You really need to fix everything else ailing this engine first, otherwise the DPF will just get clogged up again.
-Uwe-
DPF Regeneration failure on 2012 VW Touareg TDI
- Thread starter amizan
- Start date
-Uwe-
So... Uwe you were correct (or maybe the Autoscan was correct). After inspection of the air intake, one of the large hoses to the driver's side intercooler had come undone! I am not sure if it came undone because i drove 5 miles in limp mode and put a strain on the system or because the mechanic that messed up the EGR sensor connection also left this without a clip.... Now the air intake issues are gone and the Differential Pressure Sensor issue is gone as well. The only thing remaining is the DPF clogging.
The Differential Pressure Sensor readings in the Adv. Measuring Values section are similar to before and i also have these two as well on the DPF:
IDE00435 Particle filter: soot mass measured: 34.00 g
IDE00434 Particle filter: soot mass calculated: 60.45 g
The strange thing is that the Autoscan reads this:
Partile filter: soot mass measured: 149.30 g - what is this so different than what appears in the Adv. Measuring Value?
Particle filter: soot mass calculated: 60.35 g
Particul.filter diff.pressure: 160 hPa - The sensor reads 360hPA in the Adv. Measuring Value....?
I also read that the DPF might be near the end of its life if it is actually full of Ash (not soot). do you know what this symbolizes below in the autoscan?
"P Flt Ld fac Ash Cor: 1.0000 "
I feel that the EZ off solution did not work and I am back to square one having to remove and try clean the DPF... I might just take it to have it baked and professionally cleaned.
See below updated Autoscan.
Code:
Wednesday,20,April,2022,17:17:00:45649
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 22.3.0.1 (x64) HEX-V2 CB: 0.4615.4
Data version: Unknown DS336.1
www.Ross-Tech.com
VIN: WVGEK9BP1CD005604 License Plate:
Chassis Type: BP-VW52 (7P6)
Scan: 01 02 03 05 08 09 15 16 17 19 36 42 46 52 53 55 56 5F 62 65
69 6C 6D 72
VIN: WVGEK9BP1CD005604 Mileage: 398622km-247692miles
01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: Malfunction 0010
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: Malfunction 0010
46-Central Conv. -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: Malfunction 0010
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
5F-Information Electr. -- Status: Malfunction 0010
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: Malfunction 0010
69-Trailer -- Status: OK 0000
6C-Back-up Cam. -- Status: OK 0000
6D-Trunk Elect. -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CATA) Labels: None
Part No SW: 7P0 907 401 J HW: 7P0 907 401 E
Component: 3.0TDI EDC17 H17 0005
Revision: 56H17--- CVN: 0FF473B738D3FF8238D3FF82
Coding: 292A4012233600050000
Shop #: WSC 02330 444 92460
ASAM Dataset: EV_ECM30TDI0117P0907401J 001005
ROD: EV_ECM30TDI0117P0907401J_001.rod
VCID: 3635DA6018CC58AB25E-8062
VINID: 9E65D56C94A00535000051801004E1B29D
2 Faults Found:
5188 - Particle Filter
P2463 00 [175] - Excessive Soot Accumulation
MIL ON - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 398622 km
Date: 2022.04.20
Time: 04:48:26
Engine RPM: 979.50 /min
Normed load value: 30.2 %
Vehicle speed: 0 km/h
Coolant temperature: 27 °C
Intake air temperature: 21 °C
Ambient air pressure: 1010 mbar
Voltage terminal 30: 13.520 V
Unlearning counter according OBD: 40
P Flt Ld fac Ash Cor: 1.0000
Particul.filter diff.pressure: 160 hPa
Exh t Adap T Oxi Cat Ds: 49.8 °C
Exh t Adap TP Flt Ds: 25.4 °C
Exhaust gas jet volume in particle filter: 42.5 m³/h
Current operating mode_2-Bits 0-7: 00000000
Current operating mode_2-Bits 0-7: 00010000
Current operating mode_2-Bits 0-7: 00000000
Current operating mode_2-Bits 0-7: 00001110
5189 - Particulate Trap Bank 1
P2002 00 [047] - Efficiency Below Threshold
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 398622 km
Date: 2022.04.20
Time: 04:48:26
Engine RPM: 979.50 /min
Normed load value: 30.2 %
Vehicle speed: 0 km/h
Coolant temperature: 27 °C
Intake air temperature: 21 °C
Ambient air pressure: 1010 mbar
Voltage terminal 30: 13.520 V
Unlearning counter according OBD: 40
Ambient temperature: 16.5 °C
DPF: offset for differential pressure: 4 hPa
Particle filter: soot mass measured: 149.30 g
Particle filter: soot mass calculated: 60.35 g
Particle filter: kilometers since last regeneration: 32676 m
Particle filter field regeneration: cancel conditions-Bits 0-7: 00000000
Particle filter field regeneration: cancel conditions-Bits 0-7: 00000000
Readiness: 1 1 0 0 1
-------------------------------------------------------------------------------
Address 02: Auto Trans (J217) Labels:* None
Part No SW: 0C8 927 750 G HW: 0C8 927 750 G
Component: AL1000 AISIN 001 1857
Serial number: CVN: 15844593
Coding: 001368
Shop #: WSC 42005 002 1048576
ASAM Dataset: EV_TCMAL991031 001001
ROD: EV_TCMAL991031_001_VW52.rod
VCID: 3039EC78FAA8769B7F2-8064
No fault code found.
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels:* None
Part No SW: 7P0 907 379 J HW: 7P0 907 379 A
Component: MK25A H36 0433
Revision: -------- Serial number: 427310010EC010
Coding: 5B7613C349242558DAFAC89392D6A4407300
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_MK25AXT 008001
ROD: EV_ESPMK25A00800.rod
VCID: 44D1B0A85E10FA3BABA-8010
No fault code found.
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393) Labels: None
Part No SW: 4H0 907 064 BK HW: 4H0 907 064 BK
Component: BCM2 2.0 H31 0333
Revision: 00002001
Coding: 09860000000000000000
Shop #: WSC 31414 790 00001
VCID: 73B323744BBE0D83C20-8026
Subsystem 1 - Part No SW: 7P6 959 754 M HW: 7P6 959 754 M
Component: FBSTOUAREGIDG H04 0051
Serial number: 0511000056915016
Subsystem 2 - Part No SW: 4H0 905 852 B HW: 4H0 905 852 B
Component: J764 ELV MLB H38 0044
Serial number: 2311000221683004
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:* None
Part No SW: 7P6 907 040 BK HW: 7P6 907 040 BK
Component: Klima 2 Zonen H20 1305
Coding: B606200A80
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_AirCondiFront 004001
ROD: EV_AirCondiFront_VW52.rod
VCID: 7EA50240707C50EBBDE-802A
1 Fault Found:
15360256 - Component Protection
U1101 00 [008] - Active
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 1
Fault Frequency: 3
Reset counter: 124
Mileage: 397245 km
Date: 2022.03.30
Time: 00:42:28
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: None
Part No SW: 4H0 907 063 BD HW: 4H0 907 063 D
Component: BCM1 2.0 H12 0100
Revision: 15012002 Serial number: 00000001111655
Coding: 26001012973C5D010020180300005D0C431C660882010261000000020000
Shop #: WSC 31414 790 00001
VCID: 6B833B14138ED5430A0-803E
Subsystem 1 - Part No SW: 7P0 955 119 HW: 7P0 955 119
Component: WWS 111021 31 0020
Serial number: 90243400111028231403
Coding: 004DBD
Subsystem 2 - Part No SW: 7P0 955 559 D HW: 7P0 955 559 D
Component: RLFS H09 0011
Serial number: 10264691
Coding: 025223
Subsystem 3 - Part No SW: 7P6 941 431 E HW: 7P6 941 431 E
Component: E1 - LDS H04 0031
Serial number: 00000000001110110267
Subsystem 4 - Part No SW: 4H0 907 410 A HW: 4H0 907 410 A
Component: USHL4.2 H30 0020
Serial number: 0000001805569R0S3807
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:* None
Part No SW: 7P0 959 655 C HW: 7P0 959 655 C
Component: VW10Airbag025 H05 0025
Revision: -------- Serial number: 003L0000JX0X
Coding: 000000000000000000000000000000003235
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_AirbaVW10BPAVW526 001001
ROD: EV_AirbaVW10BPAVW526_001.rod
VCID: 41DFB9BC4102EF1380C-8014
Seat occupied recognition:
Subsystem 1 - Part No SW: 7P6 959 339 HW: 7P6 959 339
Component: BF-Gewichtss. 003 0005
Serial number: 5850000R1172706H59
Crash sensor for side airbag: driver side:
Serial number: 3575LRB40690T3R6A0UV
Front Passenger's Side Airbag Crash Sensor:
Serial number: 3585LRB40690T3R69HP0
Rear Side Airbag Crash Sensor (on driver's side):
Serial number: 3515RRB40550OPMK49H%
Passenger side rear thorax airbag crash sensor:
Serial number: 3525RRB405B0OPMKH9NP
Crash sensor for front airbag: driver side:
Serial number: 3555NRB40590PIJQEGOO
Crash sensor for front airbag: front passenger side:
Serial number: 3565NRB40550PIJQKHEI
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels: None
Part No SW: 4H0 953 568 F HW: 7P6 953 507 L
Component: Lenks.Modul H03 0005
Revision: -------- Serial number: 90815KJP0005S
Coding: 000015
Shop #: WSC 31414 790 00001
VCID: 3635DA60184C58AB25E-8062
Subsystem 1 - Part No SW: 7P6 959 542 HW: 7P6 959 542
Component: E221__MFL-TAS H03 0027
Serial number: 0124203
1 Fault Found:
00886 - Turn Signal Switch (E2)
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 2
Fault Frequency: 7
Reset counter: 123
Mileage: 397601 km
Time Indication: 0
Date: 2022.04.06
Time: 00:00:45
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:* None-SRI1
Part No SW: 7P6 920 980 N HW: 7P6 920 980 N
Component: Kombi H13 0239
Revision: 11240062 Serial number: 658221011593041
Coding: 8B7733022B00CF05020004
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_KombiUDSRBVW526 001013
ROD: EV_KombiUDSRBVW526.rod
VCID: 47CBA7A46F26D1234E8-8012
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:* None
Part No SW: 7P6 907 530 C HW: 7P6 907 530 A
Component: GW-CAN-L-MOST H08 5202
Revision: -------- Serial number: 00000000291319
Coding: 0001037500
Shop #: WSC 31414 790 00001
GVL: FB0F40451D7F000000
ASAM Dataset: EV_GatewVW526UDS 001006
ROD: EV_GatewUDS_VW52.rod
VCID: 3829D45812D8AEDB372-806C
Battery Monitoring Control Module:
Subsystem 1 - Part No SW: 7P0 915 181 A HW: 7P0 915 181
Component: Batt_Sensor H07 0140
Serial number: 00000000005650843827
No fault code found.
-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr (J136) Labels: None
Part No SW: 4H0 959 760 D HW: 4H0 959 760 D
Component: MEM-FS H08 0153
Revision: AA000000 Serial number: 00000016937431
Coding: 0058130000004001000001010101202020202121202020
Shop #: WSC 31414 790 00001
VCID: 3431E0680E304ABB1BA-8060
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels: None
Part No SW: 4H0 959 793 N HW: 4H0 959 793 F
Component: TSG FA H07 0166
Revision: -------- Serial number: 0000121063960
Coding: 011D07205E00453005080000
Shop #: WSC 31414 790 00001
VCID: 44D1B0A85E90FA3BABA-8010
1 Fault Found:
00920 - Heated Outside Mirrors; Driver Side (Z4) / Passenger Side (Z5)
012 - Electrical Fault in Circuit
Freeze Frame:
Fault Status: 01101100
Fault Priority: 3
Fault Frequency: 3
Reset counter: 74
Mileage: 397798 km
Time Indication: 0
Date: 2022.04.08
Time: 00:19:07
-------------------------------------------------------------------------------
Address 46: Central Conv. (J393) Labels: None
Part No SW: 4H0 907 064 BK HW: 4H0 907 064 BK
Component: BCM2 2.0 H31 0333
Revision: 00002001 Serial number: 0161545821
Coding: 0186123A28B9509480A00620210000000000000000000000000000000000
Shop #: WSC 31414 790 00001
VCID: 73B323744BBE0D83C20-8026
Subsystem 1 - Part No SW: 7P6 959 719 HW: 7P6 959 719
Component: GTO BT H19 0059
Serial number: 284119591
Subsystem 2 - Part No: 1K0 951 605 C
Component: LIN BACKUP HO H05 1501
Subsystem 3 - Part No SW: 7P0 959 591 B HW: 7P0 959 591 B
Component: J245 PS30.055 H01 0008
Serial number: WOO13391685
Coding: 191100
Subsystem 4 - Part No SW: 7P0 959 591 C HW: 7P0 959 591 C
Component: J394 PS30.055 H01 0008
Serial number: WOO1336156%
Coding: 191100
2 Faults Found:
00985 - Right Tail Light (M2)
012 - Electrical Fault in Circuit - Intermittent
Freeze Frame:
Fault Status: 00101100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 100
Mileage: 396654 km
Time Indication: 0
Date: 2022.03.02
Time: 06:07:30
02202 - Trunk / Luggage Compartment Closing Assist; Position - Locked (F332)
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 99
Mileage: 397216 km
Time Indication: 0
Date: 2022.03.29
Time: 22:05:31
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels: None
Part No SW: 4H0 959 792 F HW: 4H0 959 792 F
Component: TSG BF H07 0166
Revision: -------- Serial number: 0000121426575
Coding: 011D07205E00453005080000
Shop #: WSC 31414 790 00001
VCID: 3B23CB54236E85C3DA0-806E
No fault code found.
-------------------------------------------------------------------------------
Address 53: Parking Brake (J540-) Labels:* None
Part No SW: 7P0 907 801 F HW: 7P0 907 801 F
Component: EPB H51 1201
Revision: 00000000 Serial number: A11A070021C
Coding: 00000000
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_ParkbA7 000006
ROD: EV_ParkbA7.rod
VCID: 3635DA6018CC58AB25E-8062
Slave 1:
Slave 3:
4 Faults Found:
0025 - No Calibration
B2010 F0 [008] - Deviation from Expected Range
[Steuergerät EPB - Kalibrierung fehlgeschlagen]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Frequency: 1
Reset counter: 45
Mileage: 396654 km
Date: 2022.03.12
Time: 04:19:48
Voltage: 14.2 V
0024 - No Basic Setting
B2010 00 [009] - -
[Steuergerät EPB - System nicht kalibriert]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Frequency: 1
Voltage: 14.0 V
12652550 - Control Module Incorrectly Coded
U1014 00 [009] - -
[Steuergerät EPB - Codierungsfehler]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Frequency: 1
Voltage: 14.0 V
0018 - Switch for Electric Parking Brake
C100C 01 [009] - Electrical Failure
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Frequency: 1
Reset counter: 45
Mileage: 396654 km
Date: 2022.03.23
Time: 22:48:03
Voltage: 12.2 V
-------------------------------------------------------------------------------
Address 55: Headlight Range (J745) Labels: None
Part No SW: 7P6 907 357 HW: 7L6 907 357 C
Component: AFS-ECU H04 0110
Revision: -------- Serial number: --------------
Coding: 010A00010F000400
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_HeadlRegulVWAFS 005006
ROD: EV_HeadlRegulVWAFS_VW52.rod
VCID: 7CA10848666042FB93A-8028
Left_headlamp_power_output_stage:
Subsystem 1 - Part No SW: 8U0 941 329 HW: 8U0 941 329
Component: LeiMo links H01 0002
Coding: 130000
Right_headlamp_power_output_stage:
Subsystem 2 - Part No SW: 8U0 941 329 HW: 8U0 941 329
Component: LeiMo rechts H01 0006
Coding: 130000
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (R) Labels: None
Part No SW: 4G0 035 082 G HW: 4G0 035 082
Component: Radio U SIRIU H53 0133
Revision: AB001007 Serial number: 156J20B7565751
Coding: 020007020100000001
Shop #: WSC 31414 790 00001
VCID: 24111028BED0DA3B8BA-8070
No fault code found.
-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794) Labels: None
Part No SW: 7P6 035 664 D HW: 7P6 035 664
Component: H-BN-NA H44 0706
Revision: -------- Serial number: 445J 0B7521662
Coding: 010200050040E1EE41022B0C00000003F00001010000000000
Shop #: WSC 31414 790 00001
VCID: 392FD15C2952B7D3C8C-806C
Subsystem 1 - Part No: 8R0 060 884 AC
Component: NAR 2011 0503
Subsystem 2 - Part No SW: 7P6 919 603 C HW: 7P6 919 603 C
Component: DU8 SV Touch H26 0045
Serial number: VWZ8Z9L79004S3
Subsystem 3 - Part No SW: 7P6 919 603 C HW: 7P6 919 603 C
Component: DU8 SV Touch H26 0045
Serial number: VWZ8Z9L79004S3
Subsystem 4 - Part No: 8R0 060 961
Component: CD-Database 1886
2 Faults Found:
03276 - Please Check Software Version Management
000 - -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 6
Fault Frequency: 1
Reset counter: 7
Mileage: 394316 km
Time Indication: 0
Date: 2022.01.25
Time: 19:42:42
Freeze Frame:
Text: DUA001,Front,M,0,0,6
03175 - Invalid Data Set
000 - -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 7
Mileage: 394316 km
Time Indication: 0
Date: 2022.01.25
Time: 19:42:40
Freeze Frame:
Voltage: 12.60 V
-------------------------------------------------------------------------------
Address 62: Door, Rear Left (J388) Labels: None
Part No SW: 4H0 959 795 B HW: 4H0 959 795 B
Component: TSG HL H09 0167
Revision: -------- Serial number: 0000121490349
Coding: 011C07200000253005080000
Shop #: WSC 31414 790 00001
VCID: 3A2DCE502C54BCCBC16-806E
No fault code found.
-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502) Labels: None
Part No SW: 7P6 907 273 F HW: 7P6 907 273 F
Component: RDKBERU25 H09 0008
Serial number: 10000000050575
ASAM Dataset: EV_RDKBERU25 003006
ROD: EV_RDKBERU25_VW52.rod
VCID: 3FDBBF4437F699E3F68-806A
4 Faults Found:
8389634 - Radio Frequency Interference
C105C 00 [008] - -
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 8
Reset counter: 117
Mileage: 395459 km
Date: 2022.02.08
Time: 23:59:08
8389635 - Radio Frequency Interference
C105C 00 [008] - -
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 4
Reset counter: 128
Mileage: 397416 km
Date: 2022.04.01
Time: 07:04:36
8397314 - Front Right TPMS Sensor
C1051 31 [009] - No Signal
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 1
Fault Frequency: 1
Reset counter: 77
Mileage: 397944 km
Date: 2022.04.09
Time: 10:19:04
Vehicle speed: 10 km/h
Outside temperature: 20 °C
Reception level antenna 1: 720 mV
Offset level antenna 1: 680 mV
8397570 - Rear Left TPMS Sensor
C1052 31 [009] - No Signal
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 1
Fault Frequency: 1
Reset counter: 70
Mileage: 397748 km
Date: 2022.04.07
Time: 06:58:16
Vehicle speed: 102 km/h
Outside temperature: 35.5 °C
Reception level antenna 1: 700 mV
Offset level antenna 1: 660 mV
-------------------------------------------------------------------------------
Address 69: Trailer (J345) Labels: None
Part No SW: 7P0 907 383 F HW: 7P0 907 383 B
Component: Anhaenger H09 0110
Revision: 5A001001 Serial number: 00000160938100
Coding: 020D000000000000
Shop #: WSC 31414 790 00001
VCID: 3B23CB54236E85C3DA0-806E
No fault code found.
-------------------------------------------------------------------------------
Address 6C: Back-up Cam. Labels: None
Part No SW: 7P6 907 441 A HW: 4H0 907 441
Component: SG Rueckfahrkamera 0020
Revision: 00H04000 Serial number: 525 PA8J192588
Coding: 0110001
Shop #: WSC 31414 790 00001
VCID: 372BD7641346A1A33E8-8062
No fault code found.
-------------------------------------------------------------------------------
Address 6D: Trunk Elect. (----) Labels:* None
Part No SW: 7P6 959 107 A HW: 7P6 959 107
Component: HDSG-Modul H10 0620
Revision: 22010001 Serial number: 294100187
Coding: 0533314003
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_HeckkTouar 202137
ROD: EV_HeckkTouar.rod
VCID: 3D27C54C3DFA8BF3E44-8068
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right (J389) Labels: None
Part No SW: 4H0 959 795 B HW: 4H0 959 795 B
Component: TSG HR H09 0167
Revision: -------- Serial number: 0000121399453
Coding: 011C07200000253005080000
Shop #: WSC 31414 790 00001
VCID: 3A2DCE502C54BCCBC16-806E
No fault code found.
End----------(Elapsed Time: 02:12, VBatt start/end: 13.5V/14.1V)-----------
Last edited by a moderator:
Ash can't really be measured; it's calculated. I would guess that's some kind of correction factor that affects the calculation.
Please have a look at:
IDE00433 -- Particle filter: oil ash volume
I'm not gonna go back and re-read the whole thread. Is this the original DPF on the vehicle? Because if it is, at almost 250,000 miles, it has exceeded its design life by a factor of two. A professional cleaning might indeed be worth trying. While it's out, make sure that that the plumbing between the exhaust and the differential pressure sensor is up to snuff, in other words, check for leaks and obstructions. With a new (or freshly cleaned) DPF, I would also consider installing a new differential pressure sensor.
-Uwe-
Here's the udpate:
Uwe - in answer to your question, this was a replacement DPF that i had bought used from junk yard. i don't really recall the mileage of the car that it came out of but i believe it was in the 60-80K plus i put about 40K miles since i put it on, so that would put it at 100-120K.
Removed the DPF again and took it for some professional baking at Clean Diesel Specialists in Santa Ana, CA. For those that are local, they charged me $250 and told me that the DPF lost about 60gr of weight after the cleaning. I visually checked the hoses from the DPF to the Differential Pressure Sensor and found no cracks. I also replaced the DEF injector i had bought on Ebay with a used OEM one. I suspect that the one i had bought was a counterfeit OEM part after looking and comparing the two...
I went the extra mile and replaced the Differential Pressure Sensor as well with an OEM part from the dealership (although post-mortem i think my part was working fine). Installed the DPF after the cleaning and got same errors and same Adv. Measuring values.
Went to Basis Settings and did: Relearn values of particle filter.
Errors went away but i have not driven it anywhere yet (just down the block).
I now get the following:
Ignition on - engine not running - Difference Pressure: 0-1 hPa
Engine running: Pressure 6-7 hPa
Particulate filter bank 1 - differential pressure 0.60kPA
Soot mass caclualated: 0.13 gr
So now fingers crossed until i take it for some real driving...
Below is the full autoscan.
Code:
Monday,25,April,2022,18:24:51:45649
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 22.3.0.1 (x64) HEX-V2 CB: 0.4615.4
Data version: Unknown DS336.1
www.Ross-Tech.com
VIN: WVGEK9BP1CD005604 License Plate:
Chassis Type: BP-VW52 (7P6)
Scan: 01 02 03 05 08 09 15 16 17 19 36 42 46 52 53 55 56 5F 62 65
69 6C 6D 72
VIN: WVGEK9BP1CD005604 Mileage: 398622km-247692miles
01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: Malfunction 0010
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: Malfunction 0010
46-Central Conv. -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: Malfunction 0010
55-Headlight Range -- Status: OK 0000
56-Radio -- Status: OK 0000
5F-Information Electr. -- Status: Malfunction 0010
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: Malfunction 0010
69-Trailer -- Status: OK 0000
6C-Back-up Cam. -- Status: OK 0000
6D-Trunk Elect. -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CATA) Labels: None
Part No SW: 7P0 907 401 J HW: 7P0 907 401 E
Component: 3.0TDI EDC17 H17 0005
Revision: 56H17--- CVN: 0FF473B738D3FF8238D3FF82
Coding: 292A4012233600050000
Shop #: WSC 02330 444 92460
ASAM Dataset: EV_ECM30TDI0117P0907401J 001005
ROD: EV_ECM30TDI0117P0907401J_001.rod
VCID: 3635DA6018CC58AB25E-8062
VINID: 9E65D56C94A00535000051801004E1B29D
No fault code found.
Readiness: 0 0 0 0 1
-------------------------------------------------------------------------------
Address 02: Auto Trans (J217) Labels:* None
Part No SW: 0C8 927 750 G HW: 0C8 927 750 G
Component: AL1000 AISIN 001 1857
Serial number: CVN: 15844593
Coding: 001368
Shop #: WSC 42005 002 1048576
ASAM Dataset: EV_TCMAL991031 001001
ROD: EV_TCMAL991031_001_VW52.rod
VCID: 3039EC78FAA8769B7F2-8064
No fault code found.
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels:* None
Part No SW: 7P0 907 379 J HW: 7P0 907 379 A
Component: MK25A H36 0433
Revision: -------- Serial number: 427310010EC010
Coding: 5B7613C349242558DAFAC89392D6A4407300
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_MK25AXT 008001
ROD: EV_ESPMK25A00800.rod
VCID: 44D1B0A85E10FA3BABA-8010
No fault code found.
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393) Labels: None
Part No SW: 4H0 907 064 BK HW: 4H0 907 064 BK
Component: BCM2 2.0 H31 0333
Revision: 00002001
Coding: 09860000000000000000
Shop #: WSC 31414 790 00001
VCID: 73B323744BBE0D83C20-8026
Subsystem 1 - Part No SW: 7P6 959 754 M HW: 7P6 959 754 M
Component: FBSTOUAREGIDG H04 0051
Serial number: 0511000056915016
Subsystem 2 - Part No SW: 4H0 905 852 B HW: 4H0 905 852 B
Component: J764 ELV MLB H38 0044
Serial number: 2311000221683004
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:* None
Part No SW: 7P6 907 040 BK HW: 7P6 907 040 BK
Component: Klima 2 Zonen H20 1305
Coding: B606200A80
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_AirCondiFront 004001
ROD: EV_AirCondiFront_VW52.rod
VCID: 7EA50240707C50EBBDE-802A
1 Fault Found:
15360256 - Component Protection
U1101 00 [008] - Active
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 1
Fault Frequency: 3
Reset counter: 124
Mileage: 397245 km
Date: 2022.03.30
Time: 00:42:28
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: None
Part No SW: 4H0 907 063 BD HW: 4H0 907 063 D
Component: BCM1 2.0 H12 0100
Revision: 15012002 Serial number: 00000001111655
Coding: 26001012973C5D010020180300005D0C431C660882010261000000020000
Shop #: WSC 31414 790 00001
VCID: 6B833B14138ED5430A0-803E
Subsystem 1 - Part No SW: 7P0 955 119 HW: 7P0 955 119
Component: WWS 111021 31 0020
Serial number: 90243400111028231403
Coding: 004DBD
Subsystem 2 - Part No SW: 7P0 955 559 D HW: 7P0 955 559 D
Component: RLFS H09 0011
Serial number: 10264691
Coding: 025223
Subsystem 3 - Part No SW: 7P6 941 431 E HW: 7P6 941 431 E
Component: E1 - LDS H04 0031
Serial number: 00000000001110110267
Subsystem 4 - Part No SW: 4H0 907 410 A HW: 4H0 907 410 A
Component: USHL4.2 H30 0020
Serial number: 0000001805569R0S3807
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:* None
Part No SW: 7P0 959 655 C HW: 7P0 959 655 C
Component: VW10Airbag025 H05 0025
Revision: -------- Serial number: 003L0000JX0X
Coding: 000000000000000000000000000000003235
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_AirbaVW10BPAVW526 001001
ROD: EV_AirbaVW10BPAVW526_001.rod
VCID: 41DFB9BC4102EF1380C-8014
Seat occupied recognition:
Subsystem 1 - Part No SW: 7P6 959 339 HW: 7P6 959 339
Component: BF-Gewichtss. 003 0005
Serial number: 5850000R1172706H59
Crash sensor for side airbag: driver side:
Serial number: 3575LRB40690T3R6A0UV
Front Passenger's Side Airbag Crash Sensor:
Serial number: 3585LRB40690T3R69HP0
Rear Side Airbag Crash Sensor (on driver's side):
Serial number: 3515RRB40550OPMK49H%
Passenger side rear thorax airbag crash sensor:
Serial number: 3525RRB405B0OPMKH9NP
Crash sensor for front airbag: driver side:
Serial number: 3555NRB40590PIJQEGOO
Crash sensor for front airbag: front passenger side:
Serial number: 3565NRB40550PIJQKHEI
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels: None
Part No SW: 4H0 953 568 F HW: 7P6 953 507 L
Component: Lenks.Modul H03 0005
Revision: -------- Serial number: 90815KJP0005S
Coding: 000015
Shop #: WSC 31414 790 00001
VCID: 3635DA60184C58AB25E-8062
Subsystem 1 - Part No SW: 7P6 959 542 HW: 7P6 959 542
Component: E221__MFL-TAS H03 0027
Serial number: 0124203
1 Fault Found:
00886 - Turn Signal Switch (E2)
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 2
Fault Frequency: 7
Reset counter: 123
Mileage: 397601 km
Time Indication: 0
Date: 2022.04.06
Time: 00:00:45
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:* None-SRI1
Part No SW: 7P6 920 980 N HW: 7P6 920 980 N
Component: Kombi H13 0239
Revision: 11240062 Serial number: 658221011593041
Coding: 8B7733022B00CF05020004
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_KombiUDSRBVW526 001013
ROD: EV_KombiUDSRBVW526.rod
VCID: 47CBA7A46F26D1234E8-8012
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:* None
Part No SW: 7P6 907 530 C HW: 7P6 907 530 A
Component: GW-CAN-L-MOST H08 5202
Revision: -------- Serial number: 00000000291319
Coding: 0001037500
Shop #: WSC 31414 790 00001
GVL: FB0F40451D7F000000
ASAM Dataset: EV_GatewVW526UDS 001006
ROD: EV_GatewUDS_VW52.rod
VCID: 3829D45812D8AEDB372-806C
Battery Monitoring Control Module:
Subsystem 1 - Part No SW: 7P0 915 181 A HW: 7P0 915 181
Component: Batt_Sensor H07 0140
Serial number: 00000000005650843827
No fault code found.
-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr (J136) Labels: None
Part No SW: 4H0 959 760 D HW: 4H0 959 760 D
Component: MEM-FS H08 0153
Revision: AA000000 Serial number: 00000016937431
Coding: 0058130000004001000001010101202020202121202020
Shop #: WSC 31414 790 00001
VCID: 3431E0680E304ABB1BA-8060
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels: None
Part No SW: 4H0 959 793 N HW: 4H0 959 793 F
Component: TSG FA H07 0166
Revision: -------- Serial number: 0000121063960
Coding: 011D07205E00453005080000
Shop #: WSC 31414 790 00001
VCID: 44D1B0A85E90FA3BABA-8010
1 Fault Found:
00920 - Heated Outside Mirrors; Driver Side (Z4) / Passenger Side (Z5)
012 - Electrical Fault in Circuit
Freeze Frame:
Fault Status: 01101100
Fault Priority: 3
Fault Frequency: 3
Reset counter: 74
Mileage: 397798 km
Time Indication: 0
Date: 2022.04.08
Time: 00:19:07
-------------------------------------------------------------------------------
Address 46: Central Conv. (J393) Labels: None
Part No SW: 4H0 907 064 BK HW: 4H0 907 064 BK
Component: BCM2 2.0 H31 0333
Revision: 00002001 Serial number: 0161545821
Coding: 0186123A28B9509480A00620210000000000000000000000000000000000
Shop #: WSC 31414 790 00001
VCID: 73B323744BBE0D83C20-8026
Subsystem 1 - Part No SW: 7P6 959 719 HW: 7P6 959 719
Component: GTO BT H19 0059
Serial number: 284119591
Subsystem 2 - Part No: 1K0 951 605 C
Component: LIN BACKUP HO H05 1501
Subsystem 3 - Part No SW: 7P0 959 591 B HW: 7P0 959 591 B
Component: J245 PS30.055 H01 0008
Serial number: WOO13391685
Coding: 191100
Subsystem 4 - Part No SW: 7P0 959 591 C HW: 7P0 959 591 C
Component: J394 PS30.055 H01 0008
Serial number: WOO1336156%
Coding: 191100
2 Faults Found:
00985 - Right Tail Light (M2)
012 - Electrical Fault in Circuit - Intermittent
Freeze Frame:
Fault Status: 00101100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 100
Mileage: 396654 km
Time Indication: 0
Date: 2022.03.02
Time: 06:07:30
02202 - Trunk / Luggage Compartment Closing Assist; Position - Locked (F332)
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 99
Mileage: 397216 km
Time Indication: 0
Date: 2022.03.29
Time: 22:05:31
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels: None
Part No SW: 4H0 959 792 F HW: 4H0 959 792 F
Component: TSG BF H07 0166
Revision: -------- Serial number: 0000121426575
Coding: 011D07205E00453005080000
Shop #: WSC 31414 790 00001
VCID: 3B23CB54236E85C3DA0-806E
No fault code found.
-------------------------------------------------------------------------------
Address 53: Parking Brake (J540-) Labels:* None
Part No SW: 7P0 907 801 F HW: 7P0 907 801 F
Component: EPB H51 1201
Revision: 00000000 Serial number: A11A070021C
Coding: 00000000
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_ParkbA7 000006
ROD: EV_ParkbA7.rod
VCID: 3635DA6018CC58AB25E-8062
Slave 1:
Slave 3:
4 Faults Found:
0025 - No Calibration
B2010 F0 [008] - Deviation from Expected Range
[Steuergerät EPB - Kalibrierung fehlgeschlagen]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Frequency: 1
Reset counter: 45
Mileage: 396654 km
Date: 2022.03.12
Time: 04:19:48
Voltage: 14.2 V
0024 - No Basic Setting
B2010 00 [009] - -
[Steuergerät EPB - System nicht kalibriert]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Frequency: 1
Voltage: 14.0 V
12652550 - Control Module Incorrectly Coded
U1014 00 [009] - -
[Steuergerät EPB - Codierungsfehler]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Frequency: 1
Voltage: 14.0 V
0018 - Switch for Electric Parking Brake
C100C 01 [009] - Electrical Failure
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Frequency: 1
Reset counter: 45
Mileage: 396654 km
Date: 2022.03.23
Time: 22:48:03
Voltage: 12.2 V
-------------------------------------------------------------------------------
Address 55: Headlight Range (J745) Labels: None
Part No SW: 7P6 907 357 HW: 7L6 907 357 C
Component: AFS-ECU H04 0110
Revision: -------- Serial number: --------------
Coding: 010A00010F000400
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_HeadlRegulVWAFS 005006
ROD: EV_HeadlRegulVWAFS_VW52.rod
VCID: 7CA10848666042FB93A-8028
Left_headlamp_power_output_stage:
Subsystem 1 - Part No SW: 8U0 941 329 HW: 8U0 941 329
Component: LeiMo links H01 0002
Coding: 130000
Right_headlamp_power_output_stage:
Subsystem 2 - Part No SW: 8U0 941 329 HW: 8U0 941 329
Component: LeiMo rechts H01 0006
Coding: 130000
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (R) Labels: None
Part No SW: 4G0 035 082 G HW: 4G0 035 082
Component: Radio U SIRIU H53 0133
Revision: AB001007 Serial number: 156J20B7565751
Coding: 020007020100000001
Shop #: WSC 31414 790 00001
VCID: 24111028BED0DA3B8BA-8070
No fault code found.
-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794) Labels: None
Part No SW: 7P6 035 664 D HW: 7P6 035 664
Component: H-BN-NA H44 0706
Revision: -------- Serial number: 445J 0B7521662
Coding: 010200050040E1EE41022B0C00000003F00001010000000000
Shop #: WSC 31414 790 00001
VCID: 392FD15C2952B7D3C8C-806C
Subsystem 1 - Part No: 8R0 060 884 AC
Component: NAR 2011 0503
Subsystem 2 - Part No SW: 7P6 919 603 C HW: 7P6 919 603 C
Component: DU8 SV Touch H26 0045
Serial number: VWZ8Z9L79004S3
Subsystem 3 - Part No SW: 7P6 919 603 C HW: 7P6 919 603 C
Component: DU8 SV Touch H26 0045
Serial number: VWZ8Z9L79004S3
Subsystem 4 - Part No: 8R0 060 961
Component: CD-Database 1886
2 Faults Found:
03276 - Please Check Software Version Management
000 - -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 6
Fault Frequency: 1
Reset counter: 7
Mileage: 394316 km
Time Indication: 0
Date: 2022.01.25
Time: 19:42:42
Freeze Frame:
Text: DUA001,Front,M,0,0,6
03175 - Invalid Data Set
000 - -
Freeze Frame:
Fault Status: 01100000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 7
Mileage: 394316 km
Time Indication: 0
Date: 2022.01.25
Time: 19:42:40
Freeze Frame:
Voltage: 12.60 V
-------------------------------------------------------------------------------
Address 62: Door, Rear Left (J388) Labels: None
Part No SW: 4H0 959 795 B HW: 4H0 959 795 B
Component: TSG HL H09 0167
Revision: -------- Serial number: 0000121490349
Coding: 011C07200000253005080000
Shop #: WSC 31414 790 00001
VCID: 3A2DCE502C54BCCBC16-806E
No fault code found.
-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502) Labels: None
Part No SW: 7P6 907 273 F HW: 7P6 907 273 F
Component: RDKBERU25 H09 0008
Serial number: 10000000050575
ASAM Dataset: EV_RDKBERU25 003006
ROD: EV_RDKBERU25_VW52.rod
VCID: 3FDBBF4437F699E3F68-806A
4 Faults Found:
8389634 - Radio Frequency Interference
C105C 00 [008] - -
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 8
Reset counter: 117
Mileage: 395459 km
Date: 2022.02.08
Time: 23:59:08
8389635 - Radio Frequency Interference
C105C 00 [008] - -
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 4
Reset counter: 128
Mileage: 397416 km
Date: 2022.04.01
Time: 07:04:36
8397314 - Front Right TPMS Sensor
C1051 31 [009] - No Signal
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 1
Fault Frequency: 1
Reset counter: 77
Mileage: 397944 km
Date: 2022.04.09
Time: 10:19:04
Vehicle speed: 10 km/h
Outside temperature: 20 °C
Reception level antenna 1: 720 mV
Offset level antenna 1: 680 mV
8397570 - Rear Left TPMS Sensor
C1052 31 [009] - No Signal
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 1
Fault Frequency: 1
Reset counter: 70
Mileage: 397748 km
Date: 2022.04.07
Time: 06:58:16
Vehicle speed: 102 km/h
Outside temperature: 35.5 °C
Reception level antenna 1: 700 mV
Offset level antenna 1: 660 mV
-------------------------------------------------------------------------------
Address 69: Trailer (J345) Labels: None
Part No SW: 7P0 907 383 F HW: 7P0 907 383 B
Component: Anhaenger H09 0110
Revision: 5A001001 Serial number: 00000160938100
Coding: 020D000000000000
Shop #: WSC 31414 790 00001
VCID: 3B23CB54236E85C3DA0-806E
No fault code found.
-------------------------------------------------------------------------------
Address 6C: Back-up Cam. Labels: None
Part No SW: 7P6 907 441 A HW: 4H0 907 441
Component: SG Rueckfahrkamera 0020
Revision: 00H04000 Serial number: 525 PA8J192588
Coding: 0110001
Shop #: WSC 31414 790 00001
VCID: 372BD7641346A1A33E8-8062
No fault code found.
-------------------------------------------------------------------------------
Address 6D: Trunk Elect. (----) Labels:* None
Part No SW: 7P6 959 107 A HW: 7P6 959 107
Component: HDSG-Modul H10 0620
Revision: 22010001 Serial number: 294100187
Coding: 0533314003
Shop #: WSC 31414 790 00001
ASAM Dataset: EV_HeckkTouar 202137
ROD: EV_HeckkTouar.rod
VCID: 3D27C54C3DFA8BF3E44-8068
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right (J389) Labels: None
Part No SW: 4H0 959 795 B HW: 4H0 959 795 B
Component: TSG HR H09 0167
Revision: -------- Serial number: 0000121399453
Coding: 011C07200000253005080000
Shop #: WSC 31414 790 00001
VCID: 3A2DCE502C54BCCBC16-806E
No fault code found.
End----------(Elapsed Time: 02:15, VBatt start/end: 13.9V/14.1V)-----------Did you also re-learn the differential pressure sensor?
Those seem pretty reasonable.
-Uwe-
So, the issue with the DPF has been fully addressed and i was able to do a full cycle service regeneration just to check it out. Car drives normally. Drove it for 300 miles but now has another issue. I will post a separate thread since this issue has been solved.