Page 2 of 3 FirstFirst 123 LastLast
Results 11 to 20 of 27

Thread: New member - going to need some help

  1. #11
    New User
    Join Date
    Mar 2018
    Location
    USA
    Posts
    14
    Post Thanks / Like
    Quote Originally Posted by MasterTommy View Post
    Trickle chargers (or any chargers i know of) don’t ‘test’ the condition of the battery. They show battery status based on the voltage they read. But even a dead battery will usually charge to 13 something volts which a battery charger will award with a green light. There are some exceptions to the dead battery and the charger story, but to keep it simple; for testing a battery you’ll need a dedicated battery tester.

    Confirming my suspicions, the next step is to renew the battery (preferably OEM), adapt new battery to battery regulator if one is installed in your car, remove the auto trans module from the installion list and clear all DTC’s. It’s pointless to diagnose supply voltage faults (if any of those are real) with a dead battery. And a dead battery can definately still have enough juice to power the dash and interior illumination but not enough to even make the starter move.
    Last night I put the multimeter on the battery and it was reading 12.3V and that's after having not been charged since Thursday 3/29/18. But to your point, I'll take this battery to a local auto parts store and have them check the status. FYI - the car cranks like a champ - but I'm getting no spark.

    Thanks for your help; I'll post the results of the battery test.

    Is there a chance that these readings are the result of a broken wire somewhere?

  2. #12
    Verified VCDS User
    Join Date
    Dec 2016
    Location
    NL
    Posts
    280
    Post Thanks / Like
    Quote Originally Posted by 25Tjetta View Post
    Last night I put the multimeter on the battery and it was reading 12.3V and that's after having not been charged since Thursday 3/29/18. But to your point, I'll take this battery to a local auto parts store and have them check the status. FYI - the car cranks like a champ - but I'm getting no spark.

    Thanks for your help; I'll post the results of the battery test.

    Is there a chance that these readings are the result of a broken wire somewhere?
    Then i incorrectly assumend it didnt crank. My bad. Ill have a further look at your scan later today.
    Current:
    2018 Tiguan AD Highline 2.0 BiTDI 240hp > Stage 1+ 328hp
    2016 Polo 6C Highline 1.0 TSI 105hp

  3. #13
    New User
    Join Date
    Mar 2018
    Location
    USA
    Posts
    14
    Post Thanks / Like
    Quote Originally Posted by 25Tjetta View Post
    Last night I put the multimeter on the battery and it was reading 12.3V and that's after having not been charged since Thursday 3/29/18. But to your point, I'll take this battery to a local auto parts store and have them check the status. FYI - the car cranks like a champ - but I'm getting no spark.

    Thanks for your help; I'll post the results of the battery test.

    Is there a chance that these readings are the result of a broken wire somewhere?
    I took the battery to autozone, but the kid working was less than knowledgeable. We were not sure of the CCA of the OEM bosch battery as the battery only states 61Ah and 330A. He cross referenced to his battery and used 615 CCA for his test. Can anyone confirm the correct CCA for these batteries?

    Based on 615 CCA it was reading low... 65%.

  4. #14
    Verified VCDS User PetrolDave's Avatar
    Join Date
    Dec 2014
    Location
    South Molton, UK
    Posts
    997
    Post Thanks / Like
    Quote Originally Posted by 25Tjetta View Post
    the battery only states 61Ah and 330A.
    The battery states 330A, so that's the CCA rating that should be used.

  5. Likes 25Tjetta liked this post
  6. #15
    New User
    Join Date
    Mar 2018
    Location
    USA
    Posts
    14
    Post Thanks / Like
    Quote Originally Posted by PetrolDave View Post
    The battery states 330A, so that's the CCA rating that should be used.
    Thanks, PetrolDave. Was not sure if those were indeed one and the same. Time for a RETEST!

  7. #16
    New User
    Join Date
    Mar 2018
    Location
    USA
    Posts
    14
    Post Thanks / Like
    OK all. The battery I was using was bad per test at Autozone. I installed a brand new battery and a new (G28) Crankshaft Position Sensor, and I removed Auto Trans from my gateway installation list. I am still seeing the same results; can you take a took at this scan and give me an idea of what is causing these issues? FYI headlights, front driver seat, and ambient temp sensor have not been reinstalled at this time.

    Code:
    Saturday,14,April,2018,18:19:17:15384
    VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
    VCDS Version: 18.2.0.3 (x64)
    Data version: 20180212 DS287.0
    www.Ross-Tech.com
    
    
    VIN: 3VWJM71K28M056478   License Plate: 
    Mileage: 284730km-176923mi   Repair Order: 
    
    
    
    --------------------------------------------------------------------------------
    --------------------------------------------------------------------------------
    
    
    Chassis Type: 1K (1K0)
    Scan: 01 03 08 09 15 16 17 19 25 42 44 46 52 56 62 65 72
    
    VIN: 3VWJM71K28M056478   Mileage: 284730km-176923miles
    
    01-Engine -- Status: Malfunction 1010
    03-ABS Brakes -- Status: Malfunction 0010
    04-Steering Angle -- Status: OK 0000
    08-Auto HVAC -- Status: Malfunction 0010
    09-Cent. Elect. -- Status: Malfunction 0010
    15-Airbags -- Status: Malfunction 0010
    16-Steering wheel -- Status: Malfunction 0010
    17-Instruments -- Status: Malfunction 0010
    19-CAN Gateway -- Status: Malfunction 0010
    25-Immobilizer -- Status: Malfunction 0010
    42-Door Elect, Driver -- Status: Malfunction 0010
    44-Steering Assist -- Status: Malfunction 0010
    46-Central Conv. -- Status: Malfunction 0010
    52-Door Elect, Pass. -- Status: Malfunction 0010
    56-Radio -- Status: OK 0000
    62-Door, Rear Left -- Status: OK 0000
    65-Tire Pressure -- Status: Malfunction 0010
    72-Door, Rear Right -- Status: OK 0000
     
    -------------------------------------------------------------------------------
    Address 01: Engine        Labels: None
       Part No SW: 07K 906 032 UM    HW: 07K 906 032 Q
       Component: United.342      G   19  
       Revision: --H01---    Serial number: VWX7Z0G824R0JF
       Coding: 0000001
       Shop #: WSC 00001 000 00000
       VCID: 0831555D7B0F230450-805C
    
    1 Fault Found:
    005699 - Please check DTC Memory of Electric Load Controller 
                   P1643 - 001 - 
                 Freeze Frame:
                        Fault Status: 01100001
                        Fault Priority: 0
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 284739 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 03:57:24
    
                 Freeze Frame:
                        RPM: 0 /min
                        Load: 0.0 %
                        Speed: 0.0 km/h
                        Temperature: 24.0°C
                        Temperature: 26.0°C
                        Absolute Pres.: 960.0 mbar
                        Voltage: 11.938 V
    
    Readiness: 0000 0000
    
    -------------------------------------------------------------------------------
    Address 03: ABS Brakes        Labels: 1K0-907-379-MK70.lbl
       Part No: 1K0 907 379 P
       Component: ASR FRONT MK70      0105  
       Coding: 0017025
       Shop #: WSC 00066 000 00000
       VCID: 3FA38E816E41A4BC21-806A
    
    3 Faults Found:
    18020 - Engine Control Module Incorrectly Coded 
                P1612 - 000 -  - Intermittent
    01314 - Engine Control Module 
                004 - No Signal/Communication - Intermittent
    00668 - Supply Voltage Terminal 30 
                002 - Lower Limit Exceeded - Intermittent
    
    -------------------------------------------------------------------------------
    Address 08: Auto HVAC        Labels: 1K0-820-047.lbl
       Part No SW: 1K0 820 047 GF    HW: 1K0 820 047 GF
       Component: Climatic PQ35   141 0909  
       Revision: 00141027    Serial number: 00000000000000
       Shop #: WSC 00000 000 00000
       VCID: 6EFD03C579AB1D34FA-803A
    
    4 Faults Found:
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent
    00229 - Refrigerant Pressure 
                002 - Lower Limit Exceeded
    01317 - Control Module in Instrument Cluster (J285) 
                013 - Check DTC Memory
    01314 - Engine Control Module 
                004 - No Signal/Communication - Intermittent
    
    -------------------------------------------------------------------------------
    Address 09: Cent. Elect.        Labels:. 3C0-937-049-30-M.lbl
       Part No SW: 3C0 937 049 AH    HW: 3C0 937 049 AH
       Component: Bordnetz-SG     H54 2202  
       Revision: 00H54000    Serial number: 00000000750036
       Coding: 04050E234004150007140000001400000008730B5C000100000000000000
       Shop #: WSC 00066 123 12345
       VCID: 6FC31EC17EA1143CF1-803A
    
       Subsystem 1 - Part No: 1K1 955 119 E  Labels: 1KX-955-119.CLB
       Component: Wischer 260907 020  0501  
       Coding: 00038805
       Shop #: WSC 00066  
    
    10 Faults Found:
    01493 - Bulb for Blinkers; Front Left (M5) 
                012 - Electrical Fault in Circuit
                 Freeze Frame:
                        Fault Status: 01101100
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 103
                        Mileage: 284739 km
                        Time Indication: 0
                        Date: 2005.09.13
                        Time: 31:63:63
    
                 Freeze Frame:
                            ON
                        Voltage: 12.10 V
                            ON
                            ON
                            OFF
                            OFF
                            OFF
    
    01497 - Bulb for Blinkers; Front Right (M7) 
                012 - Electrical Fault in Circuit
                 Freeze Frame:
                        Fault Status: 01111100
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 103
                        Mileage: 284739 km
                        Time Indication: 0
                        Date: 2005.09.13
                        Time: 31:63:63
    
                 Freeze Frame:
                            ON
                        Voltage: 12.10 V
                            ON
                            ON
                            OFF
                            OFF
                            OFF
    
    02394 - Parking Light Left Front (M1) 
                012 - Electrical Fault in Circuit
                 Freeze Frame:
                        Fault Status: 01111100
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 103
                        Mileage: 284739 km
                        Time Indication: 0
                        Date: 2005.09.13
                        Time: 31:63:63
    
                 Freeze Frame:
                            ON
                        Voltage: 12.00 V
                            ON
                            ON
                            OFF
                            OFF
                            OFF
    
    02395 - Parking Light Front Right (M3) 
                012 - Electrical Fault in Circuit
                 Freeze Frame:
                        Fault Status: 01101100
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 103
                        Mileage: 284739 km
                        Time Indication: 0
                        Date: 2005.09.13
                        Time: 31:63:63
    
                 Freeze Frame:
                            ON
                        Voltage: 12.00 V
                            ON
                            ON
                            OFF
                            OFF
                            OFF
    
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 2
                        Fault Frequency: 2
                        Reset counter: 143
                        Mileage: 284739 km
                        Time Indication: 0
                        Date: 2005.09.13
                        Time: 31:63:63
    
                 Freeze Frame:
                            ON
                        Voltage: 8.85 V
                            ON
                            ON
                            OFF
                            OFF
                            OFF
    
    00978 - Lamp for Low Beam; Left (M29) 
                010 - Open or Short to Plus
                 Freeze Frame:
                        Fault Status: 01101010
                        Fault Priority: 1
                        Fault Frequency: 13
                        Reset counter: 103
                        Mileage: 271509 km
                        Time Indication: 0
                        Date: 2005.09.13
                        Time: 31:63:63
    
                 Freeze Frame:
                            ON
                        Voltage: 13.95 V
                            ON
                            ON
                            OFF
                            OFF
                            OFF
    
    00979 - Lamp for Low Beam; Right (M31) 
                010 - Open or Short to Plus
                 Freeze Frame:
                        Fault Status: 01101010
                        Fault Priority: 1
                        Fault Frequency: 254
                        Reset counter: 103
                        Mileage: 191222 km
                        Time Indication: 0
                        Date: 2005.09.13
                        Time: 31:63:63
    
                 Freeze Frame:
                            ON
                        Voltage: 12.15 V
                            ON
                            ON
                            OFF
                            OFF
                            ON
    
    02404 - Vehicle Exterior Illumination 
                012 - Electrical Fault in Circuit
                 Freeze Frame:
                        Fault Status: 01111100
                        Fault Priority: 1
                        Fault Frequency: 1
                        Reset counter: 103
                        Mileage: 278591 km
                        Time Indication: 0
                        Date: 2005.09.13
                        Time: 31:63:63
    
                 Freeze Frame:
                            ON
                        Voltage: 14.10 V
                            ON
                            ON
                            OFF
                            OFF
                            OFF
    
    00154 - Windshield Wiper Motor;  Passenger Side (V217) 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 143
                        Mileage: 284739 km
                        Time Indication: 0
                        Date: 2005.09.13
                        Time: 31:63:63
    
                 Freeze Frame:
                            OFF
                        Voltage: 9.70 V
                            OFF
                            ON
                            OFF
                            OFF
                            OFF
    
    02383 - Windshield Wiper Motor Function Restricted due to Under-Voltage 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 143
                        Mileage: 284739 km
                        Time Indication: 0
                        Date: 2005.09.13
                        Time: 31:63:63
    
                 Freeze Frame:
                            OFF
                        Voltage: 9.70 V
                            OFF
                            ON
                            OFF
                            OFF
                            OFF
    
    
    -------------------------------------------------------------------------------
    Address 15: Airbags        Labels: 1K0-909-605.lbl
       Part No SW: 1K0 909 605 AB    HW: 1K0 909 605 AB
       Component: 6A AIRBAG VW8R  034 8000  
       Revision: 05034000    Serial number: 003B6M0330NS  
       Coding: 0013889
       Shop #: WSC 00066 000 00000
       VCID: 6CF909CD4FB7EF24D4-8038
    
       Subsystem 1 - Part No: 1K0 959 339 F
       Component: BF-Gewichtsens. 007 0005
    
       Subsystem 2 - Serial number: 6332MSME147F3A06H
    
       Subsystem 3 - Serial number: 6342MSME1B3F1472G
    
       Subsystem 4 - Serial number: 6351HSME0F7B400AE
    
       Subsystem 5 - Serial number: 6361HSME0F7A035BJ
    
       Subsystem 6 - Serial number: 63727SME0F11146D1
    
       Subsystem 7 - Serial number: 63827SME0E11457C5
    
    5 Faults Found:
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent - MIL ON
    01221 - Crash Sensor Side Airbag; Driver Side (G179) 
                008 - Implausible Signal - Intermittent - MIL ON
    01221 - Crash Sensor Side Airbag; Driver Side (G179) 
                010 - Open or Short to Plus - Intermittent - MIL ON
    00591 - Seat Belt Switch; Driver (E24) 
                010 - Open or Short to Plus - MIL ON
    01217 - Side Airbag Igniter; Driver Side (N199) 
                001 - Upper Limit Exceeded - MIL ON
    
    -------------------------------------------------------------------------------
    Address 16: Steering wheel        Labels: 1K0-953-549-MY8.lbl
       Part No SW: 1K0 953 549 AP    HW: 1K0 953 549 AP
       Component: Lenksäulenmodul 036 0070  
       Coding: 0010021
       Shop #: WSC 00066 000 00000
       VCID: 00214D7D533F1B4418-8054
    
    3 Faults Found:
    00883 - Ignition Switch (D) Terminal S 
                012 - Electrical Fault in Circuit
    00002 - Transmission Control Unit 
                004 - No Signal/Communication
    02413 - Switch for Selector Lever Position P Lock (F319) 
                008 - Implausible Signal
    
    -------------------------------------------------------------------------------
    Address 17: Instruments        Labels: 1K0-920-xxx-17.lbl
       Part No SW: 1K0 920 954 F    HW: 1K0 920 954 F
       Component: KOMBIINSTRUMENT 3HL 1212  
       Revision: V0002000    Serial number: VWX7Z0G824R0JF
       Coding: 0021203
       Shop #: WSC 00066 000 00000
       VCID: 2F43DEC1BE21543CB1-807A
    
    5 Faults Found:
    00779 - Outside Air Temp Sensor (G17) 
                010 - Open or Short to Plus
                 Freeze Frame:
                        Fault Status: 01101010
                        Fault Priority: 2
                        Fault Frequency: 254
                        Reset counter: 103
                        Mileage: 274490 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 10:41:32
    
    00446 - Function Limitation due to Under-Voltage 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 2
                        Fault Frequency: 22
                        Reset counter: 143
                        Mileage: 284739 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 21:45:33
    
    00779 - Outside Air Temp Sensor (G17) 
                007 - Short to Ground - Intermittent
                 Freeze Frame:
                        Fault Status: 01101010
                        Fault Priority: 2
                        Fault Frequency: 254
                        Reset counter: 103
                        Mileage: 274490 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 10:41:32
    
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 2
                        Fault Frequency: 2
                        Reset counter: 143
                        Mileage: 0 km
                        Time Indication: 0
    
    01314 - Engine Control Module 
                004 - No Signal/Communication - Intermittent
                 Freeze Frame:
                        Fault Status: 00100100
                        Fault Priority: 2
                        Fault Frequency: 3
                        Reset counter: 143
                        Mileage: 284739 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 00:07:58
    
    
    -------------------------------------------------------------------------------
    Address 19: CAN Gateway        Labels:. 1K0-907-530-V3.clb
       Part No SW: 1K0 907 530 L    HW: 1K0 907 951 
       Component: J533  Gateway   H07 0052  
       Revision:   H07 01    Serial number: 290707F1000176
       Coding: E9807F070002021002
       Shop #: WSC 00066 000 00000
       VCID: 3041DDBDA31F4BC4A8-8064
    
    5 Faults Found:
    01314 - Engine Control Module 
                004 - No Signal/Communication - Intermittent
                 Freeze Frame:
                        Fault Status: 00110100
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 143
                        Mileage: 284739 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 00:08:00
    
    01315 - Transmission Control Module 
                004 - No Signal/Communication
                 Freeze Frame:
                        Fault Status: 01100100
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 103
                        Mileage: 284739 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 01:18:56
    
    01305 - Databus for Infotainment 
                014 - Defective - Intermittent
                 Freeze Frame:
                        Fault Status: 00101110
                        Fault Priority: 1
                        Fault Frequency: 254
                        Reset counter: 255
                        Mileage: 191322 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 23:33:36
    
    01305 - Databus for Infotainment 
                004 - No Signal/Communication
                 Freeze Frame:
                        Fault Status: 01100100
                        Fault Priority: 1
                        Fault Frequency: 254
                        Reset counter: 103
                        Mileage: 191222 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 08:18:12
    
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 3
                        Fault Frequency: 1
                        Reset counter: 143
                        Mileage: 284739 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 22:43:36
    
    
    -------------------------------------------------------------------------------
    Address 25: Immobilizer        Labels: 1K0-920-xxx-25.clb
       Part No SW: 1K0 920 954 F    HW: 1K0 920 954 F
       Component: IMMO            3HL 1212  
       Revision: V0002000    Serial number: VWX7Z0G824R0JF
       Shop #: WSC 00000 000 00000
       VCID: 2F43DEC1BE21543CB1-807A
    
    1 Fault Found:
    02241 - Engine Control Module; Immobilizer Data not Adapted 
                000 -  - 
                 Freeze Frame:
                        Fault Status: 01100000
                        Fault Priority: 2
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 0 km
                        Time Indication: 0
    
    
    -------------------------------------------------------------------------------
    Address 42: Door Elect, Driver        Labels:. 1K0-959-701-MIN3.clb
       Part No SW: 1K0 959 701 P    HW: 1K0 959 793 L
       Component: J386  TUER-SG FT    1133  
       Revision: 32008001    Serial number: 00000606478827
       Coding: 0001205
       Shop #: WSC 00066 000 00000
       VCID: 3B5BFA917A59B89C0D-806E
    
    4 Faults Found:
    01811 - Supply Voltage for Door Controller; Drivers Side (J386) 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 4
                        Fault Frequency: 1
                        Reset counter: 143
                        Mileage: 284739 km
                        Time Indication: 0
    
    00932 - Electric Window Motor; Drivers Side (V147) 
                005 - No or Incorrect Basic Setting / Adaptation
                 Freeze Frame:
                        Fault Status: 01100101
                        Fault Priority: 3
                        Fault Frequency: 3
                        Reset counter: 103
                        Mileage: 0 km
                        Time Indication: 0
    
    00928 - Locking Module for Central Locking; Front Driver Side (F220) 
                008 - Implausible Signal - Intermittent
                 Freeze Frame:
                        Fault Status: 00111000
                        Fault Priority: 3
                        Fault Frequency: 4
                        Reset counter: 139
                        Mileage: 284273 km
                        Time Indication: 0
    
    00105 - Signal Central Locking SAVE/LOCK Drivers Side 
                008 - Implausible Signal - Intermittent
                 Freeze Frame:
                        Fault Status: 00101000
                        Fault Priority: 3
                        Fault Frequency: 18
                        Reset counter: 143
                        Mileage: 283441 km
                        Time Indication: 0
    
    
    -------------------------------------------------------------------------------
    Address 44: Steering Assist        Labels: 1Kx-909-144-G2V3.clb
       Part No: 1K1 909 144 M
       Component: EPS_ZFLS Kl.070 H08 1901  
       Shop #: WSC 02069 000 90108
       VCID: 354FECA95C7D6EECFB-8060
    
    4 Faults Found:
    00668 - Supply Voltage Terminal 30 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Mileage: 284730 km
                        Temperature: 22.0°C
                        Voltage: 5.50 V
                        Voltage: 5.30 V
    
    00778 - Steering Angle Sensor (G85) 
                000 -  - 
                 Freeze Frame:
    
    01314 - Engine Control Module 
                004 - No Signal/Communication - Intermittent
                 Freeze Frame:
                        Mileage: 284730 km
                        Temperature: 9.0°C
                        Voltage: 13.00 V
                        Voltage: 12.80 V
    
    00446 - Function Limitation due to Under-Voltage 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Mileage: 284730 km
                        Temperature: 9.0°C
                        Voltage: 6.00 V
                        Voltage: 5.80 V
    
    
    -------------------------------------------------------------------------------
    Address 46: Central Conv.        Labels:. 1K0-959-433-MAX.clb
       Part No SW: 1K0 959 433 CT    HW: 1K0 959 433 CT
       Component:    KSG PQ35 RDK 052 0221  
       Revision: 00052000    Serial number: 00000000000000
       Coding: 1B900F880186083F3F04058FB0880F0488DCA0
       Shop #: WSC 00066 123 12345
       VCID: 0429416D472707643C-8050
    
       Subsystem 1 - Component:   Sounder n.mounted     
    
       Subsystem 2 - Component:       NGS n.mounted     
    
       Subsystem 3 - Component:      IRUE n.mounted     
    
    2 Faults Found:
    01038 - Central Locking Thermal Protection 
                000 -  -  - Intermittent
                 Freeze Frame:
                        Fault Status: 00110000
                        Fault Priority: 4
                        Fault Frequency: 254
                        Reset counter: 143
                        Mileage: 284238 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 23:17:09
    
    00532 - Supply Voltage B+ 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 4
                        Fault Frequency: 5
                        Reset counter: 143
                        Time Indication: 0
    
    
    -------------------------------------------------------------------------------
    Address 52: Door Elect, Pass.        Labels:. 1K0-959-702-MIN3.clb
       Part No SW: 1K0 959 702 P    HW: 1K0 959 792 L
       Component: J387  TUER-SG BT    1133  
       Revision: 32008001    Serial number: 00000561678827
       Coding: 0001204
       Shop #: WSC 00066 000 00000
       VCID: 3C59F98D7F57BFA404-8068
    
    2 Faults Found:
    01812 - Supply Voltage for Door Controller; Pass. Side (J387) 
                002 - Lower Limit Exceeded - Intermittent
                 Freeze Frame:
                        Fault Status: 00100010
                        Fault Priority: 4
                        Fault Frequency: 1
                        Reset counter: 143
                        Mileage: 284739 km
                        Time Indication: 0
    
    00933 - Electric Window Motor; Passenger Side (V148) 
                005 - No or Incorrect Basic Setting / Adaptation - Intermittent
                 Freeze Frame:
                        Fault Status: 00100101
                        Fault Priority: 3
                        Fault Frequency: 1
                        Reset counter: 129
                        Mileage: 0 km
                        Time Indication: 0
    
    
    -------------------------------------------------------------------------------
    Address 56: Radio
    Cannot be reached
    
    -------------------------------------------------------------------------------
    Address 62: Door, Rear Left        Labels:. 1K0-959-703-GEN3.clb
       Part No SW: 1K0 959 703 Q    HW: 1K0 959 795 J
       Component: J388   TUER-SG HL   1120  
       Revision: 12006001    Serial number: 00000002155425
       Coding: 0001168
       Shop #: WSC 00066 000 00000
       VCID: 3E5DF385694BADB42A-806A
    
    No fault code found.
    
    -------------------------------------------------------------------------------
    Address 65: Tire Pressure        Labels: 3C0-959-433-65.lbl
       Part No SW: 1K0 959 433 CT    HW: 1K0 959 433 CT
       Component:    RDK              0450  
       Revision: 00052000    Serial number: 00000000000000
       Coding: 0100101
       Shop #: WSC 131071 1023 2097151
       VCID: 0429416D472707643C-8050
    
    3 Faults Found:
    01521 - Sensor for Tire Pressure 
                004 - No Signal/Communication - Intermittent
                 Freeze Frame:
                        Fault Status: 00100100
                        Fault Priority: 4
                        Fault Frequency: 51
                        Reset counter: 143
                        Mileage: 284392 km
                        Time Indication: 0
    
    00667 - Ambient Temperature Signal 
                008 - Implausible Signal
                 Freeze Frame:
                        Fault Status: 01101000
                        Fault Priority: 4
                        Fault Frequency: 254
                        Reset counter: 101
                        Mileage: 284701 km
                        Time Indication: 0
    
    00625 - Vehicle Speed Signal 
                008 - Implausible Signal - Intermittent
                 Freeze Frame:
                        Fault Status: 00101000
                        Fault Priority: 4
                        Fault Frequency: 16
                        Reset counter: 143
                        Mileage: 284739 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 22:21:52
    
    
    -------------------------------------------------------------------------------
    Address 72: Door, Rear Right        Labels:. 1K0-959-704-GEN3.clb
       Part No SW: 1K0 959 704 Q    HW: 1K0 959 794 J
       Component: J389   TUER-SG HR   1120  
       Revision: 12006001    Serial number: 00000002151119
       Coding: 0001168
       Shop #: WSC 00066 000 00000
       VCID: 3FA38E816E41A4BC21-806A
    
    No fault code found.
    
    End-------------------------(Elapsed Time: 01:18)--------------------------

  8. #17
    Verified VCDS User PetrolDave's Avatar
    Join Date
    Dec 2014
    Location
    South Molton, UK
    Posts
    997
    Post Thanks / Like
    Did you clear all the fault codes after replacing the battery?

  9. #18
    New User
    Join Date
    Mar 2018
    Location
    USA
    Posts
    14
    Post Thanks / Like
    Yes, correct.

  10. #19
    Verified VCDS User PetrolDave's Avatar
    Join Date
    Dec 2014
    Location
    South Molton, UK
    Posts
    997
    Post Thanks / Like
    Given that so many modules are reporting under voltage and this fault code is present:

    Code:
    005699 - Please check DTC Memory of Electric Load Controller                 P1643 - 001 - 
                 Freeze Frame:
                        Fault Status: 01100001
                        Fault Priority: 0
                        Fault Frequency: 1
                        Reset counter: 255
                        Mileage: 284739 km
                        Time Indication: 0
                        Date: 2000.00.00
                        Time: 03:57:24
    
                 Freeze Frame:
                        RPM: 0 /min
                        Load: 0.0 %
                        Speed: 0.0 km/h
                        Temperature: 24.0°C
                        Temperature: 26.0°C
                        Absolute Pres.: 960.0 mbar
                        Voltage: 11.938 V
    I wonder if the Battery Management system is shutting down power because it hasn't been told about the new battery?

  11. #20
    New User
    Join Date
    Mar 2018
    Location
    USA
    Posts
    14
    Post Thanks / Like
    Dave, I will try doing the battery adaptation and see where that gets me. In my history with the car I never had to do this when switching batteries - but its worth a shot.


    What else do you think it could be?

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •