New to me 2006 Jetta Non working wipers

   #1  

MTShaun

Verified VCDS User
Verified
Joined
Dec 1, 2017
Messages
13
Reaction score
9
Location
USA
VCDS Serial number
C?ID=323037
Hello all, this is my first post to this forum as I just received my Vag-com last night! Thank for having me!

In the last month I acquired my 2006 Jetta 1.9 tdi with 204k miles (now with 207,8xx). I bought it knowing the wipers didn't work thinking big deal, fuse right?! Well wrong. I've checked all fuses, hood switch works, washer fluid sprays work. I got a used motor/transmission assembly from local salvage yard, same status. I drove the car to a dealer 2 hours away for them to tell me they couldn't figure out the problem and I needed to schedule another appointment. They did tell me 3 modules were not communicating... no other details although they didn't charge me either so not much to complain about there.. I have also verified battery power to wiper motor plug, have continuity thorough ground wire and signal wire was showing 10.X volts. I have pulled my dash apart and checked pins and plugs at j519 module and j527 module in steering wheel and continuity to as many wires as I can trace. It was apparent some one else has been in there before as the J527 module had a sticker on the case that was peeled back. I have invested about 16 hours into figuring out this issue and has become apparent that I needed the Vag-com. I will post my auto scan below, I see there are a couple things in the scan I didn't know was an issue as well like the heater element and radio issue. I wonder if someone has changed the original radio to a lower option stock radio because XM radio sent me a 2 month trial radio offer but this one does not have satellite option. As far as I can tell the car is completely stock. I also had and airbag light come on after I had taken the dash and steering column apart (did all this with battery disconnected) which I was able to clear. Bulb out indicator was on until I discovered city light bulbs were missing, appears as someone replaced headlights and failed to install bulbs.

If I've missed any info please ask, I am trying my best for this 1st time around. Never used vag-com before and I do not have a service manual although this will be my next investment so suggestions are greatly appreciated of which one to get.

Thank you in advance for any help offered, I am very handy and competent just needing input where to go from here.

Best Regards

Code:
Friday,01,December,2017,11:37:35:59552
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 17.8.1.0 (x64)  HEX-V2 CB: 0.4407.4
Data version: 20171130 DS276.6
www.Ross-Tech.com


VIN: 3VWST71K66M773440   License Plate: 
Mileage: 334470km-207830mi   Repair Order: 001


Chassis Type: 1K (1K0)
Scan: 01 03 08 09 0F 15 16 17 19 25 42 44 46 52 56 62 72 7D

VIN: 3VWST71K66M773440   Mileage: 334470km-207830miles

00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
0F-Digital Radio -- Status: Malfunction 0010
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
7D-Aux. Heat -- Status: Malfunction 0010
-------------------------------------------------------------------------------
Address 01: Engine        Labels: 038-906-016-BEW.lbl
   Part No SW: 03G 906 016 AB    HW: 028 101 223 8
   Component: R4 1,9L EDC G000SG  7550  
   Revision: --H01---    Serial number: VWZ7Z0F3301138
   Coding: 0050071
   Shop #: WSC 00066 000 00000
   VCID: 6393528E275B321F273-8036

No fault code found.
Readiness: 0 0 0 0 1 

-------------------------------------------------------------------------------
Address 03: ABS Brakes        Labels: 1K0-907-379-MK60-F.lbl
   Part No SW: 1K0 907 379 AA    HW: 1K0 907 379 AA
   Component: ESP FRONT MK60      0102  
   Revision: 00H13001    
   Coding: 0021122
   Shop #: WSC 00066 000 00000
   VCID: 71BF28C6EDA7908FA5F-8024

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC        Labels: 1K0-820-047.lbl
   Part No: 1K0 820 047 EC
   Component: Climatic PQ35   090 0505  
   Shop #: WSC 00000 000 00000
   VCID: 698F40A6C577684FEDF-803C

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect.        Labels:. 3C0-937-049-23-M.lbl
   Part No SW: 3C0 937 049 D    HW: 3C0 937 049 D
   Component: Bordnetz-SG     H37 1002  
   Revision: 00H37000    Serial number: 00000000253641
   Coding: 14018E234004180000140000001400000008730B5C
   Shop #: WSC 23301 444 00792
   VCID: 2A0DFFAA00F1A357245-807E

   Subsystem 1 - Component: Fehler Lin-Slave 01 

2 Faults Found:
02071 - Local Databus 
            004 - No Signal/Communication
             Freeze Frame:
                    Fault Status: 01100100
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 32
                    Mileage: 334470 km
                    Time Indication: 0

             Freeze Frame:
                        ON
                    Voltage: 13.00 V
                        ON
                        ON
                        OFF
                        OFF
                        OFF

00153 - Windshield Wiper Motor;  Driver Side (V216) 
            004 - No Signal/Communication
             Freeze Frame:
                    Fault Status: 01100100
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 32
                    Mileage: 334470 km
                    Time Indication: 0

             Freeze Frame:
                        ON
                    Voltage: 13.00 V
                        ON
                        ON
                        OFF
                        OFF
                        OFF


-------------------------------------------------------------------------------
Address 0F: Digital Radio        Labels: 8E0-035-593-XM.lbl
   Part No SW: 8E0 035 593 E    HW: 8E0 035 593 E
   Component: SDAR XM         H03 0080  
   Revision: 00000000    Serial number: AUZ4Z7F5044210
   Shop #: WSC 00000 000 00000
   VCID: 2B03FAAE0F0BBA5FDF3-807E

1 Fault Found:
02635 - Tuner Not Enabled/Activated 
            000 -  - 
             Freeze Frame:
                    Fault Status: 01100000
                    Fault Priority: 7
                    Fault Frequency: 1
                    Reset counter: 32
                    Mileage: 334470 km
                    Time Indication: 0
                    Date: 2000.00.00
                    Time: 22:33:01


-------------------------------------------------------------------------------
Address 15: Airbags        Labels: 1K0-909-605.lbl
   Part No SW: 1K0 909 605 P    HW: 1K0 909 605 P
   Component: 39 AIRBAG VW8R  032 7900  
   Revision: 03032000    Serial number: 0038FD042AJV  
   Coding: 0013113
   Shop #: WSC 00066 000 00000
   VCID: 392FD0E6F55718CF5DF-806C

   Subsystem 1 - Part No: 1K0 959 339 E
   Component: BF-Gewichtsens. 006 0005

   Subsystem 2 - Serial number: 6332MSME0D35450EF

   Subsystem 3 - Serial number: 6342MSME0D351D60D

   Subsystem 4 - Serial number: 6351HSME091C174AB

   Subsystem 5 - Serial number: 6361HSME091D1C49H

   Subsystem 6 - Serial number: 63727SME08254B4C6

   Subsystem 7 - Serial number: 63827SME086C4B5DK

No fault code found.

-------------------------------------------------------------------------------
Address 16: Steering wheel        Labels: 1K0-953-549-MY8.lbl
   Part No SW: 1K0 953 549 AH    HW: 1K0 953 549 AH
   Component: J0527           034 0070  
   Coding: 0000021
   Shop #: WSC 00066 000 00000
   VCID: 78A915E28EDDC1C7621-802C

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments        Labels: 1K0-920-xxx-17.lbl
   Part No: 1K0 920 952 L
   Component: KOMBIINSTRUMENT 3HL 4312  
   Coding: 0023203
   Shop #: WSC 23317 444 85571
   VCID: 3333E2CED73BE29F973-8066

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway        Labels:. 1K0-907-530-V1.clb
   Part No SW: 1K0 907 530 F    HW: 1K0 907 951 
   Component: Gateway         H10 0120  
   Revision:   H10       Serial number: 2800105C1284CC
   Coding: 3D3F0B60071002
   Shop #: WSC 00066 000 00000
   VCID: 2A0DFFAA00F1A357245-807E

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer        Labels: 1K0-920-xxx-25.clb
   Part No: 1K0 920 952 L
   Component: IMMO            3HL 4312  
   Shop #: WSC 00000 000 00000
   VCID: 3333E2CED73BE29F973-8066

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver        Labels: 1K0-959-701-MIN2.lbl
   Part No: 1K0 959 701 K
   Component: Tuer-SG         024 2377  
   Coding: 0001269
   Shop #: WSC 00066 000 00000
   VCID: 3635DBDAC449F7B7B0D-8062

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist        Labels: 1Kx-909-144-G2V2.clb
   Part No: 1K1 909 144 K
   Component: EPS_ZFLS Kl.5   D06 1701  
   Shop #: WSC 00000 000 00000
   VCID: 3333E2CED73BE29F973-8066

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv.        Labels:. 1K0-959-433-MIN.clb
   Part No: 1K0 959 433 AF
   Component:    KSG              0401  
   Coding: 137803281B09058F880F048051A0
   Shop #: WSC 00066 000 00000
   VCID: 74B121D292B5A5A74E9-8020

   Subsystem 1 - Component:   Sounder n.mounted     

   Subsystem 2 - Component:       NGS n.mounted     

   Subsystem 3 - Component:      IRUE n.mounted     

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass.        Labels: 1K0-959-702-MIN2.lbl
   Part No: 1K0 959 702 K
   Component: Tuer-SG         024 2377  
   Coding: 0001269
   Shop #: WSC 00066 000 00000
   VCID: 372BD6DEC3430EBFABB-8062

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio        Labels: 1K0-035-1xx-56.lbl
   Part No SW: 1K0 035 180 A    HW: 1K0 035 180 A
   Component: Radio DE2       008 0011  
   Revision: 00008000    Serial number: VWZ4Z7E2009284
   Coding: 0040400
   Shop #: WSC 00066 000 00000
   VCID: 1E65237A4CB95FF748D-804A

No fault code found.

-------------------------------------------------------------------------------
Address 62: Door, Rear Left        Labels: 1K0-959-703-GEN2.lbl
   Part No: 1K0 959 703 D
   Component: Tuer-SG         021 2434  
   Coding: 0000144
   Shop #: WSC 00066 000 00000
   VCID: 313FE8C62D27D08FE5F-8064

No fault code found.

-------------------------------------------------------------------------------
Address 72: Door, Rear Right        Labels: 1K0-959-704-GEN2.lbl
   Part No: 1K0 959 704 D
   Component: Tuer-SG         021 2434  
   Coding: 0000144
   Shop #: WSC 00066 000 00000
   VCID: 323DE7CA2821EB979C5-8066

No fault code found.

-------------------------------------------------------------------------------
Address 7D: Aux. Heat        Labels: 1K0-963-235.lbl
   Part No SW: 1K0 963 235 E    HW: 1K0 963 235 E
   Component: PTC-Element         0404  
   Revision: 00800000    Serial number:               
   Shop #: WSC 00000 000 00000
   VCID: 2D07F4B6311FB46FC17-8078

1 Fault Found:
00361 - Heater Element for Auxiliary Heater (Z35) 
            014 - Defective

End----------(Elapsed Time: 01:08, VBatt start/end: 13.0V/13.0V)-----------
 
Last edited by a moderator:
   #2  

Jack@European_Parts

Gone But Not Forgotten
Professional VCDS User
Joined
Jan 29, 2014
Messages
21,923
Reaction score
9,308
Location
Montgomery, NY, USA
VCDS Serial number
C?ID=57337
Welcome to the VCDS forums OP and thank you for posting an auto-scan........

What is the status of stalk switches in VCDS blocks....?

Take a power probe or led test light and connect it to the can wires without applying power with the probe then pull the stalk or change position of speeds and see if any COM flash changes on blink of LED.

Is power and ground at motor sufficient?
Have you coded or adapted the wiper motor as per the RTFB?

Faults are pretty clear on local DB.......see WD and verify the twisted pair for CAN.

http://forums.ross-tech.com/showthr...a-you-should-have-a-baseline-understanding-of-!


JPPSG

http://forums.ross-tech.com/showthr...essional-Problem-Solver-Guide-quot-JPPSG-quot
 
   #3  

downtime

Verified VCDS User
Verified
Joined
May 27, 2017
Messages
3,306
Reaction score
2,064
Location
Finland
VCDS Serial number
C?ID=280813
Are you sure the motor assembly you got as replacement is ok? There's no CAN connection to wiper motor as it's on LIN bus. So there shouldn't be any CAN wires going to it. As far as I remember the LIN bus works on single wire.

The error you see is usually indicator that the wiper motor assembly is dead. You might get signal to the plug but the problem is inside the assembly, there's a controller chip that fries and it does not communicate with the BCM anymore. Same effect happens if you install bad quality aftermarket xenon set.

I would return the salvaged the part you got and get another one just to make sure.

I presume Jetta has only one motor for the wipers?
 
   #5  

MTShaun

Verified VCDS User
Verified
Joined
Dec 1, 2017
Messages
13
Reaction score
9
Location
USA
VCDS Serial number
C?ID=323037
Thank you both for your quick replies.

I am playing with VCDS and figuring out some cool stuff! The wiper switch in the vcds blocks appears to be working because the status changes with each adjustment. I am not sure the motor assembly I got from the salvage yard is good or not, how can I test it? Also as I wrote in my initial post, I checked continuity to ground, it appears sufficient. The main power wire is same as battery voltage and the signal wire is 10+/- volts depending on selector stock. I don't know what is sufficient here...

The Jetta does only have one motor for the wipers in which I have become an expert in removing and installing during all my troubleshooting :)

If I get a good motor assembly would the car recognize it right away or would programming through vcds be in order?
 
   #6  

Jef

Ross-Tech Employee
Staff member
Ross-Tech Employee
Joined
Jan 29, 2014
Messages
3,949
Reaction score
6,332
Location
HQ
2 Faults Found:
02071 - Local Databus
004 - No Signal/Communication

00153 - Windshield Wiper Motor; Driver Side (V216)
004 - No Signal/Communication

G8YGwbm.jpg


You need to verify you have good power, ground and data at the wiper motor. If any of those is not to factory design, those fault codes will get flagged. If all 3 are to factory design, then bad wiper motor, or in some rare cases... bad J519. So tell me about your headlights....
 
   #7  

MTShaun

Verified VCDS User
Verified
Joined
Dec 1, 2017
Messages
13
Reaction score
9
Location
USA
VCDS Serial number
C?ID=323037
I removed my wiper motor, salvage yard will refund me but they don't have another one. I did find one at another yard so I will pick this one up and give it a try. I will keep all of you posted on the results of this next replacement!
 
   #8  

MTShaun

Verified VCDS User
Verified
Joined
Dec 1, 2017
Messages
13
Reaction score
9
Location
USA
VCDS Serial number
C?ID=323037
My headlights are factory replacements it looks like. They use the same wiring with h7 halogen bulbs.
 
   #9  

Jef

Ross-Tech Employee
Staff member
Ross-Tech Employee
Joined
Jan 29, 2014
Messages
3,949
Reaction score
6,332
Location
HQ
   #10  

MTShaun

Verified VCDS User
Verified
Joined
Dec 1, 2017
Messages
13
Reaction score
9
Location
USA
VCDS Serial number
C?ID=323037
Ok, so I put in another wiper motor. Same status no luck, I'm thinking it must the J519 Jef? On your chart I have power and ground at the motor, how do I check Data?
 
   #11  

Jef

Ross-Tech Employee
Staff member
Ross-Tech Employee
Joined
Jan 29, 2014
Messages
3,949
Reaction score
6,332
Location
HQ
Wiper motor, V216

T4p/1, ro/ws 2.5mm², from SB19 (30A), terminal 30
T4p/2, br, 2.5mm², ground connection around left headlight area
T4p/4, li/ws, 0.35mm², LIN to J519 F3

So... do you have power/ground on /1 and /2? Can they carry load (light up a fog light bulb for example)?
Data... that is /4 and it runs to the J519.

Now to toss an extra item into the mix... do you have a rain/light sensor (G397)? I don't think you do, but if so, that sensor will be tied into the same LIN bus for the wiper motor as well.
 
   #12  

MTShaun

Verified VCDS User
Verified
Joined
Dec 1, 2017
Messages
13
Reaction score
9
Location
USA
VCDS Serial number
C?ID=323037
01117 - Generator Terminal DF Load Signal
008 - Implausible Signal - Intermittent

This fault didn't show up in my earlier auto scan, what is it referencing to?
Jeff, I will do my best to decode your last post, this is all new and greek to me LOL!



Code:
Friday,01,December,2017,21:18:36:59552
VCDS -- Windows Based VAG/VAS Emulator Running on Windows 10 x64
VCDS Version: 17.8.1.0 (x64)  HEX-V2 CB: 0.4407.4
Data version: 20171130 DS276.6
www.Ross-Tech.com


VIN: 3VWST71K66M773440   License Plate: 


Chassis Type: 1K (1K0)
Scan: 01 03 08 09 0F 15 16 17 19 25 42 44 46 52 56 62 72 7D

VIN: 3VWST71K66M773440   Mileage: 334490km-207842miles

00-Steering Angle Sensor -- Status: OK 0000
01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: Malfunction 0010
0F-Digital Radio -- Status: Malfunction 0010
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
25-Immobilizer -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
44-Steering Assist -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
52-Door Elect, Pass. -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
7D-Aux. Heat -- Status: Malfunction 0010
 
-------------------------------------------------------------------------------
Address 01: Engine        Labels: 038-906-016-BEW.lbl
   Part No SW: 03G 906 016 AB    HW: 028 101 223 8
   Component: R4 1,9L EDC G000SG  7550  
   Revision: --H01---    Serial number: VWZ7Z0F3301138
   Coding: 0050071
   Shop #: WSC 00066 000 00000
   VCID: 6393528E275B321F273-8036

No fault code found.
Readiness: 0 0 0 0 0 

-------------------------------------------------------------------------------
Address 03: ABS Brakes        Labels: 1K0-907-379-MK60-F.lbl
   Part No SW: 1K0 907 379 AA    HW: 1K0 907 379 AA
   Component: ESP FRONT MK60      0102  
   Revision: 00H13001    
   Coding: 0021122
   Shop #: WSC 00066 000 00000
   VCID: 71BF28C6EDA7908FA5F-8024

No fault code found.

-------------------------------------------------------------------------------
Address 08: Auto HVAC        Labels: 1K0-820-047.lbl
   Part No: 1K0 820 047 EC
   Component: Climatic PQ35   090 0505  
   Shop #: WSC 00000 000 00000
   VCID: 698F40A6C577684FEDF-803C

No fault code found.

-------------------------------------------------------------------------------
Address 09: Cent. Elect.        Labels:. 3C0-937-049-23-M.lbl
   Part No SW: 3C0 937 049 D    HW: 3C0 937 049 D
   Component: Bordnetz-SG     H37 1002  
   Revision: 00H37000    Serial number: 00000000253641
   Coding: 14018E234004180000140000001400000008730B5C
   Shop #: WSC 23301 444 00792
   VCID: 2A0DFFAA00F1A357245-807E

   Subsystem 1 - Component: Fehler Lin-Slave 01 

3 Faults Found:
02071 - Local Databus 
            004 - No Signal/Communication
             Freeze Frame:
                    Fault Status: 01100100
                    Fault Priority: 2
                    Fault Frequency: 1
                    Reset counter: 33
                    Mileage: 334491 km
                    Time Indication: 0

             Freeze Frame:
                        ON
                    Voltage: 11.70 V
                        ON
                        ON
                        OFF
                        OFF
                        OFF

01117 - Generator Terminal DF Load Signal 
            008 - Implausible Signal - Intermittent
             Freeze Frame:
                    Fault Status: 00101000
                    Fault Priority: 2
                    Fault Frequency: 2
                    Reset counter: 73
                    Mileage: 334491 km
                    Time Indication: 0

             Freeze Frame:
                        ON
                    Voltage: 12.55 V
                        ON
                        ON
                        OFF
                        OFF
                        OFF

00153 - Windshield Wiper Motor;  Driver Side (V216) 
            004 - No Signal/Communication
             Freeze Frame:
                    Fault Status: 01100100
                    Fault Priority: 2
                    Fault Frequency: 2
                    Reset counter: 33
                    Mileage: 334491 km
                    Time Indication: 0

             Freeze Frame:
                        ON
                    Voltage: 11.70 V
                        ON
                        ON
                        OFF
                        OFF
                        OFF


-------------------------------------------------------------------------------
Address 0F: Digital Radio        Labels: 8E0-035-593-XM.lbl
   Part No SW: 8E0 035 593 E    HW: 8E0 035 593 E
   Component: SDAR XM         H03 0080  
   Revision: 00000000    Serial number: AUZ4Z7F5044210
   Shop #: WSC 00000 000 00000
   VCID: 2B03FAAE0F0BBA5FDF3-807E

1 Fault Found:
02635 - Tuner Not Enabled/Activated 
            000 -  - 
             Freeze Frame:
                    Fault Status: 01100000
                    Fault Priority: 7
                    Fault Frequency: 1
                    Reset counter: 33
                    Mileage: 334491 km
                    Time Indication: 0
                    Date: 2000.00.00
                    Time: 06:17:14


-------------------------------------------------------------------------------
Address 15: Airbags        Labels: 1K0-909-605.lbl
   Part No SW: 1K0 909 605 P    HW: 1K0 909 605 P
   Component: 39 AIRBAG VW8R  032 7900  
   Revision: 03032000    Serial number: 0038FD042AJV  
   Coding: 0013113
   Shop #: WSC 00066 000 00000
   VCID: 392FD0E6F55718CF5DF-806C

   Subsystem 1 - Part No: 1K0 959 339 E
   Component: BF-Gewichtsens. 006 0005

   Subsystem 2 - Serial number: 6332MSME0D35450EF

   Subsystem 3 - Serial number: 6342MSME0D351D60D

   Subsystem 4 - Serial number: 6351HSME091C174AB

   Subsystem 5 - Serial number: 6361HSME091D1C49H

   Subsystem 6 - Serial number: 63727SME08254B4C6

   Subsystem 7 - Serial number: 63827SME086C4B5DK

1 Fault Found:
01217 - Side Airbag Igniter; Driver Side (N199) 
            001 - Upper Limit Exceeded - Intermittent - MIL ON

-------------------------------------------------------------------------------
Address 16: Steering wheel        Labels: 1K0-953-549-MY8.lbl
   Part No SW: 1K0 953 549 AH    HW: 1K0 953 549 AH
   Component: J0527           034 0070  
   Coding: 0000021
   Shop #: WSC 00066 000 00000
   VCID: 78A915E28EDDC1C7621-802C

No fault code found.

-------------------------------------------------------------------------------
Address 17: Instruments        Labels: 1K0-920-xxx-17.lbl
   Part No: 1K0 920 952 L
   Component: KOMBIINSTRUMENT 3HL 4312  
   Coding: 0023203
   Shop #: WSC 23317 444 85571
   VCID: 3333E2CED73BE29F973-8066

No fault code found.

-------------------------------------------------------------------------------
Address 19: CAN Gateway        Labels:. 1K0-907-530-V1.clb
   Part No SW: 1K0 907 530 F    HW: 1K0 907 951 
   Component: Gateway         H10 0120  
   Revision:   H10       Serial number: 2800105C1284CC
   Coding: 3D3F0B60071002
   Shop #: WSC 00066 000 00000
   VCID: 2A0DFFAA00F1A357245-807E

No fault code found.

-------------------------------------------------------------------------------
Address 25: Immobilizer        Labels: 1K0-920-xxx-25.clb
   Part No: 1K0 920 952 L
   Component: IMMO            3HL 4312  
   Shop #: WSC 00000 000 00000
   VCID: 3333E2CED73BE29F973-8066

No fault code found.

-------------------------------------------------------------------------------
Address 42: Door Elect, Driver        Labels: 1K0-959-701-MIN2.lbl
   Part No: 1K0 959 701 K
   Component: Tuer-SG         024 2377  
   Coding: 0001269
   Shop #: WSC 00066 000 00000
   VCID: 3635DBDAC449F7B7B0D-8062

No fault code found.

-------------------------------------------------------------------------------
Address 44: Steering Assist        Labels: 1Kx-909-144-G2V2.clb
   Part No: 1K1 909 144 K
   Component: EPS_ZFLS Kl.5   D06 1701  
   Shop #: WSC 00000 000 00000
   VCID: 3333E2CED73BE29F973-8066

No fault code found.

-------------------------------------------------------------------------------
Address 46: Central Conv.        Labels:. 1K0-959-433-MIN.clb
   Part No: 1K0 959 433 AF
   Component:    KSG              0401  
   Coding: 137803281B09058F880F048051A0
   Shop #: WSC 00066 000 00000
   VCID: 74B121D292B5A5A74E9-8020

   Subsystem 1 - Component:   Sounder n.mounted     

   Subsystem 2 - Component:       NGS n.mounted     

   Subsystem 3 - Component:      IRUE n.mounted     

No fault code found.

-------------------------------------------------------------------------------
Address 52: Door Elect, Pass.        Labels: 1K0-959-702-MIN2.lbl
   Part No: 1K0 959 702 K
   Component: Tuer-SG         024 2377  
   Coding: 0001269
   Shop #: WSC 00066 000 00000
   VCID: 372BD6DEC3430EBFABB-8062

No fault code found.

-------------------------------------------------------------------------------
Address 56: Radio        Labels: 1K0-035-1xx-56.lbl
   Part No SW: 1K0 035 180 A    HW: 1K0 035 180 A
   Component: Radio DE2       008 0011  
   Revision: 00008000    Serial number: VWZ4Z7E2009284
   Coding: 0040400
   Shop #: WSC 00066 000 00000
   VCID: 1E65237A4CB95FF748D-804A

No fault code found.

-------------------------------------------------------------------------------
Address 62: Door, Rear Left        Labels: 1K0-959-703-GEN2.lbl
   Part No: 1K0 959 703 D
   Component: Tuer-SG         021 2434  
   Coding: 0000144
   Shop #: WSC 00066 000 00000
   VCID: 313FE8C62D27D08FE5F-8064

No fault code found.

-------------------------------------------------------------------------------
Address 72: Door, Rear Right        Labels: 1K0-959-704-GEN2.lbl
   Part No: 1K0 959 704 D
   Component: Tuer-SG         021 2434  
   Coding: 0000144
   Shop #: WSC 00066 000 00000
   VCID: 323DE7CA2821EB979C5-8066

No fault code found.

-------------------------------------------------------------------------------
Address 7D: Aux. Heat        Labels: 1K0-963-235.lbl
   Part No SW: 1K0 963 235 E    HW: 1K0 963 235 E
   Component: PTC-Element         0404  
   Revision: 00800000    Serial number:               
   Shop #: WSC 00000 000 00000
   VCID: 2D07F4B6311FB46FC17-8078

1 Fault Found:
00361 - Heater Element for Auxiliary Heater (Z35) 
            014 - Defective

End----(Elapsed Time: 01:13, VBatt start/end: 11.8V/11.8V. VIgn 11.8V)-----
 
Last edited by a moderator:
   #13  

MTShaun

Verified VCDS User
Verified
Joined
Dec 1, 2017
Messages
13
Reaction score
9
Location
USA
VCDS Serial number
C?ID=323037
Jef,

SB19 30a (is this the fuse box location by the battery? If so, terminal 19 30a fuse, yes I can power a fog light using the ground by left headlight. This ground was tight and clean although I disconnected to clean anyway and re-tightened. I need to get a bently manual I'm sure will help understand the info your are providing.
no rain/light sensor

Lin to j519 F3 can you give me some guidance on what and how to test?
 
   #14  

downtime

Verified VCDS User
Verified
Joined
May 27, 2017
Messages
3,306
Reaction score
2,064
Location
Finland
VCDS Serial number
C?ID=280813
Maybe stupid question but you have had your bonnet closed when you've tested the wipers with replacement motor? They are disabled if the bonnet is open and won't move an inch.
Security measure by Volkswagen :)
 
   #15  

MTShaun

Verified VCDS User
Verified
Joined
Dec 1, 2017
Messages
13
Reaction score
9
Location
USA
VCDS Serial number
C?ID=323037
downtime, not a stupid question as it may help someone reading this post later on.. but yes I am aware of the hood switch and have verified its working and is closed when I test the wiper motors i've installed. As I understand it, the reason for this switch is because without it and the hood open the wipers would crash into the hood if wipers were turned on.

Thank you for your question.
 
   #16  

downtime

Verified VCDS User
Verified
Joined
May 27, 2017
Messages
3,306
Reaction score
2,064
Location
Finland
VCDS Serial number
C?ID=280813
Good :) Just wanted to check because it may not be so clear to everyone as you wrote.

If you get your hands on another salvaged motor, try that. I still suspect that the electronics in the motor are kaput. The error codes and the problems you have are exactly the same when I fried our Golf Plus' motors probably due to a bad quality xenon set. Yes, that had cross-wiping wipers and 2 motors. Was quite expensive to fix them even with salvaged motors.
 
   #17  

Vasco Ferraz

Verified VCDS User
Verified
Joined
Jan 31, 2017
Messages
188
Reaction score
119
Location
Portugal
VCDS Serial number
C?ID=288561
And if you apply 12V directly into the motor terminals? If it is good it should move.

For precaution do that with the motor completely disconnected from the car electronics.
 
   #18  

Larry Manton

Verified VCDS User
Verified
Joined
May 19, 2016
Messages
813
Reaction score
407
Location
USA
VCDS Serial number
C?ID=112505
Freeze Frame:
ON
Voltage: 11.70 V
ON
ON
OFF
OFF
OFF

01117 - Generator Terminal DF Load Signal
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 2
Fault Frequency: 2
Reset counter: 73
Mileage: 334491 km
Time Indication: 0

Freeze Frame:
ON
Voltage: 12.55 V
ON
ON
OFF
OFF
OFF

00153 - Windshield Wiper Motor; Driver Side (V216)
004 - No Signal/Communication
Freeze Frame:
Fault Status: 01100100
Fault Priority: 2
Fault Frequency: 2
Reset counter: 33
Mileage: 334491 km
Time Indication: 0

Freeze Frame:
ON
Voltage: 11.70 V
ON
ON

something we all forget. Get busy working on a system and should have battery charger on @ all times as we have the doors open, ect. Noted voltages low here, should be enough to run wipers, but just saying..............

LARIMORE
 
   #19  

MTShaun

Verified VCDS User
Verified
Joined
Dec 1, 2017
Messages
13
Reaction score
9
Location
USA
VCDS Serial number
C?ID=323037
Ok its been a while since I posted on this problem, I just got home this morning from sometime out of state. Awaiting on my table was a brand new wiper motor so I connected it right away, ran vcds and same codes are present. Cleared codes and ran again, no change. It is very clear to me now that it is not the wiper motor itself. It is evident that a previous owner had replaced the wiper motor and I myself have installed 2 salvage yard motors and now a brand new one... I am leaning towards the J519 put could use some input on how to verify a bad J519 prior to changing/ purchasing another one. Jeff mentioned verifying data, I am no were close to an experienced individual on these types of test but can follow directions very well, please someone help. A recap of what I have already done... checked all fuses several times, changed motor with three different ones, took car to dealership 200 miles round trip (they were not much help, wanted me to come back for more diag time) bought vcds to help diag myself( so new to these types of problems and troubleshooting process) traced 12v battery power to plug at motor, tested ground at motor plug (good), can see voltage on signal wire at motor plug (not sure what it is supposed to be... seeing 10.x volts.) wiper stem works as it should per vcds, unplugged connectors at J519 to verify all pins were intact, also checked pins on J527 in steering column and checked for broken wires as best I could. Is there coding on the J519 that could be out of whack? Read something about possible coding but the dealership told me no? I am about at my wits end on this, I have countless hours chasing my tail. Thanks for all previous input and future input, I will not give up, its not in my dna..
 
   #20  

MTShaun

Verified VCDS User
Verified
Joined
Dec 1, 2017
Messages
13
Reaction score
9
Location
USA
VCDS Serial number
C?ID=323037
I'm also nervous that someone before me has already swapped out the j519 and didn't copy/transfer the original code over to a new one. No way for me to know but is a possibility right? how would I verify original coding or coding is correct?
 
Back
Top