools down again instead of fuel pressure...i'm not eliminating that as the culprit...It acted the same way the last time it went bad.

    btw, I'm trying to get the erWin data but cant seem to figure out how to download the manual I need or get a price for the subscription...

  5. #4
    VCDS Distributor
    Join Date
    Sep 2014
    Location
    UK
    Posts
    340
    Post Thanks / Like
    From your post, it sounds like you may have already seen the Ross-Tech Wiki page on this but here is the link for reference:
    http://wiki.ross-tech.com/wiki/index...cial_Functions

    If you have already tried a different MAF, you can probably rule that out for the moment. Did the MAF fault code go away when you fitted the borrowed sensor?

    Before the Fuel Pump was changed, the car ran ok but just threw up pressure faults, is that correct? Or did it have the same cutting-out symptoms as now?

  6. #5
    NostraJackAss Jack@European_Parts's Avatar
    Join Date
    Jan 2014
    Location
    1001 State Route 17K Montgomery New York 12549
    Posts
    16,802
    Post Thanks / Like
    Address 01: Engine Labels:. 06F-907-115-AXX.clb
    Part No SW: 8E0 910 115 M HW: 8E0 907 115 D
    Component: 2.0l R4/4V TFSI 0070 <<<<<<<<<<<<<<<<<<<<<<<<<<<< FIRMWARE UPDATE NEEDED!
    Revision: --H10--- Serial number:
    Coding: 010C010A190F0120
    Shop #: WSC 25324 444 54344
    VCID: AB1668C70A48471793-80FE
    2006 A4 Avant Quattro, APR stage 2+ 160K miles

    Good afternoon all, tried to follow instructions as close as possible for new posts. I'm seeking help as a means to learn the VCDS better and diagnose properly. Too busy fixing chevy trucks here in AR to work on my own stuff and learn by myself...need some training.

    Car ran fine until recently. Noticed a loss of power and CEL came on for P310B. I know its a common problem but I'm not throwing parts at this. Vehicle came with AutoZone DElphi LPFP which has worked fine for 2 yrs. After code came on, they gave me a new fuel pump. Installed it and now the car only runs for about 10 min then shuts off. Then it becomes hard to start. If it does start, it will only run for a few minutes and shut down. If it sits until cool, it will restart & the process starts all over again.

    I'm not replacing parts just bc they aren't OEM. I agreed to some degree aftermarket aren't the best, but that's not an excuse to replace parts...I want to learn this system and actually diagnose this problem. I need to prove a bad part as best as possible.

    I agree with the MAF issue causing same problem. I slaved in a known good one and came up with same result.
    blk 106
    field 1 = 50 bar at idle
    field 2 = 83.1 at idle. I know that is high. thinking bc its a delphi pump.
    after shut down and a heat soak I drop to 3 bar in field 1.

    blk 140 hpfp
    field 3 = 50 bar

    blk 230 field 3 = deviation .01-1
    high side seems to be fine

    I had the VCDS hooked up when it died this last time but don't know to how retrieve that data...

    maybe I need to look at the MAF after it cools down again instead of fuel pressure...i'm not eliminating that as the culprit...It acted the same way the last time it went bad.

    btw, I'm trying to get the erWin data but cant seem to figure out how to download the manual I need or get a price for the subscription...
    Vehicle Identification No. WAUKF78E96A159082
    Model audi a4 av. qu. 2,0
    A4
    Date of production 06.12.2005
    Model year 2006
    Sales type 8ED5EL
    Engine Code BPG
    Transmission Code JJE

    Emission standard 7GB Emission standard ULEV 2


    OP: Can you clear fault codes and re-post the new auto-scan & with additionally the OBD2 data MODES 1-01, 3, 7 & 9 please?

    OP: Have you checked to be sure the integrated FPR in fuel filter is working as specified with new lift pump & for volume using mechanical tests such as gauges and V-metric confirmed delivery?

    OP: Did you check the fuel module control unit for proper function ground and ability carry AMP load capacity to lift pump & did you measure the duty cycle with DVOM or observe in VCDS?

    OP: Is the mechanical HPP in proper order & stroke of lifter or cam ramp correct?

    JPPSG lately?

    https://forums.ross-tech.com/showthr...uot-JPPSG-quot

    Tuning by definition is induced FOD!


    Check for ECU water ingress!
    European Parts Emporium/Performance / Immobilizer Solutions EPE
    Certified Master Trained NY/BAR/BAD 7076062/ASE/SAE/NASTF Legal Factory Authorized/Licensed GeKo/FaZit # 403738
    Specializing in Custom Services IE: "welding-fabrication" / EPA-SMOG Update or Pass-Thru-Programming / Data Transfer / Immobilizers & OEM Quality Parts
    Above Magic! No Written record, AUTO-SCAN or Appointment = NO HELP!
    www.FixMyEuro.com <<<<<CLICK HERE! or vwemporium@aol.com ( JPPSG & Unverified members need not PM me & Please don't email or call facility for free tech support...use the forum )
    Getting you CONTROL again of your property - TAKE IT! In Conjunction with.........

  7. #6
    Verified VCDS User
    Join Date
    Jan 2018
    Location
    USA
    Posts
    7
    Post Thanks / Like
    I did follow that guide and took notes of pressure settings waiting for the engine to die and hopefully capture the cause. The MAF code came on bc I started the engine with the MAF connector disconnected after swapping it and didn't erase it.

    So the engine ran ok but at lower power than normal. Stage 2 on this engine is like a bull out of the gates, it began to accelerate slower and took longer to get up to speed. It never cut out though.

  8. #7
    Verified VCDS User
    Join Date
    Jan 2018
    Location
    USA
    Posts
    7
    Post Thanks / Like
    Ok...first off, Im having no luck getting a service manual for this car. Andy (Rosstech) confirmed to me this morning that Bentley has been superseded by erWin (and doesn't provide good data on the FSI engine) and I cant figure out the website to get the troubleshooting data I need. I'm continuing efforts to get that data...

    I will try to start engine, clear codes and repost data requested. Not sure about the OBD2 data modes requested. I'll search for those.

    I haven't taken FPFP off yet bc I'm pulling data first. Its on my visual check list though.

    I have not checked the FPR in the filter yet. I have not checked volumetric efficiency bc I don't have tech data to tell me what to expect.

    VCDS showed 83.1 duty cycle at idle if that's what you're asking.

    Jack, I did read your post about FOD in the ecu...I will do an inspection of the part. I've done plenty of FOD walks on the flight line keeping our B52s flying.

    Code:
    Tuesday,11,June,2019,16:49:27:19959
    VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
    VCDS Version: 19.6.0.5 (x64)  HEX-NET CB: 0.4505.4
    Data version: 20190529 DS308.0
    www.Ross-Tech.com
    
    
    VIN: WAUKF78E96A159082   License Plate: 
    Mileage: 258470km-160605mi   Repair Order: 
    
    
    Chassis Type: 8E (8E - Audi A4/S4/RS4 B6/B7 (2001 > 2008))
    Scan: 01 02 03 08 09 0F 11 15 16 17 18 25 36 37 45 46 55 56 57 65
              67 69 75 76 77
     
    VIN: WAUKF78E96A159082   Mileage: 258470km-160605miles
    -------------------------------------------------------------------------------
    Address 01: Engine        Labels:. 06F-907-115-AXX.clb
       Part No SW: 8E0 910 115 M    HW: 8E0 907 115 D
       Component: 2.0l R4/4V TFSI     0070  
       Revision: --H10---    Serial number:               
       Coding: 010C010A190F0120
       Shop #: WSC 25324 444 54344
       VCID: AB1668C70A48471793-80FE
    
    1 Fault Found:
    012555 - Low Pressure Fuel regulation 
                   P310B - 008 - Fuel Pressure Outside Specification
                 Freeze Frame:
                        Fault Status: 01101000
                        Fault Priority: 0
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 258479 km
                        Time Indication: 0
    
                 Freeze Frame:
                        RPM: 944 /min
                        Load: 24.7 %
                        Speed: 0.0 km/h
                        Temperature: 36.0°C
                        Temperature: 31.0°C
                        Absolute Pres.: 1000.0 mbar
                        Voltage: 13.843 V
    
    Readiness: 0000 0101
    
    -------------------------------------------------------------------------------
    Address 02: Auto Trans        Labels: 09L-927-760.lbl
       Part No SW: 8E1 910 156 C    HW: 09L 927 156 B
       Component: AG6 09L 2.0TFSI USA 0030  
       Revision: --H01---    Serial number:        4115320
       Coding: 0000002
       Shop #: WSC 06325 000 00000
       VCID: A71E94F716A0637777-80F2
    
    1 Fault Found:
    009783 - Torque Management Feedback Signal A 
                   P2637 - 000 -  - Intermittent
                 Freeze Frame:
                        Fault Status: 00100000
                        Fault Priority: 0
                        Fault Frequency: 8
                        Reset counter: 39
                        Mileage: 253756 km
                        Time Indication: 0
    
                 Freeze Frame:
                        RPM: 0 /min
                        RPM: 96 /min
                        RPM: 0 /min
                        (no units): 30.0
                        (no units): 25.0
                        Temperature: 48.0°C
                        T.B. Angle: 0.0°
    
    
    -------------------------------------------------------------------------------
    Address 03: ABS Brakes        Labels: 8E0-910-517.clb
       Part No SW: 8E0 910 517 E    HW: 8E0 614 517 AL
       Component: ESP8 quattro    H05 0120  
       Revision: 00000000    Serial number: 00000000000000
       Coding: 0004528
       Shop #: WSC 06325 000 00000
       VCID: A91A92CF00B4550761-80FC
    
    1 Fault Found:
    18265 - Load Signal 
                P1857 - 000 - Error Message from ECU - Intermittent
                 Freeze Frame:
                        Fault Status: 00100000
                        Fault Priority: 2
                        Fault Frequency: 21
                        Reset counter: 40
                        Time Indication: 0
    
                 Freeze Frame:
                        Hex Value: 0x3500
                        Hex Value: 0x4006
                        Hex Value: 0x0028
                        Hex Value: 0x01A8
                        Hex Value: 0x0001
    
    
    -------------------------------------------------------------------------------
    Address 08: Auto HVAC        Labels: 8E0-820-043.lbl
       Part No: 8E0 820 043 BM
       Component:   A4 Klimaautomat   2832  
       Coding: 00000
       Shop #: WSC 00000  
       VCID: ED92A6DFA5DC8927CD-50D0
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 09: Cent. Elect.        Labels: 8E0-907-279-8EC.lbl
       Part No: 8E0 907 279 L
       Component: int. Lastmodul  USA 0504  
       Coding: 11023
       Shop #: WSC 65536  
       VCID: BB365887AB28D79703-4AA4
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 15: Airbags        Labels: 8E0-959-655-94.lbl
       Part No SW: 8E0 959 655 H    HW: 8E0 959 655 H
       Component:    Airbag 9.41  H11 3540  
       Revision: 91H1135    Serial number: 0036N0016SH+  
       Coding: 0032607
       Shop #: WSC 06325 000 00000
       VCID: BC345B9BFF26D0AF0A-80E8
    
       Subsystem 1 - Part No: 8E0 910 339 B
       Component: BF-Gewichtsens. 002 0070
    
       Subsystem 2 - Serial number: 363UT         
    
       Subsystem 3 - Serial number: 0001.01.000000200000000000˙†63
    
       Subsystem 4 - Serial number: 000000˙†6332DRB40275900FL˙†63
    
       Subsystem 5 - Serial number: 5900FL˙†6342DRB40275C98B ˙†63
    
       Subsystem 6 - Serial number: 5C98B ˙†6352ARB400B501436˙†63
    
       Subsystem 7 - Serial number: 501436˙†6362ARB400B39287N˙†63
    
       Subsystem 8 - Serial number: 39287N˙†63729RB400C57256K˙†63
    
       Subsystem 9 - Serial number: 57256K˙†63829RB400C57219K˙
    
       Subsystem 10 - Serial number: 57219K˙
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 16: Steering wheel        Labels: 8E0-953-549.lbl
       Part No: 8E0 953 549 Q
       Component: Lenksįulenmodul     0601  
       Coding: 04042
       Shop #: WSC 06325  
       VCID: C1CA2A6FC9C4BD4759-4AA4
    
    1 Fault Found:
    01304 - Radio 
                49-10 - No Communications - Intermittent
    
    -------------------------------------------------------------------------------
    Address 17: Instruments        Labels: 8E0-920-9xx-8EC.lbl
       Part No SW: 8E0 920 982 F    HW: 8E0 920 982 F
       Component: KOMBI+WFS 4     H12 0110  
       Revision: 0110        Serial number: 00000000000000
       Coding: 0023241
       Shop #: WSC 25324 444 84418
       VCID: B12A7AAF29642DC7A9-5118
    
    1 Fault Found:
    01304 - Radio 
                004 - No Signal/Communication - Intermittent
    
    -------------------------------------------------------------------------------
    Address 25: Immobilizer        Labels: 8E0-920-9xx-8EC.lbl
       Part No SW: 8E0 920 982 F    HW: 8E0 920 982 F
       Component: KOMBI+WFS 4     H12 0110  
       Revision: 0110        Serial number: 00000000000000
       Coding: 0023241
       Shop #: WSC 25324 444 84418
       VCID: B12A7AAF29642DC7A9-5118
    
    1 Fault Found:
    01304 - Radio 
                004 - No Signal/Communication - Intermittent
    
    -------------------------------------------------------------------------------
    Address 36: Seat Mem. Drvr        Labels: 8E0-959-760.lbl
       Part No: 8E0 959 760 
       Component: Sitzmemory R2 F     0305  
       Coding: 00002
       Shop #: WSC 00000  
       VCID: F1AABAAFBAE46DC7E9-4B3C
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 46: Central Conv.        Labels:. 8E0-959-433-MAX.clb
       Part No: 8E0 959 433 BT
       Component: Komfortgerįt T7B    3332  
       Coding: 12156
       Shop #: WSC 06325  
       VCID: 8444E37B9656686F32-4AA4
    
       Subsystem 1 - Part No: 8E1959801G
       Component: Tõrsteuer.FS BRM 0506  
    
       Subsystem 2 - Part No: 8E1959802E
       Component: Tõrsteuer.BF BRM 0205  
    
       Subsystem 3 - Part No: 8E0959801E
       Component: Tõrsteuer.HL BRM 0606  
    
       Subsystem 4 - Part No: 8E0959802E
       Component: Tõrsteuer.HR BRM 0606  
    
    1 Fault Found:
    01572 - Alarm triggered by Door Contact Switch; Passenger Side 
                35-00 - -
    
    -------------------------------------------------------------------------------
    Address 55: Headlight Range        Labels: 4F0-910-357.lbl
       Part No SW: 4F0 910 357 E    HW: 4F0 907 357 E
       Component: AFS 1           H01 0010  
       Revision: 00000001    Serial number:               
       Coding: 0000019
       Shop #: WSC 06325 000 00000
       VCID: A81C97CB1BBE6C0F7E-80FC
    
       Subsystem 1 - Part No: 8E0 941 329 
       Component: AFS-Modul links H03 0020
    
       Subsystem 2 - Part No: 8E0 941 329 
       Component: AFS-Modul rechtsH03 0020
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 77: Telephone        Labels: 8P0-862-335.lbl
       Part No SW: 8P0 862 335 G    HW: 8P0 862 335 G
       Component: FSE_255x BT     H21 0190  
       Revision: 00000001    Serial number: 00000000348880
       Coding: 0001677
       Shop #: WSC 06325 000 00000
       VCID: BA385D83F412EE9F18-50D0
    
    1 Fault Found:
    01304 - Radio 
                004 - No Signal/Communication - Intermittent
                 Freeze Frame:
                        Fault Status: 00100100
                        Fault Priority: 5
                        Fault Frequency: 1
                        Reset counter: 158
                        Time Indication: 15
    
    
    End----------(Elapsed Time: 05:12, VBatt start/end: 14.0V/14.0V)-----------
    Code:
    Tuesday,11,June,2019,16:56:19:19959
    VCDS Release 19.6.0 (x64):  Generic OBD2
    Mode 01 - PID 01 : Readiness  --  Address 7E8
    
    Number of DTCs stored: 0  --  MIL Status: MIL OFF
    Misfire monitoring:  Passed
    Fuel System:  Passed
    Comprehensive Components:  Passed
    Catalyst monitoring:  Failed or Incomplete
    Heated catalyst monitoring: Not installed.
    Evaporative system monitoring:  Failed or Incomplete
    Secondary air system monitoring: Not installed.
    A/C system refrigerant monitoring: Not installed.
    Oxygen sensor monitoring: Not installed.
    Oxygen sensor heater monitoring: Not installed.
    Exhaust Gas Recirculation: Not installed.
    
    Tuesday,11,June,2019,16:56:57:19959
    VCDS Release 19.6.0 (x64):  Generic OBD2
    Mode 03: Emission related fault codes
    
    Address 7E8: No fault code found.
    
    Address 7E9: No fault code found.
    
    Tuesday,11,June,2019,16:57:34:19959
    VCDS Release 19.6.0 (x64):  Generic OBD2
    Mode 07: Pending emission related fault codes
    
    Address 7E8: 1 Fault Found:
    P0089 - Valve for Fuel Metering (N290): Implausible Signal
    
    Address 7E9: No fault code found.
    
    Tuesday,11,June,2019,16:57:55:19959
    VCDS Release 19.6.0 (x64):  Generic OBD2
    Mode 9 : Calibration Identification
    
    Type 02 - VIN : WAUKF78E96A159082 (Address E8)
    Type 04 - Calibration ID : 8E0910115M  0071 (Address E8)
    Type 04 - Calibration ID : 8E1910156C  0030 (Address E9)
    Type 06 - Calibration Verification Number : 483FB60A (Address E8)
    Type 06 - Calibration Verification Number : D63D83FA (Address E9)



    I cleared out codes, started engine and auto scanned. P310B came back immediately.

    Also posted OBD2 data for Jack.
    Last edited by Integrityautowerks; 06-11-2019 at 05:31 PM. Reason: CODE tags

  9. #8
    NostraJackAss Jack@European_Parts's Avatar
    Join Date
    Jan 2014
    Location
    1001 State Route 17K Montgomery New York 12549
    Posts
    16,802
    Post Thanks / Like
    Its on my visual check list though.
    Nein! Measure using the RTFB & proper tools + specs .....not just a visual!

    RTFB can be had here and yes indeed the website works!

    https://erwin.audiusa.com/erwin/showHome.do

    http://wiki.ross-tech.com/wiki/index...ir_Information


    Jack, I did read your post about FOD in the ecu...I will do an inspection of the part. I've done plenty of FOD walks on the flight line keeping our B52s flying.
    Awesome...... thank you very much!

    European Parts Emporium/Performance / Immobilizer Solutions EPE
    Certified Master Trained NY/BAR/BAD 7076062/ASE/SAE/NASTF Legal Factory Authorized/Licensed GeKo/FaZit # 403738
    Specializing in Custom Services IE: "welding-fabrication" / EPA-SMOG Update or Pass-Thru-Programming / Data Transfer / Immobilizers & OEM Quality Parts
    Above Magic! No Written record, AUTO-SCAN or Appointment = NO HELP!
    www.FixMyEuro.com <<<<<CLICK HERE! or vwemporium@aol.com ( JPPSG & Unverified members need not PM me & Please don't email or call facility for free tech support...use the forum )
    Getting you CONTROL again of your property - TAKE IT! In Conjunction with.........

  10. #9
    Verified VCDS User
    Join Date
    Jan 2018
    Location
    USA
    Posts
    7
    Post Thanks / Like
    I'm sure the erWin site works...I just cant figure out how to create a log in to get the data. No data means nein on the technical inspection of the HPFP and associated parts.
    Last edited by Integrityautowerks; 06-11-2019 at 05:30 PM.

  11. #10
    NostraJackAss Jack@European_Parts's Avatar
    Join Date
    Jan 2014
    Location
    1001 State Route 17K Montgomery New York 12549
    Posts
    16,802
    Post Thanks / Like
    European Parts Emporium/Performance / Immobilizer Solutions EPE
    Certified Master Trained NY/BAR/BAD 7076062/ASE/SAE/NASTF Legal Factory Authorized/Licensed GeKo/FaZit # 403738
    Specializing in Custom Services IE: "welding-fabrication" / EPA-SMOG Update or Pass-Thru-Programming / Data Transfer / Immobilizers & OEM Quality Parts
    Above Magic! No Written record, AUTO-SCAN or Appointment = NO HELP!
    www.FixMyEuro.com <<<<<CLICK HERE! or vwemporium@aol.com ( JPPSG & Unverified members need not PM me & Please don't email or call facility for free tech support...use the forum )
    Getting you CONTROL again of your property - TAKE IT! In Conjunction with.........

  12. Likes Uwe, Fredrick Awuor, grant@gendan liked this post

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •