N00b needs help troubleshooting some electrical system codes (lights and mirrors)

   #1  
9

93YuW'&=

Verified VCDS User
Verified
Joined
Jun 13, 2018
Messages
7
Reaction score
4
Location
USA
VCDS Serial number
C?ID=336153
Good morning all,
I recently purchased a used 2010 Jetta that had the 'bulb out' indicator on, and I can't figure out what light it is! I think the next step is diagnosing the wiring from the front-light and working back but I'm not sure which points to check (e.g. what should I check after I verify the bulb is on?)
I've checked:
Running lights
Parking lights (with the ignition turned off)
head lights
high beams
license plate lights
map lights
rear interior light
both sun visor lights


In addition, I've replaced both mirrors with aftermarket ones (different make/model each side) that were advertised as heated and look identical to the OEM ones including the wires on the mirror, but they don't warm up. The weird thing about them is that the VCDS log says that the one on the right has a motor issue, but both use the motor to adjust position just fine in all 4 directions.
I've posted my log in the post below, and would really appreciate any help troubleshooting this.

Code: 
Saturday,09,June,2018,18:06:54:43468
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 8 x64
VCDS Version: 18.2.1.2 (x64) HEX-V2 CB: 0.4411.4
Data version: 20180518 DS287.1
www.Ross-Tech.com


VIN: [redacted] License Plate: 
Mileage: 145980km-90707mi Repair Order: 



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: AJ-VW36 (1K0)
Scan: 01 02 03 08 09 15 16 17 19 25 42 44 46 52 56 62 65 72 77

VIN: [redacted] Mileage: 145980km-90707miles

01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: Malfunction 0010
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (CBU) Labels: 07K-906-055-CBT.clb
Part No SW: 07K 906 055 AG HW: 07K 906 055 M
Component: 2,5l R5/4V G 5784 
Revision: G6H04--- Serial number: 
Coding: 0000075
Shop #: WSC 00066 000 00000
VCID: 73B3239BB7BFB45F7C5-8026

No fault code found.
Readiness: 0000 0000

-------------------------------------------------------------------------------
Address 02: Auto Trans Labels: 09G-927-750.clb
Part No SW: 09G 927 750 HG HW: 09G 927 750 HG
Component: AQ 250 6F 1631 
Revision: 00H90000 Serial number: 
Coding: 0000840
Shop #: WSC 00066 000 00000
VCID: 7DA705A381FBF22F1A1-8028

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels:. 1K0-907-379-60EC1F.clb
Part No SW: 1K0 907 379 AH HW: 1K0 907 379 AH
Component: ESP MK60EC1 H30 0107 
Revision: 00H30001 
Coding: 114B400C49260001881102EA92220041300000
Shop #: WSC 00066 000 00000
VCID: 78A914B7A2D9D707497-802C

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301) Labels:| 3C8-907-336.clb
Part No SW: 3C8 907 336 AJ HW: 3C8 907 336 AJ
Component: Climatic H14 0305 
Revision: 00009001 
Coding: 0000001002
Shop #: WSC 00066 000 00147
ASAM Dataset: EV_Climatic A01005
ROD: EV_ClimaBasis_VW36.rod
VCID: 75B71D83B54BAA6F521-8020

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:. 1K0-937-08x-09.clb
Part No SW: 5K0 937 085 G HW: 5K0 937 085 G
Component: BCM PQ35 B++ 111 0129 
Revision: BI111001 
Coding: 2D200B1E902F3EE480000085400000040100008641008D605C 8020000000
Shop #: WSC 00066 000 00000
VCID: 372BD78BEF47187F80D-8062

Subsystem 1 - Part No: 1K1 955 119 F Labels: 1KX-955-119.CLB
Component: Wischer 07061 21 0512 
Coding: 009795

2 Faults Found:
00927 - Terminal 30 (Right) 
011 - Open Circuit - Intermittent
Freeze Frame:
Fault Status: 00101011
Fault Priority: 1
Fault Frequency: 2
Reset counter: 85
Mileage: 143848 km
Time Indication: 0
Date: 2012.09.12
Time: 01:19:60

Freeze Frame:
Term 15 Off
Voltage: 12.40 V
OFF
ON
OFF
OFF
OFF

02395 - Parking Light Front Right (M3) 
010 - Open or Short to Plus
Freeze Frame:
Fault Status: 01101010
Fault Priority: 2
Fault Frequency: 1
Reset counter: 206
Mileage: 141084 km
Time Indication: 0
Date: 2012.05.15
Time: 03:53:38

Freeze Frame:
Term 15 Off
Voltage: 12.20 V
OFF
ON
OFF
OFF
OFF


-------------------------------------------------------------------------------
Address 15: Airbags Labels: 1K0-909-605.lbl
Part No SW: 1K0 909 605 AD HW: 1K0 909 605 AD
Component: 04 AIRBAG VW8R 036 8900 
Revision: 06036000 Serial number: 003EVM02TVKN 
Coding: 0012340
Shop #: WSC 00066 000 00000
VCID: 6E8532EFDC9D99B793B-803A

Subsystem 1 - Part No: 1K0 959 339 H
Component: BF-Gewichtsens. 007 0006

Subsystem 2 - Serial number: 6332MSME5164750CB

Subsystem 3 - Serial number: 6342MSME53252117+

Subsystem 4 - Serial number: 6351HSME21385C378

Subsystem 5 - Serial number: 6361HSME214D153A7

Subsystem 6 - Serial number: 63727SME21575000N

Subsystem 7 - Serial number: 63827SME21444A4C2

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY9.lbl
Part No SW: 1K0 953 549 CP HW: 1K0 953 549 CP
Component: J0527 053 0111 
Coding: 0001031
Shop #: WSC 00066 000 00000
VCID: 025D765FF8058DD7673-8056

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5K0-920-xxx-17.clb-SRI1
Part No SW: 5M0 920 960 E HW: 5M0 920 960 E
Component: KOMBI H14 0112 
Revision: X0014004 Serial number: 
Coding: 270700
Shop #: WSC 00066 000 00147
ASAM Dataset: EV_KombiUDSMM9RM10 A04102
ROD: EV_KombiUDSMM9RM10_A04_VW36.rod
VCID: 313FE99301A3C64FCE9-8064

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels:. 1K0-907-530-V4.clb
Part No SW: 1K0 907 530 AD HW: 1K0 907 951 
Component: J533 Gateway H07 0112 
Revision: H07 01 Serial number: 230510F2000569
Coding: ED807F07000602001002
Shop #: WSC 00066 000 00000
VCID: 698F41F3E5737E8FC69-803C

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334) Labels:| 5K0-920-xxx-25.clb
Part No SW: 5K0 953 234 HW: 5M0 920 960 E
Component: IMMO H14 0112 
Revision: X0014004 Serial number: 
Coding: 000000
Shop #: WSC 00000 000 00000
ASAM Dataset: EV_ImmoUDSMM9RM10 A01102
ROD: EV_ImmoUDSMM9RM10_VW12.rod
VCID: 6A8D3EFFECF57597CF3-803E

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 3C0 959 701 B HW: 3C0 959 793 
Component: TUER-SG FT 002 0307 
Revision: 13101005 Serial number: 0000951539
Coding: 0004B5
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_DCU42BroseDriveSide A03004
ROD: EV_DCU42BroseDriveSide_VW36.rod
VCID: 270B07CB3F6788FF10D-8072

Slave Driver: 
Subsystem 1 - Part No SW: 1K0 959 703 AH HW: 1K0 959 795 T Labels: 1K0-959-70X-GEN4.CLB
Component: J388__TSG-HL 006 1401 
Serial number: 00000004922796 
Coding: 000490

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist Labels: 1K0-909-14x-GEN3.clb
Part No: 1K0 909 144 J
Component: EPS_ZFLS Kl. 70 3001 
Revision: 00H17000 
Shop #: WSC 02069 000 90108
VCID: 313FE9930D23C64FCE9-8064

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:| 3C0-959-70X-GEN4.clb
Part No SW: 3C0 959 702 B HW: 3C0 959 792 
Component: TUER-SG BT 002 0307 
Revision: 15101005 Serial number: 0000937860
Coding: 0004B4
Shop #: WSC 01383 790 50316
ASAM Dataset: EV_DCU52BrosePasseSide A03004
ROD: EV_DCU52BrosePasseSide.rod
VCID: 280904F732798787197-807C

Slave Passenger: 
Subsystem 1 - Part No SW: 1K0 959 704 AH HW: 1K0 959 794 T Labels: 1K0-959-70X-GEN4.CLB
Component: J389__TSG-HR 006 1401 
Serial number: 00000004965980 
Coding: 000490

1 Fault Found:
66560 - Motor for Mirror Adjustment 
B11F4 01 [008] - Electrical Failure
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 9
Reset counter: 91
Mileage: 143848 km
Date: 2018.04.21
Time: 05:36:15


-------------------------------------------------------------------------------
Address 56: Radio Labels: 1K0-035-161.lbl
Part No SW: 1K0 035 161 D HW: 1K0 035 161 D
Component: Radio DE2 020 0023 
Revision: 00020000 Serial number: VWZ4Z7K6495279
Coding: 0042401
Shop #: WSC 00066 000 00000
VCID: 20191CD756C97FC7517-8074

No fault code found.

-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502) Labels:. 1K0-937-08x-65.clb
Part No SW: 5K0 937 085 G HW: 5K0 937 085 G
Component: RDK 111 0821 
Coding: 018705
Shop #: WSC 00066 000 00000
VCID: 372BD78BEF47187F80D-8062

No fault code found.

-------------------------------------------------------------------------------
Address 77: Telephone (J738) Labels:. 1K8-035-730.clb
Part No SW: 1K8 035 730 D HW: 1K8 035 730 D
Component: Telefon H08 6900 
Revision: 00008000 Serial number: 00000A07727283
Coding: 401100
Shop #: WSC 00066 000 00000
VCID: 2A0DFEFF2CF5B5970F3-807E

No fault code found.

End----------(Elapsed Time: 01:10, VBatt start/end: 12.0V/12.1V)-----------
 
Last edited by a moderator:
   #2  
iichel

iichel

Verified VCDS User
Verified
Joined
Aug 10, 2016
Messages
3,759
Reaction score
4,174
Location
Netherlands, eastern part
VCDS Serial number
C?ID=284912
parking light front right isnt happy (see the error in 09 Central Electrics). regardless of its functioning, I'd replace it.
There's another error, Terminal 30 open (right). I don't know what it means, but it could be worthwhile checking the fuses for corrosion or a hairline fracture.
 
   #4  
9

93YuW'&=

Verified VCDS User
Verified
Joined
Jun 13, 2018
Messages
7
Reaction score
4
Location
USA
VCDS Serial number
C?ID=336153
So, I made a mess and have more errors than before. :banghead:

Whilst checking the fuses and relays in fuse boxes A & B to see if any of them were blown I managed to drop a few causing me to lose track of which ones were where. Over the course of trying to make everything work like it did before I jumbled the fuses I used the following resources:
• a pic I took of fuse box B after I realized I'd need to review everything but before I'd touched some fuses
• the fuse diagrams in my owners manual that were almost entirely wrong
• an online auto documentation repository provided by my library (EBSCO Automate)
• a page out of the Bentley factory repair manual (I don't have the whole book but one of the diagrams was in a "preview" on Google Books)

I shortly realized that none of them agreed with each other and it took a lot of trial and error to get everything working again and I ended up replacing some fuses (for example there was a 30 in fuse box B that I replaced with a 40 as none of my references showed a 30 anywhere). At some point I cleared all the codes via VCDS and now I have even more errors than before! This is especially weird as again, everything seems to work.

If anyone can provide photos of their MKV fuse boxes or any other guidance on fixing the errors below I'd greatly appreciate it!
##########
#LOG BEGINS#
##########

Code: 
Tuesday,10,July,2018,12:45:09:43468
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 18.2.1.2 (x64)  HEX-V2 CB: 0.4411.4
Data version: 20180518 DS287.1
www.Ross-Tech.com


VIN: 3VWRZ7AJ2AM147669   License Plate: 
Mileage: 146590km-91086mi   Repair Order: 



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: AJ-VW36 (1K0)
Scan: 01 02 03 08 09 15 16 17 19 25 42 44 46 52 56 62 65 72 77

VIN: 3VWRZ7AJ2AM147669   Mileage: 146590km-91086miles

01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: Malfunction 0010
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: Malfunction 0010
56-Radio -- Status: Malfunction 0010
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: Sporadic communication error 1000
-------------------------------------------------------------------------------
Address 01: Engine (CBU)       Labels: 07K-906-055-CBT.clb
   Part No SW: 07K 906 055 AG    HW: 07K 906 055 M
   Component: 2,5l R5/4V      G   5784  
   Revision: G6H04---    Serial number:               
   Coding: 0000075
   Shop #: WSC 00066 000 00000
   VCID: 73B3239BB7BFB45F7C5-8026

5 Faults Found:
000609 - Fuel Injector #1 (N30) 
               P0261 - 000 - Short to Ground - Intermittent
             Freeze Frame:
                    Fault Status: 00100000
                    Fault Priority: 0
                    Fault Frequency: 1
                    Reset counter: 255
                    Time Indication: 0
                    Date: 2047.15.31
                    Time: 31:63:63

             Freeze Frame:
                    RPM: 218 /min
                    Load: 71.0 %
                    Speed: 0.0 km/h
                    Temperature: 24.0°C
                    Temperature: 24.0°C
                    Absolute Pres.: 1000.0 mbar
                    Voltage: 10.287 V

000612 - Fuel Injector #2 (N31) 
               P0264 - 000 - Short to Ground - Intermittent
             Freeze Frame:
                    Fault Status: 00100000
                    Fault Priority: 0
                    Fault Frequency: 1
                    Reset counter: 255
                    Time Indication: 0
                    Date: 2047.15.31
                    Time: 31:63:63

             Freeze Frame:
                    RPM: 218 /min
                    Load: 71.0 %
                    Speed: 0.0 km/h
                    Temperature: 24.0°C
                    Temperature: 24.0°C
                    Absolute Pres.: 1000.0 mbar
                    Voltage: 10.287 V

000624 - Fuel Injector #4 (N33) 
               P0270 - 000 - Short to Ground - Intermittent
             Freeze Frame:
                    Fault Status: 00100000
                    Fault Priority: 0
                    Fault Frequency: 1
                    Reset counter: 255
                    Time Indication: 0
                    Date: 2047.15.31
                    Time: 31:63:63

             Freeze Frame:
                    RPM: 218 /min
                    Load: 71.0 %
                    Speed: 0.0 km/h
                    Temperature: 24.0°C
                    Temperature: 24.0°C
                    Absolute Pres.: 1000.0 mbar
                    Voltage: 10.287 V

000627 - Fuel Injector #5 (N83) 
               P0273 - 000 - Short to Ground - Intermittent
             Freeze Frame:
                    Fault Status: 00100000
                    Fault Priority: 0
                    Fault Frequency: 1
                    Reset counter: 255
                    Time Indication: 0
                    Date: 2047.15.31
                    Time: 31:63:63

             Freeze Frame:
                    RPM: 218 /min
                    Load: 71.0 %
                    Speed: 0.0 km/h
                    Temperature: 24.0°C
                    Temperature: 24.0°C
                    Absolute Pres.: 1000.0 mbar
                    Voltage: 10.287 V

000615 - Fuel Injector #3 (N32) 
               P0267 - 000 - Short to Ground - Intermittent
             Freeze Frame:
                    Fault Status: 00100000
                    Fault Priority: 0
                    Fault Frequency: 1
                    Reset counter: 255
                    Time Indication: 0
                    Date: 2047.15.31
                    Time: 31:63:63

             Freeze Frame:
                    RPM: 218 /min
                    Load: 71.0 %
                    Speed: 0.0 km/h
                    Temperature: 24.0°C
                    Temperature: 24.0°C
                    Absolute Pres.: 1000.0 mbar
                    Voltage: 10.287 V

Readiness: 0000 0000

-------------------------------------------------------------------------------
Address 02: Auto Trans        Labels: 09G-927-750.clb
   Part No SW: 09G 927 750 HG    HW: 09G 927 750 HG
   Component: AQ 250 6F           1631  
   Revision: 00H90000    Serial number:               
   Coding: 0000840
   Shop #: WSC 00066 000 00000
   VCID: 7DA705A381FBF22F1A1-8028

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels:. 1K0-907-379-60EC1F.clb
   Part No SW: 1K0 907 379 AH    HW: 1K0 907 379 AH
   Component: ESP MK60EC1   H30 0107  
   Revision: 00H30001    
   Coding: 114B400C49260001881102EA92220041300000
   Shop #: WSC 00066 000 00000
   VCID: 78A914B7A2D9D707497-802C

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301)       Labels:| 3C8-907-336.clb
   Part No SW: 3C8 907 336 AJ    HW: 3C8 907 336 AJ
   Component: Climatic      H14 0305  
   Revision: 00009001    
   Coding: 0000001002
   Shop #: WSC 00066 000 00147
   ASAM Dataset: EV_Climatic A01005
   ROD: EV_ClimaBasis_VW36.rod
   VCID: 75B71D83B54BAA6F521-8020

5 Faults Found:
13701376 - Function Restricted due to Missing Message(s) 
          U1111 00 [008] - -
          [Motorsteuergerät - kein Signal/Kommunikation]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 8
                    Reset counter: 126
                    Mileage: 146441 km
                    Date: 2018.06.19
                    Time: 18:38:54

13701392 - Function Restricted due to Missing Message(s) 
          U1111 00 [008] - -
          [Bremsensteuergerät - kein Signal/Kommunikation]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 8
                    Reset counter: 126
                    Mileage: 146441 km
                    Date: 2018.06.19
                    Time: 18:38:54

13701408 - Function Restricted due to Missing Message(s) 
          U1111 00 [008] - -
          [Diagnoseinterface für Datenbus - kein Signal/Kommunikation]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 1
                    Reset counter: 126

13701456 - Function Restricted due to Missing Message(s) 
          U1111 00 [008] - -
          [Steuergerät im Schalttafeleinsatz - kein Signal/Kommunikation]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 1
                    Reset counter: 126

9481748 - High Pressure Sensor 
          B10AE 14 [008] - Open or Short to Ground
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 126


-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:. 1K0-937-08x-09.clb
   Part No SW: 5K0 937 085 G    HW: 5K0 937 085 G
   Component: BCM PQ35 B++  111 0129  
   Revision: BI111001    
   Coding: 2D200B1E902F3EE480000085400000040100008641008D605C8020000000
   Shop #: WSC 00066 000 00000
   VCID: 372BD78BEF47187F80D-8062

   Subsystem 1 - Part No: 1K1 955 119 F  Labels: 1KX-955-119.CLB
   Component: Wischer 07061  21  0512 
   Coding: 009795

1 Fault Found:
02395 - Parking Light Front Right (M3) 
            010 - Open or Short to Plus
             Freeze Frame:
                    Fault Status: 01101010
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 86
                    Mileage: 146441 km
                    Time Indication: 0
                    Date: 2012.11.11
                    Time: 03:05:56

             Freeze Frame:
                        Term 15 On
                    Voltage: 14.05 V
                        ON
                        ON
                        OFF
                        OFF
                        OFF


-------------------------------------------------------------------------------
Address 15: Airbags        Labels: 1K0-909-605.lbl
   Part No SW: 1K0 909 605 AD    HW: 1K0 909 605 AD
   Component: 04 AIRBAG VW8R  036 8900  
   Revision: 06036000    Serial number: 003EVM02TVKN  
   Coding: 0012340
   Shop #: WSC 00066 000 00000
   VCID: 6E8532EFDC9D99B793B-803A

   Subsystem 1 - Part No: 1K0 959 339 H
   Component: BF-Gewichtsens. 007 0006

   Subsystem 2 - Serial number: 6332MSME5164750CB

   Subsystem 3 - Serial number: 6342MSME53252117+

   Subsystem 4 - Serial number: 6351HSME21385C378

   Subsystem 5 - Serial number: 6361HSME214D153A7

   Subsystem 6 - Serial number: 63727SME21575000N

   Subsystem 7 - Serial number: 63827SME21444A4C2

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel        Labels: 1K0-953-549-MY9.lbl
   Part No SW: 1K0 953 549 CP    HW: 1K0 953 549 CP
   Component: J0527           053 0111  
   Coding: 0001031
   Shop #: WSC 00066 000 00000
   VCID: 025D765FF8058DD7673-8056

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 5K0-920-xxx-17.clb-SRI1
   Part No SW: 5M0 920 960 E    HW: 5M0 920 960 E
   Component: KOMBI         H14 0112  
   Revision: X0014004    Serial number:               
   Coding: 270700
   Shop #: WSC 00066 000 00147
   ASAM Dataset: EV_KombiUDSMM9RM10 A04102
   ROD: EV_KombiUDSMM9RM10_A04_VW36.rod
   VCID: 313FE99301A3C64FCE9-8064

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway        Labels:. 1K0-907-530-V4.clb
   Part No SW: 1K0 907 530 AD    HW: 1K0 907 951 
   Component: J533  Gateway   H07 0112  
   Revision:   H07 01    Serial number: 230510F2000569
   Coding: ED807F07000602001002
   Shop #: WSC 00066 000 00000
   VCID: 698F41F3E5737E8FC69-803C

1 Fault Found:
01303 - Telephone Transceiver (R36) 
            004 - No Signal/Communication - Intermittent
             Freeze Frame:
                    Fault Status: 00110100
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 127
                    Mileage: 146441 km
                    Time Indication: 0
                    Date: 2012.11.11
                    Time: 02:59:31


-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels:| 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5M0 920 960 E
   Component: IMMO          H14 0112  
   Revision: X0014004    Serial number:               
   Coding: 000000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_ImmoUDSMM9RM10 A01102
   ROD: EV_ImmoUDSMM9RM10_VW12.rod
   VCID: 6A8D3EFFECF57597CF3-803E

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386)       Labels:| 3C0-959-70X-GEN4.clb
   Part No SW: 3C0 959 701 B    HW: 3C0 959 793 
   Component: TUER-SG FT    002 0307  
   Revision: 13101005    Serial number: 0000951539
   Coding: 0004B5
   Shop #: WSC 01383 790 50316
   ASAM Dataset: EV_DCU42BroseDriveSide A03004
   ROD: EV_DCU42BroseDriveSide_VW36.rod
   VCID: 270B07CB3F6788FF10D-8072

   Slave Driver: 
   Subsystem 1 - Part No SW: 1K0 959 703 AH    HW: 1K0 959 795 T  Labels: 1K0-959-70X-GEN4.CLB
   Component: J388__TSG-HL  006 1401 
   Serial number: 00000004922796      
   Coding: 000490

3 Faults Found:
68103 - Function Restricted due to Missing Message(s) 
          U1111 00 [008] - -
          [Front CAN gateway]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 1

68107 - Function Restricted due to Missing Message(s) 
          U1111 00 [008] - -
          [Front CAN AirBag]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 2
                    Reset counter: 126

65793 - Supply voltage 
          U1011 00 [008] - Voltage too Low
          [Front DCU undervoltage]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 126
                    Mileage: 146441 km
                    Date: 2018.06.19
                    Time: 03:10:18


-------------------------------------------------------------------------------
Address 44: Steering Assist        Labels: 1K0-909-14x-GEN3.clb
   Part No: 1K0 909 144 J
   Component: EPS_ZFLS Kl. 70     3001  
   Revision: 00H17000    
   Shop #: WSC 02069 000 90108
   VCID: 313FE9930D23C64FCE9-8064

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387)       Labels:| 3C0-959-70X-GEN4.clb
   Part No SW: 3C0 959 702 B    HW: 3C0 959 792 
   Component: TUER-SG BT    002 0307  
   Revision: 15101005    Serial number: 0000937860
   Coding: 0004B4
   Shop #: WSC 01383 790 50316
   ASAM Dataset: EV_DCU52BrosePasseSide A03004
   ROD: EV_DCU52BrosePasseSide.rod
   VCID: 280904F732798787197-807C

   Slave Passenger: 
   Subsystem 1 - Part No SW: 1K0 959 704 AH    HW: 1K0 959 794 T  Labels: 1K0-959-70X-GEN4.CLB
   Component: J389__TSG-HR  006 1401 
   Serial number: 00000004965980      
   Coding: 000490

4 Faults Found:
66560 - Motor for Mirror Adjustment 
          B11F4 01 [008] - Electrical Failure
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 17
                    Reset counter: 129
                    Mileage: 143848 km
                    Date: 2018.04.21
                    Time: 05:36:15

68103 - Function Restricted due to Missing Message(s) 
          U1111 00 [008] - -
          [Front CAN gateway]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 1

68107 - Function Restricted due to Missing Message(s) 
          U1111 00 [008] - -
          [Front CAN AirBag]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 2
                    Reset counter: 126

65793 - Supply voltage 
          U1011 00 [008] - Voltage too Low
          [Front DCU undervoltage]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 126
                    Mileage: 146441 km
                    Date: 2018.06.19
                    Time: 03:10:18


-------------------------------------------------------------------------------
Address 56: Radio        Labels: 1K0-035-161.lbl
   Part No SW: 1K0 035 161 D    HW: 1K0 035 161 D
   Component: Radio DE2       020 0023  
   Revision: 00020000    Serial number: VWZ4Z7K6495279
   Coding: 0042401
   Shop #: WSC 00066 000 00000
   VCID: 20191CD756C97FC7517-8074

1 Fault Found:
01303 - Telephone Transceiver (R36) 
            004 - No Signal/Communication - Intermittent

-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502)       Labels:. 1K0-937-08x-65.clb
   Part No SW: 5K0 937 085 G    HW: 5K0 937 085 G
   Component: RDK           111 0821  
   Coding: 018705
   Shop #: WSC 00066 000 00000
   VCID: 372BD78BEF47187F80D-8062

No fault code found.

-------------------------------------------------------------------------------
Address 77: Telephone (J738)       Labels:. 1K8-035-730.clb
   Part No SW: 1K8 035 730 D    HW: 1K8 035 730 D
   Component: Telefon       H08 6900  
   Revision: 00008000    Serial number: 00000A07727283
   Coding: 401100
   Shop #: WSC 00066 000 00000
   VCID: 2A0DFEFF2CF5B5970F3-807E

No fault code found.

End----(Elapsed Time: 01:14, VBatt start/end: 12.1V/12.1V. VIgn 12.0V)-----
 
Last edited by a moderator:
   #5  
9

93YuW'&=

Verified VCDS User
Verified
Joined
Jun 13, 2018
Messages
7
Reaction score
4
Location
USA
VCDS Serial number
C?ID=336153
No, I pulled them all and the fuses and relays look fine.

What's worse is in the process of checking I dropped a couple and then I lost track of which fuse was where. I spent a good while comparing fuse diagrams from multiple sources (since the one in the manual is worthlessly wrong), and I got everything seeming to work fine, but now I have a ton more errors in my logs (below) and the service engine bell dings when I start the car.

I'm kicking myself for not snapping pics before I started pulling fuses!
 
   #6  
9

93YuW'&=

Verified VCDS User
Verified
Joined
Jun 13, 2018
Messages
7
Reaction score
4
Location
USA
VCDS Serial number
C?ID=336153
The fuses all looked new, but then I screwed up the order of putting them back in. Now everything works, but I have a ton more codes and the check engine bell dings when I start up.
 
   #7  
Jack@European_Parts

Jack@European_Parts

Gone But Not Forgotten
Professional VCDS User
Joined
Jan 29, 2014
Messages
21,923
Reaction score
9,308
Location
Montgomery, NY, USA
VCDS Serial number
C?ID=57337
One at a time for the next time and a picture before doing anything ..........backups!

Clear codes.........
 
   #8  
9

93YuW'&=

Verified VCDS User
Verified
Joined
Jun 13, 2018
Messages
7
Reaction score
4
Location
USA
VCDS Serial number
C?ID=336153
Well I have a status update but unfortunately haven't made any progress:

I've cleared the codes a few times but keep getting the same results I posted on 7/10/18. So far I've cross referenced the fuse box diagrams from the owners manual, AutoMate, and a diagram for fuse box B from the Bentley manual that I found in a preview of the full manual. After a lot of trial and error everything seems to work but I still have a bunch of codes that weren't there before I started pulling fuses. At this point I've read the component identifier post, paid for erWin wiring diagrams, and learned how to read them but what I'm reading doesn't seem like it could possibly be correct.

If I'm reading it correctly, the very first wiring diagram from erWin says the very first fuse in fuse box B should be 200A but I've never even seen a fuse that large, and there was never anything bigger than 50A in either fuse box!

I had no idea that getting an accurate fuse box diagram would be so toilsome and have been low-key stressed out since this began. I'm getting to the point of giving up and taking it to a shop, but I'm still learning more and would really like to learn the inner workings of this car. Can anyone tell me what I'm doing (or reading) incorrectly and/or post a pic of their (correctly working) A5 fuse boxes?
 
   #9  
Dana

Dana

Administrator
Staff member
Administrator
Ross-Tech Employee
Joined
Jan 29, 2014
Messages
6,021
Reaction score
9,027
Location
Western PA, USA
SA fuses (SA1 in this specific case) are the large strip fuses on the front of that fuse box. SB are the fuses that push into the top of it near the relays. SB fuses are usually labeled with the letter F (i.e. F6 is SB6) on the panel itself.
 
   #10  
Dana

Dana

Administrator
Staff member
Administrator
Ross-Tech Employee
Joined
Jan 29, 2014
Messages
6,021
Reaction score
9,027
Location
Western PA, USA
P.S. The Bent publishers link is for one of many possible fuse arrangements on a Low (2-relay) box. In the US market there were at least 8 possible configurations between 2005 and 2010, and a nearly 50 page fuse arrangement document, so that may not be accurate at all for you. Posting a photo of the box you have should enable someone to assist with the fuse positions based on the DTCs.
 
   #11  
9

93YuW'&=

Verified VCDS User
Verified
Joined
Jun 13, 2018
Messages
7
Reaction score
4
Location
USA
VCDS Serial number
C?ID=336153
I had no idea there were so many variants! Here are the pics I took of the fuse boxes after I dropped a couple and realized that I might have some issues getting things back to normal. This was before I consulted the other sources and ended up adding more fuses. There's 2 pics of fuse box B as the camera flash obscured a different spot in each one.
 
Last edited:
   #12  
Dana

Dana

Administrator
Staff member
Administrator
Ross-Tech Employee
Joined
Jan 29, 2014
Messages
6,021
Reaction score
9,027
Location
Western PA, USA
Thanks for the photos. There were 8 possible arrangements but those are split into 4 for E-Box Low and another 4 for E-Box High. The 2-relay box is Low so that should make your exact arrangement: Fuses (SB) on E-box Low, from July 2009.

The only fuse that appears to be the incorrect size is:

F26 - SB26 - Fuse 26 (on fuse panel B) 40A - J519 - Vehicle Electrical System Control Module (M/1)

Most of the faults in the 2nd scan are flagged Intermittent so I would clear all of them to see which return. The 02395 - Parking Light Front Right (M3) - Open or Short to Plus DTC may be a bulb inside the headlight or in the bumper that's out. Earlier Mk5 models would set incorrect faults so you may even want to check the rear lights to make sure a bulb isn't out in the back.
 
  • Like
Reactions: Uwe
   #13  
9

93YuW'&=

Verified VCDS User
Verified
Joined
Jun 13, 2018
Messages
7
Reaction score
4
Location
USA
VCDS Serial number
C?ID=336153
I reverted the fuse boxes to the way they were in the pic (except for F28 since I don't have a 10A fuse at the moment) and I had some Terminal 30 related errors and the horn didn't work until I put a 5A fuse in fuse-box A F17. Now everything still seems to work and I had a couple of scans with no errors but eventually it brought back the parking light and heated seat errors which odd since they work.

I don't have the patience to chart out the fuses from the wiring diagram, maybe I'll try and track down a used copy of the Bentley manual or see if Chiltons or Haynes has anything for the MKV.

Anyway, the latest log is below:
Code: 
Friday,10,August,2018,20:55:49:43468
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 18.2.1.2 (x64)  HEX-V2 CB: 0.4411.4
Data version: 20180518 DS287.1
www.Ross-Tech.com


VIN: 3VWRZ7AJ2AM1XXXXX   License Plate: 
Mileage: 147190km-91459mi   Repair Order: 



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: AJ-VW36 (1K0)
Scan: 01 02 03 08 09 15 16 17 19 25 42 44 46 52 56 62 65 72 77

VIN: 3VWRZ7AJ2AM147669   Mileage: 147190km-91459miles

01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (CBU)       Labels: 07K-906-055-CBT.clb
   Part No SW: 07K 906 055 AG    HW: 07K 906 055 M
   Component: 2,5l R5/4V      G   5784  
   Revision: G6H04---    Serial number:               
   Coding: 0000075
   Shop #: WSC 00066 000 00000
   VCID: 73B3239BB7BFB45F7C5-8026

No fault code found.
Readiness: 0000 0000

-------------------------------------------------------------------------------
Address 02: Auto Trans        Labels: 09G-927-750.clb
   Part No SW: 09G 927 750 HG    HW: 09G 927 750 HG
   Component: AQ 250 6F           1631  
   Revision: 00H90000    Serial number:               
   Coding: 0000840
   Shop #: WSC 00066 000 00000
   VCID: 7DA705A381FBF22F1A1-8028

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels:. 1K0-907-379-60EC1F.clb
   Part No SW: 1K0 907 379 AH    HW: 1K0 907 379 AH
   Component: ESP MK60EC1   H30 0107  
   Revision: 00H30001    
   Coding: 114B400C49260001881102EA92220041300000
   Shop #: WSC 00066 000 00000
   VCID: 78A914B7A2D9D707497-802C

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301)       Labels:| 3C8-907-336.clb
   Part No SW: 3C8 907 336 AJ    HW: 3C8 907 336 AJ
   Component: Climatic      H14 0305  
   Revision: 00009001    
   Coding: 0000001002
   Shop #: WSC 00066 000 00147
   ASAM Dataset: EV_Climatic A01005
   ROD: EV_ClimaBasis_VW36.rod
   VCID: 75B71D83B54BAA6F521-8020

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:. 1K0-937-08x-09.clb
   Part No SW: 5K0 937 085 G    HW: 5K0 937 085 G
   Component: BCM PQ35 B++  111 0129  
   Revision: BI111001    
   Coding: 2D200B1E902F3EE480000085400000040100008641008D605C8020000000
   Shop #: WSC 00066 000 00000
   VCID: 372BD78BEF47187F80D-8062

   Subsystem 1 - Part No: 1K1 955 119 F  Labels: 1KX-955-119.CLB
   Component: Wischer 07061  21  0512 
   Coding: 009795

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags        Labels: 1K0-909-605.lbl
   Part No SW: 1K0 909 605 AD    HW: 1K0 909 605 AD
   Component: 04 AIRBAG VW8R  036 8900  
   Revision: 06036000    Serial number: 003EVM02TVKN  
   Coding: 0012340
   Shop #: WSC 00066 000 00000
   VCID: 6E8532EFDC9D99B793B-803A

   Subsystem 1 - Part No: 1K0 959 339 H
   Component: BF-Gewichtsens. 007 0006

   Subsystem 2 - Serial number: 6332MSME5164750CB

   Subsystem 3 - Serial number: 6342MSME53252117+

   Subsystem 4 - Serial number: 6351HSME21385C378

   Subsystem 5 - Serial number: 6361HSME214D153A7

   Subsystem 6 - Serial number: 63727SME21575000N

   Subsystem 7 - Serial number: 63827SME21444A4C2

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel        Labels: 1K0-953-549-MY9.lbl
   Part No SW: 1K0 953 549 CP    HW: 1K0 953 549 CP
   Component: J0527           053 0111  
   Coding: 0001031
   Shop #: WSC 00066 000 00000
   VCID: 025D765FF8058DD7673-8056

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 5K0-920-xxx-17.clb-SRI1
   Part No SW: 5M0 920 960 E    HW: 5M0 920 960 E
   Component: KOMBI         H14 0112  
   Revision: X0014004    Serial number:               
   Coding: 270700
   Shop #: WSC 00066 000 00147
   ASAM Dataset: EV_KombiUDSMM9RM10 A04102
   ROD: EV_KombiUDSMM9RM10_A04_VW36.rod
   VCID: 313FE99301A3C64FCE9-8064

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway        Labels:. 1K0-907-530-V4.clb
   Part No SW: 1K0 907 530 AD    HW: 1K0 907 951 
   Component: J533  Gateway   H07 0112  
   Revision:   H07 01    Serial number: 230510F2000569
   Coding: ED807F07000602001002
   Shop #: WSC 00066 000 00000
   VCID: 698F41F3E5737E8FC69-803C

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels:| 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5M0 920 960 E
   Component: IMMO          H14 0112  
   Revision: X0014004    Serial number:               
   Coding: 000000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_ImmoUDSMM9RM10 A01102
   ROD: EV_ImmoUDSMM9RM10_VW12.rod
   VCID: 6A8D3EFFECF57597CF3-803E

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386)       Labels:| 3C0-959-70X-GEN4.clb
   Part No SW: 3C0 959 701 B    HW: 3C0 959 793 
   Component: TUER-SG FT    002 0307  
   Revision: 13101005    Serial number: 0000951539
   Coding: 0004B5
   Shop #: WSC 01383 790 50316
   ASAM Dataset: EV_DCU42BroseDriveSide A03004
   ROD: EV_DCU42BroseDriveSide_VW36.rod
   VCID: 270B07CB3F6788FF10D-8072

   Slave Driver: 
   Subsystem 1 - Part No SW: 1K0 959 703 AH    HW: 1K0 959 795 T  Labels: 1K0-959-70X-GEN4.CLB
   Component: J388__TSG-HL  006 1401 
   Serial number: 00000004922796      
   Coding: 000490

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist        Labels: 1K0-909-14x-GEN3.clb
   Part No: 1K0 909 144 J
   Component: EPS_ZFLS Kl. 70     3001  
   Revision: 00H17000    
   Shop #: WSC 02069 000 90108
   VCID: 313FE9930D23C64FCE9-8064

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387)       Labels:| 3C0-959-70X-GEN4.clb
   Part No SW: 3C0 959 702 B    HW: 3C0 959 792 
   Component: TUER-SG BT    002 0307  
   Revision: 15101005    Serial number: 0000937860
   Coding: 0004B4
   Shop #: WSC 01383 790 50316
   ASAM Dataset: EV_DCU52BrosePasseSide A03004
   ROD: EV_DCU52BrosePasseSide.rod
   VCID: 280904F732798787197-807C

   Slave Passenger: 
   Subsystem 1 - Part No SW: 1K0 959 704 AH    HW: 1K0 959 794 T  Labels: 1K0-959-70X-GEN4.CLB
   Component: J389__TSG-HR  006 1401 
   Serial number: 00000004965980      
   Coding: 000490

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio        Labels: 1K0-035-161.lbl
   Part No SW: 1K0 035 161 D    HW: 1K0 035 161 D
   Component: Radio DE2       020 0023  
   Revision: 00020000    Serial number: VWZ4Z7K6495279
   Coding: 0042401
   Shop #: WSC 00066 000 00000
   VCID: 20191CD756C97FC7517-8074

No fault code found.

-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502)       Labels:. 1K0-937-08x-65.clb
   Part No SW: 5K0 937 085 G    HW: 5K0 937 085 G
   Component: RDK           111 0821  
   Coding: 018705
   Shop #: WSC 00066 000 00000
   VCID: 372BD78BEF47187F80D-8062

No fault code found.

-------------------------------------------------------------------------------
Address 77: Telephone (J738)       Labels:. 1K8-035-730.clb
   Part No SW: 1K8 035 730 D    HW: 1K8 035 730 D
   Component: Telefon       H08 6900  
   Revision: 00008000    Serial number: 00000A07727283
   Coding: 401100
   Shop #: WSC 00066 000 00000
   VCID: 2A0DFEFF2CF5B5970F3-807E

No fault code found.

End----(Elapsed Time: 01:13, VBatt start/end: 12.0V/12.0V. VIgn 11.9V)-----

--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: AJ-VW36 (1K0)
Scan: 01 02 03 08 09 15 16 17 19 25 42 44 46 52 56 62 65 72 77

VIN: 3VWRZ7AJ2AM147669   Mileage: 147200km-91465miles

01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (CBU)       Labels: 07K-906-055-CBT.clb
   Part No SW: 07K 906 055 AG    HW: 07K 906 055 M
   Component: 2,5l R5/4V      G   5784  
   Revision: G6H04---    Serial number:               
   Coding: 0000075
   Shop #: WSC 00066 000 00000
   VCID: 73B3239BB7BFB45F7C5-8026

No fault code found.
Readiness: 0000 0000

-------------------------------------------------------------------------------
Address 02: Auto Trans        Labels: 09G-927-750.clb
   Part No SW: 09G 927 750 HG    HW: 09G 927 750 HG
   Component: AQ 250 6F           1631  
   Revision: 00H90000    Serial number:               
   Coding: 0000840
   Shop #: WSC 00066 000 00000
   VCID: 7DA705A381FBF22F1A1-8028

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels:. 1K0-907-379-60EC1F.clb
   Part No SW: 1K0 907 379 AH    HW: 1K0 907 379 AH
   Component: ESP MK60EC1   H30 0107  
   Revision: 00H30001    
   Coding: 114B400C49260001881102EA92220041300000
   Shop #: WSC 00066 000 00000
   VCID: 78A914B7A2D9D707497-802C

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301)       Labels:| 3C8-907-336.clb
   Part No SW: 3C8 907 336 AJ    HW: 3C8 907 336 AJ
   Component: Climatic      H14 0305  
   Revision: 00009001    
   Coding: 0000001002
   Shop #: WSC 00066 000 00147
   ASAM Dataset: EV_Climatic A01005
   ROD: EV_ClimaBasis_VW36.rod
   VCID: 75B71D83B54BAA6F521-8020

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:. 1K0-937-08x-09.clb
   Part No SW: 5K0 937 085 G    HW: 5K0 937 085 G
   Component: BCM PQ35 B++  111 0129  
   Revision: BI111001    
   Coding: 2D200B1E902F3EE480000085400000040100008641008D605C8020000000
   Shop #: WSC 00066 000 00000
   VCID: 372BD78BEF47187F80D-8062

   Subsystem 1 - Part No: 1K1 955 119 F  Labels: 1KX-955-119.CLB
   Component: Wischer 07061  21  0512 
   Coding: 009795

2 Faults Found:
02092 - Enabling Heated Seat 
            009 - Open or Short to Ground
             Freeze Frame:
                    Fault Status: 01101001
                    Fault Priority: 5
                    Fault Frequency: 4
                    Reset counter: 130
                    Mileage: 147197 km
                    Time Indication: 0
                    Date: 2012.12.31
                    Time: 08:59:46

             Freeze Frame:
                        Term 15 On
                    Voltage: 13.75 V
                        ON
                        ON
                        OFF
                        OFF
                        ON

02395 - Parking Light Front Right (M3) 
            010 - Open or Short to Plus
             Freeze Frame:
                    Fault Status: 01101010
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 130
                    Mileage: 147197 km
                    Time Indication: 0
                    Date: 2012.12.31
                    Time: 09:00:05

             Freeze Frame:
                        Term 15 On
                    Voltage: 13.70 V
                        ON
                        ON
                        OFF
                        OFF
                        OFF


-------------------------------------------------------------------------------
Address 15: Airbags        Labels: 1K0-909-605.lbl
   Part No SW: 1K0 909 605 AD    HW: 1K0 909 605 AD
   Component: 04 AIRBAG VW8R  036 8900  
   Revision: 06036000    Serial number: 003EVM02TVKN  
   Coding: 0012340
   Shop #: WSC 00066 000 00000
   VCID: 6E8532EFDC9D99B793B-803A

   Subsystem 1 - Part No: 1K0 959 339 H
   Component: BF-Gewichtsens. 007 0006

   Subsystem 2 - Serial number: 6332MSME5164750CB

   Subsystem 3 - Serial number: 6342MSME53252117+

   Subsystem 4 - Serial number: 6351HSME21385C378

   Subsystem 5 - Serial number: 6361HSME214D153A7

   Subsystem 6 - Serial number: 63727SME21575000N

   Subsystem 7 - Serial number: 63827SME21444A4C2

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel        Labels: 1K0-953-549-MY9.lbl
   Part No SW: 1K0 953 549 CP    HW: 1K0 953 549 CP
   Component: J0527           053 0111  
   Coding: 0001031
   Shop #: WSC 00066 000 00000
   VCID: 025D765FF8058DD7673-8056

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 5K0-920-xxx-17.clb-SRI1
   Part No SW: 5M0 920 960 E    HW: 5M0 920 960 E
   Component: KOMBI         H14 0112  
   Revision: X0014004    Serial number:               
   Coding: 270700
   Shop #: WSC 00066 000 00147
   ASAM Dataset: EV_KombiUDSMM9RM10 A04102
   ROD: EV_KombiUDSMM9RM10_A04_VW36.rod
   VCID: 313FE99301A3C64FCE9-8064

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway        Labels:. 1K0-907-530-V4.clb
   Part No SW: 1K0 907 530 AD    HW: 1K0 907 951 
   Component: J533  Gateway   H07 0112  
   Revision:   H07 01    Serial number: 230510F2000569
   Coding: ED807F07000602001002
   Shop #: WSC 00066 000 00000
   VCID: 698F41F3E5737E8FC69-803C

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels:| 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5M0 920 960 E
   Component: IMMO          H14 0112  
   Revision: X0014004    Serial number:               
   Coding: 000000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_ImmoUDSMM9RM10 A01102
   ROD: EV_ImmoUDSMM9RM10_VW12.rod
   VCID: 6A8D3EFFECF57597CF3-803E

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386)       Labels:| 3C0-959-70X-GEN4.clb
   Part No SW: 3C0 959 701 B    HW: 3C0 959 793 
   Component: TUER-SG FT    002 0307  
   Revision: 13101005    Serial number: 0000951539
   Coding: 0004B5
   Shop #: WSC 01383 790 50316
   ASAM Dataset: EV_DCU42BroseDriveSide A03004
   ROD: EV_DCU42BroseDriveSide_VW36.rod
   VCID: 270B07CB3F6788FF10D-8072

   Slave Driver: 
   Subsystem 1 - Part No SW: 1K0 959 703 AH    HW: 1K0 959 795 T  Labels: 1K0-959-70X-GEN4.CLB
   Component: J388__TSG-HL  006 1401 
   Serial number: 00000004922796      
   Coding: 000490

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist        Labels: 1K0-909-14x-GEN3.clb
   Part No: 1K0 909 144 J
   Component: EPS_ZFLS Kl. 70     3001  
   Revision: 00H17000    
   Shop #: WSC 02069 000 90108
   VCID: 313FE9930D23C64FCE9-8064

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387)       Labels:| 3C0-959-70X-GEN4.clb
   Part No SW: 3C0 959 702 B    HW: 3C0 959 792 
   Component: TUER-SG BT    002 0307  
   Revision: 15101005    Serial number: 0000937860
   Coding: 0004B4
   Shop #: WSC 01383 790 50316
   ASAM Dataset: EV_DCU52BrosePasseSide A03004
   ROD: EV_DCU52BrosePasseSide.rod
   VCID: 280904F732798787197-807C

   Slave Passenger: 
   Subsystem 1 - Part No SW: 1K0 959 704 AH    HW: 1K0 959 794 T  Labels: 1K0-959-70X-GEN4.CLB
   Component: J389__TSG-HR  006 1401 
   Serial number: 00000004965980      
   Coding: 000490

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio        Labels: 1K0-035-161.lbl
   Part No SW: 1K0 035 161 D    HW: 1K0 035 161 D
   Component: Radio DE2       020 0023  
   Revision: 00020000    Serial number: VWZ4Z7K6495279
   Coding: 0042401
   Shop #: WSC 00066 000 00000
   VCID: 20191CD756C97FC7517-8074

No fault code found.

-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502)       Labels:. 1K0-937-08x-65.clb
   Part No SW: 5K0 937 085 G    HW: 5K0 937 085 G
   Component: RDK           111 0821  
   Coding: 018705
   Shop #: WSC 00066 000 00000
   VCID: 372BD78BEF47187F80D-8062

No fault code found.

-------------------------------------------------------------------------------
Address 77: Telephone (J738)       Labels:. 1K8-035-730.clb
   Part No SW: 1K8 035 730 D    HW: 1K8 035 730 D
   Component: Telefon       H08 6900  
   Revision: 00008000    Serial number: 00000A07727283
   Coding: 401100
   Shop #: WSC 00066 000 00000
   VCID: 2A0DFEFF2CF5B5970F3-807E

No fault code found.

End----------(Elapsed Time: 01:13, VBatt start/end: 12.6V/12.6V)-----------

--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Address 09: DTCs cleared
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: AJ-VW36 (1K0)
Scan: 01 02 03 08 09 15 16 17 19 25 42 44 46 52 56 62 65 72 77

VIN: 3VWRZ7AJ2AM147669   Mileage: 147200km-91465miles

01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
65-Tire Pressure -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (CBU)       Labels: 07K-906-055-CBT.clb
   Part No SW: 07K 906 055 AG    HW: 07K 906 055 M
   Component: 2,5l R5/4V      G   5784  
   Revision: G6H04---    Serial number:               
   Coding: 0000075
   Shop #: WSC 00066 000 00000
   VCID: 73B3239BB7BFB45F7C5-8026

No fault code found.
Readiness: 0000 0000

-------------------------------------------------------------------------------
Address 02: Auto Trans        Labels: 09G-927-750.clb
   Part No SW: 09G 927 750 HG    HW: 09G 927 750 HG
   Component: AQ 250 6F           1631  
   Revision: 00H90000    Serial number:               
   Coding: 0000840
   Shop #: WSC 00066 000 00000
   VCID: 7DA705A381FBF22F1A1-8028

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels:. 1K0-907-379-60EC1F.clb
   Part No SW: 1K0 907 379 AH    HW: 1K0 907 379 AH
   Component: ESP MK60EC1   H30 0107  
   Revision: 00H30001    
   Coding: 114B400C49260001881102EA92220041300000
   Shop #: WSC 00066 000 00000
   VCID: 78A914B7A2D9D707497-802C

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301)       Labels:| 3C8-907-336.clb
   Part No SW: 3C8 907 336 AJ    HW: 3C8 907 336 AJ
   Component: Climatic      H14 0305  
   Revision: 00009001    
   Coding: 0000001002
   Shop #: WSC 00066 000 00147
   ASAM Dataset: EV_Climatic A01005
   ROD: EV_ClimaBasis_VW36.rod
   VCID: 75B71D83B54BAA6F521-8020

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:. 1K0-937-08x-09.clb
   Part No SW: 5K0 937 085 G    HW: 5K0 937 085 G
   Component: BCM PQ35 B++  111 0129  
   Revision: BI111001    
   Coding: 2D200B1E902F3EE480000085400000040100008641008D605C8020000000
   Shop #: WSC 00066 000 00000
   VCID: 372BD78BEF47187F80D-8062

   Subsystem 1 - Part No: 1K1 955 119 F  Labels: 1KX-955-119.CLB
   Component: Wischer 07061  21  0512 
   Coding: 009795

2 Faults Found:
02092 - Enabling Heated Seat 
            009 - Open or Short to Ground
             Freeze Frame:
                    Fault Status: 01101001
                    Fault Priority: 5
                    Fault Frequency: 2
                    Reset counter: 130
                    Mileage: 147201 km
                    Time Indication: 0
                    Date: 2012.12.31
                    Time: 09:16:54

             Freeze Frame:
                        Term 15 On
                    Voltage: 12.50 V
                        ON
                        ON
                        OFF
                        OFF
                        OFF

02395 - Parking Light Front Right (M3) 
            010 - Open or Short to Plus
             Freeze Frame:
                    Fault Status: 01101010
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 130
                    Mileage: 147201 km
                    Time Indication: 0
                    Date: 2012.12.31
                    Time: 09:17:28

             Freeze Frame:
                        Term 15 On
                    Voltage: 12.35 V
                        ON
                        ON
                        OFF
                        OFF
                        OFF


-------------------------------------------------------------------------------
Address 15: Airbags        Labels: 1K0-909-605.lbl
   Part No SW: 1K0 909 605 AD    HW: 1K0 909 605 AD
   Component: 04 AIRBAG VW8R  036 8900  
   Revision: 06036000    Serial number: 003EVM02TVKN  
   Coding: 0012340
   Shop #: WSC 00066 000 00000
   VCID: 6E8532EFDC9D99B793B-803A

   Subsystem 1 - Part No: 1K0 959 339 H
   Component: BF-Gewichtsens. 007 0006

   Subsystem 2 - Serial number: 6332MSME5164750CB

   Subsystem 3 - Serial number: 6342MSME53252117+

   Subsystem 4 - Serial number: 6351HSME21385C378

   Subsystem 5 - Serial number: 6361HSME214D153A7

   Subsystem 6 - Serial number: 63727SME21575000N

   Subsystem 7 - Serial number: 63827SME21444A4C2

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel        Labels: 1K0-953-549-MY9.lbl
   Part No SW: 1K0 953 549 CP    HW: 1K0 953 549 CP
   Component: J0527           053 0111  
   Coding: 0001031
   Shop #: WSC 00066 000 00000
   VCID: 025D765FF8058DD7673-8056

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 5K0-920-xxx-17.clb-SRI1
   Part No SW: 5M0 920 960 E    HW: 5M0 920 960 E
   Component: KOMBI         H14 0112  
   Revision: X0014004    Serial number:               
   Coding: 270700
   Shop #: WSC 00066 000 00147
   ASAM Dataset: EV_KombiUDSMM9RM10 A04102
   ROD: EV_KombiUDSMM9RM10_A04_VW36.rod
   VCID: 313FE99301A3C64FCE9-8064

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway        Labels:. 1K0-907-530-V4.clb
   Part No SW: 1K0 907 530 AD    HW: 1K0 907 951 
   Component: J533  Gateway   H07 0112  
   Revision:   H07 01    Serial number: 230510F2000569
   Coding: ED807F07000602001002
   Shop #: WSC 00066 000 00000
   VCID: 698F41F3E5737E8FC69-803C

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels:| 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5M0 920 960 E
   Component: IMMO          H14 0112  
   Revision: X0014004    Serial number:               
   Coding: 000000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_ImmoUDSMM9RM10 A01102
   ROD: EV_ImmoUDSMM9RM10_VW12.rod
   VCID: 6A8D3EFFECF57597CF3-803E

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386)       Labels:| 3C0-959-70X-GEN4.clb
   Part No SW: 3C0 959 701 B    HW: 3C0 959 793 
   Component: TUER-SG FT    002 0307  
   Revision: 13101005    Serial number: 0000951539
   Coding: 0004B5
   Shop #: WSC 01383 790 50316
   ASAM Dataset: EV_DCU42BroseDriveSide A03004
   ROD: EV_DCU42BroseDriveSide_VW36.rod
   VCID: 270B07CB3F6788FF10D-8072

   Slave Driver: 
   Subsystem 1 - Part No SW: 1K0 959 703 AH    HW: 1K0 959 795 T  Labels: 1K0-959-70X-GEN4.CLB
   Component: J388__TSG-HL  006 1401 
   Serial number: 00000004922796      
   Coding: 000490

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist        Labels: 1K0-909-14x-GEN3.clb
   Part No: 1K0 909 144 J
   Component: EPS_ZFLS Kl. 70     3001  
   Revision: 00H17000    
   Shop #: WSC 02069 000 90108
   VCID: 313FE9930D23C64FCE9-8064

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387)       Labels:| 3C0-959-70X-GEN4.clb
   Part No SW: 3C0 959 702 B    HW: 3C0 959 792 
   Component: TUER-SG BT    002 0307  
   Revision: 15101005    Serial number: 0000937860
   Coding: 0004B4
   Shop #: WSC 01383 790 50316
   ASAM Dataset: EV_DCU52BrosePasseSide A03004
   ROD: EV_DCU52BrosePasseSide.rod
   VCID: 280904F732798787197-807C

   Slave Passenger: 
   Subsystem 1 - Part No SW: 1K0 959 704 AH    HW: 1K0 959 794 T  Labels: 1K0-959-70X-GEN4.CLB
   Component: J389__TSG-HR  006 1401 
   Serial number: 00000004965980      
   Coding: 000490

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio        Labels: 1K0-035-161.lbl
   Part No SW: 1K0 035 161 D    HW: 1K0 035 161 D
   Component: Radio DE2       020 0023  
   Revision: 00020000    Serial number: VWZ4Z7K6495279
   Coding: 0042401
   Shop #: WSC 00066 000 00000
   VCID: 20191CD756C97FC7517-8074

No fault code found.

-------------------------------------------------------------------------------
Address 65: Tire Pressure (J502)       Labels:. 1K0-937-08x-65.clb
   Part No SW: 5K0 937 085 G    HW: 5K0 937 085 G
   Component: RDK           111 0821  
   Coding: 018705
   Shop #: WSC 00066 000 00000
   VCID: 372BD78BEF47187F80D-8062

No fault code found.

-------------------------------------------------------------------------------
Address 77: Telephone (J738)       Labels:. 1K8-035-730.clb
   Part No SW: 1K8 035 730 D    HW: 1K8 035 730 D
   Component: Telefon       H08 6900  
   Revision: 00008000    Serial number: 00000A07727283
   Coding: 401100
   Shop #: WSC 00066 000 00000
   VCID: 2A0DFEFF2CF5B5970F3-807E

No fault code found.

End----------(Elapsed Time: 01:13, VBatt start/end: 12.4V/12.4V)-----------
 
Last edited:
You must log in or register to reply here.
Back
Top