2012-2014 NAR Passat(A32) TDI/CKRA – AdBlue Level Reset Procedure

   #1  

DrPeter

Ross-Tech Employee
Ross-Tech Employee
Joined
Jan 29, 2014
Messages
1,963
Reaction score
3,616
Location
16.4905° S, 151.7375° W
Hello,

The following procedure is intended for all NAR spec Passat TDI (A32) vehicles from 2012 to 2014 with the CKRA - 103kW-140HP 2.0L TDI engine.


Please provide feed back on this as this is currently untested, thank you.


2012-2014 NAR Passat(A32) TDI/CKRA – AdBlue Level Reset Procedure

Prerequisites:
- Engine fully warmed up (above 80’C) and idling
- Transmission in Park/Neutral
- Emergency brake = On
- Doors and hood are closed
- Do not depress any pedals during this procedure, until instructed to do so.

To Reset the AdBlue Level:

- Clear all fault codes(yes, even if there are none present)
- Select 01-Engine]
- Select [Basic Settings-04]
- From the pull down menu choose:
- - - [Resetting of learned values of average quantity adaptation], press [Go!]
- - - - After completion, Press [Stop]
- - - Then [Reset learned values quant. meter. unit and press. contr. Valve], press [Go!]
- - - - After completion, Press [Stop]
- Select [Check of SCR efficiency], press [Go!]
- Depress Brake pedal, then depress accelerator pedal, the ECM should take control of the Engine speed.
- This test may take up to 30+ minutes to complete!
- Upon completion, you should see ‘System Okay’, the AdBlue light and the warning message about ‘miles to no start’ will be reset. Verify there are no fault codes.

Done, end…


Please provide feed back on this as this is currently untested, thank you.

Edit - The following additional steps may need to be performed:

  • Basic Settings IDE04567 Resetting of SCR tank level detection
  • Basic Settings IDE04730 Reset SCR lock
  • Test drive vehicle


drpeter
 
Last edited by a moderator:
   #2  

kantusjack

Verified VCDS User
Verified
Joined
Apr 14, 2015
Messages
28
Reaction score
8
Location
Spain
VCDS Serial number
C?ID=69091
Hi Dr Peter,

Do you know if this procedure is valid for a VW Sharan CFGB Engine??? Do you know where can I get a procedure for a CFGB engine???
 
   #3  

DrPeter

Ross-Tech Employee
Ross-Tech Employee
Joined
Jan 29, 2014
Messages
1,963
Reaction score
3,616
Location
16.4905° S, 151.7375° W
Do you know if this procedure is valid for a VW Sharan CFGB Engine??? Do you know where can I get a procedure for a CFGB engine???

I do not, you may try it on any vehicle/engine configuration you like, I can dig into and see if I can find anything for the CFGB.

- If you could please start a new post/thread in Car Repair Support asking this question and please post a complete vehicle Auto-Scan.

I would like it if the posts here could be feedback on this procedure,

Thank you,

drpeter
 
Last edited:
   #4  

Dana

Administrator
Staff member
Administrator
Ross-Tech Employee
Joined
Jan 29, 2014
Messages
5,970
Reaction score
8,954
Location
Western PA, USA
This is just an internal note but that self test resolved ST?ID=71990

Summary for the public:
2012 NAR market TDI Passat with a BUNCH of new parts: Engine, Turbo, DPF, etc major mechanical repairs 10K ago. New NOx CAT, NOx sensor, 2.5 Gallons of AdBlue etc.. currently.

> Address 01: Engine (J623-CKRA) Labels: 03L-906-012-CKR.clb
> Part No SW: 03L 906 012 BP HW: 03L 907 309 S
> Component: R4 2,0L EDC H21 7445
> Revision: 71H21--- Serial number:
> Coding: 001D0012042400008000
> Shop #: WSC 28044 001 1048576
> ASAM Dataset: EV_ECM20TDI01103L906012BP 004009
> ROD: EV_ECM20TDI01103L906012BP.rod
> VCID: 73E456EFDA1061DAB1-8026
>
> No fault code found.
> Readiness: 0 0 0 0 1

It was threatening 15 miles until it wouldn't restart so she couldn't drive for 40-50 miles to let things happen naturally. The normal Reset SCR lock (finished correctly) followed by Resetting of SCR tank level detection (finished correctly) steps were not working and a couple mile test drive didn't help either. Peter's Check of SCR efficiency Finished Correctly within 5 min and then Resetting of SCR tank level detection finally worked! She needs to drive and see at this point.

The NOx sensor 1 test didn't complete after 13 min of holding the brake and gas.. but it would have been ideal to see it report Finished Correctly.
 
   #5  

MartinsX

Verified VCDS User
Verified
Joined
Sep 5, 2016
Messages
1,229
Reaction score
1,311
Location
Riga, Latvia
VCDS Serial number
C?ID=268515
Hi!
Do anyone know, will procedure in post #1 work for European market VW Sharan with 2,0 TDI engine CFFA?
Ad Blue warning is on, no fault codes, "Resetting of SCR tank level" didn't help. Ad Blue tank is filled.
The car will come back tomorrow, I'll try to dig deeper into this.
Second question - is the remaining times to start engine warning a real thing? I.e. engine will not start after counter will reach 0?
Code:
Wednesday,28,December,2016,18:07:39:32442
VCDS -- Windows Based VAG/VAS Emulator Running on Windows XP x86
VCDS Version: 16.8.3.1
Data version: 20161010 DS267.0
www.Ross-Tech.com

Workshop Code: 123 12345 012345

VIN: WVWZZZ7NZBV040245   License Plate: 


Chassis Type: 7N (7N0)
Scan: 01 03 08 09 15 16 17 19 25 37 42 44 46 52 53 56 61 62 72

VIN: WVWZZZ7NZBV040245   Mileage: 203400km-126386miles

01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
37-Navigation -- Status: OK 0000
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
56-Radio -- Status: OK 0000
61-Battery Regul. -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: Malfunction 0010
 
-------------------------------------------------------------------------------
Address 01: Engine (J623-CFFA)       Labels: 03L-906-018-CFF.clb
   Part No SW: 03L 906 018 H    HW: 03L 907 309 Q
   Component: R4 2,0L EDC   H24 8254  
   Revision: 44H24---    Serial number:               
   Coding: 00190012040401080000
   Shop #: WSC 00020 999 00000
   ASAM Dataset: EV_ECM20TDI01103L906018H 003006
   ROD: EV_ECM20TDI01103L906018H.rod
   VCID: 2F6D79837663F63A15-807A

No fault code found.
Readiness: 0 0 0 0 0 

-------------------------------------------------------------------------------
Address 03: ABS Brakes        Labels: 7N0-614-109.clb
   Part No SW: 7N0 614 109 M    HW: 7N0 614 109 M
   Component: J104   C3 450M VD90 0009  
   Revision: --H07---    Serial number: 00000004159246
   Coding: 0018967
   Shop #: WSC 00020 790 00000
   VCID: 377D41E346333EFA4D-8062

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301)       Labels: 3C8-907-336.clb
   Part No SW: 7N0 907 426 K    HW: 7N0 907 426 K
   Component: AC Manuell    H17 0202  
   Revision: 00001012    
   Coding: 0000000003
   Shop #: WSC 00020 999 00000
   ASAM Dataset: EV_Climatic A01005
   ROD: EV_ClimaBasis_VW36.rod
   VCID: 3C775ECFB7151DA2A0-8068

1 Fault Found:
9477489 - Motor for Air Distribution Flap 
          B109D 71 [008] - Actuator stuck
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 12
                    Reset counter: 183
                    Mileage: 203368 km
                    Date: 2016.12.28
                    Time: 10:23:10


-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels: 1K0-937-08x-09.clb
   Part No SW: 5K0 937 084 F    HW: 5K0 937 084 F
   Component: BCM PQ35 B    011 0048  
   Revision: BA011001    
   Coding: 40180A3B81251AC0400800C0100000E443011308424D01626480872000C1
   Shop #: WSC 00020 790 00000
   VCID: 35614BEB9C3FCCEA5F-8060

   Subsystem 1 - Part No SW: 7N1 955 119 A    HW: 7N1 955 119   Labels: 1KX-955-119.CLB
   Component: WWS    110406  31  0032 
   Serial number:         110426211537
   Coding: 004DBD

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels: 5K0-959-655.clb
   Part No SW: 7N0 959 655 B    HW: 7N0 959 655 B
   Component: VW10Airbag01L H07 0013  
   Serial number: 003GFP8AP2DV
   Coding: 00314C
   Shop #: WSC 00020 999 00000
   ASAM Dataset: EV_AirbaVW10TS6VW428 A01002
   ROD: EV_AirbaVW10TS6VW428.rod
   VCID: 3E7354C7A1090FB28E-806A

   Crash sensor for side airbag: driver side: 
   Subsystem 1 - Part No SW: ---            HW: ---        
   Component: S.Sens.Fahr.V  --- ---  
   Serial number: 3493ETS60956007149DL
   Coding: 000000

   Crash sensor for side airbag: front passenger side: 
   Subsystem 2 - Part No SW: ---            HW: ---        
   Component: S.Sens.Beif.V  --- ---  
   Serial number: 3503ETS60782A0B14DDS
   Coding: 000000

   Crash sensor for side airbag: rear: driver side: 
   Subsystem 3 - Part No SW: ---            HW: ---        
   Component: S.Sens.Fah  --- ---  
   Serial number: 3513ETS6020480B14DDG
   Coding: 000000

   Crash sensor for side airbag: rear: passenger side: 
   Subsystem 4 - Part No SW: ---            HW: ---        
   Component: S.Sens.Beif.H  --- ---  
   Serial number: 3523ETS60CE38F813DD8
   Coding: 000000

   Crash sensor for front airbag: driver side: 
   Subsystem 5 - Part No SW: ---            HW: ---        
   Component: F.Sens.Fahr  --- ---  
   Serial number: 35540TS60FE8EE6139D5
   Coding: 000000

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel (J527)       Labels: 5K0-953-569.clb
   Part No SW: 5K0 953 501 BG    HW: 5K0 953 569 K
   Component: LENKS.MODUL   014 0140  
   Revision: FF010040    Serial number: 20110415200198
   Coding: 1182040000
   Shop #: WSC 00020 999 00000
   ASAM Dataset: EV_VW360SteerWheelUDS A03004
   ROD: EV_VW360SteerWheelUDS.rod
   VCID: 70EFBAFFABDDA9C24C-8024

   Multifunction steering wheel control module: 
   Subsystem 1 - Part No SW: 3C8 959 537 D    HW: 3C8 959 537 D  Labels: 3C8-959-537.CLB
   Component: E221__MFL-TK6  H06 0022 
   Coding: E20000

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels: 5K0-920-xxx-17.clb
   Part No SW: 7N0 920 870 A    HW: 7N0 920 870 A
   Component: KOMBI         H20 0420  
   Serial number: 00000000000000
   Coding: 140F00
   Shop #: WSC 00020 999 00000
   ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04086
   ROD: EV_Kombi_UDS_VDD_RM09_004_VW25.rod
   VCID: 306F7AFF6B5DE9C20C-8064

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels: 7N0-907-530-V2.clb
   Part No SW: 7N0 907 530 D    HW: 1K0 907 951 
   Component: J533  Gateway H35 0614  
   Revision:   H35       Serial number: 010511F2001495
   Coding: 468002
   Shop #: WSC 00020 790 00000
   VCID: 31697FFB6857E0CA03-8064

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels: 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5K0 953 234 
   Component: IMMO          H20 0420  
   Serial number:               
   Coding: 000000
   Shop #: WSC 00000 000 00000
   ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03008
   ROD: EV_Immo_UDS_VDD_RM09_VW21.rod
   VCID: 6ADBA8978D01531202-803E

No fault code found.

-------------------------------------------------------------------------------
Address 37: Navigation (J794)       Labels: 1K0-035-27x-37.clb
   Part No SW: 3C0 035 279     HW: 3C0 035 279 
   Component: RNS315        H05 0010  
   Serial number: VWZAZ2L3336528
   Coding: 000004110400000000021000
   Shop #: WSC 00020 999 00000
   ASAM Dataset: EV_RNS315VWEUV1UDS A01005
   ROD: EV_RNS315VWEUV1UDS.rod
   VCID: 60CFCABF7B3D1942DC-8034

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386)       Labels: 7N0-959-793.clb
   Part No SW: 7N0 959 793 D    HW: 7N0 959 793 
   Component: TSG FA        H04 0400  
   Revision:             Serial number: 0000114814038 
   Coding: 011006208000411011
   Shop #: WSC 00020 790 00000
   VCID: 43852533C2EB625AE1-8016

1 Fault Found:
01705 - Selection Switch for Mirror-Adjust (E48) 
            008 - Implausible Signal
             Freeze Frame:
                    Fault Status: 01101000
                    Fault Priority: 3
                    Fault Frequency: 1
                    Reset counter: 142
                    Mileage: 203356 km
                    Time Indication: 0
                    Date: 2011.05.20
                    Time: 21:17:05


-------------------------------------------------------------------------------
Address 44: Steering Assist        Labels: 5N1-909-144.clb
   Part No SW: 5N1 909 144 L    HW: 5N1 909 148 G
   Component: J500__APA-BS KL.323 0802  
   Revision: 1AH03729    Serial number: 00111110295901
   Coding: 0000258
   Shop #: WSC 00020 790 00000
   VCID: 3B755DD37A1B1A9AA9-806E

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387)       Labels: 7N0-959-792.clb
   Part No SW: 7N0 959 792 D    HW: 7N0 959 792 
   Component: TSG BF        H04 0400  
   Revision:             Serial number: 0000115072360 
   Coding: 011006208000411011
   Shop #: WSC 00020 790 00000
   VCID: 428B2037DDF16B52EA-8016

No fault code found.

-------------------------------------------------------------------------------
Address 53: Parking Brake        Labels: 3AA-907-801.clb
   Part No SW: 3AA 907 801 E    HW: 3AA 907 801 E
   Component: J540 EPB4  VW-55183 0007  
   Revision:   H18       Serial number: 00000000326565
   Coding: 0024066
   Shop #: WSC 00020 790 00000
   VCID: 336575F3524BD2DA71-8066

No fault code found.

-------------------------------------------------------------------------------
Address 61: Battery Regul. (J840)       Labels: 1K0-907-534.clb
   Part No SW: 7N0 907 534     HW: 1K0 907 951 
   Component: Batt.regelung H35 0614  
   Serial number: 010511F2001495
   Coding: 030B185A
   Shop #: WSC 00020 790 00000
   VCID: 71E9BFFBA8D7A0CA43-8024

   Subsystem 1 - Part No SW: 1K0 915 181 F    HW: 1K0 915 181 A
   Component: J367-BDM  H07 0150 
   Serial number: 00000000009370410649

No fault code found.

-------------------------------------------------------------------------------
Address 62: Door, Rear Left
Cannot be reached

-------------------------------------------------------------------------------
Address 72: Door, Rear Right (J389)       Labels: 7N0-959-794.clb
   Part No SW: 7N0 959 794 E    HW: 7N0 959 795 A
   Component: TSG HR        H03 0400  
   Revision:             Serial number: 0000115373584 
   Coding: 010004200000411001
   Shop #: WSC 00020 790 00000
   VCID: 45813B2BCCDF5C6ACF-8010

1 Fault Found:
02131 - Child Safety Lock Motor 
            008 - Implausible Signal - Intermittent
             Freeze Frame:
                    Fault Status: 00101000
                    Fault Priority: 3
                    Fault Frequency: 1
                    Reset counter: 184
                    Mileage: 203403 km
                    Time Indication: 0
                    Date: 2011.05.21
                    Time: 17:52:47


End-------------------------(Elapsed Time: 02:49)--------------------------
 
   #6  

MartinsX

Verified VCDS User
Verified
Joined
Sep 5, 2016
Messages
1,229
Reaction score
1,311
Location
Riga, Latvia
VCDS Serial number
C?ID=268515
Procedure at post #1 did not work for this car. Nor similar procedures found in other topics here and in other sources of information. I was able to reset SCR level and SCR lock, but SCR efficiency test was refused by control module with message "Error. Request out of range". ECU software update at dealer from V.8254 to some newer version solved this out. TPI 2024801/4.
I can answer my second question, too - yes, when AdBlue system malfunction related countdown reaches 0, it is not possible to start engine.
 
   #7  

Galagonya

Verified VCDS User
Verified
Joined
Nov 16, 2017
Messages
1
Reaction score
1
Location
Hungary
VCDS Serial number
C?ID=279185
Confirmed

This method is confirmed on a 2011 VW Sharan 2.0. I forgot the enginecode sorry, but works for us.
We fought with the start because the conditions wasnt ready, but when its started and the procedure runs thru the result was great. :)

Thanks.
 
   #8  

roni024

Verified VCDS User
Verified
Joined
Jul 31, 2014
Messages
4
Reaction score
1
VCDS Serial number
C?ID=221779
I tried this reset procedure on my 2013 Passat TDI. During the check of SCR efficiency, the ECM never takes control of the engine speed. I gave up pressing the accelerator with my foot after 7 minutes. Is it normal in some cases to not have the ECM take over engine speed during that test? Should I just prop the pedal down with a push-rod and let it run longer?

Or, am I mistaken in thinking that I can remove my foot from the pedal after a few moments and the ECM will keep the RPMs around 1500?
 
   #9  

Uwe

Benevolent Dictator
Administrator
Joined
Jan 29, 2014
Messages
48,902
Reaction score
33,624
Location
USA
VCDS Serial number
HC100001
I tried this reset procedure on my 2013 Passat TDI. During the check of SCR efficiency, the ECM never takes control of the engine speed. I gave up pressing the accelerator with my foot after 7 minutes. Is it normal in some cases to not have the ECM take over engine speed during that test? Should I just prop the pedal down with a push-rod and let it run longer?

Or, am I mistaken in thinking that I can remove my foot from the pedal after a few moments and the ECM will keep the RPMs around 1500?
Did you have your other foot firmly on the brake pedal?

-Uwe-
 
   #10  

roni024

Verified VCDS User
Verified
Joined
Jul 31, 2014
Messages
4
Reaction score
1
VCDS Serial number
C?ID=221779
Yes, even when removing my foot from the accelerator to see if the RPMs would hold.

Edit: I should also mention, the glow plug indicator flashes during the procedure. I'm not sure if that's normal.
 
Last edited:
   #11  

Uwe

Benevolent Dictator
Administrator
Joined
Jan 29, 2014
Messages
48,902
Reaction score
33,624
Location
USA
VCDS Serial number
HC100001
So you're saying left foot on the brake, and accelerator pedal pressed to the floor, the ECU does not limit the engine speed to something reasonable?

ETA: Does your ECU have "Dieselgate Fix" software in it already?

-Uwe-
 
   #12  

roni024

Verified VCDS User
Verified
Joined
Jul 31, 2014
Messages
4
Reaction score
1
VCDS Serial number
C?ID=221779
ECU limits RPM to around 1500 RPM. I'm asking, is the ECU supposed to maintain that RPM when I remove my right foot from the accelerator and leave my left foot on the brake?

Edit: Dieselgate fix NOT installed
 
Last edited:
   #13  

Uwe

Benevolent Dictator
Administrator
Joined
Jan 29, 2014
Messages
48,902
Reaction score
33,624
Location
USA
VCDS Serial number
HC100001
ECU limits RPM to around 1500 RPM.
OK, that sounds correct.

I'm asking, is the ECU supposed to maintain that RPM when I remove my right foot from the accelerator and leave my left foot on the brake?
No, I don't think so. Basic Settings that require an elevated RPM (where the ECU controls the RPM) have been always been: One foot firmly on the brake, the other foot holding the loud pedal to the floor for as long as it takes.

-Uwe-
 
   #14  

roni024

Verified VCDS User
Verified
Joined
Jul 31, 2014
Messages
4
Reaction score
1
VCDS Serial number
C?ID=221779
Thank you for the explanation. After replacing the AdBlue heater assembly and pump (broke nipple when reinstalling tank), the AdBlue countdown would not go away. I tried a couple different reset procedures (the one outlined previously, and also Reset SCR fluid level - then Reset SCR lock) but the countdown remained. A couple of ignition cycles later and it went away. Maybe it took a little time for air to bleed from the reductant line. All is well.
 
  • Like
Reactions: Uwe
   #15  

golfi_vend

Verified VCDS User
Verified
Joined
Apr 9, 2014
Messages
2,303
Reaction score
2,250
Location
Tartu, Estonia
VCDS Serial number
C?ID=195131
This process helped me on imported NMS, that had range counting down with no faults.
After the process aborted it at least gave some faults.

I did update ECU software, cause on sharan the ECU software plays a huge role resetting adblue level. But no joy.
Seems like new sensor is needed(600 Euros)

Code:
Tuesday,10,April,2018,20:12:49:36026
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64
VCDS Version: 18.2.0.3 (x64)  HEX-NET CB: 0.4421.4
Data version: 20180212 DS287.0
www.Ross-Tech.com


VIN: 1VWBN7A35EC   License Plate: PASSAT USA2
Mileage: 78870km-49007mi   Repair Order: 


Chassis Type: A3-VW41 (7N0)
Scan: 01 02 03 08 09 15 16 17 19 1C 25 2E 42 44 46 4F 52 56 62 72
          75 77

VIN: 1VWBN7A35EC   Mileage: 78870km-49007miles

01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: Malfunction 0010
04-Steering Angle -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
1C-Position Sensing -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
4F-Centr. Electr. II -- Status: OK 0000
52-Door Elect, Pass. -- Status: Malfunction 0010
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
75-Telematics -- Status: Malfunction 0010
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CKRA)       Labels:. 03L-906-012-CKR.clb
   Part No SW: 03L 906 012 DE    HW: 03L 907 309 S
   Component: R4 2,0L EDC   H24 6073  
   Revision: 71H24---    Serial number:               
   Coding: 001D0012042400000000
   Shop #: WSC 09003 957 00200
   ASAM Dataset: EV_ECM20TDI01103L906012DE 004004
   ROD: EV_ECM20TDI01103L906012DE.rod
   VCID: 6A9809E48DF35314A6-803E

2 Faults Found:
18643 - NOx Sensor 1 Bank 1 
          P2200 00 [039] - Electrical Malfunction
          Not Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 78875 km
                    Date: 2018.04.10
                    Time: 20:09:43

                    Engine speed: 1497.50 /min
                    Normed load value: 16.9 %
                    Vehicle speed: 0 km/h
                    Coolant temperature: 96 °C
                    Intake air temperature: 33 °C
                    Ambient air pressure: 1010 mbar
                    Voltage terminal 30: 14.060 V
                    Unlearning counter according OBD: 40
                    Outside air temperature: 16.5 °C
                    Status of electrical malfunction of NOx sensor 1-Bits 0-7: 234
                    Exh.gas temp.sen 4: 448.6 °C
                    Mean injection quantity: 7.17 mg/stroke
                    Limitation: torque: 270.0 Nm

18644 - NOx Sensor 1 Bank 1 
          P2200 00 [039] - Electrical Malfunction
          Not Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 78875 km
                    Date: 2018.04.10
                    Time: 20:09:43

                    Engine speed: 1497.50 /min
                    Normed load value: 16.9 %
                    Vehicle speed: 0 km/h
                    Coolant temperature: 96 °C
                    Intake air temperature: 33 °C
                    Ambient air pressure: 1010 mbar
                    Voltage terminal 30: 14.060 V
                    Unlearning counter according OBD: 40
                    Air mass: actual value (mg/stroke): 667.7 mg/stroke
                    Mean injection quantity: 7.17 mg/stroke
                    EGR Vacuum Regulator Solen.val.: activation: 100.00 %
                    NOx emission NOx sensor 1: 0 ppm
                    Air mass for release of NOx sensor 1 offset test: 0.0 g
                    Calculated efficiency of NOx conversion: 0.648

Readiness: 0 0 0 1 1 

-------------------------------------------------------------------------------
Address 02: Auto Trans        Labels: 02E-927-770.clb
   Part No SW: 02E 300 062 B    HW: 02E 927 770 AL
   Component: GSG DSG AG6     521 4020  
   Revision: 05652104    Serial number: 00001310100063
   Coding: 0000020
   Shop #: WSC 09003 957 00200
   VCID: 1464771C37F735E4AC-8040

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104)       Labels:. 1K0-907-379-60EC1F.clb
   Part No SW: 1K0 907 379 BM    HW: 1K0 907 379 BM
   Component: ESP MK60EC1   H46 0164  
   Revision: 00H46001    
   Coding: C54BC0F5492800FBA30D03E7921A0042A1100012
   Shop #: WSC 09003 957 00200
   VCID: 7EB035B4E97BCFB46A-802A

1 Fault Found:
01325 - Control Module for Tire Pressure Monitoring (J502) 
            004 - No Signal/Communication - Intermittent
             Freeze Frame:
                    Fault Status: 00100100
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 194
                    Mileage: 78819 km
                    Time Indication: 0
                    Date: 2018.04.09
                    Time: 00:00:35

             Freeze Frame:
                    Count: 2
                    Count: 12
                    Count: 20480
                    Count: 16390
                    Count: 45312
                    Count: 0
                    Count: 511
                    Count: 0


-------------------------------------------------------------------------------
Address 08: Auto HVAC (J301)       Labels:| 3C8-907-336.clb
   Part No SW: 561 907 426 E    HW: 561 907 426 E
   Component: AC Manuell    H02 0303  
   Revision: 00001K02    
   Coding: 0010001002
   Shop #: WSC 09003 957 00200
   ASAM Dataset: EV_ACManuaElectGen2BHTC 001002
   ROD: EV_ACManuaElectGen2BHTC_VW36.rod
   VCID: 1D7212380C3D74AC13-8048

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519)       Labels:. 1K0-937-08x-09.clb
   Part No SW: 5K0 937 085 AB    HW: 5K0 937 085 AB
   Component: BCM PQ35 B+   122 0173  
   Revision: BH122001    
   Coding: EF200E1B902B08D4098800010600044800F1A08640801520648060000C70
   Shop #: WSC 09003 957 00200
   VCID: 73A61480D23992DC15-8026

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags (J234)       Labels:| 5K0-959-655.clb
   Part No SW: 5C0 959 655 AE    HW: 5C0 959 655 AE
   Component: AirbagVW10G   014 0851  
   Serial number: 003MWM03S9TJ  
   Coding: 00005033
   Shop #: WSC 09003 957 00200
   ASAM Dataset: EV_AirbaVW10SMEVW360 001026
   ROD: EV_AirbaVW10SMEVW360.rod
   VCID: 75A22A98D44D8CEC3B-8020

   Seat occupied recognition: 
   Subsystem 1 - Part No SW: 5C6 959 339 B    HW: 5C6 959 339 B
   Component: BF-Gewichtss.  H10 0046 
   Serial number: 6940000Y1300010ENC0L
   Coding: 303044

   Crash sensor for side airbag: driver side: 
   Subsystem 2 - Part No SW: 5K0 959 354     HW: 5K0 959 354 
   Component: S.Sens.Fahr.V  H02 ---- 
   Serial number: 3572MSME4916617DZZZ/

   Crash sensor for side airbag: front passenger side: 
   Subsystem 3 - Part No SW: 5K0 959 354     HW: 5K0 959 354 
   Component: S.Sens.Beif.V  H02 ---- 
   Serial number: 3582MSME5B00017EZZZW

   Crash sensor for side airbag: rear: driver side: 
   Subsystem 4 - Part No SW: 5K0 959 351 A    HW: 5K0 959 351 A
   Component: S.Sens.Fahr.H  H02 ---- 
   Serial number: 3516KSME3A5B4228ZZZY

   Crash sensor for side airbag: rear: passenger side: 
   Subsystem 5 - Part No SW: 5K0 959 351 A    HW: 5K0 959 351 A
   Component: S.Sens.Beif.H  H02 ---- 
   Serial number: 3526KSME6C154F28ZZZ0

   Crash sensor for front airbag: driver side: 
   Subsystem 6 - Part No SW: 5K0 959 659 A    HW: 5K0 959 659 A
   Component: F.Sens.Fahr  H02 ---- 
   Serial number: 3556LSME2372042AZZZO

   Crash sensor for front airbag: front passenger side: 
   Subsystem 7 - Part No SW: 5K0 959 659 A    HW: 5K0 959 659 A
   Component: F.Sens.Beif  H02 ---- 
   Serial number: 3566LSME3A0A6F29ZZZ7

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel (J527)       Labels:| 5K0-953-569.clb
   Part No SW: 1K5 953 521 BM    HW: 5K0 953 569 AE
   Component: LENKS.MODUL   016 0140  
   Revision: FF010042    Serial number: 20131111100818
   Coding: 088A140000
   Shop #: WSC 09003 957 00200
   ASAM Dataset: EV_SMLSNGVOLWSXS A01004
   ROD: EV_SMLSNGVOLWS.rod
   VCID: 79BA26A8F855E88C5F-802C

   Multifunction steering wheel control module: 
   Subsystem 1 - Part No SW: 3C8 959 537 D    HW: 3C8 959 537 D  Labels: 3C8-959-537.CLB
   Component: E221__MFL-YVJ  H07 0022 
   Coding: E20000

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments (J285)       Labels:| 5K0-920-XXX-17.clb-SRI1
   Part No SW: 561 920 970 G    HW: 561 920 970 G
   Component: KOMBI         H04 0811  
   Serial number: 00000000000000
   Coding: 231E01
   Shop #: WSC 09003 957 00200
   ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04721
   ROD: EV_Kombi_UDS_VDD_RM09_004_VW32.rod
   VCID: 1E701534013B6FB40A-804A

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533)       Labels:. 7N0-907-530-V2.clb
   Part No SW: 7N0 907 530 AM    HW: 7N0 907 530 AM
   Component: J533  Gateway H55 1642  
   Revision:   H55       Serial number: 25111303000645
   Coding: 461000
   Shop #: WSC 09003 957 00200
   VCID: 7BB63CA0FA69DA9C4D-802E

No fault code found.

-------------------------------------------------------------------------------
Address 1C: Position Sensing
Cannot be reached

-------------------------------------------------------------------------------
Address 25: Immobilizer (J334)       Labels:| 5K0-920-xxx-25.clb
   Part No SW: 5K0 953 234     HW: 5K0 953 234 
   Component: IMMO          H04 0811  
   Serial number:               
   Coding: 000000
   Shop #: WSC 09003 957 00200
   ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03710
   ROD: EV_Immo_UDS_VDD_RM09.rod
   VCID: 6A9809E48DF35314A6-803E

No fault code found.

-------------------------------------------------------------------------------
Address 2E: Media Player 3
Cannot be reached

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386)       Labels:| 3C0-959-70X-GEN4.clb
   Part No SW: 561 959 701     HW: 3C0 959 793 B
   Component: TUER-SG FT    002 0525  
   Revision: 13110009    Serial number: 0007645681
   Coding: 0404F5
   Shop #: WSC 09003 957 00200
   ASAM Dataset: EV_TSGFPQ25BRFVW46X A04001
   ROD: EV_TSGFPQ25BRFVW46X.rod
   VCID: 5BF65C2052A93A9C2D-800E

   Slave Driver: 
   Subsystem 1 - Part No SW: 561 959 811 B    HW: 561 959 811 B  Labels: 1K0-959-70X-GEN4.CLB
   Component: J388__TSG_HL  006 5470 
   Serial number: 14102630131126102409
   Coding: 800000

2 Faults Found:
66048 - Motor for Front Window Regulator 
          B11EC 54 [008] - Missing Calibration / Basic Setting
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 7
                    Fault Frequency: 1
                    Reset counter: 194

131584 - Motor for Rear Window Regulator 
          B11EE 54 [009] - Missing Calibration / Basic Setting
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 7
                    Fault Frequency: 1
                    Reset counter: 153


-------------------------------------------------------------------------------
Address 44: Steering Assist        Labels: 1K0-909-14x-GEN3.clb
   Part No: 1K0 909 144 R
   Component: EPS_ZFLS Kl. 290    3501  
   Revision: 00H22000    
   Shop #: WSC 01357 011 00200
   VCID: 393AE6A870D5288C1F-806C

No fault code found.

-------------------------------------------------------------------------------
Address 4F: Centr. Electr. II (J520)       Labels:. 1K0-907-532.clb
   Part No SW: 7N0 907 532     HW: 7N0 907 530 AM
   Component: EZE_2         H55 1642  
   Revision:   H55       Serial number: 25111303000645
   Coding: 01030108
   Shop #: WSC 09003 957 00200
   VCID: 6FAE18F0BE11B63CF1-803A

   Subsystem 1 - Part No SW: 561 959 591     HW: 561 959 591 
   Component: J245 P05 FFD7  H07 0004 
   Serial number: 53388786011325702777
   Coding: 181100

   Subsystem 2 - Part No SW: 561 919 204 B    HW: 561 919 204 B
   Component: Analoguhr  008 0005 

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387)       Labels:| 3C0-959-70X-GEN4.clb
   Part No SW: 561 959 702     HW: 3C0 959 792 B
   Component: TUER-SG BT    002 0525  
   Revision: 15110009    Serial number: 0007589267
   Coding: 0404F4
   Shop #: WSC 09003 957 00200
   ASAM Dataset: EV_TSGBPQ25BRFVW46X A04001
   ROD: EV_TSGBPQ25BRFVW46X.rod
   VCID: 5CF45F3C57A73DA424-8008

   Slave Passenger: 
   Subsystem 1 - Part No SW: 561 959 812 B    HW: 561 959 812 B  Labels: 1K0-959-70X-GEN4.CLB
   Component: J389__TSG_HR  006 5470 
   Serial number: 14202631131126134433
   Coding: 800000

1 Fault Found:
131584 - Motor for Rear Window Regulator 
          B11EE 54 [009] - Missing Calibration / Basic Setting
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 7
                    Fault Frequency: 1
                    Reset counter: 153


-------------------------------------------------------------------------------
Address 56: Radio (J503)       Labels:. 5M0-035-1xx-56.clb
   Part No SW: 1K0 035 188 F    HW: 1K0 035 188 F
   Component: Radio Prem-8  H05 0008  
   Revision: -----09S    Serial number: VWZ4Z7N3522745
   Coding: 0100044004000B
   Shop #: WSC 09003 957 00200
   VCID: 2B16CCE04A898A1C9D-807E

No fault code found.

-------------------------------------------------------------------------------
Address 75: Telematics (J949)       Labels:| 12E-035-284.clb
   Part No SW: 561 035 285     HW: 561 035 285 
   Component: OCULowUSA     014 0086  
   Serial number: 000003554140510
   Coding: 02140102C2163A007F1606C00000
   Shop #: WSC 09003 957 00200
   ASAM Dataset: EV_OCULow 001010
   ROD: EV_OCULow_001.rod
   VCID: 53E6B4003A79F2DCF5-8006

3 Faults Found:
12670464 - Databus 
          U1121 00 [008] - Missing Message
          [CAN TO brake]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 178
                    Reset counter: 183
                    Mileage: 50048 km
                    Date: 2016.10.03
                    Time: 18:35:02

0035 - Databus 
          U1121 00 [008] - Missing Message
          [CAN TO Airbag]
          Intermittent - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 6
                    Fault Frequency: 176
                    Reset counter: 183
                    Mileage: 50048 km
                    Date: 2016.10.03
                    Time: 18:35:02

2103041 - Control Module 
          B1788 F0 [009] - Start Prohibition Deactivated
          Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 8
                    Fault Frequency: 1
                    Reset counter: 0


-------------------------------------------------------------------------------
Address 77: Telephone (J412)       Labels:| 5N0-035-729.clb
   Part No SW: 5N0 035 729 A    HW: 5N0 035 729 A
   Component: TELEFON       H05 0315  
   Revision: 1B001001    Serial number: 00007665382819
   Coding: 0A10030080010110
   Shop #: WSC 09003 957 00200
   ASAM Dataset: EV_UHVUMI 001007
   ROD: EV_UHVUMI.rod
   VCID: 2E10C5F4719BFF34BA-807A

No fault code found.

End----------(Elapsed Time: 01:05, VBatt start/end: 14.0V/14.1V)-----------
 
   #16  

Jef

Ross-Tech Employee
Staff member
Ross-Tech Employee
Joined
Jan 29, 2014
Messages
3,949
Reaction score
6,332
Location
HQ
ST?ID=81728
E?ID=447351

Address 01: Engine (J623-CKRA) Labels:. 03L-906-012-CKR.clb
Part No SW: 03L 906 012 DE HW: 03L 907 309 S
Component: R4 2,0L EDC H24 8401

Did the steps outlined by Peter, still has nag message, 45 miles to death by adblue.

Battery charger hooked up, ignition on 10 minutes, no change.

Did Basic Settings:
  • IDE04567 Resetting of SCR tank level detection
  • IDE04730 Reset SCR lock
Still has death in 45 miles Adblue message. Test drove car and within 10 miles the Adblue nag message was gone.
 
  • Like
Reactions: Uwe
   #17  

Joey736

Verified VCDS User
Verified
Joined
Jan 8, 2020
Messages
1
Reaction score
3
Location
UK
VCDS Serial number
C?ID=385610
Just tried this on a 2016 touareg v6 tdi with adblue countdown message on display.

Scr lock reset
Scr tank level reset
Scr efficiency test ~ 15mins

Test confirmed to be completed successfully, warning light and countdown message removed from display.

Hopefully this will help others with similar issues.

Joey.
 
   #18  

Norrisnick1

Verified VCDS User
Verified
Joined
Aug 22, 2022
Messages
11
Reaction score
1
Location
Ohio, USA
VCDS Serial number
C?ID=523629
2014 passat ckra, tried the reset exactly explained and it didnt work, tried several times.
Anyone else have the same issue that was able to figure it out?
 
  • Informative
Reactions: JMR
   #19  

@DRI@N

Verified VCDS User
Verified
Joined
Nov 21, 2017
Messages
47
Reaction score
11
Location
Romania
VCDS Serial number
C?ID=317777
Hy,
I have a fault on AdBlue system, on my European Passat B8 2.0 BiTDI 2015 :

Code:
Monday,26,September,2022,16:26:31:62612
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 11 x64
VCDS Version: 22.9.0.0 (x64)  HEX-V2 CB: 0.4623.4
Data version: 20220830 DS341.0
www.Ross-Tech.com


VIN: WVWZZZ3CZFE400297
Mileage:    Repair Order: 26.09.2022
--------------------------------------------------------------------------------

                Address 01: Engine       Labels: 03N-906-026-CUA.clb
Control Module Part Number: 03N 906 026     HW: 03N 907 309 
  Component and/or Version: R4 2,0L EDC   X22 0948
           Software Coding: 0125003A047605083000
            Work Shop Code: WSC 08601 003 104857
              ASAM Dataset: EV_ECM20BTD01103N906026 001008 (VW48)
                       ROD: EV_ECM20BTD01103N906026.rod
                      VCID: 688AB06D52FC920B4F3-803C
1 Fault Found:

22585 - Reductant Level Sensor 
          P203B 00 [237] - Implausible Signal
          MIL ON - Confirmed - Tested Since Memory Clear
             Freeze Frame:
                    Fault Status: 00000001
                    Fault Priority: 2
                    Fault Frequency: 1
                    Mileage: 74700 km
                    Date: 2022.09.18
                    Time: 17:17:20

                    Engine RPM: 2189.00 /min
                    Normed load value: 34.9 %
                    Vehicle speed: 43 km/h
                    Coolant temperature: 91 °C
                    Intake air temperature: 100 °C
                    Ambient air pressure: 1000 mbar
                    Voltage terminal 30: 12.540 V
                    Unlearning counter according OBD: 40
                    Outside temperature sensor 1: B1: raw value: 22.0 °C
                    Reducing agent pump module relative press.: calculated: 7175 hPa
                    Reducing agent fill level sensor: act. value: 0.0 mm
                    Sensor for reducing agent tank temperature: temperature: 22.1 °C
                    Reducing agent system pressurization release conditions-Bits 0-7: 0
                    Reducing agent system pressurization release conditions-Bits 0-7: 0
                    Reducing agent system: current status: COSCR_PRESSURECTL
                    Reducing agent system: current status-Test_Program_SCR Con State 01 UBYTE: 4


Readiness: 1 1 0 0 0

Is possible to tell me where is this sensor, and if the first posting procedure solve my problem, because my AdBlue tank is Full ?
Thanks .
 
Last edited by a moderator:
Back
Top