Not sure if this is in the right forum, as it may not actually be a problem...
2019MY SEAT Leon with GPF
I'm trying to look at how the Gasoline Particulate Filter loads up with soot, and I'm seeing the following measured values:
IDE00434 Particle filter: soot mass calculated 0.01g
IDE13085 Particle filter: high level of soot buildup 9.6g
IDE13086 Particle filter: maximum soot build-up reached 16g
Is it possible the "soot mass calculated" is a factor of 10 or 100 out?
I've done some drives and it has peaked at 0.02g, and I've seen it drop off with a prolonged period of exhaust temp over 700 degC.
Which all seems logical, it's just that the soot load of 0.02 seems way too low, particularly if the high and maximum levels are 9.6 and 16.
Thanks
2019MY SEAT Leon with GPF
Code:
Tuesday,15,January,2019,11:42:29:29302
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 18.9.0.4 (x64) HEX-V2 CB: 0.4436.4
Data version: 20181017 DS296.0
www.Ross-Tech.com
VIN: VSSZZZ5FZKR028047 License Plate:
Chassis Type: 5F-SE37 (3Q0)
Scan: 01 02 03 08 09 10 13 14 15 16 17 19 22 42 44 4B 52 5F A9 BB
BC D6 D7
VIN: VSSZZZ5FZKR028047 Mileage: 2354km-1462miles
01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
13-Auto Dist. Reg -- Status: OK 0000
14-Susp. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
22-AWD -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
4B-Multifunc. Module -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
5F-Information Electr. -- Status: Malfunction 0010
A9-Struct. Borne Sound -- Status: OK 0000
BB-Door Rear Drv -- Status: Not registered 0001
BC-Door Rear Pass -- Status: OK 0000
D6-Light Ctrl Left 2 -- Status: OK 0000
D7-Light Ctrl Right 2 -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-DNUE) Labels: None
Part No SW: 8V0 906 259 R HW: 06K 907 425 J
Component: 2.0l R4 TFSI H13 0002
Revision: --H13---
Coding: 0B2540122426010B2000
Shop #: WSC 00049 770 00174
ASAM Dataset: EV_ECM20TFS0208V0906259R 001002
ROD: EV_ECM20TFS0208V0906259R.rod
VCID: 4FF87B21D75A0B1F571-801A
No fault code found.
Readiness: 0000 0000
-------------------------------------------------------------------------------
Address 02: Auto Trans (J743) Labels:. 0BH-927-711.clb
Part No SW: 0GC 300 012 M HW: 0GC 927 711 H
Component: GSG DQ381 H06 2305
Revision: 00H06V07
Coding: 0014
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_TCMDQ381061 001
ROD: EV_TCMDQ381061.rod
VCID: 2D0401A9BD96190F05D-8078
No fault code found.
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels: None
Part No SW: 5Q0 614 517 DG HW: 5Q0 614 517 AG
Component: ESC H62 0654
Revision: 00000000 Serial number: 62728000000312
Coding: 19EE9392542221748777070460CA6998C92A84E1E0069677304250F4C206430100000012121212B835351919323200
Shop #: WSC 00049 770 00201
ASAM Dataset: EV_Brake1UDSContiMK100IPB 037009
ROD: EV_Brake1UDSContiMK100IPB_037_SK37.rod
VCID: 79ACE5F9395E75AFD95-802C
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:| 5G0-907-044.clb
Part No SW: 5F0 907 044 AM HW: 5F0 907 044 AM
Component: Climatronic H05 1801
Revision: 00001K09
Coding: 02100204200114011005000000101020
Shop #: WSC 00049 770 00201
ASAM Dataset: EV_ACClimaBHBVW37X 006145
ROD: EV_ACClimaBHBVW37X_006_SE37.rod
VCID: 71BCDDD9612E3DEF615-8024
Fresh Air Blower Front:
Refrigerant Pressure And Temperature Sender:
Air quality sensor:
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 5Q0-937-08X-V2.clb
Part No SW: 5Q0 937 084 DD HW: 5Q0 937 084 CG
Component: BCM MQBAB H H38 0273
Serial number: 00001828400758
Coding: 000000000000000000000000000000000000000000000000000000000000
Shop #: WSC 00049 770 00174
ASAM Dataset: EV_BCMMQB 019001
ROD: EV_BCMBOSCH_019_VW37.rod
VCID: 7DA4F1E92D76498FF5D-8028
Control Unit For Wiper Motor:
Subsystem 1 - Part No SW: 5F2 955 119 A HW: 5F2 955 119 Labels: 5QX-955-119-V1.CLB
Component: WWS370 180910 041 0574
Serial number: 180919012754
Coding: 0BC5FD
Rain Light Recognition Sensor:
Subsystem 2 - Part No SW: 81A 955 555 A HW: 81A 955 555
Component: G397_RLFSS H06 0002
Serial number: 21897850X81A955555A0
Coding: 00005D
Sensor For Anti Theft Alarm System:
Subsystem 3 - Part No SW: 5Q0 951 172 HW: 5Q0 951 172
Component: Sensor, DWA 005 0316
Serial number: 000000000ZY181900HGW
Alarm horn:
Subsystem 4 - Part No SW: 5Q0 951 605 B HW: 5Q0 951 605 B
Component: Sirene, DWA 004 0007
Serial number: 00000000000000213845
No fault code found.
-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446) Labels:| 5Q0-919-294.clb
Part No SW: 5QA 919 294 C HW: 5QA 919 294
Component: PDC 8 KanalH07 0050
Serial number: 000308418618277
Coding: 0471051011
Shop #: WSC 00049 770 00201
ASAM Dataset: EV_EPHVA18AU3700000 009039
ROD: EV_EPHVA18AU3700000_009_VW37.rod
VCID: 4CC26C2D264C3007323-8018
No fault code found.
-------------------------------------------------------------------------------
Address 13: Auto Dist. Reg (J428) Labels:| 3Q0-907-572.clb
Part No SW: 5Q0 907 572 P HW: 5Q0 907 572 J
Component: ACC BOSCH MQB H11 0682
Coding: 3500008159FF8428949C814500300400000000000000000000
Shop #: WSC 00049 770 00174
ASAM Dataset: EV_ACCBOSCHVW416 002008
ROD: EV_ACCBOSCHVW416_002_VW37.rod
VCID: 44D2440D0E1CF847FA3-8010
No fault code found.
-------------------------------------------------------------------------------
Address 14: Susp. Elect. (J250) Labels: 5Q0-907-376.clb
Part No SW: 5Q0 907 376 B HW: 5Q0 907 376 A
Component: DAEMPFUNGS-SG H17 0121
Serial number: 19081841350334
ASAM Dataset: EV_DRCONTITEMIC 001019
ROD: EV_DRCONTITEMIC_VW37.rod
VCID: 382A20FD42D4ACA766B-806C
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:| 5Q0-959-655.clb
Part No SW: 3Q0 959 655 BH HW: 3Q0 959 655 BH
Component: Airbag VW21 006 0712
Revision: -------- Serial number: 003W4PLXXQNS
Coding: 98CCC000000000005C0000CC008800000065
Shop #: WSC 00049 770 00201
ASAM Dataset: EV_AirbaVW21TS6VW48X 001014
ROD: EV_AirbaVW21TS6VW48X_VW37.rod
VCID: 0554990945A6014FADD-8050
Side Sensor Driver Front:
Subsystem 1 - Part No SW: ----------- HW: 454 000 310 18
Component: SideSensor_Df 008 0887
Serial number: 35700000000783842239
Coding: 2D2D2D
Side Sensor Passenger Front:
Subsystem 2 - Part No SW: ----------- HW: 454 000 310 18
Component: SideSensor_Pf 008 0887
Serial number: 358000000004D584223E
Coding: 2D2D2D
Side Sensor Driver Rear:
Subsystem 3 - Part No SW: ----------- HW: 454 802 809 18
Component: SideSensor_Dr 301 0148
Serial number: 3510099B46F16000000R
Coding: 2D2D2D
Side Sensor Passenger Rear:
Subsystem 4 - Part No SW: ----------- HW: 454 802 909 18
Component: SideSensor_Pr 301 0148
Serial number: 35200C6F66416000000N
Coding: 2D2D2D
Front Sensor Driver:
Subsystem 5 - Part No SW: ----------- HW: 454 800 310 18
Component: FrontSensor_D 304 0149
Serial number: 3550083C72316000000C
Coding: 2D2D2D
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels:| 5Q0-953-549.clb
Part No SW: 5Q0 953 507 GP HW: 5Q0 953 549 E
Component: Lenks. Modul 003 0140
Revision: -------- Serial number: 03101820241039
Coding: 1410
Shop #: WSC 00049 770 00201
ASAM Dataset: EV_SMLSKLOMQB 020002
ROD: EV_SMLSKLOMQB_VW37.rod
VCID: 0A4EAA356CB86E37C0F-805E
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5G0-920-XXX-17.clb-SRI3
Part No SW: 5F0 920 790 A HW: 5F0 920 790 A
Component: KOMBI 609 1701
Coding: 24AD3808BB800600018876011001000080000000
Shop #: WSC 00049 770 00201
ASAM Dataset: EV_DashBoardVDDMQBA0 001026
ROD: EV_DashBoardVDDMQBA0_VW37.rod
VCID: 2708F3819F6A335FFF1-8072
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:| 3Q0-907-530-V1.clb
Part No SW: 3Q0 907 530 Q HW: 3Q0 907 530 C
Component: GW MQB High 439 4344
Revision: -------- Serial number: 0008645501
Coding: 030100F42F085900FB0082689C0F00010001070000000000000000000000
Shop #: WSC 00049 770 00201
ASAM Dataset: EV_GatewNF 013044
ROD: EV_GatewNF_VW37.rod
VCID: 3D2431E96DF6898FB5D-8068
Alternator:
Multi Function Steering Wheel Control Module:
Subsystem 2 - Part No SW: 5F0 959 537 D HW: 5F0 959 537 D
Component: E221__MFL-PR6 H04 0130
Serial number: 000000000I0365170918
Coding: 012000
Battery Monitoring Control Module:
Subsystem 3 - Part No SW: 5Q0 915 181 J HW: 5Q0 915 181 J
Component: J367-BDMConti H03 1050
Serial number: 75886002001810051C98
No fault code found.
-------------------------------------------------------------------------------
Address 22: AWD (J492) Labels:* 0CQ-907-554.clb
Part No SW: 0CQ 907 554 J HW: 0CQ 525 130
Component: Haldex4Motion H52 7084
Serial number: HA1-00026.07.18
Coding: 0001
Shop #: WSC 00049 770 00174
ASAM Dataset: EV_AllWheelContrHA1VW37X 004013
ROD: EV_AllWheelContrHA1VW37X_004.rod
VCID: 4CC26C2D264C3007323-8018
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:* None
Part No SW: 5Q4 959 593 M HW: 5Q4 959 593 F
Component: TSG FS 006 0247
Serial number: 0000346921447
Coding: 00140220DC01020000001000
Shop #: WSC 00049 770 00174
ASAM Dataset: EV_DCU2DriveSideMAXHCONT 001005
ROD: EV_DCU2DriveSideMAXHCONT_VW37.rod
VCID: 4FF87B21D75A0B1F571-801A
Drivers Door Rear Control Module:
Subsystem 1 - Part No SW: 5Q0 959 812 E HW: 5Q0 959 812 E
Component: FOND_FHSG_DRV 006 0007
Serial number: 00000000000024084719
Coding: 2D0000
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist (J500) Labels:| 5Q0-909-144.clb
Part No SW: 3Q0 909 144 M HW: 3Q0 909 144 L
Component: EPS_MQB_ZFLS 507 5082
Coding: 81170000
Shop #: WSC 00049 770 00174
ASAM Dataset: EV_SteerAssisMQB 015157
ROD: EV_SteerAssisMQB_015.rod
VCID: 3C223CED76EC8087823-8068
No fault code found.
-------------------------------------------------------------------------------
Address 4B: Multifunc. Module (J745) Labels:* None
Part No SW: 3Q0 907 338 C HW: 3Q0 907 338 C
Component: FCM MQB Low 002 0345
Serial number: 03101810803813
Coding: 000000070900095607000900000000000000000000000000000000000000
Shop #: WSC 00049 770 00201
ASAM Dataset: EV_MultiModulContiVW48X 002006
ROD: EV_MultiModulContiVW48X_002_VW37.rod
VCID: 353429C955C651CF7DD-8060
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:* None
Part No SW: 5Q4 959 592 M HW: 5Q4 959 592 F
Component: TSG BFS 006 0247
Serial number: 0000347509768
Coding: 00140020DE01020000001000
Shop #: WSC 00049 770 00174
ASAM Dataset: EV_DCU2PasseSideMAXHCONT 001005
ROD: EV_DCU2PasseSideMAXHCONT_VW37.rod
VCID: 4EC66625D05002175C7-801A
Passengers Rear Door Control Module:
Subsystem 1 - Part No SW: 5Q0 959 811 E HW: 5Q0 959 811 E
Component: FOND_FHSG_PSG 006 0007
Serial number: 00000000000024050442
Coding: 350000
No fault code found.
-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794) Labels:* None
Part No SW: 5F0 035 877 HW: 5F0 035 877
Component: MU-S-ND-ER H50 0512
Serial number: SEZAZ2U0823349
Coding: 04738201D70A00001111010100880A002F0202E601200400CE
Shop #: WSC 02391 785 00200
ASAM Dataset: EV_MUStd6C1TSAT 001015
ROD: EV_MUStd6C1TSAT_SK25.rod
VCID: 698CB5B949FEC52F295-803C
Operating And Display Unit 1:
Subsystem 1 - Part No SW: 5F0 919 606 A HW: 5F0 919 606 A
Component: ABTm-2_8-BL H41 1042
Serial number: SEZ8Z9V6D001Y5
Data medium:
Subsystem 2 - Part No SW: 6P0 919 866 AF HW: -----------
Component: ECE1 2018/19 --- 1030
Serial number: --------------------
1 Fault Found:
1637 - Interface for External Media
U11B8 00 [008] - No Communications
[USB - communication error]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 4
Fault Frequency: 1
Reset counter: 62
Mileage: 2098 km
Date: 2019.01.08
Time: 16:05:17
Voltage terminal 30: 12.1 V
Interface for external media: status-Status: Open circuit
-------------------------------------------------------------------------------
Address A9: Struct. Borne Sound (J869) Labels: 4H0-907-159.clb
Part No SW: 5F0 907 159 D HW: 4H0 907 159 A
Component: SAS-GEN 2 H07 0001
Serial number: 181004200298
ASAM Dataset: EV_SoundActuaGen2AU64X 003010
ROD: EV_SoundActuaGen2AU64X.rod
VCID: 2E0606A5B09062173C7-807A
No fault code found.
-------------------------------------------------------------------------------
Address BB: Door Rear Drv
Cannot be reached
-------------------------------------------------------------------------------
Address BC: Door Rear Pass
Cannot be reached
-------------------------------------------------------------------------------
Address D6: Light Ctrl Left 2 (A31) Labels: 7P5-941-591.clb
Part No SW: 7P5 941 591 AD HW: 7P5 941 591 A
Component: LED1L H06 0005
ASAM Dataset: EV_LED_PLUS_L_KEBODAVW416 001003
ROD: EV_LED_PLUS_L_KEBODAVW416_VW37.rod
VCID: 7EA6F6E520705297EC7-802A
No fault code found.
-------------------------------------------------------------------------------
Address D7: Light Ctrl Right 2 (A27) Labels: 7P5-941-591.clb
Part No SW: 7P5 941 591 AD HW: 7P5 941 591 A
Component: LED1R H06 0005
ASAM Dataset: EV_LED_PLUS_R_KEBODAVW416 001003
ROD: EV_LED_PLUS_R_KEBODAVW416_VW37.rod
VCID: 7EA6F6E520705297EC7-802A
No fault code found.
End----------(Elapsed Time: 01:48, VBatt start/end: 12.2V/12.2V)-----------
I'm trying to look at how the Gasoline Particulate Filter loads up with soot, and I'm seeing the following measured values:
IDE00434 Particle filter: soot mass calculated 0.01g
IDE13085 Particle filter: high level of soot buildup 9.6g
IDE13086 Particle filter: maximum soot build-up reached 16g
Is it possible the "soot mass calculated" is a factor of 10 or 100 out?
I've done some drives and it has peaked at 0.02g, and I've seen it drop off with a prolonged period of exhaust temp over 700 degC.
Which all seems logical, it's just that the soot load of 0.02 seems way too low, particularly if the high and maximum levels are 9.6 and 16.
Thanks