Page 2 of 2 FirstFirst 12
Results 11 to 16 of 16

Thread: 2012-2014 NAR Passat(A32) TDI/CKRA – AdBlue Level Reset Procedure

  1. #11
    Benevolent Dictator Uwe's Avatar
    Join Date
    Jan 2014
    Location
    Earth
    Posts
    18,789
    Post Thanks / Like
    Blog Entries
    1
    So you're saying left foot on the brake, and accelerator pedal pressed to the floor, the ECU does not limit the engine speed to something reasonable?

    ETA: Does your ECU have "Dieselgate Fix" software in it already?

    -Uwe-
    The engineering problems are likely insurmountable. It would be like proposing to land a rocket booster section on a barge floating in the middle of the ocean.

  2. #12
    Verified VCDS User
    Join Date
    Jul 2014
    Posts
    4
    Post Thanks / Like
    ECU limits RPM to around 1500 RPM. I'm asking, is the ECU supposed to maintain that RPM when I remove my right foot from the accelerator and leave my left foot on the brake?

    Edit: Dieselgate fix NOT installed
    Last edited by roni024; 02-12-2018 at 11:49 AM.

  3. #13
    Benevolent Dictator Uwe's Avatar
    Join Date
    Jan 2014
    Location
    Earth
    Posts
    18,789
    Post Thanks / Like
    Blog Entries
    1
    Quote Originally Posted by roni024 View Post
    ECU limits RPM to around 1500 RPM.
    OK, that sounds correct.

    Quote Originally Posted by roni024 View Post
    I'm asking, is the ECU supposed to maintain that RPM when I remove my right foot from the accelerator and leave my left foot on the brake?
    No, I don't think so. Basic Settings that require an elevated RPM (where the ECU controls the RPM) have been always been: One foot firmly on the brake, the other foot holding the loud pedal to the floor for as long as it takes.

    -Uwe-
    The engineering problems are likely insurmountable. It would be like proposing to land a rocket booster section on a barge floating in the middle of the ocean.

  4. Likes roni024 liked this post
  5. #14
    Verified VCDS User
    Join Date
    Jul 2014
    Posts
    4
    Post Thanks / Like
    Thank you for the explanation. After replacing the AdBlue heater assembly and pump (broke nipple when reinstalling tank), the AdBlue countdown would not go away. I tried a couple different reset procedures (the one outlined previously, and also Reset SCR fluid level - then Reset SCR lock) but the countdown remained. A couple of ignition cycles later and it went away. Maybe it took a little time for air to bleed from the reductant line. All is well.

  6. Likes Uwe liked this post
  7. #15
    Verified VCDS User golfi_vend's Avatar
    Join Date
    Apr 2014
    Location
    Võru, Estonia
    Posts
    1,558
    Post Thanks / Like
    This process helped me on imported NMS, that had range counting down with no faults.
    After the process aborted it at least gave some faults.

    I did update ECU software, cause on sharan the ECU software plays a huge role resetting adblue level. But no joy.
    Seems like new sensor is needed(600 Euros)

    Code:
    Tuesday,10,April,2018,20:12:49:36026
    VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64
    VCDS Version: 18.2.0.3 (x64)  HEX-NET CB: 0.4421.4
    Data version: 20180212 DS287.0
    www.Ross-Tech.com
    
    
    VIN: 1VWBN7A35EC   License Plate: PASSAT USA2
    Mileage: 78870km-49007mi   Repair Order: 
    
    
    Chassis Type: A3-VW41 (7N0)
    Scan: 01 02 03 08 09 15 16 17 19 1C 25 2E 42 44 46 4F 52 56 62 72
              75 77
    
    VIN: 1VWBN7A35EC   Mileage: 78870km-49007miles
    
    01-Engine -- Status: Malfunction 0010
    02-Auto Trans -- Status: OK 0000
    03-ABS Brakes -- Status: Malfunction 0010
    04-Steering Angle -- Status: OK 0000
    08-Auto HVAC -- Status: OK 0000
    09-Cent. Elect. -- Status: OK 0000
    15-Airbags -- Status: OK 0000
    16-Steering wheel -- Status: OK 0000
    17-Instruments -- Status: OK 0000
    19-CAN Gateway -- Status: OK 0000
    1C-Position Sensing -- Status: OK 0000
    25-Immobilizer -- Status: OK 0000
    2E-Media Player 3 -- Status: OK 0000
    42-Door Elect, Driver -- Status: Malfunction 0010
    44-Steering Assist -- Status: OK 0000
    46-Central Conv. -- Status: OK 0000
    4F-Centr. Electr. II -- Status: OK 0000
    52-Door Elect, Pass. -- Status: Malfunction 0010
    56-Radio -- Status: OK 0000
    62-Door, Rear Left -- Status: OK 0000
    72-Door, Rear Right -- Status: OK 0000
    75-Telematics -- Status: Malfunction 0010
    77-Telephone -- Status: OK 0000
    -------------------------------------------------------------------------------
    Address 01: Engine (J623-CKRA)       Labels:. 03L-906-012-CKR.clb
       Part No SW: 03L 906 012 DE    HW: 03L 907 309 S
       Component: R4 2,0L EDC   H24 6073  
       Revision: 71H24---    Serial number:               
       Coding: 001D0012042400000000
       Shop #: WSC 09003 957 00200
       ASAM Dataset: EV_ECM20TDI01103L906012DE 004004
       ROD: EV_ECM20TDI01103L906012DE.rod
       VCID: 6A9809E48DF35314A6-803E
    
    2 Faults Found:
    18643 - NOx Sensor 1 Bank 1 
              P2200 00 [039] - Electrical Malfunction
              Not Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 2
                        Fault Frequency: 1
                        Mileage: 78875 km
                        Date: 2018.04.10
                        Time: 20:09:43
    
                        Engine speed: 1497.50 /min
                        Normed load value: 16.9 %
                        Vehicle speed: 0 km/h
                        Coolant temperature: 96 °C
                        Intake air temperature: 33 °C
                        Ambient air pressure: 1010 mbar
                        Voltage terminal 30: 14.060 V
                        Unlearning counter according OBD: 40
                        Outside air temperature: 16.5 °C
                        Status of electrical malfunction of NOx sensor 1-Bits 0-7: 234
                        Exh.gas temp.sen 4: 448.6 °C
                        Mean injection quantity: 7.17 mg/stroke
                        Limitation: torque: 270.0 Nm
    
    18644 - NOx Sensor 1 Bank 1 
              P2200 00 [039] - Electrical Malfunction
              Not Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 2
                        Fault Frequency: 1
                        Mileage: 78875 km
                        Date: 2018.04.10
                        Time: 20:09:43
    
                        Engine speed: 1497.50 /min
                        Normed load value: 16.9 %
                        Vehicle speed: 0 km/h
                        Coolant temperature: 96 °C
                        Intake air temperature: 33 °C
                        Ambient air pressure: 1010 mbar
                        Voltage terminal 30: 14.060 V
                        Unlearning counter according OBD: 40
                        Air mass: actual value (mg/stroke): 667.7 mg/stroke
                        Mean injection quantity: 7.17 mg/stroke
                        EGR Vacuum Regulator Solen.val.: activation: 100.00 %
                        NOx emission NOx sensor 1: 0 ppm
                        Air mass for release of NOx sensor 1 offset test: 0.0 g
                        Calculated efficiency of NOx conversion: 0.648
    
    Readiness: 0 0 0 1 1 
    
    -------------------------------------------------------------------------------
    Address 02: Auto Trans        Labels: 02E-927-770.clb
       Part No SW: 02E 300 062 B    HW: 02E 927 770 AL
       Component: GSG DSG AG6     521 4020  
       Revision: 05652104    Serial number: 00001310100063
       Coding: 0000020
       Shop #: WSC 09003 957 00200
       VCID: 1464771C37F735E4AC-8040
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 03: ABS Brakes (J104)       Labels:. 1K0-907-379-60EC1F.clb
       Part No SW: 1K0 907 379 BM    HW: 1K0 907 379 BM
       Component: ESP MK60EC1   H46 0164  
       Revision: 00H46001    
       Coding: C54BC0F5492800FBA30D03E7921A0042A1100012
       Shop #: WSC 09003 957 00200
       VCID: 7EB035B4E97BCFB46A-802A
    
    1 Fault Found:
    01325 - Control Module for Tire Pressure Monitoring (J502) 
                004 - No Signal/Communication - Intermittent
                 Freeze Frame:
                        Fault Status: 00100100
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 194
                        Mileage: 78819 km
                        Time Indication: 0
                        Date: 2018.04.09
                        Time: 00:00:35
    
                 Freeze Frame:
                        Count: 2
                        Count: 12
                        Count: 20480
                        Count: 16390
                        Count: 45312
                        Count: 0
                        Count: 511
                        Count: 0
    
    
    -------------------------------------------------------------------------------
    Address 08: Auto HVAC (J301)       Labels:| 3C8-907-336.clb
       Part No SW: 561 907 426 E    HW: 561 907 426 E
       Component: AC Manuell    H02 0303  
       Revision: 00001K02    
       Coding: 0010001002
       Shop #: WSC 09003 957 00200
       ASAM Dataset: EV_ACManuaElectGen2BHTC 001002
       ROD: EV_ACManuaElectGen2BHTC_VW36.rod
       VCID: 1D7212380C3D74AC13-8048
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 09: Cent. Elect. (J519)       Labels:. 1K0-937-08x-09.clb
       Part No SW: 5K0 937 085 AB    HW: 5K0 937 085 AB
       Component: BCM PQ35 B+   122 0173  
       Revision: BH122001    
       Coding: EF200E1B902B08D4098800010600044800F1A08640801520648060000C70
       Shop #: WSC 09003 957 00200
       VCID: 73A61480D23992DC15-8026
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 15: Airbags (J234)       Labels:| 5K0-959-655.clb
       Part No SW: 5C0 959 655 AE    HW: 5C0 959 655 AE
       Component: AirbagVW10G   014 0851  
       Serial number: 003MWM03S9TJ  
       Coding: 00005033
       Shop #: WSC 09003 957 00200
       ASAM Dataset: EV_AirbaVW10SMEVW360 001026
       ROD: EV_AirbaVW10SMEVW360.rod
       VCID: 75A22A98D44D8CEC3B-8020
    
       Seat occupied recognition: 
       Subsystem 1 - Part No SW: 5C6 959 339 B    HW: 5C6 959 339 B
       Component: BF-Gewichtss.  H10 0046 
       Serial number: 6940000Y1300010ENC0L
       Coding: 303044
    
       Crash sensor for side airbag: driver side: 
       Subsystem 2 - Part No SW: 5K0 959 354     HW: 5K0 959 354 
       Component: S.Sens.Fahr.V  H02 ---- 
       Serial number: 3572MSME4916617DZZZ/
    
       Crash sensor for side airbag: front passenger side: 
       Subsystem 3 - Part No SW: 5K0 959 354     HW: 5K0 959 354 
       Component: S.Sens.Beif.V  H02 ---- 
       Serial number: 3582MSME5B00017EZZZW
    
       Crash sensor for side airbag: rear: driver side: 
       Subsystem 4 - Part No SW: 5K0 959 351 A    HW: 5K0 959 351 A
       Component: S.Sens.Fahr.H  H02 ---- 
       Serial number: 3516KSME3A5B4228ZZZY
    
       Crash sensor for side airbag: rear: passenger side: 
       Subsystem 5 - Part No SW: 5K0 959 351 A    HW: 5K0 959 351 A
       Component: S.Sens.Beif.H  H02 ---- 
       Serial number: 3526KSME6C154F28ZZZ0
    
       Crash sensor for front airbag: driver side: 
       Subsystem 6 - Part No SW: 5K0 959 659 A    HW: 5K0 959 659 A
       Component: F.Sens.Fahr  H02 ---- 
       Serial number: 3556LSME2372042AZZZO
    
       Crash sensor for front airbag: front passenger side: 
       Subsystem 7 - Part No SW: 5K0 959 659 A    HW: 5K0 959 659 A
       Component: F.Sens.Beif  H02 ---- 
       Serial number: 3566LSME3A0A6F29ZZZ7
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 16: Steering wheel (J527)       Labels:| 5K0-953-569.clb
       Part No SW: 1K5 953 521 BM    HW: 5K0 953 569 AE
       Component: LENKS.MODUL   016 0140  
       Revision: FF010042    Serial number: 20131111100818
       Coding: 088A140000
       Shop #: WSC 09003 957 00200
       ASAM Dataset: EV_SMLSNGVOLWSXS A01004
       ROD: EV_SMLSNGVOLWS.rod
       VCID: 79BA26A8F855E88C5F-802C
    
       Multifunction steering wheel control module: 
       Subsystem 1 - Part No SW: 3C8 959 537 D    HW: 3C8 959 537 D  Labels: 3C8-959-537.CLB
       Component: E221__MFL-YVJ  H07 0022 
       Coding: E20000
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 17: Instruments (J285)       Labels:| 5K0-920-XXX-17.clb-SRI1
       Part No SW: 561 920 970 G    HW: 561 920 970 G
       Component: KOMBI         H04 0811  
       Serial number: 00000000000000
       Coding: 231E01
       Shop #: WSC 09003 957 00200
       ASAM Dataset: EV_Kombi_UDS_VDD_RM09 A04721
       ROD: EV_Kombi_UDS_VDD_RM09_004_VW32.rod
       VCID: 1E701534013B6FB40A-804A
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 19: CAN Gateway (J533)       Labels:. 7N0-907-530-V2.clb
       Part No SW: 7N0 907 530 AM    HW: 7N0 907 530 AM
       Component: J533  Gateway H55 1642  
       Revision:   H55       Serial number: 25111303000645
       Coding: 461000
       Shop #: WSC 09003 957 00200
       VCID: 7BB63CA0FA69DA9C4D-802E
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 1C: Position Sensing
    Cannot be reached
    
    -------------------------------------------------------------------------------
    Address 25: Immobilizer (J334)       Labels:| 5K0-920-xxx-25.clb
       Part No SW: 5K0 953 234     HW: 5K0 953 234 
       Component: IMMO          H04 0811  
       Serial number:               
       Coding: 000000
       Shop #: WSC 09003 957 00200
       ASAM Dataset: EV_Immo_UDS_VDD_RM09 A03710
       ROD: EV_Immo_UDS_VDD_RM09.rod
       VCID: 6A9809E48DF35314A6-803E
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 2E: Media Player 3
    Cannot be reached
    
    -------------------------------------------------------------------------------
    Address 42: Door Elect, Driver (J386)       Labels:| 3C0-959-70X-GEN4.clb
       Part No SW: 561 959 701     HW: 3C0 959 793 B
       Component: TUER-SG FT    002 0525  
       Revision: 13110009    Serial number: 0007645681
       Coding: 0404F5
       Shop #: WSC 09003 957 00200
       ASAM Dataset: EV_TSGFPQ25BRFVW46X A04001
       ROD: EV_TSGFPQ25BRFVW46X.rod
       VCID: 5BF65C2052A93A9C2D-800E
    
       Slave Driver: 
       Subsystem 1 - Part No SW: 561 959 811 B    HW: 561 959 811 B  Labels: 1K0-959-70X-GEN4.CLB
       Component: J388__TSG_HL  006 5470 
       Serial number: 14102630131126102409
       Coding: 800000
    
    2 Faults Found:
    66048 - Motor for Front Window Regulator 
              B11EC 54 [008] - Missing Calibration / Basic Setting
              Intermittent - Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 7
                        Fault Frequency: 1
                        Reset counter: 194
    
    131584 - Motor for Rear Window Regulator 
              B11EE 54 [009] - Missing Calibration / Basic Setting
              Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 7
                        Fault Frequency: 1
                        Reset counter: 153
    
    
    -------------------------------------------------------------------------------
    Address 44: Steering Assist        Labels: 1K0-909-14x-GEN3.clb
       Part No: 1K0 909 144 R
       Component: EPS_ZFLS Kl. 290    3501  
       Revision: 00H22000    
       Shop #: WSC 01357 011 00200
       VCID: 393AE6A870D5288C1F-806C
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 4F: Centr. Electr. II (J520)       Labels:. 1K0-907-532.clb
       Part No SW: 7N0 907 532     HW: 7N0 907 530 AM
       Component: EZE_2         H55 1642  
       Revision:   H55       Serial number: 25111303000645
       Coding: 01030108
       Shop #: WSC 09003 957 00200
       VCID: 6FAE18F0BE11B63CF1-803A
    
       Subsystem 1 - Part No SW: 561 959 591     HW: 561 959 591 
       Component: J245 P05 FFD7  H07 0004 
       Serial number: 53388786011325702777
       Coding: 181100
    
       Subsystem 2 - Part No SW: 561 919 204 B    HW: 561 919 204 B
       Component: Analoguhr  008 0005 
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 52: Door Elect, Pass. (J387)       Labels:| 3C0-959-70X-GEN4.clb
       Part No SW: 561 959 702     HW: 3C0 959 792 B
       Component: TUER-SG BT    002 0525  
       Revision: 15110009    Serial number: 0007589267
       Coding: 0404F4
       Shop #: WSC 09003 957 00200
       ASAM Dataset: EV_TSGBPQ25BRFVW46X A04001
       ROD: EV_TSGBPQ25BRFVW46X.rod
       VCID: 5CF45F3C57A73DA424-8008
    
       Slave Passenger: 
       Subsystem 1 - Part No SW: 561 959 812 B    HW: 561 959 812 B  Labels: 1K0-959-70X-GEN4.CLB
       Component: J389__TSG_HR  006 5470 
       Serial number: 14202631131126134433
       Coding: 800000
    
    1 Fault Found:
    131584 - Motor for Rear Window Regulator 
              B11EE 54 [009] - Missing Calibration / Basic Setting
              Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 7
                        Fault Frequency: 1
                        Reset counter: 153
    
    
    -------------------------------------------------------------------------------
    Address 56: Radio (J503)       Labels:. 5M0-035-1xx-56.clb
       Part No SW: 1K0 035 188 F    HW: 1K0 035 188 F
       Component: Radio Prem-8  H05 0008  
       Revision: -----09S    Serial number: VWZ4Z7N3522745
       Coding: 0100044004000B
       Shop #: WSC 09003 957 00200
       VCID: 2B16CCE04A898A1C9D-807E
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 75: Telematics (J949)       Labels:| 12E-035-284.clb
       Part No SW: 561 035 285     HW: 561 035 285 
       Component: OCULowUSA     014 0086  
       Serial number: 000003554140510
       Coding: 02140102C2163A007F1606C00000
       Shop #: WSC 09003 957 00200
       ASAM Dataset: EV_OCULow 001010
       ROD: EV_OCULow_001.rod
       VCID: 53E6B4003A79F2DCF5-8006
    
    3 Faults Found:
    12670464 - Databus 
              U1121 00 [008] - Missing Message
              [CAN TO brake]
              Intermittent - Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 6
                        Fault Frequency: 178
                        Reset counter: 183
                        Mileage: 50048 km
                        Date: 2016.10.03
                        Time: 18:35:02
    
    0035 - Databus 
              U1121 00 [008] - Missing Message
              [CAN TO Airbag]
              Intermittent - Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 6
                        Fault Frequency: 176
                        Reset counter: 183
                        Mileage: 50048 km
                        Date: 2016.10.03
                        Time: 18:35:02
    
    2103041 - Control Module 
              B1788 F0 [009] - Start Prohibition Deactivated
              Confirmed - Tested Since Memory Clear
                 Freeze Frame:
                        Fault Status: 00000001
                        Fault Priority: 8
                        Fault Frequency: 1
                        Reset counter: 0
    
    
    -------------------------------------------------------------------------------
    Address 77: Telephone (J412)       Labels:| 5N0-035-729.clb
       Part No SW: 5N0 035 729 A    HW: 5N0 035 729 A
       Component: TELEFON       H05 0315  
       Revision: 1B001001    Serial number: 00007665382819
       Coding: 0A10030080010110
       Shop #: WSC 09003 957 00200
       ASAM Dataset: EV_UHVUMI 001007
       ROD: EV_UHVUMI.rod
       VCID: 2E10C5F4719BFF34BA-807A
    
    No fault code found.
    
    End----------(Elapsed Time: 01:05, VBatt start/end: 14.0V/14.1V)-----------
    I am a VW Freak - Le WV Freaks OR Come visit me at my work with ODIS concerns - FORSS ODIS GeKo/FaZit access for VW/AUDI/Škoda
    The world is my oyster...

  8. #16
    Ross-Tech Employee Jef's Avatar
    Join Date
    Jan 2014
    Posts
    1,468
    Post Thanks / Like
    ST?ID=81728
    E?ID=447351

    Address 01: Engine (J623-CKRA) Labels:. 03L-906-012-CKR.clb
    Part No SW: 03L 906 012 DE HW: 03L 907 309 S
    Component: R4 2,0L EDC H24 8401

    Did the steps outlined by Peter, still has nag message, 45 miles to death by adblue.

    Battery charger hooked up, ignition on 10 minutes, no change.

    Did Basic Settings:
    • IDE04567 Resetting of SCR tank level detection
    • IDE04730 Reset SCR lock

    Still has death in 45 miles Adblue message. Test drove car and within 10 miles the Adblue nag message was gone.
    Jef
    Ross Tech Support Team, Alpha Squad
    Auto-Scan, learn it, love it, live it... then check the fuses.

  9. Likes Uwe liked this post

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •