Page 2 of 2 FirstFirst 12
Results 11 to 15 of 15

Thread: Audi S3 8V new rear brake discs, callipers and line locks fitted - now EPB fault

  1. #11
    Administrator Andy's Avatar
    Join Date
    Jan 2014
    Location
    Sector 7G
    Posts
    2,591
    Post Thanks / Like
    Please post the complete AutoScan since it will show us more info about the car, even if you don't think it would be relevant.,

    Next, are you able to successfully run the Basic Settings for Start Lining Change mode and End Lining Change mode as described here?

    http://wiki.ross-tech.com/wiki/index...#Basic_Setting

  2. Likes Uwe, Jack@European_Parts, Flatcap liked this post
  3. #12
    NostraJackAss Jack@European_Parts's Avatar
    Join Date
    Jan 2014
    Location
    1001 State Route 17K Montgomery New York 12549
    Posts
    19,197
    Post Thanks / Like
    You need to start over............

    Do you have the SSP and Repair manual?

    Are your line locks interfering with the function?

    I hate retrofits and technically this is where this belongs not being general car repair.

    I bet you didn't default the module and basic brake settings......... and just retracted like doing brake pads.......?

    First you need to make sure the park brake motors work and move the calipers in and out manually!

    Move the calipers all the way in manually relaxed bottom out.....then clear DTC's and trace if with fault or replace module from frying due to failing to use a battery charger or bug in module.

    Once faults for shorts are rectified setup module for new install.

    Posting a complete auto-scan & PR codes is absolutely always relevant because it gives us details you negate, as does the JPPSG.

    http://forums.ross-tech.com/showthre...uot-JPPSG-quot

    Simulate/isolate the EBP function by leaving motors uninstalled from mechanical circuit and get module to operate without a fault!

    Watch video...... RTFB & JPPSG




    NostraJackAss Has Spoken!
    Last edited by Jack@European_Parts; 04-28-2017 at 09:20 AM.
    European Parts Emporium/Performance / Immobilizer Solutions EPE
    Certified Master Trained NY/BAR/BAD 7076062/ASE/SAE/NASTF Legal Factory Authorized/Licensed GeKo/FaZit # 403738
    Specializing in Custom Services IE: "welding-fabrication" / EPA-SMOG Update or Pass-Thru-Programming / Data Transfer / Immobilizers & OEM Quality Parts
    Above Magic! No Written record, AUTO-SCAN or Appointment = NO HELP!
    www.FixMyEuro.com <<<<<CLICK HERE! or vwemporium@aol.com ( JPPSG & Unverified members need not PM me & Please don't email or call facility for free tech support...use the forum )
    Getting you CONTROL again of your property - TAKE IT! In Conjunction with.........

  4. Likes Flatcap liked this post
  5. #13
    Verified VCDS User
    Join Date
    Apr 2017
    Location
    UK
    Posts
    8
    Post Thanks / Like
    Quote Originally Posted by Andy View Post
    Please post the complete AutoScan since it will show us more info about the car, even if you don't think it would be relevant.,

    Next, are you able to successfully run the Basic Settings for Start Lining Change mode and End Lining Change mode as described here?

    http://wiki.ross-tech.com/wiki/index...#Basic_Setting
    Thanks for your help.

    I have pasted the autoscan below - i hope ive done this correctly? I have run the start lining change and end lining change but still have the following faults:

    Code:
    Tuesday,23,May,2017,11:26:49:63578
    VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
    VCDS Version: 17.1.3.0 (x64)
    Data version: 20170320 DS267.7
    www.Ross-Tech.com
    
    Dealer/Shop Name: Kevin 
    
    VIN: WAUZZZ8V1G1022866   License Plate: 
    Mileage: 17882km-11111mi   Repair Order: 
    
    
    Chassis Type: 8V (5Q0)
    Scan: 01 03 05 08 09 10 13 14 15 16 17 19 22 2B 42 44 52 55 5F A9
              BB BC
    
    VIN: WAUZZZ8V1G1022866   Mileage: 17882km-11111miles
    
    01-Engine -- Status: OK 0000
    03-ABS Brakes -- Status: Malfunction 0010
    05-Acc/Start Auth. -- Status: OK 0000
    08-Auto HVAC -- Status: Malfunction 0010
    09-Cent. Elect. -- Status: Malfunction 0010
    10-Park/Steer Assist -- Status: Malfunction 0010
    13-Auto Dist. Reg -- Status: Malfunction 0010
    14-Susp. Elect. -- Status: OK 0000
    15-Airbags -- Status: OK 0000
    16-Steering wheel -- Status: OK 0000
    17-Instruments -- Status: OK 0000
    19-CAN Gateway -- Status: OK 0000
    22-AWD -- Status: OK 0000
    2B-Steer. Col. Lock -- Status: OK 0000
    42-Door Elect, Driver -- Status: OK 0000
    44-Steering Assist -- Status: OK 0000
    52-Door Elect, Pass. -- Status: OK 0000
    55-Headlight Range -- Status: OK 0000
    5F-Information Electr. -- Status: OK 0000
    A9-Struct. Borne Sound -- Status: OK 0000
    BB-Door Rear Drv -- Status: OK 0000
    BC-Door Rear Pass -- Status: OK 0000
    
    -------------------------------------------------------------------------------
    Address 01: Engine (J623-CJXC)       Labels: 06K-907-425-V1.clb
       Part No SW: 8V0 906 259 F    HW: 06K 907 425 B
       Component: 2.0l R4 TFSI  H13 0002  
       Revision: --H13---    
       Coding: 0A1900122446010B3004
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_ECM20TFS0208V0906259F 001004
       ROD: EV_ECM20TFS0205G0906259F_VW37.rod
       VCID: 43829D49CA6D8259B4-8016
    
    No fault code found.
    Readiness: 0000 0000
    
    -------------------------------------------------------------------------------
    Address 03: ABS Brakes (J104)       Labels: 5Q0-907-379-IPB-V1.clb
       Part No SW: 3Q0 907 379 AA    HW: 3Q0 907 379 F
       Component: ESC           H42 0623  
       Revision: 00000000    Serial number: 61935000000603
       Coding: 31F193A254222A6E017F070641C9698CC92A5480E08296F6144150F88008
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_Brake1UDSContiMK100IPB 034036
       ROD: EV_Brake1UDSContiMK100IPB_034_VW48.rod
       VCID: 79FE3FA1F8210889AE-802C
    
    4 Faults Found:
    32800 - Supply Voltage for Left Parking Brake Motor 
              C100D F0 [009] - Short Circuit
              Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 158
                        Mileage: 17872 km
                        Date: 2017.05.20
                        Time: 22:09:55
    
    32801 - Supply Voltage for Right Parking Brake Motor 
              C100E F0 [009] - Short Circuit
              Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 158
                        Mileage: 17872 km
                        Date: 2017.05.20
                        Time: 22:09:55
    
    32830 - Parking Brake Motors 
              C10E1 29 [008] - Signal Implausible
              Intermittent - Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 198
                        Mileage: 17872 km
                        Date: 2017.05.20
                        Time: 22:11:00
    
    32951 - Control Module for Electronic Parking Brake 
              C10E2 54 [137] - Missing Calibration / Basic Setting
              MIL ON - Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 151
                        Mileage: 17872 km
                        Date: 2017.05.20
                        Time: 22:11:00
    
    
    -------------------------------------------------------------------------------
    Address 05: Acc/Start Auth. (J518)       Labels: 5Q0-959-435.clb
       Part No SW: 5Q0 959 435 A    HW: 5Q0 959 435 
       Component: VWKESSYMQB    021 0604  
       Revision: 00021000    Serial number: 0372733467
       Coding: 030C0C
       Shop #: WSC 00000 000 00000
       ASAM Dataset: EV_KessyHellaMQBAB 002011
       ROD: EV_KessyHellaMQBAB_002.rod
       VCID: 3A7CE0ADBDA7C391E7-806E
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 08: Auto HVAC (E87)       Labels: 8V0-820-043.clb
       Part No SW: 8V0 820 043 D    HW: 8V0 820 043 D
       Component: AC Automat    H13 0060  
       Revision: 20027000    Serial number: 00000000688610
       Coding: 03100004000000011000000000001100
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_AirCondiFrontVaAU37X 008020
       ROD: EV_AirCondiFrontVaAU37X.rod
       VCID: 3362CD899ACD32D924-8066
    
       Relative humidity sensor in fresh air intake duct: 
       Subsystem 1 - Part No SW: 4H0 907 658     HW: 4H0 907 658 
       Component: AQ_Hum_Sensor  H03 0003 
       Serial number: 818987B7000000000001
    
    1 Fault Found:
    328964 - Motor for Front Air Distribution Flap 
              B1091 71 [008] - Actuator stuck
              Intermittent - Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 193
                        Mileage: 17052 km
                        Date: 2017.05.08
                        Time: 07:49:37
    
                        Voltage terminal 30: 14.6 V
                        Interior temperature: 18.0 °C
                        Outside air temperature: 9.5 °C
                        Front air distribution flap: actual value: 100.0 %
                        Front air distribution flap: actual value: 104
                        Front air distribution flap: specified value: 100
    
    
    -------------------------------------------------------------------------------
    Address 09: Cent. Elect. (J519)       Labels: 5Q0-937-08X-HV1.clb
       Part No SW: 5Q0 937 084 AS    HW: 5Q0 937 084 AN
       Component: BCM MQBAB H   H24 0173  
       Serial number: 01061518800908
       Coding: 07050C46C24106FD03804004B11807A80800000000000000000000000000
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_BCMMQB 015001
       ROD: EV_BCMBOSCH_016_AU37.rod
       VCID: 091E4F61A8C11809BE-805C
    
       Control Unit For Wiper Motor: 
       Subsystem 1 - Part No SW: 8V2 955 119 C    HW: 8V2 955 119 A  Labels: 5QX-955-119-V1.CLB
       Component: WWS371 150630  042 0585 
       Serial number:         150702005003
       Coding: 0A47F7
    
       Rain Light Recognition Sensor: 
       Subsystem 2 - Part No SW: 8U0 955 559 B    HW: 8U0 955 559 B  Labels: 8U0-955-559.CLB
       Component: G397_RLFS  H06 0002 
       Serial number: 24088377            
       Coding: 00006C
    
       Light switch: 
       Subsystem 3 - Part No SW: 8V0 941 531 AA    HW: 8V0 941 531 AA
       Component: E1 - LDS MQB  H05 0032 
       Serial number: 25 04 2015  00000919
    
       Sensor For Anti Theft Alarm System: 
       Subsystem 4 - Part No SW: 8V0 951 177     HW: 5Q0 951 172 
       Component: Sensor, DWA  005 0316 
       Serial number: 000000000ZY151531V10
    
       Alarm horn: 
       Subsystem 5 - Part No SW: 5Q0 951 605     HW: 5Q0 951 605 
       Component: Sirene, DWA  004 0311 
       Serial number: 00000000000032564392
    
    3 Faults Found:
    204546 - Remote key 2 
              B147A 18 [008] - Current Too Low
              Intermittent - Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 4
                        Fault Frequency: 1
                        Reset counter: 189
                        Mileage: 1048574 km
                        Date: 2000.00.00
                        Time: 00:00:00
    
    262912 - Sensor for Anti-Theft Alarm System 
              B1330 F5 [008] - Alert Emergency Activation Stage 1
              Intermittent - Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 7
                        Fault Frequency: 1
                        Reset counter: 167
                        Mileage: 15610 km
                        Date: 2017.04.05
                        Time: 09:17:09
    
    527372 - Local Data Bus 3 
              U10DB 00 [008] - Electrical Malfunction
              Intermittent - Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 188
    
    
    -------------------------------------------------------------------------------
    Address 10: Park/Steer Assist (J446)       Labels: 5Q0-919-294.clb
       Part No SW: 5Q0 919 294 K    HW: 5Q0 919 294 A
       Component: PARKHILFE 8K  H03 0054  
       Revision: --------    Serial number: 39391518006250
       Coding: 0050050001
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_EPHVA18AU3700000 002026
       ROD: EV_EPHVA18AU3700000_VW37.rod
       VCID: 43829D49CA6D8259B4-8016
    
    1 Fault Found:
    13637120 - Databus 
              U1123 00 [008] - Received Error Message
              Intermittent - Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 6
                        Fault Frequency: 43
                        Reset counter: 198
                        Mileage: 17017 km
                        Date: 2017.04.23
                        Time: 13:00:46
    
    
    -------------------------------------------------------------------------------
    Address 13: Auto Dist. Reg (J428)       Labels: 5Q0-907-567.clb
       Part No SW: 5Q0 907 567 N    HW: 5Q0 907 567 N
       Component: ACC3          H10 0400  
       Serial number: 30061503090391
       Coding: 00200301FE0309
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_ACCBoschMQB 001024
       ROD: EV_ACCBoschMQB_AU37.rod
       VCID: 4684845DF95FB77193-8012
    
    2 Faults Found:
    1060 - Databus 
              U1123 00 [040] - Received Error Message
              Intermittent - Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 6
                        Fault Frequency: 6
                        Reset counter: 198
                        Mileage: 17022 km
                        Date: 2017.05.07
                        Time: 11:30:24
    
                        Control Module temperature: 19 °C
                        Voltage terminal 15: 14.6 V
                        Vehicle speed: 0.00 m/s
                        Acceleration: 0.00 m/s²
    
    1061 - Databus 
              U1123 00 [040] - Received Error Message
              Intermittent - Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 6
                        Fault Frequency: 8
                        Reset counter: 198
                        Mileage: 17022 km
                        Date: 2017.05.07
                        Time: 11:30:24
    
                        Control Module temperature: 19 °C
                        Voltage terminal 15: 14.6 V
                        Vehicle speed: 0.00 m/s
                        Acceleration: 0.00 m/s²
    
    
    -------------------------------------------------------------------------------
    Address 14: Susp. Elect. (J250)       Labels: 8V0-907-376.clb
       Part No SW: 8V0 907 376 E    HW: 8V0 907 376 E
       Component: DAEMPFUNGS-SG H09 0072  
       Serial number:       100715004
       ASAM Dataset: EV_AudiMagneRide 002003
       ROD: EV_AudiMagneRide_002_AU37.rod
       VCID: 43829D49CA6D8259B4-8016
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 15: Airbags (J234)       Labels: 5Q0-959-655.clb
       Part No SW: 5Q0 959 655 AB    HW: 5Q0 959 655 AB
       Component: AirbagVW20    015 0388  
       Serial number: 003MMR0XJKV5
       Coding: 98FCC0000C0000005C5400CA00C800000065
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_AirbaVW20SMEVW37X 002130
       ROD: EV_AirbaVW20SMEVW37X_VW37.rod
       VCID: 000852459BFB5941E9-8054
    
       Side Sensor Driver Front: 
       Subsystem 1 - Part No SW: -----------    HW: 480 000 207 15
       Component: SideSensor_Df  001 0887 
       Serial number: 357670000004DC64051U
       Coding: 2D2D2D
    
       Side Sensor Passenger Front: 
       Subsystem 2 - Part No SW: -----------    HW: 480 000 207 15
       Component: SideSensor_Pf  001 0887 
       Serial number: 358670000000FC64051T
       Coding: 2D2D2D
    
       Side Sensor Driver Rear: 
       Subsystem 3 - Part No SW: -----------    HW: 480 400 707 15
       Component: SideSensor_Dr  001 6149 
       Serial number: 3516502A51B7E8F0913K
       Coding: 2D2D2D
    
       Side Sensor Passenger Rear: 
       Subsystem 4 - Part No SW: -----------    HW: 480 400 107 15
       Component: SideSensor_Pr  001 6149 
       Serial number: 3526502C31B65D52003+
       Coding: 2D2D2D
    
       Front Sensor Driver: 
       Subsystem 5 - Part No SW: -----------    HW: 480 402 502 15
       Component: FrontSensor_D  001 6149 
       Serial number: 3556502BD1993FB5E10W
       Coding: 2D2D2D
    
       Pedestrian Protection Driver: 
       Subsystem 6 - Part No SW: -----------    HW: 480 401 106 15
       Component: PedP_Sensor_D  001 6149 
       Serial number: 2286502BB1B5A88443BQ
       Coding: 2D2D2D
    
       Pedestrian Protection Passenger: 
       Subsystem 7 - Part No SW: -----------    HW: 480 401 106 15
       Component: PedP_Sensor_P  001 6149 
       Serial number: 2296502BD1B5A882736P
       Coding: 2D2D2D
    
       Pedestrian Protection Driver 2: 
       Subsystem 8 - Part No SW: -----------    HW: 480 002 204 15
       Component: PedPSensor_D2  001 0887 
       Serial number: I0M800000009E478441D
       Coding: 2D2D2D
    
       Pedestrian Protection Passenger 2: 
       Subsystem 9 - Part No SW: -----------    HW: 480 002 204 15
       Component: PedPSensor_P2  001 0887 
       Serial number: I0N8000000024378441$
       Coding: 2D2D2D
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 16: Steering wheel (J527)       Labels: 5Q0-953-549.clb
       Part No SW: 8V0 953 521 FK    HW: 5Q0 953 549 E
       Component: Lenks. Modul  003 0110  
       Revision: --------    Serial number: 01071504400023
       Coding: E008
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_SMLSKLOMQB 017001
       ROD: EV_SMLSKLOMQB_AU37.rod
       VCID: 08184A65B3CB6101A1-805C
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 17: Instruments (J285)       Labels: 5G0-920-XXX-17.clb
       Part No SW: 8V0 920 972 A    HW: 8V0 920 972 A
       Component: KOMBI         H03 6420  
       Coding: 278D18123F8026000181E8001000000000000000
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_DashBoardVDDMQBAB 009046
       ROD: EV_DashBoardVDDMQBAB_009_AU37.rod
       VCID: 3C70E6B5B793FDA1F5-8068
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 19: CAN Gateway (J533)       Labels: 5Q0-907-530-V1.clb
       Part No SW: 5Q0 907 530 AF    HW: 5Q0 907 530 M
       Component: GW MQB High   212 2223  
       Revision: --------    Serial number: 06071510803588
       Coding: 030100043F085A005B000278880B00000001010000000000000000000000
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_GatewConti 013020
       ROD: EV_GatewConti_013.rod
       VCID: 75E63391D4396CE9CA-8020
    
       Alternator: 
    
       Multi Function Steering Wheel Control Module: 
       Subsystem 2 - Part No SW: 8U0 951 528 A    HW: 8U0 951 528 A
       Component: E221 - MFL  H02 0014 
       Serial number: 24 03 2015  F0080670
    
       Battery Monitoring Control Module: 
       Subsystem 3 - Part No SW: 5Q0 915 181 H    HW: 5Q0 915 181 H
       Component: J367-BDMConti  H02 1011 
       Serial number: 74185703001507140285
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 22: AWD (J492)       Labels: 0CQ-907-554.clb
       Part No SW: 0CQ 907 554 D    HW: 0CQ 525 130 
       Component: Haldex4Motion H52 7082  
       Serial number: HA1-00002.06.15
       Coding: 0001
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_AllWheelContrHA1VW37X 002013
       ROD: EV_AllWheelContrHA1VW37X_SK12.rod
       VCID: 4684845DF95FB77193-8012
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 2B: Steer. Col. Lock (J764)       Labels: 5Q0-905-861.clb
       Part No SW: 5Q0 905 861 A    HW: 5Q0 905 861 A
       Component: ELV-MQBA      H01 0120  
       Revision: 00000000    Serial number: 15000170558008
       Coding: 5500000000000000
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_ELVMarquMQB 004111
       ROD: EV_ELVMarquMQB_SK25.rod
       VCID: 3460CE959FC335E13D-8060
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 42: Door Elect, Driver (J386)       Labels: 5QX-959-X93-42.clb
       Part No SW: 5Q0 959 593 E    HW: 5Q0 959 593 B
       Component: TSG FS        020 0041  
       Serial number: 010715BFT10057
       Coding: 00109A204001040000001003
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_DCUDriveSideEWMAXKLO 006003
       ROD: EV_DCUDriveSideEWMAXCONT.rod
       VCID: 43829D49CA6D8259B4-8016
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 44: Steering Assist (J500)       Labels: 5Q0-909-144.clb
       Part No SW: 3Q0 909 144 H    HW: 3Q0 909 144 H
       Component: EPS_MQB_ZFLS  505 5061  
       Coding: 8103
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_SteerAssisMQB 012140
       ROD: EV_SteerAssisMQB_VW31.rod
       VCID: 377AF9998EB5DEF918-8062
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 52: Door Elect, Pass. (J387)       Labels: 5QX-959-X92-52.clb
       Part No SW: 5Q0 959 592 E    HW: 5Q0 959 592 B
       Component: TSG BFS       020 0041  
       Serial number: 020715BG114712
       Coding: 001092204001040000001003
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_DCUPasseSideEWMAXKLO 006003
       ROD: EV_DCUPasseSideEWMAXCONT.rod
       VCID: 428C984DD5778B51BF-8016
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 55: Headlight Range (J745)       Labels: 7P6-907-357.clb
       Part No SW: 7P6 907 357 C    HW: 7P6 907 357 B
       Component: AFS-ECU       H01 0110  
       Revision: --------    Serial number: --------------
       Coding: 01A600002B200200
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_HeadlRegulAFSMQBMLB 001001
       ROD: EV_HeadlRegulAFSMQBMLB_AU37.rod
       VCID: 3F8A91B9A685E6B9D0-806A
    
       Led Headlamp Powermodule Left: 
       Subsystem 1 - Part No SW: 7PP 941 472 J    HW: 7PP 941 472 J  Labels: 3D0-941-329.CLB
       Component: LED LeiMo li.  H07 7560 
       Coding: E00100
    
       Led Headlamp Powermodule Right: 
       Subsystem 2 - Part No SW: 7PP 941 472 J    HW: 7PP 941 472 J  Labels: 3D0-941-329.CLB
       Component: LED LeiMo re.  H07 7560 
       Coding: E00100
    
       Left Headlamp Power Output Stage: 
       Subsystem 3 - Part No SW: 7PP 941 329 M    HW: 7PP 941 329 M  Labels: 3D0-941-329.CLB
       Component: LeiMo links  H01 7050 
       Coding: E00100
    
       Right Headlamp Power Output Stage: 
       Subsystem 4 - Part No SW: 7PP 941 329 M    HW: 7PP 941 329 M  Labels: 3D0-941-329.CLB
       Component: LeiMo rechts  H01 7050 
       Coding: E00100
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 5F: Information Electr. (J794)       Labels: 8V0-035-MIB-STD1.clb
       Part No SW: 8V0 035 874 C    HW: 8V0 035 874 B
       Component: MU-S-ND-ER    042 0461  
       Serial number: A7F00807150430
       Coding: 01730101FF00000021111101000A00002F0005060100010006
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_MUStd6C3PASE 002010
       ROD: EV_MUStd6C3PASE_AU37.rod
       VCID: 3C70E6B5B793FDA1F5-8068
    
       Data medium: 
       Subsystem 1 - Part No SW: 8V0 919 866 C    HW: -----------
       Component:  ECE 2015  --- 0045 
       Serial number: --------------------
    
       Display unit 1 for multimedia system: 
       Subsystem 2 - Part No SW: 8V0 919 603 C    HW: 8V0 919 603 C
       Component: DU Std  H49 0014 
       Serial number: AUZ8Z9FY30C1BG      
    
       Multimedia Operating Unit: 
       Subsystem 3 - Part No SW: 8V0 919 614 Q    HW: 8V0 919 614 Q
       Component: ControlUnit_B  H41 0054 
       Serial number: C1000024041500040367
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address A9: Struct. Borne Sound (J869)       Labels: 4H0-907-159.clb
       Part No SW: 8V0 907 159     HW: 4H0 907 159 A
       Component: SAS-GEN 2     H06 0012  
       Serial number: 150620202523
       ASAM Dataset: EV_SoundActuaGen2AU64X 003010
       ROD: EV_SoundActuaGen2AU64X_VW26.rod
       VCID: 7DF62BB1EC0934A982-8028
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address BB: Door Rear Drv (J388)       Labels: None
       Part No SW: 5Q0 959 595 E    HW: 5Q0 959 595 B
       Component: TSG HFS       020 0041  
       Serial number: 250615BFO16625
       Coding: 000092204001040000001002
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_DCURearDriveMAXKLO 006003
       ROD: EV_DCURearDriveMAXCONT.rod
       VCID: 45868351C459BC699A-8010
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address BC: Door Rear Pass (J389)       Labels: None
       Part No SW: 5Q0 959 595 E    HW: 5Q0 959 595 B
       Component: TSG HBFS      020 0041  
       Serial number: 250615BFO1580B
       Coding: 000092204001040000001002
       Shop #: WSC 06385 790 00016
       ASAM Dataset: EV_DCURearPasseMAXKLO 006003
       ROD: EV_DCURearPasseMAXCONT.rod
       VCID: 45868351C459BC699A-8010
    
    No fault code found.
    
    End-------------------------(Elapsed Time: 04:50)--------------------------
    Last edited by Uwe; 05-23-2017 at 09:14 AM. Reason: CODE tags

  6. #14
    Verified VCDS User
    Join Date
    Apr 2017
    Location
    UK
    Posts
    8
    Post Thanks / Like
    Quote Originally Posted by Jack@European_Parts View Post
    You need to start over............

    Do you have the SSP and Repair manual?

    Are your line locks interfering with the function?

    I hate retrofits and technically this is where this belongs not being general car repair.

    I bet you didn't default the module and basic brake settings......... and just retracted like doing brake pads.......?

    First you need to make sure the park brake motors work and move the calipers in and out manually!

    Move the calipers all the way in manually relaxed bottom out.....then clear DTC's and trace if with fault or replace module from frying due to failing to use a battery charger or bug in module.

    Once faults for shorts are rectified setup module for new install.

    Posting a complete auto-scan & PR codes is absolutely always relevant because it gives us details you negate, as does the JPPSG.

    http://forums.ross-tech.com/showthre...uot-JPPSG-quot

    Simulate/isolate the EBP function by leaving motors uninstalled from mechanical circuit and get module to operate without a fault!

    Watch video...... RTFB & JPPSG




    NostraJackAss Has Spoken!
    Thanks. I had already watched the video before i started. Ironic that most of that isnt actually in the Audi repair manual that i have but anyway. The parking brake motors do work - they engage and disengage but not necessarily on command - when i press the EPB button. They will come on and the light on the dash appears and then they are unable to be disengaged - unless i plug in the VCDS and run the test EPB module. I can't understand why the fault codes are saying the motors have shorted but they still work? How can they still work if they have been shorted?

  7. #15
    NostraJackAss Jack@European_Parts's Avatar
    Join Date
    Jan 2014
    Location
    1001 State Route 17K Montgomery New York 12549
    Posts
    19,197
    Post Thanks / Like
    Do they say they short when ran with no pads installed?
    European Parts Emporium/Performance / Immobilizer Solutions EPE
    Certified Master Trained NY/BAR/BAD 7076062/ASE/SAE/NASTF Legal Factory Authorized/Licensed GeKo/FaZit # 403738
    Specializing in Custom Services IE: "welding-fabrication" / EPA-SMOG Update or Pass-Thru-Programming / Data Transfer / Immobilizers & OEM Quality Parts
    Above Magic! No Written record, AUTO-SCAN or Appointment = NO HELP!
    www.FixMyEuro.com <<<<<CLICK HERE! or vwemporium@aol.com ( JPPSG & Unverified members need not PM me & Please don't email or call facility for free tech support...use the forum )
    Getting you CONTROL again of your property - TAKE IT! In Conjunction with.........

Tags for this Thread

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •