Hello,
This might have been asked a lot of times but I need a little bit feedback if possible please.
History: Skoda Octavia 1.6L CR TDI, new injectors and new EGR. After replacement of those parts engine light came on with the P2002 code after some driving. The first time I managed to clean it by service regeneration. The measured soot was 66g and it was close to the 70g limit. After regen it fell down to 6g and management light turned off. Decided just in case to use one of these DPF cleaners and fuel additive for DPF cleaninbg as well. After a few days the management light came on again after a long trip, so something is not right. I have looked into the values but the soot was a negative number. This does not seem right. Did pressure sensor got damaged or something? What do you think? The car does many frequent regenerations
Planning to inspect the sensors around the DPF this weekend
Thanks in advance for any tip
Full scan and some data attached
This might have been asked a lot of times but I need a little bit feedback if possible please.
History: Skoda Octavia 1.6L CR TDI, new injectors and new EGR. After replacement of those parts engine light came on with the P2002 code after some driving. The first time I managed to clean it by service regeneration. The measured soot was 66g and it was close to the 70g limit. After regen it fell down to 6g and management light turned off. Decided just in case to use one of these DPF cleaners and fuel additive for DPF cleaninbg as well. After a few days the management light came on again after a long trip, so something is not right. I have looked into the values but the soot was a negative number. This does not seem right. Did pressure sensor got damaged or something? What do you think? The car does many frequent regenerations
Planning to inspect the sensors around the DPF this weekend
Thanks in advance for any tip
Full scan and some data attached
Code:
Tuesday,21,May,2019,21:08:35:26039
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64
VCDS Version: 18.9.1.0 (x64) HEX-V2 CB: 0.4436.4
Data version: 20190114 DS296.0
www.Ross-Tech.com
VIN: TMBJT21Z8A2026985 License Plate: WO10TXZ
Mileage: 116220km-72215mi Repair Order:
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: 1Z-SK35 (1K0)
Scan: 01 03 08 09 15 16 17 19 25 42 44 46 52 56
VIN: TMBJT21Z8A2026985 Mileage: 116220km-72215miles
01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
56-Radio -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CAYC) Labels:. 03L-906-023-CAY.clb
Part No SW: 03L 906 023 AG HW: 03L 906 023 AG
Component: R4 1.6l TDI H23 9979
Revision: --H23--- Serial number:
Coding: 00114014030500080000
Shop #: WSC 73430 031 00999
ASAM Dataset: EV_ECM16TDI02103L906023AG 003014
ROD: EV_ECM16TDI02103L997557M.rod
VCID: 6B8237825303AB2F5BF-803E
1 Fault Found:
11791 - Particulate Trap Bank 1
P2002 00 [237] - Efficiency Below Threshold
MIL ON - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 115823 km
Date: 2019.05.12
Time: 01:23:48
Engine speed: 1605.00 /min
Normed load value: 52.5 %
Vehicle speed: 63 km/h
Coolant temperature: 94 °C
Intake air temperature: 20 °C
Ambient air pressure: 1010 mbar
Voltage terminal 30: 14.344 V
Unlearning counter according OBD: 40
Air mass: actual value:: 6.34 g/s
Particle filter: difference pressure-DIP_PF: 0.00 hPa
Particle filter: soot mass measured-MASS_SOOT_PHY_PF: 26.70 g
Particle filter: soot mass calculated-MASS_SOOT_SIM_PF: 61.66 g
Particle filter: offset for differential press.-DIP_PF_AD[0]: 0.00 hPa
Exh.gas temp.sen 3-TEG_MES[1]: 314.79 °C
Exh.gas temp.sen 4-TEG_MES[2]: 299.98 °C
Readiness: 1 1 0 0 0
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels:. 1K0-907-379-MK70M.clb
Part No SW: 1K0 907 379 AQ HW: 1K0 907 379 AQ
Component: MABS MK70M 0105
Revision: 00H32001
Coding: 0016641
Shop #: WSC 73430 790 00999
VCID: 015E752A4D0F517F913-8054
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301) Labels:| 3C8-907-336.clb
Part No SW: 3T0 820 047 H HW: 3T0 820 047 H
Component: Climatic 130 0203
Revision: 00005001
Coding: 0000000000
Shop #: WSC 73430 790 00999
ASAM Dataset: EV_Climatic A01001
ROD: EV_ClimaBasis_SK35.rod
VCID: 3430ECFE4EBD34D74A5-8060
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 1K0-937-08x-09.clb
Part No SW: 1K0 937 085 D HW: 1K0 937 085 D
Component: BCM PQ35 B+ 103 0541
Revision: 00103 AE
Coding: 48180AB8B0050CB04010008011000024010000AE424D81605C4440000000
Shop #: WSC 73430 790 00999
VCID: 3038E0EEBA2508F72ED-8064
Subsystem 1 - Part No: 1Z2 955 119 C Labels: 1KX-955-119.CLB
Component: Wischer 14070 22 0601
Coding: 00D7B7
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 1K0-909-605.lbl
Part No SW: 1K0 909 605 T HW: 1K0 909 605 T
Component: Q4 AIRBAG VW8 020 2300
Revision: 05020000 Serial number: 0038PD2EVLJ7
Coding: 0020788
Shop #: WSC 73430 790 00999
VCID: 3D26C9DA7177F59FB5B-8068
Subsystem 1 - Serial number: 6332MSME4964236AF
Subsystem 2 - Serial number: 6342MSME485431085
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY9.lbl
Part No SW: 1K0 953 549 DA HW: 1K0 953 549 DA
Component: J0527 053 0111
Coding: 0000002
Shop #: WSC 73430 790 00999
VCID: 74B02CFE02BD74D78A5-8020
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5K0-920-xxx-17.clb-SRI1
Part No SW: 1Z0 920 903 D HW: 1Z0 920 903 D
Component: KOMBI H21 0110
Serial number: 00000000000000
Coding: 410300
Shop #: WSC 73430 031 00999
ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04040
ROD: EV_Kombi_UDS_VDD_RM09_004_SK34.rod
VCID: 3634D6F658C126C7741-8062
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels:. 1K0-907-530-V4.clb
Part No SW: 1K0 907 530 AA HW: 1K0 907 951
Component: J533 Gateway H16 5223
Revision: H16 Serial number: 4120K0972709A1
Coding: E9801F06000202002303
Shop #: WSC 73430 790 00999
VCID: 669446B644619647041-8032
No fault code found.
-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels:. 5K0-920-xxx-25.clb
Part No SW: 1Z0 920 903 D HW: 1Z0 920 903 D
Component: IMMO H21 0110
Serial number: 00000000000000
ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03004
ROD: EV_Immo_UDS_VDD_RM09.rod
VCID: 3634D6F658C126C7741-8062
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels:. 1K0-959-701-MIN3.clb
Part No SW: 1T0 959 701 T HW: 1T0 959 701 T
Component: Tuer-SG 009 2114
Coding: 0000564
Shop #: WSC 73430 790 00999
VCID: 48C8A80E2EB5A03716D-801C
1 Fault Found:
01030 - Central Locking Key Switch; Driver Side; Lock
008 - Implausible Signal
-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1K0-909-14x-GEN3.clb
Part No: 1K0 909 144 H
Component: EPS_ZFLS Kl. 69 2901
Revision: 00H17000
Shop #: WSC 73430 790 00999
VCID: 2F3AE392AB1B170F377-807A
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels:. 1K0-959-702-MIN3.clb
Part No SW: 1T0 959 702 R HW: 1T0 959 702 R
Component: Tuer-SG 009 2114
Coding: 0000564
Shop #: WSC 73430 790 00999
VCID: 47CAAB3223ABAF4F1F7-8012
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (J503) Labels:. 5M0-035-1xx-56.clb
Part No SW: 1Z0 035 161 G HW: 1Z0 035 161 G
Component: Radio-SWING 008 0021
Revision: -----09S Serial number: SKZ4Z2J1112843
Coding: 000002000001
Shop #: WSC 73430 790 00999
VCID: 323CEAE6B4293AE7589-8066
No fault code found.
End------(Elapsed Time: 00:41, VBatt start/end: 12.5V/12.5V, udsna)--------