Page 1 of 2 12 LastLast
Results 1 to 10 of 12

Thread: 2004 VW Touareg V10 Brain Dead and No Start

  1. #1
    Verified VCDS User
    Join Date
    Jun 2017
    Location
    USA
    Posts
    5
    Post Thanks / Like

    2004 VW Touareg V10 Brain Dead and No Start

    Hello,

    I've posted this call for help on the ClubTouareg forum, but figured that I would get some helpful input from here as well.

    Looking for some assistance and advice regarding a non-starting and brain dead 2004 V10 (I've already read every existing thread on ClubTouareg and several on here related to this issue from start to finish).

    The symptoms began as intermittent non-starting: with key on only some of the dash would come to life (not all of the gauges would work), and turning the key to starting position would result in nothing happening. Sometimes the key would not be released from ignition and shifter could not be moved into neutral. Time and/or several tries later and eventually it would start.

    Currently with the key on, only some of the dash comes to life: the screen comes up, but does not show all of the typical pre-start icons (like glow plugs), and non of the gauges come on. Turning the key to start does nothing. The shift lever is usable and the key can be removed.

    There must have been a constant parasitic draw on the batteries because eventually they went dead. Both batteries are less than 1 year old (sized properly according to threads on here) and have been removed from the vehicle and load tested as good. They have been re-charged and re-installed.

    I have attached a vagcom scan (done prior to steps taken below). This is my first time using one so I could use help interpreting it. The main issue appears to be that there is no communication with the ECM at all. I understand that many/most of the dtc's are probably related to the dead battery. But, due to the lack of communication with the ECM, I do not know how to clear all of them in order to run a new scan. Help?

    What has been tried so far:
    1) All fuses checked (drivers side, passenger side, and in engine bay).
    2) Wiring harness under driver's floor board carpet checked. No visible sign of corrosion, but all splices were re-spliced.
    3) Batteries load tested, re-charged, and re-installed.
    4) Clean dirt and debris away from wiper area.
    5) Removed and inspected ECM's- no visible sign of water or damage on plugs (did not open cases). Cleaned electrical plugs on both.
    5) Checked starting requirements to start - found bad brake light switch and replaced.
    6) Checked door handles- passenger door black button does not work. Plan on disconnecting wire harness to all door handles if necessary, but not done yet.
    7) Kessy removed and repaired. The two MOSFETs were replaced (they appeared to be stuck open, but not burned up). The resistors all checked OK.

    Re-installed the repaired Kessy, the new brake light switch, and the re-charged batteries. No change in status- still brain dead and vagcom says no communication with ECM.

    Now the stock alarm system is acting up. While working on the car with the driver's door open and the key sitting on the seat the alarm has been arming itself and locking the doors. This is the first time it has ever done this.

    Any input to help me get this beast running would be greatly appreciated!

    Code:
    --------------------------------   I cleared the dtc's but none in the engine controler becuase of lack of communication so still no start.
    --------------------------------------------------------------------------------
    
    
    Chassis Type: 7L - VW Touareg (2003 > 11/2006)
    Scan: 01 02 03 05 06 08 09 11 13 15 16 17 18 19 1C 22 29 32 34 36
              37 39 3C 46 47 55 56 57 64 65 68 69 6C 6D 6E 75 76 77
     
    -------------------------------------------------------------------------------
    Address 02: Auto Trans        Labels: 09D-927-750.lbl
       Part No: 09D 927 750 L
       Component: AL 600 6Q           0447  
       Coding: 0004153
       Shop #: WSC 31414 000 00000
       VCID: 377633F44522CFF918-5102
    
    1 Fault Found:
    01314 - Engine Control Module ????????????????????????????????
                004 - No Signal/Communication - MIL ON
    
    -------------------------------------------------------------------------------
    Address 05: Acc/Start Auth.        Labels: 3D0-909-13x-05.lbl
       Part No SW: 3D0 909 135 M    HW: 5WK 470 26
       Component:    Kessy            6400  
       Coding: 0131304
       Shop #: WSC 31414 000 00000
       VCID: 2F660B94BD72073940-5102
    
       Subsystem 1 - Part No: XXXXXXXXXXX 
       Component: ELV                 XXXX
    
    11 Faults Found:
    00180 - Access/Start Authorization Antenna; Passenger Side (R135) 
                011 - Open Circuit
    00179 - Access/Start Authorization Antenna; Drivers Side (R134) 
                011 - Open Circuit
    00181 - Access/Start Authorization Antenna (in Rear bumper) (R136) 
                011 - Open Circuit
    00955 - Key 1 
                002 - Lower Limit Exceeded - Intermittent
    00087 - Terminal 30 for Starting Relevant Consumers************************************? 
                009 - Open or Short to Ground
    00185 - Control Circuit; Relay for Supply Voltage Terminal 15 
                009 - Open or Short to Ground - Intermittent
    01299 - Diagnostic Interface for Data Bus (J533) 
                005 - No or Incorrect Basic Setting / Adaptation
    00184 - Control Circuit for Engine Start/Stop Switch****************************?
                007 - Short to Ground - Intermittent
    01314 - Engine Control Module*******************************************? 
                004 - No Signal/Communication
    01321 - Control Module for Airbags (J234) 
                004 - No Signal/Communication
    00668 - Supply Voltage Terminal 30 
                002 - Lower Limit Exceeded
    
    -------------------------------------------------------------------------------
    Address 06: Seat Mem. Pass        Labels: None
       Part No: 7L0 959 760 
       Component: Sitzverstellung     0701  
       Shop #: WSC 00000 000 00000
       VCID: 77F6F3F405A20FF9D8-5102
    
    1 Fault Found:
    00668 - Supply Voltage Terminal 30 
                002 - Lower Limit Exceeded - Intermittent
    
    -------------------------------------------------------------------------------
    Address 08: Auto HVAC        Labels: 7L6-907-044.clb
       Part No: 7L6 907 044 F
       Component: CLIMAtronic 2+2   X 2715  
       Coding: 0001030
       Shop #: WSC 31414 000 00000
       VCID: 377633F44522CFF918-5102
    
       Subsystem 1 - Part No: 7L6 907 049 C
       Component: CLIMAtronic FOND  X 0306
    
    3 Faults Found:
    00819 - High Pressure Sensor (G65) 
                009 - Open or Short to Ground
    01336 - Company Data Bus for Comfort System 
                004 - No Signal/Communication
    00352 - Terminal 30A 
                002 - Lower Limit Exceeded
    
    -------------------------------------------------------------------------------
    Address 09: Cent. Elect.        Labels: 7Lx-937-049-V1.clb
       Part No: 7L6 937 049 L
       Component:                     2703  
       Coding: 0111839
       Shop #: WSC 23344 444 00889
       VCID: 458A493C0FCEAD699A-5102
    
    9 Faults Found:
    01498 - Bulb for Parking Lamps; Right (M3) 
                010 - Open or Short to Plus - Intermittent
    00062 - Suspension Function Request 
                007 - Short to Ground - Intermittent
    00070 - Starting Battery Voltage 
                008 - Implausible Signal
    00668 - Supply Voltage Terminal 30 *************************************
                008 - Implausible Signal - Intermittent
    00576 - Terminal 15 ************************************************
                008 - Implausible Signal
    01517 - Control Module for Trailer/Towing Sensor (J345) 
                014 - Defective
    00466 - Control Module for Steering Column Electronics (J527) 
                004 - No Signal/Communication - Intermittent
    00907 - Intervention load Management 
                000 -  - 
    02196 - Fuse for Control Module for Power Supply to Vehicle Battery (S287)   **************************
                014 - Defective - Intermittent
    
    -------------------------------------------------------------------------------
    Address 16: Steering wheel        Labels: 7L6-953-549.lbl
       Part No: 7L6 953 549 E
       Component: Lenksäulenmodul     3301  
       Coding: 0000232
       Shop #: WSC 31414 000 00000
       VCID: 41825D2C1BE68149A6-5102
    
    2 Faults Found:
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent
    01336 - Company Data Bus for Comfort System 
                004 - No Signal/Communication - Intermittent
    
    -------------------------------------------------------------------------------
    Address 18: Aux. Heat        Labels: 7L6-819-008.lbl
       Part No: 7L6 819 008 B
       Component: Standheizung  E1MAC 0235  
       Coding: 0000030
       Shop #: WSC 31414 000 00000
       VCID: 356A39FC5F2E3DE90A-5102
    
    5 Faults Found:
    00667 - Ambient Temperature Signal 
                008 - Implausible Signal
    00664 - Fuel gauge 
                002 - Lower Limit Exceeded
    01126 - Engine Speed Signal 
                008 - Implausible Signal
    01321 - Control Module for Airbags (J234) 
                004 - No Signal/Communication
    01177 - Engine Control Unit *****************************************************
                004 - No Signal/Communication
    
    -------------------------------------------------------------------------------
    Address 1C: Position Sensing        Labels: 7L6-919-879.lbl
       Part No: 7L6 919 879 
       Component: JCI PathPoint       1600  
       Shop #: WSC 00000 000 00000
       VCID: 040C943844745461CD-5102
    
    1 Fault Found:
    00926 - Terminal 30 
                002 - Lower Limit Exceeded - Intermittent
    
    -------------------------------------------------------------------------------
    Address 22: AWD        Labels: None
       Part No: 0AD 927 755 BE
       Component: TRANSFERCASE        0122  
       Shop #: WSC 00000 000 00000
       VCID: 7F061BD42D9237B990-5102
    
    3 Faults Found:
    01314 - Engine Control Module 
                004 - No Signal/Communication
    01317 - Control Module in Instrument Cluster (J285) 
                004 - No Signal/Communication
    01336 - Company Data Bus for Comfort System 
                004 - No Signal/Communication
    
    -------------------------------------------------------------------------------
    Address 29: Left Light        Labels: 3D0-909-157.lbl
       Part No: 3D0 909 157 
       Component: EVG GDL+AutoLWR(l)  X012  
       Coding: 0000003
       Shop #: WSC 31414 000 00000
       VCID: 66C8AEB05208867173-5120
    
    1 Fault Found:
    00492 - Body Pitch Angle from Level Control Module 
                008 - Implausible Signal - Intermittent
    
    -------------------------------------------------------------------------------
    Address 32: Differential Locks        Labels: None
       Part No: 0AC 927 771 B
       Component: SG-Quersperre       5018  
       Shop #: WSC 00000 000 00000
       VCID: 377633F44522CFF918-5102
    
    6 Faults Found:
    02412 - Differential Lock Rear 
                003 - Mechanical Failure
    01317 - Control Module in Instrument Cluster (J285) 
                004 - No Signal/Communication
    01312 - Powertrain Data Bus 
                014 - Defective
    02053 - Control Module for Transfer Case (J646) 
                004 - No Signal/Communication - Intermittent
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent
    01314 - Engine Control Module 
                004 - No Signal/Communication
    
    -------------------------------------------------------------------------------
    Address 36: Seat Mem. Drvr        Labels: None
       Part No: 7L0 959 760 
       Component: Sitzverstellung     0701  
       Shop #: WSC 00000 000 00000
       VCID: 77F6F3F405A20FF9D8-5102
    
    2 Faults Found:
    00668 - Supply Voltage Terminal 30 
                002 - Lower Limit Exceeded - Intermittent
    01317 - Control Module in Instrument Cluster (J285) 
                013 - Check DTC Memory
    
    -------------------------------------------------------------------------------
    Address 37: Navigation        Labels: 7L6-919-887-CD.lbl
       Part No: 7L6 919 887 B
       Component:      Navigation     0627  
       Coding: 0000002
       Shop #: WSC 31414 000 00000
       VCID: 458A493C0FCEAD699A-5102
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 39: Right Light        Labels: 3D0-909-158.lbl
       Part No: 3D0 909 158 
       Component: EVG GDL+AutoLWR(r)  X012  
       Coding: 0000003
       Shop #: WSC 31414 000 00000
       VCID: 67D6A3B455029F7948-5102
    
    1 Fault Found:
    00492 - Body Pitch Angle from Level Control Module 
                008 - Implausible Signal - Intermittent
    
    -------------------------------------------------------------------------------
    Address 46: Central Conv.        Labels: 7L0-959-933.lbl
       Part No: 7L0 959 933 E
       Component: 2N HSG              0201  
       Coding: 0000085
       Shop #: WSC 23344 444 00889
       VCID: 3E7826D06A18FEB1DB-FFFE
    
       Subsystem 1 - Part No: 7L0 959 701 B
       Component: Tuersteuergeraet FS 0201
    
       Subsystem 2 - Part No: 7L0 959 702 B
       Component: Tuersteuergeraet BF 0201
    
       Subsystem 3 - Part No: 7L0 959 703 B
       Component: Tuersteuergeraet HL 0201
    
       Subsystem 4 - Part No: 7L0 959 704 B
       Component: Tuersteuergeraet HR 0201
    
    22 Faults Found:
    00927 - Terminal 30 (Right) 
                011 - Open Circuit - Intermittent
    01516 - Terminal 30; Left 
                011 - Open Circuit - Intermittent
    00926 - Terminal 30 
                011 - Open Circuit - Intermittent
    00668 - Supply Voltage Terminal 30 
                002 - Lower Limit Exceeded - Intermittent
    00576 - Terminal 15 
                008 - Implausible Signal - Intermittent
    00893 - Switch for Trunk Handle (E234) 
                007 - Short to Ground - Intermittent
    00325 - Rear Window Opening Button (E361) 
                007 - Short to Ground - Intermittent
    01038 - Central Locking Thermal Protection 
                000 -  -  - Intermittent
    01134 - Alarm Horn (H12) 
                004 - No Signal/Communication - Intermittent
    00987 - Lamp for Brake Light; Left (M9) 
                009 - Open or Short to Ground
    00988 - Lamp for Brake Light; Right (M10) 
                009 - Open or Short to Ground
    01312 - Powertrain Data Bus 
                013 - Check DTC Memory
    01331 - Door Control Module; Driver Side (J386) 
                002 - Lower Limit Exceeded - Intermittent
    00932 - Electric Window Motor; Drivers Side (V147) 
                005 - No or Incorrect Basic Setting / Adaptation - Intermittent
    01332 - Door Control Module; Passenger Side (J387) 
                002 - Lower Limit Exceeded - Intermittent
    00486 - Front Passengers Outside Door Handle Central Locking Button (E370) 
                007 - Short to Ground
    01333 - Door Control Module; Rear Left (J388) 
                002 - Lower Limit Exceeded - Intermittent
    01333 - Door Control Module; Rear Left (J388) 
                014 - Defective
    00487 - Rear Left Outside Door Handle Central Locking Button (E371) 
                007 - Short to Ground - Intermittent
    00930 - Locking Module for Central Locking; Rear Left (F222) 
                008 - Implausible Signal - Intermittent
    01334 - Door Control Module; Rear Right (J389) 
                002 - Lower Limit Exceeded - Intermittent
    00488 - Rear Right Outside Door Handle Central Locking Button (E372) 
                007 - Short to Ground
    
    -------------------------------------------------------------------------------
    Address 47: Sound System        Labels: 7Lx-035-4xx-47.lbl
       Part No: 7L6 035 466 
       Component: 12K-AUDIOVERST      0108  
       Shop #: WSC 00000 000 00000
       VCID: 71E2CDEC6BC651C916-50E6
    
    1 Fault Found:
    00668 - Supply Voltage Terminal 30 
                002 - Lower Limit Exceeded - Intermittent
    
    -------------------------------------------------------------------------------
    Address 56: Radio        Labels: 7L6-035-186-CD.lbl
       Part No: 7L6 035 186 A
       Component:        Radio        0627  
       Coding: 0005077
       Shop #: WSC 00001 552 00000
       VCID: 31620DECAB4611C956-5102
    
    2 Faults Found:
    00668 - Supply Voltage Terminal 30 
                002 - Lower Limit Exceeded - Intermittent
    00857 - CD Changer Unit (R41) 
                003 - Mechanical Failure
    
    -------------------------------------------------------------------------------
    Address 65: Tire Pressure        Labels: 7L6-907-273.lbl
       Part No: 7L6 907 273 B
       Component: Reifendruckueberw.  0053  
       Coding: 0110320
       Shop #: WSC 00000 000 00000
       VCID: 377633F44522CFF918-5102
    
    2 Faults Found:
    01312 - Powertrain Data Bus 
                013 - Check DTC Memory - MIL ON
    02757 - Learning Tire Pressures 
                000 -  -  - MIL ON
    
    -------------------------------------------------------------------------------
    Address 68: Wiper Electr.        Labels: 7L0-955-119-V1.clb
       Part No: 7L0 955 119 F
       Component: Front Wiper         2416  
       Coding: 0000004
       Shop #: WSC 31414 000 376832
       VCID: 377633F44522CFF918-5102
    
    1 Fault Found:
    01299 - Diagnostic Interface for Data Bus (J533) 
                013 - Check DTC Memory
    
    -------------------------------------------------------------------------------
    Address 69: Trailer        Labels: 7L0-907-383-1D2.lbl
       Part No SW: 7L0 907 383 G    HW: 7L0 907 383 G
       Component: ANHAENGERELEKTRONIK 8854  
       Coding: 0000002
       Shop #: WSC 23344 444 00889
       VCID: 387430C8483CC08111-50E6
    
    1 Fault Found:
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Count: 0
                        Count: 0
    
    
    -------------------------------------------------------------------------------
    Address 6E: Ctrl Head Roof        Labels: None
       Part No: 7L6 919 044 G
       Component: DACHDISPLAY         0530  
       Revision: 00600530    Serial number: 2009268.03    
       Shop #: WSC 31414 000 00000
       VCID: 3B7E2FC4790AEB99FC-5102
    
    2 Faults Found:
    01305 - Databus for Infotainment 
                004 - No Signal/Communication - Intermittent
    00446 - Function Limitation due to Under-Voltage 
                002 - Lower Limit Exceeded - Intermittent
    
    -------------------------------------------------------------------------------
    Address 75: Telematics        Labels: 3D0-035-617.lbl
       Part No SW: 3D0 035 617 B    HW: 3D0 035 617 B
       Component: Telematik NAR1      0104  
       Coding: 0076510
       Shop #: WSC 07403 444 00051
       VCID: 1F46FB54CDD297B9F0-5102
    
    2 Faults Found:
    01321 - Control Module for Airbags (J234) 
                004 - No Signal/Communication - MIL ON
    00668 - Supply Voltage Terminal 30 
                002 - Lower Limit Exceeded - Intermittent
    
    -------------------------------------------------------------------------------
    Address 76: Park Assist        Labels: Redir Fail!
       Part No: 7L0 919 283 F
       Component: 0J Einparkhilfe     1108  
       Shop #: WSC 00000 000 00000
       VCID: 397235CC7336D989EE-5102
    
    1 Fault Found:
    01299 - Diagnostic Interface for Data Bus (J533) 
                013 - Check DTC Memory
    
    End-------------------------(Elapsed Time: 08:50)--------------------------
    
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 02: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 05: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 06: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 08: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 09: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 16: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 18: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 1C: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 22: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 29: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 32: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 36: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 37: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 39: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 46: DTCs cleared
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Chassis Type: 7L - VW Touareg (2003 > 11/2006)
    Scan: 01 02 03 05 06 08 09 11 13 15 16 17 18 19 1C 22 29 32 34 36
              37 39 3C 46 47 55 56 57 64 65 68 69 6C 6D 6E 75 76 77
     
    -------------------------------------------------------------------------------
    Address 02: Auto Trans        Labels: 09D-927-750.lbl
       Part No: 09D 927 750 L
       Component: AL 600 6Q           0447  
       Coding: 0004153
       Shop #: WSC 31414 000 00000
       VCID: 377633F44522CFF918-5102
    
    1 Fault Found:
    01314 - Engine Control Module 
                004 - No Signal/Communication - MIL ON
    
    -------------------------------------------------------------------------------
    Address 05: Acc/Start Auth.        Labels: 3D0-909-13x-05.lbl
       Part No SW: 3D0 909 135 M    HW: 5WK 470 26
       Component:    Kessy            6400  
       Coding: 0131304
       Shop #: WSC 31414 000 00000
       VCID: 2F660B94BD72073940-50E6
    
       Subsystem 1 - Part No: XXXXXXXXXXX 
       Component: ELV                 XXXX
    
    3 Faults Found:
    01314 - Engine Control Module *******************************
                004 - No Signal/Communication
    01299 - Diagnostic Interface for Data Bus (J533) 
                013 - Check DTC Memory
    01321 - Control Module for Airbags (J234)*********************
                004 - No Signal/Communication
    
    -------------------------------------------------------------------------------
    Address 06: Seat Mem. Pass        Labels: None
       Part No: 7L0 959 760 
       Component: Sitzverstellung     0701  
       Shop #: WSC 00000 000 00000
       VCID: 77F6F3F405A20FF9D8-5102
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 08: Auto HVAC        Labels: 7L6-907-044.clb
       Part No: 7L6 907 044 F
       Component: CLIMAtronic 2+2   X 2715  
       Coding: 0001030
       Shop #: WSC 31414 000 00000
       VCID: 377633F44522CFF918-50E6
    
       Subsystem 1 - Part No: 7L6 907 049 C
       Component: CLIMAtronic FOND  X 0306
    
    1 Fault Found:
    00819 - High Pressure Sensor (G65) 
                009 - Open or Short to Ground
    
    -------------------------------------------------------------------------------
    Address 09: Cent. Elect.        Labels: 7Lx-937-049-V1.clb
       Part No: 7L6 937 049 L
       Component:                     2703  
       Coding: 0111839
       Shop #: WSC 23344 444 00889
       VCID: 458A493C0FCEAD699A-5102
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 16: Steering wheel        Labels: 7L6-953-549.lbl
       Part No: 7L6 953 549 E
       Component: Lenksäulenmodul     3301  
       Coding: 0000232
       Shop #: WSC 31414 000 00000
       VCID: 41825D2C1BE68149A6-5102
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 18: Aux. Heat        Labels: 7L6-819-008.lbl
       Part No: 7L6 819 008 B
       Component: Standheizung  E1MAC 0235  
       Coding: 0000030
       Shop #: WSC 31414 000 00000
       VCID: 356A39FC5F2E3DE90A-50E6
    
    2 Faults Found:
    01321 - Control Module for Airbags (J234) 
                004 - No Signal/Communication
    01177 - Engine Control Unit ****************************
                004 - No Signal/Communication
    
    -------------------------------------------------------------------------------
    Address 1C: Position Sensing        Labels: 7L6-919-879.lbl
       Part No: 7L6 919 879 
       Component: JCI PathPoint       1600  
       Shop #: WSC 00000 000 00000
       VCID: 040C943844745461CD-5102
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 22: AWD        Labels: None
       Part No: 0AD 927 755 BE
       Component: TRANSFERCASE        0122  
       Shop #: WSC 00000 000 00000
       VCID: 7F061BD42D9237B990-5120
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 29: Left Light        Labels: 3D0-909-157.lbl
       Part No: 3D0 909 157 
       Component: EVG GDL+AutoLWR(l)  X012  
       Coding: 0000003
       Shop #: WSC 31414 000 00000
       VCID: 66C8AEB05208867173-5120
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 32: Differential Locks        Labels: None
       Part No: 0AC 927 771 B
       Component: SG-Quersperre       5018  
       Shop #: WSC 00000 000 00000
       VCID: 377633F44522CFF918-5120
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 36: Seat Mem. Drvr        Labels: None
       Part No: 7L0 959 760 
       Component: Sitzverstellung     0701  
       Shop #: WSC 00000 000 00000
       VCID: 77F6F3F405A20FF9D8-5102
    
    1 Fault Found:
    01317 - Control Module in Instrument Cluster (J285) 
                013 - Check DTC Memory
    
    -------------------------------------------------------------------------------
    Address 37: Navigation        Labels: 7L6-919-887-CD.lbl
       Part No: 7L6 919 887 B
       Component:      Navigation     0627  
       Coding: 0000002
       Shop #: WSC 31414 000 00000
       VCID: 458A493C0FCEAD699A-5102
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 39: Right Light        Labels: 3D0-909-158.lbl
       Part No: 3D0 909 158 
       Component: EVG GDL+AutoLWR(r)  X012  
       Coding: 0000003
       Shop #: WSC 31414 000 00000
       VCID: 67D6A3B455029F7948-5120
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 46: Central Conv.        Labels: 7L0-959-933.lbl
       Part No: 7L0 959 933 E
       Component: 2N HSG              0201  
       Coding: 0000085
       Shop #: WSC 23344 444 00889
       VCID: 3E7826D06A18FEB1DB-FFFE
    
       Subsystem 1 - Part No: 7L0 959 701 B
       Component: Tuersteuergeraet FS 0201
    
       Subsystem 2 - Part No: 7L0 959 702 B
       Component: Tuersteuergeraet BF 0201
    
       Subsystem 3 - Part No: 7L0 959 703 B
       Component: Tuersteuergeraet HL 0201
    
       Subsystem 4 - Part No: 7L0 959 704 B
       Component: Tuersteuergeraet HR 0201
    
    22 Faults Found:
    00927 - Terminal 30 (Right) ****************
                011 - Open Circuit - Intermittent
    01516 - Terminal 30; Left 
                011 - Open Circuit - Intermittent
    00926 - Terminal 30 
                011 - Open Circuit - Intermittent
    00668 - Supply Voltage Terminal 30 
                002 - Lower Limit Exceeded - Intermittent
    00576 - Terminal 15 
                008 - Implausible Signal - Intermittent
    00893 - Switch for Trunk Handle (E234) 
                007 - Short to Ground - Intermittent
    00325 - Rear Window Opening Button (E361) 
                007 - Short to Ground - Intermittent
    01038 - Central Locking Thermal Protection 
                000 -  -  - Intermittent
    01134 - Alarm Horn (H12) 
                004 - No Signal/Communication - Intermittent
    00987 - Lamp for Brake Light; Left (M9) 
                009 - Open or Short to Ground
    00988 - Lamp for Brake Light; Right (M10) 
                009 - Open or Short to Ground
    01312 - Powertrain Data Bus 
                013 - Check DTC Memory
    01331 - Door Control Module; Driver Side (J386) 
                002 - Lower Limit Exceeded - Intermittent
    00932 - Electric Window Motor; Drivers Side (V147) 
                005 - No or Incorrect Basic Setting / Adaptation - Intermittent
    01332 - Door Control Module; Passenger Side (J387) 
                002 - Lower Limit Exceeded - Intermittent
    00486 - Front Passengers Outside Door Handle Central Locking Button (E370) 
                007 - Short to Ground
    01333 - Door Control Module; Rear Left (J388) 
                002 - Lower Limit Exceeded - Intermittent
    01333 - Door Control Module; Rear Left (J388) 
                014 - Defective
    00487 - Rear Left Outside Door Handle Central Locking Button (E371) 
                007 - Short to Ground - Intermittent
    00930 - Locking Module for Central Locking; Rear Left (F222) 
                008 - Implausible Signal - Intermittent
    01334 - Door Control Module; Rear Right (J389) 
                002 - Lower Limit Exceeded - Intermittent
    00488 - Rear Right Outside Door Handle Central Locking Button (E372) 
                007 - Short to Ground
    
    
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
                    Address 09: Cent. Elect.       Labels: 7Lx-937-049-V1.clb
    Control Module Part Number: 7L6 937 049 L
      Component and/or Version:                     2703
               Software Coding: 0111839
                Work Shop Code: WSC 23344 444 00889
                          VCID: 458A493C0FCEAD699A-5102
    3 Faults Found:
    
    00576 - Terminal 15 
                008 - Implausible Signal
    01517 - Control Module for Trailer/Towing Sensor (J345) 
                014 - Defective
    00907 - Intervention load Management 
                000 -  - 
    
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Address 09: DTCs cleared

  2. Likes Boki Ar, ivagp liked this post
  3. #2
    VCDS Distributor Boki Ar's Avatar
    Join Date
    Oct 2014
    Location
    Arandjelovac, Serbia
    Posts
    1,110
    Post Thanks / Like
    Welcome aboard !

  4. Likes Jack@European_Parts liked this post
  5. #3
    NostraJackAss Jack@European_Parts's Avatar
    Join Date
    Jan 2014
    Location
    1001 State Route 17K Montgomery New York 12549
    Posts
    16,173
    Post Thanks / Like
    Yes welcome....
    I seriously request you remove the master ecu and see if the slave wakes up.
    Please verify the internals of the ECU's in addition to ecu supply relays and load reduction relays + ignition switch.
    Verify terminals 15 & 30 & ground 31 @ controllers directly and K lines using WD in RTFB.

    0x17 & 0x19 for cluster and gateway are also offline so these must be checked first as a combination unit.
    European Parts Emporium/Performance / Immobilizer Solutions EPE
    Certified Master Trained NY/BAR/BAD 7076062/ASE/SAE/NASTF Legal Factory Authorized/Licensed GeKo/FaZit # 403738
    Specializing in Custom Services IE: "welding-fabrication" / EPA-SMOG Update or Pass-Thru-Programming / Data Transfer / Immobilizers & OEM Quality Parts
    Above Magic! No Written record, AUTO-SCAN or Appointment = NO HELP!
    www.FixMyEuro.com <<<<<CLICK HERE! or vwemporium@aol.com ( JPPSG & Unverified members need not PM me & Please don't email or call facility for free tech support...use the forum )
    Getting you CONTROL again of your property - TAKE IT! In Conjunction with.........

  6. Likes Uwe, Boki Ar liked this post
  7. #4
    Verified VCDS User
    Join Date
    Jun 2017
    Location
    USA
    Posts
    5
    Post Thanks / Like
    Jack- thank you for the help!

    I've got a question about the ECU's- I was under the impression that the horizontally mounted one was the master and the vertically mounted one was the slave. However there is a hand written note in sharpie on the horizontally mounted one that says "slave". Can you please help me confirm which one is supposed to be the master?

    You indicate to check the supply and load reduction relay. Are there instructions somewhere for how to test a relay?

  8. #5
    NostraJackAss Jack@European_Parts's Avatar
    Join Date
    Jan 2014
    Location
    1001 State Route 17K Montgomery New York 12549
    Posts
    16,173
    Post Thanks / Like
    All in the RTFB but you could unplug one ecu at a time and query each ECU in VCDS until you rule it out.

    0x01 verse 0x11
    European Parts Emporium/Performance / Immobilizer Solutions EPE
    Certified Master Trained NY/BAR/BAD 7076062/ASE/SAE/NASTF Legal Factory Authorized/Licensed GeKo/FaZit # 403738
    Specializing in Custom Services IE: "welding-fabrication" / EPA-SMOG Update or Pass-Thru-Programming / Data Transfer / Immobilizers & OEM Quality Parts
    Above Magic! No Written record, AUTO-SCAN or Appointment = NO HELP!
    www.FixMyEuro.com <<<<<CLICK HERE! or vwemporium@aol.com ( JPPSG & Unverified members need not PM me & Please don't email or call facility for free tech support...use the forum )
    Getting you CONTROL again of your property - TAKE IT! In Conjunction with.........

  9. #6
    Verified VCDS User
    Join Date
    Jun 2014
    Location
    USA
    Posts
    128
    Post Thanks / Like
    Have you checked the relay under the driver's seat for copper showing thru the sight glass?
    Also, Bentley has dire warnings about electrical system damage on 2004's if proper seguence of batt connection is not followed. They say front batt must be first disconnected and last reconnected.

  10. #7
    Verified VCDS User
    Join Date
    Jun 2017
    Location
    USA
    Posts
    5
    Post Thanks / Like
    I'm in need of some brain power from the fantastic collective that is this forum.....

    The current diagnosis is that the two ECM's are not being powered/activated at all. Based on this, the thought is that the ignition and/or the kessy is bad.

    The kessy has been "repaired" by replacing the bad mosfets, however that should only fix the door handle portion of the kessy - if there is a more serious problem with it related to start/activation/immobilization then it would most likely need to be replaced.

    Due to these items being tied to the key programming, any of this work will now have to be done by a dealer. The dealer claiming that if they replace both of those they would need to replace the cluster, both pcms, door locks etc.

    Am I correct that there is a way around the requirement of having to replace the door locks. They could simply be unplugged behind the door panel (deactivating the touch/unlock function), correct? As long as the key fob could still be used to lock/unlock the car, I am fine with that.

    Are they correct that both PCMs would have to be replaced (I am assuming these are what I've been referring to as ECM's). Is there some work around for that?

    How about the cluster? Any work around for that?

  11. #8
    NostraJackAss Jack@European_Parts's Avatar
    Join Date
    Jan 2014
    Location
    1001 State Route 17K Montgomery New York 12549
    Posts
    16,173
    Post Thanks / Like
    I'm in need of some brain power from the fantastic collective that is this forum.....

    The current diagnosis is that the two ECM's are not being powered/activated at all. Based on this, the thought is that the ignition and/or the kessy is bad.

    The kessy has been "repaired" by replacing the bad mosfets, however that should only fix the door handle portion of the kessy - if there is a more serious problem with it related to start/activation/immobilization then it would most likely need to be replaced.

    Due to these items being tied to the key programming, any of this work will now have to be done by a dealer. The dealer claiming that if they replace both of those they would need to replace the cluster, both pcms, door locks etc.

    Am I correct that there is a way around the requirement of having to replace the door locks. They could simply be unplugged behind the door panel (deactivating the touch/unlock function), correct? As long as the key fob could still be used to lock/unlock the car, I am fine with that.

    Are they correct that both PCMs would have to be replaced (I am assuming these are what I've been referring to as ECM's). Is there some work around for that?

    How about the cluster? Any work around for that?

    Nope what they state is BS and yeah there is indeed work around.

    Immo defeat of ECU set Master/Slave for one.

    Data transfer of kessy existing to new or used unit supplied or one purchased.

    What is condition of ECU fuses and ecu supply relay terminal 15 and 30 & at the ecu's directly?

    but all splices were re-spliced
    WHY?
    Last edited by Jack@European_Parts; 09-12-2017 at 11:25 AM.
    European Parts Emporium/Performance / Immobilizer Solutions EPE
    Certified Master Trained NY/BAR/BAD 7076062/ASE/SAE/NASTF Legal Factory Authorized/Licensed GeKo/FaZit # 403738
    Specializing in Custom Services IE: "welding-fabrication" / EPA-SMOG Update or Pass-Thru-Programming / Data Transfer / Immobilizers & OEM Quality Parts
    Above Magic! No Written record, AUTO-SCAN or Appointment = NO HELP!
    www.FixMyEuro.com <<<<<CLICK HERE! or vwemporium@aol.com ( JPPSG & Unverified members need not PM me & Please don't email or call facility for free tech support...use the forum )
    Getting you CONTROL again of your property - TAKE IT! In Conjunction with.........

  12. #9
    Verified VCDS User
    Join Date
    Jun 2017
    Location
    USA
    Posts
    5
    Post Thanks / Like
    Jack- I always seem to have a hard time deciphering your responses!

    Quote Originally Posted by Jack@European_Parts View Post
    Nope what they state is BS and yeah there is indeed work around.

    Immo defeat of ECU set Master/Slave for one.
    I do not understand this one at all. I'm not familiar enough to know what "immo defeat" is or means nor the master/slave part. Could you explain/clarify what I need to know regarding this in order to have a semi-intelligent conversation with the dealer about it?

    Quote Originally Posted by Jack@European_Parts View Post
    Data transfer of kessy existing to new or used unit supplied or one purchased.
    I will find out if the dealer is capable and willing to do this.

    Quote Originally Posted by Jack@European_Parts View Post
    What is condition of ECU fuses and ecu supply relay terminal 15 and 30 & at the ecu's directly?
    All of the fuses in the dirver's, passenger's, and engine bay firewall driver's side were OK. Are there other specific ECU fuses that need to be checked? If so, where are they located? Let me find out regarding the supply terminals.
    Last edited by Uwe; 09-12-2017 at 12:12 PM. Reason: Fixed quotes

  13. #10
    NostraJackAss Jack@European_Parts's Avatar
    Join Date
    Jan 2014
    Location
    1001 State Route 17K Montgomery New York 12549
    Posts
    16,173
    Post Thanks / Like
    I do not understand this one at all. I'm not familiar enough to know what "immo defeat" is or means nor the master/slave part. Could you explain/clarify what I need to know regarding this in order to have a semi-intelligent conversation with the dealer about it?
    Master ( Main engine ecu 0x01 )
    Slave ( Second engine ecu 0x11 )

    Immo defeat will not be offered at a "dealer", nor "data transfer", so no point in that conversation with them.
    Immobilzer defeat is when we program the ECU set to ignore the high security key crap and Kessy and just run.


    All of the fuses in the dirver's, passenger's, and engine bay firewall driver's side were OK. Are there other specific ECU fuses that need to be checked? If so, where are they located? Let me find out regarding the supply terminals.
    The Repair manual ( RTFB ) and using wire diagram ( WD ) to identify power sources/terminal identifiers or grounds.

    DINS

    Sorry don't mean to be cryptic.

    JPPSG
    http://forums.ross-tech.com/showthre...uot-JPPSG-quot

    http://forums.ross-tech.com/showthre...ut-0x01-08-000

    www.bosch-classic.com/media/en/bosch_classic/.../klemmenbezeichnungen.pdf


    https://en.wikipedia.org/wiki/DIN_72552
    Last edited by Jack@European_Parts; 09-12-2017 at 01:20 PM.
    European Parts Emporium/Performance / Immobilizer Solutions EPE
    Certified Master Trained NY/BAR/BAD 7076062/ASE/SAE/NASTF Legal Factory Authorized/Licensed GeKo/FaZit # 403738
    Specializing in Custom Services IE: "welding-fabrication" / EPA-SMOG Update or Pass-Thru-Programming / Data Transfer / Immobilizers & OEM Quality Parts
    Above Magic! No Written record, AUTO-SCAN or Appointment = NO HELP!
    www.FixMyEuro.com <<<<<CLICK HERE! or vwemporium@aol.com ( JPPSG & Unverified members need not PM me & Please don't email or call facility for free tech support...use the forum )
    Getting you CONTROL again of your property - TAKE IT! In Conjunction with.........

Tags for this Thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •