Golf 5 BAG engine misfire

   #1  

Fredrick Awuor

Verified VCDS User
Verified
Joined
Jul 14, 2017
Messages
243
Reaction score
156
Location
Kenya
VCDS Serial number
C?ID=309834
Hello everyone, I have swapped plugs/ coilpacks no1 and 4 to cylinders 2 and 3 then misfire disappears but comes back after a 20 min test drive to cylinders 3 and 2,done compression test,cylinder 2 slightly higher than any cylinder at 210 psi,remaining cylinders average around 185 psi,since I don't have documented compression figures,I'm pretty groping in the dark,I'm suspecting the coilpack wiring harness but I don't have testing procedures or WD,I'd be grateful if someone can open my eyes on this and if the other fault codes are a contributing factor

Code:
Friday,09,February,2018,13:02:34:48669
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64
VCDS Version: 18.1.0.2 (x64)  HEX-V2 CB: 0.4411.4
Data version: 20180122 DS285.1
www.Ross-Tech.com

Dealer/Shop Name: FREDRICK'S VWAUDI

VIN: WVWZZZ1KZ4U002156   License Plate: 
Mileage: 124090km-77105mi   Repair Order: 



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 1K (1K0)
Scan: 01 02 03 08 09 15 16 17 19 25 42 44 46 52 56 62 72

VIN: WVWZZZ1KZ4U002156   Mileage: 124090km-77105miles

00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
56-Radio -- Status: Malfunction 0010
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine        Labels: 03C-906-056-BAG.lbl
   Part No SW: 03C 997 056 N    HW: Hardware No 
   Component: MED9.5.10        00 9270  
   Revision: 00000000    Serial number: VWZ7Z0D9450717
   Coding: 0000075
   Shop #: WSC 73330 981 12795
   VCID: 382A210DAE586A17905-806C

6 Faults Found:
16648 - Fuel Injector #2 (N31) 
            P0264 - 002 - Short to Ground - Intermittent - MIL ON
18320 - Pressure Sensor for Brake Boost (G294) 
            P1912 - 001 - Short to Plus
17439 - Intake Manifold Tuning Valve (N316) 
            P1031 - 004 - Setpoint Not Reached
16684 - Random/Multiple Cylinder Misfire Detected 
            P0300 - 001 - 
16687 - Cylinder 3 
            P0303 - 001 - Misfire Detected
16686 - Cylinder 2 
            P0302 - 001 - Misfire Detected
Readiness: 1110 0101

-------------------------------------------------------------------------------
Address 02: Auto Trans        Labels: 09G-927-750.clb
   Part No: 09G 927 750 BN
   Component: AQ 250 6F           0524  
   Coding: 0000008
   Shop #: WSC 00046 412 00000
   VCID: 7EA6F715CCFC94271A9-802A

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes        Labels: 1K0-907-379-MK60-F.lbl
   Part No: 1K0 907 379 K
   Component: ESP FRONT MK60      0103  
   Coding: 0019074
   Shop #: WSC 00046 412 00000
   VCID: 3A2E3B0590547807661-806E

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC        Labels: 1K0-820-047.lbl
   Part No: 1K0 820 047 CB
   Component: Climatic PQ35   080 0201  
   Shop #: WSC 00000 000 00000
   VCID: 6696BF75B46C2CE7F29-8032

1 Fault Found:
00229 - Refrigerant Pressure 
            002 - Lower Limit Exceeded

-------------------------------------------------------------------------------
Address 09: Cent. Elect.        Labels:. 3C0-937-049-23-M.lbl
   Part No SW: 1K0 937 049 K    HW: 1K0 937 049 K*
   Component: Bordnetz-SG 1.0 H30 0701  
   Revision: 00030000    Serial number: 00000000667936
   Coding: 008D0F0600041800001400001400000000
   Shop #: WSC 00000 000 00000
   VCID: 37282231A346656F99F-8062

   Subsystem 1 - Part No: 1K2 955 119 B  Labels: 1KX-955-119.CLB
   Component: Wischer VW350  012  0401  
   Coding: 00049109
   Shop #: WSC 00000  

No fault code found.

-------------------------------------------------------------------------------
Address 15: Airbags        Labels: 1K0-909-605.lbl
   Part No SW: 1K0 909 605 F    HW: 1K0 909 605 F
   Component: 03 AIRBAG VW8R  023 5600  
   Revision: 07023000    Serial number: 0037RD042WBD  
   Coding: 0012339
   Shop #: WSC 00046 412 00000
   VCID: 2F381A515B16ADAFC1F-807A

   Subsystem 1 - Serial number: 6332MSME022F077CG

   Subsystem 2 - Serial number: 6342MSME02307C2FD

   Subsystem 3 - Serial number: 6351HSME0206030F-

   Subsystem 4 - Serial number: 6361HSME01750F501

1 Fault Found:
01217 - Side Airbag Igniter; Driver Side (N199) 
            001 - Upper Limit Exceeded - MIL ON

-------------------------------------------------------------------------------
Address 16: Steering wheel        Labels: 1K0-953-549-MY8.lbl
   Part No SW: 1K0 953 549     HW: 1K0 953 549 
   Component: Lenksäulenmodul 012 0030  
   Coding: 0010002
   Shop #: WSC 00000 000 00000
   VCID: 6FB8DA519B96EDAF81F-803A

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments        Labels: 1K0-920-xxx-17.lbl
   Part No: 1K0 920 850 K
   Component: KOMBIINSTRUMENT VDD 3556  
   Coding: 0003501
   Shop #: WSC 06402 785 00200
   VCID: 2F381A515B16ADAFC1F-807A

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway        Labels:. 1K0-907-530-V1.clb
   Part No SW: 1K0 907 530 C    HW: 1K0 907 951 
   Component: Gateway         H08 0080  
   Revision: 08          Serial number: 2100104304030B
   Coding: 3F3F0340070003
   Shop #: WSC 00046 412 00000
   VCID: 2708F27173E6F5EF09F-8072

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer        Labels: 1K0-920-xxx-25.clb
   Part No: 1K0 920 850 K
   Component: IMMO                3556  
   Shop #: WSC 00000 000 00000
   VCID: 2F381A515B16ADAFC1F-807A

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver        Labels: 1K0-959-701-MAX1.lbl
   Part No: 1K0 959 701 G
   Component: Tuersteuergeraet 09 0124  
   Coding: 0000054
   Shop #: WSC 01279 785 00200
   VCID: 323E132548248047AE1-8066

1 Fault Found:
00131 - Outside Door Handle Illumination/mirror Light Driver Side 
            012 - Electrical Fault in Circuit

-------------------------------------------------------------------------------
Address 44: Steering Assist        Labels: 1Kx-909-144-G2V2.clb
   Part No: 1K2 909 144 G
   Component: EPS_ZFLS Kl.0       1301  
   Shop #: WSC 00000 000 00000
   VCID: 303A192D4628B257D85-8064

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv.        Labels:. 1K0-959-433-MIN.clb
   Part No: 1K0 959 433 E
   Component:    KSG              0201  
   Coding: 00E802087F2D8404085F0100
   Shop #: WSC 00046 412 00000
   VCID: 323E132548248047AE1-8066

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass.        Labels: 1K0-959-702-MAX1.lbl
   Part No: 1K0 959 702 G
   Component: Tuersteuergeraet 09 0116  
   Coding: 0000054
   Shop #: WSC 00046 000 00000
   VCID: 33301621B73E894FA57-8066

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio        Labels: 1K0-035-1xx-56.lbl
   Part No: 1K0 035 182 A
   Component: Radio BNO           0012  
   Coding: 0040400
   Shop #: WSC 00046 412 00000
   VCID: 201AE96D16C802D7485-8074

2 Faults Found:
00856 - Radio Antenna 
            011 - Open Circuit
00821 - Antenna 2 for Radio (R93) 
            011 - Open Circuit

-------------------------------------------------------------------------------
Address 62: Door, Rear Left        Labels: 1K0-959-703-GEN1.lbl
   Part No: 1K0 959 703 C
   Component: Tuersteuergeraet 06 0202  
   Coding: 0000016
   Shop #: WSC 00046 412 00000
   VCID: 303A192D4628B257D85-8064

No fault code found.

-------------------------------------------------------------------------------
Address 72: Door, Rear Right        Labels: 1K0-959-704-GEN1.lbl
   Part No: 1K0 959 704 C
   Component: Tuersteuergeraet 06 0202  
   Coding: 0000016
   Shop #: WSC 00046 412 00000
   VCID: 313C1C294D22BB5FD7B-8064

No fault code found.

End----------(Elapsed Time: 01:00, VBatt start/end: 14.1V/14.1V)-----------
 
Last edited by a moderator:
   #3  

Jack@European_Parts

Gone But Not Forgotten
Professional VCDS User
Joined
Jan 29, 2014
Messages
21,923
Reaction score
9,308
Location
Montgomery, NY, USA
VCDS Serial number
C?ID=57337
In addition to Uwe's fine suggestion...... :rolleyes:

That and the G294 being a short to + bothers me....

Get ERWIN and WD and trace the bus and all components with a DTC to see what is a shared track.
 
   #4  

downtime

Verified VCDS User
Verified
Joined
May 27, 2017
Messages
3,335
Reaction score
2,085
Location
Finland
VCDS Serial number
C?ID=280813
This is FSI engine right? If you have original coil pack, I would guess that's the reason for the problems. They are prone to go at some point on these engines.

Or another option, look here : http://www.vwaudiforum.co.uk/forum/showthread.php/74386-A2-1-6-fsi-misfire!!!!

Disconnect the ECU for 2 hours to completely reset it, seems that ECU gets "full" on it's adaptation value table and does not adjust the ignition timing correctly.
 
   #5  

Fredrick Awuor

Verified VCDS User
Verified
Joined
Jul 14, 2017
Messages
243
Reaction score
156
Location
Kenya
VCDS Serial number
C?ID=309834
In addition to Uwe's fine suggestion...... :rolleyes:

That and the G294 being a short to + bothers me....

Get ERWIN and WD and trace the bus and all components with a DTC to see what is a shared track.

Hello Jack,client says this particular injector has been replaced, there's this intermittent sharp sound of coil pack leaking current to ground even after swapping coilpacks which puzzles me,
 
   #6  

Fredrick Awuor

Verified VCDS User
Verified
Joined
Jul 14, 2017
Messages
243
Reaction score
156
Location
Kenya
VCDS Serial number
C?ID=309834
This is FSI engine right? If you have original coil pack, I would guess that's the reason for the problems. They are prone to go at some point on these engines.

Or another option, look here : http://www.vwaudiforum.co.uk/forum/showthread.php/74386-A2-1-6-fsi-misfire!!!!

Disconnect the ECU for 2 hours to completely reset it, seems that ECU gets "full" on it's adaptation value table and does not adjust the ignition timing correctly.

Thanks Downtime,Yes,it is FSI,3 coilpacks made in turkey,1 in Italy,they look original,I will try to get different coils to fit and try
 
   #7  

Jack@European_Parts

Gone But Not Forgotten
Professional VCDS User
Joined
Jan 29, 2014
Messages
21,923
Reaction score
9,308
Location
Montgomery, NY, USA
VCDS Serial number
C?ID=57337
What about water ingress inside ECU for FOD?

Two shorts .....very uncommon.......water common!
 
   #8  

Fredrick Awuor

Verified VCDS User
Verified
Joined
Jul 14, 2017
Messages
243
Reaction score
156
Location
Kenya
VCDS Serial number
C?ID=309834
What about water ingress inside ECU for FOD?

Two shorts .....very uncommon.......water common!

Hello Jack,I think downloading pdfs from erwin is a bit tricky,so i took my time and found out that the wiring harness to fuel injectors was misrouted and passed too close to EGR steel tube near coolant flange,and injector No2 wires insulation was slowly being roasted thereby exposing them to contact ground on EGR tube, I then properly rerouted the harness after applying good insulation.The misfire disappeared for good,we test drove for close to 100kms,it hasn't come back,but new error codes have come up in this autoscan,i also found one broken brake boost sensor wire,soldered back in place,no more problem with it

Code:
Friday,16,February,2018,16:01:48:48669
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 7 x64
VCDS Version: 18.1.0.2 (x64)  HEX-V2 CB: 0.4411.4
Data version: 20180122 DS285.1
www.Ross-Tech.com

Dealer/Shop Name: FREDRICK'S VWAUDI

VIN: WVWZZZ1KZ4U002156   License Plate: 
Mileage: 124360km-77273mi   Repair Order: 



--------------------------------------------------------------------------------
--------------------------------------------------------------------------------


Chassis Type: 1K (1K0)
Scan: 01 02 03 08 09 15 16 17 19 25 42 44 46 52 56 62 72

VIN: WVWZZZ1KZ4U002156   Mileage: 124360km-77273miles

00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: Malfunction 0010
02-Auto Trans -- Status: OK 0000
03-ABS Brakes -- Status: Malfunction 0010
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: Malfunction 0010
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: Malfunction 0010
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
56-Radio -- Status: Malfunction 0010
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine        Labels: 03C-906-056-BAG.lbl
   Part No SW: 03C 997 056 N    HW: Hardware No 
   Component: MED9.5.10        00 9270  
   Revision: 00000000    Serial number: VWZ7Z0D9450717
   Coding: 0000075
   Shop #: WSC 73330 981 12795
   VCID: 382A210DAE586A17905-806C

6 Faults Found:
17439 - Intake Manifold Tuning Valve (N316) 
            P1031 - 008 - Setpoint Not Reached - MIL ON
18702 - Oxygen (Lambda) Sensor Signal B1 S2 
            P2270 - 001 - too Lean - Intermittent
18973 - Low Pressure Fuel Sensor (G410) 
            P2541 - 001 - Short to Ground - Intermittent
16575 - Fuel Pressure Sensor (G247) 
            P0191 - 008 - Implausible Signal - Intermittent
16825 - EVAP Emission Control Sys 
            P0441 - 002 - Incorrect Flow - Intermittent
17480 - NOx Sensor (G295) Heater Control 
            P1072 - 008 - Circuit Malfunction - MIL ON
Readiness: 1000 0001

-------------------------------------------------------------------------------
Address 02: Auto Trans        Labels: 09G-927-750.clb
   Part No: 09G 927 750 BN
   Component: AQ 250 6F           0524  
   Coding: 0000008
   Shop #: WSC 00046 412 00000
   VCID: 7EA6F715CCFC94271A9-802A

No fault code found.

-------------------------------------------------------------------------------
Address 03: ABS Brakes        Labels: 1K0-907-379-MK60-F.lbl
   Part No: 1K0 907 379 K
   Component: ESP FRONT MK60      0103  
   Coding: 0019074
   Shop #: WSC 00046 412 00000
   VCID: 3A2E3B0590547807661-806E

1 Fault Found:
00778 - Steering Angle Sensor (G85) 
            003 - Mechanical Failure - Intermittent

-------------------------------------------------------------------------------
Address 08: Auto HVAC        Labels: 1K0-820-047.lbl
   Part No: 1K0 820 047 CB
   Component: Climatic PQ35   080 0201  
   Shop #: WSC 00000 000 00000
   VCID: 6696BF75B46C2CE7F29-8032

1 Fault Found:
00229 - Refrigerant Pressure 
            002 - Lower Limit Exceeded

-------------------------------------------------------------------------------
Address 09: Cent. Elect.        Labels:. 3C0-937-049-23-M.lbl
   Part No SW: 1K0 937 049 K    HW: 1K0 937 049 K*
   Component: Bordnetz-SG 1.0 H30 0701  
   Revision: 00030000    Serial number: 00000000667936
   Coding: 008D0F0600041800001400001400000000
   Shop #: WSC 00000 000 00000
   VCID: 37282231A346656F99F-8062

   Subsystem 1 - Part No: 1K2 955 119 B  Labels: 1KX-955-119.CLB
   Component: Wischer VW350  012  0401  
   Coding: 00049109
   Shop #: WSC 00000  

1 Fault Found:
01049 - Supply Voltage Term 50 
            006 - Short to Plus - Intermittent

-------------------------------------------------------------------------------
Address 15: Airbags        Labels: 1K0-909-605.lbl
   Part No SW: 1K0 909 605 F    HW: 1K0 909 605 F
   Component: 03 AIRBAG VW8R  023 5600  
   Revision: 07023000    Serial number: 0037RD042WBD  
   Coding: 0012339
   Shop #: WSC 00046 412 00000
   VCID: 2F381A515B16ADAFC1F-807A

   Subsystem 1 - Serial number: 6332MSME022F077CG

   Subsystem 2 - Serial number: 6342MSME02307C2FD

   Subsystem 3 - Serial number: 6351HSME0206030F-

   Subsystem 4 - Serial number: 6361HSME01750F501

1 Fault Found:
01217 - Side Airbag Igniter; Driver Side (N199) 
            001 - Upper Limit Exceeded - MIL ON

-------------------------------------------------------------------------------
Address 16: Steering wheel        Labels: 1K0-953-549-MY8.lbl
   Part No SW: 1K0 953 549     HW: 1K0 953 549 
   Component: Lenksäulenmodul 012 0030  
   Coding: 0010002
   Shop #: WSC 00000 000 00000
   VCID: 6FB8DA519B96EDAF81F-803A

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments        Labels: 1K0-920-xxx-17.lbl
   Part No: 1K0 920 850 K
   Component: KOMBIINSTRUMENT VDD 3556  
   Coding: 0003501
   Shop #: WSC 06402 785 00200
   VCID: 2F381A515B16ADAFC1F-807A

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway        Labels:. 1K0-907-530-V1.clb
   Part No SW: 1K0 907 530 C    HW: 1K0 907 951 
   Component: Gateway         H08 0080  
   Revision: 08          Serial number: 2100104304030B
   Coding: 3F3F0340070003
   Shop #: WSC 00046 412 00000
   VCID: 2708F27173E6F5EF09F-8072

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer        Labels: 1K0-920-xxx-25.clb
   Part No: 1K0 920 850 K
   Component: IMMO                3556  
   Shop #: WSC 00000 000 00000
   VCID: 2F381A515B16ADAFC1F-807A

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver        Labels: 1K0-959-701-MAX1.lbl
   Part No: 1K0 959 701 G
   Component: Tuersteuergeraet 09 0124  
   Coding: 0000054
   Shop #: WSC 01279 785 00200
   VCID: 323E132548248047AE1-8066

1 Fault Found:
00131 - Outside Door Handle Illumination/mirror Light Driver Side 
            012 - Electrical Fault in Circuit

-------------------------------------------------------------------------------
Address 44: Steering Assist        Labels: 1Kx-909-144-G2V2.clb
   Part No: 1K2 909 144 G
   Component: EPS_ZFLS Kl.0       1301  
   Shop #: WSC 00000 000 00000
   VCID: 303A192D4628B257D85-8064

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv.        Labels:. 1K0-959-433-MIN.clb
   Part No: 1K0 959 433 E
   Component:    KSG              0201  
   Coding: 00E802087F2D8404085F0100
   Shop #: WSC 00046 412 00000
   VCID: 323E132548248047AE1-8066

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass.        Labels: 1K0-959-702-MAX1.lbl
   Part No: 1K0 959 702 G
   Component: Tuersteuergeraet 09 0116  
   Coding: 0000054
   Shop #: WSC 00046 000 00000
   VCID: 33301621B73E894FA57-8066

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio        Labels: 1K0-035-1xx-56.lbl
   Part No: 1K0 035 182 A
   Component: Radio BNO           0012  
   Coding: 0040400
   Shop #: WSC 00046 412 00000
   VCID: 201AE96D16C802D7485-8074

2 Faults Found:
00856 - Radio Antenna 
            011 - Open Circuit
00821 - Antenna 2 for Radio (R93) 
            011 - Open Circuit

-------------------------------------------------------------------------------
Address 62: Door, Rear Left        Labels: 1K0-959-703-GEN1.lbl
   Part No: 1K0 959 703 C
   Component: Tuersteuergeraet 06 0202  
   Coding: 0000016
   Shop #: WSC 00046 412 00000
   VCID: 303A192D4628B257D85-8064

No fault code found.

-------------------------------------------------------------------------------
Address 72: Door, Rear Right        Labels: 1K0-959-704-GEN1.lbl
   Part No: 1K0 959 704 C
   Component: Tuersteuergeraet 06 0202  
   Coding: 0000016
   Shop #: WSC 00046 412 00000
   VCID: 313C1C294D22BB5FD7B-8064

No fault code found.

End----------(Elapsed Time: 01:04, VBatt start/end: 14.1V/14.0V)-----------
 
Last edited by a moderator:
Back
Top