Hi,
I'm new to Ross-Tech and this is my first post. I've tried to be as detailed as possible but if I've missed something please let me know. I'm having issues with the DPF on my 2008 Audi A5 3.0 TDI. The issue has been ongoing intermittently for the year and a half that I've owned the car. It's been to a couple of different Audi specialists and the issue is still present, although can go 2 -3 months with out presenting itself. The two DTC's which usually present themselves are: 5188 - Diesel Particulate Filter (Bank 1) P242F 00 [032] - Restricted/Clogged and 5189 - Particulate Trap Bank 1 P2002 00 [032] - Efficiency Below Threshold. It does occasionally present the error 5162 - Exhaust Pressure Sensor 1 (G450)P0471 00 [229] - Implausible Signal although has not yet done this since the latest pressure sensor change.
The EGR valve has been replaced as after the first pressure sensor change the car popped up with an EGR fault . The car's software has all been updated. The car has had the G450 Pressure sensor replaced three times, once before the EGR valve and twice after at different garages.
The first two codes popped up again today whilst in stuck in town traffic. The car had just completed a 20 mile run at 60mph plus and then spent around ten minutes in queued traffic The DPF was not due a regeneration (does it around every 200 miles since software update) as the car had only covered just over 50 miles since the last one completed. The DPF light lit up, stayed on for around 30 seconds, then went out and got the flashing glowplug and limp mode. After leaving the car switched off for around 45 minutes, switched back on and no DPF light or flashing glowplug with full power restored. The car has done this previously whilst stuck in traffic, once after around 100 miles on a motorway.
The freeze frame data show the Distance since regeneration at 0 miles however when going into advance measuring the data shows 54 miles since last regeneration. Clearly something is not right. With the engine off the car showed the Calculated soot level at 12.56g and measured at 0.72g. I then started the engine monitoring these fields and the measured soot levels whilst at idle increased to 24.19g after around 60 seconds before dropping back down to 3.16g after 10 minutes of sitting at idle. Calculated increased slightly to 12.65g. No error codes appeared during this 10 minutes sat at idle.
The garages have checked all connections, wiring, pressure pipe and can find no issues. Does anyone have any ideas on what could be causing this error?
Many Thanks
Michael
I'm new to Ross-Tech and this is my first post. I've tried to be as detailed as possible but if I've missed something please let me know. I'm having issues with the DPF on my 2008 Audi A5 3.0 TDI. The issue has been ongoing intermittently for the year and a half that I've owned the car. It's been to a couple of different Audi specialists and the issue is still present, although can go 2 -3 months with out presenting itself. The two DTC's which usually present themselves are: 5188 - Diesel Particulate Filter (Bank 1) P242F 00 [032] - Restricted/Clogged and 5189 - Particulate Trap Bank 1 P2002 00 [032] - Efficiency Below Threshold. It does occasionally present the error 5162 - Exhaust Pressure Sensor 1 (G450)P0471 00 [229] - Implausible Signal although has not yet done this since the latest pressure sensor change.
The EGR valve has been replaced as after the first pressure sensor change the car popped up with an EGR fault . The car's software has all been updated. The car has had the G450 Pressure sensor replaced three times, once before the EGR valve and twice after at different garages.
The first two codes popped up again today whilst in stuck in town traffic. The car had just completed a 20 mile run at 60mph plus and then spent around ten minutes in queued traffic The DPF was not due a regeneration (does it around every 200 miles since software update) as the car had only covered just over 50 miles since the last one completed. The DPF light lit up, stayed on for around 30 seconds, then went out and got the flashing glowplug and limp mode. After leaving the car switched off for around 45 minutes, switched back on and no DPF light or flashing glowplug with full power restored. The car has done this previously whilst stuck in traffic, once after around 100 miles on a motorway.
The freeze frame data show the Distance since regeneration at 0 miles however when going into advance measuring the data shows 54 miles since last regeneration. Clearly something is not right. With the engine off the car showed the Calculated soot level at 12.56g and measured at 0.72g. I then started the engine monitoring these fields and the measured soot levels whilst at idle increased to 24.19g after around 60 seconds before dropping back down to 3.16g after 10 minutes of sitting at idle. Calculated increased slightly to 12.65g. No error codes appeared during this 10 minutes sat at idle.
The garages have checked all connections, wiring, pressure pipe and can find no issues. Does anyone have any ideas on what could be causing this error?
Many Thanks
Michael
Code:
Wednesday,01,August,2018,18:35:03:27910
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 18.2.1.2 (x64) HEX-V2 CB: 0.4411.4
Data version: 20180518 DS287.1
www.Ross-Tech.com
VIN: WAUZZZ8T88A021410 License Plate: XXXXXX
Mileage: 150220km-93342mi Repair Order: 0108181834
Address 01: Engine (8K0 907 401 F)
18:34:46
ENG107988 Distance since last regeneration 87663 m
ENG106427 Exhaust gas temp.after pre-catalyst 140.0 °C
ENG106429 Exhaust gas temp.bef.turbocharger 122.4 °C
ENG106430 Exhaust gas temperature before particulate filter 131.2 °C
ENG105211 Exhaust gas vol.flow particulate filter 0.0 m³/h
ENG107984 Oil ash 0.26 l
ENG107975 Soot mass calculated 12.56 g
ENG107974 Soot mass measured 0.72 g
Code:
Wednesday,01,August,2018,18:31:35:27910
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 18.2.1.2 (x64) HEX-V2 CB: 0.4411.4
Data version: 20180518 DS287.1
www.Ross-Tech.com
VIN: WAUZZZ8T88A021410 License Plate: xxxxxx
Mileage: 150220km-93342mi Repair Order: 0108181831
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: 8T-AU48 (8T0)
Scan: 01 03 05 06 07 08 09 0E 10 15 16 17 19 36 37 42 46 47 52 53
55 56 6C 77
VIN: WAUZZZ8T88A021410 Mileage: 150220km-93342miles
01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
06-Seat Mem. Pass -- Status: Malfunction 0010
07-Control Head -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: OK 0000
0E-Media Player 1 -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
37-Navigation -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
47-Sound System -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
6C-Back-up Cam. -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CAPA) Labels:| 059-907-401-V1.clb
Part No SW: 8K0 907 401 F HW: 8K0 907 401
Component: 3.0TDI EDC17 H01 0008
Revision: --H01---
Coding: 0114002C180F0118
Shop #: WSC 74565 000 1048576
ASAM Dataset: EV_ECM30LTDIA5 A02008
ROD: EV_ECM30LTDIA5_A02.rod
VCID: 2E05F3F630919517D3B-807A
3 Faults Found:
5188 - Diesel Particulate Filter (Bank 1)
P242F 00 [032] - Restricted/Clogged
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 150221 km
Date: 2018.08.01
Time: 17:13:10
Engine speed: 809.50 /min
Normed load value: 25.5 %
Vehicle speed: 0 km/h
Coolant temperature: 84 °C
Intake air temperature: 38 °C
Ambient air pressure: 1010 mbar
Voltage terminal 30: 14.320 V
Unlearning counter according OBD: 40
Engine speed: 804.0 /min
Vehicle speed: 0.00 km/h
Field regeneration status-Bits 0-7: 00000000
Field regeneration status-Bits 0-7: 00101110
Field regeneration status-Bits 0-7: 00000000
Field regeneration status-Bits 0-7: 00000000
Particul.filter diff.pressure: 8 hPa
Exh t Adap TP Flt Us: -270.0 °C
Exhaust gas vol.flow particulate filter: 66.2 m³/h
Distance since last regeneration: 0 m
5417 - Glowplug for Cylinder 5 (Q15)
P161E 00 [109] - Open Circuit
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 149595 km
Date: 2018.07.23
Time: 08:44:50
Engine speed: 1165.00 /min
Normed load value: 64.7 %
Vehicle speed: 0 km/h
Coolant temperature: 24 °C
Intake air temperature: 23 °C
Ambient air pressure: 1010 mbar
Voltage terminal 30: 11.640 V
Unlearning counter according OBD: 40
Engine speed: 1165.0 /min
Vehicle speed: 0.00 km/h
Vehicle voltage terminal 30: 11660 mV
Coolant temperature: 24.7 °C
Preheating system status-Bits 0-7: 00000000
Preheating system status-Bits 0-7: 10110000
Glw Plg r LVS Ps: 21.65 %
Intake air temperature: 23.5 °C
5189 - Particulate Trap Bank 1
P2002 00 [032] - Efficiency Below Threshold
Intermittent - Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 150221 km
Date: 2018.08.01
Time: 17:13:10
Engine speed: 809.50 /min
Normed load value: 25.5 %
Vehicle speed: 0 km/h
Coolant temperature: 84 °C
Intake air temperature: 38 °C
Ambient air pressure: 1010 mbar
Voltage terminal 30: 14.320 V
Unlearning counter according OBD: 40
Engine speed: 804.0 /min
Vehicle speed: 0.00 km/h
Field regeneration status-Bits 0-7: 00000000
Field regeneration status-Bits 0-7: 00101110
Field regeneration status-Bits 0-7: 00000000
Field regeneration status-Bits 0-7: 00000000
Particul.filter diff.pressure: 8 hPa
Exh t Adap TP Flt Us: -270.0 °C
Exhaust gas vol.flow particulate filter: 66.2 m³/h
Distance since last regeneration: 0 m
Readiness: 0 0 0 0 0
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels:. 8K0-907-379-V1.clb
Part No SW: 8K0 907 379 N HW: 8K0 907 379 N
Component: ESP8 quattro H03 0210
Revision: -------- Serial number: --------------
Coding: 1B4500
Shop #: WSC 06325 000 00000
VCID: 44D1B15E8E9D0F4715F-8010
No fault code found.
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393) Labels:. 8K0-907-064-05.clb
Part No SW: 8K0 907 289 C HW: 8K0 907 289 C
Component: BCM2.01 H38 0253
Revision: 00003002
Coding: 031000
Shop #: WSC 06325 000 00000
VCID: 392FD0AAF95F42AF769-806C
Subsystem 1 - Part No SW: 8T0 959 754 D HW: 8T0 959 754 D
Component: FBSAUDIB8 IDG H34 0050
Serial number: 0107000147258012
Subsystem 2 - Part No SW: 8K0 905 852 C HW: 8K0 905 852 C
Component: ELVAUDIB8 H35 0039
Serial number: 0207000001350008
No fault code found.
-------------------------------------------------------------------------------
Address 06: Seat Mem. Pass (J521) Labels:. 8T0-959-760.clb
Part No SW: 8T0 959 760 B HW: 8T0 959 760 B
Component: MEM-BFS H09 0043
Revision: AA000000 Serial number: 00001001046034
Coding: 08217025002444111000
Shop #: WSC 00579 210 91872
VCID: 42DDB74694890177273-8016
1 Fault Found:
03338 - Force Limit for Fore/Aft Seat Adjustment: Forwards
005 - No or Incorrect Basic Setting / Adaptation
Freeze Frame:
Fault Status: 01100101
Fault Priority: 3
Fault Frequency: 1
Reset counter: 196
Mileage: 147858 km
Time Indication: 0
Date: 2018.06.11
Time: 17:58:08
-------------------------------------------------------------------------------
Address 07: Control Head Labels: 8T0-035-7xx-07-H.clb
Part No SW: 8T0 035 729 F HW: 4E0 035 729 A
Component: Interfacebox H43 4690
Revision: 00000000 Serial number: 331KQ077515209
Coding: 0005002
Shop #: WSC 06325 000 00000
VCID: 3C21C9BEFA6D77876DF-8068
Subsystem 1 - Part No: 8T0 919 609
Component: E0380 BedienteilH07 0100
Subsystem 2 - Serial number: 00000000024033
Subsystem 3 - Serial number: 0117.10.070000000100010063ÿ
Subsystem 4 - Serial number: 010063ÿ
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:. 8Tx-820-043-3Z.clb
Part No SW: 8T2 820 043 N HW: 8T2 820 043 N
Component: KLIMA 3 ZONEN H05 0120
Revision: D1000000 Serial number: 0107.11.070004
Coding: 36060000
Shop #: WSC 06325 000 00000
VCID: 3D27C4BAED777E8F5A1-8068
2 Faults Found:
01087 - Basic Setting Not Performed
005 - No or Incorrect Basic Setting / Adaptation
Freeze Frame:
Fault Status: 01100101
Fault Priority: 3
Fault Frequency: 1
Reset counter: 174
Mileage: 147338 km
Time Indication: 0
Date: 2018.05.25
Time: 12:10:22
01274 - Air Flow Flap Positioning Motor (V71)
003 - Mechanical Failure - Intermittent
Freeze Frame:
Fault Status: 00100011
Fault Priority: 3
Fault Frequency: 224
Reset counter: 65
Mileage: 147340 km
Time Indication: 0
Date: 2018.05.25
Time: 16:37:03
Freeze Frame:
Voltage: 14.50 V
Temperature: 14.0°C
Temperature: 11.0°C
Count: 10681
Count: 10904
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 8K0-907-063.clb
Part No SW: 8K0 907 063 D HW: 8K0 907 063 D
Component: BCM1 1.0 H21 0253
Revision: 05021001 Serial number: 00000000051818
Coding: 260050910014AF010009000300005D5D001D038800010141000000
Shop #: WSC 00385 210 90023
VCID: 3039ED8E2A2583E7C17-8064
Subsystem 1 - Part No SW: 8T2 955 119 B HW: 8J2 955 119 Labels: 1KX-955-119.CLB
Component: WWS 271007 H11 0040
Serial number: SWFBIE 0000205
Coding: 00FD11
Subsystem 2 - Part No SW: 8K0 955 559 HW: 8K0 955 559 Labels: 8K0-955-559.CLB
Component: RLS H04 0002
Serial number: 10017544
Coding: 02532C
Subsystem 3 - Part No SW: 8K0 941 531 G HW: 8K0 941 531 G
Component: E1 - LDS H07 0070
Serial number: 00000000000511070071
No fault code found.
-------------------------------------------------------------------------------
Address 0E: Media Player 1 Labels: 4E0-910-111.lbl
Part No SW: 8T2 035 110 B HW: 8T2 035 110 A
Component: MP3-Changer H42 0380
Revision: 00042002 Serial number: AUZ5ZBG4531892
Shop #: WSC 00000 000 00000
VCID: 2A0DFFE600F9F9370F3-807E
No fault code found.
-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446) Labels:. 8K0-919-475.clb
Part No SW: 8K0 919 475 C HW: 8K0 919 475 A
Component: PARKHILFE 8K H06 0010
Revision: 11001001 Serial number: 75230731706491
Coding: 300001
Shop #: WSC 06325 000 00000
VCID: 392FD0AAF95F42AF769-806C
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:| 8K0-959-655.clb
Part No SW: 8K0 959 655 B HW: 8K0 959 655 B
Component: AirbagVW-AU10 H23 0409
Serial number: 0038JD11DDB$
Coding: 30323433363030303030554A305238543053
Shop #: WSC 06325 000 00000
ASAM Dataset: EV_AirbaECUVWAUDI010 A02001
ROD: EV_AirbaECUVWAUDI010_A02.rod
VCID: 3C21C9BEF6ED77876DF-8068
Crash sensor for side airbag: driver side:
Serial number: 6334MSME3177541EF
Crash sensor for side airbag: front passenger side:
Serial number: 6344MSME3174387DK
Crash sensor for side airbag: rear: driver side:
Serial number: 6352QSME4577314BJ
Crash sensor for side airbag: rear: passenger side:
Serial number: 6362QSME4628364BM
Crash sensor for front airbag: driver side:
Serial number: 63732SME447B38395
Crash sensor for front airbag: front passenger side:
Serial number: 63832SME447A4009
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels:. 8K0-953-568.clb
Part No SW: 8K0 953 568 F HW: 8K0 953 568 F
Component: Lenks.Modul H10 0012
Revision: -------- Serial number: 90304GJV0002P
Coding: 000016
Shop #: WSC 06325 000 00000
VCID: 3D27C4BAED777E8F5A1-8068
Component: E221 - MFL H02 0003
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:. 8T0-920-xxx-17.clb
Part No SW: 8T0 920 981 B HW: 8T0 920 981 B
Component: KOMBIINSTR. H28 0214
Revision: 00100000 Serial number: 71Y36R5C7
Coding: 2F05010002002600010000
Shop #: WSC 06325 000 00000
VCID: 3B23CAA2F36370BF645-806E
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:. 8T0-907-468.clb
Part No SW: 8T0 907 468 F HW: 8T0 907 468 F
Component: GW-BEM 4CAN-M H07 0084
Revision: EB002032 Serial number: 3200E07A178057
Coding: 000003
Shop #: WSC 00583 210 66199
VCID: 44D1B15E8E9D0F4715F-8010
Subsystem 1 - Part No SW: 8K0 915 181 HW: 8K0 915 181
Component: J367-BDM H06 0150
Serial number: 17006C18221007
No fault code found.
-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr (J136) Labels:. 8T0-959-760.clb
Part No SW: 8T0 959 760 B HW: 8T0 959 760 B
Component: MEM-FS H09 0043
Revision: AA000000 Serial number: 00001001047015
Coding: 08397325002444111000
Shop #: WSC 06325 000 00000
VCID: 42DDB74694890177273-8016
No fault code found.
-------------------------------------------------------------------------------
Address 37: Navigation Labels: 4E0-910-88x-37.lbl
Part No SW: 4E0 910 887 T HW: 4E0 919 887 M
Component: MNS ECE H50 1030
Revision: 00000000 Serial number: 333K 077526955
Shop #: WSC 00583 210 66199
VCID: 3E25C3B6EC71659743B-806A
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:. 8K0-959-793.clb
Part No SW: 8T0 959 793 J HW: 8T0 959 793 D
Component: TSG FA H07 1301
Revision: -------- Serial number: --------------
Coding: 011002225E01120102
Shop #: WSC 74565 000 1048576
VCID: 50F98D0E4AE5E3E7A17-8004
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv. (J393) Labels:. 8K0-907-064-46.clb
Part No SW: 8K0 907 289 C HW: 8K0 907 289 C
Component: BCM2.01 H38 0253
Revision: 00003002 Serial number: 0107198771
Coding: 011B0682003904C0002000
Shop #: WSC 06335 000 00000
VCID: 392FD0AAF95F42AF769-806C
Subsystem 1 - Part No: 8K0 951 177
Component: DWA-Sensor H02 0030
Subsystem 2 - Part No: 1K0 951 605 C
Component: LIN BACKUP HO H03 1301
No fault code found.
-------------------------------------------------------------------------------
Address 47: Sound System (J525) Labels:. 8T0-035-223-BOM.clb
Part No SW: 8T0 035 223 M HW: 8T0 035 223 C
Component: DSP Prem H12 0280
Revision: 00H12003 Serial number: 34813000942102
Coding: 020101
Shop #: WSC 12336 024 394758
VCID: 3829D5AEC2555BA7897-806C
1 Fault Found:
02247 - Subwoofer (R148/R157)
007 - Short to Ground
Freeze Frame:
Fault Status: 01100111
Fault Priority: 5
Fault Frequency: 1
Reset counter: 174
Mileage: 147338 km
Time Indication: 0
Date: 2018.05.25
Time: 16:32:28
Freeze Frame:
Voltage: 12.00 V
Temperature: 5.0°C
Temperature: 8.0°C
Bin. Bits: 00000100
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:. 8K0-959-792.clb
Part No SW: 8K0 959 792 HW: 8K0 959 792
Component: TSG BF H09 0149
Revision: Serial number: ˆi
Coding: 011002225E012201
Shop #: WSC 06335 000 00000
VCID: 7CA109BEB6EDB7872DF-8028
No fault code found.
-------------------------------------------------------------------------------
Address 53: Parking Brake (J540) Labels: 8K0-907-801-V1.clb
Part No SW: 8K0 907 801 C HW: 8K0 907 801 C
Component: EPB Audi B8 H03 0040
Revision: 00000003 Serial number: 00000000030043
Shop #: WSC 00000 000 00000
VCID: 2F3BEEF2371B9C1FD8D-807A
No fault code found.
-------------------------------------------------------------------------------
Address 55: Headlight Range Labels: 8K0-907-357.clb
Part No: 8K0 907 357 A
Component: Dynamische LWR H01 0010
Revision: 00000001 Serial number:
Coding: 0000002
Shop #: WSC 06325 000 00000
VCID: 3333E282D733B8FFBC5-8066
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio Labels: 4E0-910-541.lbl
Part No SW: 4E0 910 541 Q HW: 4F0 035 541 L
Component: TUNER EU/US/RDW H42 0620
Revision: 00000000 Serial number: 336KY077524392
Coding: 0000001
Shop #: WSC 06325 000 00000
VCID: 2E05F3F63C119517D3B-807A
No fault code found.
-------------------------------------------------------------------------------
Address 6C: Back-up Cam. Labels: 8T0-907-441.clb
Part No SW: 8T0 907 441 HW: 4L0 907 441 A
Component: J772__Rearview 0040
Revision: --H12--- Serial number: 525PA8-J7X5068
Coding: 1022008
Shop #: WSC 06325 000 00000
VCID: 75B71C9A99C7E6CF521-8020
No fault code found.
-------------------------------------------------------------------------------
Address 77: Telephone Labels: 4E0-910-336.lbl
Part No SW: 4E0 910 336 K HW: 4E0 862 335
Component: Handyvorb2 H18 0950
Revision: 00000000 Serial number: 00000005112835
Coding: 0010920
Shop #: WSC 00385 210 89996
VCID: 2A0DFFE600F9F9370F3-807E
No fault code found.
End----------(Elapsed Time: 01:53, VBatt start/end: 12.1V/12.0V)-----------