Results 1 to 7 of 7

Thread: Throttle valve adaptation issue

  1. #1
    Verified VCDS User
    Join Date
    Nov 2018
    Location
    USA
    Posts
    21
    Post Thanks / Like

    Throttle valve adaptation issue

    I've done throttle valve adaptation before and did so again right after cleaning my throttle bodies. No issues.

    I went to do it today, just to record it for a how to video and decided to try and record the screen through the Microsoft function. It slowed the computer down tremendously and I had to stop it. Well the adaptation stopped too.

    As a result, I have a DTC that will not clear.

    On top of that, I ran the throttle valve adaptation again and could not hear the usual clicking of the throttle butterflies as they're activated. I tried to clear the DTC's and then cycle the ignition. No luck.

    Next I disconnected the negative to the battery. Connected everything up again and this time, running the adaptation, I heard the clicking. But it literally sat there for minutes on end and never finished up. Tried repeatedly with no luck and the codes will not clear.

    This is on a 2013 Audi RS5

    2761 - Throttle Actuator (J338)
    P1579 00 [039] - Adaptation Not Started

    as well as...

    10253 - Throttle Throttle Controller 2 (J544)
    P3037 00 [039] - Adaptation no Started (it really says no instead of not)

    Any idea? Car starts fine. And thanks in advance.

  2. #2
    Benevolent Dictator Uwe's Avatar
    Join Date
    Jan 2014
    Location
    Earth
    Posts
    22,521
    Post Thanks / Like
    Blog Entries
    1
    Please post an Auto-Scan for context.

    If the engine was completely cold, try warming it up a bit. Check battery voltage as well.

    -Uwe-
    The engineering problems are likely insurmountable. It would be like proposing to land a rocket booster section on a barge floating in the middle of the ocean.

  3. #3
    Verified VCDS User
    Join Date
    Nov 2018
    Location
    USA
    Posts
    21
    Post Thanks / Like
    Engine was warm, within the acceptable range. I believe the coolant was about 80 degrees Celsius. Battery voltage was 12.3.

    It's just strange that it will not clean the DTC for the throttle bodies. If I do it repeatedly, it'll clear but it's not really cleared and comes back if I check it again. There's been a lot of "buggery" since updating to the latest version, especially with logging.

  4. #4
    Verified VCDS User
    Join Date
    Nov 2018
    Location
    USA
    Posts
    21
    Post Thanks / Like
    Here's my entire auto scan.

    Code:
    Monday,11,March,2019,15:35:30:27520
    VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
    VCDS Version: 18.9.1.0 (x64)  HEX-V2 CB: 0.4436.4
    Data version: 20190114 DS296.0
    www.Ross-Tech.com
    
    
    VIN: WUAC6AFR6DA902467   License Plate: 
    Mileage: 89100km-55364mi   Repair Order: 
    
    
    
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Chassis Type: FR-AU48 (8R0)
    Scan: 01 02 03 05 06 08 09 13 15 16 17 19 1B 22 36 3C 42 44 46 47
              52 53 56 5F 6C
    
    VIN: WUAC6AFR6DA902467   Mileage: 89100km-55364miles
    
    01-Engine -- Status: Malfunction 0010
    02-Auto Trans -- Status: OK 0000
    03-ABS Brakes -- Status: OK 0000
    04-Steering Angle -- Status: OK 0000
    05-Acc/Start Auth. -- Status: OK 0000
    06-Seat Mem. Pass -- Status: OK 0000
    08-Auto HVAC -- Status: Malfunction 0010
    09-Cent. Elect. -- Status: OK 0000
    13-Auto Dist. Reg -- Status: OK 0000
    15-Airbags -- Status: OK 0000
    16-Steering wheel -- Status: OK 0000
    17-Instruments -- Status: OK 0000
    19-CAN Gateway -- Status: OK 0000
    1B-Active Steering -- Status: OK 0000
    22-AWD -- Status: OK 0000
    36-Seat Mem. Drvr -- Status: Malfunction 0010
    3C-Lane Change -- Status: OK 0000
    42-Door Elect, Driver -- Status: OK 0000
    44-Steering Assist -- Status: OK 0000
    46-Central Conv. -- Status: OK 0000
    47-Sound System -- Status: OK 0000
    52-Door Elect, Pass. -- Status: OK 0000
    53-Parking Brake -- Status: OK 0000
    56-Radio -- Status: OK 0000
    5F-Information Electr. -- Status: Malfunction 0010
    6C-Back-up Cam. -- Status: OK 0000
    -------------------------------------------------------------------------------
    Address 01: Engine (------CFSA)       Labels:. 079-907-560-CFS.clb
       Part No SW: 8T2 907 560 F    HW: 8T1 907 560 
       Component: 4.2l JHM.9X/  H04 0005  
       Revision: NAH04---    
       Coding: 1A25003225C6080D3000
       Shop #: WSC 00000 000 00000
       ASAM Dataset: EV_ECM42FSI0118T2907560F 001004
       ROD: EV_ECM42FSI0118T2907560F.rod
       VCID: 3FDBBD3337FB04FFA77-806A
    
    2 Faults Found:
    10253 - Throttle Controller 2 (J544) 
              P3037 00 [039] - Adaptation no Started
              Not Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 2
                        Fault Frequency: 4
                        Mileage: 89105 km
                        Date: 2019.03.11
                        Time: 14:15:22
    
                        Engine speed: 0.00 /min
                        Normed load value: 0.0 %
                        Vehicle speed: 0 km/h
                        Coolant temperature: 89 ∞C
                        Intake air temperature: 64 ∞C
                        Ambient air pressure: 980 mbar
                        Voltage terminal 30: 11.968 V
                        Unlearning counter according OBD: 40
                        AFS dm: 0.0 kg/h
                        Median injection timing: 0.000 ms
                        Engine operating condition: Idling
                        Engine operating condition-Test_Program_Channel 87: 5
    
    2761 - Throttle Actuator (J338) 
              P1579 00 [039] - Adaptation Not Started
              Not Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 2
                        Fault Frequency: 4
                        Mileage: 89105 km
                        Date: 2019.03.11
                        Time: 14:15:22
    
                        Engine speed: 0.00 /min
                        Normed load value: 0.0 %
                        Vehicle speed: 0 km/h
                        Coolant temperature: 89 ∞C
                        Intake air temperature: 64 ∞C
                        Ambient air pressure: 980 mbar
                        Voltage terminal 30: 11.968 V
                        Unlearning counter according OBD: 40
                        AFS dm: 0.0 kg/h
                        Median injection timing: 0.000 ms
                        Engine operating condition: Idling
                        Engine operating condition-Test_Program_Channel 87: 5
    
    Readiness: 0000 0000
    
    -------------------------------------------------------------------------------
    Address 02: Auto Trans (J217)       Labels:| 0B5-927-156.clb
       Part No SW: 8T0 927 156 F    HW: 0B5 927 156 J
       Component: 0B5 42 FSINAR H01 0008  
       Revision: --H01---    
       Coding: 000001
       Shop #: WSC 06325 000 00000
       ASAM Dataset: EV_TCMDL501021 001012
       ROD: EV_TCMDL501021.rod
       VCID: 40D9BECF4A057B07DED-8014
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 03: ABS Brakes (J104)       Labels:. 8K0-907-379-V1.clb
       Part No SW: 8T0 907 379 F    HW: 8T0 907 379 F
       Component: ESP8 quattro  H09 0100  
       Revision: --------    Serial number: --------------
       Coding: 302D1A
       Shop #: WSC 06325 000 00000
       VCID: 45D7AFDB55A75E2FEDB-8010
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 05: Acc/Start Auth. (J393)       Labels:. 8K0-907-064-05.clb
       Part No SW: 8K0 907 064 GP    HW: 8K0 907 064 FP
       Component: BCM2 2.0      H12 0633  
       Revision: 00002001    
       Coding: 0D804000000000000000
       Shop #: WSC 06325 000 00000
       VCID: 045172DF1E1DA727BA5-8050
    
       Subsystem 1 - Part No SW: 8K0 905 852 E    HW: 8K0 905 852 E
       Component: J764 ELV MLB  H40 0046 
       Serial number: 2313000016339008    
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 06: Seat Mem. Pass (J521)       Labels:. 8T0-959-760.clb
       Part No SW: 8T0 959 760 E    HW: 8T0 959 760 E
       Component: MEM-BFS       H10 0076  
       Revision: AA000000    Serial number: 00000051213831
       Coding: 00037025002C00000000
       Shop #: WSC 06342 000 00000
       VCID: 45D7AFDB55A75E2FEDB-8010
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 08: Auto HVAC (J255)       Labels: Redir Fail!
       Part No SW: 8K1 820 043 T    HW: 8K1 820 043 T
       Component: KLIMA 3 ZONEN H04 0121  
       Revision: C1000000    Serial number: 01200220130492
       Coding: 4802200000
       Shop #: WSC 06325 000 00000
       VCID: 392FD32B295F2ACF993-806C
    
    1 Fault Found:
    01274 - Air Flow Flap Positioning Motor (V71) 
                003 - Mechanical Failure - Intermittent
                 Freeze Frame:
                        Fault Status: 00100011
                        Fault Priority: 3
                        Fault Frequency: 29
                        Reset counter: 247
                        Mileage: 88168 km
                        Time Indication: 0
                        Date: 2019.02.17
                        Time: 10:37:31
    
                 Freeze Frame:
                        Voltage: 14.30 V
                        Temperature: 26.0∞C
                        Temperature: 20.0∞C
                        Count: 11062
                        Count: 10974
                        Bin. Bits: 01000000
                        Bin. Bits: 10001011
                        Time: 255.00 s
    
    
    -------------------------------------------------------------------------------
    Address 09: Cent. Elect. (J519)       Labels:. 8K0-907-063.clb
       Part No SW: 8K0 907 063 DJ    HW: 8K0 907 063 DJ
       Component: BCM1 1.0      H16 0103  
       Revision: 09016001    Serial number: 00000554864301
       Coding: 06000011043C9FF235004083000039090F9CD388A2090221000008004000010200040034000000
       Shop #: WSC 92630 444 123950
       VCID: 7AAD0C276CD9E1D7D09-802E
    
       Subsystem 1 - Part No SW: 8T1 955 119 D    HW: 8J1 955 119   Labels: 1KX-955-119.CLB
       Component: WWS 150213  H15 0080 
       Serial number: SWF13020150148      
       Coding: 00FD11
    
       Subsystem 2 - Part No SW: 8U0 955 559 B    HW: 8U0 955 559 B  Labels: 8U0-955-559.CLB
       Component: G397_RLFS  H06 0002 
       Serial number: 21004112            
       Coding: 02005D
    
       Subsystem 3 - Part No SW: 8K0 941 531 AQ    HW: 8K0 941 531 AQ
       Component: E1 - LDS  H03 0031 
       Serial number: 00000000000502130647
    
       Subsystem 4 - Part No SW: 4G0 907 410 A    HW: 4H0 907 410 A
       Component: USHL4.2  H30 0030 
       Serial number: 0000002274555R4SYJ02
    
       Subsystem 5 - Part No SW: 8K5 941 329     HW: 8K5 941 329 
    H01 0031 
    
       Subsystem 6 - Part No SW: 8K5 941 329     HW: 8K5 941 329 
    H01 0031 
    
       Subsystem 7 - Part No SW: 4H0 907 658     HW: 4H0 907 658 
       Component: AQ_Hum_Sensor  H03 0003 
       Serial number: 7C48C296000000000001
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 13: Auto Dist. Reg (J428)       Labels: None
       Part No SW: 8K0 907 561 C    HW: 8K0 907 561 C
       Component: ACC3          H11 0100  
       Serial number: 00000000000000
       Coding: 00333E
       Shop #: WSC 06325 000 00000
       VCID: 323DE407F429D997589-8066
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 15: Airbags (J234)       Labels:* 8K0-959-655.clb
       Part No SW: 8K0 959 655 P    HW: 8K0 959 655 P
       Component: AirbagVW-AU10 H45 0610  
       Serial number: 003KJD91EW3S  
       Coding: 303343334830303030304A55304C38543053
       Shop #: WSC 06325 000 00000
       ASAM Dataset: EV_AirbaECUVWAUDI010 003010
       ROD: EV_AirbaECUVWAUDI010_003_AU48.rod
       VCID: 4ACD9CE77C39B157009-801E
    
       Seat occupied recognition: 
       Subsystem 1 - Part No SW: 8K0 959 339 A    HW: 8K0 959 339 A
       Component: BF-Gewichtss.  H02 0060 
       Serial number: 5810000R130000CJ7S
    
       Crash sensor for side airbag: driver side: 
       Serial number: 6334MSME780331656
    
       Crash sensor for side airbag: front passenger side: 
       Serial number: 6344MSME78406157C
    
       Crash sensor for side airbag: rear: driver side: 
       Serial number: 6352QSME62282B44G
    
       Crash sensor for side airbag: rear: passenger side: 
       Serial number: 6362QSME5F2C5372T
    
       Crash sensor for front airbag: driver side: 
       Serial number: 63732SME712B0F585
    
       Crash sensor for front airbag: front passenger side: 
       Serial number: 63832SME542B2F444
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 16: Steering wheel (J527)       Labels:. 8K0-953-568.clb
       Part No SW: 8R0 953 568 S    HW: 8R0 953 568 S
       Component: Lenks.Modul   H07 0171  
       Revision: 00000000    Serial number: 20130219001040
       Coding: 00003E
       Shop #: WSC 06325 000 00000
       VCID: 51FF8B8B91EF828F413-8004
    
       Component: E221 - MFL  H03 0004 
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 17: Instruments (J285)       Labels:. 8T0-920-xxx-17.clb
       Part No SW: 8T0 920 984 A    HW: 8T0 920 984 A
       Component: KOMBIINSTR.   H35 0556  
       Revision: 00300000    Serial number: UVA266K2E     
       Coding: 83BF0100AF03D705020000
       Shop #: WSC 06325 000 00000
       VCID: 3D27C73B3D7716EFB5B-8068
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 19: CAN Gateway (J533)       Labels:. 8T0-907-468.clb
       Part No SW: 8R0 907 468 P    HW: 8R0 907 468 D
       Component: GW-BEM 5CAN-M H11 0055  
       Revision: 1Z100027    Serial number: 2741Z13204008E
       Coding: 80E3031600
       Shop #: WSC 06325 000 00000
       VCID: 4CC19AFF76CDAF67325-8018
    
       Subsystem 1 - Part No SW: 8T0 915 181     HW: 8T0 915 181 
       Component: J367-BDMHella  H03 8041 
       Serial number: 1367620003          
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 1B: Active Steering (J792)       Labels: None
       Part No SW: 8K0 907 144 J    HW: 8K0 907 144 J
       Component: DYNAMIKLENK.  H06 0690  
       Revision: 52001005    Serial number: --------------
       Coding: 030000
       Shop #: WSC 06325 000 00000
       VCID: 3635D8171841C5B7741-8062
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 22: AWD (J492)       Labels: 8K0-907-163.clb
       Part No SW: 8K0 907 163 B    HW: 8K0 907 163 A
       Component: 4 Wheel Drive H14 0100  
       Serial number: 001302130001758
       ASAM Dataset: EV_AllWheelDiffeQSPCAN 003019
       ROD: EV_AllWheelDiffeQSPCAN.rod
       VCID: 2F3BED73E79BF47F377-807A
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 36: Seat Mem. Drvr (J136)       Labels:. 8T0-959-760.clb
       Part No SW: 8T0 959 760 E    HW: 8T0 959 760 E
       Component: MEM-FS        H10 0076  
       Revision: AA000000    Serial number: 00000051211560
       Coding: 001B7B25002C00000000
       Shop #: WSC 11251 001 1048576
       VCID: 45D7AFDB55A75E2FEDB-8010
    
    1 Fault Found:
    03339 - Force Limit for Fore/Aft Seat Adjustment: Back 
                005 - No or Incorrect Basic Setting / Adaptation
                 Freeze Frame:
                        Fault Status: 01100101
                        Fault Priority: 3
                        Fault Frequency: 1
                        Reset counter: 168
                        Mileage: 88098 km
                        Time Indication: 0
                        Date: 2019.02.17
                        Time: 09:31:51
    
    
    -------------------------------------------------------------------------------
    Address 3C: Lane Change (J769)       Labels:| 5Q0-907-566.clb
       Part No SW: 8T0 907 566 B    HW: 8T0 907 566 B
       Component: SWA Master    H04 0060  
       Serial number: 0192285845
       Coding: 010211
       Shop #: WSC 06324 000 00000
       ASAM Dataset: EV_LaneChangAssis 001020
       ROD: EV_LaneChangAssis_AU21.rod
       VCID: 3FDBBD3337FB04FFA77-806A
    
       Lane Change Assistant 2: 
       Subsystem 1 - Part No SW: 8T0 907 568 B    HW: 8T0 907 568 B
       Component: SWA Slave  H04 0060 
       Serial number: 0192294703          
       Coding: 000102
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 42: Door Elect, Driver (J386)       Labels:. 8K0-959-793.clb
       Part No SW: 8T0 959 793 P    HW: 8T0 959 793 G
       Component: TSG FA        H09 0304  
       Revision: --------    Serial number: --------------
       Coding: 011C13224E00120102
       Shop #: WSC 06325 000 00000
       VCID: 56F57897B801E5B7941-8002
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 44: Steering Assist (J500)       Labels:| 8K0-909-144.clb
       Part No SW: 8K0 909 144 F    HW: 8K0 909 144 B
       Component: RCEPS         H36 0507  
       Revision: 00001000    Serial number: 0012646993
       Coding: 010000010001
       Shop #: WSC 06324 000 00000
       ASAM Dataset: EV_RCEPSAU48X 008014
       ROD: EV_RCEPSAU48X_008.rod
       VCID: 3431E21F0EBDD7A74A5-8060
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 46: Central Conv. (J393)       Labels:. 8K0-907-064-46.clb
       Part No SW: 8K0 907 064 GP    HW: 8K0 907 064 FP
       Component: BCM2 2.0      H12 0633  
       Revision: 00002001    Serial number: 0301332569    
       Coding: 0106069A00FAC10581B0003200000000
       Shop #: WSC 92630 444 123950
       VCID: 045172DF1E1DA727BA5-8050
    
       Subsystem 1 - Part No SW: 8K0 959 719 B    HW: 8K0 959 719 
       Component: GTO BF  H01 0080 
       Serial number: 00000000000000634856
    
       Subsystem 2 - Part No: 1K0 951 605 C
       Component: LIN BACKUP HO  H05 1501 
    
       Subsystem 3 - Part No SW: 8R0 959 591 A    HW: 8R0 959 591 
       Component: J245EE20SKB13  H05 0220 
       Serial number: 0123456789ABCDEFGHIJ
    
       Subsystem 4 - Part No SW: 4G8 959 252     HW: 4G8 959 252 
       Component: HSP-SG  H11 0028 
       Serial number: WA104645000002650945
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 47: Sound System (J525)       Labels:. 8T0-035-223-BOM.clb
       Part No SW: 8T1 035 223 A    HW: 8T1 035 223 A
       Component: DSP Prem      H05 0030  
       Revision: 00005001    Serial number: 94813011143102
       VCID: 2D07F77BED17866F05B-8078
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 52: Door Elect, Pass. (J387)       Labels:. 8K0-959-792.clb
       Part No SW: 8T0 959 792 P    HW: 8T0 959 792 G
       Component: TSG BF        H09 0304  
       Revision: --------    Serial number: --------------
       Coding: 011C13224E00120102
       Shop #: WSC 06325 000 00000
       VCID: 55F77F9BA507EEAF9DB-8000
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 53: Parking Brake (----)       Labels: 8K0-907-801-V2.clb
       Part No SW: 8K0 907 801 L    HW: 8K0 907 801 J
       Component: EPB-4         H01 0003  
       Revision: --------    Serial number: 20000000227161
       ASAM Dataset: EV_ParkiBrake 001027
       ROD: EV_ParkiBrake_AU48.rod
       VCID: 3829D62F12D533C766D-806C
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 56: Radio (R)       Labels: Redir Fail!
       Part No SW: 4G0 035 082 H    HW: 4G0 035 082 
       Component: Radio U SIRIU H60 0138  
       Revision: AB001007    Serial number: 156B50D7693479
       Coding: 020007010000000001
       Shop #: WSC 06325 000 00000
       VCID: 25170F5BB5E7BE2FCDB-8070
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 5F: Information Electr. (J794)       Labels:. 4E0-035-6xx-5F.clb
       Part No SW: 8R1 035 746 K    HW: 8R1 035 746 B
       Component: H-BNT-NA      H44 1040  
       Revision: --------    Serial number: 204BT0D7561283
       Coding: 150200020306A9EF75028B4E00000403140000000000000000
       Shop #: WSC 92630 444 123950
       VCID: 3FDBBD33377B04FFA77-806A
    
       Subsystem 1 - Part No: 8R0 060 884 BA
       Component: NAR 2013  0703 
    
       Subsystem 2 - Part No SW: 8R0 919 604 A    HW: 8R0 919 604 A
       Component: DU7 High  H42 0104 
       Serial number: A130BX0D2659970     
    
       Subsystem 3 - Part No SW: 8T0 919 611 L    HW: 8T0 919 611 C
       Component: E0380 Bedient  H02 0030 
       Serial number: 00000001419689      
    
       Subsystem 4 - Part No: 8R0 060 961 E
       Component: CD-Database  4949 
    
    No Faults Found
      or DTCs not supported by controller
      or a communication error occurred
    
    -------------------------------------------------------------------------------
    Address 6C: Back-up Cam.        Labels: 8T0-907-441.clb
       Part No SW: 8T0 907 441 C    HW: 4L0 907 441 B
       Component: J772__Rearview      0040  
       Revision: --H07---    Serial number: 525PA8-J2Z91FG
       Coding: 1021008
       Shop #: WSC 06325 000 00000
       VCID: 3829D62F1E5533C766D-806C
    
    No fault code found.
    
    End----(Elapsed Time: 02:13, VBatt start/end: 12.0V/11.9V. VIgn 11.9V)-----
    Monday,11,March,2019,17:10:05:27520
    VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
    VCDS Version: 18.9.1.0 (x64)  HEX-V2 CB: 0.4436.4
    Data version: 20190114 DS296.0
    www.Ross-Tech.com
    
    
    VIN: WUAC6AFR6DA902467   License Plate: 
    Mileage: 89100km-55364mi   Repair Order: 
    
    
    
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Chassis Type: FR-AU48 (8R0)
    Scan: 01 02 03 05 06 08 09 13 15 16 17 19 1B 22 36 3C 42 44 46 47
              52 53 56 5F 6C
    
    VIN: WUAC6AFR6DA902467   Mileage: 89100km-55364miles
    
    01-Engine -- Status: Malfunction 0010
    02-Auto Trans -- Status: OK 0000
    03-ABS Brakes -- Status: OK 0000
    04-Steering Angle -- Status: OK 0000
    05-Acc/Start Auth. -- Status: OK 0000
    06-Seat Mem. Pass -- Status: OK 0000
    08-Auto HVAC -- Status: Malfunction 0010
    09-Cent. Elect. -- Status: OK 0000
    13-Auto Dist. Reg -- Status: OK 0000
    15-Airbags -- Status: OK 0000
    16-Steering wheel -- Status: OK 0000
    17-Instruments -- Status: OK 0000
    19-CAN Gateway -- Status: OK 0000
    1B-Active Steering -- Status: OK 0000
    22-AWD -- Status: OK 0000
    36-Seat Mem. Drvr -- Status: Malfunction 0010
    3C-Lane Change -- Status: OK 0000
    42-Door Elect, Driver -- Status: OK 0000
    44-Steering Assist -- Status: OK 0000
    46-Central Conv. -- Status: OK 0000
    47-Sound System -- Status: OK 0000
    52-Door Elect, Pass. -- Status: OK 0000
    53-Parking Brake -- Status: OK 0000
    56-Radio -- Status: OK 0000
    5F-Information Electr. -- Status: Malfunction 0010
    6C-Back-up Cam. -- Status: OK 0000
    -------------------------------------------------------------------------------
    Address 01: Engine (------CFSA)       Labels:. 079-907-560-CFS.clb
       Part No SW: 8T2 907 560 F    HW: 8T1 907 560 
       Component: 4.2l JHM.9X/  H04 0005  
       Revision: NAH04---    
       Coding: 1A25003225C6080D3000
       Shop #: WSC 00000 000 00000
       ASAM Dataset: EV_ECM42FSI0118T2907560F 001004
       ROD: EV_ECM42FSI0118T2907560F.rod
       VCID: 3FDBBD3337FB04FFA77-806A
    
    2 Faults Found:
    10253 - Throttle Controller 2 (J544) 
              P3037 00 [039] - Adaptation no Started
              Not Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 2
                        Fault Frequency: 1
                        Mileage: 89104 km
                        Date: 2019.03.11
                        Time: 15:59:40
    
                        Engine speed: 0.00 /min
                        Normed load value: 0.0 %
                        Vehicle speed: 0 km/h
                        Coolant temperature: 66 ∞C
                        Intake air temperature: 61 ∞C
                        Ambient air pressure: 980 mbar
                        Voltage terminal 30: 11.826 V
                        Unlearning counter according OBD: 40
                        AFS dm: 0.0 kg/h
                        Median injection timing: 0.000 ms
                        Engine operating condition: Idling
                        Engine operating condition-Test_Program_Channel 87: 5
    
    2761 - Throttle Actuator (J338) 
              P1579 00 [039] - Adaptation Not Started
              Not Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 2
                        Fault Frequency: 1
                        Mileage: 89104 km
                        Date: 2019.03.11
                        Time: 15:59:40
    
                        Engine speed: 0.00 /min
                        Normed load value: 0.0 %
                        Vehicle speed: 0 km/h
                        Coolant temperature: 66 ∞C
                        Intake air temperature: 61 ∞C
                        Ambient air pressure: 980 mbar
                        Voltage terminal 30: 11.826 V
                        Unlearning counter according OBD: 40
                        AFS dm: 0.0 kg/h
                        Median injection timing: 0.000 ms
                        Engine operating condition: Idling
                        Engine operating condition-Test_Program_Channel 87: 5
    
    Readiness: 1110 1101
    
    -------------------------------------------------------------------------------
    Address 02: Auto Trans (J217)       Labels:| 0B5-927-156.clb
       Part No SW: 8T0 927 156 F    HW: 0B5 927 156 J
       Component: 0B5 42 FSINAR H01 0008  
       Revision: --H01---    
       Coding: 000001
       Shop #: WSC 06325 000 00000
       ASAM Dataset: EV_TCMDL501021 001012
       ROD: EV_TCMDL501021.rod
       VCID: 40D9BECF4A057B07DED-8014
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 03: ABS Brakes (J104)       Labels:. 8K0-907-379-V1.clb
       Part No SW: 8T0 907 379 F    HW: 8T0 907 379 F
       Component: ESP8 quattro  H09 0100  
       Revision: --------    Serial number: --------------
       Coding: 302D1A
       Shop #: WSC 06325 000 00000
       VCID: 45D7AFDB55A75E2FEDB-8010
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 05: Acc/Start Auth. (J393)       Labels:. 8K0-907-064-05.clb
       Part No SW: 8K0 907 064 GP    HW: 8K0 907 064 FP
       Component: BCM2 2.0      H12 0633  
       Revision: 00002001    
       Coding: 0D804000000000000000
       Shop #: WSC 06325 000 00000
       VCID: 045172DF1E1DA727BA5-8050
    
       Subsystem 1 - Part No SW: 8K0 905 852 E    HW: 8K0 905 852 E
       Component: J764 ELV MLB  H40 0046 
       Serial number: 2313000016339008    
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 06: Seat Mem. Pass (J521)       Labels:. 8T0-959-760.clb
       Part No SW: 8T0 959 760 E    HW: 8T0 959 760 E
       Component: MEM-BFS       H10 0076  
       Revision: AA000000    Serial number: 00000051213831
       Coding: 00037025002C00000000
       Shop #: WSC 06342 000 00000
       VCID: 45D7AFDB55A75E2FEDB-8010
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 08: Auto HVAC (J255)       Labels: Redir Fail!
       Part No SW: 8K1 820 043 T    HW: 8K1 820 043 T
       Component: KLIMA 3 ZONEN H04 0121  
       Revision: C1000000    Serial number: 01200220130492
       Coding: 4802200000
       Shop #: WSC 06325 000 00000
       VCID: 392FD32B295F2ACF993-806C
    
    2 Faults Found:
    01087 - Basic Setting Not Performed 
                005 - No or Incorrect Basic Setting / Adaptation
                 Freeze Frame:
                        Fault Status: 01100101
                        Fault Priority: 3
                        Fault Frequency: 1
                        Reset counter: 207
                        Mileage: 89104 km
                        Time Indication: 0
                        Date: 2019.03.11
                        Time: 16:00:11
    
    01274 - Air Flow Flap Positioning Motor (V71) 
                002 - Lower Limit Exceeded
                 Freeze Frame:
                        Fault Status: 01100010
                        Fault Priority: 3
                        Fault Frequency: 1
                        Reset counter: 207
                        Mileage: 89104 km
                        Time Indication: 0
                        Date: 2019.03.11
                        Time: 16:04:56
    
                 Freeze Frame:
                        Voltage: 11.70 V
                        Temperature: 28.0∞C
                        Temperature: 26.0∞C
                        Count: 1850
                        Count: 953
                        Bin. Bits: 00000000
                        Bin. Bits: 10001011
                        Time: 2.55 s
    
    
    -------------------------------------------------------------------------------
    Address 09: Cent. Elect. (J519)       Labels:. 8K0-907-063.clb
       Part No SW: 8K0 907 063 DJ    HW: 8K0 907 063 DJ
       Component: BCM1 1.0      H16 0103  
       Revision: 09016001    Serial number: 00000554864301
       Coding: 06000011043C9FF235004083000039090F9CD388A2090221000008004000010200040034000000
       Shop #: WSC 92630 444 123950
       VCID: 7AAD0C276CD9E1D7D09-802E
    
       Subsystem 1 - Part No SW: 8T1 955 119 D    HW: 8J1 955 119   Labels: 1KX-955-119.CLB
       Component: WWS 150213  H15 0080 
       Serial number: SWF13020150148      
       Coding: 00FD11
    
       Subsystem 2 - Part No SW: 8U0 955 559 B    HW: 8U0 955 559 B  Labels: 8U0-955-559.CLB
       Component: G397_RLFS  H06 0002 
       Serial number: 21004112            
       Coding: 02005D
    
       Subsystem 3 - Part No SW: 8K0 941 531 AQ    HW: 8K0 941 531 AQ
       Component: E1 - LDS  H03 0031 
       Serial number: 00000000000502130647
    
       Subsystem 4 - Part No SW: 4G0 907 410 A    HW: 4H0 907 410 A
       Component: USHL4.2  H30 0030 
       Serial number: 0000002274555R4SYJ02
    
       Subsystem 5 - Part No SW: 8K5 941 329     HW: 8K5 941 329 
    H01 0031 
    
       Subsystem 6 - Part No SW: 8K5 941 329     HW: 8K5 941 329 
    H01 0031 
    
       Subsystem 7 - Part No SW: 4H0 907 658     HW: 4H0 907 658 
       Component: AQ_Hum_Sensor  H03 0003 
       Serial number: 7C48C296000000000001
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 13: Auto Dist. Reg (J428)       Labels: None
       Part No SW: 8K0 907 561 C    HW: 8K0 907 561 C
       Component: ACC3          H11 0100  
       Serial number: 00000000000000
       Coding: 00333E
       Shop #: WSC 06325 000 00000
       VCID: 323DE407F429D997589-8066
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 15: Airbags (J234)       Labels:* 8K0-959-655.clb
       Part No SW: 8K0 959 655 P    HW: 8K0 959 655 P
       Component: AirbagVW-AU10 H45 0610  
       Serial number: 003KJD91EW3S  
       Coding: 303343334830303030304A55304C38543053
       Shop #: WSC 06325 000 00000
       ASAM Dataset: EV_AirbaECUVWAUDI010 003010
       ROD: EV_AirbaECUVWAUDI010_003_AU48.rod
       VCID: 4ACD9CE77C39B157009-801E
    
       Seat occupied recognition: 
       Subsystem 1 - Part No SW: 8K0 959 339 A    HW: 8K0 959 339 A
       Component: BF-Gewichtss.  H02 0060 
       Serial number: 5810000R130000CJ7S
    
       Crash sensor for side airbag: driver side: 
       Serial number: 6334MSME780331656
    
       Crash sensor for side airbag: front passenger side: 
       Serial number: 6344MSME78406157C
    
       Crash sensor for side airbag: rear: driver side: 
       Serial number: 6352QSME62282B44G
    
       Crash sensor for side airbag: rear: passenger side: 
       Serial number: 6362QSME5F2C5372T
    
       Crash sensor for front airbag: driver side: 
       Serial number: 63732SME712B0F585
    
       Crash sensor for front airbag: front passenger side: 
       Serial number: 63832SME542B2F444
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 16: Steering wheel (J527)       Labels:. 8K0-953-568.clb
       Part No SW: 8R0 953 568 S    HW: 8R0 953 568 S
       Component: Lenks.Modul   H07 0171  
       Revision: 00000000    Serial number: 20130219001040
       Coding: 00003E
       Shop #: WSC 06325 000 00000
       VCID: 51FF8B8B91EF828F413-8004
    
       Component: E221 - MFL  H03 0004 
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 17: Instruments (J285)       Labels:. 8T0-920-xxx-17.clb
       Part No SW: 8T0 920 984 A    HW: 8T0 920 984 A
       Component: KOMBIINSTR.   H35 0556  
       Revision: 00300000    Serial number: UVA266K2E     
       Coding: 83BF0100AF03D705020000
       Shop #: WSC 06325 000 00000
       VCID: 3D27C73B3D7716EFB5B-8068
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 19: CAN Gateway (J533)       Labels:. 8T0-907-468.clb
       Part No SW: 8R0 907 468 P    HW: 8R0 907 468 D
       Component: GW-BEM 5CAN-M H11 0055  
       Revision: 1Z100027    Serial number: 2741Z13204008E
       Coding: 80E3031600
       Shop #: WSC 06325 000 00000
       VCID: 4CC19AFF76CDAF67325-8018
    
       Subsystem 1 - Part No SW: 8T0 915 181     HW: 8T0 915 181 
       Component: J367-BDMHella  H03 8041 
       Serial number: 1367620003          
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 1B: Active Steering (J792)       Labels: None
       Part No SW: 8K0 907 144 J    HW: 8K0 907 144 J
       Component: DYNAMIKLENK.  H06 0690  
       Revision: 52001005    Serial number: --------------
       Coding: 030000
       Shop #: WSC 06325 000 00000
       VCID: 3635D8171841C5B7741-8062
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 22: AWD (J492)       Labels: 8K0-907-163.clb
       Part No SW: 8K0 907 163 B    HW: 8K0 907 163 A
       Component: 4 Wheel Drive H14 0100  
       Serial number: 001302130001758
       ASAM Dataset: EV_AllWheelDiffeQSPCAN 003019
       ROD: EV_AllWheelDiffeQSPCAN.rod
       VCID: 2F3BED73E79BF47F377-807A
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 36: Seat Mem. Drvr (J136)       Labels:. 8T0-959-760.clb
       Part No SW: 8T0 959 760 E    HW: 8T0 959 760 E
       Component: MEM-FS        H10 0076  
       Revision: AA000000    Serial number: 00000051211560
       Coding: 001B7B25002C00000000
       Shop #: WSC 11251 001 1048576
       VCID: 45D7AFDB55A75E2FEDB-8010
    
    1 Fault Found:
    03339 - Force Limit for Fore/Aft Seat Adjustment: Back 
                005 - No or Incorrect Basic Setting / Adaptation
                 Freeze Frame:
                        Fault Status: 01100101
                        Fault Priority: 3
                        Fault Frequency: 1
                        Reset counter: 207
                        Mileage: 89104 km
                        Time Indication: 0
                        Date: 2019.03.11
                        Time: 14:59:28
    
    
    -------------------------------------------------------------------------------
    Address 3C: Lane Change (J769)       Labels:| 5Q0-907-566.clb
       Part No SW: 8T0 907 566 B    HW: 8T0 907 566 B
       Component: SWA Master    H04 0060  
       Serial number: 0192285845
       Coding: 010211
       Shop #: WSC 06324 000 00000
       ASAM Dataset: EV_LaneChangAssis 001020
       ROD: EV_LaneChangAssis_AU21.rod
       VCID: 3FDBBD3337FB04FFA77-806A
    
       Lane Change Assistant 2: 
       Subsystem 1 - Part No SW: 8T0 907 568 B    HW: 8T0 907 568 B
       Component: SWA Slave  H04 0060 
       Serial number: 0192294703          
       Coding: 000102
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 42: Door Elect, Driver (J386)       Labels:. 8K0-959-793.clb
       Part No SW: 8T0 959 793 P    HW: 8T0 959 793 G
       Component: TSG FA        H09 0304  
       Revision: --------    Serial number: --------------
       Coding: 011C13224E00120102
       Shop #: WSC 06325 000 00000
       VCID: 56F57897B801E5B7941-8002
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 44: Steering Assist (J500)       Labels:| 8K0-909-144.clb
       Part No SW: 8K0 909 144 F    HW: 8K0 909 144 B
       Component: RCEPS         H36 0507  
       Revision: 00001000    Serial number: 0012646993
       Coding: 010000010001
       Shop #: WSC 06324 000 00000
       ASAM Dataset: EV_RCEPSAU48X 008014
       ROD: EV_RCEPSAU48X_008.rod
       VCID: 3431E21F0EBDD7A74A5-8060
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 46: Central Conv. (J393)       Labels:. 8K0-907-064-46.clb
       Part No SW: 8K0 907 064 GP    HW: 8K0 907 064 FP
       Component: BCM2 2.0      H12 0633  
       Revision: 00002001    Serial number: 0301332569    
       Coding: 0106069A00FAC10581B0003200000000
       Shop #: WSC 92630 444 123950
       VCID: 045172DF1E1DA727BA5-8050
    
       Subsystem 1 - Part No SW: 8K0 959 719 B    HW: 8K0 959 719 
       Component: GTO BF  H01 0080 
       Serial number: 00000000000000634856
    
       Subsystem 2 - Part No: 1K0 951 605 C
       Component: LIN BACKUP HO  H05 1501 
    
       Subsystem 3 - Part No SW: 8R0 959 591 A    HW: 8R0 959 591 
       Component: J245EE20SKB13  H05 0220 
       Serial number: 0123456789ABCDEFGHIJ
    
       Subsystem 4 - Part No SW: 4G8 959 252     HW: 4G8 959 252 
       Component: HSP-SG  H11 0028 
       Serial number: WA104645000002650945
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 47: Sound System (J525)       Labels:. 8T0-035-223-BOM.clb
       Part No SW: 8T1 035 223 A    HW: 8T1 035 223 A
       Component: DSP Prem      H05 0030  
       Revision: 00005001    Serial number: 94813011143102
       VCID: 2D07F77BED17866F05B-8078
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 52: Door Elect, Pass. (J387)       Labels:. 8K0-959-792.clb
       Part No SW: 8T0 959 792 P    HW: 8T0 959 792 G
       Component: TSG BF        H09 0304  
       Revision: --------    Serial number: --------------
       Coding: 011C13224E00120102
       Shop #: WSC 06325 000 00000
       VCID: 55F77F9BA507EEAF9DB-8000
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 53: Parking Brake (----)       Labels: 8K0-907-801-V2.clb
       Part No SW: 8K0 907 801 L    HW: 8K0 907 801 J
       Component: EPB-4         H01 0003  
       Revision: --------    Serial number: 20000000227161
       ASAM Dataset: EV_ParkiBrake 001027
       ROD: EV_ParkiBrake_AU48.rod
       VCID: 3829D62F12D533C766D-806C
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 56: Radio (R)       Labels: Redir Fail!
       Part No SW: 4G0 035 082 H    HW: 4G0 035 082 
       Component: Radio U SIRIU H60 0138  
       Revision: AB001007    Serial number: 156B50D7693479
       Coding: 020007010000000001
       Shop #: WSC 06325 000 00000
       VCID: 25170F5BB5E7BE2FCDB-8070
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 5F: Information Electr. (J794)       Labels:. 4E0-035-6xx-5F.clb
       Part No SW: 8R1 035 746 K    HW: 8R1 035 746 B
       Component: H-BNT-NA      H44 1040  
       Revision: --------    Serial number: 204BT0D7561283
       Coding: 150200020306A9EF75028B4E00000403140000000000000000
       Shop #: WSC 92630 444 123950
       VCID: 3FDBBD33377B04FFA77-806A
    
       Subsystem 1 - Part No: 8R0 060 884 BA
       Component: NAR 2013  0703 
    
       Subsystem 2 - Part No SW: 8R0 919 604 A    HW: 8R0 919 604 A
       Component: DU7 High  H42 0104 
       Serial number: A130BX0D2659970     
    
       Subsystem 3 - Part No SW: 8T0 919 611 L    HW: 8T0 919 611 C
       Component: E0380 Bedient  H02 0030 
       Serial number: 00000001419689      
    
       Subsystem 4 - Part No: 8R0 060 961 E
       Component: CD-Database  4949 
    
    1 Fault Found:
    03276 - Please Check Software Version Management 
                000 -  - 
                 Freeze Frame:
                        Fault Status: 01100000
                        Fault Priority: 6
                        Fault Frequency: 1
                        Reset counter: 207
                        Mileage: 89104 km
                        Time Indication: 0
                        Date: 2019.03.11
                        Time: 14:59:32
    
                 Freeze Frame:
                        Text: DUA130,Front,M,0,0,6                    
    
    
    -------------------------------------------------------------------------------
    Address 6C: Back-up Cam.        Labels: 8T0-907-441.clb
       Part No SW: 8T0 907 441 C    HW: 4L0 907 441 B
       Component: J772__Rearview      0040  
       Revision: --H07---    Serial number: 525PA8-J2Z91FG
       Coding: 1021008
       Shop #: WSC 06325 000 00000
       VCID: 3829D62F1E5533C766D-806C
    
    No fault code found.
    End----(Elapsed Time: 02:02, VBatt start/end: 11.9V/11.8V. VIgn 11.8V)-----
    Last edited by Uwe; 03-11-2019 at 09:07 PM. Reason: CODE tags

  5. #5
    Benevolent Dictator Uwe's Avatar
    Join Date
    Jan 2014
    Location
    Earth
    Posts
    22,521
    Post Thanks / Like
    Blog Entries
    1
    Both faults show battery voltage in the freeze-frame data under 12V.

    Personally, the first thing I would try is doing it with a battery charger connected.

    -Uwe-
    The engineering problems are likely insurmountable. It would be like proposing to land a rocket booster section on a barge floating in the middle of the ocean.

  6. Likes Dana liked this post
  7. #6
    Verified VCDS User
    Join Date
    Nov 2018
    Location
    USA
    Posts
    21
    Post Thanks / Like
    I'll try that. I have a voltage meter in the cig lighter and it said 12.3. Guess it's not calibrated.

  8. #7
    Verified VCDS User
    Join Date
    Nov 2018
    Location
    USA
    Posts
    21
    Post Thanks / Like
    Yep, despite reading 11.9 volts, which is supposed to be fine, hooking it up to a battery tender solved the issue.

  9. Likes NZDubNurd, Uwe, Andy, Dana liked this post

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •