Charge Air Pressure Issue

   #1  

Mika Rummukainen

Verified VCDS User
Verified
Joined
Jun 29, 2019
Messages
10
Reaction score
6
Location
Canberra, AU
I have a Golf R 7 with stage 3 hardware and recently the car has started running super rich and the EPC light comes on when a moderate amount of boost is used. The light has gradually started coming on earlier and earlier from startup over the last few weeks.
VCDS is reading the actual charge air pressure static at just about 1 bar, even though the specified value changes as it should. If I disconnect the lower MAP sensor the actual starts measuring as it should, but this process triggers the engine light. It continues measuring correctly if I plug the sensor back in but reverts to flatline 1 bar if I clear the fault or restart the car.
What on earth is going on?
Could someone also help me out with what the two MAP sensors actually do, and which of these is measuring the Actual Charge Air Pressure?
 
   #4  

Mika Rummukainen

Verified VCDS User
Verified
Joined
Jun 29, 2019
Messages
10
Reaction score
6
Location
Canberra, AU
Below is the scan, this is before the car was run today and no unplugging of sensors etc. The EPC light was triggered on the previous drive.

The car is a 2016 Golf R with BOSS 600 turbo, dump pipe and high flow cat, standard mufflers and rear exhaust, upgraded HPFP, intake pipes, intercooler and custom tune to 25psi boost and 275kW atw.

Code:
Chassis Type: AU-VW37 (5Q0)
Scan: 01 02 03 05 08 09 10 13 14 15 16 17 19 22 2B 3C 42 44 52 55
5F A9

VIN: WVWZZZAUZGW147296 Mileage: 49489km-30751miles

01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
10-Park/Steer Assist -- Status: OK 0000
13-Auto Dist. Reg -- Status: Malfunction 0010
14-Susp. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
22-AWD -- Status: OK 0000
2B-Steer. Col. Lock -- Status: OK 0000
3C-Lane Change -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
5F-Information Electr. -- Status: OK 0000
A9-Struct. Borne Sound -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CJXB) Labels:. 06K-907-425-V1.clb
Part No SW: 5G0 906 259 F HW: 06K 907 425 B
Component: 2.0l R4 TFSI H13 0002 
Revision: --H13--- 
Coding: 091D00122466050B3004
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_ECM20TFS0205G0906259F 001004
ROD: EV_ECM20TFS0205G0906259F.rod
VCID: 313F14F7C1AA0DEF75B-8064

1 Fault Found:
14846 - Turbocharger Boost Control Position Sensor Circuit 
P2563 00 [109] - Implausible Signal
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 49412 km
Date: 2019.06.29
Time: 15:11:00

Engine speed: 3657.00 /min
Normed load value: 23.9 %
Vehicle speed: 30 km/h
Coolant temperature: 93 °C
Intake air temperature: 33 °C
Ambient air pressure: 940 mbar
Voltage terminal 30: 14.101 V
Unlearning counter according OBD: 40
Status of charge air pressure control valve basic setting-LV_BPA_AD_REQ[0]: 00000001 
Charge air pressure control valve uncond voltage sensor: 4.5386 V
Charge air pressure control valve position: target value: 0.00 %
Charge air pressure control valve position: actual value: 0.00 %
Charge air pressure control valve activation pulse duty factor: -20.15 %
Charge air pressure control valve voltage: position closed: 4.4482 V
STATE_BPA[0]: AD

Readiness: 0010 0000

-------------------------------------------------------------------------------
Address 02: Auto Trans (J743) Labels: 0D9-927-770.clb
Part No SW: 0D9 300 012 HW: 02E 927 770 AQ
Component: DQ250-6A MQB H53 4911 
Revision: 06253104 Serial number: TFK01509211648
Coding: 0014
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_TCMDQ250021 001001
ROD: EV_TCMDQ250021.rod
VCID: 53F37E7F9B761FFF277-8006

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels: 5Q0-907-379-IPB-V1.clb
Part No SW: 3Q0 907 379 AB HW: 3Q0 907 379 G
Component: ESC H42 0723 
Revision: 00000000 Serial number: 62665000000441
Coding: 01FA93A1542429730779070941C96980C92A94E0E08296F718 4250B8C209
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_Brake1UDSContiMK100IPB 034036
ROD: EV_Brake1UDSContiMK100IPB_034_VW37.rod
VCID: 7AADF3DB5C5C0EB7841-802E

No fault code found.

-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J518) Labels:| 5Q0-959-435.clb
Part No SW: 5Q0 959 435 A HW: 5Q0 959 435 
Component: VWKESSYMQB 021 0604 
Revision: 00021000 Serial number: 0382103910
Coding: 030C0C
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_KessyHellaMQBAB 002011
ROD: EV_KessyHellaMQBAB_002.rod
VCID: 3A2D33DB1CDCCEB7C41-806E

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:| 5G0-907-044.clb
Part No SW: 5G0 907 044 BD HW: 5G0 907 044 BD
Component: Climatronic H03 1001 
Revision: 00001K08 
Coding: 00120004200100001005000012101402
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_ACClimaBHBVW37X 004131
ROD: EV_ACClimaBHBVW37X_004_VW37.rod
VCID: 6A8DC39B2CFCBE37741-803E

Fresh Air Blower Front: 

Geber für Kältemitteldruck/Kältemitteltemperatur: 

Air quality sensor: 

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels:| 5Q0-937-08X-HV1.clb
Part No SW: 5Q0 937 084 AS HW: 5Q0 937 084 AN
Component: BCM MQBAB H H24 0175 
Serial number: 01061527902828
Coding: 03011A46C24122F30BA44080B10C0728180000000000000000 0000000000
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_BCMMQB 015001
ROD: EV_BCMBOSCH_015.rod
VCID: 094F9C1709BA152F9DB-805C

Control Unit For Wiper Motor: 
Subsystem 1 - Part No SW: 5G2 955 119 A HW: 5G2 955 119 A Labels: 5QX-955-119-V1.CLB
Component: WWS 150820 042 0551 
Serial number: 150922125759
Coding: 0E4DDD

Rain Light Recognition Sensor: 
Subsystem 2 - Part No SW: 5Q0 955 547 A HW: 5Q0 955 547 A Labels: 5Q0-955-547.CLB
Component: RLHS 037 0059 
Serial number: S5Y15M10D13H10M36S50
Coding: 06A8DD

Sensor For Anti Theft Alarm System: 
Subsystem 3 - Part No SW: 5Q0 951 172 HW: 5Q0 951 172 
Component: Sensor, DWA 005 0316 
Serial number: 000000000ZY152363GME

Alarm horn: 
Subsystem 4 - Part No SW: 5Q0 951 605 HW: 5Q0 951 605 
Component: Sirene, DWA 004 0311 
Serial number: 00000000000063621735

No fault code found.

-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446) Labels:| 5Q0-919-294.clb
Part No SW: 5Q0 919 294 K HW: 5Q0 919 294 A
Component: PARKHILFE 8K H03 0054 
Revision: -------- Serial number: 39331528100210
Coding: 0071155011
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_EPHVA18AU3700000 002026
ROD: EV_EPHVA18AU3700000_002_VW37.rod
VCID: 43D34E3F6B168F7F977-8016

No fault code found.

-------------------------------------------------------------------------------
Address 13: Auto Dist. Reg (J428) Labels:| 5Q0-907-572-V1.clb
Part No SW: 5Q0 907 572 F HW: 5Q0 907 572 F
Component: ACC Bosch MQB H05 0400 
Serial number: 23081503212727
Coding: 001C1300FE0739
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_ACCMRRBoschVW372 001016
ROD: EV_ACCMRRBoschVW372_VW26.rod
VCID: 3A2D33DB1CDCCEB7C41-806E

1 Fault Found:
1043 - Automatic Distance Control 
B10E7 F0 [008] - Disconnected
[FAULT_CIS_TSK_IRREV_FAIL]
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 1
Reset counter: 220
Mileage: 49166 km
Date: 2019.06.22
Time: 13:11:48

Control Module temperature: 17 °C
Voltage terminal 15: 12.6 V
Vehicle speed: 0.00 m/s
Acceleration: 0.00 m/s²


-------------------------------------------------------------------------------
Address 14: Susp. Elect. (J250) Labels: 5Q0-907-376.clb
Part No SW: 5Q0 907 376 A HW: 5Q0 907 376 A
Component: DAEMPFUNGS-SG H17 0120 
Serial number: 09101541350449
ASAM Dataset: EV_DRCONTITEMIC 001019
ROD: EV_DRCONTITEMIC_VW37.rod
VCID: 372B2AEF2FCED3DF3BF-8062

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels:| 5Q0-959-655.clb
Part No SW: 5Q0 959 655 AA HW: 5Q0 959 655 AA
Component: AirbagVW20 015 0388 
Serial number: 003MLR138CZ3
Coding: 98CCC000000000005C00000000C800000065
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_AirbaVW20SMEVW37X 002130
ROD: EV_AirbaVW20SMEVW37X.rod
VCID: 7F5B02CF477E2B9FB3F-802A

Belt Pretensioner left: 
Subsystem 1 - Part No SW: 5G0 980 945 B HW: 5G0 980 945 B
Component: BeltPretRevFL H36 0350 
Serial number: 34169677B07101540181
Coding: 333135

Belt Pretensioner right: 
Subsystem 2 - Part No SW: 5G0 980 946 B HW: 5G0 980 946 B
Component: BeltPretRevFR H36 0350 
Serial number: 34169676B06101590769
Coding: 333135

Side Sensor Driver Front: 
Subsystem 3 - Part No SW: ----------- HW: 480 002 809 15
Component: SideSensor_Df 001 0887 
Serial number: 3576700000054790B61S
Coding: 2D2D2D

Side Sensor Passenger Front: 
Subsystem 4 - Part No SW: ----------- HW: 480 002 809 15
Component: SideSensor_Pf 001 0887 
Serial number: 35867000000D5941961Y
Coding: 2D2D2D

Side Sensor Driver Rear: 
Subsystem 5 - Part No SW: ----------- HW: 480 403 009 15
Component: SideSensor_Dr 001 6149 
Serial number: 3516502C31CF2D7141EL
Coding: 2D2D2D

Side Sensor Passenger Rear: 
Subsystem 6 - Part No SW: ----------- HW: 480 403 009 15
Component: SideSensor_Pr 001 6149 
Serial number: 3526502B91CF2DA4030H
Coding: 2D2D2D

Front Sensor Driver: 
Subsystem 7 - Part No SW: ----------- HW: 480 403 009 15
Component: FrontSensor_D 001 6149 
Serial number: 3556502AB1CF2D75030J
Coding: 2D2D2D

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels:| 5Q0-953-549.clb
Part No SW: 5Q0 953 507 HN HW: 5Q0 953 549 E
Component: Lenks. Modul 003 0110 
Revision: -------- Serial number: 03101504220493
Coding: 0C10
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_SMLSKLOMQB 017001
ROD: EV_SMLSKLOMQB_010_VW37.rod
VCID: 094F9C1709BA152F9DB-805C

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels:| 5G0-920-XXX-17.clb-SRI3
Part No SW: 5G1 920 758 A HW: 5G1 920 758 A
Component: KOMBI 302 6420 
Coding: 272D08183F88000801886A095400000000000000
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_DashBoardVDDMQBAB 009046
ROD: EV_DashBoardVDDMQBAB_009_VW37.rod
VCID: 2D070887DD92690F513-8078

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels:| 5Q0-907-530-V1.clb
Part No SW: 5Q0 907 530 AF HW: 5Q0 907 530 F
Component: GW MQB High 128 1223 
Revision: -------- Serial number: 0004017225
Coding: 030100043F085900FB00027E9C0F0001000105000000000000 0000000000
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_GatewLear 013020
ROD: EV_GatewLear_013.rod
VCID: 75B7E0E7754261CFE93-8020

Alternator: 

Multi Function Steering Wheel Control Module: 
Subsystem 2 - Part No SW: 5G0 959 442 N HW: 5G0 959 442 N Labels: 3C8-959-537.CLB
Component: E221__MFL-DC1 H10 0040 
Serial number: 29150001765000105382
Coding: 2DFFFF

Battery Monitoring Control Module: 
Subsystem 3 - Part No SW: 5Q0 915 181 G HW: 5Q0 915 181 G
Component: J367-BDMHella H04 8050 
Serial number: 7462318003 

No fault code found.

-------------------------------------------------------------------------------
Address 22: AWD (J492) Labels:* 0CQ-907-554.clb
Part No SW: 0CQ 907 554 H HW: 0CQ 525 130 
Component: Haldex4Motion H52 7083 
Serial number: HA1-00014.08.15
Coding: 0001
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_AllWheelContrHA1VW37X 004013
ROD: EV_AllWheelContrHA1VW37X_004.rod
VCID: 4ACD631B4C3C5E37541-801E

No fault code found.

-------------------------------------------------------------------------------
Address 2B: Steer. Col. Lock (J764) Labels:* 5Q0-905-861.clb
Part No SW: 5Q0 905 861 A HW: 5Q0 905 861 A
Component: ELV-MQBA H01 0120 
Revision: 00000000 Serial number: 15000219118010
Coding: 5D00000000000000
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_ELVMarquMQB 004111
ROD: EV_ELVMarquMQB.rod
VCID: 34311DE33EB838C71ED-8060

No fault code found.

-------------------------------------------------------------------------------
Address 3C: Lane Change (J1086) Labels:| 5Q0-907-686.clb
Part No SW: 5Q0 907 686 B HW: 5Q0 907 686 B
Component: HRE_Master H11 0071 
Serial number: 0381851243
Coding: 02011203
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_HREntryHella 001028
ROD: EV_HREntryHella_VW37.rod
VCID: 3C2135C316E8F087D6D-8068

Lane Change Assistant 2: 
Subsystem 1 - Part No SW: 5Q0 907 685 B HW: 5Q0 907 685 B
Component: HRE_Slave H11 0071 
Serial number: 0381863340 
Coding: 020112

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels:| 5QX-959-X93-42.clb
Part No SW: 5Q0 959 593 E HW: 5Q0 959 593 B
Component: TSG FS 020 0041 
Serial number: 220915BIL04483
Coding: 003E12208001048000001000
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_DCUDriveSideEWMAXKLO 006003
ROD: EV_DCUDriveSideEWMAXCONT.rod
VCID: 43D34E3F6B168F7F977-8016

Drivers Door Rear Control Module: 
Subsystem 1 - Part No SW: 5Q0 959 812 HW: 5Q0 959 812 Labels: 5QX-959-81X-V1.CLB
Component: FOND_FHSG_DRV 005 0005 
Serial number: 00000000000007600373
Coding: 0D0000

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist (J500) Labels:| 5Q0-909-144.clb
Part No SW: 3Q0 909 144 J HW: 3Q0 909 144 H
Component: EPS_MQB_ZFLS 505 5063 
Coding: 8103
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_SteerAssisMQB 012140
ROD: EV_SteerAssisMQB_012_VW37.rod
VCID: 392F2CD719DAC5AFCDB-806C

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels:| 5QX-959-X92-52.clb
Part No SW: 5Q0 959 592 E HW: 5Q0 959 592 B
Component: TSG BFS 020 0041 
Serial number: 250915BIO13175
Coding: 003E10208E01048000801000
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_DCUPasseSideEWMAXKLO 006003
ROD: EV_DCUPasseSideEWMAXCONT.rod
VCID: 42DD4B3B740C86779C1-8016

Passengers Rear Door Control Module: 
Subsystem 1 - Part No SW: 5Q0 959 811 HW: 5Q0 959 811 Labels: 5QX-959-81X-V1.CLB
Component: FOND_FHSG_PSG 005 0005 
Serial number: 00000000000007468013
Coding: 150000

No fault code found.

-------------------------------------------------------------------------------
Address 55: Headlight Range (J745) Labels:| 7P6-907-357.clb
Part No SW: 7P6 907 357 D HW: 7P6 907 357 A
Component: AFS-ECU H07 0090 
Revision: -------- Serial number: --------------
Coding: 02A602000B000200
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_HeadlRegulVWAFSMQB 001120
ROD: EV_HeadlRegulVWAFSMQB.rod
VCID: 40D941337A0094678A5-8014

Left Headlamp Power Output Stage: 
Subsystem 1 - Part No SW: 3D0 941 329 E HW: 3D0 941 329 E Labels: 3D0-941-329.CLB
Component: LeiMo links H01 0002 
Coding: 2E0000

Right Headlamp Power Output Stage: 
Subsystem 2 - Part No SW: 3D0 941 329 E HW: 3D0 941 329 E Labels: 3D0-941-329.CLB
Component: LeiMo rechts H01 0002 
Coding: 2E0000

No fault code found.

-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794) Labels:| 5G0-035-MIB-STD2.clb
Part No SW: 3Q0 035 846 HW: 3Q0 035 846 
Component: MU-S-N-ER 820 0627 
Serial number: 
Coding: 02730008FF00000051510001000828001F0207D601200102C7
Shop #: WSC 131071 1023 2097151
ASAM Dataset: EV_MUStd4CDELP 001001
ROD: EV_MUStd4CDELP_VW37.rod
VCID: 6E85CF8B10145217289-803A

Operating And Display Unit 1: 
Subsystem 1 - Part No SW: 3G0 919 605 D HW: 3G0 919 605 D
Component: ABT_Std-2_Nav H43 4064 
Serial number: VWZ6Z9R2790762 

Data medium: 
Subsystem 2 - Part No SW: 3G0 919 866 K HW: -----------
Component: MRM2 2015/16 --- 0420 
Serial number: --------------------

No fault code found.

-------------------------------------------------------------------------------
Address A9: Struct. Borne Sound (J869) Labels: 4H0-907-159.clb
Part No SW: 5G0 907 159 D HW: 4H0 907 159 A
Component: SAS-GEN 2 H07 0001 
Serial number: 150908201126
ASAM Dataset: EV_SoundActuaGen2AU64X 003010
ROD: EV_SoundActuaGen2AU64X.rod
VCID: 2F3B128FD79E1B1F63F-807A

No fault code found.

End----------(Elapsed Time: 04:09, VBatt start/end: 12.1V/12.0V)-----------
 
   #5  

Jack@European_Parts

Gone But Not Forgotten
Professional VCDS User
Joined
Jan 29, 2014
Messages
21,923
Reaction score
9,308
Location
Montgomery, NY, USA
VCDS Serial number
C?ID=57337
Clear faults and then immediately re-post the scan please.

Repair harness or check/clean/change G31
 
   #7  

Jack@European_Parts

Gone But Not Forgotten
Professional VCDS User
Joined
Jan 29, 2014
Messages
21,923
Reaction score
9,308
Location
Montgomery, NY, USA
VCDS Serial number
C?ID=57337
RTFB the WD and search it, than you will be enlightened.
 
   #9  

Jack@European_Parts

Gone But Not Forgotten
Professional VCDS User
Joined
Jan 29, 2014
Messages
21,923
Reaction score
9,308
Location
Montgomery, NY, USA
VCDS Serial number
C?ID=57337
You would think that someone which is to modify a car to "Stage III dog dukers" would have a better understanding of what or how their car operates.

OP in addition to RTFB I recommend you read SSP on this engine for design and function.

It will illustrate in simple detail things you should know.
 
   #10  

Uwe

Benevolent Dictator
Administrator
Joined
Jan 29, 2014
Messages
48,925
Reaction score
33,652
Location
USA
VCDS Serial number
HC100001
You would think that someone which is to modify a car to "Stage III dog dukers" would have a better understanding of what or how their car operates.
If they did it themselves, sure. But what if the just took the car (and a big wad of money) to a tuner and said: "Make it really fast!" ?? I'd suppose there are also some in-between scenarios.

-Uwe-
 
   #11  

Jack@European_Parts

Gone But Not Forgotten
Professional VCDS User
Joined
Jan 29, 2014
Messages
21,923
Reaction score
9,308
Location
Montgomery, NY, USA
VCDS Serial number
C?ID=57337
If they did it themselves, sure. But what if the just took the car (and a big wad of money) to a tuner and said: "Make it really fast!" ?? I'd suppose there are also some in-between scenarios.

-Uwe-

Well sure but all the same if OP is asking this stuff, SSP will be very informative crash course.
 
  • Like
Reactions: Uwe
   #12  

Mika Rummukainen

Verified VCDS User
Verified
Joined
Jun 29, 2019
Messages
10
Reaction score
6
Location
Canberra, AU
Hi guys, thanks for your help. I did put the hardware in myself but I am certainly no genius with tinkering with the electronics! Chucking it all in is easy, anything after that is waaaay beyond me!
Are your RTFB and WD and SSP text supposed to be links? it does come up with text when hovering but don't lead anywhere if clicked. I have Googled the Fine Book and somehow found a link to Erwin, I then registered and found the wiring diagram link but it then asks for payment. Happy to pay if this is obviously the right path I'm going down, though it seems there is something obvious that I'm missing.
Yes, I am a complete noob, but it really is difficult to learn all of this stuff with literally no experience of electronics and programming etc... don't hurt me!

Is the G31 the top sensor or the lower one?
 
   #14  

Mika Rummukainen

Verified VCDS User
Verified
Joined
Jun 29, 2019
Messages
10
Reaction score
6
Location
Canberra, AU
I cleared the faults and did an Auto-Scan,here are the results:

Code:
Tuesday,02,July,2019,21:58:04:13686
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x86
VCDS Version: 19.6.0.6  HEX-V2 CB: 0.4505.4
Data version: 20190529 DS308.0
www.Ross-Tech.com


VIN: WVWZZZAUZGW147296   License Plate: 


Chassis Type: AU-VW37 (5Q0)
Scan: 01 02 03 05 08 09 10 13 14 15 16 17 19 22 2B 3C 42 44 52 55
          5F A9

VIN: WVWZZZAUZGW147296   Mileage: 49489km-30751miles

01-Engine -- Status: OK 0000
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
10-Park/Steer Assist -- Status: OK 0000
13-Auto Dist. Reg -- Status: Malfunction 0010
14-Susp. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
22-AWD -- Status: OK 0000
2B-Steer. Col. Lock -- Status: OK 0000
3C-Lane Change -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
55-Headlight Range -- Status: OK 0000
5F-Information Electr. -- Status: OK 0000
A9-Struct. Borne Sound -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CJXB)       Labels:. 06K-907-425-V1.clb
   Part No SW: 5G0 906 259 F    HW: 06K 907 425 B
   Component: 2.0l R4 TFSI  H13 0002  
   Revision: --H13---    
   Coding: 091D00122466050B3004
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_ECM20TFS0205G0906259F 001004
   ROD: EV_ECM20TFS0205G0906259F.rod
   VCID: 313F14F7C1AA0DEF75B-8064

No fault code found.
Readiness: 1110 0000

-------------------------------------------------------------------------------
Address 02: Auto Trans (J743)       Labels: 0D9-927-770.clb
   Part No SW: 0D9 300 012     HW: 02E 927 770 AQ
   Component: DQ250-6A MQB  H53 4911  
   Revision: 06253104    Serial number: TFK01509211648
   Coding: 0014
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_TCMDQ250021 001001
   ROD: EV_TCMDQ250021.rod
   VCID: 53F37E7F9B761FFF277-8006

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels: 5Q0-907-379-IPB-V1.clb
   Part No SW: 3Q0 907 379 AB    HW: 3Q0 907 379 G
   Component: ESC           H42 0723  
   Revision: 00000000    Serial number: 62665000000441
   Coding: 01FA93A1542429730779070941C96980C92A94E0E08296F7184250B8C209
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_Brake1UDSContiMK100IPB 034036
   ROD: EV_Brake1UDSContiMK100IPB_034_VW37.rod
   VCID: 7AADF3DB5C5C0EB7841-802E

No fault code found.

-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J518)       Labels:| 5Q0-959-435.clb
   Part No SW: 5Q0 959 435 A    HW: 5Q0 959 435 
   Component: VWKESSYMQB    021 0604  
   Revision: 00021000    Serial number: 0382103910
   Coding: 030C0C
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_KessyHellaMQBAB 002011
   ROD: EV_KessyHellaMQBAB_002.rod
   VCID: 3A2D33DB1CDCCEB7C41-806E

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255)       Labels:| 5G0-907-044.clb
   Part No SW: 5G0 907 044 BD    HW: 5G0 907 044 BD
   Component: Climatronic   H03 1001  
   Revision: 00001K08    
   Coding: 00120004200100001005000012101402
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_ACClimaBHBVW37X 004131
   ROD: EV_ACClimaBHBVW37X_004_VW37.rod
   VCID: 6A8DC39B2CFCBE37741-803E

   Fresh Air Blower Front: 

   Geber für Kältemitteldruck/Kältemitteltemperatur: 

   Air quality sensor: 

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:| 5Q0-937-08X-HV1.clb
   Part No SW: 5Q0 937 084 AS    HW: 5Q0 937 084 AN
   Component: BCM MQBAB H   H24 0175  
   Serial number: 01061527902828
   Coding: 03011A46C24122F30BA44080B10C07281800000000000000000000000000
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_BCMMQB 015001
   ROD: EV_BCMBOSCH_015.rod
   VCID: 094F9C1709BA152F9DB-805C

   Control Unit For Wiper Motor: 
   Subsystem 1 - Part No SW: 5G2 955 119 A    HW: 5G2 955 119 A  Labels: 5QX-955-119-V1.CLB
   Component: WWS    150820  042 0551 
   Serial number:         150922125759
   Coding: 0E4DDD

   Rain Light Recognition Sensor: 
   Subsystem 2 - Part No SW: 5Q0 955 547 A    HW: 5Q0 955 547 A  Labels: 5Q0-955-547.CLB
   Component: RLHS  037 0059 
   Serial number: S5Y15M10D13H10M36S50
   Coding: 06A8DD

   Sensor For Anti Theft Alarm System: 
   Subsystem 3 - Part No SW: 5Q0 951 172     HW: 5Q0 951 172 
   Component: Sensor, DWA  005 0316 
   Serial number: 000000000ZY152363GME

   Alarm horn: 
   Subsystem 4 - Part No SW: 5Q0 951 605     HW: 5Q0 951 605 
   Component: Sirene, DWA  004 0311 
   Serial number: 00000000000063621735

1 Fault Found:
204290 - Remote key 1 
          B1479 18 [009] - Current Too Low
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 4
                    Fault Frequency: 1
                    Reset counter: 206
                    Mileage: 49489 km
                    Date: 2019.07.01
                    Time: 18:38:14


-------------------------------------------------------------------------------
Address 10: Park/Steer Assist (J446)       Labels:| 5Q0-919-294.clb
   Part No SW: 5Q0 919 294 K    HW: 5Q0 919 294 A
   Component: PARKHILFE 8K  H03 0054  
   Revision: --------    Serial number: 39331528100210
   Coding: 0071155011
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_EPHVA18AU3700000 002026
   ROD: EV_EPHVA18AU3700000_002_VW37.rod
   VCID: 43D34E3F6B168F7F977-8016

No fault code found.

-------------------------------------------------------------------------------
Address 13: Auto Dist. Reg (J428)       Labels:| 5Q0-907-572-V1.clb
   Part No SW: 5Q0 907 572 F    HW: 5Q0 907 572 F
   Component: ACC Bosch MQB H05 0400  
   Serial number: 23081503212727
   Coding: 001C1300FE0739
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_ACCMRRBoschVW372 001016
   ROD: EV_ACCMRRBoschVW372_VW26.rod
   VCID: 3A2D33DB1CDCCEB7C41-806E

1 Fault Found:
1043 - Automatic Distance Control 
          B10E7 F0 [008] - Disconnected
          [FAULT_CIS_TSK_IRREV_FAIL]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 1
                    Reset counter: 220
                    Mileage: 49166 km
                    Date: 2019.06.22
                    Time: 13:11:48

                    Control Module temperature: 17 °C
                    Voltage terminal 15: 12.6 V
                    Vehicle speed: 0.00 m/s
                    Acceleration: 0.00 m/s²


-------------------------------------------------------------------------------
Address 14: Susp. Elect. (J250)       Labels: 5Q0-907-376.clb
   Part No SW: 5Q0 907 376 A    HW: 5Q0 907 376 A
   Component: DAEMPFUNGS-SG H17 0120  
   Serial number: 09101541350449
   ASAM Dataset: EV_DRCONTITEMIC 001019
   ROD: EV_DRCONTITEMIC_VW37.rod
   VCID: 372B2AEF2FCED3DF3BF-8062

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels:| 5Q0-959-655.clb
   Part No SW: 5Q0 959 655 AA    HW: 5Q0 959 655 AA
   Component: AirbagVW20    015 0388  
   Serial number: 003MLR138CZ3
   Coding: 98CCC000000000005C00000000C800000065
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_AirbaVW20SMEVW37X 002130
   ROD: EV_AirbaVW20SMEVW37X.rod
   VCID: 7F5B02CF477E2B9FB3F-802A

   Belt Pretensioner left: 
   Subsystem 1 - Part No SW: 5G0 980 945 B    HW: 5G0 980 945 B
   Component: BeltPretRevFL  H36 0350 
   Serial number: 34169677B07101540181
   Coding: 333135

   Belt Pretensioner right: 
   Subsystem 2 - Part No SW: 5G0 980 946 B    HW: 5G0 980 946 B
   Component: BeltPretRevFR  H36 0350 
   Serial number: 34169676B06101590769
   Coding: 333135

   Side Sensor Driver Front: 
   Subsystem 3 - Part No SW: -----------    HW: 480 002 809 15
   Component: SideSensor_Df  001 0887 
   Serial number: 3576700000054790B61S
   Coding: 2D2D2D

   Side Sensor Passenger Front: 
   Subsystem 4 - Part No SW: -----------    HW: 480 002 809 15
   Component: SideSensor_Pf  001 0887 
   Serial number: 35867000000D5941961Y
   Coding: 2D2D2D

   Side Sensor Driver Rear: 
   Subsystem 5 - Part No SW: -----------    HW: 480 403 009 15
   Component: SideSensor_Dr  001 6149 
   Serial number: 3516502C31CF2D7141EL
   Coding: 2D2D2D

   Side Sensor Passenger Rear: 
   Subsystem 6 - Part No SW: -----------    HW: 480 403 009 15
   Component: SideSensor_Pr  001 6149 
   Serial number: 3526502B91CF2DA4030H
   Coding: 2D2D2D

   Front Sensor Driver: 
   Subsystem 7 - Part No SW: -----------    HW: 480 403 009 15
   Component: FrontSensor_D  001 6149 
   Serial number: 3556502AB1CF2D75030J
   Coding: 2D2D2D

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel (J527)       Labels:| 5Q0-953-549.clb
   Part No SW: 5Q0 953 507 HN    HW: 5Q0 953 549 E
   Component: Lenks. Modul  003 0110  
   Revision: --------    Serial number: 03101504220493
   Coding: 0C10
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_SMLSKLOMQB 017001
   ROD: EV_SMLSKLOMQB_010_VW37.rod
   VCID: 094F9C1709BA152F9DB-805C

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 5G0-920-XXX-17.clb-SRI3
   Part No SW: 5G1 920 758 A    HW: 5G1 920 758 A
   Component: KOMBI         302 6420  
   Coding: 272D08183F88000801886A095400000000000000
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_DashBoardVDDMQBAB 009046
   ROD: EV_DashBoardVDDMQBAB_009_VW37.rod
   VCID: 2D070887DD92690F513-8078

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels:| 5Q0-907-530-V1.clb
   Part No SW: 5Q0 907 530 AF    HW: 5Q0 907 530 F
   Component: GW MQB High   128 1223  
   Revision: --------    Serial number: 0004017225
   Coding: 030100043F085900FB00027E9C0F00010001050000000000000000000000
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_GatewLear 013020
   ROD: EV_GatewLear_013.rod
   VCID: 75B7E0E7754261CFE93-8020

   Alternator: 

   Multi Function Steering Wheel Control Module: 
   Subsystem 2 - Part No SW: 5G0 959 442 N    HW: 5G0 959 442 N  Labels: 3C8-959-537.CLB
   Component: E221__MFL-DC1  H10 0040 
   Serial number: 29150001765000105382
   Coding: 2DFFFF

   Battery Monitoring Control Module: 
   Subsystem 3 - Part No SW: 5Q0 915 181 G    HW: 5Q0 915 181 G
   Component: J367-BDMHella  H04 8050 
   Serial number: 7462318003          

No fault code found.

-------------------------------------------------------------------------------
Address 22: AWD (J492)       Labels:* 0CQ-907-554.clb
   Part No SW: 0CQ 907 554 H    HW: 0CQ 525 130 
   Component: Haldex4Motion H52 7083  
   Serial number: HA1-00014.08.15
   Coding: 0001
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_AllWheelContrHA1VW37X 004013
   ROD: EV_AllWheelContrHA1VW37X_004.rod
   VCID: 4ACD631B4C3C5E37541-801E

No fault code found.

-------------------------------------------------------------------------------
Address 2B: Steer. Col. Lock (J764)       Labels:* 5Q0-905-861.clb
   Part No SW: 5Q0 905 861 A    HW: 5Q0 905 861 A
   Component: ELV-MQBA      H01 0120  
   Revision: 00000000    Serial number: 15000219118010
   Coding: 5D00000000000000
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_ELVMarquMQB 004111
   ROD: EV_ELVMarquMQB.rod
   VCID: 34311DE33EB838C71ED-8060

No fault code found.

-------------------------------------------------------------------------------
Address 3C: Lane Change (J1086)       Labels:| 5Q0-907-686.clb
   Part No SW: 5Q0 907 686 B    HW: 5Q0 907 686 B
   Component: HRE_Master    H11 0071  
   Serial number: 0381851243
   Coding: 02011203
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_HREntryHella 001028
   ROD: EV_HREntryHella_VW37.rod
   VCID: 3C2135C316E8F087D6D-8068

   Lane Change Assistant 2: 
   Subsystem 1 - Part No SW: 5Q0 907 685 B    HW: 5Q0 907 685 B
   Component: HRE_Slave  H11 0071 
   Serial number: 0381863340          
   Coding: 020112

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386)       Labels:| 5QX-959-X93-42.clb
   Part No SW: 5Q0 959 593 E    HW: 5Q0 959 593 B
   Component: TSG FS        020 0041  
   Serial number: 220915BIL04483
   Coding: 003E12208001048000001000
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_DCUDriveSideEWMAXKLO 006003
   ROD: EV_DCUDriveSideEWMAXCONT.rod
   VCID: 43D34E3F6B168F7F977-8016

   Drivers Door Rear Control Module: 
   Subsystem 1 - Part No SW: 5Q0 959 812     HW: 5Q0 959 812   Labels: 5QX-959-81X-V1.CLB
   Component: FOND_FHSG_DRV  005 0005 
   Serial number: 00000000000007600373
   Coding: 0D0000

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist (J500)       Labels:| 5Q0-909-144.clb
   Part No SW: 3Q0 909 144 J    HW: 3Q0 909 144 H
   Component: EPS_MQB_ZFLS  505 5063  
   Coding: 8103
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_SteerAssisMQB 012140
   ROD: EV_SteerAssisMQB_012_VW37.rod
   VCID: 392F2CD719DAC5AFCDB-806C

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387)       Labels:| 5QX-959-X92-52.clb
   Part No SW: 5Q0 959 592 E    HW: 5Q0 959 592 B
   Component: TSG BFS       020 0041  
   Serial number: 250915BIO13175
   Coding: 003E10208E01048000801000
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_DCUPasseSideEWMAXKLO 006003
   ROD: EV_DCUPasseSideEWMAXCONT.rod
   VCID: 42DD4B3B740C86779C1-8016

   Passengers Rear Door Control Module: 
   Subsystem 1 - Part No SW: 5Q0 959 811     HW: 5Q0 959 811   Labels: 5QX-959-81X-V1.CLB
   Component: FOND_FHSG_PSG  005 0005 
   Serial number: 00000000000007468013
   Coding: 150000

No fault code found.

-------------------------------------------------------------------------------
Address 55: Headlight Range (J745)       Labels:| 7P6-907-357.clb
   Part No SW: 7P6 907 357 D    HW: 7P6 907 357 A
   Component: AFS-ECU       H07 0090  
   Revision: --------    Serial number: --------------
   Coding: 02A602000B000200
   Shop #: WSC 01357 011 00200
   ASAM Dataset: EV_HeadlRegulVWAFSMQB 001120
   ROD: EV_HeadlRegulVWAFSMQB.rod
   VCID: 40D941337A0094678A5-8014

   Left Headlamp Power Output Stage: 
   Subsystem 1 - Part No SW: 3D0 941 329 E    HW: 3D0 941 329 E  Labels: 3D0-941-329.CLB
   Component: LeiMo links  H01 0002 
   Coding: 2E0000

   Right Headlamp Power Output Stage: 
   Subsystem 2 - Part No SW: 3D0 941 329 E    HW: 3D0 941 329 E  Labels: 3D0-941-329.CLB
   Component: LeiMo rechts  H01 0002 
   Coding: 2E0000

No fault code found.

-------------------------------------------------------------------------------
Address 5F: Information Electr. (J794)       Labels:| 5G0-035-MIB-STD2.clb
   Part No SW: 3Q0 035 846     HW: 3Q0 035 846 
   Component: MU-S-N-ER     820 0627  
   Serial number:               
   Coding: 02730008FF00000051510001000828001F0307D601200100C7
   Shop #: WSC 12345 123 12345
   ASAM Dataset: EV_MUStd4CDELP 001001
   ROD: EV_MUStd4CDELP_VW37.rod
   VCID: 6E85CF8B10145217289-803A

   Operating And Display Unit 1: 
   Subsystem 1 - Part No SW: 3G0 919 605 D    HW: 3G0 919 605 D
   Component: ABT_Std-2_Nav  H43 4064 
   Serial number: VWZ6Z9R2790762      

   Data medium: 
   Subsystem 2 - Part No SW: 3G0 919 866 K    HW: -----------
   Component: MRM2 2015/16  --- 0420 
   Serial number: --------------------

No fault code found.

-------------------------------------------------------------------------------
Address A9: Struct. Borne Sound (J869)       Labels: 4H0-907-159.clb
   Part No SW: 5G0 907 159 D    HW: 4H0 907 159 A
   Component: SAS-GEN 2     H07 0001  
   Serial number: 150908201126
   ASAM Dataset: EV_SoundActuaGen2AU64X 003010
   ROD: EV_SoundActuaGen2AU64X.rod
   VCID: 2F3B128FD79E1B1F63F-807A

No fault code found.

End----(Elapsed Time: 01:45, VBatt start/end: 11.9V/11.7V. VIgn 11.8V)-----
 
   #15  

Jack@European_Parts

Gone But Not Forgotten
Professional VCDS User
Joined
Jan 29, 2014
Messages
21,923
Reaction score
9,308
Location
Montgomery, NY, USA
VCDS Serial number
C?ID=57337
This means you are running deletes and the stack is effectively corrupted due to lazy tuner.
 
   #16  

Jack@European_Parts

Gone But Not Forgotten
Professional VCDS User
Joined
Jan 29, 2014
Messages
21,923
Reaction score
9,308
Location
Montgomery, NY, USA
VCDS Serial number
C?ID=57337
OP

Search online for stuff like EA888 GEN 3

https://www.carworklog.com/stuff/SS... engines of series EA888 (3rd generation).pdf

https://i.postimg.cc/5fqYvqMP/OP-SHOULDNT-START-MODS-WITHOUT-KNOWLEDGE.png?dl=1


OP-SHOULDNT-START-MODS-WITHOUT-KNOWLEDGE.png
 
Last edited:
   #17  

Mika Rummukainen

Verified VCDS User
Verified
Joined
Jun 29, 2019
Messages
10
Reaction score
6
Location
Canberra, AU
Wow, thanks mate, that's really handy. I've tried googling MAP sensor etc and looked into dozens of forums but found nothing, the links you've given are awesome. I've cleaned the G71 sensor and will clean the G31 sensor, now that I know where it is.

What does it mean that I am running deletes? Is that the turbo muffler delete?
 
   #18  

Jack@European_Parts

Gone But Not Forgotten
Professional VCDS User
Joined
Jan 29, 2014
Messages
21,923
Reaction score
9,308
Location
Montgomery, NY, USA
VCDS Serial number
C?ID=57337
The tuning code in your engine controller is modified and impaired to false present a readiness status, in addition this means fault codes or thresholds are vacated.
This is only done to perform a nefarious act and not inspirit of real Motorsports.
It means that the MIL may not illuminate when needed & to warn you of a possible error.
In cases like this and due to lazy tuners it will or may make diagnosis procedure's harder & since if controller doesn't report, than VCDS won't see in these cases either.
This is why it will be essential to know mechanicals and how things should operate in addition to manual test methods RTFB and SSP.

A second stock controller also may aid you for things like this too & make VCDS a stronger tool for you in combination.
 
   #19  

Mika Rummukainen

Verified VCDS User
Verified
Joined
Jun 29, 2019
Messages
10
Reaction score
6
Location
Canberra, AU
Thanks mate, though the second scan with no faults was done after the faults were cleared and prior to starting and driving the car. The EPC light always comes on when a modest amount of boost is used after starting, it makes sense to me that a fault is not triggered prior to boost being generated. The fault is present in the log after driving and the EPC light being triggered.

I'm not too sure that it's a case of fault codes being hidden as the fault does arise when the car is made to boost and realises there is a discreapancy between the expected signal and the actual. Prior to that there is no discrepancy, hence no fault.
 
   #20  

Jack@European_Parts

Gone But Not Forgotten
Professional VCDS User
Joined
Jan 29, 2014
Messages
21,923
Reaction score
9,308
Location
Montgomery, NY, USA
VCDS Serial number
C?ID=57337
It's a generalization....
Did you check wiring as per known TSB for the TV harness being in error?
 
Back
Top