So I have a MK5 Golf GTI, with a lot of modifications. Recently I have changed to a TTRS fuel pump but I doubt that is the issue. The vehicle cranks, starts and then dies like a second after.
I am having a nightmare with this car and I have built it in the summer only for it to be standstill after about a week of use, but never occurred to have any of these errors regarding the communications.
These were the engine codes when the vehicle was in working order, with some issue regarding the alarm and rear doors not working properly.
00821 - antenna 2 for radio R93 open circuit
01334 - door control module rear right no signal/communication
01135 - interior monitoring sensors no signal
01134 - Alarm horn no signal
00931 - locking module for central locking rear rigght
00930 - locking module for central locking rear left
01314 - engine control module no signal
01333 - ecu left rear door no signal
00883 ignition switch D electrical problem in circuit intermittent
01305 - databus for infotainment no signal
01320 - climatronic ecu no sigal
05634 - power supply voltage 30 p1602 lower limit reached
05635 - inter control module failed self
Since then, it has died and I purchased a VCDS. (Scan will be below) However, I asked one of the FB groups and said it was the BCM that may be faulty, changed this and it worked for a full 2 days. I understand that it is something to do with the communications but I do not understand what, and where to go from here. If anyone could possibly help me that would be wonderful. I just want to drive my car!
I am having a nightmare with this car and I have built it in the summer only for it to be standstill after about a week of use, but never occurred to have any of these errors regarding the communications.
These were the engine codes when the vehicle was in working order, with some issue regarding the alarm and rear doors not working properly.
00821 - antenna 2 for radio R93 open circuit
01334 - door control module rear right no signal/communication
01135 - interior monitoring sensors no signal
01134 - Alarm horn no signal
00931 - locking module for central locking rear rigght
00930 - locking module for central locking rear left
01314 - engine control module no signal
01333 - ecu left rear door no signal
00883 ignition switch D electrical problem in circuit intermittent
01305 - databus for infotainment no signal
01320 - climatronic ecu no sigal
05634 - power supply voltage 30 p1602 lower limit reached
05635 - inter control module failed self
Since then, it has died and I purchased a VCDS. (Scan will be below) However, I asked one of the FB groups and said it was the BCM that may be faulty, changed this and it worked for a full 2 days. I understand that it is something to do with the communications but I do not understand what, and where to go from here. If anyone could possibly help me that would be wonderful. I just want to drive my car!
Code:
Tuesday,31,January,2023,17:23:19:02823
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 22.10.0.1 (x64) HEX-V2 CB: 0.4623.4
Data version: 20221026 DS344.0
www.Ross-Tech.com
VIN: WVWZZZ1KZ6W022316 License Plate:
Chassis Type: 1K-VW35 (1K0)
Scan: 01 03 08 09 15 16 17 19 22 25 42 44 46 52 55 56 62 72
VIN: WVWZZZ1KZ6W022316 Mileage: 224950km-139777miles
01-Engine -- Status: Cannot be reached 1100
03-ABS Brakes -- Status: Cannot be reached 1100
04-Steering Angle -- Status: Cannot be reached 1100
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: Cannot be reached 1100
16-Steering wheel -- Status: Malfunction 0010
17-Instruments -- Status: Malfunction 0010
19-CAN Gateway -- Status: Malfunction 0010
22-AWD -- Status: Cannot be reached 1100
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: Cannot be reached 1100
46-Central Conv. -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
55-Headlight Range -- Status: Cannot be reached 1100
56-Radio -- Status: Malfunction 1010
62-Door, Rear Left -- Status: Cannot be reached 1100
72-Door, Rear Right -- Status: Cannot be reached 1100
-------------------------------------------------------------------------------
Address 01: Engine
Cannot be reached
-------------------------------------------------------------------------------
Address 03: ABS Brakes
Cannot be reached
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels:| 5K0-907-044.clb
Part No SW: 5K0 907 044 HA HW: 5K0 907 044 HA
Component: Climatronic H19 1414
Revision: 00001004
Coding: 0010004003
Shop #: WSC 01357 011 00200
ASAM Dataset: EV_Climatronic A01010
ROD: EV_ClimaAutoBasis_VW36.rod
VCID: 71BFD998F129AAF314C-8024
12 Faults Found:
9472881 - Motor for Fresh Air / Recirculated Air Flap
B108B 71 [024] - Actuator Stuck
Intermittent - Confirmed - Not Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 34
Mileage: 224957 km
Date: 2000.00.00
Time: 00:01:27
13701376 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[Motorsteuergerät - kein Signal/Kommunikation]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 2
Reset counter: 34
Mileage: 224957 km
Date: 2000.00.00
Time: 00:01:26
13701392 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[Bremsensteuergerät - kein Signal/Kommunikation]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 4
Reset counter: 34
Mileage: 224957 km
Date: 2000.00.00
Time: 00:01:26
13701424 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[Steuergerät für Bordnetz - kein Signal/Kommunikation]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 2
Reset counter: 34
Mileage: 224957 km
Date: 2000.00.00
Time: 00:01:26
13701456 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[Steuergerät im Schalttafeleinsatz - kein Signal/Kommunikation]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 2
Reset counter: 34
Mileage: 224957 km
Date: 2000.00.00
Time: 00:01:26
13701520 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[Türsteuergerät hinten links - kein Signal/Kommunikation]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 2
Reset counter: 34
Mileage: 224957 km
Date: 2000.00.00
Time: 00:01:26
13701536 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[Türsteuergerät hinten rechts - kein Signal/Kommunikation]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 2
Reset counter: 34
Mileage: 224957 km
Date: 2000.00.00
Time: 00:01:26
9481748 - High Pressure Sensor
B10AE 14 [009] - Open or Short to Ground
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Reset counter: 34
Mileage: 224957 km
Date: 2000.00.00
Time: 00:01:26
9496597 - Sunlight Photo Sensor
B10E8 15 [009] - Open or Short to Plus
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 3
Fault Frequency: 1
Reset counter: 34
Mileage: 224957 km
Date: 2000.00.00
Time: 00:01:26
9496613 - Sunlight Photo Sensor
B10E8 15 [009] - Open or Short to Plus
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 3
Fault Frequency: 1
Reset counter: 34
Mileage: 224957 km
Date: 2000.00.00
Time: 00:01:26
9479189 - Signal Line for Air Quality Sensor
B10A4 15 [008] - Open or Short to Plus
Intermittent - Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 3
Fault Frequency: 2
Reset counter: 74
Mileage: 224957 km
Date: 2000.00.00
Time: 00:01:26
13701600 - Function Restricted due to Missing Message(s)
U1111 00 [009] - -
[Airbagsteuergerät - kein Signal/Kommunikation --> Fehlende Botschaft [ID] von Airbagsteuergerät]
Confirmed - Tested Since Memory Clear
Freeze Frame:
Fault Status: 00000001
Fault Priority: 6
Fault Frequency: 3
Reset counter: 34
Mileage: 224957 km
Date: 2000.00.00
Time: 00:01:26
-------------------------------------------------------------------------------
Address 09: Cent. Elect. Labels:. 3C0-937-049-23-H.lbl
Part No SW: 3C0 937 049 E HW: 3C0 937 049 E
Component: Bordnetz-SG H37 1002
Revision: 00H37000 Serial number: 00000001996961
Coding: E78D8F2700041800001400001400000000087F075C
Shop #: WSC 12345 785 00200
VCID: 2B030BF01F0580236E0-807E
Subsystem 1 - Part No: 1K2 955 119 C Labels: 1KX-955-119.CLB
Component: Wischer VW350 012 0402
Coding: 00065493
Shop #: WSC 12345
Subsystem 2 - Part No: 1K0 955 559 R Labels: 1K0-955-559-AF.CLB
Component: RegenLichtSens 010 1010
Coding: 00207646
Shop #: WSC 12345
10 Faults Found:
02394 - Parking Light Left Front (M1)
012 - Electrical Fault in Circuit - Intermittent
Freeze Frame:
Fault Status: 00101100
Fault Priority: 2
Fault Frequency: 40
Reset counter: 74
Mileage: 171207 km
Time Indication: 0
Freeze Frame:
OFF
Voltage: 10.60 V
OFF
ON
OFF
OFF
OFF
02498 - Left Low Beam Reflector Motor (V294)
012 - Electrical Fault in Circuit
Freeze Frame:
Fault Status: 01111100
Fault Priority: 3
Fault Frequency: 1
Reset counter: 34
Mileage: 150486 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 13.75 V
ON
ON
OFF
OFF
OFF
02499 - Right Low Beam Reflector Motor (V295)
012 - Electrical Fault in Circuit
Freeze Frame:
Fault Status: 01111100
Fault Priority: 3
Fault Frequency: 1
Reset counter: 34
Mileage: 150486 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 13.75 V
ON
ON
OFF
OFF
OFF
01495 - Bulb for High-Beams; Left (M30)
010 - Open or Short to Plus
Freeze Frame:
Fault Status: 01101010
Fault Priority: 3
Fault Frequency: 1
Reset counter: 34
Mileage: 224957 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 12.15 V
ON
ON
OFF
OFF
OFF
01499 - Bulb for High-Beams; Right (M32)
010 - Open or Short to Plus
Freeze Frame:
Fault Status: 01101010
Fault Priority: 3
Fault Frequency: 1
Reset counter: 34
Mileage: 224957 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 12.15 V
ON
ON
OFF
OFF
OFF
01333 - Door Control Module; Rear Left (J388)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 2
Reset counter: 34
Mileage: 224957 km
Time Indication: 0
Freeze Frame:
OFF
Voltage: 12.35 V
OFF
ON
OFF
OFF
OFF
01334 - Door Control Module; Rear Right (J389)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 2
Reset counter: 34
Mileage: 224957 km
Time Indication: 0
Freeze Frame:
OFF
Voltage: 12.35 V
OFF
ON
OFF
OFF
OFF
01321 - Control Module for Airbags (J234)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 34
Mileage: 224957 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 12.25 V
ON
ON
OFF
OFF
OFF
01314 - Engine Control Module
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 34
Mileage: 224957 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 12.25 V
ON
ON
OFF
OFF
OFF
00975 - Heated Rear Window (Z1)
012 - Electrical Fault in Circuit
Freeze Frame:
Fault Status: 01111100
Fault Priority: 5
Fault Frequency: 1
Reset counter: 34
Mileage: 151744 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 13.35 V
ON
ON
OFF
OFF
OFF
-------------------------------------------------------------------------------
Address 15: Airbags
Cannot be reached
-------------------------------------------------------------------------------
Address 16: Steering wheel Labels: 1K0-953-549-MY8.lbl
Part No SW: 1K0 953 549 AG HW: 1K0 953 549 AG
Component: J0527 634 0070
Coding: 0012112
Shop #: WSC 01279 785 00200
VCID: 77ABE78093CDF4C3DA8-8022
Subsystem 1 - Part No: XXXXXXXXXXX
Component: E0221 007 0050
1 Fault Found:
00002 - Transmission Control Unit
004 - No Signal/Communication
-------------------------------------------------------------------------------
Address 17: Instruments Labels: 1K0-920-xxx-17.lbl
Part No: 1K6 920 962
Component: KOMBIINSTRUMENT VDD 1012
Coding: 0003403
Shop #: WSC 00011 067 57207
VCID: 6E85C2E4EC97B50B09E-803A
7 Faults Found:
00438 - Fuel Supply Sensor 2 (G169)
010 - Open or Short to Plus - Intermittent
00438 - Fuel Supply Sensor 2 (G169)
015 - Cannot Be Tested at this Time
01309 - Power Steering Control Module (J500)
004 - No Signal/Communication
01314 - Engine Control Module
004 - No Signal/Communication
01316 - ABS Control Module
004 - No Signal/Communication
01321 - Control Module for Airbags (J234)
004 - No Signal/Communication
01771 - Control Module for Headlight Range (J431)
004 - No Signal/Communication
-------------------------------------------------------------------------------
Address 19: CAN Gateway Labels:. 1K0-907-530-V4.clb
Part No SW: 1K0 907 530 AD HW: 1K0 907 951
Component: J533 Gateway H16 0231
Revision: H16 Serial number: 4320K09A2501A2
Coding: E9837F06000202002103
Shop #: WSC 06314 000 00000
VCID: 698FB1F8D57952335CC-803C
5 Faults Found:
01333 - Door Control Module; Rear Left (J388)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 34
Mileage: 224957 km
Time Indication: 0
01334 - Door Control Module; Rear Right (J389)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 34
Mileage: 224957 km
Time Indication: 0
01305 - Databus for Infotainment
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 1
Fault Frequency: 1
Reset counter: 74
Mileage: 224957 km
Time Indication: 0
01304 - Radio
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 74
Mileage: 224957 km
Time Indication: 0
01312 - Powertrain Data Bus
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 1
Fault Frequency: 1
Reset counter: 34
Mileage: 224957 km
Time Indication: 0
-------------------------------------------------------------------------------
Address 22: AWD
Cannot be reached
-------------------------------------------------------------------------------
Address 25: Immobilizer Labels: 1K0-920-xxx-25.clb
Part No: 1K6 920 962
Component: IMMO VDD 1012
Shop #: WSC 00000 000 00000
VCID: 6E85C2E4EC97B50B09E-803A
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver Labels:. 1K0-959-701-MIN3.clb
Part No SW: 1K0 959 701 M HW: 1K0 959 701 M
Component: Tuer-SG 005 0972
Coding: 0000692
Shop #: WSC 01279 785 00200
VCID: 382924BCDE533BBB132-806C
No fault code found.
-------------------------------------------------------------------------------
Address 44: Steering Assist
Cannot be reached
-------------------------------------------------------------------------------
Address 46: Central Conv. Labels:. 1K0-959-433-MIN.clb
Part No: 1K0 959 433 AK
Component: KSG 0401
Coding: 01C802087F2D8405485FC69010CC
Shop #: WSC 00000 785 00200
VCID: 79AFE1B8A5D9E2B3ACC-802C
Subsystem 1 - Component: Sounder No Answer
Subsystem 2 - Component: NGS No Answer
Subsystem 3 - Component: IRUE No Answer
6 Faults Found:
01333 - Door Control Module; Rear Left (J388)
004 - No Signal/Communication
01334 - Door Control Module; Rear Right (J389)
004 - No Signal/Communication
01135 - Interior Monitoring Sensors
004 - No Signal/Communication
00323 - Vehicle Inclination Sensor (G384)
004 - No Signal/Communication
01134 - Alarm Horn (H12)
004 - No Signal/Communication
01312 - Powertrain Data Bus
013 - Check DTC Memory
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. Labels:. 1K0-959-702-MIN3.clb
Part No SW: 1K0 959 702 M HW: 1K0 959 702 M
Component: Tuer-SG 005 0972
Coding: 0000692
Shop #: WSC 01279 785 00200
VCID: 392F21B8E55922B3ECC-806C
No fault code found.
-------------------------------------------------------------------------------
Address 55: Headlight Range
Cannot be reached
-------------------------------------------------------------------------------
Address 56: Radio (J503) Labels:. 5M0-035-1xx-56.clb
Part No SW: 5M0 035 186 J HW: 5M0 035 186 J
Component: Radio RCD310 042 0082
Revision: 01000001 Serial number: VWZ1Z2M4102409
Coding: 01000400020001
Shop #: WSC 31414 790 31414
VCID: 33331390CB35D8E3260-8066
2 Faults Found:
00625 - Vehicle Speed Signal
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 6
Fault Frequency: 5
Reset counter: 34
Mileage: 224957 km
Time Indication: 0
Date: 2000.00.00
Time: 00:01:47
00821 - Antenna 2 for Radio (R93)
011 - Open Circuit
Freeze Frame:
Fault Status: 01101011
Fault Priority: 5
Fault Frequency: 1
Reset counter: 34
Mileage: 224957 km
Time Indication: 0
Date: 2000.00.00
Time: 00:01:44
-------------------------------------------------------------------------------
Address 62: Door, Rear Left
Cannot be reached
-------------------------------------------------------------------------------
Address 72: Door, Rear Right
Cannot be reached
End----------(Elapsed Time: 00:50, VBatt start/end: 12.2V/12.2V)-----------