So, I'm new to this whole VAG thing so have invested in the Hex-Net as an enthusiastic amature. While I have worked on vehicles for years, I've virtually no experience with the modern electronic systems.
I've had a DPF issue and hoped this would help work out what is going on. Unfortunately, it seems there are a couple of faults
My main issue is DPF Bank 1. My local garage is not AUDI but tried 4 forced regens. This dropped everything to fine limits for 5 days before the engine management light was back on. They are stumped and hadn't seen a dual sensor DPF before so aren't sure how to progress or what the fault really is (replace the DPF?).
Then comes the Instrument Cluster. Seems it has no basic coding?
Next is the AC. This was fine until a week ago and now won't operate. Is this needing the system refilled or a new sensor and if a sensor, where is it hidden?
Last is the fuel cap and flap. Seems there's a short to ground and I should check the wiring. Any assistance on the location of the wiring would be appreciated.
Thank you all in advance your your help!
I've had a DPF issue and hoped this would help work out what is going on. Unfortunately, it seems there are a couple of faults
My main issue is DPF Bank 1. My local garage is not AUDI but tried 4 forced regens. This dropped everything to fine limits for 5 days before the engine management light was back on. They are stumped and hadn't seen a dual sensor DPF before so aren't sure how to progress or what the fault really is (replace the DPF?).
Then comes the Instrument Cluster. Seems it has no basic coding?
Next is the AC. This was fine until a week ago and now won't operate. Is this needing the system refilled or a new sensor and if a sensor, where is it hidden?
Last is the fuel cap and flap. Seems there's a short to ground and I should check the wiring. Any assistance on the location of the wiring would be appreciated.
Thank you all in advance your your help!
Code:
hassis Type: 4G-AU57 (4G5)
Scan: 01 03 05 08 09 10 15 16 17 19 3B 42 44 46 52 53 5F 62 6D 72
AC
VIN: WAUZZZ4G4EN187470 Mileage: 177944km-110569miles
01-Engine -- Status: Malfunction 0010
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: Malfunction 0010
19-CAN Gateway -- Status: OK 0000
3B-Sensor Elect. -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
5F-Information Electr. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
6D-Trunk Elect. -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
AC-Reductant Control -- Status: OK 000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CNHA) Labels:. 04L-907-309-V1.clb
Part No SW: 04L 906 021 FE HW: 04L 907 309
Component: R4 2,0L EDC H23 8243
Revision: 85H23---
Coding: 12194012242401080000
Shop #: WSC 24297 000 1048576
ASAM Dataset: EV_ECM20TDI01104L906021FE 002007
ROD: EV_ECM20TDI01104L906021FE_002.rod
VCID: 6D9221EEBCE5832CC3-8038
1 Fault Found:
19226 - Particulate Trap Bank 1
P2002 00 [101] - Efficiency Below Threshold
Not Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 4
Mileage: 177746 km
Date: 2018.03.13
Time: 08:53:49
Engine speed: 1670.00 /min
Normed load value: 63.9 %
Vehicle speed: 61 km/h
Coolant temperature: 82 °C
Intake air temperature: 70 °C
Ambient air pressure: 990 mbar
Voltage terminal 30: 14.400 V
Unlearning counter according OBD: 40
Exhaust mass flow of low-pressure EGR: calculated: 3.015
Differential pressure ratio: low-pressure EGR: 24.5 kg/h
Exh.recircul. 2: differential pres.sensor 1 bank 1: adap. value: 30.4 hPa
Exhaust recirculat.2: different.press.sens.1 bank 1: raw value: 29.1 hPa
Exh.recircul.valve 1 bank 1: pos.feedback - Act.value: 64.10 %
Exhaust recirc.valve 2 bank 1: posit.feedback - Act.value: 40.28 %
Exh. gas recirc. 2: diff. press. sensor 1 bank 1: dyn. value: 31.0 hPa
Readiness: 0 0 0 0 0
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:* None
Part No SW: 4G0 820 043 BA HW: 4G0 820 043 BA
Component: KLIMA 2 ZONEN H14 0096
Serial number: 11071400110129
Coding: 3422090821
Shop #: WSC 02391 785 00200
ASAM Dataset: EV_AirCondiBasisUDS 004002
ROD: EV_AirCondiBasisUDS_004.rod
VCID: 5F8E4B264649E1BC41-800A
1 Fault Found:
0267 - Sensor for Refrigerant Pressure and Temperature
B10C2 21 [009] - Signal Amplitude Too Low
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 7
Fault Frequency: 4
Reset counter: 216
Mileage: 177738 km
Date: 2018.03.13
Time: 08:26:17
Compressor current: actual value: 0 mA
Outside air temperature: 6.0 °C
Temperature after evaporator: 4.64 °C
Engine speed: 981 /min
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:. 4H0-920-xxx-17.clb-SRI1
Part No SW: 4G8 920 950 S HW: 4G8 920 950 S
Component: MDieGb H43 0411
Revision: 27450259 Serial number: 658160714592048
Coding: 33A4120003412600010000
Shop #: WSC 02391 785 00200
ASAM Dataset: EV_RBC7KMID 004048
ROD: EV_RBC7KMID.rod
VCID: 3FCEABA6A609C1BC21-806A
1 Fault Found:
1048578 - No Basic Setting
B2010 00 [009] - -
[Steuergerät keine oder falsche Grundeinstellung / Adaption]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 1
Reset counter: 208
Mileage: 177719 km
Date: 2018.03.12
Time: 09:24:49
-------------------------------------------------------------------------------
Address 46: Central Conv. (J393) Labels:. 4H0-907-064-46.clb
Part No SW: 4H0 907 064 FH HW: 4H0 907 064 EH
Component: BCM2 2.0 H36 0551
Revision: 00002001 Serial number: 0340547598
Coding: 013B0622A0B930408320090400010F470000000000000000000000000000
Shop #: WSC 02391 785 00200
VCID: 74A4348AD7CF52E40C-8020
Subsystem 1 - Part No: 4G0 951 177
Component: DWA-Sensor H01 0010
Subsystem 2 - Part No: 1K0 951 605 C
Component: LIN BACKUP HO H05 1501
2 Faults Found:
02616 - Fuel Tank Cap; Unlock
009 - Open or Short to Ground
Freeze Frame:
Fault Status: 01101001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 208
Mileage: 177719 km
Time Indication: 0
Date: 2018.03.12
Time: 09:59:06
02615 - Fuel Tank Cap; Lock
009 - Open or Short to Ground
Freeze Frame:
Fault Status: 01101001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 208
Mileage: 177719 km
Time Indication: 0
Date: 2018.03.12
Time: 09:59:22
