2004 Passat B5.5 W8 M/T
Greetings, picked up a oddball wtf 8 cylinder 1 of 11 Silverstone Gray sedan Passat and having troublesome on a few codes.
First scan when I got home, and what I've done and think I might know, or not.
03: ABS Brakes-First start the car, sometimes but not always, the ABS and Traction Control lights are on. And sometimes they don't, until after a few minute, or begin driving. I've checked connections from left front all the way to inside wheel well. ABS wheel inside rotor has light surface rust. Cleaned and inspected sensor. (doesn't mean it's good though) Checked measuring blocks and all 4 wheels are reading same mph even with lights on. Engine light comes on 10-30 min of driving which I assume is related to front left ABS fault. Vehicle speed sensor has been replaced, but throws code as shown. Also, speedo is 5 mph fast by 3 different GPS devices. OEM rims and correct tire size in place.
08: Auto HVAC-Flaps work fine to any position I put them to. Clueless to the faults.
17: Instruments, 19: CAN Gateway, 75: Telematics No label?-Throwing different faults because it's an aftermarket Kenwood DDX372BT. Not much to do about that, correct? Would rather have original Monsoon.
36: Seat Mem. Drvr - Seat(s) work fine in all positions.
55: Headlight Range - Most likely a frayed, bare wire touching inside the housing due to hotter than hell xenon and insulation age. Common VAG problem that I've yet to pull front clip and headlights to inspect and most likely heat shrink and polish lens to new.
Any advice or direction is greatly appreciated on these issues. It's a great car that got bad reviews because of the W8, but with 3" duals straight back from cats and a 6-spd m/t to boot, it's different and a blast to drive. Reviews anyways are like 1.8's and 2.8's. Everyone has one, even me.
Also, can't seem to pull up the Gateway list. It's like, not there.
Greetings, picked up a oddball wtf 8 cylinder 1 of 11 Silverstone Gray sedan Passat and having troublesome on a few codes.
First scan when I got home, and what I've done and think I might know, or not.
03: ABS Brakes-First start the car, sometimes but not always, the ABS and Traction Control lights are on. And sometimes they don't, until after a few minute, or begin driving. I've checked connections from left front all the way to inside wheel well. ABS wheel inside rotor has light surface rust. Cleaned and inspected sensor. (doesn't mean it's good though) Checked measuring blocks and all 4 wheels are reading same mph even with lights on. Engine light comes on 10-30 min of driving which I assume is related to front left ABS fault. Vehicle speed sensor has been replaced, but throws code as shown. Also, speedo is 5 mph fast by 3 different GPS devices. OEM rims and correct tire size in place.
08: Auto HVAC-Flaps work fine to any position I put them to. Clueless to the faults.
17: Instruments, 19: CAN Gateway, 75: Telematics No label?-Throwing different faults because it's an aftermarket Kenwood DDX372BT. Not much to do about that, correct? Would rather have original Monsoon.
36: Seat Mem. Drvr - Seat(s) work fine in all positions.
55: Headlight Range - Most likely a frayed, bare wire touching inside the housing due to hotter than hell xenon and insulation age. Common VAG problem that I've yet to pull front clip and headlights to inspect and most likely heat shrink and polish lens to new.
Any advice or direction is greatly appreciated on these issues. It's a great car that got bad reviews because of the W8, but with 3" duals straight back from cats and a 6-spd m/t to boot, it's different and a blast to drive. Reviews anyways are like 1.8's and 2.8's. Everyone has one, even me.
Also, can't seem to pull up the Gateway list. It's like, not there.
Code:
Monday,25,March,2019,20:08:17:45417
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 18.9.1.0 (x64) HEX-NET CB: 0.4437.4
Data version: 20190114 DS296.0
www.Ross-Tech.com
Workshop Code: 444 46561 004666
VIN: WVWKK63B84P146078 License Plate:
Chassis Type: 3B (3B - VW Passat B5 (1997 > 2005))
Scan: 01 02 03 08 15 16 17 19 35 36 37 46 47 55 56 57 58 75 76 77
VIN: WVWKK63B84P146078 Mileage: 309440km-192277miles
-------------------------------------------------------------------------------
Address 01: Engine Labels: 07D-906-018-BDP.lbl
Part No: 07D 906 018 AP
Component: B5S-4.0L-HS-LEG 5204
Coding: 00172
Shop #: WSC 14627
VCID: 74A4DBB6460A46EAC9-513C
WVWKK63B84P146078 VWZ7Z0C8148920
1 Fault Found:
16885 - Vehicle Speed Sensor
P0501 - 35-00 - Implausible Signal
Readiness: 0000 0000
-------------------------------------------------------------------------------
Address 03: ABS Brakes Labels: 4B0-614-517.lbl
Part No: 4B0 614 517 AA
Component: ABS/ESP allrad 2329
Coding: 05395
Shop #: WSC 00028
VCID: 608CA7E6E2F2CA4ABD-51CE
1 Fault Found:
00283 - ABS Wheel Speed Sensor; Front Left (G47)
30-00 - Open or Short to Plus
-------------------------------------------------------------------------------
Address 08: Auto HVAC Labels: 3Bx-907-044.lbl
Part No: 3B7 907 044
Component: CLIMATRONIC B5W8 0005
Coding: 27210
Shop #: WSC 05311
VCID: 6484ABF6F6EAD66A59-5184
4 Faults Found:
00603 - Footwell/defroster Flap Positioning Motor (V85)
37-00 - Faulty
01271 - Positioning Motor for Temperature Flap (V68)
37-00 - Faulty
01272 - Positioning Motor for Central Flap (V70)
37-00 - Faulty
01274 - Air Flow Flap Positioning Motor (V71)
37-00 - Faulty
-------------------------------------------------------------------------------
Address 15: Airbags Labels: 6Q0-909-605-VW5.lbl
Part No: 1C0 909 605 C
Component: 0C AIRBAG VW61 04 0003
Coding: 12355
Shop #: WSC 00028
VCID: 2404EBF6B66A966A99-513C
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1J0-907-487-A.lbl
Part No: 1J0 907 487 A
Component: Lenkradelektronik 0005
Coding: 00118
Shop #: WSC 00028
VCID: 2F2E14DAEFAC253274-5160
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 3B0-920-xx5-17.lbl
Part No: 3B7 920 949 A
Component: KOMBI+WEGFAHRSP VDO V03
Coding: 31236
Shop #: WSC 00000
VCID: 2E1009DEE8A62C3A7F-513C
WVWKK63B84P146078 VWZ7Z0C8148920
1 Fault Found:
01304 - Radio
49-00 - No Communications
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels: 6N0-909-901-19.lbl
Part No: 6N0 909 901
Component: Gateway K<->CAN 0001
Coding: 00006
Shop #: WSC 00028
VCID: 70ACD7A632127ACA2D-513C
1 Fault Found:
01304 - Radio
49-00 - No Communications
-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr Labels: 3B1-959-760.lbl
Part No: 3B1 959 760 E
Component: °301
Shop #: WSC 00000 008 00000
VCID: 2F2E14DABFAC253274-513C
9 Faults Found:
01008 - Note; Emergency OFF Switch is Active!
000 - -
00994 - Sensor for Front Height Adjustment On Drivers Seat (G215)
011 - Open Circuit
00995 - Sensor for Rear Height Adjustment On Drivers Seat (G216)
011 - Open Circuit
01009 - Sensor for Driver's Seat Position Fore/Aft (G218)
011 - Open Circuit
01010 - Sensor for Driver's Seat Recline (G219)
011 - Open Circuit
00999 - Motor for Front Height Adjustment of Driver's Seat (V29)
000 - -
01000 - Motor for Rear Height Adjustment of Driver's Seat (V30)
000 - -
01173 - Motor for Driver Seat Fore/Aft Adjustment (V28)
000 - -
00998 - Motor for Driver's Seat Recline (V45)
000 - -
-------------------------------------------------------------------------------
Address 46: Central Conv. Labels: 1C0-959-799.lbl
Part No: 1C0 959 799 C
Component: 09 Komfortgerát HLO 0003
Coding: 00258
Shop #: WSC 00028
VCID: 373E2CBA17FCEDF22C-4B00
Subsystem 1 - Part No: 1C0959801
Component: 09 Tõrsteuer.FS KLO 0202
Subsystem 2 - Part No: 1C0959802A
Component: 09 Tõrsteuer.BF KLO 0202
Subsystem 3 - Part No: 1C0959811
Component: 09 Tõrsteuer.HL KLO 0202
Subsystem 4 - Part No: 1C0959812
Component: 09 Tõrsteuer.HR KLO 0202
No fault code found.
-------------------------------------------------------------------------------
Address 55: Headlight Range Labels: 4Z7-907-357.lbl
Part No: 4Z7 907 357
Component: dynamische LWR D09
Coding: 00008
Shop #: WSC 00028
VCID: 04448B7616AA766AF9-4B3C
1 Fault Found:
00774 - Level Control System Sensor; Rear Left (G76)
31-00 - Open or Short to Ground
-------------------------------------------------------------------------------
Address 58: Aux Fuel Tank Labels: 3B7-906-268.lbl
Part No: 3B7 906 268 A
Component: Kraftst. Zusatztank 0005
VCID: 2C1403D6DEBA5E2A51-513C
No fault code found.
-------------------------------------------------------------------------------
Address 75: Telematics Labels: None
Part No SW: 3B0 035 617 G HW: 3B0 035 617 G
Component: Telematik NAR1 0410
Coding: 0041110
Shop #: WSC 01080 444 00741
VCID: 2208EDEEFC7E985AEB-5118
3 Faults Found:
01304 - Radio
012 - Electrical Fault in Circuit - MIL ON
01304 - Radio
013 - Check DTC Memory - MIL ON
00470 - Company Comfort Databus in Single Wire
012 - Electrical Fault in Circuit - MIL ON
End----------(Elapsed Time: 04:01, VBatt start/end: 14.1V/14.0V)-----------
Last edited: