Results 1 to 10 of 10

Thread: Passat B5.5 W8 ABS codes and then some

Threaded View

Previous Post Previous Post   Next Post Next Post
  1. #1
    Verified VCDS User
    Join Date
    Jan 2019
    Location
    Indiana
    Posts
    14
    Post Thanks / Like

    Passat B5.5 W8 ABS codes and then some

    2004 Passat B5.5 W8 M/T
    Greetings, picked up a oddball wtf 8 cylinder 1 of 11 Silverstone Gray sedan Passat and having troublesome on a few codes.

    First scan when I got home, and what I've done and think I might know, or not.

    03: ABS Brakes-First start the car, sometimes but not always, the ABS and Traction Control lights are on. And sometimes they don't, until after a few minute, or begin driving. I've checked connections from left front all the way to inside wheel well. ABS wheel inside rotor has light surface rust. Cleaned and inspected sensor. (doesn't mean it's good though) Checked measuring blocks and all 4 wheels are reading same mph even with lights on. Engine light comes on 10-30 min of driving which I assume is related to front left ABS fault. Vehicle speed sensor has been replaced, but throws code as shown. Also, speedo is 5 mph fast by 3 different GPS devices. OEM rims and correct tire size in place.

    08: Auto HVAC-Flaps work fine to any position I put them to. Clueless to the faults.

    17: Instruments, 19: CAN Gateway, 75: Telematics No label?-Throwing different faults because it's an aftermarket Kenwood DDX372BT. Not much to do about that, correct? Would rather have original Monsoon.

    36: Seat Mem. Drvr - Seat(s) work fine in all positions.

    55: Headlight Range - Most likely a frayed, bare wire touching inside the housing due to hotter than hell xenon and insulation age. Common VAG problem that I've yet to pull front clip and headlights to inspect and most likely heat shrink and polish lens to new.

    Any advice or direction is greatly appreciated on these issues. It's a great car that got bad reviews because of the W8, but with 3" duals straight back from cats and a 6-spd m/t to boot, it's different and a blast to drive. Reviews anyways are like 1.8's and 2.8's. Everyone has one, even me.

    Also, can't seem to pull up the Gateway list. It's like, not there.


    Code:
    Monday,25,March,2019,20:08:17:45417
    VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
    VCDS Version: 18.9.1.0 (x64)  HEX-NET CB: 0.4437.4
    Data version: 20190114 DS296.0
    www.Ross-Tech.com
    
    Workshop Code: 444 46561 004666
    
    VIN: WVWKK63B84P146078   License Plate: 
    
    
    Chassis Type: 3B (3B - VW Passat B5 (1997 > 2005))
    Scan: 01 02 03 08 15 16 17 19 35 36 37 46 47 55 56 57 58 75 76 77
             
     
    VIN: WVWKK63B84P146078   Mileage: 309440km-192277miles
    -------------------------------------------------------------------------------
    Address 01: Engine        Labels: 07D-906-018-BDP.lbl
       Part No: 07D 906 018 AP
       Component:   B5S-4.0L-HS-LEG   5204  
       Coding: 00172
       Shop #: WSC 14627  
       VCID: 74A4DBB6460A46EAC9-513C
       WVWKK63B84P146078     VWZ7Z0C8148920
    
    1 Fault Found:
    16885 - Vehicle Speed Sensor 
                P0501 - 35-00 - Implausible Signal
    Readiness: 0000 0000
    
    -------------------------------------------------------------------------------
    Address 03: ABS Brakes        Labels: 4B0-614-517.lbl
       Part No: 4B0 614 517 AA
       Component: ABS/ESP allrad      2329  
       Coding: 05395
       Shop #: WSC 00028  
       VCID: 608CA7E6E2F2CA4ABD-51CE
    
    1 Fault Found:
    00283 - ABS Wheel Speed Sensor; Front Left  (G47) 
                30-00 - Open or Short to Plus
    
    -------------------------------------------------------------------------------
    Address 08: Auto HVAC        Labels: 3Bx-907-044.lbl
       Part No: 3B7 907 044 
       Component: CLIMATRONIC B5W8    0005  
       Coding: 27210
       Shop #: WSC 05311  
       VCID: 6484ABF6F6EAD66A59-5184
    
    4 Faults Found:
    00603 - Footwell/defroster Flap Positioning Motor (V85) 
                37-00 - Faulty
    01271 - Positioning Motor for Temperature Flap (V68) 
                37-00 - Faulty
    01272 - Positioning Motor for Central Flap (V70) 
                37-00 - Faulty
    01274 - Air Flow Flap Positioning Motor (V71) 
                37-00 - Faulty
    
    -------------------------------------------------------------------------------
    Address 15: Airbags        Labels: 6Q0-909-605-VW5.lbl
       Part No: 1C0 909 605 C
       Component: 0C AIRBAG VW61 04   0003  
       Coding: 12355
       Shop #: WSC 00028  
       VCID: 2404EBF6B66A966A99-513C
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 16: Steering wheel        Labels: 1J0-907-487-A.lbl
       Part No: 1J0 907 487 A
       Component: Lenkradelektronik   0005  
       Coding: 00118
       Shop #: WSC 00028  
       VCID: 2F2E14DAEFAC253274-5160
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 17: Instruments        Labels: 3B0-920-xx5-17.lbl
       Part No: 3B7 920 949 A
       Component: KOMBI+WEGFAHRSP VDO V03  
       Coding: 31236
       Shop #: WSC 00000  
       VCID: 2E1009DEE8A62C3A7F-513C
       WVWKK63B84P146078     VWZ7Z0C8148920
    
    1 Fault Found:
    01304 - Radio 
                49-00 - No Communications
    
    -------------------------------------------------------------------------------
    Address 19: CAN Gateway        Labels: 6N0-909-901-19.lbl
       Part No: 6N0 909 901 
       Component: Gateway K<->CAN    0001  
       Coding: 00006
       Shop #: WSC 00028  
       VCID: 70ACD7A632127ACA2D-513C
    
    1 Fault Found:
    01304 - Radio 
                49-00 - No Communications
    
    -------------------------------------------------------------------------------
    Address 36: Seat Mem. Drvr        Labels: 3B1-959-760.lbl
       Part No: 3B1 959 760 E
       Component: °301  
       Shop #: WSC 00000 008 00000
       VCID: 2F2E14DABFAC253274-513C
    
    9 Faults Found:
    01008 - Note; Emergency OFF Switch is Active! 
                000 -  - 
    00994 - Sensor for Front Height Adjustment On Drivers Seat (G215) 
                011 - Open Circuit
    00995 - Sensor for Rear Height Adjustment On Drivers Seat (G216) 
                011 - Open Circuit
    01009 - Sensor for Driver's Seat Position Fore/Aft (G218) 
                011 - Open Circuit
    01010 - Sensor for Driver's Seat Recline (G219) 
                011 - Open Circuit
    00999 - Motor for Front Height Adjustment of Driver's Seat (V29) 
                000 -  - 
    01000 - Motor for Rear Height Adjustment of Driver's Seat (V30) 
                000 -  - 
    01173 - Motor for Driver Seat Fore/Aft Adjustment (V28) 
                000 -  - 
    00998 - Motor for Driver's Seat Recline (V45) 
                000 -  - 
    
    -------------------------------------------------------------------------------
    Address 46: Central Conv.        Labels: 1C0-959-799.lbl
       Part No: 1C0 959 799 C
       Component: 09 Komfortgerát HLO 0003  
       Coding: 00258
       Shop #: WSC 00028  
       VCID: 373E2CBA17FCEDF22C-4B00
    
       Subsystem 1 - Part No: 1C0959801
       Component: 09 Tőrsteuer.FS KLO 0202  
    
       Subsystem 2 - Part No: 1C0959802A
       Component: 09 Tőrsteuer.BF KLO 0202  
    
       Subsystem 3 - Part No: 1C0959811
       Component: 09 Tőrsteuer.HL KLO 0202  
    
       Subsystem 4 - Part No: 1C0959812
       Component: 09 Tőrsteuer.HR KLO 0202  
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 55: Headlight Range        Labels: 4Z7-907-357.lbl
       Part No: 4Z7 907 357 
       Component: dynamische LWR       D09  
       Coding: 00008
       Shop #: WSC 00028  
       VCID: 04448B7616AA766AF9-4B3C
    
    1 Fault Found:
    00774 - Level Control System Sensor; Rear Left (G76) 
                31-00 - Open or Short to Ground
    
    -------------------------------------------------------------------------------
    Address 58: Aux Fuel Tank        Labels: 3B7-906-268.lbl
       Part No: 3B7 906 268 A
       Component: Kraftst. Zusatztank 0005  
       VCID: 2C1403D6DEBA5E2A51-513C
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 75: Telematics        Labels: None
       Part No SW: 3B0 035 617 G    HW: 3B0 035 617 G
       Component: Telematik NAR1      0410  
       Coding: 0041110
       Shop #: WSC 01080 444 00741
       VCID: 2208EDEEFC7E985AEB-5118
    
    3 Faults Found:
    01304 - Radio 
                012 - Electrical Fault in Circuit - MIL ON
    01304 - Radio 
                013 - Check DTC Memory - MIL ON
    00470 - Company Comfort Databus in Single Wire 
                012 - Electrical Fault in Circuit - MIL ON
    
    End----------(Elapsed Time: 04:01, VBatt start/end: 14.1V/14.0V)-----------
    Last edited by budvidua; 04-12-2019 at 10:27 PM.

  2. Likes NZDubNurd liked this post

Tags for this Thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •